Eurotech ReliaGATE 10-20 Owner's manual

ReliaGATE 10-20
Eurotech
Brand
Eurotech
Model
ReliaGATE 10-20
Type
Owner's manual
ReliaGATE 10
-20
Multi
-Service Gateway and Edge Controller
USER MANUAL
Rev
1.0 – May 2015 – 110129-0001B
ReliaGATE 10
-20
Multi
-Service Gateway and Edge Controller
USER MANUAL
Rev
B – March 2019 – 110129-0001B
© 2017 Eurotech
Trademarks
All trademarks or registered trademarks, logos, designs and products appearing in this document are property of
their respective owners
Revision History
Revision
Description
1
Initial Release
2
Update
A
Updated product images
Added warnings in French
Updated SW features list
Minor grammar and formatting updates
September 2015
B
Updated GPIO input range specification
Added reverse polarity warning note
Updated CE Directive
Updated links to Eurotech website
Updated debug section
Updated references to 3G (changed to cellular)
March 2019
ReliaGATE 10-20 User Manual Table of Contents
3
110129
-0001B
Table of Contents
Trademarks .................................................................................................................................................................. 2
Revision History ........................................................................................................................................................... 2
Table of Contents .......................................................................................................................................................... 3
Safety and Regulatory .................................................................................................................................................. 7
Alerts that can be found throughout this manual ......................................................................................................... 8
Alertes peuvant être trouvées dans ce manuel ........................................................................................................... 8
Safety Notices and Warnings ...................................................................................................................................... 9
Avis de sécurité et avertissements .............................................................................................................................. 9
Do not operate in an explosive atmosphere .......................................................................................................... 9
Ne pas utiliser dans une atmosphère explosive .................................................................................................... 9
Antistatic precautions ............................................................................................................................................. 9
Précautions antistatiques ....................................................................................................................................... 9
Connection to power supply or other devices ...................................................................................................... 10
Raccordement à l'alimentation ou d'autres appareils .......................................................................................... 10
Installation ............................................................................................................................................................ 11
Ventilation............................................................................................................................................................. 11
Maintenance ......................................................................................................................................................... 11
Cleaning ............................................................................................................................................................... 12
Nettoyage ............................................................................................................................................................. 12
Life Support Policy ..................................................................................................................................................... 12
Politique Life Support ................................................................................................................................................ 12
Warranty .................................................................................................................................................................... 12
CE Notice ................................................................................................................................................................... 12
Directive RED 2014/53/EU ........................................................................................................................................ 13
WEEE ........................................................................................................................................................................ 13
RoHS ......................................................................................................................................................................... 13
EMC Requirements for Industry Canada .................................................................................................................. 13
FCC Part 15 Class B Statement ................................................................................................................................ 14
Technical Assistance ................................................................................................................................................. 14
Transportation ...................................................................................................................................................... 14
Conventions ............................................................................................................................................................... 15
Product Overview ........................................................................................................................................................ 17
Block Diagram ........................................................................................................................................................... 18
Features ..................................................................................................................................................................... 19
Product Options ......................................................................................................................................................... 19
Related Documents ................................................................................................................................................... 20
Product Specifications ............................................................................................................................................... 21
Front Panel Interfaces ............................................................................................................................................... 22
Power Supply ....................................................................................................................................................... 22
Ethernet ................................................................................................................................................................ 23
USB ...................................................................................................................................................................... 23
Serial 1 ................................................................................................................................................................. 24
Serial 2 ................................................................................................................................................................. 24
Rear Panel Interfaces ................................................................................................................................................ 25
Wi-Fi (IEEE 802.11) and Bluetooth ...................................................................................................................... 25
GPS (Optional) ..................................................................................................................................................... 25
Discrete I/O .......................................................................................................................................................... 26
ReliaCELL 10-20 Docking Bay: USB/Cellular, SD, SIM, Debug ......................................................................... 27
Table of Contents ReliaGATE 10-20 User Manual
4
110129-
0001B
Other Features ........................................................................................................................................................... 28
Accelerometer ...................................................................................................................................................... 28
Real Time Clock (RTC) ........................................................................................................................................ 29
User Interface ............................................................................................................................................................ 30
LED Indicators ...................................................................................................................................................... 30
Environmental ............................................................................................................................................................ 31
