Crem International cqube espresso User manual

User Guide

CQUBE M Espresso

U_EN

Rev. 111124 Art. nr/Art. no.

1730136-02

Your dealer

CREM International AB

Box 10, Viksgränd 2, SE-670 40 Åmotfors, Sweden

Tel: +46 (0)570-477 00, Fax: +46 (0)570-47719

E-mail: [email protected] www.creminternational.com

2.

1. Contents CQube Espresso

1. Contents page 2

2. General, Safety regulations, Fact, 3

3. Overview, front 4

3. Overview, mixer system 5

3. Overview components, ingredients canister 6

3. Overview membrane switch, button function front 7

3. Overview user card 8

4. Installation and start-up, Position machine, Fit machine 9

Connection of the hoses for cooling unit with carbonic acid, (base cab.) 9

Connection of carbonic acid tube, (base cabinet) 10

Connections: electricity 10

Connections: water, Start-up of coffee maker 11

Connect: electric cable for cold water

12

Fill ingredients canister 13

5. Operation;

Brewing of espresso in cup, Cold water dispenser 14

Brewing of chocolate in jug 15

6. Cleaning program

Clean brew mechanism 16 - 17

Rinsing the blender bowls 18

Cleaning dispenser valves 19

Flush brew mechanism 20

7. Cleaning every week

Disassemble blender system , Wash parts 21

Re-install blender system 22

8. Cleaning and care

Exterior cleaning when necessary 23

Clean condenser - replacement of carbonic acid tube 23

9. Message shown on display 24

10. PROGRAMMING Activate with card 25

11. Programming Main menu 26

Jug Beverage 27

Clean Machine 28

Counters 29-30

12. Dimension sketch 31

3.

2. General . CQube Espresso

Thank you for choosing a CQube espresso machine. We hope you enjoy it !

- The machine must be connected correctly for your own safety.

Read the user guide before using the machine.

- The guide contains important instructions for proper and safe use.

- Always keep the guide close at hand.

The machine must be disconnected from mains electricity supply before carrying out any maintenance.

All installation work must be carried out by qualiﬁ ed personnel.

Safety regulations

- The appliance is not intended for use by persons (including children) with reduced physical,

sensory or mental capabilities, or lack of experience and knowledge, unless they have been given

supervision or instruction concerning the use of the appliance by a person responsible for their safety

- Children should be supervised to ensure they do not play with the appliance

- The brewer must be connected to the water mains in accordance with any national rules that may apply.

Facts:

Built-in grinder

Filtered water with or Optional

without carbonic acid

Function for selecting jug Chocolate

Options for selecting drink 10 -12

Ingredient canister 2

Cleaning function with smartcard Yes

Electronic temperature control Yes

Adjustable coffee strength Yes

Illumination of cup during brewing Yes

Energy-saving mode Yes

USER CARD Yes

Touch screen Optional

Tank volume Thermoblock for espresso, tank 5 L. for Instant/hotwater

Power supply 230V/2200W+170W

Cold water hook-up ½” external thread

Water puriﬁ cation ﬁ lter ﬁ lter

Carbonated water 20 litres/hour

Bean container 2.0 kg

Ingredient canister chocolate

Ingredient canister topping

Waste box 150 espresso pucks

Temperatures;

The recommended room temperature when the machine operates 20-23 ° C

(maximum 15 - 35 ° C)

Machine weight:

CQUBE M no base cabinet 42 Kg

Base cabinet 25 Kg

Grinder 6 Kg

Cold water 12 Kg

Cold water + carbonic acid 16 Kg

4.

3. Overview, front. CQube Espresso

Cup shelf

Tap for

water drinks

Drip cover

Drip tray

Display

Pre-selection buttons

Energy-saving mode

Stop

Card reader

Accessories;

Base cabinet with carbonic acid tube and cooler

Dispenser

hot drinks

Menu

Drinks

Bean container

Door Lock

5.

3. Overview inside. CQube Espresso

Grinder

dispenser

Brewing-

mechanism

Bean-

container

Ingredients

canister

Bean valve

Chute

ON/OFF

switch

Cleaning

buttons

Mixing bowl

Grounds tray

6.

3. Overview of components, ingredients container. CQube Espresso

Ingredients canister.

Detail; Ingredients; Width Height KG Cups in gram Amount of cups

Canister Beans 160 180 2,0 14 143

Canister Chocolate 67 250 1,5 20 76

Canister Topping 67 250 1,1 9 122

Espresso

maskin

Behållare Topping 160 250 2,9 0,01 291

Behållare Chocolate 67 250 1,5 0,02 76

5. Overview of components, function buttons AC12

7.

3. Overview: Membrane switch function, front CQube Espresso

Buttons function front.

Press the buttons if you want to increase a value or browse through a menu.

Press the button if you want to decrease a value or go back through the menu.

Press the Back button if you want to leave the submenu and go back to

the main menu.

Press the Enter button if you want to enter the menu, change a value or a setting.

Conﬁ rm the new setting by pressing the E-button.

Press the STOP button if you want to return to the start menu.

