RH Systems PT12 Owner's manual







PT12



RHSystems,LLC

1225WHoustonAve.,

GilbertAZ,85233

Manual

Introduction



PT12Manual 7/20/2021

Page2of48



TABLEOFCONTENTS 



Introduction...........................................................................................................................................................5



QuickStart/InitialSetup.......................................................................................................................................6



2.1



ConnectingaTemperatureProbe.................................................................................................................6



StartingUpthePT12..............................................................................................................................................7



3.1



ObtainingaReading.......................................................................................................................................7



3.2



PlottingTemperature....................................................................................................................................9



Operation.............................................................................................................................................................10



4.1



ConnectingTemperatureProbes.................................................................................................................10



4.1.1



BasicProbes.........................................................................................................................................11



4.1.2



SmartProbes.......................................................................................................................................12



4.1.3



User‐SuppliedProbes..........................................................................................................................12



4.2



ChannelMeasurementRate........................................................................................................................13



4.3



NavigatingtheUserInterface......................................................................................................................13



4.3.1



TemperatureGraphDisplayMode......................................................................................................14



ScrollingtheGraph..........................................................................................................................15



ZoomingtheGraph..........................................................................................................................16



AxisControl......................................................................................................................................16



GraphStatistics................................................................................................................................17



4.3.2



ResistanceGraph.................................................................................................................................18



4.3.3



AllTemperatureDisplayMode............................................................................................................18



4.3.4



AllResistanceDisplayMode................................................................................................................19



4.3.5



Numeric4xDisplayMode....................................................................................................................19



4.3.6



Numeric2xDisplaymode....................................................................................................................20



4.3.7



ComboDisplayMode...........................................................................................................................21



4.3.8



ProbeStatusDisplayMode..................................................................................................................22



4.3.9



ChangingDisplayedUnitsofMeasurement........................................................................................23



4.3.10



ChangingNumberFormat...................................................................................................................23



4.4



ConfiguringtheProbes................................................................................................................................24



4.4.1



Averaging.............................................................................................................................................25



4.4.2



CurrentMode......................................................................................................................................26



4.4.3



CoefficientMode.................................................................................................................................27



Callendar‐VanDusen(CVD).............................................................................................................27



ITS90................................................................................................................................................28



4.4.4



ProbeConfigurationManagement......................................................................................................32



4.5



FileManager................................................................................................................................................34



4.5.1



CopyingLogFilestoUSBDrive............................................................................................................34



4.5.2



DeletingLogFiles.................................................................................................................................34



4.5.3



SetPreferredLoggingLocation............................................................................................................35



4.6



SystemInfo..................................................................................................................................................36



SerialCommunications........................................................................................................................................37



5.1



SerialConnections.......................................................................................................................................37



5.1.1



ElectricalWiringtotheRS‐232Ports...................................................................................................37



RS232PinOut..................................................................................................................................37



SerialConfiguration.........................................................................................................................38



5.1.2



USBtoSerialPort.................................................................................................................................38



5.2



Protocol.......................................................................................................................................................39



5.2.1



CommunicationSequenceandTerminationCharacters.....................................................................39



5.2.2



CaseSensitivity....................................................................................................................................39



5.2.3



NumericValues....................................................................................................................................39



5.3



CommandList..............................................................................................................................................40



5.3.1



SystemLevelCommands.....................................................................................................................40



5.3.2



ChannelCommands.............................................................................................................................41



Introduction



PT12Manual 7/20/2021

Page3of48



ChannelSubCommands..................................................................................................................41



5.3.3



ProbeCommands................................................................................................................................43



Calibration...........................................................................................................................................................45



Uncertainty..........................................................................................................................................................46



Specifications.......................................................................................................................................................47



DocumentHistory................................................................................................................................................48



FORSUPPORT,PLEASEEMAILSUPPORT@RHS.COMORCALL(480)926‐1955WITH

TECHNICALORCALIBRATIONQUESTIONS.



Introduction



PT12Manual 7/20/2021

Page4of48



Introduction



PT12Manual 7/20/2021

Page5of48



INTRODUCTION

ThePT12isahighlypreciseandstableplatinumresistancethermometer(PRT)basedmulti‐channeltemperature

measurementsystem.Usingacustomdesignedhighprecisionmeasurementcircuitwithfullcurrentreversaland

multiplexedsampling,thePT12provides12channelsoflowuncertaintytemperaturedataforvalidationand

calibration.

