Monogram ZV925SLSS Installation guide

Brand: Monogram

Model: ZV925SLSS

Type: Installation guide

Monogram ZV925SLSS is a 36-inch Island Chimney Vent Hood designed to efficiently remove smoke, odor, and moisture from your kitchen. With its powerful ventilation system, it can handle up to 1200 CFM of airflow, ensuring a cleaner and fresher cooking environment. The hood features a 3-speed fan control, allowing you to adjust the fan speed based on your cooking needs. It also comes equipped with dishwasher-safe aluminum mesh filters that effectively capture grease and other particles, making cleaning a breeze.

INSTALLATION

INSTRUCTIONS

36” Island Chimney Vent Hood

ZV925

MONOGRAM.COM

2 49-80329 Rev. 5

Safety Information

READ AND SAVE THESE INSTRUCTIONS

BEFORE YOU BEGIN

Read these instructions completely and carefully.

Ŷ IMPORTANT — Save these instructions

for local inspector’s use.

Ŷ IMPORTANT — Observe all governing

codes and ordinances.

ŶNote to Installer — Be sure to leave these

instructions with the Consumer.

ŶNote to Consumer — Keep these instructions with

your Owner’s Manual for future reference.

ŶSkill Level — Installation of this appliance requires

basic mechanical and electrical skills.

ŶCompletion Time — 1 to 3 Hours.

Ŷ3URSHULQVWDOODWLRQLVWKHUHVSRQVLELOLW\RIWKHLQVWDOOHU

3URGXFWIDLOXUHGXHWRLPSURSHULQVWDOODWLRQLVQRW

covered under the warranty.

Ŷ)RU0RQRJUDPORFDOVHUYLFHLQ\RXUDUHDYLVLW

monogram.com.

Ŷ)RU0RQRJUDPVHUYLFHLQ&DQDGDYLVLWmonogram.ca

Ŷ)RU0RQRJUDP3DUWVDQG$FFHVVRULHVYLVLW

monogram.com/use-and-care/parts.

CAUTION

Due to the weight and size of these

vent hoods and to reduce the risk of personal injury

RUGDPDJHWRWKHSURGXFW TWO PEOPLE ARE

REQUIRED FOR PROPER INSTALLATION.

ATTENTION

À cause du poids et de la taille de

ces hottes et pour reduire le risque de blessures et

GHGRPPDJHVIL FAUT DEUX PERSONNES POUR

FAIRE L’INSTALLATION CORRECTEMENT.

WARNING

To reduce the risk of fire or electrical

VKRFNGRQRWXVHWKLVUDQJHKRRGZLWKDQ\H[WHUQDO

VROLGVWDWHVSHHGFRQWUROGHYLFH$Q\VXFKDOWHUDWLRQ

from original factory wiring could result in damage to

the unit and/or create an electrical safety hazard.

AVERTISSEMENT

3RXUUpGXLUHOHULVTXH

G¶LQFHQGLHRXGHFKRFpOHFWULTXHLOQHIDXWSDV

XWLOLVHUFHWWHKRWWHDYHFXQUpJXODWHXUGHYLWHVVH

pOHFWURQLTXHH[WHUQH7RXWHPRGLILFDWLRQGHFHW\SHGX

branchement d’usine peute endommager l’appareil ou

FUpHUXQULVTXHGHFKRFpOHFWULTXH

TO REDUCE THE RISK OF FIRE, USE ONLY

METAL DUCTWORK.

WARNING

725('8&(7+(5,6.2)),5(

(/(&75,&$/6+2&.25,1-85<723(56216

2%6(59(7+()2//2:,1*

$8VHWKLVXQLWRQO\LQWKHPDQQHULQWHQGHGE\WKH

PDQXIDFWXUHU,I\RXKDYHDQ\TXHVWLRQVFRQWDFW

the manufacturer.

%%HIRUHVHUYLFLQJRUFOHDQLQJWKHXQLWVZLWFKWKH

power off at the service panel and lock the service

disconnecting means to prevent the power from

EHLQJVZLWFKHGRQDFFLGHQWDOO\:KHQWKHVHUYLFH

GLVFRQQHFWLQJPHDQVFDQQRWEHORFNHGVHFXUHO\

IDVWHQDSURPLQHQWZDUQLQJGHYLFHVXFKDVDWDJ

to the service panel.

AVERTISSEMENT

32855e'8,5(/(5,648(

'¶,1&(1',('(&+2&e/(&75,48(28'(

%/(6685(6,/)$872%6(59(5/(65(*/(6

68,9$17(6

$8WLOLVHUFHWDSSDUHLOXQLTXHPHQWGHODPDQLpUH

SUpYXHSDUOHIDEULFDQW(QFDVGHTXHVWLRQ

consulter le fabricant.

%$YDQWWRXWHLQWHUYHQWLRQRXQHWWR\DJHFRXSHU

O¶DOLPHQWDWLRQpOHFWULTXHDXGLVMRQFWHXUHWYHUURXLOOHU

OHSDQQHDXGXGLVMRQFWHXUSRXUpYLWHUODPLVHVRXV

tension accidentelle. S’il n’est pas possible de

YHUURXLOOHUOHSDQQHDXGXGLVFRQFWHXUDWWDFKHUXQ

SODFDUGRXXQHpWLTXHWWHWUpVYLVLEOHDXSDQQHDX

Ŷ)RUJHQHUDOYHQWLODWLQJXVHRQO\'RQRWXVHWRH[KDXVW

KD]DUGRXVRUH[SORVLYHPDWHULDOVRUYDSRUV

Ŷ6WUXFWXUDOIUDPLQJLQVWDOODWLRQZRUNDQGHOHFWULFDO

wiring must be done by qualified person(s) in

accordance with all applicable codes and standards

including fire-rated construction.

