Dow Great Stuff Pro 187273 User manual

Brand: Dow Great Stuff Pro

Model: 187273

Type: User manual

enhanced protection on every level

professionally sealed with

great stuff pro

™

products

US/CANADA . RESIDENTIAL

Plumbing stack vent

Interior partitions

Attic hatch

Kitchen fan vent

Light ﬁxtures/electrical

outlets (outside perimeter

of electrical boxes)**

Doors

Typical Sources of Air Leaks

Outdoor faucet

Chases/sofﬁts/drop

ceilings

Cracks/separation in

foundation wall/basement

ﬂoor

Floor drain/weeping tile

Dryer vent

Holes and tears in

housewrap/vapor barrier

Sill plate

Windows

Entry points for electrical

service, TV cable and

telephone

Bathroom fan vent

professionally sealed

Air inﬁltration can cause:

•Increasedheating/coolingbills

•Excessfuelconsumptiontocondition

the

home’sinterior

•Heating/coolingsystemoveruse,which

canshortenitslifeorcausethehometo

requirealargerunitthannecessary

•Increasedgreenhousegas

emissions

•

Entryofunwantedmoisture,

dust

orotherallergens,noise,

insects,

etc.

Don’twasteanytime,seal

these

airleakswitheasy-to-use

GREAT

STUFFPRO

™

products.

onlyafewdollarspercan,

GREAT

STUFFPRO

™

Insulating

Foam

Sealantscansave

big

bucks.

AIR LEAKS ARE A BIG WASTE

Compressing

ﬁberglass insulation

causes it to lose

insulating value.

Stufﬁng ﬁberglass

insulation into narrow,

hard-to-ﬁll gaps leads

to limited insulation

value and a poor

air seal.

* Source: www.energystar.gov

** Before applying, turn off electrical power to that area of the home.

Be sure that wiring has protective covering. Never apply foam to

exposed wiring or inside an electrical box.

Air inﬁltration accounts for

25%-40% of a home’s energy loss.*

GREAT STUFF PRO

™

Insulating

Foam Sealants can ﬁll the void.

exceptional product performance

Professionally Sealed

Attic hatch Electrical wire penetration Plumbing penetration Sill plate

®™ Trademark of The Dow Chemical Company (“Dow”) or an afﬁliated company of Dow

In a study conducted by Dow and D.R. Nelson & Associates, air loss was measured

in 15 homes using blower door tests. Potential energy savings were estimated using

REM Home Energy Analysis Software. Results vary based on construction, style, year

built, and other distinct home characteristics. Participating homeowners were current

employees of Dow.

GREAT STUFF PRO

™

Gaps & Cracks Insulating Foam

Sealant is a minimal-expanding gap/crack ﬁller.

•Formsapermanent,airtightandwater-resistantbond

•Fills,sealsandinsulatesgapsupto3"(76mm)

•Tack-freein5-10minutes;trimswithin1hour

•Foamelasticityallowsformovementwithinastructure

•Paintable/sandable

Estimated Yields for GREAT STUFF PRO

™

Gaps & Cracks

(1)

Can Size,

oz. (g)

Delivery Yield, linear

ft (m)

Number of

Quart Tubes

of Caulk

Replaced by

Can

24 (681) Gun 970 (296) Up to 22

24 (681) Reusable

Straw

775 (236) Up to 18

(1) Based on ideal conditions and 3/8" (1 cm) diameter bead.

See How Easy*

Project Seal rim joist

Product GREAT STUFF

PRO

™

Gaps &

Cracks Insulating

Foam Sealant

Energy Savings $125 annually

Payback <3 months

Return on

Investment

600%

In the United States,

GREAT STUFF PRO

™

Gaps & Cracks was

the ﬁrst foam to

be recognized as

a ﬁreblock, which

means it resists

the free passage

of ﬂames to other

areas of the building

through concealed

spaces. The foam is

a bright orange color,

easily identiﬁable by

U.S. code ofﬁcials.

