Specic
Information
Manual
230 Select
Manual Part Number: MRP 1902268
230 Select i
Manual Part Number: MRP 1902268
230 Se l e c t Sp e c i f i c in f o r m a t i o n ma n u a l
Ta b l e o f Co n T e n T s
1. Load Capacity ..........................................................1
2. Passenger Locations ...............................................1
3. Safety Label Locations ............................................ 2
4. Basic Boat Dimensions and Clearances .................4
5. Function and Location of Through-Hull Cutouts ......5
6. Helm, Gauge & Switch Layout .................................6
7. Deck Layout .............................................................7
8. Cleats .......................................................................8
9. Navigation and Anchor Lights ..................................8
10. Bilge Layout ...........................................................8
11. Fire Extinguishing System (Optional) .................... 8
12. Fuel System ...........................................................8
13. Entertainment System ........................................... 8
14. Rear Facing Lounger (Optional) ............................9
15. Canvas ................................................................... 9
16. Electrical Schematic ..............................................9
Information in this publication is based upon the latest product specifications available at printing. Sea Ray
®
Boats, Inc. reserves the right to make changes at any time, without notice, in the colors, equipment, specifications,
materials and prices of all models, or to discontinue models. Should changes in production models be made, Sea
Ray
®
is not obligated to make similar changes or modifications to models sold prior to the date of such changes.
Owner’s Manual
230 Select
Printed in the U.S.A. June 2008
Sea Ray Boats, Inc. 2600 Sea Ray Blvd., Knoxville, TN 37914
For information call 1-800-SRBOATS or fax 1-314-213-7878
(International 1-314-216-3333)
Internet Address: http://www.searay.com
Note: Not all accessories shown in pictures or described herein are
standard equipment or even available as options.
Options and features are subject to change without notice.
The following are registered trademarks of the Brunswick Corporation: Sea Ray
®
& The SR Wave Logo
230 Selectii
Manual Part Number: MRP 1902268
THIS PAGE INTENTIONALLY LEFT BLANK
1
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
1. Lo a d Ca p a C i t y
Refer to the General Information Manual for a
detailed explanation of Load Capacity.
Never carry more weight or passengers than indicated
on the certification plate, regardless of weather or
water conditions.
The boat can capsize, swamp or sink.
! DANGER
Rotating propellers can injure or kill you.
Shut off engine when persons are in water near
boat, or on swim platform or ladder.
! DANGER
Rear facing transom seats MUST NOT be used while
engine is running or boat is moving.
! WARNING
2. pa s s e n g e r Lo C a t i o n s
Refer to the General Information Manual for a
detailed explanation of Passenger Locations.
Boat motion can be erratic.
You can fall overboard or be injured by hitting
something in or on the boat.
All persons must be in cockpit area or cabin and be
prepared for sudden boat movement.
Use front or bow deck area only during anchoring,
mooring or emergencies.
! WARNING
Wet decks are slippery.
You can be seriously injured if you slip and fall.
Wear slip resistant footwear secured to your feet and
hold on to rails or boat structure.
! WARNING
C
726
230 Select
9
Bu i l d e r ’S pl a t e (i n t e r n a t i o n a l )
(fi g . 1.1)
BOAT MANUFACTURER
MFR’S MODEL
DESIGNATION
MAXIMUM NUMBER
OF PASSENGERS
MAXIMUM LOAD
CAPACITY
Bu i l d e r ’S pl a t e (d o m e S t i c )
(fi g . 1.2)
MAXIMUM CAPACITIES
10 PERSONS OR 1400 LBS.
1600 POUNDS, PERSONS, GEAR
STEERING, FUEL AND ELECTRICAL SYSTEMS
THIS BOAT COMPLIES WITH U.S. COAST
GUARD SAFETY STANDARDS IN EFFECT ON
THE DATE OF CERTIFICATION
MODEL: 230 Select
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
Certified
NMMA
pa S S e n g e r lo c a t i o n S
(fi g . 1.3)
ACCOMMODATION DECK
(DECK AREA INTENDED FOR
OCCUPATION DURING NORMAL
OPERATION)
2
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
3. sa f e t y La b e L Lo C a t i o n s
Sa f e t y la B e l lo c a t i o n S
(fi g . 2.1)
TO AVOID RISK OF SERIOUS INJURY OR DEATH
SHUT OFF ENGINE WHEN NEAR SWIMMERS
OR PRIOR TO USING SWIM PLATFORM AND
BOARDING LADDER.
MRP 1745519 SR-7214
DANGER
!
MRP 1745157 SR-7119A
DANGER
!
NO SMOKING
GASOLINE VAPORS ARE EXPLOSIVE
NOTICE
GASOLINE RECOMMENDATION
Minimum octane rating of 87 AKI.
