VIAIR 450P-RV-Automatic User manual

VIAIR
Brand
VIAIR
Model
450P-RV-Automatic
Category
Air compressors
Type
User manual

This manual is also suitable for

IMPORTANT SAFETY INSTRUCTIONS:
CAUTION: To reduce risk of electrical shock or electrocution:
- Donotdisassemble.Donotattemptrepairsormodications.
Refertoqualiedserviceagenciesforallserviceandrepairs.
- Do not use this product in or area where it can fall or be pulled into water or other liquids.
- Do not reach for this product if it has fallen into liquid.
- Usethiscompressorwith12-voltDCsystemsonly.
- Thisproductshouldneverbeleftunattendedduringuse.
WARNING:Topreventinjury:
- Neverallowchildrentooperatethiscompressor.
Closesupervisionisnecessarywhenthiscompressorisbeingusednearchildren.
- ThiscompressorwillbecomeveryHOTduringandimmediatelyafteruse.
Donottouchanypartofthiscompressorwithbarehands,otherthantheON/OFFswitch
duringandimmediatelyafteruse.
- Donotusethisproductnearamesorexplosivematerialsorwhereaerosolproducts
arebeingused.
- Donotoperatethisproductwhereoxygenisbeingadministered.
- Donotpumpanythingotherthanatmosphericair.
- Neverusethisproductwhilesleepyordrowsy.
- Donotuseanytoolsorattachmentswithoutrstdeterminingmaximumairpressureforthat
tool or attachment.
- Neverpointanyairnozzleorairsprayertowardanotherpersonoranypartofthebody.
- ThisaircompressorisequippedwithanAutomaticResetThermalProtector,andcan
automaticallyrestartafterthethermalprotectorresets.Alwayscutopowersourcewhen
thermalprotectorbecomesactivated.
- Wearsafetyglassesorgoggleswhenoperatingthisproduct.
- Useonlyinwellventilatedareas.
- Afterusage,alwaysreleaseexcesspressurefromthecoilhosebyturningOn/OswitchtotheO
position,disconnecthosefromcompressor,withthetireinationgunstillconnectedtotheother
endofthecoilhose,pulltriggeronthetireinationguntoreleaseexcesspressure.
USER MANUAL
450P-RV AUTOMATIC PORTABLE COMPRESSOR
450P-RV AUTOMATIC PORTABLE COMPRESSOR
OPERATING INSTRUCTIONS:
Pleasereadandfollowtheoperatinginstructionscarefullytoassurethatyouwillenjoythe
convenienceandbestuseoutofyouraircompressor.
1.AlwaysoperatethecompressorATORBELOWTHEMAXIMUMPRESSURERATINGofthe
compressor.RefertoSpecicationssectionofthismanual.
2.AlwaysOBSERVETHEMAXIMUMDUTYCYCLEoftheaircompressor.RefertoSpecications
sectionofthismanualfordetails.Operationsexceedingmaximumpressureratingsandorduty
cyclewillresultindamagetoaircompressor.
3.YouraircompressorisequippedwithanAUTOMATICTHERMALOVERLOADPROTECTOR.
Thisfeatureisdesignedtoprotecttheaircompressorfromover-heatingandcausingpermanent
damagetoyouraircompressor.Thethermaloverloadprotectorwillautomaticallycutopower
toaircompressorshouldinternaloperatingtemperatureoftheaircompressorriseabovesafe
levelsduringexcessiveuse.
4.Shouldyourcompressorshutosuddenlyafterextendeduse,donotattempttorestartair
compressor.TurnON/OFFswitchofaircompressortotheOFFposition.Theautomaticthermal
overloadprotectorwillautomaticallyresetwheninternaltemperatureoftheaircompressordrops
belowsafelevel.Afterallowingaircompressortocooloforabout30minutes,youcansafely
resumeuseoftheaircompressorbyturningontheaircompressor.
5.Foryourconvenience,andtoprotecttheaircompressorfromover-pressureoperationthatcan
causepermanentdamagetotheunit-thiscompressorisequippedwithbuilt-inpressureswitch
withafactorysetcut-onpressureof130PSI(±5%)andafactorysetcut-opressureof
155PSI(±5%).Duringinationoftirepressuresbetween130PSIto155PSI,ifyoustopination,
thecompressormaynotrestart.Thisiscompletelynormal,sinceinlinepressureisgreaterthan
cut-onpressureofthepressureswitchandlessthancut-opressureofthepressureswitch.
