Eastman Kodak DryView 8700 User manual

Brand: Eastman Kodak

Model: DryView 8700

Category: Measuring, testing & control

Type: User manual

This manual is also suitable for

User Guide

Kodak DryView 8700/8500 Laser Imager

8599110

41-1202-0176-3

3/01 Rev. B

Warnings and Cautions

2001 March Rev. B 8599110

Warnings and Cautions for

Kodak DryView 8700/8500 Laser Imager

Safety Instructions

Read and understand all instructions before using.

WARNING

This equipment is operated with hazardous voltage which can shock,

burn, or cause death.

Remove wall plug before servicing equipment. Never pull on cord to remove from

outlet. Grasp plug and pull to disconnect.

Do not operate equipment with a damaged power cord.

Do not use an extension cord to power this equipment.

Position the power cord so it will not be tripped over or pulled.

Connect this equipment to a grounded outlet.

Use only the power cord supplied with this equipment.

WARNING

For Continued Protection against Fire, Replace Fuses with only the Same Type and

Fuse Rating.

WARNING

This equipment contains moving parts that may be accessible to the user. Loose

clothing, jewelry, or long hair may cause minor personal injury or damage to the

equipment. Do not operate equipment with the covers open. Do not operate

equipment with any of the safety interlocks overridden.

WARNING

This equipment is not contained in a sealed cabinet. Therefore, it must not be used

in locations where it can come in contact with liquids, including bodily fluids.

User Guide

8599110 2001 March Rev. B

CAUTION

Avoid Laser Beam

This equipment employs a 150 milliwatt laser. Laser radiation may be

present when the machine operates without panels or covers installed.

Use of controls or adjustments, or performance of procedures other than those

specified herein, may result in eye damage.

Covers shall be removed by authorized service personnel only.

CAUTION

Do not substitute or modify any part of this equipment without approval of Eastman

Kodak Company.

CAUTION

General External Cleaning: This equipment may be cleaned with a damp cloth

using water with mild detergent, or commercial electronic equipment cleaner.

ATTENTION:

Surface Chaude. Ne pas toucher!

ACHTUNG:

Nicht anfassen. Heisse Oberflache!

ATTENZIONE:

Non toccare. Superficie Calda!

CAUTION:

Do not touch. Hot surface!

ADVERTENCIA:

No tocar. Superficia Caliente!

OPGEPAST:

Niet aanraken. Heet Oppervlak!

Do not touch, Hot Surface!

CAUTION

U.S. Federal law restricts this device to the sale by, or on the order of, a licensed

health care practitioner.

Warnings and Cautions

iii

2001 March Rev. B 8599110

CAUTION

This equipment is intended to connect to other medical devices. Only qualified

service personnel may perform installation and service maintenance. The laser in

the equipment is not a patient device. Therefore, the equipment must be installed no

closer than 1.83 meters from a patient bed or chair.

CAUTION

Do not use in the presence of flammable anesthetics, oxygen or nitrous oxide. This

equipment does not have a gas–sealed electronics enclosure and could ignite any

flammable or explosive gases present in its environment.

CAUTION

This equipment has been tested and found to comply with the limits for a Class B

digital device, pursuant to part 15 of the FCC rules. Those limits are designed to

provide reasonable protection against harmful interference in a residential

installation. This equipment generates, uses, and can radiate radio frequency

energy and, if not installed and used in accordance with the instructions, may cause

harmful interference to radio communications. However, there is no guarantee that

interference will not occur in a particular installation. If this equipment does cause

harmful interference to radio or television reception, which can be determined by

turning the equipment off and on, the user is encouraged to try to correct the

interference by one or more of the following measures:

 Reorient or relocate the receiving antenna.

 Increase the separation between the equipment and the receiver.

 Connect the equipment into an outlet on a circuit different from that to which the

receiver is connected.

 Consult the dealer or an experienced radio/TV technician for help.

 FCC ID: PA4870085007E2620

User Guide

8599110 2001 March Rev. B

Class 1 Laser

Laser de catégorie 1

Laser-Klasse 1

Laser di Classe 1

Klass 1 Laser

Front

Left

Rear

DANGER - Invisible Laser Radiation When Open.

Avoid Direct Exposure to Beam.

ATTENTION - Rayonnement Laser Invisible En Cas

D’Ouverture. Exposition Dangereuse

Au Faisceau.

VORSICHT - Unsichtbare Laserstrahlung Wenn Abdeckung

Geöffnet. Nicht Dem Strahl Aussetzen.

