Vecow EMBC-1000-7600U User manual

USER

Manual

USER

Manual

2.4.0 Edition 20220525

EMBC-1000

Intel® Core™ i7/i5/i3 U-series SoC (Kaby Lake/Skylake) 3.5" Single Board

Computer, 2 GigE LAN, 4 USB 3.0, 5 COM, SUMIT, -40°C to 85°C Operation

ii

Version Date Page Description Remark

0.1 04/12/2016 All Preliminary Release

1.0 05/05/2016 All Ocial Release

1.1 05/20/2016 69-71 Update

1.2 07/11/2016 All Update

1.3 07/26/2016 All Update

1.4 07/28/2016 10-12 Update

1.5 05/09/2017 60 Update

1.6 07/19/2017 36-37 Update

1.7 09/15/2017 32 Update

1.8 10/02/2017 30-31 Update

1.9 01/18/2018 13 Update

2.0 12/20/2018 iv, 1-12 Update

2.1 02/14/2019 28 Update

2.2 03/21/2019 All Update

2.3 03/22/2021 2, 4, 5, 7, 8, 10, 18 Update

2.4 05/25/2022 75-77 Update

Record of Revision

iii

This manual is released by Vecow Co., Ltd. for reference purpose only. All

product oerings and specications are subject to change without prior notice.

It does not represent commitment of Vecow Co., Ltd. Vecow shall not be liable

for direct, indirect, special, incidental, or consequential damages arising out of

the use of the product or documentation or any infringements upon the rights of

third parties, which may result from such use.

This equipment has been tested and found to comply with the limits for a Class

A digital device, pursuant to part 15 of the FCC Rules. These limits are designed

to provide reasonable protection against harmful interference when the

equipment is operated in a commercial environment. This equipment generates,

uses, and can radiate radio frequency energy, and if it is not installed and used

in accordance with the instruction manual, it may cause harmful interference to

radio communications. Operation of this equipment in a residential area is likely

to cause harmful interference in which case the user will be required to correct

the interference at his own expense.

FCC

The products described in this manual complies with all applicable European

Union (CE) directives if it has a CE marking. For computer systems to

remain CE compliant, only CE-compliant parts may be used. Maintaining CE

compliance also requires proper cable and cabling techniques.

CE

This document contains proprietary information protected by copyright. No part

of this publication may be reproduced in any form or by any means, electric,

photocopying, recording or otherwise, without prior written authorization

by Vecow Co., Ltd. The rights of all the brand names, product names, and

trademarks belong to their respective owners.

