SGM p Series User manual

Brand: SGM

Model: p Series

Category: Stroboscopes & disco lights

Type: User manual

This manual is also suitable for

P-6
P-6 POI

USER

MANUAL

P-SERIES

P-6

P-6 POI

P-6 Series dimensions

This manual covers installation, use, and maintenance of the SGM P-6 Series.

A digital version is available at www.sgmlight.com, or upon request via [email protected].

P-6 SERIES

USER MANUAL REV. C

. The information in this document is subject to change without notice.



             







English edition

All dimensions in millimeters and inches. Drawing not to scale.

P-6

P-6 POI

Contents

Safety information .....................................................................................................................4

Overview .................................................................................................................................5

Preparing for installation ............................................................................................................6

Installing / rigging the P-6 Series .................................................................................................6

Tilt Lock ..................................................................................................................................7

Connecting AC power ................................................................................................................8

 ...............................................................................................................8

 ............................................................................................

 ......................................................................................10

 ......................................................................................................11

 .................................................................................................11

 ...................................................................................................................12

 .........................................................................................................................13

RDM ......................................................................................................................................14

 .....................................................................................................................14

...........................................................................................15

Accessories ...........................................................................................................................18

Maintenance ...........................................................................................................................20

 .........................................................................................................21

 .......................................................................................................................21

 .....................................................................................................21

User Notes .............................................................................................................................22

User Notes .............................................................................................................................23

WARNING!

Read the following safety precautions carefully before unpacking, installing,

powering, or operating the device.

SGM luminaries are intended for professional use only. They are not suitable for household use.

Les luminaires SGM sont impropre à l’usage domestique. Uniquement à usage professionnel.

This product must be installed in accordance with the applicable installation code by a person familiar with

the construction and operation of the product and the hazards involved.

Ce produit doit être installé selon le code d’installation pertinent, par une personne qui connaît bien

le produit et son fonctionnement ainsi que les risques inhérent.

Safety information

• 

• 

• 

• 

• 

DANGER! Risk of electric shock. Do not open the device.

• 

• 

• 

• 

• 

• 

• 

• 

CAUTION:



• 

• 

• 

corrosion-resistant hardware.

• 



• 



• 

it must have a minimum gauge of 4 mm.

WARNING! Take measures to prevent personal injury.

               



P-6 Series features:

• 



• 

• 

• 

• 

• 

• 

• 

• 

• 

• 

Overview

P-6 POI

A: 24xRGB + 24W LEDs

B: P-6 Tilt lock

C: Cooling fans

D: Control panel (POI n/a)

E: OLED Display (POI n/a)

F: Rubber feet (POI n/a)

G: GORE-TEX membrane

H: DMX in and out

I: Power in and out

J: Handle

K: Barndoors attachment points (x2)

L: Safety wire attachment point

M: Holes for Omega bracket / M-10 screws (x6)

N: P-6 POI Tilt lock (POI only)

O: LED indicator (POI only)

P 6





Unpacking





• 

• 

• 

• 

• 

Location / application



• 

• 

When selecting a location for the device, ensure that:

• 

• 

• 



• For wireless DMX or standalone operation



• For cabled DMX operation

             



Transportation





Preparing for installation



             







               





PLEASE NOTE!!

The 1/4-turn fasteners are only locked when turned fully clockwise.





rigging the P-6 POI” on page 16.

Installing / rigging the P-6 Series

106 mm

[ 4,2in ]

Ø 18 mm

[ 0,7in ]

Figure 2: P-6 Series locking points

WARNING! Always secure an elevated P-6 with a safety wire





• 

• Have a minimum gauge of 4 mm.

• 

CAUTION!!

• Always use a safety wire.

• Make sure the slack of the safety wire is at a minimum.

• Never use the handle for secondary attachment.

Rigging process using SGM Omega brackets

               



1.              

                o f



2. 



3.               -

              a







4. 



5. 



6. -



7. 

Holes for omega bracket

Omega bracket

Figure 3: Base with omega bracket

Figure 4: Safety wire attachment point







1. 

2. Adjust the tilt to the angle desired and hold it.

3. 



enough.

CAUTION!!





Angle indicator



The angle indicator in the wheel shows the current angle of inclination.

