CPG CK-HPSU212 Boasting 6 Powerful 30000 BTU Burners User manual

1

USERMANUAL

GasStepUpHotPlate

MODELS:CKͲHPSU212,CKͲHPSU424,

CKͲHPSU636

ϭϭ/201ϴ

02/2022

2



IMPORTANTFORFUTUREREFERENCE

Pleasecompletethisinformationandretainthismanualforthelifeoftheequipment.ForWarranty

Serviceand/orparts,thisinformationisrequired.



ModelNumberSerialNumberDatePurchased



WARNING:Foryoursafety,donotstoreorusegasolineorotherflammablevaporsor

liquidsinthevicinityofthisoranyotherappliances.Keeptheareafreeandclearof

combustibles.(SeeANSIZ83.14B,1991).



WARNING˖Improperinstallation,adjustment,alteration,serviceormaintenancecan

causepropertydamage,injury,ordeath.Readtheinstallationoperatingand

maintenanceinstructionsthoroughlybeforeinstalling,orservicingthisequipment.



WARNING˖Instructionsmustbepostedinaprominentlocation.Allsafetyprecautions

mustbetakenintheeventtheusersmellsgas.Safetyinformationcanbeobtainedfrom

yourlocalgassupplier.



CAUTION:Thesemodelsaredesigned,built,andsoldforcommercialuseonly.Ifthesemodels

arepositionedsothegeneralpubliccanusetheequipment,makesurethatcautions,

warnings,andoperatinginstructionsareclearlypostedneareachunitsothatanyone

usingtheequipmentwilluseitcorrectlyandnotinjurethemselvesorharmtheequipment.



GASPRESSURE

Theapplianceandit’sindividualshutoffvalve(tobesuppliedbyuser)mustbedisconnectedfrom

thegassupplypipingsystemduringanypressuretestingofthatsystemattestpressuresinexcessof

½psi(3.45kPa).

Theappliancemustbeisolatedfromthegassupplypipingsystembyclosingit’sindividualmanual

shutͲoffvalveduringanypressuretestingofthegassupplypipingsystemattestpressuresequalto

orlessthan½psi(3.45kPa).



WARNING˖Afactoryauthorizedagentshouldhandleallmaintenanceandrepair.Before

doinganymaintenanceorrepair,contactyourauthorizedservicerepresentative.



3



CongratulationsonyourpurchaseofCPGcommercialcookingequipment.CPGtakesprideinthe

designandqualityofourproducts.Whenusedasintendedandwithpropercareandmaintenance,

youwillexperienceyearsofreliableoperationfromthisequipment.Toensurebestresults,itis

importantthatyoureadandfollowtheinstructionsinthismanualcarefully.



TABLEOFCONTENTS:



ITEMPAGEITEMPAGE

Safetyprecautions 4Cleaning&Maintenance8

GeneralInstallationInstructions5Service/Repair8

Specifications&Dimensions5ExplosionViewDrawing9

Conversion6SparePartsList10Ͳ11

LightingInstructions7Warranty12



4



LOCATIONOFDATAPL AT E

Thedataplateislocatedonthesidepanel.

IMMEDIATELYINSPECTFORSHIPPINGDAMAGE

Equipmentshouldbeexaminedfordamagebeforeandduringunloading.Thefreightcarrierhas

assumedresponsibilityforitssafetransitanddelivery.Ifequipmentisreceiveddamaged,either

apparentorconcealed,aclaimmustbemadewiththedeliveringcarrier.



A)Apparentdamageorlossmustbenotedonthefreightbillatthetimeofdelivery.Itmustthenbe

signedbythecarrierrepresentative(Driver).Ifthisisnotdone,thecarriermayrefusetheclaim.The

carriercansupplythenecessaryforms.



B)Ifconcealeddamageorlossisnotapparentuntilafterequipmentisuncrated,arequestfor

inspectionmustbemadetothecarrierwithin15days.Thecarriershouldarrangeaninspection.Be

certaintoholdallcontentsandpackagingmaterial.



