DeWalt DXH165 User manual

If you have questions or comments, contact us.

Pour toute question ou tout commentaire, nous contacter. Llámenos si tiene alguna pregunta o comentario.

855-805-5745 • www.dewalt.com

INSTRUCTION MANUAL

GUIDE DE’UTILISATION

MANUAL DE INSTRUCCIONES

Electric Forced Air Heater DXH165

Chauffage électrique à air forcé DXH165

Calentador eléctrico de aire forzado DXH165

2017 - 41000 - CB

READ INSTRUCTIONS CAREFULLY: Read

and follow all instructions. Place instructions in

a safe place for future reference. Do not allow

anyone who has not read these instructions to

assemble, adjust or operate the heater.

VEUILLEZ LIRE ATTENTIVEMENT LES INSTRUCTIONS :

Lisez et observez toutes les instructions. Conservez ces

instructions dans un endroit sécuritaire pour vous y référer

ultérieurement. Interdisez à quiconque n’ayant pas lu les

présentes directives d’assembler, de régler ou de faire

fonctionner cette fournaise.

LEA CUIDADOSAMENTE LAS INSTRUCCIONES:

Lea y siga todas las instrucciones. Conserve

estas instrucciones en un lugar seguro para futura

referencia. No permita que nadie que no haya leído

estas instrucciones arme, ajuste o use el calentador.

English

2

WARNING: DO NOT OPERATE THIS HEATER UNTIL YOU READ AND

UNDERSTAND THIS INSTRUCTION MANUAL FOR SAFETY, OPERATION,

AND MAINTENANCE INSTRUCTIONS.

CAUTION: Use of this heater in any means not described in this manual

may cause ﬁre, electric shock, personal injury and/or property damage.

CAUTION: This heater is hot when in use. To avoid burns,

do not let bare skin touch hot surfaces. Keep combustible materials, such

as furniture, pillows, bedding, papers, clothes, and curtains at least 6 feet

( 1.8 m) from the front of the heater and keep them at least 2 feet (.6 m)

away from the sides and rear

CAUTION: In order to avoid unintended cycling of the heater, always

unplug or disconnect unit from power source when not in use.

CAUTION: Do not cover the power supply wiring or run the wiring under

any carpet or rugs. Arrange cord and connections away from trafﬁc patterns

so it is not a tripping hazard.

CAUTION: Connect unit to only properly grounded outlets and

adequately sized and grounded electrical systems.

CAUTION: Do not use this unit with unapproved or under sized electrical

connections or wiring. They may overheat and cause a risk of ﬁre.

Deﬁnitions: Safety Guidelines

The deﬁnitions below describe the level of severity for each signal word. Please read the manual and pay attention to these symbols.

DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.

WARNING: Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.

CAUTION: Indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury.

NOTICE: Indicates a practice not related to personal injury which, if not avoided, may result in property damage.

WARNING: Do not use the heater if the unit, plug or cord has

visible damage or the unit has malfunctioned. Contact a reputable

electrician before reusing.

WARNING: Do not expose to wet conditions; unit is intended

for indoor use only.

WARNING: Unit not intended for use in indoor areas where

heater may be exposed to water. Avoid use in bathrooms, laundry

rooms or any other areas where the unit may come in contact with

water.

WARNING: Do not insert or allow any foreign objects to enter

the unit via the intake or exhaust vents on the unit. Failure to

observe this warning may result in electric shock, ﬁre or damage to

the unit.

WARNING: To prevent ﬁre do not block either the air intake or

exhaust.

WARNING: Unit is equipped with internal active electrical

components that spark during use. Do not use in areas where

fumes from gasoline, paint or other ﬂammable liquids may be

present.

WARNING: Extreme caution must be used when any heater is

used by or near children or invalids and whenever the heater is left

operating and unattended.

SAVE THESE INSTRUCTIONS.

English

3

CONTENTS

WARNINGS ............................................................................ 2

ASSEMBLY ............................................................................. 3

OPERATION ........................................................................ 3-4

SPECIFICATIONS ................................................................... 4

CLEARANCES ........................................................................ 4

MAINTENANCE ...................................................................... 4

TROUBLESHOOTING ............................................................ 5

WIRING DIAGRAM ................................................................. 6

EXPLODED VIEW/PARTS LIST ............................................ 7-8

WARRANTY ........................................................................... 9

INSTRUCTIONS FOR ORDERING PARTS .............................. 9

Assembly

• Remove the heater and all of the packaging material from the box.

• Check all of the packing material for loose parts and set aside.

• Locate the hardware package containing four screws and the handle.

• Throughly inspect the heater for damage. If any is found do not contact the place

of purchase. Please call the Manufacturer at 855-805-5745.

• Use the screws the fasten the handle to the top of the unit. Note: Do not over

tighten the screws as they can crack the handle.