Refer to the engine owner’s manual for
additional information.
LEAKING FUEL IS A FIRE AND EXPLOSION
HAZARD. INSPECT SYSTEM REGULARLY.
EXAMINE FUEL TANKS FOR LEAKS OR
CORROSION AT LEAST ANNUALLY.
MRP 1745513 SR-7151
WARNING
!
STAY CLEAR OF MOVING PARTS
WHILE ENGINE IS RUNNING.
MRP 1745512 SR-7149
DANGER
!
LOCATED ON UNDERSIDE OF MOTOR BOX
CHECK BAT T E R Y C EL L FLUID LEVEL
APPROXIMATELY EVERY 4 WEEKS, AND MORE
OFTEN IN SUMMER AND HOT ZONES.
MRP # 1746895 SR-7139
NOTICE
ONLY ON BOATS WITHOUT AN OPTIONAL
AUTOMATIC FIRE SUPPRESSION SYSTEM
MRP #1744762 SR-766
MAXIMUM CAPACITIES
10 PERSONS OR 1600 LBS.
1600 POUNDS, PERSONS, GEAR
STEERING, FUEL AND ELECTRICAL SYSTEMS
THIS BOAT COMPLIES WITH U.S. COAST
GUARD SAFETY STANDARDS IN EFFECT ON
THE DATE OF CERTIFICATION
MODEL: 230 SELECT
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
Certified
NMMA
C
726
230 Select
9
IN LIEU OF NMMA CAPACITY PLATE ON
INTERNATIONAL BOATS
MRP 1745125 SR-7111
WARNING
!
USE CAUTION WITH SKIER IN TOW
AS TOW ROPE MAY BACKLASH INTO
COCKPIT WHEN RELEASED
CARBON MONOXIDE CAN BE FATAL. In all gasoline powered boats, engine exhaust stems
produce colorless and odorless carbon monoxide gas (“CO”). Direct prolonged exposure can result in
CO poisoning which may be harmful or FATAL. To prevent excess exposure and reduce the possibility of
accumulations of CO in the boat, the operator should include adequate ventilation through ultilization of cabin
hatches and walk-through windshields to increase air movement through the boat. The following conditions tend
to increase the accumulation of CO in and about the boat and require the operator’s particular attention:
INDICATIONS OF EXCESSIVE EXPOSURE TO “CO” CONCENTRATIONS MAY INCLUDE NAUSEA, DIZZINESS, HEADACHE AND DROWSINESS,
AVOID RISK OF INJURY OR DEATH, SHUTOFF ENGINE NEAR SWIMMERS OR PRIOR TO USING SWIM PLATFORM, SUNPAD OR BOARDING LADDER.
USE CAUTION WITH SKIER IN TOW AS TOW ROPE MAY BACKLASH INTO COCKPIT WHEN RELEASED
AVOID COLLISIONS - high
boat trim angles, persons and gear. Such issues are considered under the control of the operator.
NOTICE: It is recommended that all occupants wear approved Personal Flotation Devices (PFD’s).
! DANGER
! WARNING
MRP# 1601301
SR-509
!
WARNING
Carbon monoxide (CO) can cause brain damage or death.
Engine and generator exhaust contains odorless and colorless carbon monoxide gas.
Signs of carbon monoxide poisoning include nausea, headache, dizziness, drowsiness,
and lack of consciousness.
Get fresh air if anyone shows signs of carbon monoxide poisoning.
See Owner's Manual for information regarding carbon monoxide poisoning.
NW-204-05
x
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
MRP 1831429
!
DANGER
Carbon monoxide (CO) can cause brain damage
or death.
Engine and generator exhaust contains odorless
and colorless carbon monoxide gas.
Carbon monoxide will be around the back of the
boat when engines or generators are running.
Move to fresh air, if you feel nausea, headache,
dizziness, or drowsiness.
NW-206-05
x
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
MRP 1811367
DISCHARGE OF OIL OR OILY WASTE INTO NAVIGABLE WATERS IS
PROHIBITED OF SUCH A DISCHARGE CAUSES A FILM, SHEEN OR
A DISCOLORATION OF THE SURFACE, OR CAUSES A SLUDGE
OR EMULSION BENEATH THE SURFACE OF THE WATER.
VIOLATORS ARE SUBJECT TO PENALITIES.
MRP # 1745514 SR-7166
CE OPTION ONLY
VISIBILITY FROM THIS HELM STATION IS
LIMITED AVOID COLLISIONS-MAINTAIN
LOOKOUT AS REQUIRED IN ‘RULES
OF THE ROAD’ BY US COAST GUARD
MRP # 1752856 SR-7153
WARNING
!