NOTE: In POI versions, SGM provides a POI Spanner with a pig-nose key for tilt adjustment. Either use the large or the small



Tilt Lock

Pitch angle

indicator



Connecting AC power













• 

• 

• 

         

         













PLEASE NOTE!







CAUTION!!



The fixture must be grounded/

earthed and be able to be isolated

from AC power. The AC power

supply must incorporate a fuse or

curcuit breaker for fault protection.

Color

Black

White

green/yellow

Conductor

live

neutral

ground (earth)

Symbol

Wire

Figure 6: P-6 Power cable

The fixture must be grounded/

earthed and be able to be isolated

from AC power. The AC power

supply must incorporate a fuse or

circuit breaker for fault protection.

Color

Black

White

green/yellow

Conductor

live

neutral

ground (earth)

Symbol

Wire

Figure 7: Connecting AC Power





















DMX

ESC

ENTER

6CH MODE

(14)

Figure 8: OLED display and control panel



Using the display panel

• 

• 

• 

Display



B - DMX address.









Error Indicator





Shortcuts

• 

• 

• 

• 





       



connectors suitable for outdoor use.



 For POI versions, please refer to pages 16-17 to see how to connect DMX and AC power.



Connecting a wireless transmitter





• 

• Press the connect button on the wireless transmitter.

• 

Note: for POI versions, refer to page 17 to see how to connect to a wireless transmitter.

Disconnecting a wireless transmitter



menu.

Note: for POI versions, refer to page 17 to see how to disconnect from a wireless transmitter.

Signal priority



cabled DMX over wireless DMX.





NOTE: In POI version with wireless, the DMX signal strength can only be checked through RDM.

Connecting to a DMX control device

Figure 9: Display view

DMX

6CH MODE

(14)

A B C D

About DMX



                      



-





PLEASE NOTE:

• Standard microphone cable is not suitable for transmitting DMX.

• 

• 

DMX Start address











     



NOTE!!





Set/edit DMX address













            



DMX modes







DMX

6CH MODE

(14)

DMX address

available

DMX

Figure 10: Set/edit DMX address

P-6 Connection Diagram

Max. 32 units/DMX line

1 2 xx

CONNECTION DIAGRAM

•

Light A/

mmervej 23 · 8210

arhus V · Den

el +45 70 20 74 00 · i

sgm

· w

SGM_P-6 (Rev.2)

115 - 277V AC

50-60 Hz

450 W

115 - 277V AC

50-60 Hz

450 W

115 - 277V AC

50-60 Hz

450 W

DMX Termination

on last fixture DMX out

DATA

GND

DATA -

DATA +

120 Ohm +/- 5%

Max. 6 units/16 A circuit

P 6 P 6P 6

Figure 11: P-6 connection diagram (see page 17 for POI)









scenes with its own RGB and shutter settings.











STANDALONE.





           













Using standalone operation

Figure 12: Standalone operation

Setting a static color manually















Factory default



• 

• 

• 

• 

• 

• 

• 

Effects

           



Color temperature correction



Ultra high-speed strobe effect



Beam angle







Flipping the OLED display (POI n.a.)





the same time.

Setting the OLED display saver (POI n.a.)





brightness.





Setting the fan mode





NOTE: In POI version, the fan mode adjustment is possible through RDM.





Pixel 1

Pixel 3

Pixel 5

Pixel 4

Pixel 2

Pixel 6

Level 1 Level 2 Level 3 Function

Mode Select Mode - Select DMX mode

Info  - 

 - 

Serial Number - 

RDM ID - 

DMX View  

 Mainboard



LED Left

LED Right















Base

Power on time - 

LED On Time - 

Errors - 

Settings   

Signal strength 

  

2. Stand-alone



 



 Disable 

Enable 

  

 

 Standard 

Silent 

 

 - 

Manual  Red 

Green 

Blue 

Run Program  

 - 

Editor Program 

Scene 

Red 

Green 

Blue 

Shutter 

 

 

 

 

Test Off - 

Automated Test - 

 - 

Control menu

Supported RDM functions









RDM functions

RDM

Name Sensor Type

Mainboard 

LED Left 1 

LED Left 2 

LED Left 3 

LED Right 1 

LED Right 2 

LED Right 3 

Name Sensor Type

 Other

 Other

 Other

 Other

 Other

Base 

PID Actions allowed Name

 - Device Label

 - Manufacturer Label

 - 

 - 

 - 

 - Sensor Value

 - 

 - Device Hours

PID Actions allowed Name

 - 

 - 

 - 

 - 

 - Reset Device

 GET Serial Nr.

