Harman P43 Owner's manual

Brand: Harman

Model: P43

Category: Stoves

Type: Owner's manual

This manual is also suitable for

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/141 3-90-04301c

INSTALLER: Leave this manual with party responsible for use and operation.

OWNER: Retain this manual for future reference.

Contact your local dealer with questions on installation, operation or service.

Please read this entire manual before

installation and use of this pellet fuel-

burning room heater.

Failure to follow these instructions could

result in property damage, bodily injury

or even death.

• Donotstoreorusegasolineorotherammablevapors

andliquidsinthevicinityofthisoranyotherappliance.

• Donotoverre-Ifanyexternalpartstartstoglow,you

areoverring.Reducefeedrate.Overringwillvoid

yourwarranty.

• Complywithallminimumclearancestocombustibles

asspecied.Failuretocomplymaycausehousere.

Checkbuildingcodespriortoinstallation.

• InstallationMUSTcomplywithlocal,regional,stateand

nationalcodesandregulations.

• Contactlocalbuildingorreofcialsaboutrestrictions

andinstallationinspectionrequirementsinyourarea.

Testedandapprovedforwoodpelletsandshelledeld

cornfuelonly.Burningofanyothertypeoffuelvoids

yourwarranty.

Hot glass will cause burns.

• Donottouchglassuntilitiscooled

• NEVERallowchildrentotouchglass

• Keepchildrenaway

• CAREFULLYSUPERVISEchildreninsameroomas

stove.

• Alertchildrenandadultstohazardsofhightemperatures.

High temperatures may ignite clothing or other

ammable materials.

• Keepclothing,furniture,draperiesandotherammable

materialsaway.

HOT SURFACES!

Glassandothersurfacesarehot

duringoperationANDcooldown.

To obtain a Frenchtranslation of this manual, please

contactyourdealerorvisitwww.harmanstoves.com

Pourobtenirunetraductionfrançaisedecemanuel,s’il

vousplaît contacter votre revendeurou visitez www.

harmanstoves.com

NOTE

WARNING

Owner’s Manual

Care and Operation

Model(s):

P43 Freestanding Pellet Stove

NOTICE: SAVE THESE INSTRUCTIONS

P43

Use&CareVideo

CAUTION

Service parts list has been removed from this manual.

Refer to Owner’s Manual or Individual service parts list.

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/142 3-90-04301c

Listing Label Information/Location

A. Congratulations

CongratulationsonselectingaHarman®FreestandingPellet

Stove.TheHarman® P43pelletstove youhaveselected

isdesignedtoprovidetheutmostinsafety,reliability,and

efciency.

Astheownerofanewpelletstove,you’llwanttoreadand

carefullyfollowalloftheinstructionscontainedinthisowner’s

manual.Payspecialattentiontoallcautionsandwarnings.

Thisowner’smanual shouldberetainedforfuturereference.

Wesuggest that you keep it with your other important

documentsandproductmanuals.

Yournew Harman® P43 Freestanding Pellet Stove will

giveyouyearsofdurableuseandtrouble-freeenjoyment.

WelcometotheHarman®family!

Themodelinformationregardingyourspecicstovecanbefoundon

theratingplateusuallylocatedinthecontrolareaofthestove.

Readthismanualbeforeoperatingthisappliance.

PleaseretainthisOwner’sManualforfuturereference.

ReadtheInstallationManualbeforemakinganyinstallationornishingchanges.

Welcome

Brand:________________________________________________ ModelName:___________________________

SerialNumber:__________________________________________ DateInstalled: __________________________

Appliance Information:

Local Dealer Information

DEALER: Fill in

your name, address,

phone and email

information here and

appliance information

below.

DealerName:________________________________________________________

Address:____________________________________________________________

____________________________________________________________

Phone:_____________________________________________________________

Email:_____________________________________________________________

SerialNumber

ModelName

"PREVENT HOUSE FIRES"

Install and Use Only in Accordance With Manufacturer's Installation and Operation Instructions.

Contact Local Building or Fire Ofﬁ cials About Restrictions and Installation Inspection in Your Area.

WARNING: THE STRUCTURAL INTEGRITY OF THE MANUFACTURED HOME FLOOR, WALL,

AND CEILING/ROOF MUST BE MAINTAINED. DO NOT INSTALL IN SLEEPING ROOM.

An outside combustion air inlet must be provided. Refer to Manufacturer’s instructions and local

codes regarding the requirements for passing the exhaust venting system through a combustible

wall or ceiling.

Inspect and Clean Exhaust Venting System Frequently.

Use a 3" or 4" diameter type "L" or "PL" venting system.

Do Not Connect This Unit to a Chimney Flue Serving Another Appliance.

FOR USE WITH WOOD PELLET FUEL OR UP TO 50% CORN / PELLET MIXTURE ONLY.

The Use of Other Fuels May Create an Unsafe Condition.

Input Rating Max: 5.5 lb. fuel/hr.

U.S. Electrical Rating: 115 VAC, 60 Hz, Start 4.2 AMPS, Run 2.8 AMPS

Route Power Cord Away From Unit.

DANGER: Risk of Electrical Shock. Disconnect Power Before Servicing Unit.

For Further Instruction, Refer To Owner's Manual.

Replace glass only with 5mm ceramic available from your dealer.

Keep Viewing and Ash Removal Doors Tightly Closed During Operation.

DO NOT REMOVE THIS LABEL / NE PAS ENLEVER CETTE ÉTIQUETTE

MINIMUM CLEARANCES TO COMBUSTIBLES/

DISTANCES DE SECURITE PAR RAPPORT AUX

MATERIAUX COMBUSTIBLES:

Back Wall / Entre Mur Arrière 2”/ 51mm 2”/ 51mm

Side Wall / Entre Paroi Latér 16”/ 406mm 10”/ 254mm

CORNER INSTALLATION / EN ANGLE

Walls to Appliance 9”/228mm 9”/228mm

Entre Murs et appareil

FLOOR PROTECTION / Protection Du Plancher

USA Canada

Sides*/Côtés (A) 6” 200mm

Back**/Arrière (B) 6” 200mm

Front*/Avant (C) 6” 450mm

**Measured from pedestal base in the US ONLY

**Mesuré à partir de la base du socle aux États-Unis uniquement

*Measured from Glass Opening

*Mesurer à partir de la surface de la porte en verre

Floor Protection Must Be a Non-Combustible Material.

Must Also be Place Under Any Horizontal Flue Connector, Extending

2” or 51mm Beyond the Pipe Measurement.

Pour protéger le plancher, il faut sous le pêole un matériau. Qui doit

aussi être placé sous les parties horizontales du tuyau de raccord

à la cheminée et s’étendre à 51mm o 2 po. au-delà de la mesure

du tuyau.

Made in U.S.A. of US and imported parts. / Fabriqué

aux États-Unis-d’Amérique par des pièces d’origine

américaine et pièces importées.

"PREVENTION DES INCENDIES"

Respecter scrupuleusement les instructions du constructeur pour l'installation et les consignes

de fonctionnement. Respecter les règles de sécuritè en vigueur dans votre région.

AVERTISSEMENT POUR MOBILE HOMES: Ne pas installer dans une chambre. ll est imperatif

de prévoir une prise d'alr extérieur. L'intégrité structurale du plancher, du plafond et des murs doit étre

strictement préservée. Se reporter aux instructions du fabricant et aux réglementations spéciﬁ ques

locales concernant les précautions requises lors de la traversée d'un mur ou d'un plafond.

