Lacanche UL Beaune/Bussy Owner's manual

LG 962 G/ E/ CT

BEAUNE

BUSSY

• Do not store or use gasoline or other vapors and liquids in the vicinity of this or any other

appliance.

• WHAT TO DO IF YOU SMELL GAS.

• Do not try to light any appliance.

• Do not touch any electrical switch.

• Do not use any phone in your building.

• Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

• If you cannot reach your gas supplier, call the department.

• Installation and service must be performed by a installer, service agency or the gas

supplier.

WARNING : If the information in this manual is not followed exactly, a or

explosion may result causing property damage, personal injury or death.

WARNING :

THIS RANGE CAN TIP

INJURY TO PERSONS COULD RESULT

INSTALL ANTI-TIP DEVICE PACKED WITH RANGE

SEE INSTALLATION INSTRUCTIONS

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 1/42

Lacanche ranges ordered after May 1st, 2015, have the option to be manufactured with a new

minimum chassis height of 36 5/8’’ (930mm) – as well as the default range height of 35 3/8’’

(900mm). Please make note, as this change may impact necessary clearance allowances to

combustible surfaces above the cooktop surface in certain installations requiring

permit/occupancy inspections.

TECHNICALDATASHEETS,MEASUREMENTSANDDIMENSIONS ————————————3

INSTALLER’SMANUAL7

CABINETPREPARATION———————————————————————————————9

GASCONNECTION—————————————————————————————————10

OPENINGANDREFITTINGTHEHOB —————————————————————————11

CHANGEOFGAZ ——————————————————12

ELECTRICCONNECTION ——————————————————————————————18

INSTALLATION ———————————————————————————————————19

SERVICEINSTRUCTIONS ——————————————————————————————20

ELECTRICCIRCUITDIAGRAMS ———————————————————————————21

GASLINE——————————————————————————————————————24

USER’SMANUAL27

SAFETYINSTRUCTIONS———————————————————————————————29

GASSURFACEBURNERS ——————————————————————————————31

BEFOREUSINGOVENS———————————————————————————————33

GASOVEN —————————————————————————————————————35

ELECTRICOVEN ——————————————————————————————————37

MULTIFUNCTIONELECTRICOVENVERTICAL ————————————————————39

CLEANINGANDMAINTENANCE ———————————————————————————41

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 2/42

773.5 mm* - 30 4/9

”

719 mm* - 28 3/10

”

650 mm* - 25 4/7

”

35 mm* - 1 3/8

”

930 mm* - 36 5/8

”

70 mm* - 2 3/4 ”

70 mm* - 2 3/4

”

1070 mm* - 42 1/8 ”

959 mm* - 37 3/4 ”

790 mm* - 31 1/8

”

300 mm* - 11 3/4

”

899 mm* - 35 2/5

”

300 mm* - 11 3/4

”

930 mm* - 36 5/8

”

523 mm* - 20 3/5

”

BUSSY

TECHNICAL DATA SHEETS, MEASUREMENTS

AND DIMENSIONS

* The range Height is adjustable : 930 mm-36 5/8 ’’ to 946 mm-37 1/4 ’’

790 mm* - 31 1/8 ”

300 mm* - 11 3/4”

899 mm* - 35 2/5”

300 mm* - 11 3/4”

930 mm* - 36 5/8”

773.5 mm* - 30 4/9”

719 mm* - 28 3/10”

650 mm* - 25 4/7”

35 mm* - 1 3/8

”

930 mm* - 36 5/8 ”

70 mm* - 2 3/4”

70 mm* - 2 3/4 ”

1070 mm* - 42 1/8 ”

959 mm* - 37 3/4 ”

523 mm* - 20 3/5”

BEAUNE

Gas connection :Tube  NPT, 1/2” i.d. gas thread, on male

coupling

Electric connection, on terminal block at the rear of the

appliance - 240v, 30A, 4 Wire

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 3/42

6-burner cook’s stove, 2 ovens

-6burnerofdifferentsizeandpowerindividually

controlledbyasafetyvalve

-Electricalignition.

-TRADITION»modelequippedwitha385x510

mm(155/32’’x205/64’’)heatingplate.