Torestartcompressor,deatetirepressuretobelow130PSI,reconnecttirechucktotirevalve
stemandresumetireination.
6.Pleasenotethatyoumayexperienceaslightdelayofthecompressor’smotorstartingwhenthe
ON/OFFswitchisturnedonwhilecompressorispressurized(whenthereispressureintheline
thatthecompressorisconnectedto).Thisisanormaldelayedreaction,notaCompressor
ON/OFFswitchmalfunction.
7.Itisstronglyrecommendedthatyoukeepthevehicle’senginerunningwhileusingtheair
compressortopreventdischargeofyourvehicle’sbattery.
8.ONLYOPERATETHEAIRCOMPRESSORINWELLVENTILATEDAREAS.
Compressorperformanceisenhancedwhenoperatingcompressorwithvehicleenginerunning.
IMPORTANT:Enginemustberunningwhileusingthiscompressor.
Beforeattachingaircompressorpowerclampstoyourvehicle’sbatteryterminals,checktomake
surethattheON\/OFFswitchofyourcompressorisintheOFFposition.AttachthePositive(+)
batteryclamp(Red)tothePositiveterminalofthebatteryandtheNegative(-)batteryclamp(Black)
totheNegativeterminalofthebattery.Alwayskeepyourvehicle’senginerunningwhileoperating
compressortoavoiddrainingyourvehicle’sbattery.
CAUTION:YourPortableAirCompressorisMoistureandDustResistant,butNOTWATERORDUST
PROOF.Neverplacecompressorinsoftsandwhilerunningthecompressor.Vibrationfromthe
compressorwillcausethecompressortosettleintosoftsand,resultingincompressordrawingin
foreignparticles.Neverexposecompressortowaterwhilerunningthecompressor.
USER MANUAL
OPERATING INSTRUCTIONS (cont’d):
This air compressor comes with 1/4” quick connect stud. An extension coil hose and a tire
ination gun are also included with your compressor. Each end of the extension coil hose is
equipped with a 1/4” quick connect coupler. The tire ination gun comes with a 1/4” quick
connect stud, pressure gauge, rubber hose, bleeder valve and tire chuck. Attach one end of
the extension coil hose to the stud on your compressor and the other end to the stud on the
tire gun kit. The tire gun kit can be used for both airing up and airing down. Please familiarize
yourself with the following functions of this versatile air tool:
TIRE INFLATION:
1.Attachoneendoftheextensioncoilhosetothecompressorandtheotherendtothetiregunkit,
45-degreeangledchuckor90-degreetwist-onchuck–dependingonneed.
2.Turncompressorswitchonandholddownthetriggeronthetiregunkittobeginination.
3.Whendesiredpressureisreached,releasethetrigger.Ifnishedwithuse,turnpowerswitchon
compressoroposition.
NOTE:Toreleaseexcesspressure,turnocompressoranddisconnecthosefromcompressor.
Withthetireinationgunstillconnectedtotheotherendofthecoilhose,pulltriggeronthetire
inationguntoreleaseexcesspressure.
CAUTION:Toavoidoverination,neverexceedrecommendedpressureonarticlestobeinated.
Burstingcancauseseriousinjury.
NOTE:Youraircompressorisequippedwithapressureswitch(cutonat130PSI,cutoat
155PSI).Thisfeatureisdesignedtoprotecttheaircompressorfromover-pressurecausing
permanentdamagetoyouraircompressor.Thepressureswitchautomaticallyturnsothemotor
whentheinternalpressureoftheaircompressorreachesthefactoryset“cut-o”pressureof
155PSIandrestartswhentheinternalpressuredropsbelow130PSI.
TIRE DEFLATION:
1.Withtheinationoptionofyourchoicestillconnectedtothetireinationgun,pressthebleeder
valvebuttononthetiregunkittodecreasetirepressure,pressthebleedervalvebuttononthetire
gunkittodecreasetirepressure.
2.Pressthebleedervalvebuttononthetiregunkittodecreasetirepressure.