GREAT STUFF PRO

™

GAPS & CRACKS INSULATING FOAM SEALANT

strong bond

GREAT STUFF PRO

™

Window & Door Insulating Foam Sealant is

exclusively formulated to stop drafts by air sealing the gap between

the window or door and its rough opening.

•Lowpressure-buildformulationprovennottodistortorbowwindow

and door frames when applied properly*

•Formsadurable,airtight,moisture-resistantbond

•Tack-freein5-10minutes;trimswithin1hour

•Flexiblesealremainspliableduringexpansionandcontraction

•Easytopushandrepositionfoamifgapisoverlled

GREAT STUFF PRO

™

Wall & Floor Adhesive is a

premium-grade,heavy-dutyadhesiveforinteriorand

exterior use. Available in 26.5 oz (751 g) cans.

Secures Common Substrates

•Drywall

•Interioracousticalceilingtiles

•Lumber,particleboardandplywood

•Masonry,tileandconcrete

•STYROFOAM

™

Brand Extruded Polystyrene Foam

Insulation

Beneﬁts

•Excellentbondingpower;fewerfastenersarerequired

in drywall applications

•Adherestodry,dampandfrozenlumber

•All-weatherformulationenhancesproductivity

•Freeze/thawstability

•Fast-grabtack;initialbondinapproximately2hours

when applied properly

•Highyield(onecanequivalentupto16quarttubesof

caulk adhesive)**

• Long-termbondreduceslikelihoodofdrywallnailpops

andoorsqueaks

•RecommendedusewithICF(insulatedconcreteform)

and SIP (structural insulated panel) construction

GREAT STUFF PRO

™

WINDOW & DOOR

INSULATING FOAM SEALANT

Reduce nail pops in drywall attachment and use fewer

fasteners with GREAT STUFF PRO

™

Wall & Floor Adhesive.

GREAT STUFF PRO

™

WALL & FLOOR ADHESIVE

*Up to 30 days

Estimated Yields for GREAT STUFF PRO

™

Window & Door

Can Size, oz. (g) Delivery Number of

Windows

(1)

20 (567) Straw 6-9

20 (567) Gun 8-11

(1) Based on ideal conditions and 36" x 60" (1 m x 1.5 m) window,

3/8" (1 cm) wide gap, 1" (25 mm) deep, 3/8" diameter bead.

®™Trademark of The Dow Chemical Company (“Dow”) or an afﬁliated company of Dow

*TestedtoAAMA812-04pressure-buildat0.08psi(gunfoam).

**Based on ideal conditions and 1/4" (6 mm) diameter bead.

30-Day Restartability

• Designedtocreateair-andmoisture-tightseal

between gun and can

• Sealpreventsfoamincanfromcuringandblocking

dispensing valve

• Storecanuprightwithgunsecurelyattachedand

ﬂow control knob closed for up to 30 days

Pinpoint Control

• Flowcontrolforvaryingbeadsizefrom1/8"to3"

(0.3 cm to 8 cm)

• One-handoperationforeasyapplication

Maximum Yield

• Nopost-dispensingfoamdrip

• Lessfoamwasteduetorestartabilityandpinpointcontrol

®™Trademark of The Dow Chemical Company (“Dow”) or an afﬁliated company of Dow

• Innovativesolutionsimpliesuncuredpolyurethanefoam

cleanup

• WorkswithPROSeriesfoamdispensingguns

• Inexpensiveandeasytouse

• Formulatedtogiveexceptionalresultscleaninguncured

foam from gun or can surface

PRO SERIES FOAM DISPENSING GUNS GREAT STUFF PRO

™

GUN CLEANER

Remove uncured foam

from gun.

Remove uncured foam

from gun adapter on can.

Cleaner with red spray nozzle attached.

Cleaner with black gun adapter mechanism.

Attach gun to can. Clean residual uncured

foam from inside of gun.