Contróler et nettoyer fréquemment tout le systeme d'evacuation des fumées conformément aux

recommandations du constructeur. Utiliser des tuyaux <<Spécial granulés>> de Ø76 mm ou

102 mm. Ne pas raccorder ce poéle à un conduit de cheminée déjà utilisé pour un autre appareil.

FONCTIONNE EXCLUSIVEMENT AVEC DES GRANULES DE BOIS.

Appareil de chauffage à granulé type. Consommation maximum: 2.5 kg/h.

US coupure: 115 VAC, 60 Hz, 4.2 amps Démarrer, Exécuter 2.8 AMPS

fonctionnement normal 1.1A. Tenir le cordon d'alimentation à l'écart du poèle.

DANGER: Risque d'électrocution. Débrancher l'appareil avant toute intervention.

Ne remplacer la vitre qu'avec une vitre céramique 5mm de méme qualité disponible

auprès de votre revendeur.

Pour une information plus compléte, se reporter à la notice d'utilisation. Tenir la porte

hermétiquement close durant fonctionnement.

Ne faites pas obstacle l’espace sous le réchauffeur. Toujours fournir un approvisionnement sufﬁ sant en air frais

jusqu’au lieu d’installation Appliance

P.N. 3-90-04300

WITHOUT

SIDE SHIELDS

WITH

SIDE SHIELDS

Sans Écrans

Latéraux

Avec Écrans

Latéraux

US ENVIRONMENTAL PROTECTION AGENCY

This appliance complies with Canadian Standards Association (CSA) B415.1 and Title 40

of the U.S. Code of Federal Regulations, Part 60, SubPart AAA. This model is exempt from

EPA certiﬁ cation under 40 CFR 60.531 by deﬁ nition [Wood Heater (A) “air-to-fuel ratio”].

Cet appareil est conforme a l’Association Canadienne des Standards (CSA) B415.1-10,

clause 4 et Titre 40 du Code des Régulations Fédérales des États-Unis, partie 60, section

AAA. Ce modèle est exempt de la certiﬁ cation EPA sous 40 CFR 60.531 par déﬁ nition

(Appareil de chauffage au bois (A) “ ratio Air-Combustible).

Date of Manufacture / Date de fabrication:

Fabriqué par: Hearth and Home Technologies 352 Mountain House Road, Halifax PA 17032

2013 2014 2015 JAN FEB MAR APR MAY JUN JUL AUG SEP OCT NOV DEC

HarmanPP38+/P43PelletStove

BlackBackgroundwithbaremetalforprint-adhesivebacked,metalplate.

BARCODE LABEL

008

Serial No.

de série:

Report #/ Raport #135-S-21-6.2 (PP38+)

Report #/ Raport #135-S-23-4, 135-S-23b-6.2 (P43)

Tested to / Testé à:

ASTM E1509-04, ULC/ORD-C1482-M1990,

ULC-S627-00

Room Heater Pellet Fuel Burning Type. Also for use in Mobile Homes.

Appareil de chauffage à granulés de bois Utilisable dans des mobile homes.

This pellet burning appliance has been tested and listed for use in

Manufactured Homes in accordance with OAR 814-23-900 through 814-23-909

MODEL/MODÈLE:"PP38+/P43"

2"(51mm)

10" (254mm) with side shields

16" (406mm) w/out side shields

USA CANADA

FLOOR PROTECTOR

PROTECTION DE SOL

FLOOR PROTECTION

9"(228mm)

Rev E

10-3/4"

4-3/8"

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/143 3-90-04301c

Safety Alert Key:

• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.

• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.

• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.

• NOTICE: Used to address practices not related to personal injury.

Table of Contents

1 Welcome

A. Congratulations .................................2

B. LimitedLifetimeWarranty..........................4

2 Product Specic and Important Safety Information

A. ApplianceCertication............................6

B. MobileHomeApproved...........................6

C. GlassSpecications(Ceramic) .....................6

D. ElectricalRating.................................6

E. BTU&EfciencySpecications.....................6

3 General Information

A. ApplianceSafety ................................7

B. ClearSpace....................................7

C. ControlExplanation..............................8

D. FuelSpecication................................9

E. GeneralOperatingInformation.....................10

4 Operating Instructions

A. StartingYourFirstFire........................... 11

B. FireCharacteristics ............................. 11

C. FeedRateAdjustmentInstructions ................. 11

D. IgnitionCycles.................................12

E. AutomaticIgnition...............................13

F. ManualIgnition.................................15

5 Maintenance and Service

A. ProperShutdownProcedure......................17

B. QuickReferenceMaintenanceChart................17

C. GeneralMaintenance............................17

D. GlassMaintenance..............................18

E. BurnpotMaintenance............................19

F. CombustionBlowerChamber .....................20

G.PelletFeederChamber ..........................21

6 Troubleshooting and Frequently Asked Questions

A. ErrorCodeDescription...........................22

B. FrequentlyAskedQuestions ......................23

C. Troubleshooting................................24

7 Reference Materials

A. SafetyReminders...............................25

B. MotorandComponentLocation....................26

C. LossofPowerAddendum ........................27

D. ContactInformation.............................28

= Contains updated information



Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/144 3-90-04301c

4021-645F02-18-13 Page1of2

Hearth & Home Technologies

LIMITED LIFETIME WARRANTY

Hearth&HomeTechnologies,onbehalfofitshearthbrands(”HHT”),extendsthefollowingwarrantyforHHT

gas,wood,pellet,coalandelectrichearthappliancesthatarepurchasedfromanHHTauthorizeddealer.

WARRANTY COVERAGE:

HHTwarrantstotheoriginalowneroftheHHTapplianceatthesiteofinstallation,andtoanytransfereetakingownership

oftheapplianceatthesiteofinstallationwithintwoyearsfollowingthedateoforiginalpurchase,thattheHHTappliance

willbefreefromdefectsinmaterialsandworkmanshipatthetimeofmanufacture.Afterinstallation,ifcoveredcompo-

nentsmanufacturedbyHHTarefoundtobedefectiveinmaterialsorworkmanshipduringtheapplicablewarrantyperiod,

HHTwill,atitsoption,repairorreplacethecoveredcomponents.HHT,atitsowndiscretion,mayfullydischargeallofits

obligationsundersuchwarrantiesbyreplacingtheproductitselforrefundingtheverifiedpurchasepriceoftheproduct

itself.Themaximumamountrecoverableunderthiswarrantyislimitedtothepurchasepriceoftheproduct.Thiswarranty

issubjecttoconditions,exclusionsandlimitationsasdescribedbelow.

WARRANTY PERIOD:

Warrantycoveragebeginsonthedateoforiginalpurchase.Inthecaseofnewhomeconstruction,warrantycoverage

beginsonthedateoffirstoccupancyofthedwellingorsixmonthsafterthesaleoftheproductbyanindependent,

authorizedHHTdealer/distributor,whicheveroccursearlier.Thewarrantyshallcommencenolaterthan24months

followingthedateofproductshipmentfromHHT,regardlessoftheinstallationoroccupancydate.Thewarrantyperiodfor

partsandlaborforcoveredcomponentsisproducedinthefollowingtable.