Usingoneofthreeautomaticoruserselectablecurrents,thePT12repeatedlyscansall12channels.Employinga

fullreversalcurrentsource,thePT12eliminatespolaritysensitiveerrorsnormallyinherenttoDCmeasuring

techniques.Accuracyisfurtherenhancedbyreferencingallmeasurementstoaseriesofhighaccuracy,

temperaturestableinternalreferenceresistors.

TheintegratedfirmwareallowseachchanneltobeindividuallyprogrammedwithITS‐90orCallendar‐VanDusen

(CVD)coefficientsfordirectconversionofresistancemeasurementstotemperature.Itincorporatesafullcolor,

pinchzoomtouchscreenastheuserinterface.Althoughnotrequiredforoperation,thePT12mayalsobe

connectedtoaPCoveranRS‐232orUSBinterface.



QuickStart/InitialSetup



PT12Manual 7/20/2021

Page6of48



QUICKSTART/INITIALSETUP



Thequickstartisintendedtogetyouupandrunningquickly.Foradditionalinformationseesection4Operation.



2.1 CONNECTINGATEMPERATUREPROBE



Selectanyofthesuppliedprobesandconnectittoanydesiredchannel(theremainderofthissectionwillassume

channel5).Wheninsertingtheplug,ensurethereddotslineup.



StartingUpthePT12



PT12Manual 7/20/2021

Page7of48



STARTINGUPTHEPT12

PlugintheincludedACpoweradaptertoa110‐240VACoutlet.Plugtheroundconnectorofthepoweradapter

intothebackofthePT12.Asplashscreenshouldappearinabout15secondsandthemachinewillfullyboot

withinabout30seconds.



3.1 OBTAININGAREADING



Oncethesystemfullybootsandtheuserinterfaceispresent,probe5shouldindicateareasonabletemperature

value.Allprobecoefficients(ifasmartprobe)areautomaticallyreadfromtheprobeandappliedtochannel5.



ThePT12hasseveraldifferentdisplaymodes.Itwillpowerupinthepreviousmodethatwasdisplayedonshut

down.Tochangedisplaymodes,swipewithafingerfromtheleft‐handsidetobringupthemenu.



Fromthismenu,unitsmaybechanged,oranewdisplayformatmaybeselected.



Power(12VDC,3A)USBFlashDriveUSBSerialRS‐232

Swipe

StartingUpthePT12



PT12Manual 7/20/2021

Page8of48



Toselectadisplaymode,tapthedesiredicon.Themenuwillhide,andthenewdisplaymodewillappear.Forthis

quickstartexample,selectthetopleftdisplaymodeicon(thisisthetemperaturegraphdisplaymode).



Formoreinformationseesection4.3NavigatingtheUserInterface.



StartingUpthePT12



PT12Manual 7/20/2021

Page9of48



3.2 PLOTTINGTEMPERATURE



Toaddaprobe’svaluetothegraph,taptheappropriateprobe(probe5inthiscase)onthetopportionofthe

screen.Theprobe’srecentdatawillbeplottedonthegraph.Toensurethatthedataisvisible,taptheShowAll

graphbuttons,andtheContinuousUpdatebuttontoenablethem.Whenenabled,theyarehighlightedinlight

blue.



Dragasinglefingeronthegraphtoscrollinanydirection.Usetwofingersforpinch‐zoomoperation.Foradditional

informationongraphfunctions,seesection4.3.1TemperatureGraphDisplayMode



Note:Thegraphonlyretainsthelast48hoursofdata,whilethelogfileholdsallthedatasincethelastpower

cycleorwhenloggingwaslasttoggledon.Seesections4.5FileManagerand4.6SystemInfo.



Operation



PT12Manual 7/20/2021

Page10of48



OPERATION 



ThePT12measurestemperaturebyratiometriccomparisonoftheunknownresistanceofatemperatureprobeto

aseriesoftemperaturestableprecisionreferenceresistors.

Throughcustomselectionofthefourreferenceresistors,thePT12operatingrangeandprecisioncanbetunedfor

either25Ω PRTsor100Ω PRTs.Alternatively,itcanbecustomizedtocoverbothrangeswithslightlylessoverall

precision.(Formoreinformationoncustomization,contactRHSystems).ThePT12supportsthreedistinctcurrent

modeswhichcanbemanuallyorautomaticallyselected.Thethreecurrentmodesavailableareapproximately0.3

mA,0.6mA,and1mA.ThePT12willattempttogetthemostaccuratereadingpossiblewhenutilizingautocurrent

mode.



