Lithonia Lighting IBH 11L MV - QTY 24 Installation guide

Brand: Lithonia Lighting

Model: IBH 11L MV - QTY 24

Category: Floodlights

Type: Installation guide

This manual is also suitable for

IBH 11L MV



Page1of4



LEDIMPORTANTSAFETYINSTRUCTIONS



 Toreducetheriskofdeath,personalinjuryorpropertydamagefromfire,electricshock,fallingparts,cuts/abrasions,and

otherhazardspleasereadallwarningsandinstructionsincludedwithandonthefixtureboxandallfixturelabels.

 Beforeinstalling,servicing,orperformingroutinemaintenanceupon

thisequipment,followthesegeneralprecautions.

 Installationandserviceofluminairesshouldbeperformedbyaqualifiedlicensedelectrician.

 Maintenanceoftheluminairesshouldbeperformedbyperson(s)familiarwiththeluminaires’constructionandoperation

andanyhazardsinvolved.Regularfixturemaintenanceprogramsarerecommended.

 Itwill

occasionallybenecessarytocleantheoutsideoftherefractor/lens.Frequencyofcleaningwilldependonambient

dirtlevelandminimumlightoutputwhichisacceptabletouser.Refractor/lensshouldbewashedinasolutionofwarm

waterandanymild,non‐abrasivehouseholddetergent,rinsedwithcleanwaterandwiped

dry.Shouldopticalassembly

becomedirtyontheinside,wiperefractor/lensandcleaninabovemanner,replacingdamagedgasketsasnecessary.

 DONOTINSTALLDAMAGEDPRODUCT!Thisluminairehasbeenproperlypackedsothatnopartsshouldhavebeen

damagedduringtransit.Inspecttoconfirm.Anypartdamagedor

brokenduringorafterassemblyshouldbereplaced.

 Recycle:ForinformationonhowtorecycleLEDelectronicproducts,pleasevisitwww.epa.gov

. 

 Theseinstructionsdonotpurporttocoveralldetailsorvariationsinequipmentnortoprovideeverypossiblecontingency

tomeetinconnectionwithinstallation,operation,ormaintenance.Shouldfurtherinformationbedesiredorshould

particularproblemsarisewhicharenotcoveredsufficientlyforthepurchaser’sorowner’spurposes,

thismattershouldbe

referredtoAcuityBrandsLighting,Inc.



READANDFOLLOWALLSAFETYINSTRUCTIONS!

SAVETHESEINSTRUCTIONSANDDELIVERTOOWNERAFTERINSTALLATION



 Disconnectorturnoffpowerbefore

installationorservicing.

 Verifythatsupplyvoltageiscorrectby

comparingitwiththeluminairelabel

information.

 Makeallelectricalandgrounded

connectionsinaccordancewiththeNational

ElectricalCode(NEC)andanyapplicable

localcoderequirements.

 Allwiringconnections

shouldbecapped

withULapprovedrecognizedwire

connectors.

WARNING

RISKOFELECTRICSHOCK



 Allowlamp/fixturetocoolbeforehandling.

Donottouchenclosureorlightsource.

 Donotexceedmaximumwattagemar kedon

luminairelabel.

 Followallmanufacturer’swarnings,

recommendationsandrestrictionsfor:driver

type,burningposition,mounting

locations/methods,replacementand

recycling.



WARNING

RISKOFBURN



 Wearglovesandsafetyglassesatalltimes

whenremovingluminairefromcarton,

installing,servicingorperforming

maintenance.

 Avoiddirecteyeexposuretothelightsource

whileitison.

CAUTION

RISKOFINJURY



 Keepcombustibleandothermaterialsthat

canburn,awayfromlamp/lens.

 Donotoperateincloseproximitytopersons,

combustiblematerialsorsubstances

affectedbyheatordrying.



CAUTION

RISK OF FIRE



Page2of4



LEDIMPORTANTSAFETYINSTRUCTIONS



Please see product specific installation instructions for additional warnings or any applicable FCC or other regulatory

statements.

Failure to follow any of these instructions could void product warranties. For a complete listing of product Terms and

Conditions, please visit www.acuitybrands.com.



OurBrands Indoor/Outdoor IndoorLighting OutdoorLighting Controls Daylighting 

LithoniaLighting Gotham  AmericanElectricLighting DARKTOLIGHT SunOptics

Carandini MarkArchitecturalLighting AntiqueStreetLamps LC&D

Holophane Peerless  Hydrel  ROAM

RELOC  RenaissanceLighting Tersen  SensorSwitch

LightConcepts WinonaLightingSynergy



AcuityBrandsLighting,Inc.assumesnoresponsibilityforclaimsarisingoutofimproperorcarelessinstallationorhandlingofitsproducts.

ABLLEDGeneralWarnings,FormNo.503.203

©2010AcuityBrandsLighting,Inc.Allrightsreserved.12/01/10



 Neverconnectcomponentsunderload.

 Donotmountorsupportthesefixturesinamannerthatcancuttheouterjacketordamagewire

insulation.

 Unlessindividualproductspecificationsdeemotherwise:NeverconnectanLEDproductdirectlytoa

dimmerpacks,occupancysensors,timingdevices,orother

relatedcontroldevices.LEDfixturesmustbe

powereddirectlyoffaswitchedcircuit.

 Unlessindividualproductspecificationsdeemotherwise:Donotrestrictfixtureventilation. Allowfor

somevolumeofairspacearoundfixture.AvoidcoveringLEDfixtureswithinsulation,foam,orother

materialthatwillpreventconvectionorconductioncooling.

