Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/141 3-90-04301c

INSTALLER: Leave this manual with party responsible for use and operation.

OWNER: Retain this manual for future reference.

Contact your local dealer with questions on installation, operation or service.

Please read this entire manual before

installation and use of this pellet fuel-

burning room heater.

Failure to follow these instructions could

result in property damage, bodily injury

• Complywithallminimumclearancestocombustibles

asspecied.Failuretocomplymaycausehousere.

Checkbuildingcodespriortoinstallation.

• InstallationMUSTcomplywithlocal,regional,stateand

nationalcodesandregulations.

• Contactlocalbuildingorreofcialsaboutrestrictions

andinstallationinspectionrequirementsinyourarea.

Testedandapprovedforwoodpelletsandshelledeld

cornfuelonly.Burningofanyothertypeoffuelvoids

yourwarranty.

• Alertchildrenandadultstohazardsofhightemperatures.

High temperatures may ignite clothing or other

ammable materials.

• Keepclothing,furniture,draperiesandotherammable

materialsaway.

To obtain a Frenchtranslation of this manual, please

contactyourdealerorvisitwww.harmanstoves.com

Model(s):

P43 Freestanding Pellet Stove

P43

Use&CareVideo

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/142 3-90-04301c

Stove.TheHarman® P43pelletstove youhaveselected

isdesignedtoprovidetheutmostinsafety,reliability,and

efciency.

Astheownerofanewpelletstove,you’llwanttoreadand

manual.Payspecialattentiontoallcautionsandwarnings.

1

Local Dealer Information

DEALER: Fill in

SerialNumber

ModelName

"PREVENT HOUSE FIRES"

WARNING: THE STRUCTURAL INTEGRITY OF THE MANUFACTURED HOME FLOOR, WALL,

DANGER: Risk of Electrical Shock. Disconnect Power Before Servicing Unit.

"PREVENTION DES INCENDIES"

AVERTISSEMENT POUR MOBILE HOMES: Ne pas installer dans une chambre. ll est imperatif

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/143 3-90-04301c

G.PelletFeederChamber ..........................21

C. Troubleshooting................................24

7 Reference Materials

= Contains updated information



Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/144 3-90-04301c

4021-645F02-18-13 Page1of2

LIMITED LIFETIME WARRANTY

willbefreefromdefectsinmaterialsandworkmanshipatthetimeofmanufacture.Afterinstallation,ifcoveredcompo-

nentsmanufacturedbyHHTarefoundtobedefectiveinmaterialsorworkmanshipduringtheapplicablewarrantyperiod,

HHTwill,atitsoption,repairorreplacethecoveredcomponents.HHT,atitsowndiscretion,mayfullydischargeallofits

obligationsundersuchwarrantiesbyreplacingtheproductitselforrefundingtheverifiedpurchasepriceoftheproduct

itself.Themaximumamountrecoverableunderthiswarrantyislimitedtothepurchasepriceoftheproduct.Thiswarranty

issubjecttoconditions,exclusionsandlimitationsasdescribedbelow.

Warrantycoveragebeginsonthedateoforiginalpurchase.Inthecaseofnewhomeconstruction,warrantycoverage

beginsonthedateoffirstoccupancyofthedwellingorsixmonthsafterthesaleoftheproductbyanindependent,

authorizedHHTdealer/distributor,whicheveroccursearlier.Thewarrantyshallcommencenolaterthan24months

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/145 3-90-04301c

• ThiswarrantyisonlyvalidwhiletheHHTapplianceremainsatthesiteoforiginalinstallation.

•ThiswarrantyisonlyvalidinthecountryinwhichtheHHTauthorizeddealerordistributorthatsoldtheappliance

resides.

• Contactyourinstallingdealerforwarrantyservice.Iftheinstallingdealerisunabletoprovidenecessaryparts,contact

thenearestHHTauthorizeddealerorsupplier.Additionalservicefeesmayapplyifyouareseekingwarrantyservice

fromadealerotherthanthedealerfromwhomyouoriginallypurchasedtheproduct.

• Checkwithyourdealerinadvanceforanycoststoyouwhenarrangingawarrantycall.Travelandshippingcharges

forpartsarenotcoveredbythiswarranty.

• Theappliancehasbeenover-firedoroperatedinatmospherescontaminatedbychlorine,fluorine,orotherdamaging

• Theowner’sexclusiveremedyandHHT’ssoleobligationunderthiswarranty,underanyotherwarranty,expressor

implied,orincontract,tortorotherwise,shallbelimitedtoreplacement,repair,orrefund,asspecifiedabove.Inno

eventwillHHTbeliableforanyincidentalorconsequentialdamagescausedbydefectsintheappliance.Somestates

donotallowexclusionsorlimitationofincidentalorconsequentialdamages,sotheselimitationsmaynotapplytoyou.

