Nilfisk F1.5L User manual

Nilfisk
Brand
Nilfisk
Model
F1.5L
Type
User manual
USER
MANUAL
MODEL NUMBER:
F1.5L
F1.5LBK
and related units
1.5 Liter Pump-Up Foam Unit
English (Original Instrucons)
Page 2 of 5 | 01152018
User Manual: 0.4 gallon (1.5 liter) Pump-Up Foam Unit | English
READ ALL INSTRUCTIONS BEFORE OPERATING EQUIPMENT
Model Number: F1.5L, F1.5LBK and related units
Read this manual completely and understand the
machine before operang or servicing it.
• Readallinstruconsbeforeinstallingoroperangunit.
• Alwayswearappropriatepersonalprotecveequipment
(PPE)whenoperangorservicingunit.
• Alwaysfollowallchemicalsafetyprecauonsand
handlinginstruconsprovidedbythechemical
manufacturerandSafetyDataSheet(SDS).
• Ifthisunitismodiedorservicedwithpartsnotlistedin
thismanual,theunitmaynotoperatecorrectly.
• Neverpointthedischargewandatyourself,another
person,oranyobjectyoudonotwantcoveredin
chemical.
• Neverleaveunitunaendedwhilepressurized.
• Alwaysdepressurizeunitbeforeaempngtoremove
thepumpassembly.
• Alwaysdepressurizeunitaeruse(asdescribedinthe
AerUseInstrucons).Alwaysstoreunitdepressurized.
• Donotpressurizeunitbyanymeansotherthanthebuilt-
inpumpassembly.
• Donotmodifyorremovepressurereliefvalve.Donot
useunitifpressurereliefvalveisnotoperaonal.
• Alwaysushtheunitwithfreshwaterwhenswitching
fromanalkalinetoanacidoranacidtoanalkaline.
• Alwayscarryunitbythecarryinghandle.Neverlior
carrytheunitbythepumphandleorthewand.
• Neveruseunitwithhydrocarbonsorammable
products.
• Donotexceedauidtemperatureof100˚F(37˚C).
WARNING
PROTECT THE ENVIRONMENT
Pleasedisposeofpackagingmaterials,oldmachine
components,andhazardousuidsinanenvironmentallysafe
wayaccordingtolocalwastedisposalregulaons.
Alwaysremembertorecycle.
*Specicaonsandpartsaresubjecttochangewithoutnoce.
REQUIREMENTS
Liquidtemperature
range
40-100˚F(4.4-37˚C)
Chemicalcompability Chemicalproductsusedwiththis
equipmentmustbeformulated
forthistypeofapplicaonand
compablewithunitmaterialsand
pumpseals.Formoreinformaon
onchemicalcompability,consult
themanufacturerorSDSforyour
productorcontactourcustomer
servicedepartment.
SPECIFICATIONS
Powertype Manual
Chemicalpickuptype Drawsfrompre-mixedsoluon
Numberofproducts
unitcandrawfrom
Oneproduct
OperangCapacity 0.3gallon(1.1liter)
Dischargewand/p
type
Polypropylenetriggerhandlewith
110degreefanp
Outputdistance 1-2(0.3-0.6m)
Pumpseals Viton
Page3of5|01152018
User Manual: 0.4 gallon (1.5 liter) Pump-Up Foam Unit | English
READ ALL INSTRUCTIONS BEFORE OPERATING EQUIPMENT
Model Number: F1.5L, F1.5LBK and related units
Operaon Instrucons:
1. Ensureallairpressureisreleasedfromunitbyacvang
thepressurereleasevalve(locatedonthesideofthe
pumpassembly(PA-F1.5L)).
2. Securelyholdtheunitandunscrewthepumpassembly
(PA-F1.5L)fromthetankinacounter-clockwisemoon.
3. Followallinstruconsfromchemicalmanufacturer.Fill
tank3/4ofthewaywithpre-mixedsoluon.
(Note:Donotoverlltankwithsoluon.)
4. Securelyholdthetankandscrewthepumpassembly(PA-
F1.5L)backoninaclockwisemoon.
5. Pressurizethetankbypumpingapproximately20to25
mes,orunlitbecomediculttopump.(Note:The
pressurereliefvalvewillleakiftheairpressureistoohigh.
