Gasmate 3020BPL Owner's manual

Brand: Gasmate

Model: 3020BPL

Type: Owner's manual

Gasmate 3020BPL is a portable gas heater designed for outdoor use. It features a new burner design that radiates heat more efficiently and a polished alloy reflector and safety guard. The heater screws directly onto a 3/8” BSP LH camping cylinder and uses propane gas.

Due to its portable nature, it is perfect for providing warmth while camping, fishing, or enjoying other outdoor activities. Moreover, it is easy to use. To light the heater, simply open the cylinder control valve approximately half a turn and light the gas at the burner either with a lighted match or by pressing the piezo ignitor. The flame can be regulated to the desired heat level by opening or closing the valve.

IMPORTANT

Read these instructions for use carefully.

Familiarise yourself with the appliance

before connecting it to its gas container.

Keep these instructions for future

reference.

ONLY USE IN WELL-VENTILATED AREAS.

CARBON MONOXIDE HAZARD!

THIS APPLIANCE CAN PRODUCE CARBON

MONOXIDE WHICH HAS NO ODOUR. USING

IT IN AN ENCLOSED SPACE (FOR EXAMPLE,

CARAVAN, TENT, CAR, MOBILE HOME)

MAY CAUSE DEATH.

• Donotmodifythisappliance.

• Checkthatsealsbetweentheapplianceand

 thegascontainerareinplaceandingood

 conditionbeforeconnectingthegascontainer.

• Donotusetheapplianceifithasdamagedor

 wornseals.

• Donotusethisapplianceifitisleaking,

 damagedordoesnotoperateproperly.

• Thisappliancemustonlybeservicedbyan

 authorizedperson.

• Theopeningsatthebaseoftheburner

 provideairforcombustion,theyshouldnever

 beobstructed.Iftheamebecomes

 signicantlyorangechecktheseopenings

 forablockage.

• Iftheappliancecannotbeadjustedto

 performcorrectlyitshouldnotbeuseduntil

 servicedorrepaired.

• Tocheckthatthegascylinderislled,when

 shakenasloshingsoundwillbeheard.

CAUTION:Accessiblepartsmaybeveryhot.

Keepyoungchildrenaway.

Duringusetheheaterbodywillbeveryhot.

Ensurethegasisturnedoffandtheheateris

coolbeforemoving.

USE OUTDOORS ONLY.

PROPANE PRODUCT

Thisapplianceshallonlybeusedwitha

propanegascylindercertiedtoAS2469.

IT MAY BE HAZARDOUS TO ATTEMPT TO

FIT OTHER TYPES OF GAS CONTAINERS.

Gascylindersshouldbestoredoutdoorsina

wellventilatedareaoutofreachofchildren.Any

indoorstorageshallcomplywithAS/NZS1596.

Afteruse,turnthegascylindervalveoffand

waitfortheametogoout.

Ifthereisaleakonyourappliance(smell

ofgas)immediatelyattempttoturnoffthe

cylindervalve.Removetheappliancetoa

well-ventilatedlocationawayfromanyignition

source.Checkforleaksusingsoapywater.Do

nottrytodetectleaksusingaame.

0274403/11

Important:Retaintheseinstructionsforfutureuse.

Gasmate

isaregisteredtrademarkof:SitroGroupAustraliaPtyLtdwww.gasmate.com.au

 AberLtd-Hamilton,N.Z. www.gasmate.co.nz

Portable Gas Heater

Model No. 3020B & 3020BPL

Product Features:

• Newburnerdesignradiates

 heatmoreefciently

• Polishedalloyreector

 andsafetyguard

• Screwsdirectlyonto

 a3/8”BSPLH

 campingcylinder

• Propanegas

• Foroutdooruseonly

• AGAcertied

For any queries or assistance call

Customer Service

(AustraliaOnly)

1300 174 876

Hoursofoperation:

MondaytoFriday8.30am-5.30pmEST

Do not return to place of purchase.

Contact1300174876

Yourpurchasereceiptwillberequiredforwarrantyclaims.

3020B-01

3020B-02

3020B-03

3020B-04

3020B-05

3020B-06

3020B-05

3020B-07

3020B-08

3020B-09

3020BPL

AD901

AD902

GENERAL INFORMATION

GAS CONSUMPTION g/h MJ/h BTU FM Jet

3020B and 3020BPL 96g/h 4.9MJ/h 4650BTU 0.13mm

SAFE APPLIANCE LOCATIONS

Thisapplianceshallonlybeusedinanabove

groundopen-airsituationwithnaturalventilation,

withoutstagnantareas,wheregasleakageand

productsofcombustionarerapidlydispersedby

windandnaturalconvection.