Thiswarrantygivesyouspecificrights;youmayalsohaveotherrights,whichvaryfromstatetostate.EXCEPTTO

THEEXTENTPROVIDEDBYLAW,HHTMAKESNOEXPRESSWARRANTIESOTHERTHANTHEWARRANTY

SPECIFIEDHEREIN.THEDURATIONOFANYIMPLIEDWARRANTYISLIMITEDTODURATIONOFTHE

EXPRESSEDWARRANTYSPECIFIEDABOVE.

Thiswarrantydoesnotcoverthefollowing:

• Minorexpansion,contraction,ormovementofcertainpartscausingnoise.Theseconditionsarenormalandcom-

plaintsrelatedtothisnoisearenotcoveredbythiswarranty.

• Damagesresultingfrom:(1)failuretoinstall,operate,ormaintaintheapplianceinaccordancewiththeinstallation

instructions,operatinginstructions,andlistingagentidentificationlabelfurnishedwiththeappliance;(2)failureto

installtheapplianceinaccordancewithlocalbuildingcodes;(3)shippingorimproperhandling;(4)improperopera-

tion,abuse,misuse,continuedoperationwithdamaged,corrodedorfailedcomponents,accident,orimproperly/

incorrectlyperformedrepairs;(5)environmentalconditions,inadequateventilation,negativepressure,ordrafting

causedbytightlysealedconstructions,insufficientmake-upairsupply,orhandlingdevicessuchasexhaustfansor

forcedairfurnacesorothersuchcauses;(6)useoffuelsotherthanthosespecifiedintheoperatinginstructions;(7)

installationoruseofcomponentsnotsuppliedwiththeapplianceoranyothercomponentsnotexpresslyauthorized

ationmustbegiventoappliancelocationandconfiguration,environmentalconditions,insulationandairtightnessof

thestructure.

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/146 3-90-04301c

2

A. Appliance Certication E. BTU & Efciency Specications

TheP43FreestandingPelletStovebyHarman®isexempt

from Environmental ProtectionAgency certication under

40CFR60.531bydenition[WoodHeater(A)“AirtoFuel

Ratio].

B. Mobile Home Approved

whennotinstalledinasleepingroomandwhenanoutside

homeinstallation.

NOTE: Thisinstallationmustconformwithlocalcodes.

Intheabsenceoflocalcodesyoumustcomplywiththe

ASTM E 1509-04, ULC/ORD-C1482-M1990, ULC-S627-

00, (UM) 84-HUD

C. Glass Specications

This appliance is equipped with 5mm mirrored ceramic

glass.Replaceglassonlywith5mmceramicglass.Please

contactyourdealerforreplacementglass.

D. Electrical Rating

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/147 3-90-04301c

3

• Keepchildrenaway

• CAREFULLYSUPERVISEchildreninsameroomasstove.

• Alertchildrenandadultstohazardsofhightemperatures.

materials.

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/148 3-90-04301c

Temp dial

Allowsyoutoadjusttheroomtemperaturesetting,in

RoomTempMode,usingtheouterscalemarkedin

degreesFahrenheit.Italsoallowsyoutoadjustthe

constantburnsetting,whileinConstantburnMode,

Power Light

Indicatespowertothe

shut down. Blinks to

Indicatesigniterison.

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/149 3-90-04301c

Hearth&HomeTechnologiesrecommendsusingonlyfuel

thatiscertiedbythePelletFuelsInstitute(PFI).

FuelMaterial

• Madefromsawdustand/orotherwoodby-products

• Shelledeldcorn(whenmixedwithwoodpellets)

• Sourcematerialtypicallydeterminesashcontent

HigherAshContentMaterial

• Hardwoodswithhighmineralcontent

• Barkandleavesassourcematerial

• “Standard”gradepellets,cornandotherbiomass

• Mustbecleanandfreeofdebris

• Mustbemixedwithwoodpellets.(Upto50%)

• Stalk parts, excessive nes and cob remnants may

causefeedsystemjamsorblockage

CAUTION! Do not burn fuel that contains an additive;

(such as soybean oil)

• Maycausehopperre

• Damagetoproductmayresult

Read the list of ingredients on the packaging. If you are

buyingeldcorn,theonlyingredientlistedshouldbeeld

Minerals and other non-combustible materials, like sand,

willturnintoahardglass-likesubstancewhenheated.

Treesfromdifferentareaswillvaryinmineralcontent.For

this reason, some fuels will produce more clinkers than

others.