Theterm“LimitedLifetime”inthetablebelowisdefinedas:20yearsfromthebeginningdateofwarrantycoveragefor

gasappliances,and10yearsfromthebeginningdateofwarrantycoverageforwood,pellet,andcoalappliances.These

timeperiodsreflecttheminimumexpectedusefullivesofthedesignatedcomponentsundernormaloperatingconditions.

Seeconditions,exclusions,andlimitationsonnextpage.

Parts Labor Gas Wood Pellet

EPA

Wood

Coal Electric Venting

XXXXXXX

Allpartsandmaterialexceptas

coveredbyConditions,

Exclusions,andLimitations

listed

XXX

Igniters,electroniccomponents,

andglass

X X X X X Factory-installedblowers

X Moldedrefractorypanels

X Firepotsandburnpots

5years 1year X X Castingsandbaffles

7years 3years X X X

Manifoldtubes,

HHTchimneyandtermination

years

1year X Burners,logsandrefractory

Limited

Lifetime

3years X X X X X Fireboxandheatexchanger

XXXXXXX

Allreplacementparts

beyondwarrantyperiod

WarrantyPeriod HHTManufacturedAppliancesandVenting

1Year

ComponentsCovered

3years

2years

90Days

B. Limited Lifetime Warranty

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/145 3-90-04301c

4021-645F02-18-13 Page2of2

WARRANTY CONDITIONS:

• ThiswarrantyonlycoversHHTappliancesthatarepurchasedthroughanHHTauthorizeddealerordistributor.Alistof

HHTauthorizeddealersisavailableontheHHTbrandedwebsites.

• ThiswarrantyisonlyvalidwhiletheHHTapplianceremainsatthesiteoforiginalinstallation.

•ThiswarrantyisonlyvalidinthecountryinwhichtheHHTauthorizeddealerordistributorthatsoldtheappliance

resides.

• Contactyourinstallingdealerforwarrantyservice.Iftheinstallingdealerisunabletoprovidenecessaryparts,contact

thenearestHHTauthorizeddealerorsupplier.Additionalservicefeesmayapplyifyouareseekingwarrantyservice

fromadealerotherthanthedealerfromwhomyouoriginallypurchasedtheproduct.

• Checkwithyourdealerinadvanceforanycoststoyouwhenarrangingawarrantycall.Travelandshippingcharges

forpartsarenotcoveredbythiswarranty.

This warranty is void if:

• Theappliancehasbeenover-firedoroperatedinatmospherescontaminatedbychlorine,fluorine,orotherdamaging

chemicals.Over-firingcanbeidentifiedby,butnotlimitedto,warpedplatesortubes,rustcoloredcastiron,bubbling,

crackinganddiscolorationofsteelorenamelfinishes.

• Theapplianceissubjectedtoprolongedperiodsofdampnessorcondensation.

• Thereisanydamagetotheapplianceorothercomponentsduetowaterorweatherdamagewhichistheresultof,but

notlimitedto,improperchimneyorventinginstallation.

LIMITATIONS OF LIABILITY:

• Theowner’sexclusiveremedyandHHT’ssoleobligationunderthiswarranty,underanyotherwarranty,expressor

implied,orincontract,tortorotherwise,shallbelimitedtoreplacement,repair,orrefund,asspecifiedabove.Inno

eventwillHHTbeliableforanyincidentalorconsequentialdamagescausedbydefectsintheappliance.Somestates

donotallowexclusionsorlimitationofincidentalorconsequentialdamages,sotheselimitationsmaynotapplytoyou.

Thiswarrantygivesyouspecificrights;youmayalsohaveotherrights,whichvaryfromstatetostate.EXCEPTTO

THEEXTENTPROVIDEDBYLAW,HHTMAKESNOEXPRESSWARRANTIESOTHERTHANTHEWARRANTY

SPECIFIEDHEREIN.THEDURATIONOFANYIMPLIEDWARRANTYISLIMITEDTODURATIONOFTHE

EXPRESSEDWARRANTYSPECIFIEDABOVE.

WARRANTY EXCLUSIONS:

Thiswarrantydoesnotcoverthefollowing:

• Changesinsurfacefinishesasaresultofnormaluse.Asaheatingappliance,somechangesincolorofinteriorand

exteriorsurfacefinishesmayoccur.Thisisnotaflawandisnotcoveredunderwarranty.

• Damagetoprinted,plated,orenameledsurfacescausedbyfingerprints,accidents,misuse,scratches,melteditems,

orotherexternalsourcesandresiduesleftontheplatedsurfacesfromtheuseofabrasivecleanersorpolishes.

• Repairorreplacementofpartsthataresubjecttonormalwearandtearduringthewarrantyperiod.Theseparts

include:paint,wood,pelletandcoalgaskets,firebricks,grates,flameguides,batteriesandthediscolorationofglass.

• Minorexpansion,contraction,ormovementofcertainpartscausingnoise.Theseconditionsarenormalandcom-

plaintsrelatedtothisnoisearenotcoveredbythiswarranty.

• Damagesresultingfrom:(1)failuretoinstall,operate,ormaintaintheapplianceinaccordancewiththeinstallation

instructions,operatinginstructions,andlistingagentidentificationlabelfurnishedwiththeappliance;(2)failureto

installtheapplianceinaccordancewithlocalbuildingcodes;(3)shippingorimproperhandling;(4)improperopera-

tion,abuse,misuse,continuedoperationwithdamaged,corrodedorfailedcomponents,accident,orimproperly/

incorrectlyperformedrepairs;(5)environmentalconditions,inadequateventilation,negativepressure,ordrafting

causedbytightlysealedconstructions,insufficientmake-upairsupply,orhandlingdevicessuchasexhaustfansor

forcedairfurnacesorothersuchcauses;(6)useoffuelsotherthanthosespecifiedintheoperatinginstructions;(7)

installationoruseofcomponentsnotsuppliedwiththeapplianceoranyothercomponentsnotexpresslyauthorized

andapprovedbyHHT;(8)modificationoftheappliancenotexpresslyauthorizedandapprovedbyHHTinwriting;

and/or(9)interruptionsorfluctuationsofelectricalpowersupplytotheappliance.

• Non-HHTventingcomponents,hearthcomponentsorotheraccessoriesusedinconjunctionwiththeappliance.

• Anypartofapre-existingfireplacesysteminwhichaninsertoradecorativegasapplianceisinstalled.

• HHT’sobligationunderthiswarrantydoesnotextendtotheappliance’scapabilitytoheatthedesiredspace.Informa-

tionisprovidedtoassisttheconsumerandthedealerinselectingtheproperappliancefortheapplication.Consider-

ationmustbegiventoappliancelocationandconfiguration,environmentalconditions,insulationandairtightnessof

thestructure.

B. Limited Lifetime Warranty (continued)

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/146 3-90-04301c

Product Specic and Important Safety Information

A. Appliance Certication E. BTU & Efciency Specications

TheP43FreestandingPelletStovebyHarman®isexempt

from Environmental ProtectionAgency certication under

40CFR60.531bydenition[WoodHeater(A)“AirtoFuel

Ratio].

B. Mobile Home Approved

This appliance is approved for mobile home installations

whennotinstalledinasleepingroomandwhenanoutside

combustionairinletisprovided.