Installationshouldbeperformedbyaqualifiedinstallerwhothoroughlyread,understandsand

followstheseinstruction.



Ifyouhavequestionsconcerningtheinstallation,operation,maintenanceorserviceofthisproduct,

visitCookingPerformanceGroup’swebsiteatwww.CookingPerformanceGroup.com.



SAFETYPRECAUTIONS



DANGER˖Thissymbolwarnsofimminenthazardwhichwillresultinseriousinjuryor

death.



WARNING:Thissymbolreferstoapotentialhazardorunsafepractice,whichcouldresult

inseriousinjuryordeath.



CAUTION:Thissymbolreferstoapotentialhazardorunsafepractice,whichcouldresult

inminorormoderateinjuryorproductorpropertydamage.



NOTICE:Thissymbolreferstoinformationthatneedsspecialattentionormustbefully

understoodeventhoughnotdangerous.



NOTICE:Thisproductisintendedforcommercialuseonly.Notforhouseholduse.



NOTICE:Localcodesregardinginstallationvarygreatlyfromoneareatoanother.TheNational

FireProtectionAssociation,Inc.,statesinitsNFPA96latesteditionthatlocalcodesare

“AuthorityHavingJurisdiction”whenitcomestorequirementforinstallationof

equipment.Therefore,installationshouldcomplywithalllocalcodes.



5



GENERALINSTALLATIONINSTRUCTIONS



Ensuregassupplyandgastype,asshownonunitnameplate,match.



UnitinstallationmustconformwiththeNationalFuelGasCode,ANSIZ223.1/NFPA54,theNational

GasInstallationCode,CSAͲB149.1,orthePropaneInstallationCode,CSAͲB149.2asapplicableand

inaccordancewithlocalcodes.



Screwlegsintothepermanentlyfastenednutsonthefourcornersoftheunitandtightenbyhand.

Leveltheunitbyturningtheadjustmentscrewatthebottomofeachleg.Donotslideunitwithlegs

mounted,liftifnecessarytomoveunit.



Pipethreadingcompoundmustberesistanttotheactionofliquefiedpetroleumgases.



Caution:DONOTuseanopenflametocheckforleaks.Checkallgaspipingforleakswithasoapand

watersolutionbeforeoperatingunit.



THESEUNITSARESUITABLEFORINSTALLATIONONNONͲCOMBUSTIBLESURFACESON LY.

Combustibleclearances:

6"sides(152mm)6"rear(152mm) 4"floor(102mm)

Noncombustibleclearances:

0"sides(0mm) 0"rear(0mm)4"floor(102mm)



Donotobstructtheflowofcombustionandventilationair,undertheunitbythelegsorbehindthe

unitbytheflue.



Adequateclearanceforairopeningsintothecombustionchamberisrequired.Donotplaceobjects

betweenthebottomoftheunitandthecountertop.



Theremustbeadequateclearanceforremovalofthefrontpanel.Allmajorpartsexcepttheburners

areremovablethroughthefrontifthegaslineisdisconnected.



SPECIFICATIONANDDIMENSIONS



MODELWIDTH

IN.(MM)

DEPTH

IN.(MM)

HEIGHT

IN.(MM)

#OF

BURNERS

BTU/PER

NAT/LP

TOTAL

BTU/ Hr

W.C.

IN.

CKͲHPSU21212(305)26.8(680)18.9(480)230,000 60,000 6/10

CKͲHPSU42424(610)26.8(680)18.9(480)430,000 120,000 6/10

CKͲHPSU63636(915)26.8(680)18.9(480)630,000 180,000 6/10



Note:regulator–75mm/3.25inchdepth.Dimensionsabovedonotincluderegulator.



6



CONVERSION



InstructionsareforconversionfromNaturalGastoPropane(L.P.)onallmodels.Theconversion

shouldbedonebeforeconnectingtheunittothegassupply.

