Procom M32-M-HC Installation guide





WOOD FIREPLACE MANTEL

Model #M32-M-HC/MO/U

Questions， problems, missing parts? Before returning to your retailer, call our customer

service department at 877-886-5989， 8:00a.m---4:30p.m, EST, Monday-Friday or e-mail

customerservice@usaprocom.com.



PC-M32-M-1201



2



PRODUCT SPECIFICATIONS



3



PACKAGE CONTENTS

PART DESCRIPTION QUANTITY PART NUMBER

A Top 1 M32-M-401-HC/MO/U

B Panel 1 M32-M-402-HC/MO/U

C Left Side Panel 1 M32-M-403-HC/MO/U

D Right Side Panel 1 M32-M-404-HC/MO/U

E Base 1 M32-M-405-HC/MO/U

If a part is missing or damaged - return to place of purchase (exterior wood

components are not replaceable).



4



HARDWARE CONTENTS

Part

Description Quantity

Picture

(Shown to size)

AA

Cam Dowel

15

Cam Lock 15

BB

CC

ST4 Screw

1 -9/16 in.

8

WARNINGSANDCAUTIONS

WARNING

• When tightening screws, do not over tighten, this may cause threads to strip. We recommend using a

hand-held screwdriver rather than a power screwdriver.

• Do not force screws into holes.

CAUTION

• For corner installations (optional); if baseboards are installed where the fireplace is intended to be

displayed, then the fireplace will not fit flush against the wall. For a proper flush fit, you may need to

remove part of the baseboard molding if necessary.

PREPARATION

Before beginning assembly of product, make sure all hardware contents parts are present. Compare parts with

package contents list and diagram above. If any part is missing or damaged, do not attempt to assemble the

product. Contact customer service for replacement parts.

Estimated Assembly Time: 15 minutes

Tools Required for Assembly: Phillips Screwdriver, Flathead Screwdriver, Drill, and Tape Measure.



5



ASSEMBLY INSTRUCTIONS

1. Screw the Cam Dowels (AA) into the Left Side Panel

(C) and Right Side Panel (D),insert the Cam Locks (BB)

into the Panel (B).Attach the Left Side Panel (C) and

Right Side Panel (D) to the Panel (B) by tightening the

Cam Locks (BB) as shown in Fig 1.

Fig 1

Hardware Used

Fig 2

2. Screw the Cam Dowels (AA) into Top (A), insert the

Cam Locks (BB) into the Left Side Panel (C), Right

Side Panel (D) and the Panel (B). Attach the Top (A)

into assembled frame (B, C, D) by tightening the Cam

Locks (BB) as shown in Fig 2.

Hardware Used

AA

BB

AA

BB

Cam Dowel

×4

Cam Lock

×4

Cam Dowel

×7

Cam Lock

×7



6



3. Screw the Cam Dowels (AA) into the Left Side Panel (C)

and Right Side Panel (D).Insert Cam Locks (BB) into the

Base (E). Attach the Base (E) into assembled frame (C, D)

by tightening the Cam Locks (BB) as shown in Fig 3.

Fig 3

Hardware Used

Fig 4

4. Fasten the wooden support brackets attached to the

Left Side Panel (C) and the Right Side Panel (D) to the

Top (A) and the Base (E) with ST4 Screw 1-9/16 in. (II) as

shown in Fig 4.

Hardware Used

AA

BB

CC

Cam Dowel

×4

Cam Lock

×4

ST4 Screw

1 -9/16 in.

×8



7



Fig 5

Fig 6

5. After assembling the mantel (A, B, C, D, E), lift upright

and push the insert from the front of the mantel as shown in

Fig 5.

6.Position the fireplace to the desired place as shown in

Fig 6.

GG



8



REPLACEMENT PARTS LIST

Part Description Part # Quantity

Hardware Package HP004 1

AA Cam Dowel PCAM-023 15

BB Cam Lock PCAM-023 15

CC ST4 Screw 1-9/16 in. GB/T 951 4×40 8



9

WARRANTY INFORMATION

Keep This Warranty

IMPORTANT: We urge you to fill out your warranty registration card within TEN (10) days of date of

installation, complete with the entire serial number which can be found on the rating plate attached to

your product. Retain this portion of the card for your records. Always specify model and serial numbers

when communicating with customer service.

Always specify model and serial numbers when communicating with customer service.

We reserve the right to amend these specifications at any time without notice. The only warranty

applicable is our standard written warranty. We make no other warranty, expressed or implied.

LIMITED WARRANTY:

PRO-COM warrants this product to be free from defects in materials and components for TWO (2) years

from the date of first purchase, provided that the product has been properly installed, operated and

maintained in accordance with all applicable instructions, to make a claim under this warranty, the Bill of

Sale or cancelled check must be presented.

RESPONSIBILITY OF OWNER

This warranty is extended only to the original retail purchaser. This warranty covers the cost of part(s)

required to restore this heater to proper operating condition and an allowance for labor when provided by

a PRO-COM Authorized Service Center.

Warranty part(s) MUST be obtained through authorized dealers of this product and/or PRO-COM who will

provide original factory replacement parts. Failure to use original factory replacement parts voids this

warranty. The heater MUST be installed by a qualified installer in accordance with all local codes and

instructions furnished with the unit.

WHAT IS NOT COVERED

This warranty does not apply to parts that are not in original condition because of normal wear and tear or

parts that fail or become damaged as a result of misuse, accidents, lack of proper maintenance or

defects caused by improper installation. Travel, diagnostic cost, labor, transportation and any and all

such other costs related to repairing a defective heater will be the responsibility of the owner.

TO THE FULL EXTENT ALLOWED BY THE LAW OF THE JURISDICTION THAT GOVERNS THE SALE

OF THE PRODUCT, THIS EXPRESS WARRANTY EXCLUDES ANY AND ALL OTHER EXPRESSED

WARRANTIES AND LIMITS THE DURATION OF ANY AND ALL IMPLIED WARRANTIES. INCLUDING

WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE TO TWO (2)

YEARS ON ALL COMPONENTS FROM THE DATE OF FIRST PURCHASE. PRO-COM'S LIABILITY IS

HEREBY LIMITED TO THE PURCHASE PRICE OF THE PRODUCT AND PRO-COM SHALL NOT BE

LIABLE FOR ANY OTHER DAMAGES WHATSOEVER INCLUDING INDIRECT. INCIDENTAL OR

CONSEQUENTIAL DAMAGES.

Some states do not allow a limitation on how long an implied warranty lasts or an exclusion or limitation of

accidental or consequential damages, the above limitation on implied warranties, or exclusion or

limitation on damages may not apply to you.

This warranty gives you specific legal right, and you may also have other rights that vary from state to

state

. Print in China

Procom M32-M-HC Installation guide

This manual is also suitable for

Procom M32-M-HC Installation guide

Related papers

Other documents