Mechanical Specifications ......................................................................................................................................... 33
Mounting the ReliaGATE 10-20 ................................................................................................................................. 34
Mounting a ReliaCELL 10-20 Modem ....................................................................................................................... 34
Administrative Console .............................................................................................................................................. 35
Logging In .................................................................................................................................................................. 35
Booting up and using the Serial Console .................................................................................................................. 35
Remote Login ............................................................................................................................................................ 35
Security Settings ........................................................................................................................................................ 36
Linux Peripheral Access ............................................................................................................................................ 37
Ethernet ..................................................................................................................................................................... 37
Wi-Fi .......................................................................................................................................................................... 37
Serial Ports ................................................................................................................................................................ 37
Accelerometer ............................................................................................................................................................ 37
Flash Memory ............................................................................................................................................................ 38
Analog Inputs ............................................................................................................................................................. 38
GPIO .......................................................................................................................................................................... 38
CAN Bus .................................................................................................................................................................... 39
ReliaCELL 10-20 ....................................................................................................................................................... 39
GPS ........................................................................................................................................................................... 40
Watchdog ................................................................................................................................................................... 40
Suspend/Resume ...................................................................................................................................................... 41
Linux Application Development ................................................................................................................................ 43
Developing Applications ............................................................................................................................................ 43
Installing the Toolchain .............................................................................................................................................. 43
Internet of Things (IoT) Application Development................................................................................................... 45
Everyware Software Framework (ESF) ..................................................................................................................... 45
Everyware Cloud (EC) ............................................................................................................................................... 46
Appendix A – BSP 10.x.x ............................................................................................................................................ 47
Administrative ............................................................................................................................................................ 47
Logging In............................................................................................................................................................. 47
Booting up and using the Serial Console ............................................................................................................. 47
Remote Login ....................................................................................................................................................... 47
Security Settings .................................................................................................................................................. 48
Peripheral Access ...................................................................................................................................................... 49
Ethernet ................................................................................................................................................................ 49
Wi-Fi ..................................................................................................................................................................... 49
Serial Ports ........................................................................................................................................................... 49
Accelerometer ...................................................................................................................................................... 49
Flash Memory ...................................................................................................................................................... 50
Analog Inputs ....................................................................................................................................................... 50
GPIO .................................................................................................................................................................... 50
CAN Bus............................................................................................................................................................... 51
ReliaCELL 10-20 .................................................................................................................................................. 51
ReliaGATE 10-20 User Manual Table of Contents
5
110129
-0001B
GPS ...................................................................................................................................................................... 52
Watchdog ............................................................................................................................................................. 52
Suspend/Resume ................................................................................................................................................. 53
ReliaGATE 10-20 User Manual Safety and Regulatory
7
110129
-0001B
Safety and Regulatory
Carefully read and understand the instructions in this manual before using this device.
Whenever you have any doubt regarding the operation of this device, consult this manual or contact your local
Eurotech Technical Support Team (see the last page of this manual for details).
Keep this manual for future reference.
To lower the risk of personal injury, electric shock, fire or damage to equipment, observe the following
precautions, as well as using good technical judgment, whenever installing or using the device.
Eurotech has made every effort to ensure the accuracy of this document; however, Eurotech assumes no liability
resulting from any error/omission in this document, or from the use of the information contained herein.
Eurotech reserves the right to revise this document or to make changes to its content at any time without any
obligation to notify any person of such revision or changes.
Sécurité et réglementation
Lire attentivement la notice et comprendre les instructions avant d'utiliser cet appareil.
Chaque fois que vous avez le moindre doute concernant le fonctionnement de cet appareil, consultez ce manuel
ou contactez notre équipe locale de support technique Eurotech (voir la dernière page de ce manuel pour plus de
détails).
Conservez ce manuel.
Pour réduire le risque de blessures corporelles, de choc électrique, d’incendie ou de dégâts matériels,
respectez les précautions de ce manuel, ainsi que les précautions habituelles d’utilisation de tout matériel
électrique, à chaque installation ou utilisation de l'appareil.
Eurotech a fait tous les efforts nécessaires afin d’assurer l'exactitude de ce document. Toutefois, Eurotech décline
toute responsabilité résultant d'une erreur ou omission dans ce document, ou de l'utilisation de l'information
contenue dans ce document.
Eurotech réserve le droit de réviser ce document ou d'apporter des modifications à son contenu à tout moment et
sans aucune obligation de notifier toute personne de telles révisions ou modifications.