Unitsareshippedfromthefactoryequippedforusewithnaturalgas.OrificesnecessaryforLP

(propane)areprovidedinabagtiedtothevalveonthefrontpanel.



Remove



the



knobs



and



front



panel.

.Uns







2.Remove the burner from the top

of the gas pipe.

1. Remove the trivets from the

top of the appliance.

Note:UnitNumberonside

oforificefittings.

PlasticInsert

3.Replacetheorifice

fittin

sintothevalve.

5.Beforeinstallingtheregulator,

unscrewtheoctagonalcapup,youcan

read(NAT)ontheplasticinsertoutof

thecap,flipitoverandsnapbackin

6.Continuewith

installation.

RegulatorwithbrasscapL.PPositionofinsert

4.Installthefront

anelknobs

7



LIGHTINGINSTRUCTIONS



Lightingpilot

Thepilotlightontheappliancehasbeensetatthefactory.Ascrewdrivermayberequiredforthe

firstlightingtoadjusttheflameforyourelevation.



1.Turnoffthemanualvalveandwait5minutestoclearthegas.

2.Turnallknobstothe"OFF"position.

3.Holdanignitionsource(match)atthepilot.Whentheflameisestablished,removetheignition

source.

4.Turntheburnerknobsto"ON".Iftheburnerdoesnotignite,promptlyopenthepilotvalve

more.Ifthepilotflameappearslargerthannecessary,turnitdownandresetburnerignition.The

pilotflameshouldbeassmallaspossiblebutlargeenoughtoguaranteereliableignitionofthe

burnerswhentheknobsareturnedto"ON".



Lightingmainburner

Tolightburner,turnknobto“ON.”Thenbackofftothedesiredflamelevel.Therangeofadjustment

isvirtuallyinfinitebetween“ON”and“OFF”.



Mainburnerairsupply:



1.Forefficientburneroperation,aproperbalanceofgasvolumeandprimaryairsupplymustbe

maintainedwhichwillresultincompletecombustion.Insufficientairsupplyresultsinayellow

streamingflame.Primaryairsupplyiscontrolledbyanairshutteronthefrontoftheburner.

2.Loosenthescrewsonthefrontoftheburnerandadjusttheairshuttertoeliminatetheyellow

tipsoftheburnerflame.Locktheairshutterinplacebytighteningthescrews.



CAUTION

Allburnersarelitfromconstantlyburningpilots.Turningthevalvetothedesiredflameheightisall

thatisrequiredtoputtheunitinservice.



Donotpermitfanstoblowdirectlyattheunit.Whereverpossible,avoidopenwindowsnexttothe

units'sidesorback.AvoidwalltypefanswhichcreateaircrossͲcurrentswithinaroom.



Itisalsonecessarythatsufficientairshouldbeallowedtoentertheroomtocompensateforthe

amountofairremovedbyanyventilatingsystem.Otherwise,asubnormalatmosphericpressurewill

occur,affectingoperationandcausingundesirableworkingconditions.



Aproperlydesignedandinstalledhoodwillactastheheartoftheventilatingsystemfortheroom

orareainwhichtheunitisinstalled,andwillleavetheunitindependentofchangingdraft

conditions.



Allvalvesmustbecheckedandlubricatedperiodically.Thismustbedonebyanauthorizedservice

representativeinyourarea.

8



CLEANING&MAINTENANCE



CAUTION:UseonlynonͲabrasivecleaners.Abrasivecleanerscouldscratchthefinishofyourunit,

marringit’sappearanceandmakingitsusceptibletodirtaccumulation.Donotusesteel

wool,otherabrasivecleanersorcleaners/sanitizerscontainingchlorine,iodine,

ammoniaorbrominechemicalsasthesewilldeterioratethestainlesssteelandglassmaterialand

shortenthelifeoftheunit.



