Perle IOLAN SDG4 / SDG4 TX / STG4 Quick start guide

Brand: Perle

Model: IOLAN SDG4 / SDG4 TX / STG4

Type: Quick start guide

IOLANSDG4/SDG4TX/STG4QuickStartGuide‐P/N5500421‐10(RevC)

IOLANSDG4

SDG4TX/STG4

QuickStartGuide

______________________________________________________________

TheSDG4/SDG4TX/STG4modelsprovideSerialtoEthernetconnectivity.Leading

edgefeaturesinclude;universalsoftwareselectableEIA232/422/485interface,

nextgenerationIPsupport(IPV6)and10/100/1000Ethernetspeeds.

Thisguidecoversbasicinstallationandconfigurationandisintendedforfirsttime

setuporproductevaluation.

Completedetailscanbefoundinthefollowingguidesat

www.perle.com/downloads.

IOLANUser’sGuide

IOLANCommandLineInterfaceReferenceGuide

IOLANSDG4/SDG4T/STG4HardwareInstallationGuide

What’s in the box?

 TheIOLAN

SDG4–4portswithfourRJ45serialportsor

SDG4TX–ExtendedTemperaturewith4portswithfourRJ45serialportsor

STG4–4portswithfourRJ45serialports(RS232only)

 Externalpowersupply

 AQuickStartGuide(thisdocument)

 RJ45‐DB9adapter

 Poweradapter,strainreliefstrapandrubberfeet

 Wallmountbrackets

Hardware Overview

IOLANSDG4/SDG4TX/STG4QuickStartGuide‐P/N5500421‐10(RevC)

2

Back View SDG4/STG4 with connector for Barrel Connection

Back View SDG4 TX with connector for Terminal Connection

Button/Switch Functions

ResetButton

TheinsetRESETbuttonwillreboottheIOLANifpushedinandreleasedquickly.It

willresettheIOLANtofactorydefaultsifpushedinandheldformorethanthree

seconds

ConsoleSwitch

TheIOLANissetinthefactorytoserial(upposition).Unlessyouplantoattacha

consoletotheIOLAN,leavethedipswitchintheserialposition.IfthisDIPswitchis

settothedownposition,thentheserialportisinconsolemode.Inconsolemode,

theportprovidesaccesstotheIOLANmanagementfunctionusingtheindustry

standardCLIcommandset.SeetheIOLANCommandLineInterfaceReference

Guide.



Connecting the Hardware

Connectingthebarrelconnector

PlugthebarrelconnectorendintotheIOLAN,thenplugthepoweradapterintoa

powersource.ThePower/ReadyLEDshouldshowasolidgreenaftertheboot

sequence.



WiringtheTerminalBlock



1. EnsurepowerisNOTappliedtothewirespriortoconnection.

IOLANSDG4/SDG4TX/STG4QuickStartGuide‐P/N5500421‐10(RevC)

3

2. Oneachendwire(12‐20AWG),removetheinsulationfromthecopperwire

5mm(3/16ofaninch).

3. Loosentheleftscrewonthetopoftheterminalconnectorblock,theninsert

yourpositive(+)wireintotheleftterminalandscrewitdowntight(.51Nm

torque).Loosentherightscrewonthetopoftheterminalconnectorblock,

theninsertyournegative(‐)wireintotherightterminalandscrewitdown

tight(.51Nmtorque).

4. Turnonpoweratsource.

5. ConnecttheEthernetcablefromtheRJ‐45plug(10/100/1000)totheHUBor

switchthatwillprovidenetworkconnectivity(ifapplicabletoyour

application).

6. TheconsoledipswitchontheIOLANshouldbesettotheuppositionfor

serialmode.

7. Connectthepowercordstrainrelief,ifdesired.SeeIOLANSDG4/SDG4TX

/STG4HardwareInstallationGuidefordetails.

8. Connectthegroundinglug(notprovided)tothegroundingscrew,ifdesired.

SeeIOLANSDG4/SDG4TX/STG4HardwareInstallationGuidefordetails.



Power On Cycle

WhenthepowerisconnectedtotheIOLAN,thePower/ReadyLEDwillcycle

throughseveralsequencesandwillendinasolidgreenoncetheunitisfully

bootedandreadytobeconfigured.IftheLEDisnotsolidgreenaftertwominutes,

seetheIOLANSDG4/SDG4TX/STG4HardwareInstallationGuide.



LED Guide

SystemReady

GreenSolid—SystemReady

Flashing—SystemisbootingorDIPswitchisinconsolemode

Yellow—Flashing—Booting

Red—Errorcondition.SeetheIOLANSDG4/SDG4T/STG4Hardware

InstallationGuide

Link10/100/1000

Green—1000Mbps(flasheswithactivity)

Amber—10/100Mbps(flasheswithactivity)

Off—NoLANconnection

SerialActivity

Off—Noserialactivity

On—Tx/Rxflasheswithtransmit/receiveserialactivity



IOLANSDG4/SDG4TX/STG4QuickStartGuide‐P/N5500421‐10(RevC)

4

Connecting Ethernet

ConnectthenetworktotheEthernetportusingaCat5/5eEthernetcable.

Connecting the Serial Device

ConnecttheserialdevicetotheIOLANserialport.

SeetheIOLANSDG4/SDG4T/STG4HardwareInstallationGuideforpinoutdetails

andhowtoterminatetheserialportfor485/Full/Halfand422modeifyour

applicationrequiresit.

Configuring the Unit

TheIOLANfeaturesseveraldifferentconfigurationmethods(i.e.HTTP,Telnet,

SNMP)aswellasanexternalWindowsbasedUtility(DeviceManager).Forthe

mostuptodatedocumentationonanyoftheseconfigurationmethodsseethe

IOLANUser'sGuideorforthemostrecentversionoftheDeviceManagerand

otherutilities,pleaserefertothePerlewebsiteatwww.perle.com

Connecting to the IOLAN

1. InstalltheDeviceManagertoyourlaptoporPC.

2. StarttheDeviceManagerprogramfrominstalledprograms.

3. UndertheDeviceManagermenu,selectFile,thenselectConnectto.

4. YourIOLANwillshowasUnconfiguredinthelist.

5. SelectyourIOLANfromthelistandselecttheAssignIPbutton.

6. AssignavalidIPaddresstotheIOLANthatisonyournetwork.

7. Youwillbepromptedbythesoftwarefortheadminpasswordbeforebeing

abletoconnectandconfiguretheIOLAN(superuser(casesensitive)).

8. Youshouldchangetheadminpasswordtorestrictunauthorizedaccessto

theIOLAN.

Registering the IOLAN

YoushouldregisterIOLANonlineat:

www.perle.com/support_services/warranty_reg.asp

Contacting Technical Support

ContactinformationforthePerleTechnicalAssistanceCenter(PTAC)canbefound

atthelinkbelow.

www.perle.com/support_services/support_request.shtm

Perle IOLAN SDG4 / SDG4 TX / STG4 Quick start guide

Perle IOLAN SDG4 / SDG4 TX / STG4 Quick start guide

Perle IOLAN SDG4 / SDG4 TX / STG4 Quick start guide

Related papers

Other documents