VARNING - Osynlig Laserstrålning. Laserstråining När

Denna Del Ä Öppnad. Strålen Är Farlig.

Warnings and Cautions

2001 March Rev. B 8599110

for External Interface Box Accessories

Read and understand all instructions before using.

Classifications

UL Classified

File Number E183646

Control Number 9R46

Medical Equipment

UL 2601-1 CAN/CSA No. 601.1

Classified by Underwriters Laboratories Inc.Ò With Respect to Electric Shock,

Fire, Casualty and Medical Hazards only in Accordance with UL 2601-1, CAN/CSA

C22.2 No. 601.1 and IEC 601.1.

WARNING

This equipment is operated with hazardous voltage which can shock,

burn or cause death.

¯ Remove wall plug before servicing equipment. Never pull on cord to remove from

outlet. Grasp plug and pull to disconnect.

¯ Do not operate equipment with a damaged power cord.

¯ Do not use an extension cord to power this equipment.

¯ Use only the power cord supplied with this equipment.

¯ Position the power cord so it will not be tripped over or pulled.

¯ Connect this equipment to a grounded outlet.

¯ Do not place a portable multiple--socket outlet (power strip) on the floor. Mount

the power strip on a wall or on the underside of a table.

User Guide

8599110 2001 March Rev. B

WARNING

This equipment contains moving parts that may be accessible to the user. Loose

clothing, jewelry or long hair may cause minor personal injury or damage to the

equipment. Do not operate equipment with the covers open. Do not operate

equipment with any of the safety interlocks overridden..

WARNING

This equipment is not contained in a sealed cabinet. Therefore, it must not be used

in locations where it can come in contact with liquids, including bodily fluids.

WARNING

For Continued Protection against Fire, Replace Fuses with only the Same Type and

Fuse Rating.

CAUTION

Do not substitute or modify any part of this equipment without approval of Eastman

Kodak Company.

CAUTION

General External Cleaning: This equipment may be cleaned with a damp cloth

using water with mild detergent, or commercial electronic equipment cleaner.

Type B Applied Part

CAUTION

Do not use in the presence of flammable anesthetics, oxygen or nitrous oxide. This

equipment does not have a gas--sealed electronics enclosure and could ignite any

flammable or explosive gases present in its environment.

CAUTION

This equipment is intended to connect to other medical devices. Only qualified

service personnel may perform installation and service maintenance.

CAUTION

U.S. Federal law restricts this device to the sale by, or on the order of, a licensed

health care practitioner.

Warnings and Cautions

vii

2001 March Rev. B 8599110

Read and understand all instructions before using.

Label located on back of machine.

User Guide

viii

8599110 2001 March Rev. B

BLANK PAGE

Agency, Regulatory and CE Marking Compliance

2001 March Rev. B 8599110

Agency, Regulatory and CE Marking Compliance

This equipment has been tested for and complies with the following Safety and

Emission Standards. Certificates of Compliance and Declarations of Conformity

have been issued as shown below.

Safety:

Canada:

 C22.2 NO 950-95–CAN/CSA Safety for Information Technology Equipment,

Including Electrical Business Equipment

 C22.2 NO 601.1–M90–CAN/CSA Medical Electrical Equipment – Part 1:

General Requirements for Safety

 CSA–CS–03: Rules for Telecommunication Equipment

Europe:

 EN60950: Safety of Information Technology Equipment, Including Electrical

Business Equipment (IEC 60950 : 1991, Modified) (Includes Amendment A1 and

A2: 1993)

 EN60601–1–1: Medical electrical equipment – Part 1: General requirements for

safety – Section 1: Collateral standard: Safety requirements for medical electrical

systems

 EN60825–1: Safety of laser products – Part 1: Equipment classification,

requirements and user’s guide

U.S.A.:

 UL 1950: Safety of Information Technology Equipment, Including Electrical

Business Equipment DOD (Bi–National Standard) with UL 2601–1 Medical

Electrical Equipment, Part 1: General Requirements for Safety

 21CFR1040.10 Class I: FDA CDRH Code of Federal Regulations Title 21,

Volume 8, Food and Drugs, Part 1040 Performance Standards For

Light–Emitting Products, Section 10 Laser Products

 FDA Premarket Notification 510(K): Regulatory Requirements For Medical

Devices

 47 CFR Part 68: FCC Rules for Telecommunication Equipment

User Guide

8599110 2001 March Rev. B

Rest of World:

 IEC 950: Safety of information technology equipment

 IEC 60601–1–1: Medical electrical equipment – Part 1: General requirements for

safety – Section 1: Collateral standard: Safety requirements for medical electrical

systems

 IEC 60825–1: Safety of laser products – Part 1: Equipment classification,

requirements and user’s guide

EMC:

Canada:

 CAN/CSA–C108.6–M91 Class A: Limits and Methods of Measurement of

Electromagnetic Disturbance Characteristics of Industrial, Scientific and Medical

(ISM) Radio–Frequency Equipment

Europe:

 EN55022 (CISPR 22) Class B Group 1: Limits and Methods of Measurement of

Radio Interference Characteristics of Information Technology Equipment

 EN300330: 1999 European Telecommunication Standard, Sections 7.2 and 7.4

Emission Requirements

 EN300683: 1997 European Telecommunication Standard, Section 8 Emission

Requirements and Immunity Requirements

 EN61000–3–2 (IEC 1000–3–2): 1995 Electromagnetic Compatibility (EMC) –

Part 3: Limits – Section 2: Limits for Harmonic Current Emissions (equipment

input current <= 16A per phase)

 EN61000–3–3 (IEC 1000–3–3): 1995 Electromagnetic Compatibility (EMC) –

Part 3: Limits – Section 3: Limits for Voltage Flicker Emissions (equipment input

<– 16A per phase)

 EN 61000–4–2 (IEC 1000–4–2): Electromagnetic Compatibility (EMC) – Part 4:

Testing and Measurement techniques – Section 2: Electrostatic Discharge

Immunity Test. Basic EMC Publication

 EN 61000–4–3 (IEC 1000–4–3): Electromagnetic Compatibility (EMC) – Part 4:

Testing and Measurement Techniques – Section 3: Radiated, Radio–frequency,

Electromagnetic Field Immunity Test

 EN 61000–4–4 (IEC 1000–4–4): Electromagnetic Compatibility (EMC) – Part 4:

Testing and Measurement techniques – Section 4: Electrical Fast Transient/Burst

Immunity Test. Basic EMC Publication

Agency, Regulatory and CE Marking Compliance

2001 March Rev. B 8599110

 EN 61000–4–5 (IEC 1000–4–5): Electromagnetic Compatibility (EMC) – Part 4:

Testing and Measurement Techniques – Section 5: Surge Immunity Test

 EN 61000–4–6 (IEC 1000–4–6): Electromagnetic Compatibility (EMC) – Part 4:

Testing and Measurement Techniques – Section 6: Immunity to Conducted

Disturbances, Induced by Radio–Frequency Fields

 EN61000–4–8 (IEC1000–4–8): Electromagnetic Compatibility (EMC) – Part 4:

Testing and Measurement Techniques – Section 8: Power Frequency Magnetic

Field

 EN 61000–4–11 (IEC 1000–4–11): Electromagnetic Compatibility (EMC) –

Part 4: Testing and Measuring Techniques – Section 11: Voltage Dips, Short

Interruptions and Voltage Variations Immunity Tests

U.S.A.:

 FCC Rules and Regulations, Title 47, Part 15, Subpart B, Class B: Radio

Frequency Devices: Unintentional Radiators; Part 15, Subpart C, Section 15.209

Radiated Emission Requirements

Rest of World:

 CISPR 22 Class B Group 1: Limits and Methods of Measurement of Radio

Interference Characteristics of Information Technology Equipment

Directives:

EU:

 73/23/EEC Council Directive on the Harmonization of the Laws of Member

States Relating to Electrical Equipment Designed for Use within Certain Voltage

Limits

 89/336/EEC Council Directive on the Approximation of the Laws of the Member

States Relating to Electromagnetic Compatibility

 93/42/EEC Council Directive Concerning Medical Devices

 99/5/EEC Council Directive on Radio Equipment and Telecommunications

Terminal Equipment

0123

User Guide

xii

8599110 2001 March Rev. B

CE Marking:

Documents concerning the conformance of this product to Council Directive

93/42/EEC of 14 June 1993 concerning Medical Devices can be obtained from the

Eastman Kodak Health Imaging Systems European Representative at:

Kodak AG

Quality Services

Product Safety

70323 Stuttgart

Germany

Phone: ++49 711 406 2993

Fax: ++49 711 406 3513

DOC:

 Canada 1016104159A

This Class A digital apparatus meets all requirements of the Canadian

Interference-Causing Equipment Regulations.

Cet appareil numérique de la Classe A respecte toutes les exigences du Règlement

sur le matérial brouilleur du Canada.