Thestructuralintegrityofthemobilehomeoor,ceiling,and

wallsmustbemaintained.Theappliancemustbeproperly

groundedtotheframeofthemobilehomeanduseonlylisted

pelletvent,Class“PL”connectorpipe.

A Harman® OutsideAir Kit must be installed in a mobile

homeinstallation.

NOTE: Thisinstallationmustconformwithlocalcodes.

Intheabsenceoflocalcodesyoumustcomplywiththe

ASTM E 1509-04, ULC/ORD-C1482-M1990, ULC-S627-

00, (UM) 84-HUD

C. Glass Specications

This appliance is equipped with 5mm mirrored ceramic

glass.Replaceglassonlywith5mmceramicglass.Please

contactyourdealerforreplacementglass.

D. Electrical Rating

115VAC,60Hz,Start4.2Amps,Run2.8Amps

NOTE: Some generator or battery back-up systems may

not be compatible with the micro-processor electronics

on this appliance. Please consult the power supply

manufacturer for compatible systems.

MODEL: P43PelletStove

LABORATORY: OMNITestLaboratories,Inc

REPORT NO. 135-S-23-4,135-S-23b-6.2

TYPE: PelletFueled/SupplementaryFor

ResidentialUse

STANDARD(s): ASTME1509-04,ULC/ORD-

C1482-M1990,ULC-S627-00

Particulate

Emissions Rating:

N/A

*BTU Output: 8,000-43,000/hr

Heating Capacity: upto2,400sq.ft.dependingon

climatezone

Hopper Capacity: 50lbs

Fuel: WoodPelletsorShelledCorn

Shipping Weight: 260lbs

NOTE: Hearth &HomeTechnologies, manufacturer of

thisappliance,reservestherighttoalteritsproducts,their

specicationsand/orpricewithoutnotice.

*BTUoutputwillvary,dependingonthebrandoffuelyou

usein your appliance. ConsultyourHarman® dealer for

bestresults.

WARNING! Risk of Fire! Hearth & Home Technologies

disclaims any responsibility for, and the warranty and agency

listing will be voided by the below actions.

DO NOT:

 • Installoroperatedamagedappliance

 • Modifyappliance

 • Install other than as instructed by Hearth & Home

Technologies

 • Operate the appliance without fully assembling all

components

 • Overre

 • Install any component not approved by Hearth &

Home Technologies

 • InstallpartsorcomponentsnotListedorapproved.

 • Disablesafetyswitches

Improper installation, adjustment, alteration, service or

maintenancecancauseinjuryorpropertydamage.

Forassistanceoradditionalinformation,consultaqualied

installer, service agency or your dealer.

Harman® is a registered trademark of Hearth & Home

Technologies.

THE STRUCTURAL INTEGRITY OF THE

MANUFACTURED HOME FLOOR, WALL, AND

CEILING/ROOF MUST BE MAINTAINED.

DO NOT INSTALL IN SLEEPING ROOM.

WARNING

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/147 3-90-04301c

WARNING! DO NOT operate stove before reading and

understanding operating instructions. Failure to operate

stove according to operating instructions could cause

re or injury.

If you expect that small children or vulnerable adults

may come into contact with this appliance, the following

precautionsarerecommended:

• Installaphysicalbarriersuchas:

 - Adecorativerescreen.

 - Adjustablesafetygate.

• Install a switch lock ora wall/remote control with child

protectionlockoutfeature.

• Keepremotecontrolsoutofreachofchildren.

• Never leave children alone near a hot stove, whether

operatingorcoolingdown.

• TeachchildrentoNEVERtouchthestove.

• Considernotusingthestovewhenchildrenwillbepresent.

Contact your dealer for more information, or visit: www.

hpba.org/safety-information.

Topreventunintendedoperationwhennotusingyourstove

foranextendedperiodoftime(summermonths,vacations,

trips,etc):

• Unplugstovefromreceptacle.

A. Appliance Safety

General Information

B. Clear Space

WARNING! RISK OF FIRE! Do NOT place combustible

objects in front or to the sides of the appliance. High

temperatures may ignite clothing, furniture or draperies.

Mantel:

 Avoid placing candles and other heat-sensitive

objectsonmantelorhearth.Heatmaydamagethese

objects.

NOTICE: Clearances may only be reduced by means

approvedbytheregulatoryauthorityhavingjurisdiction.

WARNING! RISK OF FIRE! Keep combustible materials,

gasoline and other ammable vapors and liquids clear of

appliance.

• Do NOT store ammable materials in the appliance’s

vicinity.

• DoNOT use gasoline, lantern fuel, kerosene, charcoal

lighteruidorsimilarliquidstostartor“freshenup”are

in this heater.

Keep all such liquids well away from the heater while it is in

use as combustible materials may ignite.

HOT SURFACES!

Glassandothersurfacesarehotduring

operationANDcooldown.

Hot glass will cause burns.

• DO NOTtouchglassuntilitiscooled

• NEVERallowchildrentotouchglass

• Keepchildrenaway

• CAREFULLYSUPERVISEchildreninsameroomasstove.

• Alertchildrenandadultstohazardsofhightemperatures.

High temperatures may ignite clothing or other ammable

materials.

• Keep clothing, furniture, draperies and other ammable

materialsaway.

WARNING

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/148 3-90-04301c

Feed limit

Sets the maximum feed

rate

Test

Runs all motors at full

speed for one minute

to check operation.

Afterwards the

control will simulate

a minimum burn with

the combustion blower

remaining on low.

Distribution Blower

speed adjustment

range.

L=low

H=high

Variable speed

anywhere between L

and H; although as the

constant burn. goes up

,sodoestheLandH

scale.

Temp dial

Allowsyoutoadjusttheroomtemperaturesetting,in

RoomTempMode,usingtheouterscalemarkedin

degreesFahrenheit.Italsoallowsyoutoadjustthe

constantburnsetting,whileinConstantburnMode,

using the inner scale marked from 1 to 7.

Mode Selector

Allows you to choose between

RoomTempMode, Constantburn

Mode, or OFF.Also allows you to

vary the distribution blower speed

by turning the knob to the high or

low side of each mode.

Power Light

Indicatespowertothe

control.

Indicatespowertothe

feed motor.

Indicates power to

combustion blower

Status Light

Will be lit in either stove

or room temp mode

when pointer is not

within off position band

except after normal

shut down. Blinks to

indicate errors listed

below.

Indicates power to

distribution blower.

Dealer Diagnostic Port

For dealer maintenance

only. Requires special DDM

monitor supplied to Harman®

Dealersexclusively.

Indicatesigniterison.

Igniter switch

Set to appropriate

Start-Up mode.

C. Control Explanation

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/149 3-90-04301c

Fuel and Fuel Storage

Pellet fuel quality can uctuate from manufacturer to

manufacturer,andevenfrombagtobag.

Hearth&HomeTechnologiesrecommendsusingonlyfuel

thatiscertiedbythePelletFuelsInstitute(PFI).

FuelMaterial

• Madefromsawdustand/orotherwoodby-products

• Shelledeldcorn(whenmixedwithwoodpellets)

• Sourcematerialtypicallydeterminesashcontent

HigherAshContentMaterial

• Hardwoodswithhighmineralcontent

• Barkandleavesassourcematerial

• “Standard”gradepellets,cornandotherbiomass

LowerAshContentMaterial

• Softwood;pine,r,etc.