Moisture

Always burn dry fuel. Burning fuel with high moisture

contenttakesenergytodryandtendstocooltheappliance

thus,robbingheatfromyourhome.Damppelletfuelcould

turnbackintosawdustwhichdoesnotowproperlythrough

• Lengthshouldbenomorethan1-1/2inches(38mm)

• Pellet length can vary from lot to lot from the same

Performance

• Higherashcontentrequiresmorefrequentmaintenance.

• “Premium” grade pellets will produce the highest heat

output.

• Burning pellets longer than 1-1/2 inches (38mm) can

causeinconsistentfeedingand/orignition.

Werecommendthatyoubuyfuelinmulti-tonlotswhenever

possible. However, we do recommend trying different

brands prior to purchasing multi-ton lots, to ensure your

satisfaction.

unburnedfuelbeingpushedintotheashpan.

Storage

• Woodpelletsshouldbeleftintheiroriginalsealedbag

untilreadytouse,topreventmoisture.

• Shelledcornshouldbestoredinatightlysealedcontainer

topreventmoistureandtodeterpests

• Donotstorefuelwithinthespeciedclearanceareas,or

inalocationthatwillinterferewithroutinecleaningand

maintenanceprocedures.

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1416 3-90-04301c

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1417 3-90-04301c

NOTICE:Thesearerecommendations.Cleanmorefrequentlyifyouencounterheavybuild-upofashattherecommended

intervaloryouseesootcomingfromthevent.Not properly cleaning your appliance on a regular basis will void your

5

• Smokespillageintoroomcanoccurifappliance

isnotcoolbeforeunplugging.

• Riskofshockifappliancenotunpluggedbefore

servicingappliance.

A. Proper Shutdown Procedure

C. General Maintenance

Whenproperlymaintained,yourstovewillgiveyoumany

yearsoftrouble-freeservice.Contact your dealertoanswer

questionsregardingproperoperation,trouble-shootingand

serviceforyourappliance.Visitwww.harmanstoves.comto

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1418 3-90-04301c

mustbetreatedwithcommonsenseandcare.Neverabusetheglassbyslammingthedoorshutorstrikingtheglasswith

aheavyobject.Iftheglassisbrokenordamaged,donotoperatethestoveuntilithasbeenreplaced.

Glass - Replacement

Ifthestove’sglassiscrackedorbroken,youmustreplaceitbeforeoperatingyourstove.Removepiecescarefully.Replace

glassonlywithHarman®replacementglass;do not use substitutes.

Carefullyremovedamagedglass,gasketmaterial,andholddownclips(setaside).

Installtheselfadhesive1/4"”gasketmaterialaroundthefrontfaceoftheglass.Settheglasspanelandgasketgentlyonto

thedoor.Installtheholddownclipsandtightenwithbolts.

Glass - Cleaning

Sometimesitwillbenecessarytocleanaccumulatedashfromtheglasssurface;allowingthisashtoremainontheglass

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1419 3-90-04301c

pot.(Weekly at minimum)

downto auger tube Figure5.1. It is notnecessary to

completelyremove all material fromthe burn pot.The

excesswillbepushedoutduringthenextuse.

Monthly, or after each ton of fuel burned:

• Loosenthe(2)wingthumbscrewsonthelowerfrontangle

oftheburnpot.Figure5.2

• Liftofftheclean-outcovertoopenthebottomclean-out

Figure 5.3

Theigniterismadetoberemovableforservicebyinsulated

male/femalewireconnectors.Theseconnectionsbetween

thehotleads(thewiresinsidetheburnpot)andthecold

leads(thewiresfromthecontrolboard)arealwayspulled

totheinsiderearofthefeederbody. (Not coiled inside the

burn pot.)

Itisveryimportantthattheseconnectionsaretotheinside

rearofthefeederbody.Also,theextrawireoftheigniterwire

serviceloopmustbepulledoutthroughtherearofthefeeder

Burnpotigniter

E. Burnpot Maintenance

Figure 5.1

Figure 5.2

Figure 5.3

Use caution when cleaning burn pot clean-out

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1420 3-90-04301c

blower fan blade. Figure 5.4. In order to remove the

retainer.Figure5.5.This will allow the combustion intake

cover to be removed.To remove the combustion intake

coverpulltowardsthefrontoftheunitwhileslidingtothe

right.Figure5.6.

Nowthatthecombustionintakecoverisremovedyoucan

combustionblowerfanbladeandareasaroundit.

The exhaust passage may need cleaned as well. Keep

inmindtheESPSensorislocatedjustinsidetheexhaust

passageFigure5.7.BesurenottodamagetheESPSensor

Figure 5.6

Figure 5.7

ExhaustPassage