Disclaimer

Declaration of Conformity

Copyright and Trademarks

iv

Part Number Description

EMBC-1000-

7600U

EMBC-1000 Embedded Single Board Computer, onboard Intel®

Core™ i7-7600U Processor (Kaby Lake-U), 2 GbE LAN, 5 COM,

4 USB 3.0, 4 USB 2.0, 2 Mini PCIe, 16 GPIO

EMBC-1000-

600U

EMBC-1000 Embedded Single Board Computer, onboard Intel®

Core™ i7-6600U Processor (Skylake-U), 2 GbE LAN, 5 COM,

4 USB 3.0, 4 USB 2.0, 2 Mini PCIe, 16 GPIO

EMBC-1000-

300U

EMBC-1000 Embedded Single Board Computer, onboard Intel®

Core™ i5-6300U Processor (Skylake-U), 2 GbE LAN, 5 COM,

4 USB 3.0, 4 USB 2.0, 2 Mini PCIe, 16 GPIO

EMBC-1000-

100U

EMBC-1000 Embedded Single Board Computer, onboard Intel®

Core™ i3-6100U Processor (Skylake-U), 2 GbE LAN, 5 COM,

4 USB 3.0, 4 USB 2.0, 2 Mini PCIe, 16 GPIO

EMBC-1000-

955U

EMBC-1000 Embedded Single Board Computer, onboard Intel®

Celeron® 3955U Processor (Skylake-U), 2 GbE LAN, 5 COM,

4 USB 3.0, 2 USB 2.0, 2 Mini PCIe, 16 GPIO

EMBC-1000E-

600U

EMBC-1000 Embedded Single Board Computer, onboard Intel®

Core™ i7-6600U Processor (Skylake-U), 2 GbE LAN, 5 COM,

4 USB 3.0, SUMIT, 2 Mini PCIe, 16 GPIO

Order Information

v

Part Number Description

61-1301009-0DA COM Port Cable

61-13B0707-386 SATA Data Cable

61-13P0430-08A SATA Power Cable

61-193102U-156 USB 2.0 Cable

61-13T10LM-3CG Audio Cable

61-13S33KM-3CG KB/MS Cable

62-A110100-011 Heat Sink

62-A210100-011 Heat Spreader

Optional Accessories

vi

Table of Contents

CHAPTER 1 GENERAL INTRODUCTION 1

1.1 Overview 1

1.2 Features 2

1.3 Product Specication 2

1.3.1 Specications of EMBC-1000-7600U 2

1.3.2 Specications of EMBC-1000-600U 4

1.3.3 Specications of EMBC-1000-300U 5

1.3.4 Specications of EMBC-1000-100U 7

1.3.5 Specications of EMBC-1000-955U 8

1.3.6 Specications of EMBC-1000E-600U 10

1.4 Supported CPU List 12

1.5 Mechanical Dimensions 12

1.5.1 EMBC-1000 Mechanical Drawing (Main Board) 12

1.5.2 EMBC-1000 Heat Sink Mechanical Drawing 13

1.5.3 EMBC-1000 Heat Spreader Mechanical Drawing 13

1.5.4 EMBC-1000 Mechanical Drawing (Main Board + Heat Sink) 14

1.5.5 EMBC-1000 Mechanical Drawing (Board + Heat Spreader) 14

CHAPTER 2 GETTING TO KNOW YOUR EMBC-1000 15

2.1 Packing List 15

2.2 Connector/Jumper Locations 15

2.3 Jumper Settings 37

CHAPTER 3 INSTALLATION 40

3.1 Installing Heat Sink 40

3.2 Installing Heat Spreader 42

3.3 Installing DDR4 SO-DIMM Module 43

3.4 Installing Mini PCIe Card 44

3.5 Installing SIM Card 45

vii

CHAPTER 4 BIOS SETUP 47

4.1 Entering Setup 47

4.2 Main Menu 48

4.3 Advanced Function 49

4.4 Chipset 59

4.5 Security 64

4.6 Boot 65

4.7 Save & Exit 66

APPENDIX A : ISOLATED DIO GUIDE 68

APPENDIX B : WDT Functions 71

APPENDIX C : Power Consumption 72

APPENDIX D : Install Win11 (BIOS TPM Setting) 75

1

GENERAL INTRODUCTION

1

GENERAL INTRODUCTION

EMBC-1000 Series 3.5” Embedded Single Board Computer is an all-in-one,

compact, versatile and high performance embedded engine in the market. With

Intel® Core™ i7/i5/i3 U-series processor (Kaby Lake-U/Skylake-U), dual channel

DDR4 2400/2133 MHz up to 32GB memory, EMBC-1000 serves up to 10%

CPU performance enhanced than the former generation Intel® SoC solution with

lower CPU power consumption; Advanced Intel® HD Graphics 620/520 graphics

engine supports DirectX 12, OpenGL 4.4 and OpenCL 2.0 API, onboard DVI-D,

DisplayPort and dual channel 24-bit LVDS display interface support up to ultra

HD 4K resolution, EMBC-1000 oers up to 34% improved graphics performance

than the former generation.

Multiple Gen 3 PCIe (8GT/s), SATA III (6Gbps), USB 3.0 (5Gbps), PoE (1Gbps)

LAN and exible 3G/4G/WiFi/LTE/GPS/GPRS/UMTS wireless connections make

high-speed data conveying possible. Vecow EMBC-1000 Series Embedded

Single Board Computer delivers you outstanding Power-Ecient Performance

for demanding workloads.

Featured with 2 independent Gigabit LANs support iAMT 11.0, 5 COM RS-

232/422/485, 4 external USB 3.0, 4 USB 2.0, 2 Mini PCIe sockets, 1 SIM card

socket for 3G/4G/LTE/WiFi/GPRS/UMTS, 2 SATA III, 16 GPIO, onboard SUMIT

A, B connection, 9V to 36V wide range power input, fanless -40°C to 85°C

operating temperature, smart manageability features, all-in-one and cable-

less designs, Vecow EMBC-1000 Series Embedded Single Board Computer

integrates outstanding performance, remarkable power productivity, smart

manageability, mobile availability, industrial-grade reliability and all-in-one

compact solution for low-prole high-performance embedded applications.