Safety and Regulatory ReliaGATE 10-20 User Manual
8
110129-
0001B
Alerts that can be found throughout this manual
Alertes peuvant être trouvées dans ce manuel
Symbol
Meaning
DANGER!
Information highlighting potential electrical shock hazards:
• Personal injury or death could occur.
• Damage to the system, connected peripheral devices, or software could occur.
Always use appropriate safety precautions. Also ensure that the installation meets all the requirements as
set out for the environment that the equipment will be deployed in.
DANGER!
Informations soulignant un risque de choc électrique:
• De graves blessures ou la mort peuvent être provoquées.
• Des dommages au système, aux périphériques connectés, ou au logiciel pourraient se produire.
Toujours suivre les précautions de sécurité appropriées. Assurez-vous également que l'installation réponde
à toutes les exigences nécessaires à l'environnement d’utilisation du matériel
WARNING!
Information highlighting potential hazards:
• Personal injury or death could occur.
• Damage to the system, connected peripheral devices, or software could occur.
Always use appropriate safety precautions. Also ensure that the installation meets all the requirements as
set out for the environment that the equipment will be deployed in.
DANGERS!
Informations soulignant les dangers potentiels:
• De graves blessures ou la mort peuvent être provoquées.
• Des dommages au système, aux périphériques connectés, ou au logiciel pourraient se produire.
Toujours suivre les précautions de sécurité appropriées. Assurez-vous également que l'installation réponde
à toutes les exigences nécessaires à l'environnement d’utilisation du matériel
NOTE
These will highlight important features or instructions.
Note: Caractéristiques ou instructions importantes.
ReliaGATE 10-20 User Manual Safety and Regulatory
9
110129
-0001B
Safety Notices and Warnings
Observe the following safety precautions during all phases of operation, service, and repair of the device.
Failure to comply with these precautions or with specific warnings elsewhere in this manual violates safety
standards of design, manufacture, and intended use of the device.
Eurotech assumes no liability for the customer’s failure to comply with these requirements.
The safety precautions listed below represent warnings of certain dangers of which Eurotech is aware. You, as the
user of the device, should follow these warnings and all other safety precautions necessary for the safe operation
of the device in your operating environment.
Avis de sécurité et avertissements
Respectez les consignes de sécurité suivantes lors de toutes les phases de fonctionnement, de service et de
réparation de l'appareil.
Le non-respect de ces consignes ou des avertissements spécifiques contenus dans ce manuel viole les normes
de conception, de fabrication, de sécurité, et d'utilisation de l'appareil.
Eurotech décline toute responsabilité lors du non-respect de ces exigences par les clients.
Les précautions de sécurité indiquées ci-dessous représentent les avertissements de certains dangers connus
d’Eurotech. En tant qu'utilisateur de l'appareil, vous devez suivre ces avertissements et toutes les autres mesures
de sécurité nécessaires pour un fonctionnement sûr de l'appareil.
Do not operate in an explosive atmosphere
Ne pas utiliser dans une atmosphère explosive
WARNING!
Do not operate the equipment in the presence of flammable gases or fumes. Operation of any
electrical equipment in such an environment constitutes a definite safety hazard.
ATTENTION!
Ne pas faire fonctionner l'équipement en présence de gaz ou de vapeurs inflammables. L'utilisation
de tout équipement électrique dans un tel environnement constitue un réel danger.
Antistatic precautions
Précautions antistatiques
WARNING!
To avoid ESD (Electro Static Discharge) damage, always use appropriate antistatic precautions
when handing any electronic equipment.
ATTENTION!
Pour éviter les dommages dus aux décharges ESD (Electro Static Discharge), utilisez toujours les
protections antistatiques appropriées lors de la manipulation de tout équipement électronique.
Safety and Regulatory ReliaGATE 10-20 User Manual
10
110129-
0001B
Connection to power supply or other devices
Raccordement à l'alimentation ou d'autres appareils
DANGER!
Before applying power to the system, thoroughly review all installation, operation, and safety
instructions.
Failure to install the system power supply correctly or to follow all operating instructions correctly
may create an electrical shock hazard, which can result in personal injury or loss of life, and/or
damage to equipment or other property
DANGER!
Avant de mettre le système sous tension, examiner attentivement toutes les instructions
d'installation, d'exploitation et de sécurité.