Table of Contents

xiii

2001 March Rev. B 8599110

PLEASE NOTE

The information contained herein is based on the experience

and knowledge relating to the subject matter gained by Eastman

Kodak Company prior to publication.

No patent license is granted by this information.

Eastman Kodak Company reserves the right to change this

information without notice and makes no warranty, express or

implied, with respect to this information. Kodak shall not be liable

for any loss or damage, including consequential or special

damages, resulting from the use of this information, even if loss

or damage is caused by Kodak’s negligence or other fault.

Table of Contents

Description Page

Warnings and Cautions

for DryView 8700/8500 Laser Imager i. . . . . . . . . . . . . .

Warnings and Cautions

for External Interface Box Accessories iv. . . . . . . . . . .

Agency, Regulatory and CE Marking Compliance vi. . . . .

Introduction 1-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Introducing the DryView 8700 and 8500 Laser Imagers 1-1

System Configurations 1-2. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Keypad Feature Comparison 1-3. . . . . . . . . . . . . . . . . . . . . . .

How the DryView 8700/8500 Laser Imager Works 1-4. . . .

Controls and Indicators 2-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

DryView 8700/8500 Laser Imager 2-1. . . . . . . . . . . . . . . . . .

Local Panel 2-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Local Panel – Main Menu 2-4. . . . . . . . . . . . . . . . . . . . . . . . . .

Local Panel – User Settings Menu (Applies to 8700/8500

Standard and Plus systems.) 2-6. . . . . . . . . . . . . . . . . . .

DryView 8700/8500 Keypad (Used only on 8700/8500

Standard systems.) 2-8. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Kodak Keypad (Used on 8700/8500 Standard and Plus

systems and on Multi–Input/Dual Printer systems.) 2-10

User Guide

xiv

8599110 2001 March Rev. B

Description Page

Kodak Keypad – Main Menu 2-12. . . . . . . . . . . . . . . . . . . . . . .

Kodak Keypad – Format Menu 2-14. . . . . . . . . . . . . . . . . . . . .

Kodak Keypad – Imager Menu 2-16. . . . . . . . . . . . . . . . . . . . .

Kodak Keypad – Contrast, Density, & Count Menu 2-18. . . .

Kodak Keypad – Keypad Menu 2-20. . . . . . . . . . . . . . . . . . . . .

Operation and Maintenance 3-1. . . . . . . . . . . . . . . . . . . . . . . . .

System Power Up 3-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Format/Acquire/Print – DryView 8700/8500 Keypad 3-2. .

Format/Acquire/Print – Kodak Keypad 3-3. . . . . . . . . . . . . . .

Density/Contrast Selection – Local Panel

(Applies to 8700/8500 Standard and Plus systems.) 3-4

Density/Contrast Selection – Kodak Keypad

(Applies to 8700/8500 Standard and Plus systems and

Multi–Input/Dual Printer systems.) 3-5. . . . . . . . . . . . . . .

Moving Stored Images – Kodak Keypad 3-6. . . . . . . . . . . . .

Erasing Stored Images – DryView 8700/8500 Keypad 3-7

Erasing Stored Images – Kodak Keypad 3-7. . . . . . . . . . . .

Deleting a Job from the Print Queue – DryView 8700/8500

Keypad 3-8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Deleting a Job from the Print Queue – Kodak Keypad 3-8.

Loading/Unloading Film 3-9. . . . . . . . . . . . . . . . . . . . . . . . . . .

Cleaning the Platen 3-10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Replacing the Developer Filter 3-12. . . . . . . . . . . . . . . . . . . . .

Troubleshooting 4-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Local Panel and Keypad Message Types 4-1. . . . . . . . . . . .

Local Panel Error Message Table 4-2. . . . . . . . . . . . . . . . . . .

Kodak Keypad Error Message Table 4-4. . . . . . . . . . . . . . . .

DryView 8700/8500 Keypad Error Message Table 4-5. . . .

Removing Jams from Area 1 4-6. . . . . . . . . . . . . . . . . . . . . . .

Removing Jams from Area 2a 4-7. . . . . . . . . . . . . . . . . . . . . .

Removing Jams from Area 2b 4-8. . . . . . . . . . . . . . . . . . . . . .

Removing Jams from Area 3 4-9. . . . . . . . . . . . . . . . . . . . . . .

Table of Contents

2001 March Rev. B 8599110

Description Page

Removing Jams from Area 4 4-10. . . . . . . . . . . . . . . . . . . . . . .

