Schwinn Adult Tricycle Owner's manual

This manual contains important safety, performance and maintenance

information. Read the manual before taking your rst ride on your

new bicycle, and keep the manual handy for future reference.

To register your bike visit

www.schwinnbikes.com/registerbike

Owner

’

s Manual

Adult Tricycle

Contents

1 Introduction

Safety Signal Words ..................2

2 Safety

User Responsibility...................2

Protective Gear and Clothing . . . . . . . . . . . 3

Riding Safety . . . . . . . . . . . . . . . . . . . . . . . 3

Wet Weather........................4

Night Riding . . . . . . . . . . . . . . . . . . . . . . . . 5

3 Parts...............................6

4 Assembly...........................8

Getting Organized . . . . . . . . . . . . . . . . . . . 8

Initial Set-up - Attach the Handlebars.....9

Attach the Rear Frame ...............11

Attach the Secondary Chain...........12

Attach the Rear Wheels . . . . . . . . . . . . . . 13

Attach the Front Fender . . . . . . . . . . . . . . 15

Attach the Front Wheel...............17

Assemble the Front Brake ............18

Rear Brake Adjustment . . . . . . . . . . . . . . 25

Brake Locking Buttons . . . . . . . . . . . . . . . 27

Attach the Rear Fenders . . . . . . . . . . . . . 28

Assemble the Wire Basket ............29

Attach the Wire Basket ...............30

Attach the Saddle ...................31

Attach the Pedals ...................32

Adjust the Handlebar ................33

Adjust the Seat .....................34

5 Use...............................35

Pre-Ride Checklist . . . . . . . . . . . . . . . . . . 35

6 Maintenance and Troubleshooting.....40

Parts Maintenance . . . . . . . . . . . . . . . . . . 40

Hub Bearings . . . . . . . . . . . . . . . . . . . . . . 44

 InatingtheTireTube ................45

 RepairingaFlatTire .................46

7 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . 47

8 Purchase Record . . . . . . . . . . . . . . . . . . . 49

1

This manual contains important information

regarding safety, assembly, use, and maintenance

of the tricycle but is not intended to be a complete or

comprehensive manual covering all aspects concerning

tricycle ownership. We recommend consulting a tricycle

specialist if you have any doubts or concerns regarding

your experience or ability to properly assemble and

maintain the tricycle.

Our customer service department is dedicated to your

satisfactionwithPacicCycleandit’sproducts.Ifyou

have questions or need advice regarding assembly,

parts, performance, or returns, please contact the

expertsatPacicCycle.

Enjoy the ride.

Toll fre e: 1-800-626-2811.

Customer Service hours: 8 AM- 5 PM (Central

StandardTime,CST)MondaythruFriday.

You may also reach us at:

Web: www.schwinnbikes.com

Email:customerservice@pacic-cycle.com

Mail:PacicCycle

PO Box 344

 4730ERadioTowerLn

Olney, IL 62450

Do not return this item to the store. Please call

Pacic Cycle customer service if you need

assistance.

Introduction

1

2

Safety

2

Safety Signal Words

Thefollowingsafetysignalwordsindicateasafety

message.Thesymbolalertsyoutopotentialhazards.

Failure to follow the warning may result in damage to

property, injury, or death.

!

WARNING!

Indicates a hazard or unsafe practice that will result in

severe injury or death.

Failure to read, understand and follow the safety

information in this manual may result in serious injury

or death.

!

CAUTION!

Indicates a hazard or unsafe practice that could result

in minor injury.

NOTICE

Indicates a hazard unrelated to personal injury, such as

property damage.

User Responsibility

• All persons assembling, using, and maintaining

the tricycle must read and understand the safety

warnings and operating instructions in this manual

before using the tricycle.

• It is the responsibility of the user, or in the case of

a child rider, an adult, to ensure the tricycle is in

proper operating condition before each use.

See the Safety Checklist in the Use section of

this manual.

• A responsible adult must supervise the use of the

tricycle by a child. You must ensure:

•Thechildiswearingtheproperprotective

attire and approved tricycle helmet.