ENERGY SAVING MODE button. Keep the STOP button pressed down

for c. 5 seconds. The display shows; Energy Saving Mode. To return to

normal setting, keep the Stop button pressed down for 5 sec.

ENERGY SAVING MODE, the machine switches off the front display and

decreases the temperature in the water tank to c. 65

°C.

USER CARD

5. Overview of components, function buttons AC12

8.

3. Overview: USER CARD CQube Espresso

USER CARD

Insert the card:

Display will show the Service Menu, Jug Beverage and you can now browse

forwards through the menu.

USER CARD Item number: 1602692.

Is used for cleaning and setting jug beverages.

The user card is supplied by your dealer.

For full menus. See Programming Manual.

Service Menu

Jug Beverage

To use the machine again. Remove the card and keep it in a safe place.

9.

4. Installation and start-up. CQube Espresso

1. Place the machine on a ﬂ at surface that is impermeable to water.

2. With assembly with a base cabinet; Mount the machine's top cabinet with the M6 x 35 screws

supplied.

Figure 1.

A

M6 x 35

Note: Make sure air is able to circulate freely behind the machine. (minimum 10cm).

Note: Only for installation with cold water function.

A

90°

WATER IN CARBONATED WATER OUT

WATER

Installation of refrigeration unit with carbonic acid,

(base cabinet)

3. Connect the 8mm hoses 3 units. (A) parallel

between the top and base cabinets, hose for

hose, left to left, etc. (See ﬁ g. 1).

10.

4. Installation and start-up. CQube Espresso

Figure 2.

Connect electricity to top cabineton the machine.

5. Connect the plug to a earthed wall socket

230V 10A.

Note: For the coffee machine: cold water unit without carbonic acid

Start-up refrigeration unit on the coffee machine without carbonic acid.

There is no pressure adjustment pump in this machine.

Follow instructions 1, 2, 6, 7, 8, 9,10,14, 16, 17

Note:

Do not connect the electrical cable from the cold water unit, before the machine has

heated up for c.10 minutes.

4. Connect the carbon dioxide tube to the

gas canister and open the tap, check that the

factory set pressure is c. 3.5bar.

May be adjusted +0.5 -1.0 bar.

Put the carbon dioxide tube in place (ﬁ gure 2).

CARBONATED WATER WATER OUT

Connect the water to the top cabinet on the machine.

6. Connect the factory-supplied tube to the cold water feed using a ½” R- connection

piece Make sure no folding or sharp bending occurs when you push the machine back

in place.

If the water pipe is new, ﬂ ush the system with water ﬁ rst to remove

copper shavings. These can damage the inlet valve.

The new tube set supplied with the appliance must be used. Old tubes may not

be reused. Connection to a closable valve is recommended.

Min. water pressure; 2 bar (200kPa). Max. water pressure: 8 bar (800kPa).

7. Open the water tap.

8. Open the door and switch on the circuit breaker. See ﬁ gure.

9. Close the door

10. The display indicates Low Water Level, Press Enter Key

Press the E button

The water tank will now automatically ﬁ ll with 5 litres of water.

At the same time the espresso system will be ﬂ ushed with

about 50ml of water.

Place a pitcher under the spout of the Espresso.

The element will not be powered until the water reaches the level sensor.

Set temperature is c. 96º Celsius.

11. Once the water heating is complete

the "Low temp" text will disappear from the display. (The display text will start to rotate).

12. Shut off the machine.

11.

4. Installation and start-up. CQube Espresso

ON

Start-up of coffee machine with built-in refrigeration unit for water

13. Now connect the electricity cable which comes from the bottom

cabinet into the electric socket for the machine (B) in the

top cabinet see ﬁ gure 3).

14. Switch on the machine again:

and wait until the text in the display starts to rotate.

Note: The fresh-brew machine must be warm before cold water can

be dispensed.

15.

Take a glass and Press on the button for cold water until water is dispensed

in an even ﬂ ow and the pressure increase pump that is buzzing gives a different

calmer sound (refrigeration-compressor is relatively quite so it should not

usually be heard very much)

Note: If no cold water comes. Restart the machine.

16. Press on the button for carbonated water so that the holder ﬁ lls and until you

have an even ﬂ ow of water.

After this the pressure increase pump will only have this quieter noise or be

completely quiet,

17. Wait for c. 10 minutes and the machine is ready to be used.

(This is to ensure that the water is refrigerated).

12.

Figure.3.

B

4. Installation and start-up. CQube Espresso

ON

13.

4. Installation and start-up. CQube Espresso

18. Fill the container.

Fill ingredients into the containers.

Remove the ingredients containers to avoid spilling

in the machine) and ﬁ ll with ingredients.

19. Fill the bean container with coffee beans.

Lift the lid and ﬁ ll the bean container with freshly

roasted coffee beans without additives. (e.g. ﬂ avour

essence and sugar), Open the valve (A) on the

bean container.

20. When placing the ingredients container

Ensure that the ingredients pipes are (ﬂ ush) against

the condensation traps. See (A).

A A

14.

Brewing a cup of espresso.