• Materialswithlowermineralcontent

• “Premium”gradepellets

Shelledeldcorn

• Mustbe15%moisturecontentorless

• Mustbecleanandfreeofdebris

• Mustbemixedwithwoodpellets.(Upto50%)

• Stalk parts, excessive nes and cob remnants may

causefeedsystemjamsorblockage

CAUTION! Do not burn fuel that contains an additive;

(such as soybean oil)

• Maycausehopperre

• Damagetoproductmayresult

Read the list of ingredients on the packaging. If you are

buyingeldcorn,theonlyingredientlistedshouldbeeld

corn.

WARNING! Risk of Chemical Poisoning!

DoNOTburntreatedseedcorn

• Chemicalpesticidesareharmfulorfatalifswallowed

• Burningtreatedseedcornwillvoidtheproductwarranty

Clinkers

Minerals and other non-combustible materials, like sand,

willturnintoahardglass-likesubstancewhenheated.

Treesfromdifferentareaswillvaryinmineralcontent.For

this reason, some fuels will produce more clinkers than

others.

Moisture

Always burn dry fuel. Burning fuel with high moisture

contenttakesenergytodryandtendstocooltheappliance

thus,robbingheatfromyourhome.Damppelletfuelcould

turnbackintosawdustwhichdoesnotowproperlythrough

thefeedsystem.

NOTICE

Hearth&HomeTechnologiesisnotresponsibleforstove

performanceorextramaintenancerequiredasaresultof

usingfuelwithhigherashormineralcontent.

Size

• Pellets are either 1/4 inch or 5/16 inch (6-8mm) in

diameter

• Lengthshouldbenomorethan1-1/2inches(38mm)

• Pellet length can vary from lot to lot from the same

manufacturer.

Performance

• Higherashcontentrequiresmorefrequentmaintenance.

• “Premium” grade pellets will produce the highest heat

output.

• Burning pellets longer than 1-1/2 inches (38mm) can

causeinconsistentfeedingand/orignition.

Werecommendthatyoubuyfuelinmulti-tonlotswhenever

possible. However, we do recommend trying different

brands prior to purchasing multi-ton lots, to ensure your

satisfaction.

CAUTION! Tested and approved for use with wood pellets

andamixtureofshelledeldcornandwoodpelletsONLY.

Burningofanyotherfuelwillvoidyourwarranty.

Whenchangingfromwoodpelletstoacorn/pelletmixture,

theFeed limit will likelyneedadjustedto a lower setting.

When under maximum demand, ensure there is no

unburnedfuelbeingpushedintotheashpan.

Storage

• Woodpelletsshouldbeleftintheiroriginalsealedbag

untilreadytouse,topreventmoisture.

• Shelledcornshouldbestoredinatightlysealedcontainer

topreventmoistureandtodeterpests

• Donotstorefuelwithinthespeciedclearanceareas,or

inalocationthatwillinterferewithroutinecleaningand

maintenanceprocedures.

D. Fuel Specications

CAUTION

Tested and approved for use with wood pellets and a

mixture of shelled eld corn and wood pellets ONLY.

Burningofanyotherfuelwillvoidyourwarranty.

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1410 3-90-04301c

E. Before Your First Fire

1. Makesureyourappliancehasbeenproperlyinstalledand

thatallsafetyrequirementshavebeenmet.Payparticular

attentiontothereprotectionandventinginstructions.

2. Doublecheckthattheashpanandreboxareempty!

3. Closethefrontdoor.

FireHazard.

Keepcombustiblematerials,gasoline

andotherammablevaporsandliquids

clearofappliance.

E. General Operating Information

1. Room Sensor Calls For Heat

Theapplianceislikemostmodernfurnaces;whentheroom

sensorcallsforheat,yourappliancewill automaticallylight

anddeliverheat.

Whentheroomisuptotemperatureandtheroomsensoris

satised,theappliancewillshutdown.

2. Heat Output Controls

The appliance will turn on and off as the roomsensor

demands.Whentheroomsensorcallsforheat,theappliance

willalwaysstartuponHigh.Afterburningapproximately7-10

minutes,theappliancewillthenburnattherateatwhichit

wasoriginallyset.Iftheapplianceissetatoneofthelower

settings,itwillrunquieterbuttakelongertoheatupanarea

thanifitweresetatahigherburnrate.

Regardlessoftheburnrate,whentheareaiswarmenough

tosatisfytheroomsensor,theappliancewillshutoff.

WARNING

• DoNOTstoreammablematerialsintheappliance’svicinity.

• NEVER USE GASOLINE, GASOLINE-TYPE LANTERN

FUEL, KEROSENE, CHARCOALLIGHTER FLUID, OR

SIMILARLIQUIDSTOSTARTOR“FRESHENUP”AFIRE

INTHISHEATER.KEEPALLSUCHLIQUIDSWELLAWAY

FROMTHEHEATERWHILEITISINUSE.

• DONOTBURNGARBAGEORFLAMMABLEFLUIDSSUCH

ASGASOLINE,NAPHTHAORENGINEOIL.

• DONOTUSECHEMICALSOFFLUIDSTOSTARTTHE

FIRE.

• Combustiblematerialsmayignite.

Figure 3.1

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1411 3-90-04301c

B. Fire Characteristics

Aproperlyadjustedrehasamediumactiveamepattern

that extends out of the burn pot approximately 6 inches

(152mm).

C. Feed Rate Adjustment Instructions

Thefeedadjustmentcontrolisfactorysetat#4,andshould

beadequateformostfuels.



However,iftheflameheightistoohighortoolow,youwill

needtoadjustthefeedrate.Waituntiltheappliancehasbeen

burningfor15minutesbeforemakingyouradjustmentsand

llow15minutesforfeedadjustmenttotakeeffect.

A. Starting Your First Fire

1. Aroom sensor is requiredfor proper operation of this

appliancein “RoomTemp” mode. Atthis time, ll the

hopperwith pellets, insure the control is setto “OFF”.

Figure4.2.Plugthepowercordintoaproperlygrounded,

nearbyoutlet.

2.Oncepowerispresent,theunititwillrunthroughaquick

diagnosticstesttoinsurethecontrolisoperatingproperly.

Thisisnormal.

3. Foryourrstreitmaybenecessarytopurgetheauger

systemby putting the feed limit knob to “Test”priorto

startingtheunit.Figure4.3.Thisinsuresthatplentyof

fuelenterstheburnpotforproperignition.

4. Fliptoggleswitchtodesiredmode“autoormanual”.Figure

4.4.Setfeedlimitknobtodesiredsettingandturnmode

dialto“RoomTemp”or“Constantburn”Figure4.5.Note:

Feedrateof#4isagoodstartingpoint.Adjustmentsmay

needtobemadedependingonfuelqualityand/orheat

outputdesired.

5.

Thefuelfeedsystemandtheignitershould

now

beon.

6. Oncetheappliancehasignited,letitburnforapproximately

7-10minutes.Afterthistime,theigniterlightshouldturn

offandtheunitshouldbegintooperateperthesettings

atthecontrol.

Figure 4.5

Odorsandvaporsreleasedduringinitialoperation.

• Curingofhightemperaturepaint.

• Openwindowsforaircirculation.

Odorsmaybeirritatingtosensitiveindividuals.

Figure 4.2 Figure 4.3

Figure 4.4

Operating Instructions

CAUTION

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1412 3-90-04301c

D. Ignition Cycles

1. Atthebeginningofeachignitioncycle,itisnormaltosee

somesmokeintherebox.Thesmokewillstoponcethe

restarts.