4.1 CONNECTINGTEMPERATUREPROBES



Thereare12LEMOconnectors(oneperprobe)onthePT12andanynumberofprobes(between1and12)maybe

connectedinanyorderatanygiventime.Toconnectaprobe,ensurethereddotsbetweentheplugand

receptaclearealigned,thenpushtoconnect.Pullinguponthebodyoftheplugreleasesthecatch,allowingthe

probetoberemoved.Onceinserted,thePT12willautomaticallydetecttheprobeanddetermineifitisasmart

probe(withinternalconfigurationmemory)orabasicprobe(withoutanymemory).



Operation



PT12Manual 7/20/2021

Page11of48



4.1.1 BASICPROBES



Basicprobesdonothaveinternalmemoryandusethechannel’sconfigurationforcoefficients.Ifyoumoveabasic

probefromonechanneltoanother,youwillhavetomanuallyreentertheprobecoefficients.Pins1and6are

jumperedtogetherinsidetheLEMOplugtoindicateabasicprobe.



Jumper

Wire

Image3.1.1

LEMOF66.1B.306

Basic

Probe

Operation



PT12Manual 7/20/2021

Page12of48



4.1.2 SMARTPROBES



TheLEMOconnectorofeachsmartprobeisembeddedwithaMaximIntegratedDS28EC20‐20Kb1‐WireEEPROM

chip.Thismemorychipholdstheprobe’scoefficients,serialnumber,andcalibrationdate.Whenasmartprobeis

pluggedin,thePT12automaticallydetectsitandextractsconfigurationinformationfromthechip.Manualentryof

coefficientsisnotrequiredastheconfigurationinformationtravelswiththeproberegardlessofwhichchannelit’s

pluggedinto.



4.1.3 USER‐SUPPLIEDPROBES



UsersuppliedprobesmaybeutilizedbywiringthemtoaLEMOconnector(part#FGG.1B.306).Tocreateabasic

probe,shortpin1topin6.Tocreateasmartprobe,insertaMaximIntegratedDS28EC20withpin1ofthechipto

pin1oftheLEMOandpin2ofthechiptopin6oftheLEMO.Pin3ofthechipisunusedandshouldbecutoff.See

Image3.1.2above.Bothsmartandbasicprobeswillrequireaninitialentryofcoefficients.Uponsaving,thesmart

probecoefficientswilltravelwiththeprobe.BasicprobecoefficientswillberetainedinthePT12channel.



LEMOF66.1B.306

DS28EC20

Image3.1.2

Operation



PT12Manual 7/20/2021

Page13of48



4.2 CHANNELMEASUREMENTRATE



Ittakesapproximately90msecperreadingforeachoftheattachedprobesandeachofthefourinternalreference

resistors.Meaning,iftwelveprobesareattached,thetotalmeasurementtimetoupdatealltwelvechannelsand

thefourreferenceresistorsisjustunder1.5seconds.Iffewerprobesarepluggedin,unusedchannelsare

automaticallyskipped,increasingmeasurementfrequency.Forexample,withonlyoneattachedprobe,the

approximateupdateratewouldbelessthan0.5seconds.



4.3 NAVIGATINGTHEUSERINTERFACE



ThePT12hasatouchscreeninterfacethatsupportstap,pinch/zoom,swipe,andlongpress.Theyeachhave

differentfunctionsandaresupportedonvariousdisplaymodes.

ThePT12hasseveraldifferentdisplaymodes.Itwillpowerupinthepreviousmodethatwasdisplayedonshut

down.Tochangedisplaymodesswipewithafingerfromtheleft‐handside.Thisbringsupamenuofavailable

displaymodes.



 

Toselectadisplaymode,tapthedesiredicon.Themenuwillhide,andthenewdisplaymodewillappear.



Thedisplaymodeiconsanddescriptions:

TemperatureGraph:Majorityofthescreenisfilledwithatemperaturegraphwith12small

temperaturevalueslistedabove.

ResistanceGraph:Majorityofthescreenisfilledwitharesistancegraphwith12smallresistance

valueslistedabove.

AllTemperatures:Showsa2x6gridwiththetemperaturesofalltwelveprobes.

Swipe

Operation



PT12Manual 7/20/2021

Page14of48



AllResistances:Showsa2x6gridwiththeresistancesofalltwelveprobes.

4xNumeric:Showsa2x2gridwiththetemperaturesandresistancesofanyfourselectedprobes.

2xNumeric:Showstemperaturesandresistancesinalargefontforanytwoselectedprobes.

Combo:Showsuptotwelveconnectedprobetemperaturesononeside,aminigraph,andalarge

numericvalue(temperatureandresistance)foranysingleprobeselected.

ProbeStatus:ShowstheprobeconnectionstatusofeachchannelofthePT12.