 Unlessindividualproductspecificationsdeemotherwise:Donotexceedfixturesmaximumambient

temperature.

 Onlyusefixtureinitsintendedlocation.

 LEDproductsarePolaritySensitive.EnsureproperPolaritybefore installation.

 ElectrostaticDischarge(ESD):ESDcandamageLEDfixtures.Personalgroundingequipmentmustbe

wornduringallinstallation

orservicingoftheunit.

 DonottouchindividualelectricalcomponentsasthiscancauseESD,shortenlamplife,oralter

performance.

 Somecomponentsinsidethefixturemaynotbeserviceable.Intheunlikelyeventyourunitmayrequire

service,stopusingtheunitimmediately andcontactan

ABLrepresentativeforassistance.

 Alwaysreadthefixturescompleteinstallationinstructionspriortoinstallationforanyadditionalfixture

specificwarnings.

CAUTION:RISKOFPRODUCTDAMAGE



Page3of4



LEDIMPORTANTSAFETYINSTRUCTIONS



SECTION1:INSTALLATIONIBHLED2FTlengthshown(Note:currentIBHLEDisonlysetupforcommercialuse)

1) Disconnectallpowertotheexistingluminaireandremovetheexistingluminairefromtheceiling.Inspecttheexisting

mountinglocationfordamagebeforeinstallthenewIBHLEDhighbayinthis

location.

2) RemovethenewLEDfixturefrompackagingandinspectforanydamages.HandlenewLEDfixturewithcare.Ifdamageddo

notuse;callyourlocalrepforreplacement.

3) CHAINMOUNTEXAMPLE;Installthechainintotheprovidedwirehanger.Securetheotherendofthechain

toastructure

usinghardwareratedfortheload.InstallthewirehangerontothesideofthetopIBHLEDchannel.Contactfactoryor

agencyconcerningareasthathavehighvibration,oroverheadcranesand/orhighvelocity.SEEFIGURE1.

Makesurethewiringhangersarefullyengagedintothesideholesonthetopchannel.Ifusing"S"hooks,makesure

allloopsarecrimpedclosed.

4) ConnecttheLEDhighbaywiringtolinewire,black‐to‐black,white‐to‐whiteandgreen‐to‐green.UseonlyUL

listedwiring

connectors105C(orgreater)andULlistedwiring(105Corgreater).UseonlyULlistedcords.

**NOTE:Purpleandgrayleadinsidethedrivercompartmentare0‐10V(lowvoltage)dimmingleads.Connecttodimming

lowvoltagewiringonly.

5) Cleanallresidues/fingerprintsfromthenewLEDhigh

bayandlens.Doublecheckallhanginghardwarebeforemovingonto

thenextinstallation.



SECTION2:SERVICINGIBH12LSHOWN

1) DisconnectallpowertotheIBHhighbaybeingservice.

2) Toaccessthedriver

,removethetwoscrewsattheendsoppositethesafetycableside.

3) Rotatetopdriverhousingtoitssideandremovethetwoscrewsholdingthechannelcover.FIGURE2A.

4) Rotatetheledhousingtoitsside(ifhangingbythetopchannel).SEEFIGURE2B.

5) Slide

thechannelcoveroffitssecuringclips.SEEFIGURE2.

6) Installnewdriverifneededinthesamelocation.Makesurethenewdriverhassameelectricalspecificationsastheold

driver.Markallwiringbeforeremovetheolddriver.

7) MakesuretoinstalltheEMIferritecore

ontothepowerleadsofthenewdriver.Ifpresentinyourassembly.

8) UseonlyULlistedcomponents,wiringandconnectors.

9) Whenserviceisdone,makesuretopushallledwiringbackintothedriverhousingbeforerotatingthedriverhousingto

closedposition.SEEFIGURE2Aand

FIGURE2B.Donotletwiringgetcaughtoutsidethetwoassemblies.

10) Tocleanlens

,removeonebottomendcoverandslidelensout.NOTE:LEDhousingismadefromaluminumsheets.Donot

overtightenscrewswhenre‐installingtheendcover.UsehandheldscrewdriverONLYtoremoveandinstallscrews.

11) Slidelensoutslowlyandcleanbothsidesof

lens.Cleanlenswillensureoptimallightoutput.SEEFIGURE3.

12) Reinstallthelensandendcoverwhencleaningisdone.Glosssideoflensfacesfloor

.

13) Maintenanceoftheluminairesshouldbeperformedbyperson(s)familiarwiththeluminaires’constructionandoperationand

anyhazardsinvolved.Regularfixturemaintenanceprogramsarerecommendedforoptimallightoutput.



Page4of4



LEDIMPORTANTSAFETYINSTRUCTIONS



Five‐yearlimitedwarranty.Warrantytermsarelocatedat(U459430REVF)

www.acuitybrands.com/customerresources/term_and_conditions.aspx

Lithonia Lighting IBH 11L MV - QTY 24 Installation guide

Brand: Lithonia Lighting

Model: IBH 11L MV - QTY 24

Category: Floodlights

Type: Installation guide

This manual is also suitable for

IBH 11L MV

Download PDF

report

Lithonia Lighting IBH 11L MV - QTY 24 Installation guide

This manual is also suitable for

Lithonia Lighting IBH 11L MV - QTY 24 Installation guide

Related papers

Other documents