180 200

405

Désignation Burner diameter

Intensive Ø 90 mm

Fast Ø 72 mm

Semi fast Ø 55 mm

Appliance Width Depth Heightmm/’’ WeightGross/Net-Kg/lb

LG 1052 G 1130mm/44.5’’ 760mm/29.9’’ 1050mm/41.3’’ 120kg/108kg–267/240lb

BEAUNE

BUSSY

180 200

405

TECHNICAL DATA SHEETS, MEASUREMENTS

AND DIMENSIONS

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 4/42

INSTALLER’S MANUAL

Gas oven :

►Enamelledsheetmetal.

►DimensionsLxlxh:400mm(15.7’’)x460mm(18.1’’)x305mm(12’’).

►4shelflevelwith58mmspacing,55liters/1,94ft3

►CHeatingprovidedbythermostaticallycontrolledburner,thermocouplesafetycut-outs.

►Electricalignition.

Static electric oven :

►Enamelledsheetmetal.

►DimensionsLxlxh:400mm(15.7’’)x460mm(18.1’’)x305mm(12’’).

►Thermostaticallycontrolledroofandbaseheatingelements,safetycut-outbysafetythermostat.

Rating : 2700 W – Power supply : 240 VAC 60Hz.

Multifunction electric oven vertical :

►Enamelledsheetmetal.

►Ovenwithchoiceoftwomodesoffunctioningbyselector.

►DimensionsLxlxh:325mm(12.7’’)x450(17.7’’)mmx410mm(16.1’’);59litres/2.08ft3,3shelflevels

with70mmspacing.

►Thisisfittedwithanelectricgrillwitharatingof2100W.

Function static electric oven :

Theheatingelementsconsistofa1500Welementatthebaseandaperipheral700W

elementintheroofwhichoperatesimultaneously.

Thermostaticallycontrolledroofandbaseheatingelements,safetythermostat.

Power : 2200 W – Supply : 230 V 1N~ 50 Hz/ 400 V 3N~ 50 Hz

Function oven ventilated :

Theovenisheatedbyacircular2650Welement.

Thermostaticallycontrolledroofandbaseheatingelements,safetythermostat.

Power : 2650 W – Supply : 230 V 1N~ 50 Hz/ 400 V 3N~ 50 Hz

Accessories :

Oven:Onedriptray,oneshelf,onepastrytrayperoven.

Pressures and hourly consumption :

Appliancegassupplyingcanbeswitched

PRESSURE 6’’ WC 10’’ WC

GAS Natural gas L.P. Propane

Burner Btu / hr Btu / hr

Oven 13500 11000

Intensive(I) 15000 13000

Fast(F) 11000 10000

Semifast(SF) 5000 5000

Directives :

Gasappliances:2009/142/CEE

LowVoltage:2006/95/CEE

CEM:2004/108/CEE

TECHNICAL DATA SHEETS, MEASUREMENTS

AND DIMENSIONS

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 5/42

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 6/42

"BEAUNE - BUSSY"

INSTALLER’S MANUAL

Appliancesmustbeinstalledinaworkmanlikemannerinaccordancewiththeinstructionsinthismanual

andlocallyapplicableregulations.

This manual will be handed over to the user after installation.

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 7/42

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 8/42

INSTALLER’S MANUAL

CABINET PREPARATION

BEAUNE/ BUSSY :

A B C D E F G H I J K L M N O

mm 914 330 457 930 150 230 175 395 20 60 765 865 905 51 660

’’ 36 13 18 36 5 15/16 91/16 67/815 9/16

13/16 23/830 1/834 1/16 35 5/8 2 26

B

A

D

K

G

I

C

J

E

F

H

L

M

N

Gas

connecon on range

Electrical

connec

O

Ø The range is a free standing unit. If the unit is to be placed next to cabinets, the clearances

shown in Figure 1 are required.

Ø The range cooktop surface must be no lower than the adjacent base countertop surface.

Ø Min clearances to combustibles :

Ø 0’’ (0 mm) from rear (with spacer installed).

Ø 0’’ (0 mm) from sides below countertop surface height.

Ø 2’’ (51 mm) from sides above countertop surface height.

Ø Cabinets 13’’ (330 mm) deep may be installed above the range at least 30’’ above the plane

of the cooking surface.

Use range only with factory supplied legs.

1

IMPORTANT

►Recommended to be installed under an exhaust hood.

►

Do not install this unit near combustible walls, partitions, pieces of furniture or

decorative material unless these are covered with adequate thermal insulation of the

noncombustible type.

Make sure the resulting installation meets fire regulations.