Any enclosure in which the appliance is used

shall comply with the following:

Anenclosurewithwallsonallsides,butatleast

onepermanentopeningatgroundlevelandno

overheadcover(seeExample1).

Withinapartialenclosurethatincludesan

overheadcoverandnomorethantwowalls

(seeExample2&3).

Within a partial enclosure that includes an

overhead cover and more than two walls, the

following will apply:

atleast25%ofthetotalwallareaiscompletely

open,andatleast30%oftheremainingwallarea

isopenandunrestricted(seeExample4&5).

In the case of balconies, at least 20% of the

total wall area shall be and remain open and

unrestricted.

DIAGRAMMATIC REPRESENTATIONS OF OUTDOOR AREAS

Thefollowingguresarediagrammaticrepresentationsofoutdoorareas.Rectangularareashavebeen

usedinthesegures–thesameprinciplesapplytoanyothershapedarea.

INSTRUCTIONS FOR USE

1. Removeappliancefromcartonandremove

 anytransitprotectionmaterial.

 a. Theapplianceareamustbekeptclearand

  freeofcombustiblematerials,gasolineand

  otherflammablevapoursandliquids.

 b. Gasorificesandburnermustbekept

  clearofdirtandcobwebs.Flowof

  combustionandventilationairthroughthe

  perforatedportionsoftheappliancemust

  notbeobstructed.

 c.Anycleaningagentusedontheappliance

  shouldbeofanon-combustibleand

  non-corrosivenature.

2. Properclearancefromcombustiblematerials

 mustbemaintainedatalltimes.Theminimum

 clearancesareasfollows:

Minimum Clearance from Combustibles:

Side600mm Top600mm

Combustiblematerialsareconsideredtobe

wood,compressedpaper,plantfibres,plastic,

plexiglasorothermaterialscapableofbeing

ignitedandburned.

Suchmaterialsshallbeconsideredcombustible

eventhoughflameproofed,fire-retardant

treatedorplastered.Additionalclearancemay

berequiredforglass,paintedsurfacesandother

materialswhichmaybedamagedbyradiantor

convectionheat.

3. Attachtheappliancetothespecifiedcylinder

 andensurethatcontrolvalveisfullyclosed

 andthesealinggasketisfirmlysealedagainst

 neckofconnector.

4. Theapplianceshouldonlybeoperatedonlyon

 alevelandstablesurface.

LIGHTING AND REGULATING

Openthecylindercontrolvalveapproximately

halfaturnandlightgasatburnereitherwith

alightedmatchorpressingthepiezoignitor.

Regulatetheflametotheheatdesiredby

openingorclosingthevalve.Avoidexcessflame

fromthegauze.

REPLACING JETS

Ifthejetshouldbecomeblockedorneed

replacement,unscrewtheadaptorandremove

jet.Toclearblockedjetswashinpetrol.Donot

usewiresorprickers.Ifwashingisunsuccessful,

fitnewjet.

ANNUAL MAINTENANCE

Cleanthebodyofyourapplianceusingacotton

clothsoakedinsoapyhotwater.Neveruse

abrasiveorflammablecleaningproducts.Usea

softbrushtocleantheburner.

STORAGE

Whentheapplianceisnotuseditmustbe

storedinasuitableareatoprotectitfromany

riskofdeterioration.Keepitinawellventilated

areaandoutofreachofchildren.

HANDY HINTS

a.Inspectthe“O”Ringandrubberwasher

 regularlyandreplaceifwornordamaged.

b. Neverconnectordisconnecttheappliance

 nearanopenflame.

c. CheckforgasleakswithSOAPYWATER.

DO NOT USE A FLAME.

d. Ensuretheapplianceiscompletely 

 extinguishedbeforedisconnectingfromthe

 cylinder.

e. DONOTplacetheappliancecloserthan60cm

 fromceilingorflammablematerial.

f. Whenliftingappliancealwaysusethehandle

 onthegascylinder,NEVERUSETHEHEATER.

SPARE PARTS

3020B-01 Gaurd

3020B-02 HeatingGauze

3020B-03 Locknut

3020B-04 Reflector

3020B-05 Locknut

3020B-06 BurnerTube

3020B-07 ShieldCup

3020B-08 AirMixingCollar

3020B-09 FMJet(0.13mm)

AD9-01 Connectorforcylinderwith

3/8”BSPLHmalethreading

AD9-02 0-Ringforconnector

3020BPL Piezoignitorassembly

GAS CONTROL

Gasmate 3020BPL Owner's manual

Gasmate 3020BPL Owner's manual

Gasmate 3020BPL Owner's manual

Related papers

Other documents