Ne pas installer l'alimentation électrique correctement ou ne pas de suivre toutes les instructions
correctement peut créer un risque de choc électrique, pouvant entrainer des blessures graves, la
mort et / ou endommager l'équipement ou d'autres biens
• To avoid injuries, always disconnect power and discharge circuits before touching them.
• Pour éviter les blessures, toujours débrancher les circuits d'alimentation et de décharge avant de les toucher.
• Only start the device with a power supply that meets the requirements stated on the voltage label. In case of
uncertainties about the required power supply, please contact the Eurotech Technical Support Team or the
electricity authority
• Ne démarrer l'appareil qu’avec une alimentation répondant aux exigences indiquées sur l'étiquette de tension. En cas
d'incertitudes sur l'alimentation requise, contactez l'équipe de support technique Eurotech.
• Before connecting other equipment carefully read any supplied instructions
• Avant de connecter d'autres équipements, lire attentivement les instructions fournies
• Always disconnect the power before connecting or disconnecting cables
• Toujours débrancher l'alimentation avant de connecter ou déconnecter les câbles
• Do not perform connections with wet hands
• Ne pas effectuer les connexions avec les mains mouillées
• Check any power cords for damage before use
• Vérifiez l’état des cordons d'alimentation avant utilisation
• Use certified power cables. The power cable must meet the requirements (voltage and current) of the device.
• Utilisez des câbles d'alimentation certifiés. Le câble d'alimentation doit répondre aux exigences (tension et courant) de
l'appareil.
• Position cables with care. Avoid positioning cables in places where they may be trampled on or compressed
by objects placed on them. Take particular care of the plug, power-point and outlet of power cable
• Positionnez les câbles avec soin. Evitez de placer les câbles dans des endroits où ils peuvent être piétinés ou compressées
par des objets placés sur eux. Prenez un soin particulier de la prise, et de la sortie du câble d'alimentation
• Avoid overcharging any power outlets
• Evitez de surcharger les prises de courant
• Only apply power to the device or connected equipment after checking that all the above conditions have
been met
• N’alimenter l'appareil ou l’équipement connecté qu’après avoir vérifié que toutes les conditions ci-dessus ont été
respectées
ReliaGATE 10-20 User Manual Safety and Regulatory
11
110129
-0001B
Installation
WARNING!
•
Verify that the mounting location can withstand the added loads caused by the addition of the
device, it should be firmly secured so that it will not cause any potentially hazardous
situations (e.g. falling down due to vibration or shock)
• Do not operate the device near heat sources or flames.
ATTENTION!
• • Vérifiez que l'emplacement de montage peut supporter les charges supplémentaires
causées par l'ajout de l'appareil, il doit être solidement fixé afin de ne pas provoquer de
situations potentiellement dangereuses (par exemple, tomber à cause des vibrations ou des
chocs)
• • Ne pas utiliser l'appareil près de sources de chaleur ou de flammes.
NOTE:
If the device must be moved from one place to another with different ambient temperatures, ensure sufficient
time for the temperature of the device to stabilize before repowering.
NOTE:
Si l'appareil doit être déplacé d'un endroit à un autre soumis à différentes températures ambiantes, prévoir
suffisamment de temps pour que la température de l'appareil se stabilise avant de remettre le courant.
Ventilation
WARNING!
Ensure adequate ventilation to avoid overheating, Eurotech suggests the following steps:
• When installing the device within a cabinet, rack or other enclosed space, be sure to leave
sufficient space to allow adequate air circulation
ATTENTION!
Assurer une ventilation adéquate pour éviter la surchauffe, Eurotech suggère les étapes suivantes:
• Lorsque vous installez l'appareil dans une armoire, rack ou un autre espace clos, assurez-
vous de laisser un espace suffisant pour permettre une circulation d'air suffisante
Maintenance
DANGER!
• Never open, dismantle or repair the device!
• For your maintenance or repair requirement please contact a qualified Eurotech engineer.
If the device does not function correctly and you are unable to find a solution, feel free to contact
the Eurotech Technical Support Team.
DANGER!
• Ne jamais ouvrir, démonter ou tenter de réparer l'appareil!
• Pour votre entretien ou pour la réparation contactez un technicien qualifié Eurotech.
Si l’appareil ne fonctionne pas correctement et que vous êtes incapable de trouver une solution,
vous pouvez contacter l'équipe de support technique Eurotech.