THE APPLIANCE MUST BE INSTALLED IN ACCORDANCE WITH THE LOCAL CODES

OR National Fuel Gas Code, ANSI Z223.1 or latest edition.

Manual shut-off valve should be installed in an accessible location in the gas piping

external to the appliance for the purpose of turning on or shutting off gas to the

appliance.

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 9/42

5

8

/

on on range

►

In the state of Massachusetts, the appliance must be installed by a licensed

plumber or gas fitter.

Place electrical and gas

stub-outs in this area

INSTALLER’S MANUAL

Ensurethattheovenissettothetypeofgasused(seelabelonthegasconnector).

Ifthegassupplyisnotcompatiblewiththegassettingofyourrangethesettingmustbemodied.

Refertothe“Changingthehobgas”sectionofthepresentinstructions.

Butane-fuelled units :Connectunitto2.6kg/hpressurereducer.Usetwocylindersconnectedtoa

3-wayvalveaheadofthepressureregulatorincaseofprolonged,continuousduty.

Propane-fuelled units :Connectunittoa3.0kg/hpressurereducer.Usetwocylindersanda3-way

valveaheadofthepressureregulatorincaseofprolonged,continuousduty.Theuseof37kgor

externcryogenictanksisbothpossibleandrecommended.

Before connection

Check :

◊Pipeworkisperfectlycleaninordertopreventtheinjectorsbecomingblockedandmalfunctioning

ofthemagneticheads.

◊Thegasforwhichtheappliancewassetup:Ratingplateandmarkings.

◊Cross-sectionalareaofgassupplypipeworkiscompatiblewiththeappliance’sthermaloutput.

◊Provideadequateairsupplyduringuseoftheappliance.

Gas connection

Femalecoupling Ø 15/21,1/2”IDNPTon A/figure 1.

After connection

CheckthemanifoldpressureonpressureconnectionØ15/21,1/8”NPTon B/figure 2.

Subsequently check the circuit for gas leaks.

GAS CONNECTION

Table1

Country GAS Pressure(Pn)

U.S Naturalgas 6’’WC

U.S L.P.propane 10’’WC

A

B

TheapplianceisdesignedtooperatewiththegasesinTable1.

12

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 10/42

INSTALLER’S MANUAL

To remove top :

1-Removethepansupportsandburners.

2-Unscrewthescrew(s)onburners,see

A

and

B

/figures 1and 2.

3- Loosenedthe2screws

C

/figure 3throughtheventilationstrip.

4. Pullandraisethetopfigure 4

5-Wedgethecookingsurface

D

/figure

4

.

Retting the cooking surface

Whenrefittingthecookingsurface,itisvitaltotightenfasteningscrews.Failuretodosocancause

distortionofthecookingsurface.

Itmaybenecessarytoopenthehobunderthefollowingcircumstances:

-Makingadjustmentswhenchanginggastype.

-Adjustingthermocouples.

-Resettingthesafetythermostatwithvitro-ceramichob.

OPENING AND REFITTING THE HOB

D

C

AB

12

3

4

D

1.Pullfoward

2.Liftthetable

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 11/42

INSTALLER’S MANUAL

CHANGE OF GAZ

Table 1

Country GAS Pressure (Pn)

U.S. Natural gas 6’’ WC

U.S. L.P.

propane 10’’ WC

Changing the gas type of top :

Convertible regulator

Thereversiblecapislabeledeither«LP»or«Nat»andiseasilyrecognizedbytheraisedcenter

screwslot(fornatural)orthecenterdepth(forLP).

TochangeLPtoNaturalorviceversa,thesealscrewintheregulatorlidisunscrewed,reversed

andreinstalledtoconvertfromonesettingtoanother/figures 2and 3.

Lacancherangesaresuppliedwiththegasttingrequestedwhentheorderisplaced.Thesettings

mustbene-tunedwhentherangeisinstalled.

Theapplianceisdesignedtooperatewiththegasesintable1.

IMPORTANT : Close the mains gas valve before carrying out any works.

IMPORTANT

In case of use with a gas other than that for which the appliance was initially set up, it is

crucial to replace the injectors and modify the adjustments as dened below. Subsequently

check the circuit for gas leaks

Apressureregulatorgure

1islocatedinthe

rightrearcornerunderthehob,togainaccess

tothepressureregulator,removethetop.