Handle and Hardware pack are located in the carton loose, be sure not to throw out.

Operational Information

The DeWalt Electric forced air heaters are designed to be used by professionals.

Heat is created by electric current passing through coiled metal elements bringing them up to very high temperatures. The fan then passes room air over the hot elements exchanging cold air for warm.

The air moving over the coils keeps them from reaching temperatures that are not safe for the normal operation of the heater. However it is important to keep all combustible materials and any objects that

may be sucked into the fan blades at a safe distance (please refer to the table on the next page for appropriate distances). Make sure that the fan blades remain unobstructed at all times.

Keep unit clean and dust free. Do not block unit intake or exhaust at any time.

Review and understand all warnings in this manual. Follow all local codes.

This unit is designed to be used with 115v ac only.

This unit is supplied with the appropriate (NEMA 5-15P) plug. Do not use any plug other than the one supplied by the manufacturer.

If damage has occurred please refer to the parts listing in this manual and contact the manufacturer for a replacement.

This unit is designed to be used with a properly grounded NEMA 5-15 outlet only (show on the right).

Operation

WARNING: Outlet must be properly grounded, failure to do so may result in electric shock.

English

4

ON/OFF FAULT/LED THERMOSTAT

WARNING:

Never attempt to service the heater while the unit is hot, In use, or plugged in. Only

qualiﬁed service technicians should service these units.

• Throughly inspect the unit prior to use.

• Keep heater clean and free of dust and debris.

• The use of an air compressor can be used to blow out the case. Be sure to only

use moderate air pressure as to not damage any internal components.

• A soft dry cloth should be used for cleaning of outer shell and handle.

• The fan motor is sealed and does not need to be lubricated.

Starting Instructions

1. Place the heater on a stable and level surface. Insure clearance to

combustibles are observed (see table on this page).

2. Turn thermostat counter-clockwise to lowest setting.

3. Plug the heater into a properly grounded outlet.

4. Depress the power switch into the on “I” position.

5. Turn thermostat knob up (clockwise) until desired temperature is reached.

6. The Heating element and fan will remain on until the temperature

setting is reached. The unit will cycle on and off as needed.

To Stop Heating

1. Rotate the thermostat knob to the lowest position.

2. Flip the power switch into the “off” position.

3. Disconnect plug from power supply.

NOTE: This heater is equipped with an overheat limit switch which may cause the

heater to stop. This is indicated by a visual alarm when the power switch is in the

on position and the “fault” light comes on. (ﬁg 1) Check and remove the cause of

the overheating before restarting. This can take up to 15 minuets to cool before it

can be restarted.

Maintenance

Speciﬁcations

Model: DXH165

Heat Output BTU/WATTS

5118/1500

Airflow (CFM) 120

Electrical Supply

120V/12.5A /60Hz

Power Cord (supplied) 3-14 AWG

Plug (supplied)

NEMA 5-15p

Min. Extension Cord 3-12 AWG

Thermostat 23°F - 95°F

Dimensions: (L”xW”xH”) 13”x9”x11”

Weight (lbs.) 14 lb.

Clearance to Combustibles

Outlet (Feet) 6 (1.8m)

Rear (Feet) 2 (.6m)

Top (Feet) 2 (.6m)

Bottom Non-combustible floor

FIG. 1

English

5

Storage

When not in use, the heater must be disconnected from power source, dusted off and the cord

should be loosely wound around the handle.

For service :

Please call Toll-Free 855-805-5745 www.dewalt.com

Our ofﬁce hours are 8:30 AM – 5:00 PM, EST, Monday through Friday.

Please include the model number, date of purchase, and description of problem in all

communication.

WARNING: USE ONLY MANUFACTURER’S REPLACEMENT

PARTS. USE OF ANY OTHER PARTS COULD CAUSE INJURY OR

DEATH. REPLACEMENT PARTS ARE ONLY AVAILABLE

DIRECT FROM THE FACTORY AND MUST BE INSTALLED BY A

QUALIFIED SERVICE AGENCY.

Troubleshooting

Unit does not work • Defective thermostat or wrong thermostat setting

• Open circuit breaker or fuse

• Thermal overload switch has been tripped

• Faulty Connection

• Damaged or defective plug or outlet

Unit runs continuously ` • Defective thermostat or wrong thermostat setting

• Heat losses higher than unit capacity (unit undersized)

Elements are on but motor does not rotate • Defective Motor

• Thermal overload switch has been tripped

• Blocked fan blades

Enclosure is extremely hot • Defective thermal protection

• Blocked air vents

• Defective motor

Desired room temperature cannot be reached • One or more elements are defective

• Defective thermostat or wrong thermostat setting

• Voltage lower than that written on Rate tag

• Heat losses higher than unit capacity (unit undersized)