 GET / SET 



Please note: 

Sensors



Please note: The table is subject to change without notice.

Troubleshooting

Problem Potential cause(s) Remedies





 



Main fuse is blown. 

 Power was turned off. 

 





DMX cables were disconnected. 

  

 Install a XLR 120ohm DMX termination at the end of



 

 







 The minimum values are out of calibration. 

 





Physical differences



















PLEASE NOTE!!

Remote Device Management (RDM) requires a correct DMX cabled installation and termination.

When setting addresses through RDM and using USB dongles, disable the USB selective suspend to ensure a proper

voltage on the DMX link. If any lag or trouble occurs when addressing, decrease the cable length range to <12 m. and only



LED Indicator

                





• Static green:

• Flashing green:

• Flashing orange (when using the magnet):



•    



• Off: 

SGM Addressing Tool









POI Permanent Outdoor Installation

Figure 14: P-6 POI LED indicator

P-6 POI

A: 24xRGB + 24W LEDs

B: P-6 Tilt lock

C: Cooling fans

D: Control panel (POI n/a)

E: OLED Display (POI n/a)

F: Rubber feet (POI n/a)

G: GORE-TEX membrane

H: DMX in and out

I: Power in and out

J: Handle

K: Barndoors attachment points (x2)

L: Safety wire attachment point

M: Holes for Omega bracket / M-10 screws (x6)

N: P-6 POI Tilt lock (POI only)

O: LED indicator (POI only)

P 6



Figure 18: P-6 POI base with dimensions

POI Spanner

      



    







POI Tilt lock





1. 

2. 



3. 

4. 

Installation and rigging the P-6 POI





the base.

-







information on correct POI rated mounting.

A: Magnet

B: Small pig-nose key

C: Large pig-nose key

Figure 16: POI Spanner

Figure 17: P-6 POI Tilt lock

Connecting DMX and AC power in POI





            





PLEASE NOTE!!

• Standard microphone cable are not suitable for transmitting DMX.

• 

• 

• 

1 2 XX

Max. 32 units/DMX line

XLR pin out

5 PIN XLR

DATA

GND

DATA -

DATA +

Shield / GND

White / DMX in / Data -

Red / DMX in / Data +

Shield / GND

Black / DMX out / Data -

Yellow / DMX out / Data +

Junction box

DMX cable

Shield / GND

White / DMX in / Data -

Red / DMX in / Data +

Shield / GND

Black / DMX out / Data -

Yellow / DMX out / Data +

Junction box

DMX cable

DMX termination last junction box

DMX cable

White / DMX in / Data -

Red / DMX in / Data +

Black / DMX out / Data -

Yellow / DMX out / Data +

120 Ohm +/- 5%

Figure 19: Connecting DMX and AC Power in P-6 POI

SGM

Shield

olor

Whi

ondu

Black

ell

ound

DMX IN: Data -

DMX IN: Data +

DMX OUT

: Data -

DMX OUT

: Data +

SGM POI DMX Cable

Connecting a wireless transmitter in POI







1. 



transmitter.

2. 





Disconnecting a wireless transmitter in POI





P-6 POI connection diagram

Accessories





Barndoors







1. 

2. 

3. 

Filter frames



• 

• 

• 

• 

• 









Upper lock pins

Attachment

points

Lower

lock pins

Filter frame front view

Filter frame back view

P-6 with lter frame

Figure 20: P-6 Barndoors

Figure 21: P-6 Filter frames

PLEASE NOTE!!





For further information and other possibilities visit www.sgmlight.com or contact your local SGM dealer.

Anti-glare shields



• Full anti-glare shield 

• Half anti-glare shield







Note: The anti-glare shields are suitable for both permanent outdoor and indoor installations.

Figure 22: Full and half anti-glare shields

SGM Vacuum Test kit







             







SGM Uploader cable





             

          







• 

• 

• Through RDM.











Cleaning









                  

connectors.





Maintenance

Figure 24: SGM Firmware tool

Figure 22: SGM Vacuum Test Kit

Figure 23: SGM Uploader cable

Page is loading ...