Vecow EMBC-1000 Series Embedded Single Board Computer delivers

outstanding performance, compact integrated functions, smart manageability,

mobile availability, trusted reliability and flexible expansion features for

your Healthcare Service, Smart Automation, Point-Of-Information (POI),

Self-Services, In-vehicle Infotainment, Industry 4.0 and any compact high-

performance Internet of Thing (IoT) applications.

1.1 Overview

2

GENERAL INTRODUCTION

©Vecow EMBC-1000 User Manual

1.3 Product Specication

1.3.1 Specications of EMBC-1000-7600U

System

Processor Intel® Core™ i7-7600U Processor (Kaby Lake-U, up to 4M

Cache, 3.9GHz)

Chipset Intel® SoC (Kaby Lake)

BIOS AMI

SIO IT8786E

Memory 1 DDR4 2400/2133 MHz SO-DIMM, up to 32GB

Graphics

Graphics Processor Intel® HD Graphics 620

Interface

• DVI-D : Up to 1920 x 1080

• DisplayPort : Up to 3840 x 2160

• LVDS : Dual Channel 24-bit, up to 1920 x 1200

Ethernet

LAN 1 Intel® I219LM Gigabit LAN supports iAMT 11.0

LAN 2 Intel® I210 Gigabit LAN

Audio

Audio Codec Realtek ALC888S-VD, 7.1 Channel HD Audio

Audio Interface 1 Line-in, 1 Line-out, 1 Mic-in

1.2 Features

• Intel® Core™ i7/i5/i3 U-series SoC (Kaby Lake-U/Skylake-U), up to 3

independent Full HD displays

• DDR4 2400/2133 MHz memory, up to 32GB

• Onboard DisplayPort, DVI and dual channel 24-bit LVDS display interface

• Dual Independent Gigabit LAN supports iAMT 11.0

• 2 Mini PCIe Socket for 3G/4G/LTE/WiFi/GPRS/UMTS

• 4 USB 3.0, 5 COM, 16 GPIO

• Supports full function SUMIT A, B expansion

• 9V to 36V DC Power Input

• Easy to customize for low-profile system applications

• One-stop SUMIT Expansion Design and Manufacturing Services

3

GENERAL INTRODUCTION

I/O Interface

Front I/O

• 1 DVI-D Connector

• 1 DisplayPort Connector

• 4 USB 3.0 Connector

• 2 RJ45 Connector

• 1 COM RS-232/422/485 DB9 Connector

Internal I/O

• 1 ATX 4-pin Power Connector

• 4 COM RS-232/422/485 Connector

• 2 Mini PCIe Connector

• 1 SIM Card Socket

• 1 DDR4 SO-DIMM Socket

• 1 LVDS Backlight Connector

• 2 SATA Connector

• 1 SATA Power Connector

• 2 USB 2.0 Connector for 4 USB Port

• 1 GPIO Connector

• 1 Fan Connector

Storage

SATA 2 SATA III (6Gbps)

mSATA 1 SATA III (Mini PCIe Type, 6Gbps)

Expansion

Mini PCIe

2 Mini PCIe Socket :

• 1 Mini PCIe for PCIe/USB/SIM Card

• 1 Mini PCIe for PCIe/USB/Optional mSATA

SUMIT (Optional) • 1 SUMIT Connector A (Internal)

• 1 SUMIT Connector B (Internal)

Power

Power Input 9V to 36V, DC-in

Power Interface ATX Power Connector

Others

Watchdog Timer Reset : 1 to 255 sec./min. per step

Smart Management Wake on LAN, PXE supported

HW Monitor Monitoring temperature, voltages. Auto throttling control

when CPU overheats.