NatSetting LPSetting

1

2 3

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 12/42

INSTALLER’S MANUAL

Table 2

Burners SF F I

GAS Pressure

Natural gas 6»WC 0.90 1.30 1.45

L.P. propane 10»WC 0.65 0.90 1.05

CHANGE OF GAS

Changing the gas type of the hob/ Setting gas burner hob :

Hob injector:

►Lifttheairring A/figure 4.

►Replacetheinjectors Binaccordancewithtable2andfigure 4(Øin1/100mm).

Ifnecessary,themixertubesofthelateralburnersmaintainedbyacross-bar C/figure 5,may

bereleased. 

Toreleasethetubesloosenscrews

D/figure 2andthenscrew E/figure 6.

N.B. Whenreplacinginjector(s),alsoreplacethesealingwasher(seeparagraph“GasLine”).

Lacancherangesaresuppliedwiththegasttingrequestedwhentheorderisplaced.Thesettings

mustbene-tunedwhentherangeisinstalled.

IMPORTANT : Close the mains gas valve before carrying out any works.

IMPORTANT

In case of use with a gas other than that for which the appliance was initially set up, it is

crucial to replace the injectors and modify the adjustments as dened below.

wrench,12

F

4

6

5

BC

A

E

D

7

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 13/42

INSTALLER’S MANUAL

Adjusting reduced ow of hob burners :

Afterconnectionorchangeofgas,itiscrucialtomodifythisadjustment:

►Removetheknob.

►Lighttheappropriateburner.

►Adjusttominimumsetting.

►Useasmallscrewdrivertosettheadjustingscrew

G

/figure 8.

N.B : Flameis reducedto ¼of itssize inthe minimumsetting, theburner mustremain litwhen

changingfrommaximumsettingtominimumsetting.

Adjusting the safety devices for each thermocouple of the hob: :

Iftheburnergoesout,havingkeptthecontrolknobpushedinforroughlytwentyseconds,check

that :

-Themagneticheadgripthevalvemoderately.

-Theflametouchesthepointofthermocouple

H

figure 8,

-Thethermocouplesandmagneticheadsareabsolutelyclean.

9

H

CHANGE OF GAS

Adjusting the primary air of hob burners :

► Positiontheburnerbodiesandamediffusersintheirrespectivelocations.

►Adjusttheairring F/figure 7,tabel3.

N.B:Normalamesarebluishgreenexceptfornaturalgasameswhichareviolet.

Table 3

Burners SF F I

GAS Pressure Oppening / inches

Natural gas 6»WC 2,5/1/82,5/1/8max

L.P. propane 10»WC 3,5/1/8max max

G

8

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 14/42

INSTALLER’S MANUAL

►Removethedrawer.

►Loosenthescrew J/gure 11 .and. 12.

►Pushtheburnertothebottomoftheovenandlifttorelease.

CHANGE OF GAS

Changing the oven gas type :

Removing the oven burner/ Settings of oven gas :

►Removethebase I/figure 10.

►Unscrewthescrew Jholdingtheburner.

►Pushtheburnertothebottomoftheovenandlifttorelease/gure 11 .

10

I

J

11

Oven injector :

►Removetheburner.

►Unscrewthenut Konlywithasize7wrench,figures. 12and. 13.

►Replacetheinjector L/figure 12and 14,table4.

Air ring

Injector

Screw

J

Setsrew

K

L

Table 4 Ø

GAS Pressure Oven Pilot burner

Natural gas 6»WC 1.40 0,45

L.P. propane 10»WC 0.95 0,25

12

Pilot burner orice :

Changethepilotburnerorice

GaspilotLP:65103032

GaspilotNG:65103031

K

13

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 15/42

INSTALLER’S MANUAL

CHANGE OF GAS

CAUTION :Whenrettingplacethebaseunderneaththegrooveonthefascia/

gure17.

16 17

Adjustingairring

Table 5 Opening in mm /

inches

GAS Pressure Oven

Natural gas 6»WC 4/3/16

L.P. propane 10»WC 6/1/4

Adjustment of oven primary airow :

►Carryouttheadjustmentringbymovingthe1irthroughthetwoholesinthesole 15and 16

,tablen°5.

14

L

15

Adjusting pilot burner air supply :

Turnring

M

/gure

18 tofullyopenforButane/Propane,tohalfopenfornaturalgas.