Safety and Regulatory ReliaGATE 10-20 User Manual
12
110129-
0001B
If the equipment does not work properly, especially if smells unusual, unplug it immediately and contact the
Eurotech Technical Support Team (see last page of this manual for further details).
Si l'équipement ne fonctionne pas correctement, surtout en cas d’odeurs inhabituelles, débranchez-le
immédiatement et contactez l'équipe d'assistance technique Eurotech (voir la dernière page de ce manuel pour
plus de détails).
Cleaning
Nettoyage
WARNING!
When cleaning the device, remember to:
• Ensure sufficient ESD protection during the cleaning process.
• Remove any power from the device.
• When cleaning an enclosed system or peripheral use a dry cloth on the external casing.
• Do not use detergents, aerosol sprays, solvents or abrasive sponges.
ATTENTION!
Lors du nettoyage de l'appareil, pensez à:
• Assurer une protection ESD suffisante pendant le processus de nettoyage.
• Débrancher l'appareil.
• Lors du nettoyage d'un système ou d’un périphérique clos, utiliser un chiffon sec sur le
boîtier externe.
• Ne pas utiliser de détergents, d'aérosols, de solvants ou d'éponges abrasives.
Life Support Policy
Politique Life Support
WARNING!
Users must not use Eurotech products as critical components of life support devices or systems
without the express written approval of Eurotech Spa.
ATTENTION!
Les utilisateurs ne doivent pas utiliser les produits Eurotech dans des dispositifs critiques ou des
systèmes d’assistance de la vie sans l'autorisation expresse écrite de Eurotech Spa.
Warranty
Please contact your local Eurotech Sales Office for detailed warranty terms and conditions.
Refer to the back covers of this manual for full contact details.
CE Notice
This product is CE marked.
The CE mark on the product indicates that it conforms with the essential requirements of the
applicable EC directives.
Eurotech is not responsible for the use of its products together with equipment (e.g. power supplies,
personal computers, etc...) that are not CE marked and compliant with technical requirements
specified in this manual.
ReliaGATE 10-20 User Manual Safety and Regulatory
13
110129
-0001B
Directive RED 2014/53/EU
This product meets the requirements of the Directive 2014/53/EU of the European Parliament and of the Concil of
16 April 2014 on the harmonization of the laws of the Member States relating to the marking available on the market
of radio equipment.
WEEE
The information below complies with the regulations set out in the 2002/96/EC directive, subsequently superseded
by 2003/108/EC. It refers electrical and electronic equipment and the waste management of such products.
When disposing of a device, including all of its components, subassemblies and materials that are an integral part
of the product, you should consider the WEEE directive.
The use of the following symbol, attached to the equipment, packaging, instruction literature, or the
guarantee sheet, states that the device has been marketed after August 13th 2005, and implies that
you must separate all of its components when possible, and dispose of them in accordance with waste
disposal legislations:
• Because of the substances present in the equipment, improper use or disposal of the refuse can cause
damage to human health and the environment.
• With reference to WEEE, it is compulsory not to dispose of the equipment with normal urban refuse; an
arrangement for separate collection and disposal is essential.
• To avoid any possible legal implications, contact your local waste collection body for full recycling information.
RoHS
This device, including all the components, subassemblies and the consumable materials that are an integral part
of the product, have been manufactured in compliance with the European directive 2002/95/EC known as the RoHS
directive (Restrictions of the use of certain Hazardous Substances). This directive targets the reduction of certain
hazardous substances previously used in electrical and electronic equipment (EEE).
EMC Requirements for Industry Canada
This Class B digital apparatus meets all requirements of the Canadian Interference‐
Causing Equipment Regulations. This device complies with Industry Canada RSS
Appliance radio exempt from licensing. The operation is permitted for the following
two conditions:
1. The device may not cause harmful interference, and
2. The user of the device must accept any interference suffered, even if the
interference is likely to jeopardize the operation.
Safety and Regulatory ReliaGATE 10-20 User Manual
14
110129-
0001B
Disclaimer:
This equipment generates and can radiate radio frequency energy and may cause harmful interference to
radio communications. If this equipment does cause harmful interference to radio or television reception,
which can be determined by turning the equipment off and on, the user is encouraged to try to correct the
interference by such measures as reorienting the receiving antenna, increasing separation between
equipment and receiver, or connecting the equipment into an outlet on a different electrical circuit.