3.Whendesiredpressureisreached,releasethebleedervalvebuttontohaltdeation.
IMPORTANT:Makesurecompressorsitsuprightwhileoperatingcompressor.Donotoperate
compressorinanyotherposition.Avoidtuggingatcompressortomoveit.Instead,move
compressortothesamesideofvehicleastiresthatarebeingairedup.
AlwaysmakesurethePortableCompressor’spowercordisuncoiledandfullyextended
whenusingyouraircompressortoavoidoverheatingthepowercord.
INLINE PRESSURE GAUGE:
1.Thepressuregaugeontheinationgunprovidesconvenienttirepressuremonitoringwhenairing
upordown(notairowofthecompressor).Thiseliminatesswitchingbackandforthbetweena
tirechuckandatirepressuregauge.
2.Pleasenotethatduringinationanddeation,duetoairvelocity,pressuregaugecannotprovide
accuratepressurereadings.Releaseleveronthetireinationgunduringinationtocheck
tire air pressure.
NOTE:Toreleaseexcesspressure,turnocompressoranddisconnecthosefromcompressor.
Withthetireinationgunstillconnectedtotheotherendofthecoilhose,pulltriggeronthetire
inationguntoreleaseexcesspressure.
450P-RV AUTOMATIC PORTABLE COMPRESSOR
USER MANUAL
SAFETY PRECAUTIONS:
1.Alwaysinatetirestomanufacturer’srecommendedtirepressures.Exerciseextremecaution
whendrivingwithaired-downtires.Reinatetiresbeforehigh-speedroadwaytravel.
2.Neverexceed20M.P.H.whendrivingwithpartiallyinatedtires.
3.Nevermakesharpturnswhiledrivingwithreducedtirepressure.
4.Re-inatetiresbeforehighspeedtravelingontoroadways.
5.Useheat-resistant,minimum200PSI-ratedworkingpressureextensionhose.
Donotuseaftermarkethoseswithlessthan200PSIworkingpressure.Someaftermarkethoses
maynotbesuitableforusewiththisaircompressorduetoheatandpressuretypicallygenerated
bythistypeofaircompressors.
CAUTION:Nevertouchtheaircompressororttingsconnectedtotheaircompressorotherthan
theON/OFFswitchwithbarehandsduringorimmediatelyafteruse.Theextensionhoseandttings
connectedextensionhosewillbecomeveryHOTduringandafteruse.Ifnecessary,wearheat
resistantglovestoremovehosefromthecompressorquickconnectstud.
MAINTENANCE & REPAIRS:
Youraircompressorisequippedwithpermanentlylubricated,maintenance-freemotor.
Nevertrytolubricatethecompressor.Regularlycleandustanddirtfromcompressorcoolingns
andmotorhousing.AllrepairsshouldbeperformedbyManufacturerorManufacturerauthorized
serviceagenciesonly.
450P-RV AUTOMATIC PORTABLE COMPRESSOR
USER MANUAL
450P-RV-AUTOMATIC ACCESSORIES:
45-Degree Extended Reach, Angled Chuck:
Open-endedairchuckallowsreachintoareasdiculttoreachbyhand.
ConnectstoTireInationGun.
90-Degree Twist-on Chuck:
Thisopen-endedairchuckcanbeattachedtoanyinationvalvewherethereislimitedclearance.
Primary Hose & Extension Hoses:
Dualhoses,withquickconnectcouplings.
Tire Ination Gun:
Normallyclosed-endedchuck,(untilleverisengaged)allairchucksattachtotheTireInationGun
withquickconnectcouplings.
INLET AIR FILTER INSTALLATION INSTRUCTION:
1.ChecktomakesureairlterelementisproperlyinstalledinyourInletAirFilterAssembly
2.Removethetemporaryprotectiveredplugfromcompressor’sairinletport.
3.Installinletairlterontocompressor’sairinletport.(ThreadtapeNotRecommended).
4.Handtighteninletairlter.
IMPORTANT:Foroptimalcompressorperformance,replacelterelementperiodically.
Cloggedlterwilldrasticallyreducecompressorowrateandperformance.