18

M

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 16/42

INSTALLER’S MANUAL

Adjusting the oven thermocouple safety devices :

Iftheburnergoesout,havingkeptthecontrolknobpushedinforroughlytwentyseconds,check:

-(Moderate)tighteningofMagneticheadonthevalve.

-Theflametouchesthepointofthermocouple.

-Thethermocouplesandmagneticheadsareabsolutelyclean.

CHANGE OF GAS

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 17/42

INSTALLER’S MANUAL

Appliancesmustbeinstalledinaworkmanlikemannerinaccordancewiththeinstructionsin

thismanualandlocallyapplicableregulations.Thismanualwillbehandedovertotheuserafter

installation.

Before connection, check that the

Mainsvoltageiscompatiblewiththeappliance’sratedvoltageandthermaloutput.

Connection :

-Usea3-wiregroundedcordratedfor13Aor4-wireratedfor30A125/250VAC,typeSRD,

SRDT,S,SOorST.

-WherelocalCodesdonotpermitgroundingthroughneutral,usea4-wirepowersupplycordor

«pigtail»kit.Cordmustbeagencyapprovedforusewithhouseholdranges.

-Removecover(orcovers) A/figure 1,tothebackoftheunitidentifiedby .

-Useastandardflexiblecabletoconnecttoterminalblock B/figures 1& 2.

-Securethecablebymeansofcableclamp C/figure 2,dependingonyourpowersupplyfigures

1& 2.

-Refitaccessdoor.

It is hazardous to put the appliance into service without connecting it to suitable ground.

ELECTRIC CONNECTION

Noliabilitycanbeacceptedforaccidentsresultingfromnon-compliancewiththis

requirementorincorrectgrounding.

L N

1 2

400 V 3N ~ 50 Hz 230 V 1N ~ 50 Hz

230 V 1N ~ 50 Hz 230 V 3 ~ 50 Hz

L1 NL2 L3

1 2 3 4 5

N L1 L2 L3L

1 2 3 4 5 1 2 3 4 5

The supply of three phase 400 without neutral is not possible

1

A

C

B

D

2

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 18/42

INSTALLER’S MANUAL

Back spacer vent fitting :

Itismandatorytomountthebackspacervent Atothewallsuppliedwiththeappliance.

Screwthe2brackets Btothewallaccordingtofigures 1, 2and 3(screwsnotsupplied),

thenfitthebackspacerventontothesebracketsbyusingthewashersandnutssuppliedwiththe

range.

Stability device installation instructions :

Screwtheanti-tipbrackettothewall(screwsnotsupplied).

Removetheleft-handdrawer,pushtherangeagainstthewalluntiltheanti-tipbracketscrewgoes

throughthebackoftherange.Throughthedrawergap,screwthenutanditswasherontheanti-

tipbracketscrew.

INSTALLATION

A

B

1 2 3

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 19/42

INSTALLER’S MANUAL

Lubricating gas valve.

Ifthegastapstendstostickslightly,youmayfollowthisprocedure:

• 1-Shutoffthevalveand/orthemainelectricalsupplyoftheunit.

• 2-Takeouttheknobcorrespondingtothegasvalvetobegreased.

• 3-Unscrewtheheadfromthebodyoftheburnervalve.

• 4-Greasethetapshaft(Hightemperaturelubricant,forexample:SILICALGEL™

BARBAHL).

Caution!Anyexcessgreaseshouldberemoved.

Reverseoperation3to1(inthatorder)toputvalveandknobbackon.

Limiting thermostat :

Inaccordancewiththeconstructionregulations,thelimiterthermostatisintendedtoprotectthe

rangefromoverheating.

Intheeventofoverheatingthelimiterthermostatistriggeredandcutsouttherange’soven

functions.

Thelimitermaythereforebeunexpectedlytriggeredwhentheovenisfirstheatedandstopthe

ovenfromworking.

Resetting the limiting thermostat :

Toaccessinternalcomponents.Liftandsecuretop(seeparagraph“Openingandrefittingthehob”)

Presspushbuttonitem A/Figure 1inordertoresetthelimitingthermostat.

Note:ALWAYS IDENTIFYthereasonwhythethermostattripped.

SERVICE INSTRUCTIONS

1

A

Notice provisoire Beaune - Bussy UL - FT164h - Date : 16/10/12 20/42

Page is loading ...

Lacanche UL Beaune/Bussy Owner's manual

Related papers

Other documents