•Thechildisseatedsecurelyandthetricycle

isproperlyttedtothechild.

 •Thechildunderstandsapplicablelawsand

common sense rules of safe responsible

bicycling.

3

Protective Gear and Clothing

Always wear proper attire when riding the tricycle, you

should wear:

• Colors that are easily seen and, if possible,

reectiveclothing.

• Clothing appropriate for the weather conditions.

• Use of protective gear such as pads for the knees

and elbows is highly recommended for children.

• Aproperlytted,ASTMorSNELLapproved,

tricycle helmet shall be worn at all times by riders

of the tricycle. For information regarding how to

properlytahelmetvisit:http://www.nhtsa.gov/

people/injury/pedbimot/bike/easystepsweb

Note: Some states have helmet laws regarding

children. Always follow local or state regulations

regarding helmet use.

Do not wear:

• Loose clothing parts, strings, jewelry that may

become entangled with moving parts on the

tricycle or interfere with handling of the tricycle.

• Pants with loose pant legs. If necessary, always

tuck pant legs into a sock or use a leg band to

avoid the clothing becoming caught in the

drive chain.

• Shoes with untied shoe laces.

Use of Reector and Lights

• Federal regulations require every tricycle over

16” to be equipped with front and rear wheel

reectorsaswellaspedalreectors.

• Statesmayrequirespecicsafetydevices.

Always follow state or local regulations regarding

required safety devices.

• Alwayscheckthereectorsareinplacebefore

using the tricycle.

• Tohelpenhanceyourvisibilitytoautomobile

drivers use front and rear lights.

Riding Safety

• Familiarizeyourselfwithallthetricycle’sfeatures

before riding. Practice gear shifts, braking, and

the use of toe clips and straps, if installed.

4

• Always ride defensively in a predictable, straight

line.Neverrideagainsttrafc.

• Concentrate on the path ahead. Avoid pot holes,

gravel, wet road markings, oil, curbs, speed

bumps, drain grates and other obstacles.

• Cross train tracks at a 90 degree angle or walk

your tricycle across.

• Expect the unexpected (e.g. opening car doors or

carsbackingoutofconcealeddriveways).

• Takeextracareatintersectionsandwhen

preparing to pass other vehicles.

• Maintain a comfortable stopping distance from all

other riders, vehicles and objects. Safe braking

distances and forces are subject to the prevailing

weather conditions. Do not lock up the brakes.

Whenbraking,alwaysapplytherearbrakerst,

thenthefront.Thefrontbrakeismorepowerful

and if it is not correctly applied, you may lose

control and fall.

• Always use the correct hand signals to indicate

turning or stopping.

• Obeythetrafclaws(e.g.stoppingataredlight

orstopsign,givingwaytopedestrians).

• Wearproperridingattire,reectiveifpossible,

and avoid open toe shoes.

• Avoid wearing loose pants. If you are wearing

loose pants, tuck the pant leg into a sock or use

leg clips/elastic bands to prevent them from being

caught in the drive chain.

• Don’tuseitemsthatmayrestrictyourhearing.

• Don’tcarrypackagesorpassengersthat

will interfere with your visibility or control of

the tricycle.

Wet Weather

• Be aware of road conditions. Pot holes and

slippery surfaces such as line markings and train

tracks all become more hazardous when wet.

• Decrease your riding speed, avoid sudden

braking and sharp turns.

• Braking will require additional distance. Initiate

braking slowly and earlier than usual.

• Wearreectiveclothingandusesafetylightsfor

increased visibility.

5

Night Riding

• Riding at night is not recommended. Check with

local law or regulations regarding the use of lights

for night riding.

• Ensure tricycle is equipped with a full set of

correctlypositionedandcleanreectors.

• Use a white light on the front and a red light

ontherear.Ifpossible,uselightswithashing

capability. Flashing lights enhance visibility.

• If using battery powered lights, make sure

batteries are well charged.

• Wearreectiveandlightcoloredclothing.

• Slow down and use familiar roads with

street lighting.