Donotoverlltankwithair.)
6. Tostartfoaming,pointthewandassemblyattheareayou
wishtofoamandpressdownontheOn/Ocontrolto
dischargefoam.ReleaseOn/Ocontroltostopfoaming.
7. Fordrainapplicaons,posiondrainaachmentoverthe
drainorinsertplugintodrain.Tostartfoaming,pointthe
wandassemblyattheareayouwishtofoamandpress
downontheOn/Ocontroltodischargefoam.Release
On/Ocontroltostopfoaming.
Aer Use Instrucons:
1. Releaseairpressurefromunitaereachusebyacvang
thepressurereleasevalve(locatedonthesideofthe
pumpassembly(PA-F1.5L)).
2. Itisrecommendedtoalwaysemptyoutremaining
soluonandrunfreshwaterthroughtheunittorinseall
partsthoroughlyaereachuseandbeforestorage.
Maintenance Instrucons:
Warning: Always depressurize unit before performing
maintenance.
Tokeepyourunitoperangproperly,periodicallyperformthe
followingmaintenanceprocedures:
• Checkthepumpassemblyforwearandleaks.
• Checkthesucontubeandscreenfordebrisandcleanas
needed.
• Replacewadding(WD-F1.5L)insidedischargewandas
needed.Replacewaddingbyfollowingstepsbelow:
1. Removethedischargewandbyunthreadingretaining
nut(WA-1.5L-RN).
2. Removethewadding(WD-F1.5L)insidethedischarge
wandanddiscard.
3. Insertnewwaddingdisksinsidethedischargewand.
4. Threadtheretainingnutbackon.Makesurethe
o-ring(WA-1.5L-OR)isinplace.
• Periodicallylubricatethepumpsealwithafoodsafe
lubricants.Tolubricatethepumpseal,raisepumphandle
andapply5to10dropsoffoodsafelubricantbetween
pumpandpumpsleeve.NEVERUSELUBRICANTSSUCH
ASWD40.
Page 4 of 5 | 01152018
User Manual: 0.4 gallon (1.5 liter) Pump-Up Foam Unit | English
READ ALL INSTRUCTIONS BEFORE OPERATING EQUIPMENT
Model Number: F1.5L, F1.5LBK and related units
PUMP ASSEMBLY
ITEM NUMBER: PA-F1.5L
WAND ASSEMBLY:
ITEM NUMBER: WA-F1.5L
WA-1.5L-RN
WD-F1.5L
STB-F1.5L
WA-1.5L-OR
PW-1.5L
TANKS
ITEM NUMBERS: TANK1.5L, TANK1.5LBK
TANK1.5L (white tank)
TANK1.5LBK (black tank)
Liquid level viewing stripe
Pressure relief valve
On/off
WA-F1.5L
PST-F1.5L
Exploded View
Page 5 of 5 | 01152018
User Manual: 0.4 gallon (1.5 liter) Pump-Up Foam Unit | English
READ ALL INSTRUCTIONS BEFORE OPERATING EQUIPMENT
Model Number: F1.5L, F1.5LBK and related units
DHB3814
WD-F1.5L
WA-1.5L-RN
WA-1.5L-OR
PW-1.5L
H14C
RMS2
HM1414
ITEM NUMBER DESCRIPTION
DHB3814 3/8FLATSEAT1/4HOSEBARB
H14C 1/4inIDCLEARPOLYVINYLTUBING-Availableper.(3/8
inOD)
HB1414 1/4inMPTX1/4inHOSEBARB
HM1414 HOSEMENDER-1/4inchBARBX1/4inchBARB
PA-F1.5L PUMPASSEMBLYFOR1.5LFOAMUNIT
PW-1.5L POLYWANDFOR1.5LPUMPUP
RDC12 RUBBERDRAINCUPFOR1/2INCHBARB
ITEM NUMBER DESCRIPTION
RMS2 RUBBERMOLDEDSTOPPER-SIZE#2-EPDM
STB-F1.5L BUTTONSPRAYTIPFOR1.5LPUMPUP
TANK1.5L 1.5LTANK-WHITE
TANK1.5LBK 1.5LTANK-BLACK
WA-1.5L-OR O-RINGFOR1.5LWANDASSEMBLY
WA-1.5L-RN RETAININGNUTFOR1.5LWANDASSEMBLY
WD-F1.5L WADDINGDISKFOR1.5LPUMPUP(1PIECE)
ITEM NUMBER: WA-F1.5L-DP.75
ITEM NUMBER: WA-F1.5L-DP3.75
DHB3814
WD-F1.5L
WA-1.5L-RN
WA-1.5L-OR
PW-1.5L
H14C
RDC12
HB1414
FOR UNITS WITH DRAIN ATTACHMENTS:
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5

Nilfisk F1.5L User manual

Nilfisk
Brand
Nilfisk
Model
F1.5L
Type
User manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Other documents