Additional restrictions and requirements may be listed in the System Specifications.
Disclaimer:
Cet équipement génère et peut émettre des ondes radiofréquence et peut causer des interférences
nuisibles aux communications radio. Si cet équipement provoque des interférences nuisibles à la réception
de radio ou de télévision, ce qui peut être déterminé en allumant et éteignant l'équipement, l'utilisateur est
encouragé à essayer de corriger l'interférence par des mesures telles que la réorientation de l'antenne de
réception, en augmentant la distance de séparation entre l'équipement et le récepteur, ou de raccorder
l'appareil à une prise sur un circuit électrique différent.
Des restrictions et des exigences supplémentaires peuvent être mentionnées dans les spécifications du
système.
FCC Part 15 Class B Statement
This equipment has been tested and found to comply with the limits for a Class B digital device,
pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection
against harmful interference in a residential installation. This equipment generates, uses, and
can radiate radio frequency energy and, if not installed and used in accordance with the
instructions, may cause harmful interference to radio communications.
Warning: Changes or modifications to this unit not expressly approved by the party responsible for compliance
could void the user’s authority to operate the equipment.
Technical Assistance
For any technical questions, or if you cannot isolate a problem with your device, or for any enquiry about repair and
returns policies, feel free to contact your local Eurotech Technical Support Team.
See the back cover for full contact details.
Transportation
When transporting any module or system, for any reason, it should be packed using anti-static material and placed
in a sturdy box with enough packing material to adequately cushion it.
Warning:
Any product returned to Eurotech that is damaged due to inappropriate packaging will not be
covered by the warranty!
ATTENTION!
Tout produit retourné à Eurotech et endommagé en raison de l'emballage inapproprié ne sera pas
couvert par la garantie!
ReliaGATE 10-20 User Manual Safety and Regulatory
15
110129
-0001B
Conventions
The following table describes the conventions for signal names used in this document.
Convention
Explanation
GND
Digital ground plane
#
Active low signal
_P
Positive signal in differential pair
_N
Negative signal in differential pair
The following table describes the abbreviations for direction and electrical characteristics of a signal used in this
document.
Type
Explanation
I
Signal is an input to the system
O
Signal is an output from the system
IO
Signal may be input or output
P
Power and ground
A
Analog signal
3.3
3.3 V signal level
5
5 V signal level
NC
No Connection
Reserved
Use is reserved to Eurotech
ReliaGATE 10-20 User Manual Product Overview
17
110129
-0001B
Product Overview
The ReliaGATE 10-20 is a ready-to-deploy, industrial-grade, gateway for advanced Internet of Things applications.
It is a smart device that enables communications, edge computational power, simplified application deployment,
and integration with Internet of Things (IoT) and Machine to Machine (M2M) platforms for immediate service
generation. It provides a capable communication architecture and offers connectivity to a wide range of sensors
and edge devices making it easy to collect data from the field and deliver it to your business application. ReliaGATE
10-20 supports wireless applications including GPS, Wi-Fi, cellular and wired connectivity such as USB 2.0, Gigabit
Ethernet, serial ports, CAN 2.0b, Analog inputs, and isolated digital I/O.
With the ReliaGATE 10-20, you can easily manage configuration and deliver out-of-the-box connectivity for your
IoT/M2M and connected applications. It comes with an optimized Yocto-based Linux operating system specifically
targeted for this device. The ReliaGATE 10-20 comes with Java and OSGi-based middleware for IoT gateways,
Eurotech’s Everyware™ Software Framework (ESF). ESF abstracts and isolates the application developer from
the complexity of the hardware subsystems and ensures application portability across architectures. ESF built-in
components are configurable services covering the most-common building blocks for IoT applications such as I/O
access, network configuration, data services, and remote management. ESF support the Eurotech’s Everyware™
Cloud for remote access and remote management of IoT gateways.
The following figure shows a full-featured ReliaGATE 10-20. A ReliaCELL 10-20 cellular module is mounted. Actual
units may vary in appearance depending on the selected options.
Figure 1. ReliaGATE 10-20, with ReliaCELL 10-20
Product Overview ReliaGATE 10-20 User Manual
18
110129-
0001B
Block Diagram
The following diagram illustrates the standard product delivery for the ReliaGATE 10-20. Additional factory options
are shown in green. Inquire with your local sales representative for any non-standard features.