2. Thedistributionblowerwillautomaticallyturnonafteryour

appliancehasreachedthesettemperature.

Thisblowertransfersheatfromyourapplianceintothe

room,andwillcontinuetorunin“constantburn”mode

atthesetspeedyouhavethecontrolknobat.In“room

temp” mode however, the blower will turn on and off

inaccordancetowhattemperaturetheroomsensoris

reading.Whentheroomsensorissatisedtheblowerwill

shutdownuntiltheroomsensorseesademandforheat.

3. Occasionallytheappliancemayrunoutoffuelandshut

itselfdown.Whenthishappens,theunitwillneedtobe

turnedtotheoffpositionandrestarted.

Ifneeded,followtheinstructionsinSectionA “Starting

YourFirstFire”.

FireRisk

DoNOToperateappliance:

• Withappliancedooropen.

• Burnpotooropen.

• Cleaningslideplatesopen.

DoNOTstorefuel:

• Closerthanrequiredclearancestocombustibles

toappliance

• Withinspace required for loading or ash

removal.

WARNING

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1413 3-90-04301c

Igniter Switch to "AUTO" (up position)

Makesuretheunitispluggedintoaproperlygrounded,120

VAC,60Hzelectricalsource.Thepowerlightshouldbethe

onlylightlit.

Note: Be sure there is no fuel or other combustibles in

the ash pan prior to lighting.

1. TurnModeSelectorto"OFF".

2. Fillhopperwithpellets.

3. Cleanburnpotwithscraper,ifnecessary.

4. Ifstartingafteranemptyhopper,turnFeedLimitto"TEST"

(forone60secondcycle).Thiswillowpelletsintothe

augertubeandalsoallowyoutocheckthemotorsfor

operation.

NOTE: The auger motor will not operate with the view

door open.

5. TurnFeedLimitto#4.

6. FliptheIgniterSwitchupintothe"AUTO"position.

7. TurntheTemperatureDialtothedesiredroomtemperature.

8. TurnModeSelectortoRoomTemperatureorConstant

burnerature.

9. Fillhopperwithpelletsandremoveashesasrequired.

Keepthe hopper lid and rebox doors closedwhile in

operation.Maintaindoorsealsingoodcondition.Failure

todosowillaffectoperationoftheapplianceandmay

permitescapeofsmokeorgasesintothelivingspace.

1. Fines are small pieces of broken pellets (sawdust). Fines

donotoweasilyandoftenbuilduponthehopperfunnel

bottomangles.Thesenescanbepushedintothefeeder

openingandthenllthehopperwithpellets.Asthesystem

works, they will be burned.

2. The "TEST" cycle will operate the feed motor for exactly

one minute. Turning to "TEST" again and again may load

too much fuel into the burn pot causing excessive smoke

on start-up.

3. Thereboxlowpressureswitchwillnotallowtheauger

motor or the igniter element to operate if the view door is

open.

4. AdjustFeedRate.Ifthisisyourrstreoryouaretrying

different pellets, set the feed limit to #4, Figure 4.6 This

is a conservative number and will probably need to be

increased. After you know a feed rate setting that works

well, use that setting. Remember, if your feed rate is too

high you may waste fuel.

5. This is usually a weekly maintenance procedure. Cleaning

the burn pot with the scraper with a small amount of new

fuel in the bottom is not a problem. First, scrape the ashes

off the front of the burn pot into the ash pan. Then scrape

the holed surface downward into the burn pot. When the

stove feeds, these scrapings will be pushed out by the

feeder.

6. The ash pan can hold the ashes from approximately 1 ton

of premium fuel. This means the ashes will only need to

be emptied a few times a year.

7. Setting the feed limit # for maximum burn: With the unit

burningin"AUTO",turnto"StoveMode"andputthefan

on"H".SettheTemperatureDialto#7.Allowtheunitto

burn for about 30 minutes and check ash on front of burn

pot.Figure4.7.Iftheashlineislargerthan1",turnthe

feed limit from #4 to #5. Allow another 30 minutes of burn

timeandcheckagain.If,at#6setting,a1"orlessashbed

is not obtainable, it is not a problem. The 1" ash bed is

only at maximum burn rate and during normal operation,

the ash bed will be larger.

Figure 4.6

SeeNote7

Figure 4.7

E. Automatic Ignition

BURNING GARBAGE, USE OF IMPROPER FUELS,

FIRE STARTERS OR ALTERING THE STOVE FOR

HIGHER HEAT OUTPUT MAY CAUSE DAMAGE TO

THE STOVE AND COULD RESULT IN A HOUSE FIRE.

USE ONLY APPROVED FUELS AND FOLLOW ONLY

THESE OPERATION GUIDELINES.

WARNING

NEVER USE GASOLINE, GASOLINE-TYPE LANTERN

FUEL, KEROSENE, CHARCOAL LIGHTER FLUID, OR

SIMILAR LIQUIDS TO START OR 'FRESHEN UP' A FIRE

IN THIS HEATER. KEEP ALL SUCH LIQUIDS WELL

AWAY FROM THE HEATER, WHILE IN USE.

WARNING

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1414 3-90-04301c

TheP43PelletStoveismorethanjustautomaticignition,it

isalsoautomatictemperaturecontrol.Theautomaticsystem

willallowtheresizetobeadjustedtomatchtheheating

needsandevenputthereoutifnecessary.Ifheatisneeded

afterthereisout,theP43PelletStovewillautomatically

re-igniteandadjusttheresizetomatchtheheatingneed.

Thetotallyautomaticroomsensormodeisrecommended

becauseofitsefciency.Theunitcanbeswitchedbetween

"AUTO"and"MANUAL"atanytimeduringoperation.

Igniter switch to “AUTO”

Room Temperature Mode

In“RoomTempMode”heatoutputiscontrolledautomatically

bytheRoomSensingProbe.WhentheRoomSensingProbe

callsforheat,thestovewillincreaseoutput.WhentheRoom

SensingProbeisgettingclosetothesettemperature,the

stovewillbegintoleveloffoutputandkeepthereburning

atjusttherighttemperaturetomaintainthatsetting.

Highoutput is determined by the feed rate setting.This

setting,generallyon#4,canbeincreasedifhigherburnrates

arenecessary(Figure4.6).Theunit’smaximumburnrate

shouldnotcreatelessthan1”ofashontheburnpotfront

edge(Figure4.7).Overfeedingisnotasafetyconcern,but

fuelmaybewastedifunburnedpelletsfallintotheashpan.

In“RoomTempMode”aconstantfuelconsumptionrateis

sacricedforexactroomtemperature.Therefore,asitgets

coldermorepelletswillbeburnedautomatically.

Thedistribution blower speed will vary according to the

positionofthemodeselectorpointer,andresize.

Igniter switch to “AUTO”

Constant burn Mode

Thisallowsforautomaticignitionuponstart-uponly.Theunit

canthenbesetatanydesiredsetting.Theheatoutputand

fuelconsumption willremainconstantregardless of room

temperature.Theunit’smaximumfeedrateshouldnotcreate

lessthan1”ofashontheburnpotfrontedge.Figure4.7.

Theunit’slowburnormaintenancesettingisaslowasitwill

go.Itwillnotgooutunlessitrunsoutoffueloristurnedoff.

