Coleman PowerMate User manual

IMPORTANT - Please make

certain that everyone who uses

the Coleman Powermate

Pressure Washer thoroughly

reads and understands these

instructions prior to operation.

IMPORTANT - Veiller à ce que

toute personne amenée à utiliser

cet appareil lise soigneusement

ces instructions et les comprenne

avant de procéder à son

utilisation.

IMPORTANTE - Favor de

ceciorarse de que toda persona

que use el Lavador de presión

Coleman Powermate lea y

entienda todas las instrucciones

antes de la operación.

PW0923500 INSERT

www.colemanpowermate.com LFL 12/02 0057720.01

Page is loading ...

5

REF. PART DESCRIPTION DESCRIPTION DESCRIPCION

NO. NO.

10059128Cover 7046CouvercleCubierta1

20059129Lock nut 7044ÈcrouTuerca3

30059130Handwheel 7045TraiterMango1

40058682Adjusting Screw Plug 6324Vis de réglageTornillo de ajuste1

50057930O-ring 12007Joint ToriqueAro2

60058674O-ring 7937Joint ToriqueAro4

70059131Adjusting Screw 6524Vis de réglageTornillo de ajuste1

80059132Spacer 6573EntretoisesEpaciador1

90059133Spring 6609RessortResorte1

100058678Washer 7917ARondelle, plateArandel la plana1

1100586778mm Ball 6227BillesCojinete 1

120058676Seat 6256SiègeAsiento1

130058675O-ring 8638Joint ToriqueAro1

140059134Unloader Body 6506Décharger corpsDescargador cuerpo1

150059135Seal Ring, 3/8” 8548Joint d’étanchéité collierEmpaque Anillo2

160059136Discharge Bolt 13443Boulon de refoulementPerno de descarga1

170059137Bypass Tube 6531Corps de dispositif de dérivationAlojamiento de paso1

180059138Inlet Fitting 6503PosePrueba1

190059139Seal Ring 1/2” 8541Joint d’étanchéité collierEmpaque Anillo2

200059140Inlet Bolt 13442Boulon d’admissionPerno de entrada1

210059141Piston Cap 6239Piston couverclePiston cubierta1

220059142Piston 07914APistonPiston1

230058673Back-up ring 12031-0002Bague antiextrusionResorte de respaldo2

240058685O-ring 12326Joint ToriqueAro1

250058686Kick Back Valve 12325Kick back soupape de côneKick back válvula cono1

260058687Spring 12328RessortResorte1

270057944Injector orifice 6339Orifice d'injecteurOrificio del inyector1

280057945O-ring 6312Joint ToriqueAro1

290057946O-ring 7913Joint ToriqueAro1

300059459Injector assembly1

350059143External lock toothe washer 08197Contre-écrouArandela, de cierre1

360059144Nut 07939ÈcrouTuerca1

PARTS LIST / LISTE DES PIÈCES / LISTA DE PIEZAS

1

2

3

4

5

6

7

8

9

10

11

12

13

16

15

14

20

19

18

19

5

22

6

23

15

6

17

24

25

26

27

28

29

30

AR SERIES UNLOADER / DISPOSITIF DE MARCHE À VIDE SÉRIE AR / DESCARGADOR SERIE AR

PARTS DRAWING / DESSIN DES PIÈCES / DIAGRAMA DE PIEZAS

Following is information concerning the four nozzles pro-

vided with your pressure washer.

NOTE: The force of the spray on the surface you are

cleaning increases as you move closer to the surface.

0° High Pressure (Red): The water stream discharged is

very aggressive. Use with extreme caution to prevent damage

to the surface being cleaned or injury to persons or animals.

15° High Pressure (Yellow): This is the nozzle used for

most cleaning applications. It provides wide coverage and a

powerful water stream.

40° High Pressure (White): This nozzle is used for

cleaning with a wider coverage over a larger area with a

powerful water stream.

65° Low Pressure (Black): Provides low pressure spray

and a wide coverage. Used primarily when operating the

chemical injector to apply chemicals.

Replacing the Nozzles

To replace a nozzle with a different nozzle, an easy quick

connect has been added to the end of the wand. With the

handle in the locked close position and the wand pointing

away from the user. Pull back on the quick connect fitting and

pull out the nozzle and replace with desired nozzle.

The pump is shipped with a shipping plug, this will need

to be replaced with the vent plug that is supplied.

PRESSURE ADJUSTMENT

The pressure is adjustable by turning the pressure adjust-

ment knob located on the pump of the pressure washer. The

knob must be set at the extreme clockwise position for maxi-

mum pressure and turned several turns counter clockwise for

maximum pressure.

NOTE: With the pressure adjustment knob turned to

the maximum pressure position (clockwise), the pump

pressure may exceed the rated pressure of the machine

which could over load the engine. Adjust the knob counter

clockwise to reduce the pressure and lower the power

requirements of your pressure washer pump.

The pressure may also be regulated by the use of the

engine speed.

6

Item# Description Torque Amount

6Screw43 in.-lbs

10Screw with Lock Washer85 in.-lbs.

34Hex Head Cap Screw, 222 in.-lbs.

Valve Casing

32Plug59 in-lbs.

Inlet Pressure . . . . . . . . . . . . .Positive Inlet Pressure Required

RPM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Up to 3600 RPM

Temperature of Pumped Fluids . . . . . . . . . . . . . . .Up to 160°F

Inlet Ports . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .(2) 1/2” BSP

Discharge Ports . . . . . . . . . . . . . . . . . . . . . . . . . . .(2) 3/8” BSP

Key Width . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8mm

Weight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16 lbs.

Crankcase oil Capacity . . . . . . . . . . . . . . . . . . . . . . .14.2 fl. oz.

Change oil after (HR) . . . . . . . . . . . . . .Initially 50/Every 500

Consult the pump manufacturer for special requirements that

must be met if the pump is to operate beyond one or more of

the limits specified above.

Plunger Packing Kit (9152)

Order # 0057908

Valve Assembly Kit (9116)

Order # 0057909

Oil Seal Kit (9144)

Order # 0057910

Unloader Repair Kit (9516)

Order # 0057962

P321 SERIES TORQUE SPECIFICATIONS

P321 SERIES REPAIR KITS

P321 SPECIFICATIONS

SPRAY NOZZLE SELECTION

PUMP PREPARATION

PRESSURE ADJUSTMENT

English

Page is loading ...

4970 Airport Road

P. O. Box 6001

Kearney, NE 68848

1-800-445-1805

1-308-237-2181

Fax 1-308-234-4187

Coleman PowerMate User manual

This manual is also suitable for

Coleman PowerMate User manual

in other languages

Related papers

Other documents