• Ride at night only if necessary.

6

Before assembly check and see that all the parts are included. If parts are missing or damaged call customer

service toll free at 1-800-626-2811.

Parts

3

secondary chain

front wheel

handlebar

pedals(2)

rear frame

rearfenders(2)

rearwheels(2)

main frame

rear brake

rear brake lever

front brake lever

front fender

wire basket

saddle

seat stem

plastic wheel

caps(2)

7

Hardware

4

Frame Assembly Hardware

Handlebar Hardware

4 nuts 4 washers

stem wedge cap

Secondary Chain Hardware

secondary chain

2 master links

Rear Wheel Axle Hardware

2 plastic caps 2 nuts 2 washers

Front Wheel Axle Hardware

2 nuts

Basket Hardware

4 washers

4 bolts

Rear Fender Hardware

!

WARNING!

8

Assembly

5

Improperly assembly of the tricycle may result in

unexpected product performance and serious injury

or death. Assemble the tricycle according to the

instructions in this manual or have a professional

tricycle mechanic assemble the tricycle.

Getting Organized

Thefollowingtoolsanditemsareneededforassembly:

• Phillipsheadscrewdriver(minimumfourinchshaft)

• 6 mm, 10 mm Allen keys

• Adjustable wrench or 10 mm, 15 mm, and 17 mm

open and box end wrenches

• Needle nose pliers with cable cutting ability

• Grease(Automotiveoranti-slipcoppergrease)

9

Initial Set-up - Attach the Handlebars

Parts: Handlebar, main frame

Hardware:Thestemwedgeboltandbinderboltcome

attached to the handlebar. Stem wedge bolt cap.

Tools: 6 mm Allen wrench, grease

1. Remove the cap covering the stem wedge bolt.

2. Apply a light layer of grease to the stem and

frame head tube.

3. Insert the stem of the handlebar into the frame

head tube until the Minimum Insertion mark is not

visible. If necessary, unscrew the stem wedge bolt

until there is play in the stem wedge.

NOTICE

Thestemmaybreakordamagemayoccurifthestem

is not inserted the minimum amount. Insert the stem

until the Minimum Insertion mark is not visible.

4. Rotate the handle bar so it is square with the fork.

5. Tightenthestemwedgebolttolockthestem

in place.

6. Replace the cap onto the stem wedge bolt.

7. Loosen the handlebar binder bolt and rotate the

handlebar into the riding position.

8. Using the 6 mm Allen wrench, tighten the handlebar

binder bolt until the handlebar is locked in place.

9. Turnthetricyleassemblyoversoitrestsonthe

handlebar and main frame.

9

10

6

binder bolt

stem wedge bolt

main frame

1

2

3

4

5

8

Stem

Minimum

insertion mark

11

Attach the Rear Frame

Parts: rear frame, main frame

Hardware: 4 nuts, 4 square bolts, 4

washers, come attached to the

frame. Remove the nuts and

washers only.

Tools: None required.

1. Join the rear frame and main frame

together by sliding the bolts from the

main frame into the slots on the rear

frame.Theboltsonthefrontofthe

mainframe(furthestfromthegears)

shouldtintotheslotsonthebackof

therearframe.Theboltsontheback

of the main frame (closest to the

gears)shouldtintotheslotsonthe

front of the rear frame.

2. Slide a washer over the end of a bolt

and fasten a nut to the end of the bolt.

Note: Do not tighten the nuts at this

time.Thiswillbedoneafterthe

secondary chain is attached.

3. Repeat step 2 on the remaining bolts.

rear frame slots

main frame bolts

3

2

Side view of frame alignment

1

Rear and main frame attached

gears

12

Attach the Secondary Chain

Parts: secondary chain, frame assembly

Hardware: 2 master links

Tools: 17 mm open and box end wrench.

1. Wrap the secondary chain around the inner sprocket

on the rear hub and drive sprocket on the rear axle.

2. Adjust the position of the rear frame until the ends of

the secondary chain meet each other, leaving one

chain link length space in between the ends.