UART 4
Buf
UART 1
Xcvr
USB 5
USB6
USB7
Gigabit Ethernet 2
Gigabit Ethernet 1
Power
RTC
AUD6
MIPI
CSI-2
2x3 LEDs
GPIOs
Smart Power
Controller
Reset
Vin
Power InputIGN
CPU OFF
Alive
USB-
ETH
Audio
CODEC
ReliaGATE 10-20
ReliaCELL 10-20
( USB 3.0)
3.3V
USB OTG
LCD
HDMI
SIM
GPS (SMA)
UART 5
UART 2
SPI
Bus 3
SD 4
(8-bit)
SD 2
(4-bit)
Keypad
GPIO
USB
2.0
LVDS
Display 0
DDR3
BAT
7-
Port
USB
HUB
USB 1
USB 2
USB 3
USB4
Xcvr
Buf
I
2
C
eMMC
NAND
flash
Power
Manager
Freescale i. MX 6
Processor
x2 USB
USB OTG
microSD
Serial 1
Serial 2
GPS
CAN
Bus
CAN I/F
x2 A/D
Line Out (R)
Mic (R)
CAN 2.0b
DRAM
Cellular
A/D
Reset
RESET
Serial 5
Serial 4
SATA
Serial 5
Serial 4
PCIe
Wi-
Fi
Wi-Fi/BT (SMA)
BT
Accelerometer
x4 GPIO
Boot Switch
ReliaGATE 10-20 User Manual Product Overview
19
110129
-0001B
Features
Processor
• Freescale iMX6 800MHz Solo or Quad Core processor
Memory
• 512MB to 2GB DDR3 DRAM
• 4GB to 64GB on-board flash with soldered down eMMC
• MicroSD expansion slot
Communications
• Two gigabit Ethernet ports
• Three USB 2.0 host ports
• Two serial ports
• One CAN 2.0b
• Wi-Fi IEEE 802.11
• Bluetooth
• GPS receiver (Optional)
• Cellular: Accepts all variants of ReliaCELL 10-20 modems
Indicators
• Six (6) LED status indicators (four are user programmable)
Discrete I/Os
• Two analog inputs
• Four digital inputs/outputs
Software
• Yocto-based Linux Operating System
• Everyware Software Framework (v 3.0.2 or higher)
• Supports Everyware Cloud for remote management
Power Supply
• Supports 6-36VDC (12V Nominal), with transient protection, vehicle ignition input, and a Low Power Mode
• 4 W power consumption, typical
• 17W, maximum
Other
• Battery-backed real-time clock (RTC)
• Accelerometer
• Industrial Temperature Rated (Operational): -40ºC to +80ºC
Product Options
If your application requires any additional features or options, contact your local Eurotech sales representative for
availability.
Product Overview ReliaGATE 10-20 User Manual
20
110129-
0001B
Related Documents
This manual describes the ReliaGATE 10-20 at the system level and is intended for installers, software developers,
and system integrators. The following documents are also important resources for the ReliaGATE 10-20.
Document
Available at
ReliaGATE 10-20 Product Page
https://www.eurotech.com/en/products/subsystems/embedded-computers/reliagate-
10-20
ESF Website
esf.eurotech.com
ESF Download
https://www.eurotech.com/download/en/pb.aspx?pg=ESF
(click the Developer Environment tab)
EC Developer’s Guide
everywarecloud.eurotech.com/doc/ECDevGuide
Kura Website
www.eclipse.org/kura
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27
  • Page 28 28
  • Page 29 29
  • Page 30 30
  • Page 31 31
  • Page 32 32
  • Page 33 33
  • Page 34 34
  • Page 35 35
  • Page 36 36
  • Page 37 37
  • Page 38 38
  • Page 39 39
  • Page 40 40
  • Page 41 41
  • Page 42 42
  • Page 43 43
  • Page 44 44
  • Page 45 45
  • Page 46 46
  • Page 47 47
  • Page 48 48
  • Page 49 49
  • Page 50 50
  • Page 51 51
  • Page 52 52
  • Page 53 53
  • Page 54 54
  • Page 55 55

Eurotech ReliaGATE 10-20 Owner's manual

ReliaGATE 10-20
Eurotech
Brand
Eurotech
Model
ReliaGATE 10-20
Type
Owner's manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

in other languages

Related papers

Other documents