Ŷ6XIILFLHQWDLULVQHHGHGIRUSURSHUFRPEXVWLRQDQG

H[KDXVWLQJRIJDVHVWKURXJKWKHIOXHFKLPQH\RIIXHO

EXUQLQJHTXLSPHQWWRSUHYHQWEDFNGUDIWLQJ)ROORZ

the heating equipment manufacturer’s guidelines

and safety standards such as those published by

WKH1DWLRQDO)LUH3URWHFWLRQ$VVRFLDWLRQ1)3$DQG

WKH$PHULFDQ6RFLHW\IRU+HDWLQJ5HIULJHUDWLRQDQG

$LU&RQGLWLRQLQJ(QJLQHHUV$6+5$(DQGWKHORFDO

FRGHDXWKRULWLHV:KHQDSSOLFDEOHLQVWDOODQ\PDNHXS

(replacement) air system in accordance with local

EXLOGLQJFRGHUHTXLUHPHQWV9LVLW*($SSOLDQFHVFRP

for available makeup air solutions.

Ŷ/RFDOFRGHVYDU\,QVWDOODWLRQRIHOHFWULFDOFRQQHFWLRQV

and grounding must comply with applicable codes.

,QWKHDEVHQFHRIORFDOFRGHVWKHYHQWVKRXOGEH

LQVWDOOHGLQDFFRUGDQFHZLWK1DWLRQDO(OHFWULFDO&RGH

$16,1)3$RUODWHVWHGLWLRQ

CAUTION

To reduce risk of fire and to properly

H[KDXVWDLUEHVXUHWRGXFWDLURXWVLGH²GRQRWYHQW

H[KDXVWDLULQWRVSDFHVZLWKLQZDOOVRUFHLOLQJVRULQWR

DWWLFVFUDZOVSDFHVRUJDUDJHV

ATTENTION

Il faut prendre soin d’installer

XQFRQGXLWYHUVO¶H[WpULHXUSRXUUpGXLUHOHULVTXH

G¶LQFHQGLHHWSRXYRLUpYDFXHUO¶DLUFRUUHFWHPHQW,O

QHIDXWSDVpYDFXHUO¶DLUFRUUHFWHPHQW,OQHIDXWSDV

pYDFXHUO¶DLUGDQVO¶HVSDFHHQWUHOHVSDURLVG¶XQPXU

XQSODIRQGRXXQJUHQLHUXQHVSDFHVDQLWDLUHRXXQ

garage.

49-80329 Rev. 5 3

Design Information

CONTENTS

Design Information

3URGXFW'LPHQVLRQV ...................................................... 3

Advance Planning

$GYDQFH3ODQQLQJ ........................................................ 4

3RZHU6XSSO\ ...............................................................4

'XFW)LWWLQJV ................................................................ 5

Installation Preparation

Tools and Materials Required ....................................... 6

5HPRYHWKH3DFNDJLQJ ................................................ 6

Installation Height ......................................................... 

3DUWV3URYLGHG .............................................................. 8

Installation Preparation

Construct Ceiling Support ............................................. 

Installation Instructions—Vented to the Outside

6WHS0RXQW7HPSODWH .............................................. 12

6WHS$GMXVW)UDPH+HLJKW ....................................... 12

6WHS&XW'XFWWR/HQJWKIRU9HQWHG,QVWDOODWLRQ...... 13

6WHS,QVWDOOWKH6XSSRUW)UDPH ............................... 13

6WHS,QVWDOO+RRG$WWDFKPHQW6FUHZV ..................... 13

6WHS0RXQWWKH+RRGRQWRWKH6XSSRUW .................. 14

6WHS&RQQHFW&DEOHV .............................................. 14

6WHS&RQQHFW(OHFWULFDO ........................................... 15

6WHS3UHSDUHWKH'XFW&RYHUV ................................ 16

6WHS,QVWDOO8SSHU'XFW&RYHU .............................. 16

6WHS,QVWDOO/RZHU'XFW&RYHU .............................. 

6WHS,QVWDOO'XFW&RYHU7ULP ................................. 

6WHS,QVWDOO0HWDO)LOWHU.......................................... 

6WHS)LQDOL]H,QVWDOODWLRQ ....................................... 

Installation Instructions—Recirculating

6WHS0RXQW7HPSODWH .............................................. 18

6WHS$GMXVW)UDPH+HLJKW ....................................... 18

6WHS,QVWDOO$LU'HIOHFWRU&XW'XFW

for Recirculating Operation ............................. 

6WHS,QVWDOO8SSHU6XSSRUW)UDPH .......................... 

6WHS,QVWDOO/RZHU6WUXFWXUHWR8SSHU6WUXFWXUH ..... 

6WHS,QVWDOO%ORZHU0RWRU ........................................ 

6WHS,QVWDOO+RRG$WWDFKPHQW6FUHZV ..................... 

6WHS0RXQWWKH+RRGRQWRWKH6XSSRUW .................. 

6WHS&RQQHFW&DEOHV .............................................. 21

6WHS&RQQHFW(OHFWULFDO ......................................... 21

6WHS3UHSDUHWKH'XFW&RYHUV .............................. 22

6WHS,QVWDOO8SSHU'XFW&RYHU .............................. 22

6WHS,QVWDOO/RZHU'XFW&RYHU .............................. 22

6WHS,QVWDOO'XFW&RYHU7ULP ................................. 23

6WHS,QVWDOO)LOWHUV .................................................. 23

6WHS)LQDOL]H,QVWDOODWLRQ ....................................... 23

PRODUCT DIMENSIONS

These vent hoods are supplied with a support frame for

FHLOLQJKHLJKWVRI¶´WR¶´

Decorative duct covers conceal the ductwork running

from the top of the hood to the ceiling.

=;DFFHVVRU\LVDYDLODEOHIRUFHLOLQJKHLJKWVRI

¶´WR¶´

NOTE: Installation height should be measured from the

cooking surface to the bottom of the outer glass portion

of the hood.

7KLVKRRGPXVWEHLQVWDOOHG´PLQDQG´PD[

above the cooking surface. The cooking surface should

EHDWOHDVW´DERYHWKHIORRU

7KLVKRRGPD\EHYHQWHGWRWKHRXWGRRUVRULWFDQEH

installed for recirculating operation.

This hood can be installed over any Monogram electric

or gas cooktop. It cannot be installed over a Monogram

3URIHVVLRQDOFRRNWRSRUUDQJH

 7KHVXSSOLHGGXFWFRYHUILWV¶´WR¶FHLOLQJKHLJKWV

)RU¶´WR¶´FHLOLQJVRUGHU=;

27 9/16"

3 1/4"

35 7/8"

*Height

Ceiling

2 3/4"

*Height to

ceiling





24" min.*

PD[

36" min.

([DFWLQVWDOODWLRQ

height depends on

ceiling height.

4 49-80329 Rev. 5

Installation Preparation

ADVANCE PLANNING

Ductwork Planning

Ŷ7KHVHYHQWKRRGVDUHHTXLSSHGIRU´URXQG

ductwork.

Ŷ'HWHUPLQHWKHH[DFWORFDWLRQRIWKHYHQWKRRG

Ŷ3ODQWKHURXWHIRUYHQWLQJH[KDXVWWRWKHRXWGRRUV

Ŷ8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWURXWHSRVVLEOH

)RUVDWLVIDFWRU\SHUIRUPDQFHGXFWUXQVKRXOG

QRWH[FHHGIWHTXLYDOHQWOHQJWKIRUDQ\GXFW

configurations.

Ŷ5HIHUWR³'XFW)LWWLQJV´FKDUWWRFRPSXWHWKH

PD[LPXPSHUPLVVLEOHOHQJWKIRUGXFWUXQVWRWKH

outdoors.

Ŷ8VHULJLGPHWDOGXFWZRUNRQO\

Ŷ,QVWDOODURRIFDSZLWKGDPSHUDWWKHH[WHULRU

opening. Order the cap and any transitions needed

in advance.

Ŷ:KHQDSSOLFDEOHLQVWDOODQ\PDNHXSUHSODFHPHQW

air system in accordance with local building code

UHTXLUHPHQWV9LVLW*($SSOLDQFHVFRPIRUDYDLODEOH

makeup air solutions.

Ductwork Planning

Ŷ7KHVHYHQWKRRGVDUHKHDY\$GHTXDWHVWUXFWXUDO

support must be provided. The ceiling structure

must be capable of supporting the weight of the

hood and any inadvertent user contact loads

DSSUR[LPDWHO\SRXQGV7KHKRRGVXSSRUW

IUDPHZLOOEHVXSSRUWHGE\[FURVVIUDPLQJ

Ŷ,QVWDOODWLRQZLOOEHHDVLHULIWKHYHQWKRRGLVLQVWDOOHG

before the cooktop or countertop below is installed.

Accessory Duct Cover

Ŷ$OOPRGHOVDUHVKLSSHGZLWKDGXFWFRYHUIRUFHLOLQJ

KHLJKWVRI¶´WR¶

POWER SUPPLY

IMPORTANT - (Please read carefully)

WARNING

)253(5621$/6$)(7<7+,6

$33/,$1&(0867%(3523(5/<*5281'('

AVERTISSEMENT

3285'(65$,6216

'(6e&85,7e&(7$33$5(,/'2,7Ç75(

&255(&7(0(170,6¬/$7(55(

Remove house fuse or open circuit breaker before

beginning installation.

'RQRWXVHDQH[WHQVLRQFRUGRUDGDSWHUSOXJZLWK

WKLVDSSOLDQFH)ROORZ1DWLRQDOHOHFWULFDOFRGHVRU

prevailing local codes and ordinances.

Electrical supply

7KHVHYHQWKRRGVPXVWEHVXSSOLHGZLWK9+]

DQGFRQQHFWHGWRDQLQGLYLGXDOSURSHUO\JURXQGHG

EUDQFKFLUFXLWDQGSURWHFWHGE\DRUDPSFLUFXLW

breaker or time delay fuse.

Ŷ:LULQJPXVWEHZLUHZLWKJURXQG

Ŷ,IWKHHOHFWULFDOVXSSO\GRHVQRWPHHWWKHDERYH

UHTXLUHPHQWVFDOODOLFHQVHGHOHFWULFLDQEHIRUH

proceeding.

Ŷ5RXWHKRXVHZLULQJLQWKHFHLOLQJDVFORVHWRWKH

LQVWDOODWLRQORFDWLRQDVSRVVLEOH$OORZDGGLWLRQDO

OHQJWKIURPFHLOLQJMRLVWVWRUHDFKWKHMXQFWLRQER[

on the bottom of the hood support frame.

Ŷ&RQQHFWWKHZLULQJWRWKHKRXVHZLULQJLQ

accordance with local codes.

Grounding instructions

The grounding conductor must be connected to

DJURXQGPHWDOSHUPDQHQWZLULQJV\VWHPRUDQ

equipment-grounding terminal or lead on the hood.

WARNING

The improper connection of the

equipment-grounding conductor can result in a risk

of electric shock. Check with a qualified electrician or

service representative if you are in doubt whether the

appliance is properly grounded.

AVERTISSEMENT

Le mauvais branchement du fil

GHPLVHjODWHUUHSHXWFDXVHUXQFKRFpOHFWULTXH(Q

FDVGHGRXWHFRQVXOWHUXQpOHFWULFLHQTXDOLILpRXXQ

WHFKQLFLHQSRXUGpWHUPLQHUVLO¶DSSDUHLOHVWjODWHUUH

=;DFFHVVRU\ duct cover is available

WRUHDFK1" WR1" ceiling heights. The

accessory should be ordered with the hood and be

on site before final framing and wall finishing.

49-80329 Rev. 5 5

Installation Preparation

DUCT FITTINGS

This Hood Must Use an 8” Round

Duct. It Can Transition to a

3-1/4” x 12” Duct.

8VHWKLVFKDUWWRFRPSXWHPD[LPXPSHUPLVVLEOHOHQJWKV

for duct runs to outdoors.

NOTE:'RQRWH[FHHGPD[LPXPSHUPLVVLEOHHTXLYDOHQW

lengths!

Maximum duct length: 100 foot for range hoods.

Flexible ducting

,IIOH[LEOHPHWDOGXFWLQJLVXVHGDOOWKHHTXLYDOHQWIHHW

YDOXHVLQWKHWDEOHVKRXOGEHGRXEOHG7KHIOH[LEOHPHWDO

GXFWVKRXOGEHVWUDLJKWDQGVPRRWKDQGH[WHQGHGDV

much as possible.

DO NOTXVHIOH[LEOHSODVWLFGXFWLQJ

NOTE: $Q\KRPHYHQWLODWLRQV\VWHPVXFKDVD

YHQWLODWLRQKRRGPD\LQWHUUXSWWKHSURSHUIORZRI

FRPEXVWLRQDLUDQGH[KDXVWUHTXLUHGE\ILUHSODFHVJDV

IXUQDFHVJDVZDWHUKHDWHUVDQGRWKHUQDWXUDOO\YHQWHG

systems. To minimize the chance of interruption of such

QDWXUDOO\YHQWHGV\VWHPVIROORZWKHKHDWLQJHTXLSPHQW

manufacturer’s guidelines and safety standards such

DVWKRVHSXEOLVKHGE\1)3$DQG$6+5$(:KHQ

DSSOLFDEOHLQVWDOODQ\PDNHXSUHSODFHPHQWDLUV\VWHP

in accordance with local building code requirements. Visit

GEAppliances.com for available makeup air solutions.

Duct Piece Dimensions

Equivalent

Length*

Quantity

Used

Total

Equivalent

Length

5RXQG

straight

1 ft. (per foot

length)

´[´

straight

1 ft. (per foot

length)

HOERZ IW

HOERZ IW

´[´

HOERZ

43 ft.

´[´

HOERZ

26 ft.

´[´

IODW

elbow

IW

´URXQGWR

´[´

transition

2 ft.

´[´

WR´URXQG

transition

5 ft.

´URXQGWR

´[´

WUDQVLWLRQ

elbow

6 ft.

´[´

WR´URXQG

WUDQVLWLRQ

elbow

13 ft.

Round wall

cap with

damper

32 ft.

´[´

wall cap with

damper

IW

Round roof

cap

44 ft.

$FWXDOOHQJWKRIVWUDLJKWGXFWSOXVGXFWILWWLQJ

equivalent. Equivalent length of duct pieces

DUHEDVHGRQDFWXDOWHVWVFRQGXFWHGE\*(

$SSOLDQFHV(YDOXDWLRQ(QJLQHHULQJDQGUHIOHFW

requirements for good venting performance

with any ventilation hood.

Total Duct Run

6 49-80329 Rev. 5

Installation Preparation

TOOLS AND MATERIALS REQUIRED

(NOT SUPPLIED)

REMOVE THE PACKAGING

CAUTION

/,)77+(+22'2872)7+(%2;

%<7+(&(17(50(7$/3257,21'2127/,)7%<

7+(*/$666,'(6

ATTENTION

/(9(=/$+277(¬/¶(;7e5,(85

'(/$%2Ì7(3$5/$3257,210e7$/&(175$/

1(/(9(=3$63$5/(6&Ð7e6'(9(55(

CAUTION

:HDUJORYHVWRSURWHFWDJDLQVW

sharp edges.

ATTENTION

3RUWH]GHVJDQWVSRXUpYLWHUOHV

EOHVVXUHVFDXVpHVSDUOHVWUDQFKDQWV

Ŷ*UDVSWKHKRRGE\WKHPHWDOLQVHUWLQWKHFHQWHUDQG

OLIWVWUDLJKWXSDQGRXWRIWKHER[

Ŷ5HPRYHDQGSURSHUO\GLVFDUGWKHSODVWLFZUDSSLQJ

Ŷ5HPRYHSDUWVER[GXFWFRYHUVDQGRWKHUSDFNDJLQJ

3HQFLODQGWDSHPHDVXUH

3OLHUV

9+]RU$PS

2-wire with ground. properly

grounded branch circuit.

Key hole saw

:LUHFXWWHUVWULSSHU

Step ladder

Metal snips

Saber saw

or sawsall

:LUHQXWV

3KLOOLSVDQG

flat blade

screwdrivers

Strain relief for

junction cover.

Spirit level

)ODVKOLJKW

Safety glasses

8" round metal

GXFWOHQJWKWR

suit installation.

Duct tape

3/8" swivel

socket or pivoting

KH[VRFNHWZLWK

H[WHQVLRQV

Carpenter’s square

Hammer

Electric or battery-operated drill

DQGELWV3KLOOLSVDQGIODW

blade screwdriver bits.

49-80329 Rev. 5 

Installation Preparation

DETERMINE INSTALLATION HEIGHT

Ŷ'HFRUDWLYHGXFWFRYHUVDUHSURYLGHGWRFRQFHDOWKH

ductwork running to the ceiling.

Ŷ7KLVKRRGFDQEHLQVWDOOHGIRUUHFLUFXODWLQJ

RSHUDWLRQ1RNLWVUHTXLUHG

7KHKRRGLQVWDOODWLRQKHLJKWIURPWKHFRRNLQJVXUIDFH

WRWKHERWWRPRIWKHKRRGGHSHQGVXSRQFHLOLQJ

height.

)RURSWLPXPSHUIRUPDQFHWKHKRRGPXVWEH´PLQ

DQG´PD[DERYHWKHFRRNLQJVXUIDFH

Use the chart on this page to accurately determine

LQVWDOODWLRQKHLJKWDQGVXSSRUWIUDPHDGMXVWPHQWDQG

WRVHOHFWWKHFRUUHFWVL]HWRSWULPSLHFH$%&RU'

=;$FFHVVRU\'XFWFRYHULQFOXGHVD´

long duct cover and 3 sets of duct cover top trim

SLHFHVODEHOHG()*

Ceiling

Height

Possible Hood

Installation

Height (inches)

Mounting Frame

Height (inches)

Trim

Needed

 26  $

8’   $

 24 34 1/2 B

 28  $

 25 34 1/2 B

   $

3" 26 34 1/2 B

   $

  34 1/2 B

 24 38 1/2 C

 28 34 1/2 B

 25 38 1/2 C

  34 1/2 B

 26 38 1/2 C

  34 1/2 B

  38 1/2 C

 24 42 1/2 D

 28 38 1/2 C

 25 42 1/2 D

  38 1/2 C

 26 42 1/2 D

  38 1/2 C

  42 1/2 D

ZX92510 Accessory Duct Cover

 24 46 1/2 E

 28 42 1/2 D

 25 46 1/2 E

  42 1/2 D

 26 46 1/2 E

3"  42 1/2 D

  46 1/2 E

 24  )

 28 46 1/2 E

 25  )

  46 1/2 E

 26  )

  46 1/2 E

   )

 24 54 1/2 *

 28  )

 25 54 1/2 *

   )

 26 54 1/2 *

   )

  54 1/2 *

 28 54 1/2 *

8 49-80329 Rev. 5

Installation Preparation

PARTS PROVIDED

Locate the parts packed with the hood.

HARDWARE PACKAGE

Locate and check

contents. Screws

shown actual size.

$LUGHIOHFWRUIRU

recirculating installation

49-80406

Printed in Italy 04-06 JR

36≤ Hood

Template

8-1/2

≤ Dia.

Cut a 1≤Dia.

Wire Access

Hole

Cut a 1≤Dia.

Wire Access

Hole

Drill 3/16≤

Pilot Holes

Approx. 1-1/2≤

Deep

Drill 3/16≤

Pilot Holes

Approx. 1-1/2≤

Deep

10-1/16≤ to

Centerline

of Holes

7-1/16≤ to

Centerline

of Holes

FRONT OF HOOD

7-1/16≤ to

Centerline

of Holes

Template

6 ceiling

mounting

screws

VFUHZVWRWDO

• 24 support frame screws

KRRGDWWDFKPHQW

screws

• 2 upper duct cover

attachment screws

• 4 recirculating

deflector screws

• 2 duct cover bracket

attachment screws

12 sheet

metal

screws

Decorative duct covers

(14"ZLGHGHHSZKHQDVVHPEOHG

12 cage

nuts

Telescoping support

frame

Upper duct cover trim pieces

2 each of 4 sizes

1 charcoal filter for

recirculating installation

Stainless steel filter

24-3/4"

23-1/4"

2 Duct cover

brackets

2 thumb

screws

Lower duct cover trim pieces

Note: Some additional hardware/screws included.

49-80329 Rev. 5 

Installation Preparation

CONSTRUCT CEILING SUPPORT

Plan the Location of the Hood and Ductwork

ŶUse a plumb bob to check the location. The

countertop/cooktop below the hood must be

centered with the hood.

Ŷ7KHKRRGVKRXOGH[WHQGEH\RQGWKHIURQW

and rear edge of the cooking appliance.

ŶThe duct in the ceiling must be centered

over the cooktop.

Ceiling Support Structure

Ŷ$WWKHKRRGORFDWLRQLQVWDOO[FURVVIUDPLQJ

EHWZHHQFHLOLQJMRLVWVDVVKRZQ[¶VDUHUHTXLUHGWR

support the weight of the hood.)

Ŷ$UUDQJHFURVVIUDPLQJLQWKHFHLOLQJWRVXLWWKHH[LVWLQJ

structure.

Ŷ<RXUFHLOLQJMRLVWVZLOOEHOLNHRQHRIWKHIROORZLQJ

H[DPSOHV

Ceiling

Hood ducting

centerline

Cooktop

Countertop

)URQW



13-3/4"

Side view

$OLJQZLWKFHQWHU

of cooktop

Top view – ceiling joists parallel to front of hood



Install cross-framing

symmetrically over duct/

cooktop centerline

16" joist

spacing



´GXFW

)URQW

hood

[FURVV

framing

Cooktop

outline

$OLJQGXFWWR

center of cooktop

(;$03/($

 49-80329 Rev. 5

Installation Preparation

CONSTRUCT CEILING SUPPORT (Cont.)

Top view – ceiling joists run perpendicular to front of hood

Top view – ceiling joists at angle to front of hood

LQVWDOO

cross-framing

symmetrically over

duct/cooktop

centerline

16" joist

spacing



8" duct

)URQW

hood

[FURVV

framing

Cooktop

outline

$OLJQGXFW

to center of

cooktop

LQVWDOOFURVV

framing symmetrically over

duct/cooktop centerline

16" joist

spacing



8" duct

)URQW

hood

[FURVV

framing

Cooktop

outline

$OLJQGXFW

to center of

cooktop

(;$03/(%

(;$03/(&

49-80329 Rev. 5 11

Installation Preparation

CONSTRUCT CEILING SUPPORT (Cont.(

Ŷ6HFXUHHDFK[EORFNZLWKDWOHDVWIRXU

ZRRGVFUHZV´ORQJQRWVXSSOLHG8VHZRRG

screws total for the two supports.

ŶThe cross framing must be accurately aligned to

assure correct positioning of the hood.

ŶThe cross framing must be level in all directions.

Check with a spirit level and adjust if necessary.

IMPORTANT: The ceiling structure must be capable of

VXSSRUWLQJWKHZHLJKWRIWKHKRRGDSSUR[LPDWHO\

pounds) and any inadvertent user contact loads. The

KRRGVXSSRUWIUDPHZLOOEHVXSSRUWHGE\WKH[FURVV

framing.

Ductwork for Installations Vented to the Outdoors

Ŷ8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWURXWHSRVVLEOH

)RUVDWLVIDFWRU\SHUIRUPDQFHGXFWUXQVKRXOGQRW

H[FHHGIHHWHTXLYDOHQWOHQJWKIRUDQ\GXFW

configuration.

Ŷ5HIHUWR³'XFW)LWWLQJV´FKDUWWRFRPSXWHWKH

PD[LPXPSHUPLVVLEOHOHQJWKIRUGXFWUXQVWRWKH

outdoors.

Ŷ7KLVYHQWKRRGPXVWXVH´URXQGULJLGGXFW

Ŷ,QVWDOOWKHKRXVHGXFWZRUNWRUXQKRUL]RQWDOO\EHWZHHQ

ceiling joists or straight up through the roof.

Finish the Ceiling

Ŷ)LQLVKWKHFHLOLQJVXUIDFH%HVXUHWRPDUNORFDWLRQRI

the ceiling joists and cross framing. Check to be sure

the ceiling is level; use shims if necessary.

Ceiling Joint

2x4

10"

Duct

Vent Straight Up

Through The Ceiling

8" Duct

Ceiling joist

[

Vent straight up through

the ceiling

Ceiling

Joist

10-3/4

2x 4

Cross Framing

Height

Adjustment

Screw Holes

7-1/16"

[PLQFURVVIUDPLQJ

Ceiling

joist





Height

adjustment

screws

12 49-80329 Rev. 5

Installation Instructions

MOUNT TEMPLATE

Ŷ$OLJQWKHWHPSODWHZLWKWKHPDUNVRQWKHFHLOLQJDQG

tape in place.

– Be sure the template is oriented correctly with the

front of the hood.

Ŷ8VHDSOXPEEREWREHVXUHWKHPRXQWLQJKROHV

will provide parallel alignment with the countertop

below.

Ŷ&HQWHUSXQFKDOOKROHORFDWLRQV

Ŷ'ULOOSLORWKROHVLQWKHVFUHZORFDWLRQV8VHD´

ELWDQGGULOODSSUR[LPDWHO\´GHHS

Ŷ'ULYHKH[KHDGZRRGVFUHZVLQWRWKHFHQWHURIWKH

FHLOLQJMRLVWVDQGFURVVIUDPLQJ/HDYHD´JDSWR

allow the screw head to engage the keyhole slots on

the support frames.

Ŷ&XWWKH´GXFWRSHQLQJWKURXJKWKHVKHHWURFN

ADJUST FRAME HEIGHT

Ŷ0HDVXUHH[DFWFHLOLQJKHLJKW

Ŷ)LQGWKHH[DFWIUDPHKHLJKWUHTXLUHG

RQWKHFKDUWRQSDJH

Ŷ5HPRYHVFUHZVRQHDFKRIWKH

sides of the frame to loosen the upper

VWUXFWXUHORZHUVWUXFWXUHDQGEORZHU

motor.

Ŷ$GMXVWWKHKHLJKW³;´DFFRUGLQJWR

WKHFKDUWRQSDJH8VHDWRWDORI

32 screws (8 screws on each side)

WRVHFXUHWKHXSSHUVWUXFWXUHORZHU

structure and blower/motor together.

INSTALLATION—VENTED TO THE OUTSIDE

1/4" Gap

49-80406

Printed in Italy 04-06 JR

36≤ Hood

Template

8-1/2

≤

Dia.

Cut a 1≤Dia.

Wire Access

Hole

Cut a 1≤Dia.

Wire Access

Hole

Drill 3/16≤

Pilot Holes

Approx. 1-1/2≤

Deep

Drill 3/16≤

Pilot Holes

Approx. 1-1/2≤

Deep

10-1/16≤ to

Centerline

of Holes

7-1/16≤ to

Centerline

of Holes

FRONT OF HOOD

7-1/16≤ to

Centerline

of Holes

24"min.

PD[

36"min.

)UDPH

height

2-3/4"

Ceiling

height

49-80329 Rev. 5 13

Installation Instructions

CUT DUCT TO LENGTH FOR

VENTED

Ŷ0HDVXUHIURPKRXVH

GXFWWRH[KDXVW

opening.

Ŷ&XWWKH´GXFWOHQJWK

to size.

Ŷ6OLSGXFWRYHUWKH

H[KDXVWRSHQLQJ

Ŷ6HDOWKHFRQQHFWLRQ

with duct tape.

INSTALL HOOD ATTACHMENT

SCREWS

Ŷ,QVWDOOKRRGDWWDFKPHQWVFUHZVLQWKHERWWRPRI

WKHVXSSRUWDVVKRZQ/HDYH´JDSEHWZHHQ

screw head and support flange.

INSTALL THE SUPPORT FRAME

Ŷ5DLVHWKHVXSSRUWWRZDUG

the ceiling.

Ŷ7KUHDGWKHKRXVHZLULQJ

through one of the large

KROHVSUHIHUDEO\RQWKHOHIW

side.

Ŷ&DUHIXOO\HQJDJHWKH

ceiling mounting screws to

WKHNH\KROHVORWV$1'WKH

house duct in the top of the

frame.

Ŷ7LJKWHQWKHPRXQWLQJ

screws against the frame.

Ŷ,QVWDOOVDIHW\VFUHZV

Ŷ8VHGXFWWDSHWRVHDOWKH

duct connection at the top.

INSTALLATION—VENTED TO THE OUTSIDE

Duct

House

duct

)UDPH

height

Duct

length

Duct

Safety screws

Keyhole

slots

House wiring

Keyhole

slots

Install 4

attachment

screws

14 49-80329 Rev. 5

Installation Instructions

INSTALLATION—VENTED TO THE OUTSIDE

CONNECT CABLES

Ŷ-RLQWKHWZRFDEOHFRQQHFWRUVDWWKHIURQWRIWKH

hood. Secure the cables behind the retainer clip.

MOUNT THE HOOD ONTO THE

SUPPORT

WARNING

2 people are required to lift and

position the hood onto the mounting bracket.

AVERTISSEMENT

,IIDXWGHX[SHUVRQQHVSRXU

lever et mettre en place la hotte sur le support de

montage.

Ŷ/LIWWKHKRRGWRWKHERWWRPRIWKHVXSSRUWHQJDJLQJ

the keyhole slots to the 4 mounting screws.

Ŷ7LJKWHQWKHPRXQWLQJVFUHZV

Ŷ,QVWDOODGGLWLRQDOVFUHZVDVVKRZQ

Install

6 screws

Retainer clip

To lights

To control

panel

49-80329 Rev. 5 15

Installation Instructions

CONNECT ELECTRICAL

Verify that power is turned off at the source.

WARNING

If house wiring is not 2-wire with a

JURXQGZLUHDJURXQGPXVWEHSURYLGHGE\WKHLQVWDOOHU

:KHQKRXVHZLULQJLVDOXPLQXPEHVXUHWRXVH8/

DSSURYHGDQWLR[LGDQWFRPSRXQGDQGDOXPLQXPWR

copper connectors.

AVERTISSEMENT

Si le câblage de la maison n’est

SDVGXW\SHjGHX[ILOVDYHFXQILOGHWHUUHO¶LQVWDOODWHXU

GRLWIRXUQLUXQFLUFXLWGHWHUUH4XDQGOHVILOVGHOD

PDLVRQVRQWHQDOXPLQLXPLOSUHQGUHVRLQG¶XWLOLVHUGHOD

SkWHDQWLR[LGDWLRQDSSURXYpHSDU8/HWGHVFRQQHFWHXUV

pour l’aluminium-cuivre.

Ŷ5HPRYHMXQFWLRQER[FRYHUDQGNQRFNRXWRQWKH

left side.

Ŷ6HFXUHWKHKRXVHZLULQJWRWKHMXQFWLRQER[ZLWK

a strain relief.

Ŷ

Connect white leads to branch circuit white lead.

Ŷ&RQQHFWEODFNOHDGVWREUDQFKFLUFXLWEODFNOHDG

Ŷ&RQQHFWJUHHQ\HOORZOHDGVWREUDQFKFLUFXLWJUHHQ

lead or bare ground lead.

Ŷ6HFXUHDOOFRQQHFWLRQVZLWKZLUHQXWVRQHDFK

electrical connector.

Ŷ3XVKZLUHVLQWRMXQFWLRQER[DQGUHSODFHFRYHU

Be sure wires are not pinched.

Ŷ6HFXUH-%R[FRYHUZLWKRULJLQDOVFUHZ

Knockout

-%R[FRYHU

INSTALLATION—VENTED TO THE OUTSIDE

-%R[FRYHU

House wiring

16 49-80329 Rev. 5

Installation Instructions

PREPARE THE DUCT COVERS

Ŷ5HPRYHWKHSODVWLFSURWHFWLYHFRYHULQJRQDOOGXFW

pieces.

Ŷ,QVWDOOFDJHQXWVRQHDFKLQVLGHVHFWLRQRIWKHWRS

duct cover. The cage nuts fit into the rectangular

VORWVFOLSVIDFLQJRXWZDUG

Ŷ,QVWDOOFDJHQXWVRQHDFKVLGHRIWKHORZHUGXFW

covers.

INSTALL UPPER DUCT COVER

Ŷ3ODFHWKHWDOOGXFWFRYHUVRQWRWKHWRSRIWKHKRRG

This section has venting holes on one end.

NOTE: If you are installing this hood for

UHFLUFXODWLQJRSHUDWLRQSODFHWKHGXFWFRYHUVRQWR

the hood with the venting slots at the top.

,IWKHKRRGLVYHQWHGWRWKHRXWVLGHWKHKROHV

should be positioned on the bottom.

Ŷ6HFXUHWKHVLGHVZLWKVFUHZVLQVWDOOHGWKURXJKWKH

cage nuts.

Ŷ5DLVHWKHDVVHPEOHGGXFWFRYHUVWRWKHWRSDJDLQVW

the ceiling.

Ŷ0DWFKPRXQWLQJKROHVRQHRQHDFKVLGH,QVWDOO

screws through the duct and into the support.

INSTALLATION—VENTED TO THE OUTSIDE

Support

frame

3ODQ

diagram

Rectangular slots

1XW

Top

sections

Top

sections

49-80329 Rev. 5 

Installation Instructions

INSTALL LOWER DUCT

Ŷ3ODFHUHDUGXFWFRYHURQWRWKHKRRG

Ŷ3ODFHIURQWGXFWFRYHURQWRWKHKRRG

Ŷ6HFXUHWKHGXFWFRYHUVZLWKVFUHZV

INSTALL DUCT COVER TRIM

Ŷ,QVWDOOVLGHEUDFNHWVWRVHFXUHWKHORZHUGXFWWLJKWO\

against the upper duct.

Ŷ+ROGORZHUWULPVWULSVQDUURZSLHFHVZLWKKRRNV

IDFLQJGRZQ3ODFHWKHKRRNVLQVLGHWKHVORWVDQG

slide downward.

Ŷ6HOHFWWKHFRUUHFWVL]HXSSHUWULPVWULSVDQGSUHVV

into place.

INSTALL METAL FILTER

IMPORTANT:&KHFNWREHVXUHWKDWWKHPDLQ21

2))VZLWFKQH[WWRWKHPRWRULVLQWKH21SRVLWLRQ

Ŷ7LSWKHILOWHULQWRWKHOHIWRUULJKWVLGHRIWKHRSHQLQJ

Lift the filter to the opposite side and into the filter

lock.

Ŷ7RUHPRYHWKHILOWHUSXOOWKHILOWHUORFNGRZQZDUG

FINALIZE INSTALLATION

Ŷ5HPRYHDOOWDSHDQGSDFNLQJPDWHULDO

Ŷ5HIHUWRWKH2ZQHU¶V0DQXDOIRURSHUDWLQJ

instructions.

INSTALLATION—VENTED TO THE OUTSIDE

)URQWERWWRPGXFWFRYHUVHFWLRQ

(snap into place and secure

with 6 screws – 3 per side)

3ODQGLDJUDPWRS

view

)URQWERWWRPGXFW

cover sections

Upper

trim

strip

Lower

trim strip

Lower

trim

strip

Upper

trim

strip

Side

bracket

)LOWHUORFN

18 49-80329 Rev. 5

Installation Instructions

MOUNT TEMPLATE

Ŷ$OLJQWKHWHPSODWHZLWKWKHPDUNVRQWKHFHLOLQJDQG

tape in place.

– Be sure the template is oriented correctly with the

front of the hood.

Ŷ8VHDSOXPEEREWREHVXUHWKHPRXQWLQJKROHV

will provide parallel alignment with the countertop

below.