Overheating • Defective thermostat or wrong thermostat setting

• Defective Motor

Heater emits a humming sound • Defective motor

• Fan blade blocked

English

6

Wiring Diagram

English

7

DXH165

20

English

8

Parts List DXH165

REF. # .............ITEM#............ DESCRIPTION

1..........................41010 ................COVER, TOP, SHELL, OUTER

2..........................41011 ................PANEL, FRONT

3..........................41012 ................PANEL, REAR

4..........................41013 ................SHIELD, RADIATION, TUBE

5..........................41014 ................BASE, PLATE

6..........................41016 ................PANEL, SIDE, LEFT

7..........................41017 ................PANEL, SIDE, RIGHT

8..........................41018 ................BRACKET, MOUNT, MOTOR

9..........................41019 ................BLADE, FAN

10........................41020 ................GUARD, GRILL, FRONT

11........................41021 ................GUARD, GRILL, REAR

12........................41022 ................PANEL, CONTROL, PLASTIC

13........................41023 ................ELEMENT, HEATING

14........................41024 ................MOTOR, FAN

REF. # .............ITEM#............ DESCRIPTION

15........................41025 ................BUSHING, STRAIN, RELIEF

16........................40801 ................HANDLE, CARRY

17........................41027 ................KNOB, THERMOSTAT, PLASTIC

18........................N/A .....................BRACKET, WIRE MOUNT

19........................41029 ................SUPPORT, HEATING ELEMENT

20........................41030 ................FOOT, RUBBER

21........................41031 ................CLIP, SENSOR, CAPILLARY TUBE

22........................41032 ................SWITCH, HIGH LIMIT, 77C

23........................41015 ................

BOARD, CIRCUIT, HIGH LIMIT, INDICATOR

24........................41034 ................

THERMOSTAT, TEMPERATURE, AMBIENT

25........................41035 ................SWITCH, LIGHTED, ON/OFF

26........................41036 ................BUSHING, PLASTIC, WIRE

27........................41028 ................FRONT SCREEN ASSEMBLY

28........................41093 ................RADIATION SHIELD TUBE W/BRACKETS

* ..........................41097 ................Power Cord

*Not shown on drawing.

WARNING:

Use only manufacturer’s replacement parts. Use of any other parts could cause injury or death.

Replacement parts are only available direct from the factory and must be installed by a qualiﬁed

service agency.

For Service

Please call Toll-Free 855-805-5745 www.dewalt.com

Our ofﬁce hours are 8:00 AM – 5:00 PM, EST, Monday through Friday.

Please include the model number, date of purchase, and description of problem in all communication.

9

English

INSTRUCTION MANUAL

Electric Forced-Air Heater DXH165

PARTS ORDERING INFORMATION:

Use only manufacturer’s replacement parts. Use of any other parts could cause

injury or death. Replacement parts are only available direct from the factory and

must be installed by a qualiﬁed service agency.

Warning:

PURCHASING: Accessories may be purchased at any DeWalt

®

local dealer or direct

from the factory

FOR INFORMATION REGARDING SERVICE:

Please call Toll-Free 855-805-5745

www.dewalt.com

Our ofﬁce hours are 8:00 AM – 5:00 PM, EST, Monday through Friday.

Please include the model number, date of purchase, and description of problem in all

communication.

LIMITED WARRANTY:

DeWalt

®

warrants its heaters and accessories to be free from defects in

material and workmanship for a period of 1 year from date of purchase.

DeWalt

®

will repair or replace this product free of charge if it has been

proven to be defective within the 1-year period, and is returned at customer

expense with proof of purchase to DeWalt

®

within the warranty period.

CSA C22.2#46

DEWALT

®

, GUARANTEED TOUGH

®

and the

yellow and black color scheme are trademarks

of the DEWALT Industrial Tool Co., used under

Under license from Dewalt Industrial Tool Co.

U.L. 1278

Electric Forced Air Heater DXH165

Appareil de chauffage à air forcé électrique modèle DXH165

Calentador eléctrico de aire forzado DXH165

2017 - 41000 - CB

INSTRUCTION MANUAL

MANUEL D’INSTRUCTIONS

MANUAL DE INSTRUCCIONES

READ INSTRUCTIONS CAREFULLY: Read

and follow all instructions. Place instructions in

a safe place for future reference. Do not allow

anyone who has not read these instructions to

assemble, adjust or operate the heater.

VEUILLEZ LIRE ATTENTIVEMENT LES INSTRUCTIONS :

Lisez et observez toutes les instructions. Conservez ces

instructions dans un endroit sécuritaire pour vous y référer

ultérieurement. Interdisez à quiconque n’ayant pas lu les

présentes instructions d’assembler, d’ajuster ou de faire

fonctionner l’appareil de chauffage.