Software Support

Microsoft Windows 10, Windows 8.1, Windows 7

Linux Fedora 19, Ubuntu 10.04 LTS, or Linux Kernel 3.0 above

Mechanical

Dimension (W x H) 146mm x 102mm (5.75” x 4.02”)

Environment

Operating Temperature -40°C to 85°C (-40°F to 185°F)

Storage Temperature -40°C to 85°C (-40°F to 185°F)

Humidity 5% to 95% Humidity, non-condensing

Relative Humidity 95% at 85°C

EMC CE, FCC

4

GENERAL INTRODUCTION

©Vecow EMBC-1000 User Manual

1.3.2 Specications of EMBC-1000-600U

System

Processor Intel® Core™ i7-6600U Processor (Skylake-U, up to 4M

Cache, 3.4GHz)

Chipset Intel® SoC (Skylake)

BIOS AMI

SIO IT8786E

Memory 1 DDR4 2400/2133 MHz SO-DIMM, up to 32GB

Graphics

Graphics Processor Intel® HD Graphics 520

Interface

• DVI-D : Up to 1920 x 1080

• DisplayPort : Up to 3840 x 2160

• LVDS : Dual Channel 24-bit, up to 1920 x 1200

Ethernet

LAN 1 Intel® I219LM Gigabit LAN supports iAMT 11.0

LAN 2 Intel® I210 Gigabit LAN

Audio

Audio Codec Realtek ALC888S-VD, 7.1 Channel HD Audio

Audio Interface 1 Line-in, 1 Line-out, 1 Mic-in

I/O Interface

Front I/O

• 1 DVI-D Connector

• 1 DisplayPort Connector

• 4 USB 3.0 Connector

• 2 RJ45 Connector

• 1 COM RS-232/422/485 DB9 Connector

Internal I/O

• 1 ATX 4-pin Power Connector

• 4 COM RS-232/422/485 Connector

• 2 Mini PCIe Connector

• 1 SIM Card Socket

• 1 DDR4 SO-DIMM Socket

• 1 LVDS Backlight Connector

• 2 SATA Connector

• 1 SATA Power Connector

• 2 USB 2.0 Connector for 4 USB Port

• 1 GPIO Connector

• 1 Fan Connector

Storage

SATA 2 SATA III (6Gbps)

mSATA 1 SATA III (Mini PCIe Type, 6Gbps)

Expansion

Mini PCIe

2 Mini PCIe Socket :

• 1 Mini PCIe for PCIe/USB/SIM Card

• 1 Mini PCIe for PCIe/USB/Optional mSATA

SUMIT (Optional) • 1 SUMIT Connector A (Internal)

• 1 SUMIT Connector B (Internal)

5

GENERAL INTRODUCTION

1.3.3 Specications of EMBC-1000-300U

System

Processor Intel® Core™ i5-6300U Processor (Skylake-U, up to 3M

Cache, 3.0GHz)

Chipset Intel® SoC (Skylake)

BIOS AMI

SIO IT8786E

Memory 1 DDR4 2400/2133 MHz SO-DIMM, up to 32GB

Graphics

Graphics Processor Intel® HD Graphics 520

Interface • DVI-D : Up to 1920 x 1080

• DisplayPort : Up to 3840 x 2160

• LVDS : Dual Channel 24-bit, up to 1920 x 1200

Ethernet

LAN 1 Intel® I219LM Gigabit LAN supports iAMT 11.0

LAN 2 Intel® I210 Gigabit LAN

Audio

Audio Codec Realtek ALC888S-VD, 7.1 Channel HD Audio

Audio Interface 1 Line-in, 1 Line-out, 1 Mic-in

Power

Power Input 9V to 36V, DC-in

Power Interface ATX Power Connector

Others

Watchdog Timer Reset : 1 to 255 sec./min. per step

Smart Management Wake on LAN, PXE supported

HW Monitor Monitoring temperature, voltages. Auto throttling control

when CPU overheats.

Software Support

Microsoft Windows 10, Windows 8.1, Windows 7

Linux Fedora 19, Ubuntu 10.04 LTS, or Linux Kernel 3.0 above

Mechanical

Dimension (W x H) 146mm x 102mm (5.75” x 4.02”)

Environment

Operating Temperature -40°C to 85°C (-40°F to 185°F)

Storage Temperature -40°C to 85°C (-40°F to 185°F)

Humidity 5% to 95% Humidity, non-condensing

Relative Humidity 95% at 85°C

EMC CE, FCC

6

GENERAL INTRODUCTION

©Vecow EMBC-1000 User Manual

I/O Interface

Front I/O • 1 DVI-D Connector

• 1 DisplayPort Connector

• 4 USB 3.0 Connector

• 2 RJ45 Connector

• 1 COM RS-232/422/485 DB9 Connector

Internal I/O • 1 ATX 4-pin Power Connector

• 4 COM RS-232/422/485 Connector

• 2 Mini PCIe Connector

• 1 SIM Card Socket

• 1 DDR4 SO-DIMM Socket

• 1 LVDS Connector

• 1 LVDS Backlight Connector

• 2 SATA Connector

• 1 SATA Power Connector

• 2 USB 2.0 Connector for 4 USB Port

• 1 GPIO Connector

• 1 Fan Connector

Storage

SATA 2 SATA III (6Gbps)

mSATA 1 SATA III (Mini PCIe Type, 6Gbps)

Expansion

Mini PCIe 2 Mini PCIe Socket :

• 1 Mini PCIe for PCIe/USB/SIM Card

• 1 Mini PCIe for PCIe/USB/Optional mSATA

SUMIT (Optional) • 1 SUMIT Connector A (Internal)

• 1 SUMIT Connector B (Internal)

Power

Power Input 9V to 36V, DC-in

Power Interface ATX Power Connector

Others

Watchdog Timer Reset : 1 to 255 sec./min. per step

Smart Management Wake on LAN, PXE supported

HW Monitor Monitoring temperature, voltages. Auto throttling control

when CPU overheats.

Software Support

Microsoft Windows 10, Windows 8.1, Windows 7

Linux Fedora 19, Ubuntu 10.04 LTS, or Linux Kernel 3.0 above

Mechanical

Dimension (W x H) 146mm x 102mm (5.75” x 4.02”)

Environment

Operating Temperature -40°C to 85°C (-40°F to 185°F)

Storage Temperature -40°C to 85°C (-40°F to 185°F)

Humidity 5% to 95% Humidity, non-condensing

Relative Humidity 95% at 85°C

EMC CE, FCC

7

GENERAL INTRODUCTION

1.3.4 Specications of EMBC-1000-100U

System

Processor Intel® Core™ i3-6100U Processor (Skylake-U, up to 3M

Cache, 2.3GHz)

Chipset Intel® SoC (Skylake)

BIOS AMI

SIO IT8786E

Memory 1 DDR4 2400/2133 MHz SO-DIMM, up to 32GB

Graphics

Graphics Processor Intel® HD Graphics 520

Interface • DVI-D : Up to 1920 x 1080

• DisplayPort : Up to 3840 x 2160

• LVDS : Dual Channel 24-bit, up to 1920 x 1200

Ethernet

LAN 1 Intel® I219LM Gigabit LAN supports iAMT 11.0

LAN 2 Intel® I210 Gigabit LAN

Audio

Audio Codec Realtek ALC888S-VD, 7.1 Channel HD Audio

I/O Interface

Front I/O • 1 DVI-D Connector

• 1 DisplayPort Connector

• 4 USB 3.0 Connector

• 2 RJ45 Connector

• 1 COM RS-232/422/485 DB9 Connector

Internal I/O • 1 ATX 4-pin Power Connector

• 4 COM RS-232/422/485 Connector

• 2 Mini PCIe Connector

• 1 SIM Card Socket

• 1 DDR4 SO-DIMM Socket

• 1 LVDS Connector

• 1 LVDS Backlight Connector

• 2 SATA Connector

• 1 SATA Power Connector

• 2 USB 2.0 Connector for 4 USB Port

• 1 GPIO Connector

• 1 Fan Connector

Storage

SATA 2 SATA III (6Gbps)

mSATA 1 SATA III (Mini PCIe Type, 6Gbps)

Expansion

Mini PCIe 2 Mini PCIe Socket :

• 1 Mini PCIe for PCIe/USB/SIM Card

• 1 Mini PCIe for PCIe/USB/Optional mSATA

SUMIT (Optional) • 1 SUMIT Connector A (Internal)

• 1 SUMIT Connector B (Internal)

8

GENERAL INTRODUCTION

©Vecow EMBC-1000 User Manual

1.3.5 Specications of EMBC-1000-955U

System

Processor Intel® Celeron® 3955U Processor (Skylake-U, up to 2M Cache,

2.0GHz)