Shut-Down Procedure

To kill there or stopburning the stove, turn the Mode

Selectorto“OFF”.Thiswillcausetheretodiminishand

burnout.Whenthereburnsoutandthestovecoolsdown

everythingwillstop.

Ifyoupulltheplugtoshutdownthestove,allmotorswillstop.

Thismaycauseincompletecombustionandsmokeinthe

rebox.Iftheloaddoorisopened,thesmokemayescape.

Thebestwaytoshutdownthestoveissimplyletitrunout

ofpellets,thenthestovewillshutdownautomatically.

Room Temperature Mode: This setting will produce a room temperature

of 70 degrees with the distribution blower at medium speed.

This setting will produce medium heat with the distribution

blower on "low".

This setting will produce continuous maximum heat output

with the distribution blower at full speed.

Constant burn Mode

E. Automatic Ignition (Continued)

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1415 3-90-04301c

SeeNote7

Igniter Switch to “MANUAL” (down position) Make

suretheunitispluggedintoa120VAC,60Hzelectrical

source.Thepowerlightshouldbetheonlylightlit.

NOTE: Be sure there is no fuel or other combustibles in

the ash pan prior to lighting.

1.TurnFeedlimittodesiredfeedrate.No.4isgoodformost

pellets.

2.Turnthe MODESELECTORto “OFF”and then to the

desiredmode. Thiswill reset control and start the

combustionmotor.

3.TurntheTEMPERATUREDIALtothedesiredsetting.

4.Cleanburnpotwithscraperifnecessary.

5.Fillburnpotwithpellets,onlylevelwithfrontedge.(Do

NotOverFill).

6.Addstartinggelontopofthepellets.Stirgelintopellets

forfastlighting.

7.Lightstarting gel with a match, and close the door.

Operationwill begin when there reaches the proper

temperature.

8.Fillhopperwithpelletsandremoveashesasrequired.

Storefuelinadryarea,awayfromallignitionsourcesand

outsidealllimits of the stove's clearance requirements to

combustibles.Donotstorethefuelwereitinterfereswith

therefuelingofthestoveoremptyingofashes.Donotstore

anyashesremovedfrom thestovenearthefuel orother

combustiblematerials.

STARTER

GEL

1. Fines are small pieces of broken pellets (sawdust). Fines do

notoweasilyandoftenbuilduponthehopperfunnelbottom

angles.Thesenescanbepushedintothefeederopeningand

thenllthehopperwithpellets.Asthesystemworks,theywill

be burned.

2. The "TEST" cycle will operate the feeder motor for exactly one

minute. Turning to "TEST" again and again may load too much

fuel into the burn pot causing excessive smoke on start-up.

3. The low pressure switch will not allow the feed motor to operate

if the viewing door is open.

4.AdjustFeedRate.Ifthisisyourrstreoryouaretryingdifferent

pellets, set the feed limit to #4, Figure 4.8. This is a conservative

number and will probably need to be increased. After you know

a feed rate setting that works well, use that setting. Remember,

if your feed rate is too high you may waste fuel.

5. Setting the feed limit # for maximum burn: With the unit

burning in "AUTO",turnto"StoveMode" and put the fan on

"H".SettheTemperatureDialto#7.Allowtheunittoburnfor

about 30 minutes and check ash on front of burn pot. Figure

4.9.Iftheashlineislargerthan1",turnthefeedlimitfrom#4

to #5. Allow another 30 minutes of burn time and check again.

If,at#6setting,a1"orlessashbedisnotobtainable,itisnot

a problem. The 1" ash bed is only at maximum burn rate and

during normal operation, the ash bed will be larger.

F. Manual Ignition

Figure 4.8

Figure 4.9

BURNING GARBAGE, USE OF IMPROPER FUELS,

FIRE STARTERS OR ALTERING THE STOVE FOR

HIGHER HEAT OUTPUT MAY CAUSE DAMAGE TO

THE STOVE AND COULD RESULT IN A HOUSE FIRE.

USE ONLY APPROVED FUELS AND FOLLOW ONLY

THESE OPERATION GUIDELINES.

WARNING

NEVER USE GASOLINE, GASOLINE-TYPE LANTERN

FUEL, KEROSENE, CHARCOAL LIGHTER FLUID, OR

SIMILAR LIQUIDS TO START OR 'FRESHEN UP' A FIRE

IN THIS HEATER. KEEP ALL SUCH LIQUIDS WELL

AWAY FROM THE HEATER, WHILE IN USE.

WARNING

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1416 3-90-04301c

F. Manual Ignition (Continued)

TheP43PelletStoveiscapableofmanualoperation.This

alsoallowstheoperatortomanuallycontroloperationduring

anemergency(i.e.igniterfailure,whenusinga512Hbattery

backup,orwhenusingcertaingenerators.)

Theunitcanbeswitchedbetween"AUTO"and"MANUAL"

atanytimeduringoperation.

Igniter Switch to "MANUAL"

Room Temperature Mode

Therewillhavetobelitwithstartinggelandamatch,or

started automatically,see "Automatic Operation". Turnto

"Manual"positiononcethestartcyclebegins.

Thedifferencebetween"AUTO"RoomTemperatureMode

and"Manual"RoomTemperatureModeisthattherewillnot

gooutastheroomtemperaturegoesabovethecontrolboard

setting.Theunitcanonlygotolowburnandwillremainthere

untilitrunsoutoffueloruntilmoreheatisneededandthe

feedrateincreases.Feedrateadjustmentsanddialsettings

arethesameas"AUTO"settings.

Igniter Switch to "MANUAL"

Constant burn Mode

Theadvantageofthismodeistoallowtheoperatortohave

alargeviewingrewithoutblowingextraheatintotheroom.

Duringoperation,withthetemperaturedialsetat#4orless,

thedistributionfanwillnotoperate.A#4onthetemperature

dialanda#4onthefeedlimitisapproximately80%output.

Itisnotnecessarytooperatethedistributionblowerbelow

thispoint.Therefore, there can be ahigher feed rate (a

largerviewingre)withoutanexcessofhotairblowinginto

theroom.

AnexampleofwhentousetheManualConstantburnMode

isifyouwanttowatchalargereandtheroomisalreadyup

totemperature.TheConstantburnModeallowsyoutohave

alargerreandalowersoundlevel,withoutthedistribution

blower.

NOTE: During the use of this mode, if you keep increasing

the temperature dial setting to increase the re size, the

distribution blower will automatically come on when the

ESP Temperature reaches 350

F, or 81% output.

NOTE: When starting the unit in the "AUTO" mode

and switching to "MANUAL", you may switch at any

time. Once an ignition cycle is started, it will continue

regardless of mode.

Room Temperature Mode: This setting will produce a room temperature

of 70 degrees with the distribution blower at medium speed.

Thissettingwillproducealargeviewingrewithouta

distribution blower operating.

Manual Constant burn Mode

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1417 3-90-04301c

Types of Fuel

Thetypeoffuelyouareburningwilldictatehowoftenyouhave

tocleanyourburnpot.

Ifthefuelyouareburninghasahighdirtorashcontentoryou

areburningshelledeldcorn,itmaybenecessarytocleanthe

burnpotmorethanonceaday.