Removing Jams from Area 5 4-12. . . . . . . . . . . . . . . . . . . . . . .

Manually Closing the Film Cartridge 4-13. . . . . . . . . . . . . . . . .

Unlocking the Left Door and Supply Door Via Mechanical

Releases 4-14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Specifications 5-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Dimensions 5-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Electrical 5-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Operating Environment 5-1. . . . . . . . . . . . . . . . . . . . . . . . . . . .

Environmental Effects 5-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

DryView 8700/8500 Laser Imager Storage

Environment 5-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Host Control 5-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

DryView 8700/8500 Keypad 5-2. . . . . . . . . . . . . . . . . . . . . . .

Kodak Keypad 5-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Technical Information 6-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Description 6-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Spectral Sensitivity 6-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Image Quality 6-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Automatic Image Quality Control 6-2. . . . . . . . . . . . . . . . . . .

Less Impact on the Environment 6-3. . . . . . . . . . . . . . . . . . .

Storage and Handling of Undeveloped Film 6-4. . . . . . . . . .

Handling of Developed Film 6-4. . . . . . . . . . . . . . . . . . . . . . . .

Archivability of Developed Film 6-5. . . . . . . . . . . . . . . . . . . . .

Exposure to Moisture 6-5. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Odor Dissipation 6-5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Heat Dissipation 6-5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Film Recycling 6-6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

IMPORTANT NOTICE TO PURCHASER 6-6. . . . . . . . . . . .

User Guide

xvi

8599110 2001 March Rev. B

BLANK PAGE

Introduction

1-1

2001 March Rev. B 8599110

Introduction

Introducing the Kodak DryView 8700 and 8500 Laser Imagers

The Kodak DryView 8700 Laser Imager (8700 Laser Imager) and the Kodak

DryView 8500 Laser Imager (8500 Laser Imager) are continuous–tone laser

imagers with an integrated photothermographic film developer.

The two imagers are nearly identical except for film size. The 8700 Laser Imager

uses only 14” x 17” (35 x 43 cm) Kodak DryView Laser Imaging Film (DryView film).

The 8500 Laser Imager also uses DryView film but accepts only 11 in. x 14 in.

(28 x 35 cm) film sheets.

Both film sizes are available in clear or blue base, packaged in 125-sheet Kodak

Instant Daylight Load Film Cartridges.

The 8700/8500 Laser Imagers are both available in three different configurations,

with two different remote keypads, described later in this manual.

Figure 1-1. Kodak DryView 8700/8500 Laser Imager

User Guide

1-2

8599110 2001 March Rev. B

System Configurations

The 8700/8500 Laser Imagers are both available in three different configurations.

Key features of each configuration are:

8700/8500 Laser Imager Standard System

 Supports up to two inputs (can be upgraded to support multiple inputs).

 Provides up to 64 megabytes of image memory, in 16 megabyte increments.

 Uses copper cable for external connections.

 Image acquisition and printing are accomplished via host control, Kodak

DryView 8700/8500 Keypad, or Kodak Keypad.

8700/8500 Laser Imager Plus System

 Supports up to two inputs (can be upgraded to support multiple inputs).

 Provides up to 128 megabytes of image memory, in 32 megabyte increments.

 Uses fiber optic cable for external connections.

 Image acquisition and printing are accomplished via host control or Kodak

Keypad.

Multi-Input/Dual Printer System

 Consists of an 8700 or 8500 Dual Printer connected to a Kodak DryView 8800

Multi-Input Manager (8800 Multi–Input Manager) or 969 HQ Laser Imager.

 Supports up to eight inputs.

 Provides 32 or 64 megabytes of image memory per input.

 Uses fiber optic cable for external connections.

 Image acquisition and printing are accomplished via host control or Kodak

Keypad.

 The 8800 Multi–Input Manager can provide output connects for one or two laser

printers. Connects to any of the following printers:

– Kodak DryView 8700 Laser Imager

– Kodak DryView 8500 Laser Imager

– Kodak DryView 8300 Laser Imager

– 969 HQ Laser Imager

If dual printers are connected, the two printers can be the same or mixed.

Page is loading ...

Eastman Kodak DryView 8700 User manual

Brand: Eastman Kodak

Model: DryView 8700

Category: Measuring, testing & control

Type: User manual

This manual is also suitable for

Download PDF

report

Eastman Kodak DryView 8700 User manual

This manual is also suitable for

Eastman Kodak DryView 8700 User manual

Related papers

Other documents