450P-RV AUTOMATIC PORTABLE COMPRESSOR
USER MANUAL
TROUBLESHOOTING GUIDE:
Compressorwillnotrun 1.Nopower,orpowerswitch
inOFFposition
2.Blownfuse
3.Motoroverheats
1.Makesurecompressor
switchisON
2. Disconnect compressor
frompowersource,replace
fuse.(RefertoSpecications
section for correct
fuseamperage)
3.Letcompressorcoolofor
about30minutestoallow
thermaloverloadswitchtoreset.
Thermaloverload
protector cuts out
repeatedly
1.Lackofproperventilationor
ambienttemperatureistoohigh
2.Compressorvalvesfailed
1.Movecompressortowell
ventilatedarea,orareawith
lower ambient temperature
2.Serviceorreplacecompressor
Excessiveknocking
orrattling
1.Wornbearingoneccentricor
motor shaft
2.Cylinderorpistonringisworn
1.Serviceorreplacecompressor
Compressorairowlower
thannormal,orcannot
pumptohigherpressures
1.Wornpistonringorinletvalve 1.Serviceorreplacecompressor
PROBLEM: POSSIBLECAUSE(S) CORRECTIVEACTION
450P-RV AUTOMATIC PORTABLE COMPRESSOR
USER MANUAL
15EDELMAN•IRVINE,CA92618
TEL:(949)585-0011•FAX:(949)585-0188
www.viaircorp.com
MODEL 450P-RV AUTOMATIC SPECIFICATIONS:
PartNumber: 45053/450P-RVAutomatic
MotorVoltage: 12-volt
MotorType: PermanentMagnetic
Max.IntermittentPressure: 150PSI
Max.DutyCycle: 100%(Continuous)
(Min.On/O@72ºF&100PSI)
ContinuousUse@72ºF&30PSI: Continuous
Max.CurrentConsumption: 23Amps
Fuse: 30Amps
InlinePressureGauge: 160PSI
Built-inPressureSwitch: 130PSIOn,155PSIO
Auto.ResetThermalProtection: Yes
450P-RV AUTOMATIC PORTABLE COMPRESSOR
*Tolerance:
±
3%
LIMITED WARRANTY:
VIAIRCorporationwarrantsthisproduct,whenproperlyinstalledandundernormalconditionsofuse,tobefreefromdefectsin
workmanshipandmaterialsforaperiodofoneyearfromitsoriginaldateofpurchase.Toreceivewarrantyserviceorrepair,please
contactVIAIRCorporation.
Returnsshouldbemadewithinoneyearofthedateofpurchase,afteraReturnGoodsAuthorization(RGA)numberhasbeen
assignedbyVIAIRCorporation.ToobtainRGA,faxacopyofyourreceiptto(949)585-0188.Forcompletewarrantydetails,please
visit:www.viaircorp.com/warranty
PLEASE NOTE:
THISWARRANTYCOVERSPRODUCTDEFECTSONLY;ITDOESNOTCOVERINCIDENTALORCONSEQUENTIALDAMAGES
ASRESULTOFMISUSEORABUSE.
ThisManualisproprietarytoVIAIRCorporationandnoownershiprightsareherebytransferred.NopartoftheManualshallbe
used,reproduced,translated,converted,adapted,storedinaretrievalsystem,communicatedortransmittedbyanymeans,forany
commercialpurpose,includingwithoutlimitation,sale,resale,license,rentalorlease,withoutthepriorexpresswrittenconsentofVIAIR.
VIAIRdoesnotmakeanyrepresentations,warrantiesorguarantees,expressorimplied,astotheaccuracyorcompletenessofthe
Manual.UsersmustbeawarethatupdatesandamendmentswillbemadefromtimetotimetotheManual.Itistheuser’sresponsibility
todeterminewhethertherehavebeenanysuchupdatesoramendments.NeitherVIAIRnoranyofitsdirectors,ocers,employees
oragentsshallbeliableincontract,tortorinanyothermannerwhatsoevertoanypersonforanyloss,damage,injury,liability,costor
expenseofanynature,includingwithoutlimitationincidental,special,directorconsequentialdamagesarisingoutoforinconnection
withtheuseoftheManual.
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8

VIAIR 450P-RV-Automatic User manual

VIAIR
Brand
VIAIR
Model
450P-RV-Automatic
Category
Air compressors
Type
User manual
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents