Leisure Unity Owner's manual

Owner’s Manual

1

UNITY MOTORHOME TABLE OF CONTENTS

TABLE OF CONTENTS

INTRODUCTION 5

Owner’s Manual 5

Motorhome Information Kit 6

Options and Equipment 6

Vehicle Certification Labels 6

Reference Number Codes 6

Certiﬁcation Label Samples 7

Unity Floor Plans 8

Service Assistance 22

Reporting Safety Defects 22

Coach Specifications 23

SAFETY 25

General Safety 25

Alarms 26

Combination Carbon Monoxide / LP Gas Alarm 26

Fuel and Propane Safety 27

Smoke Alarm 28

Fire Prevention 28

Fire Safety Tips 28

Emergency Escape - Egress Window 29

Fire Extinguisher 29

MOTORHOME OPERATION 31

Motorhome Preparation 31

Motorhome Loading and Weights 31

Towing 32

Auxiliary Vehicle Towing 32

Pre-Trip Inspection 33

Emergency Equipment Checklist 33

Final Checks 34

Maximum Occupancy 34

Seat/Shoulder Belts 34

Driver/Passenger Seat Controls 36

Traveling 37

Driving Characteristics 37

Controls 37

General Handling 37

High Wind Handling 37

Mountain Driving 37

Driving Safety Tips 38

Travel Tips 38

Severe Weather Information 39

Emergencies While Driving 40

Hazard Warning Lights 40

Flat Tire 40

When the Vehicle is Disabled 40

Overheating 41

Parking 41

Backing Up 41

Extended Occupancy 42

Leveling the Motorhome 42

Stabilizers 43

Leveling Jacks 43

AUTOLEVEL Operation 43

TABLE OF CONTENTS UNITY MOTORHOME

2

Manual Operation 44

Refueling the Vehicle Chassis 45

Fuel Tank Capacity 45

Fuel Types 45

Removing the Fuel Cap 46

Filling the Tank 46

Door Locks 46

Locking and Unlocking Procedures 46

Keys 47

Entry Door Step 47

Step Override Switch 48

Step Cover (On Speciﬁc Models) 48

Entry Step Electrical Diagram 49

Lighting 50

Interior Overhead Light Dimmer Switch 50

Exterior/Interior Light Switches 50

Under Cabinet Light Switches 50

Slide Out Room 51

Before Operating the Slide Out Room 51

Extending the Slide out Room 52

Retracting the Slide Out Room 52

Servicing All-Weather Seals 52

Slide Out Room Emergency Operation 52

Awning 55

Extending the Awning 55

Retracting the Awning 56

Auto-Retract 56

APPLIANCE AND EQUIPMENT OPERATION 57

Dometic IoT System (U24RL Multiplex System)

57

Refrigerator 57

Operating the Refrigerator 57

Refrigerator Operating Tips 58

Exterior Refrigerator Compartment 58

Stove Top 58

Lighting Burners 58

Microwave/Convection Oven 59

Operating the Microwave/Convection Oven 59

Microwave/Convection Oven Operating Tips 59

Exterior BBQ Connection 60

Operating the Exterior BBQ Connection 60

LP Gas Furnace 60

Operating the LP Gas Furnace 60

LP Gas Furnace Operating Tips 60

Dometic Comfort Control Center 61

Operating the Thermostat 61

Roof Air Conditioner with Heat Pump 61

Heat Pump 61

Maintaining the Roof Air Conditioner/Heat Pump 62

Coach Power Roof Vent 62

Operating Controls 62

Bathroom Roof Vent 63

Operating Controls 63

Side Window Vents 64

Manual Roof Vent 64

Opening the Roof Vent 64

Closing the Roof Vent 65

Adjustments for day/night Shades 65

Adjusting the Tension 65

Entertainment Systems 66

U24IB and U24TB Floor Plans 66

U24CB, U24FX and U24RL Floor Plans 66

U24MB Floor Plan 67

TV Operation 67

BluRay Operation 67

TV Utility Panel 68

External Cable TV Connection 68

External Satellite TV Connection 68

HDMI Switch Box 69

WIFI Extender 69

Entertainment System Schematics 70

Satellite Pre-wire Schematic 74

Beds and Seating 75

Leisure Lounge Plus System (optional) 75

Leisure Lounge Plus Seating 77

U24CB Seating/Sleeping 78

U24TB Sleeping 79

U24IB/TB Seating 79

Leisure Lounge Seating 80

U24RL Rear Lounge 81

ELECTRICAL SYSTEM OPERATION 83

Electrical Supply 83

Shore Power 83

Battery Disconnect Switch 83

Wiring Schematic 84

System Monitor 90

Power Distribution Panels 91

120 Volt AC Circuit Breakers 91

12 Volt DC Coach Fuses 91

12 Volt DC Chassis Fuses 92

Driver seat pedestal fuses 92

Ground Fault Circuit Interrupter (GFCI) 92

Auxiliary LP Gas Generator (Optional) 92

Operating the Auxiliary LP Gas Generator 93

UNITY MOTORHOME TABLE OF CONTENTS

3

Starting the Auxiliary LP Gas Generator 93

Stopping the Auxiliary LP Gas Generator 93

Auto Gen Start (Available with LP Generator) 94

Auxiliary Diesel Generator (Optional) 94

Starting the Auxiliary Diesel Generator 94

Stopping the Auxiliary Diesel Generator 95

Generator Safety 96

Automatic Power Transfer Switch 96

12 Volt DC system 97

Chassis Battery 97

Coach Batteries (12 Volt DC Power Supply) 97

Coach Battery Condition Meter 98

Battery Maintenance 98

Battery Problems 98

Long-Term Storage 99

Additional Battery Maintenance Suggestions 99

Inverter 100

Inverter Remote Control Panel 101

Surge guard (optional) 101

Accidental 240 volt Protection 102

Troubleshooting Guide 102

Solar Power Unit (Optional) 102

Lighting Maintenance 103

Exterior Lighting 103

Interior Lighting 104

WATER AND PLUMBING SYSTEM 107

Water Supply 107

Fresh Water System 107

City Water Supply 107

Filling the Fresh Water Tank 108

Water Pump Switch 109

Disinfecting the Water Tank 109

Water Pump 110

Water Pump Initial Startup 110

Water Pump Troubleshooting 110

Water Pump Electrical Diagram 111

Draining the Fresh Water System 112

Draining the hot and cold water systems 112

Water Filter 113

Waste Systems 113

Grey Water Waste Holding Tank 113

Black Water Waste Holding Tank 113

Dumping Holding Tanks 114

Black Water Waste Tank Rinse 114

Macerator 115

WASTE WATER HOLDING TANK - DO’S AND DON’TS

115

Using On-Site Sewer Hook-Ups 116

Water Heater 116

Water heater operation 116

Truma AquaGo® Water Heater 117

Switching ON the Appliance 117

AquaGo® comfort plus 117

Operating modes 117

Winterizing 117

Operating mode / Description 118

Water Fixtures 118

Fresh Water Toilet 118

Manual Flush Toilet 118

Macerator Toilet 119

Cleaning the Manual Flush Toilet 119

Showers 120

Interior Shower 120

Exterior Shower 120

LIQUID PROPANE GAS SYSTEM 121

LP Gas Control Valve 121

Safe Use of LP Gas 121

Precautions for the Safe use of LP Gas 121

How LP Gas Works 122

Selecting Fuel Types 122

LP Gas Tank System 122

Reﬁlling the LP Gas Tank 122

After reﬁlling the LP gas tank 123

Air in the LP Gas Tank 123

Traveling with LP Gas 123

LP Gas Tank Regulator 124

LP Gas Leaks 124

Avoiding Asphyxiation 125

MOTORHOME MAINTENANCE 127

Exterior Care and Maintenance 127

Roof 127

Underbody 127

Washing, Waxing and Polishing 127

Stripes and Decals 127

Exterior Lighting 127

Solar Panels 128

Interior Care 128

Carpets 128

Upholstery 128

Spots and Stains 128

Vinyl Fabrics 128

Draperies, Curtains and Bedspreads 129

Walls 129

TABLE OF CONTENTS UNITY MOTORHOME

4

Cabinetry, Tables and Countertops 129

Sinks 129

Refrigerator 129

Stove Top - General 129

Stove Top - Burners 129

Microwave/Convection Oven 130

Bathroom - General 130

Toilet 130

Doors and Windows 130

Storage and Winterization 130

Storage Checklist 130

Cold Temperature Storage 131

Spring Startup 131

Cold Temperature Operation 131

Chassis 131

LP Gas 131

Waste System 131

Water System Winterization 132

Draining the Water System 132

Adding Plumbing Anti-Freeze 132

Blowing Out the Air Lines 133

De-Winterizing the Water Systems 133

Maintenance and Servicing 134

LP Gas Tank Valve 134

Stabilizers 134

Entry Door Step 135

4 point leveling system 135

NEW VEHICLE LIMITED WARRANTY 137

UNITY MOTORHOME INTRODUCTION

5

INTRODUCTION

Congratulations! Thank you for selecting a Leisure Travel

Vans Motorhome.

Welcome to the exciting world of motorhome travel and

camping, with all the comforts of home with you, while

you travel and enjoy the outdoors.

Your motorhome has been designed and manufactured

to enhance your travel and camping experience and

to provide you with safe, efficient and trouble-free

operation.

Before your first drive, become familiar with the

operation of the vehicle chassis and all functions and

operations of the motorhome. Spend adequate time

with your dealer when you take delivery to learn all you

can about your new motorhome.

OWNER’S MANUAL

This manual was prepared to aid the operator and

occupants in the operation and care of the motorhome.

There are many options to Leisure Travel Vans, so ensure

that you are familiar with your motorhome’s systems

and equipment. All operators and occupants of the

motorhome should read, understand and follow the

instructions in this manual, the vehicle chassis manual &

the information contained in the Motorhome Information

Kit provided with your new motorhome.

Your motorhome contains a number of systems,

components, equipment, and appliances manufactured

by vendors that supply components for Triple E RV.

These vendors are unrelated to Triple E RV.

Before operating the motorhome for the ﬁrst time –

even if an experienced motorhome operator – read

and become familiar with all of the relevant manuals

to your motorhome, components, equipment and

appliances provided in the Motorhome Information

Kit. Your familiarity with the detailed operation of

your motorhome will assist in your safe, efﬁcient and

trouble-free motorhome operation.

KEEP the Motorhome Information Kit within your

motorhome for readily available reference.

PASS this manual, the Chassis Operation Manual and

the Motorhome Information Kit to any subsequent

operator or owner.

For clariﬁcation or further details on any of the enclosed

information, please contact:

Your Leisure Travel Vans Dealer or Triple E RV Customer

Service at:

Email: info@tripleerv.com

Toll Free: 8779929906

Telephone: 2043254361

Fax: 2043255241

INTRODUCTION UNITY MOTORHOME

6

MOTORHOME INFORMATION KIT

The Motorhome Information Kit includes but isn’t limited

to information on the components, equipment and

appliances listed below (based on options selected).

•Refrigerator

•Stove top

•Furnace

•Electrical Panel

•Toilet

•Water Heater

•Water Pump

•Water Filtration

•Vent (roof)

•Fire Extinguisher

•Smoke Detector

•Thermostat

•CO Detector

•Propane Detector

•Gas Regulator

•TV Antenna

•TV/DVD

•Chassis

•Air Conditioner

•Generator

•Stabilizers/Leveling Jacks

•Rear View Monitor

•Inverter

•Entertainment System

•Safety

•Flooring and Countertops

•Electric Step

•Solar Panel

•Surge Protector

•Safe

•Awning

OPTIONS AND EQUIPMENT

Leisure Travel Vans are available in various sizes

and floor plan configurations and with differing

optional equipment. The equipment, accessories and

components described in this manual may not apply in

all respects to your motorhome. Read the material and

manuals provided in the Motorhome Information Kit for

detailed instructions regarding the equipment speciﬁc

to your motorhome.

VEHICLE CERTIFICATION LABELS

The vehicle certiﬁcation labels afﬁxed to your motorhome

contain vehicle identification and other important

reference information. Never remove or destroy these

labels. The labels are located on the driver & passenger

door frames. See location details on the following page.

REFERENCE NUMBER CODES

MANUFACTURE/CONVERSION DATE

The date on which the coach portion of your motorhome

was built.

GROSS VEHICLE WEIGHT RATING GVWR

The maximum permissible weight of this fully loaded

motorhome.

SLEEPING CAPACITY WEIGHT RATING SCWR

The manufacturer’s designated number of sleeping

positions multiplied by 154 lbs (70 Kgs).

OCCUPANT AND CARGO CARRYING CAPACITY

OCCC

The value equal to the GVWR minus UVW and full LP

Gas weight. In other words, OCCC is the amount of

weight in occupants, cargo, water and trailer tongue

weight that can be added to the motorhome without

exceeding the GVWR.

GROSS COMBINED WEIGHT RATING GCWR

The Gross Combined Weights Rating of the motorhome,

i.e, combined weight of the Motorhome and any towed

vehicle.

DESIGNATED SLEEPING CAPACITY

The manufacturer’s designated number of sleeping

positions.

GROSS AXLE WEIGHT RATING GAWR

The value speciﬁed as the load carrying capacity of

a single axle system, as measured at the tire-ground

interface.

TIRE SPECIFICATION

Recommended tires speciﬁcation to meet handling,

loading and safety requirements. Replacement tires

must meet these speciﬁcations.

UNITY MOTORHOME INTRODUCTION

7

COLD TIRE INFLATION PRESSURE

Inﬂation pressures recommended (while cold) for the

tires originally installed on your motorhome. These tire

pressure levels must be maintained to ensure proper

handling, safety and fuel economy.

CARGO CARRYING CAPACITYCCCCANADA

Equal to GVWR minus each of the following: UVW, full

fresh (potable) water weight (including water heater),

full LPGas weight and SCWR.

UNLOADED VEHICLE WEIGHT UVW

The weight of this motorhome as manufactured at the

factory with full fuel, engine oil and coolants.

MASS OF WASTE WATER TANKS

Total weight of the black and grey water tanks when

ﬁlled to capacity.

VEHICLE IDENTIFICATION NUMBER VIN

This number identifies the chassis on which the

motorhome is built.

TYPE

The National Highway Traffic Safety Association

(NHTSA) designated usage classification for your

Motorhome. MPV signiﬁes a Multi-purpose vehicle.

CERTIFICATION LABEL SAMPLES

LOCATED IN WARDROBE CLOSET CANADA MODELS ONLY

LOCATED ON DRIVESIDE DOOR FRAME CANADA MODELS

LOCATED ON DRIVERSIDE DOOR FRAME US MODELS

LOCATED ON PASSENGERSIDE DOOR FRAME US MODELS

LOCATED ON DRIVERSIDE DOOR FRAME ALL MODELS

LOCATED IN WARDROBE CLOSET ALL MODELS

LOCATED ON PASSENGER SIDE CAB PILLAR ALL MODELS

INTRODUCTION UNITY MOTORHOME

8

UNITY FLOOR PLANS

U24MB PASSENGER SIDE VIEW

1 Light

2 Refrigerator Vents

3 External Receptacle

4 Awning

5 Entrance Step

6 BBQ Hook-Up

7 Storage Compartment

8

Inverter and Storage Compartment

9 Furnace Exhaust

10 Generator Compartment

11 Ladder

1

22

3

4

5

6

77

8

9

10

11

U24MB DRIVER SIDE VIEW

1 Awning

2 Slide Out Room

3 Water Heater

4 Diesel Fill

5 Storage Compartment

6

Sewer Hose Hatch (Behind Doors)

7 Shore Power Connection

8 Utility Center

9 Sewer Termination

1 2

34 55 6

7 8 9

UNITY MOTORHOME INTRODUCTION

9

U24MB TOP VIEW

1 Solar Panel

2 Roof Vent

3 Sky Light

4 Air Conditioner

5 WiFi/TV Antenna

6 Satellite

7 Stack Vent

111

12

23

3

4

56

7

U24MB LEISURE LOUNGE FLOOR PLAN

INTRODUCTION UNITY MOTORHOME

10

U24MB LEISURE LOUNGE PLUS FLOOR PLAN

UNITY MOTORHOME INTRODUCTION

11

U24CB PASSENGER SIDE VIEW

1 Light

2

Inverter and Storage Compartment

3 External Receptacle

4 Water Heater

5 BBQ Hook-Up

6 Storage Compartment

7 Furnace Exhaust

8 Awning

9 Entrance Step

10 Ladder Option

1

2

3

4

566

7

8

9

10

U24CB DRIVER SIDE VIEW

1 Slide Out Room

2 Awning

3 Refrigerator Vents

4 Sewer Termination

5 Diesel Fill

6 Generator Compartment

7 Storage Compartment

8

Sewer Hose Hatch (Behind Doors)

9 Shore Power Connection

10 Utility Center

1

2

33 4

5678

9

10

INTRODUCTION UNITY MOTORHOME

12

U24CB TOP VIEW

1 Solar Panels

2 Roof Vent

3 Skylight

4 Stack Vent

5 Satellite

6 A/C

7 TV/WiFi Antenna

8 Stack Vent

11

23

3

4

56

7

2

8

U24CB BOOTH DINETTE FLOOR PLAN

UNITY MOTORHOME INTRODUCTION

13

U24CB ULOUNGE FLOOR PLAN

INTRODUCTION UNITY MOTORHOME

14

U24IB PASSENGER SIDE VIEW

1 Light

2

Inverter and Storage Compartment

3 External Receptacle

4 Generator Compartment

5 BBQ Hook-Up

6 Storage Compartment

7 Furnace Exhaust

8 Refrigerator Vents

9 Awning

10 Entrance Step

11 Ladder Option

1

2

3

4

5

66

6 7

88

9

10

11

U24IB DRIVER SIDE VIEW

1 Water Heater

2 Sewer Hose (Behind Doors)

3 Diesel Fill

4 Storage Compartment

5 Utility Center

6 Shore Power Connection

7 Sewer Termination

12

344 4

5

67

UNITY MOTORHOME INTRODUCTION

15

U24IB TOP VIEW

1 Solar Panels

2 Roof Vent

3 Skylight

4 Stack Vent

5 Satellite

6 A/C

7 TV/WiFi Antenna

11

1122

3

34

5

6 7

U24IB FLOOR PLAN

INTRODUCTION UNITY MOTORHOME

16

U24TB PASSENGER SIDE VIEW

1 Light

2

Inverter and Storage Compartment

3 External Receptacle

4 Generator Compartment

5 BBQ Hook-Up

6 Storage Compartment

7 Furnace Exhaust

8 Refrigerator Vents

9 Awning

10 Entrance Step

11 Ladder Option

1

2

3

4

5

66

6 7

88

9

10

11

U24TB DRIVER SIDE VIEW

1 Water Heater

2 Sewer Hose (Behind Doors)

3 Diesel Fill

4 Storage Compartment

5 Utility Center

6 Shore Power Connection

7 Sewer Termination

12

344 5

6 7

UNITY MOTORHOME INTRODUCTION

17

U24TB TOP VIEW

1 Solar Panels

2 Roof Vent

3 Skylight

4 Stack Vent

5 Satellite

6 A/C

7 TV/WiFi Antenna

11

11223

3

4

5

6

7

U24TB FLOOR PLAN

INTRODUCTION UNITY MOTORHOME

18

U24 FX PASSENGER SIDE VIEW

1 Light

2

Inverter and Storage Compartment

3 External Receptacle

4 Awning

5 Generator Compartment

6 BBQ Hook-Up

7 Storage Compartment

8 Entrance Step

9 Furnace Exhaust

10 Water Heater

11 Ladder Option

1

2

3

4

6

67

75 8

9

10

11

U24FX DRIVER SIDE VIEW

1 Refrigerator Vents

2 Awning

3 Diesel Fill

4 Storage Compartment

5 Sewer Hose (Behind Doors)

6 Shore Power Connection

7 Utility Center

8 Slide Out Room

9 Sewer Termination

11

2

3 44

567

8

9

UNITY MOTORHOME INTRODUCTION

19

U24FX TOP VIEW

1 Solar Panels

2 Roof Vent

3 Skylight

4 Stack Vent

5 Satellite

6 A/C

7 TV/WiFi Antenna

11

11 2

2

3

4

56 7

U24FX FLOOR PLAN

Page is loading ...

Leisure Unity Owner's manual

Related papers

Other documents