1. Put a cup under the espresso dispenser.

2. The strength of the drink is set to default.

If you would like to increase or decrease the

strength then follow the steps in the

section below, otherwise proceed to Point 3.

Stronger drink; Press + button

alternatively

Weaker drink; Press - button

3. Select drink espresso by pressing on

the button espresso on the menu.

The display shows:”Please wait”, and the cup

light goes on.

4. Wait until the cup light switches off and the text

”Please wait” has disappeared from the display

before removing the cup.

5. Operations. Brewing a cup of espresso, CQube Espresso

Cold water dispenser (with or without carbonic acid).

1. Hold a glass under the dispenser for Water and press on the button

COLD WATER or CARBONATED WATER.

Dispensing cold water

15.

5. Operation. Brewing chocolate in a jug. CQube Espresso

1. Put a jug under the espresso dispenser and fold up the cup shelf.

2. Insert the user card in the card reader(A)

3. The display shows Service Menu, Jug Beverage.

4. Press the E button.

5. Change the number of cups you want to brew in your jug.

(6 cups is the default setting.)

with alternative button.

Brewing is possible for up to 12 cups or down to 1 cup.

6. Press the button for chocolate.

Wait until the cup light switches off and the message "please wait" has

disappeared from the display before removing the jug.

7. Remove the user card.

Note: If no selection is made, remove the user card. To stop press the STOP button.

A

1. Insert the user card in the card reader (A)

2. Move through the menu until the display shows

Service Menu, Clean Machine.

3. Press the E button.

4. Move through the menu until the display shows

Select Cleaning, Clean Brewer.

5. Press the E button.

The display shows; Open Door, Fill Detergent.

6. Open the door. The display shows; Fill Detergent, Close Door.

7. Put a cleaning tablet in brewmechanism. See ﬁ g. B

8. Close the door. The display shows; Place Jug, Enter To Start.

9. Put a 1 litre container under the coffee dispenser. See ﬁ g. C

Display shows: ”Preparing Please Wait”.

”Preparing Unit” ”Please Wait”.

16.

Automatic cleaning with brewing mechanism:

Cleaning the brewer mechanism should be done once a week.

6. Cleaning programme; Clean brewing mechanism CQube Espresso

ﬁ g. B

ﬁ g. C

A

17.

6. Cleaning programme; Clean the brewing mechanism. CQube Espresso

Continuation:

10. Press E-button to start cleaning.

11. Display indicates: Preparing unit, Please wait.

12. Cleaning Unit, Time Left 60 seconds. The machine counts down from 60 seconds.

13. Display indicates: Cleaning unit, Brewcycles left 3. Machine is now cleaning the system.

14. Close door.

15. Remove user card.

Total cleaning time about 5 minutes.

Note: When the cleaning agent has been added, the process must no be interrupted

but be allowed to run its course.

Remember that the water splashing from the spout is very hot!

Espresso machine cleaning for brewing mechanism Is available from

your dealer:

Product no. 1104171

1. Lift up the cup shelf. Put a container that takes c. 0.5 litres under the dispenser

for espresso

2. Insert the user card in the card reader (A)

3. Move through the menu until the display shows Service Menu, Clean Machine.

4. Press the E button.

5. Move through the menu until the display shows Select Cleaning, Clean Mixer.

6. Press the E button.

7. The machine will no clean the blender bowls for c. 5 seconds.

Repeat the cleaning procedures 2-3 times.

8. Remove the user card.

18.

6. Cleaning programme; Rinsing the blender bowls CQube Espresso

Automatic rinsing of the blender bowls, at least once a day.

Cleaning means rinsing with water and rotating the whisk motor.

A

Cleaning of dispenser valves

1. Lift up the cup shelf. Put a container under both the Espresso and Water dispensers.

2. Insert the user card in the card reader (A)

3. Move through the menu until the display shows Service Menu, Clean Machine.

4. Press the E button.

5. Move through the menu until the display shows Select Cleaning, Clean Valves.

6. Press the E button.

7. Dispenser valves will not start to open and close with 3 pulses/second for

a max of 6 seconds. Repeat the procedure 2 - 3 times.

8. Remove the user card.

19.

6. Cleaning programme; Dispenser valves CQube Espresso

Automatic cleaning of dispenser valves:

Cleaning entails that the valves "knock" off any lime scale and other particles

that may get stuck in the cylinders and ﬂ ushing them with water.

A

20.

6. Cleaning programme; Flush brew mechanism ESP CQube Espresso

Flush brew mechanism with water if necessary.

Flush brew mechanism.

1. Lift up the cup shelf. Put a container under the Espresso dispenser.

2. Insert the user card in the card reader (A).

3. Move through the menu until the display shows Service Menu, Clean Machine.

4. Press the E button.

5. Move through the menu until the display shows Select Cleaning, Rinse Brewer ESP.

6. Press the E button.

7. Brew mechanism will now be ﬂ ushed with water.

8. Remove the card.

A

Page is loading ...

Crem International cqube espresso User manual

This manual is also suitable for

Crem International cqube espresso User manual

Other documents