2. Alpha
  3. Ground Mount Security Bar

Alpha Ground Mount Security Bar Quick start guide

  • Hello! I am an AI chatbot trained to assist you with the Alpha Ground Mount Security Bar Quick start guide. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
Tools and Materials Required
• HandDrill
• CenterPunch
• 4-footLevel
• 7/16"SocketDriverwithExtension
• 1/8"DrillBit
• #K(9/32"or.281")DrillBit
• TapeMeasure
• MaskingTape
• Pencil
• UtilityKnife
• Vacuum(Toremovedrillswarffromcabinetinterior)
• Lock(seeFig.1fordimensions)
SecurityBarFieldInstallationInstructionsFiel
ForFPE,UPE-3,UPE-6,UPE-M3,UPE-M6,PNSeriesandCESeriesEnclosures
Eachsecuritybarkitcontainsthepartsandaccessoriesneededtosecureoneenclosuredoor.Enclosureswithbothafrontandback
door,requiretwokits(expectwherenotedbelow).DetailedplacementspecicationsforeachsupportedenclosureareintheSecurity
BarFieldInstallationManual(SearchforP/N745-847-C1-001)availableatwww.alpha.com.
Installing the Security Bar
Theinstallationoutlinedinthisdocumentappliestoeachof
thesupportedenclosures.SeePage2forinstallationdetail
gures.LockdimensionsmustconformtoFigure1.
Ifnecessary,placementspecicationsforeachsupported
enclosureareintheSecurityBarFieldInstallationManual
(AlphaP/N745-847-C1-001)availableatwww.alpha.com.
B
A
C
A=5/16"
B=3/4"
C=21/2"
Figure1,LockDimensions
1. Usinga4-ftlevelandapencil,marktheenclosurewherethe
topofthesidebracketswillbeplaced,seeFigure2.
2. Positionthesidebracketandcenterpunchtheholes
3. Removethedoor.Protectanyelectronicequipmentfrom
drillshavingsbeforedrilling,andensurethedrillbitwillnot
contactanyequipmentasitpassesintotheenclosure.
Page1of2
Onlyqualiedpersonnelshouldcompletethisinstallation.Irreparabledamagemayoccurtothe
enclosureorequipmentifnotinstalledcorrectly.
CAUTION!
4. Pilotdrillthesidebracketholesusingthe1/8"drillbit.
5. Drillthetwotopholesusinga#Kdrillbit.SeeFigure3.
6. Usingthesidebracketsastemplates,markanddrillthetwo
bottomholes.
7. Installthesidebrackets,seeFigure4,andreplacethedoor.
8. Installthesecuritybarinthesidebrackets.Positionanduse
thelockbracketasatemplateformarkingitsholes.
9. Drillthelockbracketholes.
NOTE:
Wherenecessary,usetheutilityknifetocutand
removeinsulationfromthehardwarearea.
10. Installthelockbracket.SeeFigure5.
11. InstalltheotherSecurityBarSideandLockBracketsby
repeatingSteps1–8.
12. Removeanymetalshavings.
13. SecuretheenclosurewiththeSecurityBar,LockandLock
Guard.SeeFigure6.
Enclosure Color AlphaPartNumber
#ofRequired
Kits
KitComponentsDescription(Qty)
UPE
SeafoamGreen 745-847-20
1
• LockBracket(2)
• SideBracket(4)
• SecurityBar(2)
• LockGuard(2)
• CarriageBolt1/4"-20X3/4"(12)
• LockWasher1/4"(12)
• FlatWasher1/4"(12)
• HexNut1/4"-20(12)
Gray 745-847-21
PN
SeafoamGreen 745-847-20
2
Gray 745-847-21
CE
SeafoamGreen 745-847-20
2
Gray 745-847-21
FPE
SeafoamGreen 745-847-22
1
• LockBracket(4)
• SideBracket(8)
• SecurityBar(4)
• LockGuard(4)
• CarriageBolt1/4"-20X3/4"(24)
• LockWasher1/4"(24)
• FlatWasher1/4"(24)
• HexNut1/4"-20(24)
Gray 745-847-23
PineGreen 745-847-24
White 745-847-25
NOTE:
Onenclosuredoorswithlouvers,positiontheLock
Brackettoeithersideofthelouvers.SeePage2.
AlphaTechnologiesreservestherighttomakechangestotheproductsandinformationcontainedinthisdocumentwithoutnotice.
Copyright©2006AlphaTechnologies.AllRightsReserved.Alpha
®
isaregisteredtrademarkofAlphaTechnologies.memberofTheAlphaGroup™isatrademarkofAlphaTechnologies.
745-847-C2-001,Rev.B(08/2013)
Formoreinformationvisitwww.alpha.com
UnitedStates Bellingham,WashingtonTel:3606472360Fax:3606714936
Canada Burnaby,BritishColumbiaTel:6044301476Fax:6044308908
member of
The Group
T
M
Page2of2
Detailed specications for each supported enclosure are in the security bar eld installation manual (search for Alpha part
number 745-847-C1-001) available at www.Alpha.com. The FPE enclosure is shown below as an example.
Figure4,SideBracketInstallation
(Left bracket installation is mirrored)
(FPE Enclosure shown as an example))
CARRIAGE BOLT
1/4"-20 X 3/4"
FLAT WASHER 1/4" (2 PLACES)
LOCK WASHER 1/4" (2 PLACES)
NUT 1/4"-20 (2 PLACES)
ENCLOSURE DOOR
LOCK BRACKET
Figure5,LockBracketAlignmentandInstallation
LOCK BAR
LOCK
LOCK GUARD
Figure6,LockGuardInstallation
Figure3,DrillLocations
Figure2,MarkingBracketLocations
Thesecuritybarandlockbracketlockholesmustlineupbeforesecuringthelock
brackettotheenclosuredoor,seeFigure5.
NOTE:
Step1
Step2
Step3
Step4
/