Chipset Intel® SoC (Skylake)

BIOS AMI

SIO IT8786E

Memory 1 DDR4 2400/2133 MHz SO-DIMM, up to 32GB

Graphics

Graphics Processor Intel® HD Graphics 520

Interface

• DVI-D : Up to 1920 x 1080

• DisplayPort : Up to 3840 x 2160

• LVDS : Dual Channel 24-bit, up to 1920 x 1200

Ethernet

LAN 1 Intel® I219LM Gigabit LAN supports iAMT 11.0

LAN 2 Intel® I210 Gigabit LAN

Audio

Audio Codec Realtek ALC888S-VD, 7.1 Channel HD Audio

Audio Interface 1 Line-in, 1 Line-out, 1 Mic-in

Power

Power Input 9V to 36V, DC-in

Power Interface ATX Power Connector

Others

Watchdog Timer Reset : 1 to 255 sec./min. per step

Smart Management Wake on LAN, PXE supported

HW Monitor Monitoring temperature, voltages. Auto throttling control

when CPU overheats.

Software Support

Microsoft Windows 10, Windows 8.1, Windows 7

Linux Fedora 19, Ubuntu 10.04 LTS, or Linux Kernel 3.0 above

Mechanical

Dimension (W x H) 146mm x 102mm (5.75” x 4.02”)

Environment

Operating Temperature -40°C to 85°C (-40°F to 185°F)

Storage Temperature -40°C to 85°C (-40°F to 185°F)

Humidity 5% to 95% Humidity, non-condensing

Relative Humidity 95% at 85°C

EMC CE, FCC

9

GENERAL INTRODUCTION

I/O Interface

Front I/O

• 1 DVI-D Connector

• 1 DisplayPort Connector

• 4 USB 3.0 Connector

• 2 RJ45 Connector

• 1 COM RS-232/422/485 DB9 Connector

Internal I/O

• 1 ATX 4-pin Power Connector

• 4 COM RS-232/422/485 Connector

• 2 Mini PCIe Connector

• 1 SIM Card Socket

• 1 DDR4 SO-DIMM Socket

• 1 LVDS Connector

• 1 LVDS Backlight Connector

• 2 SATA Connector

• 1 SATA Power Connector

• 1 USB 2.0 Connector for 2 USB Port

• 1 GPIO Connector

• 1 Fan Connector

Storage

SATA 2 SATA III (6Gbps)

mSATA 1 SATA III (Mini PCIe Type, 6Gbps)

Expansion

Mini PCIe

2 Mini PCIe Socket :

• 1 Mini PCIe for PCIe/USB/SIM Card

• 1 Mini PCIe for PCIe/USB/Optional mSATA

SUMIT (Optional) • 1 SUMIT Connector A (Internal)

• 1 SUMIT Connector B (Internal)

Power

Power Input 9V to 36V, DC-in

Power Interface ATX Power Connector

Others

Watchdog Timer Reset : 1 to 255 sec./min. per step

Smart Management Wake on LAN, PXE supported

HW Monitor Monitoring temperature, voltages. Auto throttling control

when CPU overheats.

Software Support

Microsoft Windows 10, Windows 8.1, Windows 7

Linux Fedora 19, Ubuntu 10.04 LTS, or Linux Kernel 3.0 above

Mechanical

Dimension (W x H) 146mm x 102mm (5.75” x 4.02”)

Environment

Operating Temperature -40°C to 85°C (-40°F to 185°F)

Storage Temperature -40°C to 85°C (-40°F to 185°F)

Humidity 5% to 95% Humidity, non-condensing

Relative Humidity 95% at 85°C

EMC CE, FCC

10

GENERAL INTRODUCTION

1.3.6 Specications of EMBC-1000E-600U

System

Processor Intel® Core™ i7-6600U Processor (Skylake-U, up to 4M

Cache, 3.4GHz)

Chipset Intel® SoC (Skylake)

