Warnings
2 Door Robe Assembly Instructions
www.tesco.com
Produced in England for TESCO Stores Ltd.
Tesco 2011.
C
Before you start
Important: Retain these instructions for future reference.
Unwrap all packaging materials and place the components
on top of the carton box or on a clean oor to prevent it
from scratching.
This product should only be used on rm level ground.
Keep small parts out of reach of children.
Do’s
Dont’s
Follow each assembly step in order to prevent incorrect
assembly.
Assemble on a clean soft surface to avoid damage.
Check the pack and make sure you have all the parts listed.
Ensure that this product is fully assembled as illustrated
before use.
Make sure all screws are fully tightened before use.
When you are ready to start, make sure that you have the
right tools, plenty of space and a clean, dry area for
assembly.
Tesco do not recommend the use of power tools to
construct this product.
Do not sit or stand on the product.
Do not overtighten screws or bolts.
Do not use this product if parts are missing, damaged or
worn.
Number of people required to assemble
One person to assemble the unit and two people to lift the
unit into position.
Time to assemble
Tradesman’s tips
“Hi, look out for me throughout this manual. Wherever
you see my picture I will have a handy tip to help you
with the assembly of your product”.
My rst tip is: “Before you start get a cup of tea, sit down
and read through these instructions carefully”.
And for good measure my second tip is that you will need
the following tools to assemble this product, so gather
them to hand before you start.
Tools required
not supplied
Pozi (large)
not supplied not supplied
not supplied
Pozi (Small)
supplied
2
45 minutes.
2 Door Robe Assembly Instructions
www.tesco.com
Produced in England for TESCO Stores Ltd.
Tesco 2011.
C3
Our promise
Further Assistance
We are happy to refund or replace any Tesco product which
falls below the high standard you expect. Just ask any
member of sta. This will not eect your statutory rights.
Home service technicians
If you have a fault with your product please contact our
customer service team on 08450 264 549. If you have had
the product for 28 days or less you may be oered a
replacement, refund or for a fully trained home service
technician to visit your home to assess the fault and repair
the product where possible.
If you have had the product for more than 28 days we send
an independent home service technician to review and
repair the product where possible and recommend further
action.
Missing parts
If you are missing any xtures and ttings for your product
please contact our customer service team on 0845 0613967
and they will be happy to arrange for a replacement to be
sent to you free of charge.
Tesco Self Assembly Furniture telephone
Service
Tesco has enlisted the help of FIRA Service Technicians,the
UK’ s experts on furniture, to provide a helpline for those
hitting snags when putting their at pack item together.
The Knowledgeable and patient sta at FIRA can help you
and are available to take your call 08.00hrs to 20.00hrs
Monday to Friday on: 0845 520 5516*
*Calls are charged at local rates.
The Furniture Ombudsman
As part of our commitment to maintaining high standards and
responsible furniture retailing, Tescos is a Full Member of The
Furniture Ombudsman. This means that if you’re not entirely
satised with your purchase - and we haven’t managed to
resolve the problem - you can contact them to look into it
for you. By signing up to The Furniture Ombudsman Code of
Practice we promise to follow their decisions - ensuring that
you get a fair deal. This means that you can buy in complete
condence when selecting your furniture from Tesco.
You should rst discuss your complaint with our customer
service team on 08450 264 549 so that we can try to solve any
issues. After that, if you’re still not happy you can contact The
Furniture Ombudsman at www.thefurnitureombudsman.org
You can write to us at
Tesco Stores Ltd,
New Tesco House,
Delamare Road,
Cheshunt,
Herts, EN8 9SL, UK
FREEPHONE 0800 50 55 55
To view our full furniture range please visit direct.tesco.com
“Inspiring Consumer Condence”
Assembly service
If you decide that you do not wish to assemble this
product yourself, please contact our trained assembly team
on 08450 264 549 and one of our skilled sta will be happy
to talk you through the assembly.
A
A
A
A
2 Door Wardrobe assembly instructions
www.tesco.com
Produced in England for TESCO Stores Ltd.
Tesco 2011.
C7
3
4
8
Pozi (large)
A
A
A
A
1
1
3
4
A x8 3.5 x 45
Before securing the back it is necessary to square up
the unit. You can do this by measuring between
XX-XX and YY-YY ensuring these are the same
(DIAG 1). If they not (DIAG 2). Apply slight pressure
as indicated (DIAG 3) until they are the same.
DIAG 1 DIAG 2 DIAG 3
XX
XX
YY
YY
XX
XX
YY
YY
XX
XX
YY
YY
YY
XX
YY
XX
2
not supplied
Plain chipboard surface
facing outwards.
Plain chipboard surface
facing outwards.
2 Door Wardrobe assembly instructions
www.tesco.com
Produced in England for TESCO Stores Ltd.
Tesco 2011.
C8
5
14
6
Align backpanel so that there is an equal gap from
the edge of top, bottom and end panels.
Use the nail guide when locating the nails. this will
hold the nails vertical and ensure the correct distance
from the edge.
H x60
TWO PEOPLE WILL BE REQUIRED
TO LIFT UNIT UPRIGHT.
Once you have fixed the hanging rail in
place, unscrew the top screw in the hanging
bracket by 2 turns so that the screw slightly
protrudes to prevent the rail coming out.
N x1 M x8
3
2
1
6
3
4
Cover Caps
M
M
Cover Caps
M
M
not supplied supplied
2 Door Wardrobe assembly instructions
www.tesco.com
Produced in England for TESCO Stores Ltd.
Tesco 2011.
C9
7
not supplied
Pozi (large)
B
B
B
Underside view
Ensure the underside of screw
B slides into slot on hingeplate.
Hinge correctly attached to
hingeplate.
Hinge incorrectly attached to
hingeplate.
Diagram 1
Diagram 2
Diagram 3
a:
b:
Repeat on the remaining door.
3
4
5
2 Door Wardrobe assembly instructions
www.tesco.com
Produced in England for TESCO Stores Ltd.
Tesco 2011.
C10
8You will need to support the
weight of the door during
this process. If the door is
close to the ground this can
be achieved by using blocks
or similar. Otherwise a second
person may be required to
assist.
Loosen, but do not remove the
top and bottom screws on all
hinge mounting plates.
Try to work on the hinges
one at a time. This will
prevent the weight of the
door pulling it out of
position.
This method can also be used to
straighten-up tilting or twisting
doors.
Try to work on the hinges one
at a time. Gradually adjusting
and checking to see what
changes each adjustment makes.
If you are nding the screw
dicult to turn it may help to
loosen the rear screw,
retightening after adjustments
are complete.
5
5
2 Door Wardrobe assembly instructions
www.tesco.com
Produced in England for TESCO Stores Ltd.
Tesco 2011.
C11
9
19
19
We recommend that this unit is xed to a suitable wall to prevent possible
overbalancing. We have included a xing bracket for this. No xing screws
are provided as they will need to suit the wall type, and the length of
screw will depend on the distance from the back of the unit to the
wall. Please ensure xings used are appropriate to your wall type. Locate the
bracket to the top panel or to the end panel as close to top as possible. We do
not specify exact location for the bracket,this is left to the customer’s discretion.
Please take care when drilling into the wall, avoiding any pipes and wires.
The use of residual current device (RCD) is recommended when
working with tools.If in doubt consult a qualied person.
Warning:
2 people to lift.
Lift with care.
Warning:
Pozi (large) 3.5 x 13
E x2 H x1
REV. C
not supplied
/