Dirtyfuelwillcauseclinkerstoformintheburnpot.Aclinkeris

formedwhendirt,ashoranon-burnablesubstanceisheated

to2000°F(1093°C)andbecomesglass-like.

B. Quick Reference Maintenance Chart

Follow the detailed instructions found in this

section for each step listed in the chart below.

Cleaning or Inspection

Frequency Daily Weekly Monthly Yearly

AshPan Every5bagsoffueldepending

onthefueltypeorashbuild-up

OR X

AshRemovalfromFirebox Every5bagsormore

frequentlydependingonthe

fueltypeorashbuild-up

OR X

HeatExchanger Every1tonoffuel OR X

Blower,Combustion(Exhaust) Morefrequentlydependingon

thefueltype

OR  X

Blower,Distribution Every25bagsormore

frequentlydependingonthe

fueltype

OR X

DoorGasketInspection Priortoheatingseason OR X

ExhaustPath Morefrequentlydependingon

ashbuild-up

OR X

Firebox-PrepareforNon-BurnSeason Atendofheatingseason OR X

Burnpot-Burningpellets-hardwood Every3bags OR X

Burnpot-Burningpellets-softwood Every5bags OR X

Glass Whenclearviewofburnpot

becomesobscure

OR X

Hopper/HopperLidGasket Every50bagsoffuelorwhen

changingfueltypes

OR X

VentingSystem Morefrequentlydependingon

thefueltype

OR X

NOTICE:Thesearerecommendations.Cleanmorefrequentlyifyouencounterheavybuild-upofashattherecommended

intervaloryouseesootcomingfromthevent.Not properly cleaning your appliance on a regular basis will void your

warranty.

Maintenance & Service

Shock and Smoke Hazard

• Turnunittotheoffposition,letappliance

completelycoolandcombustionblowermust

beoff.Nowyoucanunplugappliancebefore

servicing.

• Smokespillageintoroomcanoccurifappliance

isnotcoolbeforeunplugging.

• Riskofshockifappliancenotunpluggedbefore

servicingappliance.

A. Proper Shutdown Procedure

C. General Maintenance

Whenproperlymaintained,yourstovewillgiveyoumany

yearsoftrouble-freeservice.Contact your dealertoanswer

questionsregardingproperoperation,trouble-shootingand

serviceforyourappliance.Visitwww.harmanstoves.comto

ndadealer.Werecommendannualservicebyaqualied

servicetechnician.

CAUTION

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1418 3-90-04301c

Theglassusedinyourstoveismanufacturedtoexactstandardstowithstandthehighheatofthere,butlikeallglass,it

mustbetreatedwithcommonsenseandcare.Neverabusetheglassbyslammingthedoorshutorstrikingtheglasswith

aheavyobject.Iftheglassisbrokenordamaged,donotoperatethestoveuntilithasbeenreplaced.

Glass - Replacement

Ifthestove’sglassiscrackedorbroken,youmustreplaceitbeforeoperatingyourstove.Removepiecescarefully.Replace

glassonlywithHarman®replacementglass;do not use substitutes.

Carefullyremovedamagedglass,gasketmaterial,andholddownclips(setaside).

Installtheselfadhesive1/4"”gasketmaterialaroundthefrontfaceoftheglass.Settheglasspanelandgasketgentlyonto

thedoor.Installtheholddownclipsandtightenwithbolts.

Glass - Cleaning

Sometimesitwillbenecessarytocleanaccumulatedashfromtheglasssurface;allowingthisashtoremainontheglass

forlongperiodscanresultin“etching”duetotheacidityoftheash.Nevercleantheglasswhileitishot,anddo not use

abrasivesubstances.Washthesurfacewithcoolwater,andrinsethoroughly.Youmaywishtouseanon-abrasivecleaner

specicallydesignedforuseonstoveglass.Inanycase,drythoroughlybeforerelightingyourstove.

Glass Gasket

Replace glass only with high temperature

mirrored ceramic glass.

Inspectdoorgasketduringcleaning

and inspection

D. Glass Maintenance

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1419 3-90-04301c

Wheneveraddingfuel,taketheopportunitytocleantheburn

pot.(Weekly at minimum)

• Scrapethetopholedsurfaceandsidesoftheburnpot

downto auger tube Figure5.1. It is notnecessary to

completelyremove all material fromthe burn pot.The

excesswillbepushedoutduringthenextuse.

Monthly, or after each ton of fuel burned:

• Loosenthe(2)wingthumbscrewsonthelowerfrontangle

oftheburnpot.Figure5.2

• Liftofftheclean-outcovertoopenthebottomclean-out

chamber.Figure5.3

• Cleanashbuildupfrominsidethechamberwhilecover

isoff.Usethescrapertotaponthetopfrontedgeofthe

burnpot.Thiswill help knock pieces of ash, loosened

bythescrapingprocess,downthroughtheholes.Italso

helpsknockscaleoffoftheigniterelement.

Figure 5.3

Theigniterismadetoberemovableforservicebyinsulated

male/femalewireconnectors.Theseconnectionsbetween

thehotleads(thewiresinsidetheburnpot)andthecold

leads(thewiresfromthecontrolboard)arealwayspulled

totheinsiderearofthefeederbody. (Not coiled inside the

burn pot.)

Itisveryimportantthattheseconnectionsaretotheinside

rearofthefeederbody.Also,theextrawireoftheigniterwire

serviceloopmustbepulledoutthroughtherearofthefeeder

andtiedupsothatitwillnotbedamagedbyanymovingparts.

Disconnect the power to the unit before removing

cover.

Note: The hot lead/cold lead connection must always

be pulled to the rear of the feeder body before

operation.

Viewed from below through the ash pan opening.

Igniterhotleadwires

(High temperature)

Burnpotigniter

E. Burnpot Maintenance

Figure 5.1

Figure 5.2

Figure 5.3

Wing Thumb Screws

Use caution when cleaning burn pot clean-out

chamber. Do not damage the high temperature igniter

wires.

WARNING

DANGER

Harman® • P43 Owner’s Manual_R24 • 2008 -___ • 04/1420 3-90-04301c

Monthly Cleaning- continued:

Thereisacombustionintakecoverlocatedbehindtheash

panthatmustberemovedtoproperlycleanthecombustion

blower fan blade. Figure 5.4. In order to remove the

combustionintake cover you must pullup on the intake

retainer.Figure5.5.This will allow the combustion intake

cover to be removed.To remove the combustion intake

coverpulltowardsthefrontoftheunitwhileslidingtothe

right.Figure5.6.

Nowthatthecombustionintakecoverisremovedyoucan

remove any flyash or debris that has collected around

combustionblowerfanbladeandareasaroundit.

The exhaust passage may need cleaned as well. Keep

inmindtheESPSensorislocatedjustinsidetheexhaust

passageFigure5.7.BesurenottodamagetheESPSensor

whilecleaningthisarea.

Figure 5.4

IntakeRetainer

CombustionIntakeCover

F. Combustion Blower Chamber

Figure 5.5

PulluponIntakeRetainer

Figure 5.6

Pullandslidetotheright

ESPSensor

Figure 5.7

ExhaustPassage

Page is loading ...

Harman P43 Owner's manual

Brand: Harman

Model: P43

Category: Stoves

Type: Owner's manual

This manual is also suitable for

Download PDF

report

Harman P43 Owner's manual

This manual is also suitable for

Harman P43 Owner's manual

Related papers

Other documents