INCLUDES TWO OPERATING

ATTACHMENTS:

When using to

clean gun or

cans, always

point away from

people and

open ﬂames.

precise delivery

• Premiummodelwithstainless

steel barrel for longer life

• Nonstickcanadapter,needle

and check valve

• Smoothdispensingnozzle

• Durable,lightweight,high-strength

aluminum body

•Nonstickcanadapter

•Replaceablesmoothdispensingnozzle

•Includesoneneedle-nosetip

PRO 15

PRO 14

PRO 13

• MosteconomicalGREATSTUFFPRO

™

gun

• Lightweight,durableplastichandleand

body with metal trigger

•Replaceablebarbeddispensingnozzle

• Includestwo8"plasticextensionstraws

andtwo2"cone-shapedtips

®™Trademark of The Dow Chemical Company (“Dow”) or an afﬁliated company of Dow

Habitat for Humanity is a registered service mark owned by Habitat for Humanity International

Printed in U.S.A.

FormNo.179-07481-0314CDP

178-00460-0314CDP

NOTICE: No freedom from any patent owned by Dow or others is to be inferred. Because use conditions and applicable laws may differ from one location to another and may change with time, Customer is responsible for

determining whether products and the information in this document are appropriate for Customer’s use and for ensuring that Customer’s workplace and disposal practices are in compliance with applicable laws and other

government enactments. The product shown in this literature may not be available for sale and/or available in all geographies where Dow is represented. The claims made may not have been approved for use in all countries

or regions. Dow assumes no obligation or liability for the information in this document. References to “Dow” or the “Company” mean the Dow legal entity selling the products to Customer unless otherwise expressly noted.

NOEXPRESSWARRANTIESAREGIVENEXCEPTFORANYAPPLICABLEWRITTENWARRANTIESSPECIFICALLYPROVIDEDBYDOW.ALLIMPLIEDWARRANTIESINCLUDINGTHOSEOFMERCHANTABILITYANDFITNESS

FORAPARTICULARPURPOSEAREEXPRESSLYEXCLUDED.

Dow Polyurethane Foam Insulation and Sealants

CAUTION:Whencured,theseproductsarecombustibleandwillburnifexposedtoopenameorsparksfromhigh-energysources.Donotexposetotemperaturesabove240ºF(116ºC).Formoreinformation,consultMSDS,

callDowat1-866-583-BLUE(2583)orcontactyourlocalbuildinginspector.Inanemergency,call1-989-636-4400intheU.S.or1-519-339-3711inCanada.

GREAT STUFF PRO™ Insulating Foam Sealants contain isocyanate and a ﬂammable blowing agent. Read the labels and Material Safety Data Sheets carefully before use. Eliminate all sources of ignition before use. Wear long

sleeves,gloves,andgogglesorsafetyglasses.Provideadequateventilationorwearproperrespiratoryprotection.Contentsunderpressure.

GREAT STUFF PRO™ Gun Cleaner is ﬂammable and contains acetone and propane. Read the label and Material Safety Data Sheet carefully before use. Eliminate all sources of ignition before use. Wear gloves, and goggles or

safetyglasses.Provideadequateventilationorwearproperrespiratoryprotection.Contentsunderpressure.

Building and/or construction practices unrelated to building materials could greatly affect moisture and the potential for mold formation. No material supplier including Dow can give assurance that mold will not develop in any

speciﬁc system.

THEDOWCHEMICALCOMPANY.DowBuildingSolutions.200Larkin.Midland,MI48674

DOW CHEMICAL CANADA ULC . Dow Building Solutions . Suite 2100 . 450 – 1st St., SW . Calgary, AB T2P 5H1

ForTechnicalInformation:1-866-583-BLUE(2583)(English).1-800-363-6210(French)

ForSalesInformation:1-800-232-2436(English).1-800-565-1255(French)

www.dowgreatstuff.com

CDP 44826