Ŷ&HQWHUSXQFKDOOKROHORFDWLRQV

Ŷ'ULOOSLORWKROHVLQWKHVFUHZORFDWLRQV8VHD´

ELWDQGGULOODSSUR[LPDWHO\´GHHS

Ŷ'ULYHKH[KHDGZRRGVFUHZVLQWRWKHFHQWHURIWKH

FHLOLQJMRLVWVDQGFURVVIUDPLQJ/HDYHD´JDSWR

allow the screw head to engage the keyhole slots on

the support frames.

Ŷ&XWWKH´GXFWRSHQLQJWKURXJKWKHVKHHWURFN

ADJUST FRAME HEIGHT

Ŷ0HDVXUHH[DFWFHLOLQJKHLJKW

Ŷ)LQGWKHH[DFWIUDPHKHLJKWUHTXLUHG

RQWKHFKDUWRQSDJH

Ŷ5HPRYHVFUHZVRQHDFKRIWKH

sides of the frame to loosen the upper

VWUXFWXUHORZHUVWUXFWXUHDQGEORZHU

motor.

Ŷ$GMXVWWKHKHLJKW³;´DFFRUGLQJWR

WKHFKDUWRQSDJH8VHDWRWDORI

32 screws (8 screws on each side)

WRVHFXUHWKHXSSHUVWUXFWXUHORZHU

structure and blower/motor together.

INSTALLATION—VENTED TO THE OUTSIDE

1/4" Gap

49-80406

Printed in Italy 04-06 JR

36≤ Hood

Template

8-1/2

≤

Dia.

Cut a 1≤Dia.

Wire Access

Hole

Cut a 1≤Dia.

Wire Access

Hole

Drill 3/16≤

Pilot Holes

Approx. 1-1/2≤

Deep

Drill 3/16≤

Pilot Holes

Approx. 1-1/2≤

Deep

10-1/16≤ to

Centerline

of Holes

7-1/16≤ to

Centerline

of Holes

FRONT OF HOOD

7-1/16≤ to

Centerline

of Holes

24"min.

PD[

36"min.

)UDPH

height

2-3/4"

Ceiling

height

Mark

each

piece to

indicate

where

screw

holes

align.

NOTE: Low ceilings may require that the

lower portion of the support frame be removed.

The upper support frame may be secured

directly to the blower/motor. Refer to the

FKDUWRQSDJHIRU\RXUFHLOLQJKHLJKWDQG

to be sure the duct cover trim piece will fit.

49-80329 Rev. 5 

INSTALL AIR DEFLECTOR,

CUT DUCT FOR RECIRCULATING

OPERATION

Ŷ7HPSRUDULO\VOLGHWKHDLUGHIOHFWRU

into the support frame.

Ŷ0HDVXUHGXFWOHQJWKEHWZHHQ

the deflector and over the

H[KDXVWRSHQLQJ

Ŷ&XWGXFWSLHFHWROHQJWKDQG

set aside.

INSTALL UPPER SUPPORT

FRAME

Ŷ5DLVHWKHXSSHUVXSSRUW

toward the ceiling.

Ŷ7KUHDGWKHKRXVHZLULQJ

through one of the large

KROHVSUHIHUDEO\RQWKHOHIW

side.

Ŷ&DUHIXOO\HQJDJHWKHFHLOLQJ

mounting screws to the

keyhole slots in the top of

the frame.

Ŷ7LJKWHQWKHPRXQWLQJVFUHZVDJDLQVWWKHIUDPH

Ŷ,QVWDOOVDIHW\VFUHZV

Ŷ6OLGHDLUGHIOHFWRU

into the support

frame.

Ŷ6HFXUHWKHGHIOHFWRU

to the support with

4 screws.

Ŷ,QVWDOOWKHGXFW

piece to the bottom

of the deflector

and seal the

connection with

duct tape.

Installation Instructions

INSTALLATION—RECIRCULATING

)5217

Duct

length

Safety

screws

Keyhole

slots

House wiring

Keyhole

slots

 49-80329 Rev. 5

Installation Instructions

INSTALLATION—RECIRCULATING

INSTALL LOWER STRUCTURE TO

UPPER STRUCTURE

Ŷ6OLGHORZHUIUDPHLQWRWKH

upper frame. Match the

marked alignment holes.

Ŷ6HFXUHWKHXSSHUDQGORZHU

IUDPHZLWKVFUHZVRQ

each side of the frame.

INSTALL HOOD ATTACHMENT

SCREWS

Ŷ,QVWDOOKRRGDWWDFKPHQWVFUHZVLQWKHERWWRPRI

WKHVXSSRUWDVVKRZQ/HDYH´JDSEHWZHHQ

screw head and support flange.

MOUNT THE HOOD ONTO THE

SUPPORT

WARNING

2 people are required to lift and

position the hood onto the mounting bracket.

AVERTISSEMENT

,IIDXWGHX[SHUVRQQHVSRXU

lever et mettre en place la hotte sur le support de

montage.

Ŷ/LIWWKHKRRGWRWKHERWWRP

RIWKHVXSSRUWHQJDJLQJ

the keyhole slots to the 4

mounting screws.

Ŷ7LJKWHQWKHPRXQWLQJ

screws.

Ŷ,QVWDOO

additional

screws as

shown.

INSTALL BLOWER/MOTOR

Ŷ5DLVHWKHEORZHU

motor piece toward the

assembled frame.

Ŷ&DUHIXOO\UDLVHWKHPRWRUWR

the marked reference point

while making sure the duct

piece slips over the blower

outlet flange.

Ŷ6HFXUHWKHEORZHUPRWRUWR

WKHIUDPHXVLQJVFUHZV

4 on each side.

Ŷ8VHWDSHWRVHDOWKHGXFW

connection.

Install 4

attachment

screws

Install 6 screws

Page is loading ...

Monogram ZV925SLSS Installation guide

Monogram ZV925SLSS Installation guide

Monogram ZV925SLSS Installation guide

Related papers

Other documents