3. Toconnectthetwoendsofthechain:

a. Insert the post of a master link through the

hole on the end of the secondary chain link.

b. Insert the post of the other master link through

the opposite end of the secondary chain, and

on the opposite side of the chain.

c. Pull the chain so the posts are inserted into

the smaller hole of the master chain.

4. Pull the rear frame back so the secondary chain is

taut and there is less than 5 mm of play up or down.

Important! Be sure the rear frame is perpendicular

to main frame. Failure to square the frames will affect

performance of the tricycle.

5. Firmly tighten the four bolts holding the rear frame to

the main frame.

inner

sprocket

drive

sprocket

b

5

2

Have a second

person pulling the

chain taut while

tightening the bolts.

Tip!

3

4

a

1

c

Front view of chain

Post inserted into link

!

WARNING!

13

Attach the Rear Wheels

Failure to properly tighten the nuts holding the wheels

onto the tricycle may result in poor riding performance,

the tire falling off and serious injury or death. Always

be sure the wheels are securely attached to the frame

before using the tricycle.

Parts: Drive wheel, non-drive wheel

Hardware: 2 plastic caps, 2 locknuts, 2 washers.

The locknuts come attached to the axle.

Remove the locknuts before you begin this

procedure.

Tools: 17 mm open and box end wrench

See the facing page for diagrams of the following steps.

1. Placethedrivewheel(withanotchedopening)on

the axle.

2. Place the washer on the axle.

3. Place the locknut on the axle and tighten securely.

Note:Thedrive

wheel hub has

a notched

opening that

matches the

notched axle.

4. Screw the plastic caps on each end of the axles.

5. Toattachthenon-drivewheelrepeatstepsone

through four.

Note:Topreventtheaxlefromturningwhile

attaching the non-drive wheel, it is important to hold

the drive wheel while tightening the locknut on the

non-drive wheel.

14

1

2

3

5

4

15

Attach the Front Fender

Parts: Front fender, main frame

Hardware: washer, long screw, small screw,

Tools: Phillips head screwdriver

See the facing page for diagrams of the following steps.

1. Removetheforkprotector(notshown).

2. Disconnect the brake noodle from the brake

carrier by:

a. Using a 5 mm Allen wrench loosen the

cable anchor bolt enough so the cable

can move freely.

b. Lift the brake noodle and cable out of the

brake carrier.

3. Remove the hardware from the fork.

2

hex wrench

a

cable anchor bolt

brake

noodle

brake

carrier

b

16

4. Position the front fender so the attachment bar is

on the inside of the main frame, and aligns with the

threaded screw hole of the fork.

5. Place a washer on the large screw and slide it

through the attachment bar, and into the threaded

hole in the fork.

6. Align the fender braces with the small hole on the

ends of the fork.

7. Loosely screw the fender braces to the fork.

Note:Thefenderwillbepositionedandrmlyfastened

after the front tire is attached.

Decal should be

on the outside of

the frame.

Tip!

4

5

3

6

7

!

WARNING!

17

Attach the Front Wheel

Failure to properly tighten the nuts holding the wheels

onto the tricycle may result in poor riding performance,

the tire falling off and serious injury or death. Be sure

the wheels are securely attached to the frame before

using the tricycle.

Parts: Front wheel, main frame assembly

Hardware: 2 large nuts

Tools: 15 mm open and box end wrench,

Adjustable Pliers

1. Place the front wheel into the fork openings.

Be sure both sides of the axle rest on the

metal and the wheel is centered.

2. Place the nut on the axle and loosely tighten.

3. Place the remaining nut on the opposite side and

loosely tighten.

4. Tighteneachnutuntilbotharermly

set,aminimumof20ftlbs(240in-lb).

5. Inspect the wheel for even rotation.

Before proceeding to the next step,

lift and rotate the tricycle.

3

2

1

Tip!

Page is loading ...

Schwinn Adult Tricycle Owner's manual

This manual is also suitable for

Schwinn Adult Tricycle Owner's manual

in other languages

Related papers

Other documents