BIOS AMI

SIO IT8786E

Memory 1 DDR4 2400/2133 MHz SO-DIMM, up to 32GB

Graphics

Graphics Processor Intel® HD Graphics 520

Interface • DVI-D : Up to 1920 x 1080

• DisplayPort : Up to 3840 x 2160

• LVDS : Dual Channel 24-bit, up to 1920 x 1200

Ethernet

LAN 1 Intel® I219LM Gigabit LAN supports iAMT 11.0

LAN 2 Intel® I210 Gigabit LAN

Audio

Audio Codec Realtek ALC888S-VD, 7.1 Channel HD Audio

Audio Interface 1 Line-in, 1 Line-out, 1 Mic-in

I/O Interface

Front I/O • 1 DVI-D Connector

• 1 DisplayPort Connector

• 4 USB 3.0 Connector

• 2 RJ45 Connector

• 1 COM RS-232/422/485 DB9 Connector

Internal I/O • 1 ATX 4-pin Power Connector

• 4 COM RS-232/422/485 Connector

• 2 Mini PCIe Connector

• 1 SIM Card Socket

• 1 DDR4 SO-DIMM Socket

• 1 LVDS Connector

• 1 LVDS Backlight Connector

• 2 SATA Connector

• 1 SATA Power Connector

• 1 GPIO Connector

• 1 Fan Connector

Storage

SATA 2 SATA III (6Gbps)

mSATA 1 SATA III (Mini PCIe Type, 6Gbps)

Expansion

Mini PCIe 2 Mini PCIe Socket :

• 1 Mini PCIe for PCIe/USB/SIM Card

• 1 Mini PCIe for PCIe/USB/Optional mSATA

SUMIT (Optional) • 1 SUMIT Connector A (Internal)

• 1 SUMIT Connector B (Internal)

11

GENERAL INTRODUCTION

Power

Power Input 9V to 36V, DC-in

Power Interface ATX Power Connector

Others

Watchdog Timer Reset : 1 to 255 sec./min. per step

Smart Management Wake on LAN, PXE supported

HW Monitor Monitoring temperature, voltages. Auto throttling control

when CPU overheats.

Software Support

Microsoft Windows 10, Windows 8.1, Windows 7

Linux Fedora 19, Ubuntu 10.04 LTS, or Linux Kernel 3.0 above

Mechanical

Dimension (W x H) 146mm x 102mm (5.75” x 4.02”)

Environment

Operating Temperature -40°C to 85°C (-40°F to 185°F)

Storage Temperature -40°C to 85°C (-40°F to 185°F)

Humidity 5% to 95% Humidity, non-condensing

Relative Humidity 95% at 85°C

EMC CE, FCC

12

GENERAL INTRODUCTION

1.4 Supported CPU List

CPU Name TDP Cache Max. Frequency Embedded

i7-7600U 15W 4MB Up to 3.90GHz Yes

i7-6600U 15W 4MB Up to 3.40GHz Yes

i5-6300U 15W 4MB Up to 3.00GHz Yes

i3-6100U 15W 4MB Up to 2.30GHz Yes

Celeron 3955U 15W 2MB Up to 2.00GHz Yes

1.5 Mechanical Dimensions

1.5.1 EMBC-1000 Mechanical Drawing (Main Board)

Unit: mm (inch)

5.0 (0.2”)

11.8 (0.5”)

56.2 (2.2”)

141.9 (5.6”)

5.1 (0.2”)

7.6 (0.3”)

81.3 (3.2”)

96.6 (3.8”)

146 (5.75”)

102 (4.02”)

ø 3.3 (ø0.1”)

ø 7.2 (ø0.3”)

146 (5.75”)

9.9 (0.4”)

12.9 (0.5”)

16.3 (0.6”)

18.3 (0.7”)

31.6 (1.2”)

13

GENERAL INTRODUCTION

1.5.2 EMBC-1000 Heat Sink Mechanical Drawing

Unit: mm (inch)

106.2 (4.18”)

150.4 (5.92”)

12.5 (0.49”)

30.4 (1.19”)

1.5.3 EMBC-1000 Heat Spreader Mechanical Drawing

Unit: mm (inch)

103.8 (4.08”)

148.0 (5.82”)

12.7 (0.5”)

Page is loading ...

Vecow EMBC-1000-7600U, EMBC-1000-100U, EMBC-1000-300U, EMBC-1000-600U, EMBC-1000-955U, EMBC-1000E-600U User manual

Related papers

Other documents