Daily

1. Thoroughlycleanback,sides,topandfrontofunit.

2. Cleangratesdaily.



Weekly

1. Cleanunitthoroughly.Cleanstainlesssteelorchromedsurfaceswithadampclothandpolish

withasoft,drycloth.Adetergentmaybeusedforcleaning.Toremovediscolorations,usea

nonͲabrasivecleaner.

2. Tocleanthedrippan:removethedrippanbygrabbingthehandleandpullingitoutofthe

openinginthefrontpanel.Toreplacethepan,reversethisprocedure.

3. Burnerairshutteropeningsmustbekeptclean.Mainburnerportsmustbekeptclean.Toclean

burners,boiltheminastrongsolutionoflyewaterfor15to20minutes.Theneitherbrushwith

awirebrushorcleangasportswithasharpͲpointedmetalinstrumenttoensureopenports.



CAUTION:Cleantheregulatoratleastonceamonth.Makesuretheventopeningisopen

andnotblockedinanyway.Failuretodosowillcausevariationsinpressure.Yourunit

willnotfunctionaswellanditcouldshortenthelifeoftheproduct.

SERVICE/REPAIR



NOTE:THISAPPLIANCEMUSTONLYBESERVICEDBYANAUTHORIZEDAGE NT.



NOTE:Partsprotectedbythemanufacturerorhisagentarenottobeadjustedbytheinstaller

unlesstheinstallerisanauthorizedserviceagent.

IfyouhaveanyquestionsorproblemscontactyournearestServiceRepresentative.

9



EXPLOSIONVIEWDRAWING



MODEL:CKͲHPSU424



10

Spare Parts List

NO. DESCRIPTION MODEL CODE QTY

1 Dial

CK-HPSU212

CK-HPSU424

CK-HPSU636

06.05.1472429

2 Tray

CK-HPSU212

CK-HPSU424

CK-HPSU636

01.05.1029410

01.05.1029318

01.05.1029365

3 Foot

CK-HPSU212

CK-HPSU424

CK-HPSU636

01.02.1005373 4

4 Regulator

CK-HPSU212

CK-HPSU424

CK-HPSU636

01.22.1069501 1

5 Orifice

CK-HPSU212-NAT

CK-HPSU424-NAT

CK-HPSU636-NAT

01.20.1068643

CK-HPSU212-LPG

CK-HPSU424-LPG

CK-HPSU636-LPG

01.20.1068652

6 Burner

CK-HPSU212

CK-HPSU424

CK-HPSU636

06.05.1472521

7 Grate

CK-HPSU212

CK-HPSU424

CK-HPSU636

01.03.1015096

8 Pilot pipe assy.-Rear

CK-HPSU212

CK-HPSU424

CK-HPSU636

01.24.1071026

9 Orifice connection-Front

CK-HPSU212

CK-HPSU424

CK-HPSU636

01.18.1067402

10 Orifice connection-Rear

CK-HPSU212

CK-HPSU424

CK-HPSU636

01.18.1067404

11

11 Pilot pipe assy.-Front

CK-HPSU212

CK-HPSU424

CK-HPSU636

01.24.1071015

12 Main pipe assy.-Front

CK-HPSU212

CK-HPSU424

CK-HPSU636

06.05.1473192

13 Main pipe assy.-Rear

CK-HPSU212

CK-HPSU424

CK-HPSU636

06.05.1473193

14 Valve connection

CK-HPSU212

CK-HPSU424

CK-HPSU636

66.04.1820085

15 Valve

CK-HPSU212

CK-HPSU424

CK-HPSU636

01.20.1068502

16 Pilot valve

CK-HPSU212

CK-HPSU424

CK-HPSU636

01.20.1068508

CookingPerformanceGroup

Lancaster,Pennsylvania

website:www.cookingperformancegroup.com

CPG CK-HPSU212 Boasting 6 Powerful 30000 BTU Burners User manual

Related papers

Other documents