4.3.1 TEMPERATUREGRAPHDISPLAYMODE

Toaddaprobetothegraph,taponitsnumericvalue.Thenumericvaluewillbeoutlinedinaunique

color,andthetemperatureplotwillappearonthegraphinthatsamecolor.



NOTE:Thegraphonlyretainsthelast48hours’worthofdata,whilethelogholdsallthedatasincethelastpower

cycleorwhenloggingwaslasttoggledon.



Operation



PT12Manual 7/20/2021

Page15of48



SCROLLINGTHEGRAPH



Toscrollthegraph,dragafingerinanydirection.Alternatively,toscrollasingleaxis,dragwithintheaxisarea.







Operation



PT12Manual 7/20/2021

Page16of48



ZOOMINGTHEGRAPH



Pinchin/outwithtwofingerstozoomthegraphin/out.



Alternatively,tozoomasingleaxis,longpressontheaxisareathendrag.Fory‐axis,dragupordowntozoominor

out.Forx‐axis,dragrightorlefttozoominorout.



AXISCONTROL



ShowAll(x‐axis):Whilethebuttonisselectedthex‐axiswillbescaledtoshowalldata.

ShowAll(y‐axis):Whilethebuttonisselectedthey‐axiswillbescaledtoshowalldata.

Fixedy‐axis(semi‐auto):Whilethebuttonisselectedthey‐axisisfixed.Ifthedatagoesoutofboundsthe

y‐axisautomaticallyadjuststofitthedata.

Lockedy‐axis:Whilethebuttonisselectedthey‐axisremainsexactlyasshownwithoutanyauto

adjustment.



X‐axisWidth:Fixesthewidthofthex‐axistothespecifiedperiodoftime.

Scrollingdoesnotaffectthisvaluehowever,zoomingoverridesthisvalue.The

numericvaluedisplaysinhours,minutes,orsecondsbasedonitsassociated

drop‐downmenu.



ContinuousUpdate:Whilethebuttonisselected,thegraphwillalwaysdisplaythemostrecentvalues,

scrollingthetimeaxisasrequired.Manuallyscrollingorzoomingwilldisablethisbutton.



Operation



PT12Manual 7/20/2021

Page17of48



GRAPHSTATISTICS



Todisplaynumericalstatisticsofanycurrentlygrapheddata,longpressanddragtheboxtohighlightthegraph

datayouwishtoanalyze.Afterreleasing,thestatisticswillbeshownabovethegraph.



Scrollthestatisticaldataleftorrighttodisplaymoreinformation.



Operation



PT12Manual 7/20/2021

Page18of48



4.3.2 RESISTANCEGRAPH

Theresistancedisplaygraphisidenticaltothetemperaturegraphofsection4.3.1TemperatureGraph

DisplayMode,withtheexceptionthatvaluesshownandgraphedareproberesistancesratherthantemperatures.

4.3.3 ALLTEMPERATUREDISPLAYMODE

TheAllTemperatureDisplayModesimultaneouslyshowsalltwelvetemperaturesinthelargestfont

possible.



Unconnectedchannelsappearwithblankvalues.



Operation



PT12Manual 7/20/2021

Page19of48



4.3.4 ALLRESISTANCEDISPLAYMODE

TheAllResistanceDisplayModesimultaneouslyshowsalltwelveresistancesinthelargestfontpossible.



Unconnectedchannelsappearwithblankvalues.



4.3.5 NUMERIC4XDISPLAYMODE

TheNumeric4xDisplayModeshowsanycombinationoffourindividuallyselectablechannels.Eachofthe

fourchannelsmaybeselectedtoshowtemperatureorresistanceinalargefontwhileshowingtheoppositeina

smallerfont.



Operation



PT12Manual 7/20/2021

Page20of48



Toswapaprobe’sindicationfromtemperaturetoresistance,tapitsbottomrightbutton:







Thetemperatureandresistancevalueforthatprobeswapplaces.Totoggleresistancebacktotemperature,tap

thebuttonagain.



Tapthedrop‐downmenuonanyofthefourchannelstoselectadifferentchannel: 



4.3.6 NUMERIC2XDISPLAYMODE

The2xNumericDisplayModeshowsanycombinationoftwoindividuallyselectablechannels.Eachofthe

twochannelsmaybeselectedtoshowtemperatureorresistanceinthelargestpossiblefont.Operationisidentical

tosection4.3.5Numeric4xDisplayMode.



Page is loading ...

RH Systems PT12 Owner's manual

This manual is also suitable for

RH Systems PT12 Owner's manual

Other documents