LEA CUIDADOSAMENTE LAS INSTRUCCIONES:

Lea y siga todas las instrucciones. Conserve

estas instrucciones en un lugar seguro para futura

referencia. No permita que nadie que no haya leído

estas instrucciones arme, ajuste o use el calentador.

855-805-5745 • www.dewalt.com

If you have questions or comments, contact us.

Si vous avez des questions ou commentaires, veuillez nous contacter. Llámenos si tiene alguna pregunta o comentario.

Page is loading ...

Electric Forced Air Heater DXH165

Appareil de chauffage à air forcé électrique modèle DXH165

Calentador eléctrico de aire forzado DXH165

2017 - 41000 - CB

INSTRUCTION MANUAL

MANUEL D’INSTRUCTIONS

MANUAL DE INSTRUCCIONES

READ INSTRUCTIONS CAREFULLY: Read

and follow all instructions. Place instructions in

a safe place for future reference. Do not allow

anyone who has not read these instructions to

assemble, adjust or operate the heater.

VEUILLEZ LIRE ATTENTIVEMENT LES INSTRUCTIONS :

Lisez et observez toutes les instructions. Conservez ces

instructions dans un endroit sécuritaire pour vous y référer

ultérieurement. Interdisez à quiconque n’ayant pas lu les

présentes instructions d’assembler, d’ajuster ou de faire

fonctionner l’appareil de chauffage.

LEA CUIDADOSAMENTE LAS INSTRUCCIONES:

Lea y siga todas las instrucciones. Conserve

estas instrucciones en un lugar seguro para futura

referencia. No permita que nadie que no haya leído

estas instrucciones arme, ajuste o use el calentador.

855-805-5745 • www.dewalt.com

If you have questions or comments, contact us.

Si vous avez des questions ou commentaires, veuillez nous contacter. Llámenos si tiene alguna pregunta o comentario.

Page is loading ...

ADVERTENCIA:

Use solamente partes de repuesto del fabricante. El uso de cualquier otra parte podría causar heridas

o la muerte. Las partes de repuesto están disponibles únicamente en la fábrica y deben ser instaladas

por una agencia de servicio caliﬁcada.

Español

8

Lista de partes DXH165

REF .............ARTÍCULO ....... DESCRIPCIÓN

1..........................41010 ................CUBIERTA, SUPERIOR, EXTERNA

2..........................41011 ................PANEL, FRONTAL

3..........................41012 ................PANEL, TRASERO

4..........................41013 ................PANTALLA, RADIACIÓN, TUBO

5..........................41014 ................BASE, PLACA

6..........................41016 ................PANEL, LATERAL, IZQUIERDO

7..........................41017 ................PANEL, LATERAL, DERECHO

8..........................41018 ................SOPORTE, MONTAJE, MOTOR

9..........................41019 ................ASPA, VENTILADOR

10........................41020 ................PROTECTOR, REJILLA, FRONTAL

11........................41021 ................PROTECTOR, REJILLA, TRASERO

12........................41022 ................PANEL, CONTROL, PLÁSTICO

13........................41023 ................ELEMENTO, CALEFACTOR

14........................41024 ................MOTOR, VENTILADOR

REF .............ARTÍCULO ....... DESCRIPCIÓN

15........................41025 ................CASQUILLO, PRENSACABLES

16........................40801 ................ASA, TRANSPORTE

17........................41027 ................CONTROL, TERMOSTATO, PLÁSTICO

18........................N/A .....................SOPORTE, MONTAJE DE CABLES

19........................41029 ................SOPORTE, ELEMENTO CALEFACTOR

20........................41030 ................PATA, GOMA

21........................41031 ................PINZA, SENSOR, TUBO CAPILAR

22........................41032 ................

INTERRUPTOR, LÍMITE SUPERIOR, 77 °C

23........................41015 ................

PLACA, CIRCUITO, LÍMITE SUPERIOR, INDICADOR

24........................41034 ................

TERMOSTATO, TEMPERATURA, AMBIENTE

25........................41035 ................

INTERRUPTOR, CON LUZ, ENCENDIDO/APAGADO

26........................41036 ................CASQUILLO, PLÁSTICO, CABLE

27........................41028 ................ASAMBLEA DE PANTALLA FRONTAL

28........................41093 ................RADIACIÓN TUBO SHIELD CON SOPORTES

* ..........................41097 ................Cable de alimentación

*No se muestra en el diagrama.

Para obtener servicio

Llame sin cargo al 855-805-5745, www.dewalt.com

Nuestro horario de trabajo es de 8:00 AM a 5:00 PM, de lunes a viernes, hora del este.

Por favor, incluya el número de modelo, la fecha de compra y la descripción del problema en todas sus

comunicaciones.

Page is loading ...

DeWalt DXH165 User manual

DeWalt DXH165 User manual

in other languages

Related papers

Other documents