3
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
sa f e t y La b e L Lo C a t i o n s (Co n t i n u e d )
Sa f e t y la B e l lo c a t i o n S
(fi g . 3.1)
MRP 852558
TO AVOID RISK OF SERIOUS INJURY SUN PAD MUST
BE IN DOWN POSITION WHEN ENGINE IS RUNNING.
DANGER
!
IF SWITCH IS TURNED OFF WHILE
ENGINE IS RUNNING ALTERNATOR
WILL BE DAMAGED.
MRP # 1746901 SR-7167
ON BATTERY SWITCH PANEL
CAUTION
!
MRP 1798084
CALIFORNIA RESIDENTS ONLY
BOATS SOLD IN THE STATE OF CALIFORNIA IN
ACCORDANCE WITH CALIFORNIA HEALTH &
SAFETY CODE §§ 25249.5-.13:
ONLY ON BENCH SEAT OPTION
MOTORBOX SEATING PLANS
TRANSOME BENCH SEAT SEATING PLAN
4
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
4. ba s i C bo a t di m e n s i o n s a n d CL e a r a n C e s
(D) 6’ 4” (1.93 m)
Bo a t di m e n S i o n S a n d cl e a r a n c e S
(fi g . 4.1)
(A) Overall Length
With Std. Swim Platform ......... 23ft. 0in. 7.01 m
(B) Beam (Width) ........................... 8ft. 6in. 2.59 m
(C) Draft (Stern Drive Down) ......... 38in.* 96.5 cm*
Draft (Stern Drive Up) .................... 23in.* 58.4 cm*
Dry Weight ..................................... 4,244 lbs. 1,925 kg.
Fuel Capacity ................................. 50 gal. 189.3 liters
Usable Fuel ................................... 45 gal. 170.3 liters
Dead Rise ...................................... 21°
230 Select SpecificationS HeigHt DimenSionS
(D) Keel to Top of Windshield ..............6ft. 4in. 1.93 m
(E) Waterline to Top of Windshield .......4ft. 5in. 1.35 m
(C) 38”
(96.5 cm)
(A) 23’ (7.01 m)
WATERLINE
KEEL
(B)
8’ 6” (2.59 m)
(E) 4’ 5” (1.35 m)
NOTE: DIMENSIONS CAN
AND RUNNING CONDITIONS
5
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
5. fu n C t i o n a n d Lo C a t i o n o f th r o u g h -hu L L Cu t o u t s
po r t th r o u g h -hu l l cu t o u t S
(fi g . 5.1)
Bi l g e th r o u g h -hu l l cu t o u t S
(fi g . 5.3)
tr a n S o m th r o u g h -hu l l cu t o u t S
(fi g . 5.4)
GARBOARD DRAIN
TRANSDUCER
STERN EYE BOLTS
(2 EACH PORT & STBD)
PORT
DOCKING
LIGHT (OPT)
CORSA™
EXHAUST
(OPT)
PORT DASH
COOLER
DRAIN
STARBOARD
DOCKING
LIGHT (OPT)
CORSA™
EXHAUST
(OPT)
BILGE PUMP
DRAIN
St a r B o a r d th r o u g h -hu l l cu t o u t S
(fi g . 5.2)
6
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
6. he L m , ga u g e & sw i t C h La y o u t
he l m la y o u t (St a n d a r d )
(fi g . 6.1)
SPEEDOMETER
STEREO REMOTE
QUAD GAUGE
INSTRUMENT PANEL
COMPASS SPEAKER
SYSTEM TACH
SWITCH PANEL
he l m la y o u t (co n f i g u r e d w/ op t i o n a l gpS)
(fi g . 6.2)
TRIM
FUEL
GPS (OPT)
GASOLINE VAPORS CAN EXPLODE
STOP
DOCKING
LIGHTS
WA RNING
NAV
LIGHTS
!
BEFORE STARTING ENGINE: CHECK ENGINE COMPARTMENT BILGE FOR GASOLINE OR VAPORS. OPERAT E BLOWER FOR
FOUR MINUTES AND VERIFY BLOWER OPERA T ION. RUN BLOWER WHEN VESSEL IS OPERATING BELOW CRUISING SPEEDS.
IF SYSTEM DISCHARGES, SHUTDOWN ENGINE, BLOWER, AND ELECTRICAL SYSTEM.
ANCHOR
LIGHT
HORN
RESULTING IN INJURY OR DEAT H
AUTOMATIC EXTINGUISHING SYSTEM
ENGINE
BILGE
PUMP
THRU-HULL
EXHAUST
START
LIGHT ON -UNIT CHARGED
LIGHT OFF -UNIT DISCHARGED
WIPER
RUN
COCKPIT
LIGHTS
BILGE
BLOWER
ACCY
co n t r o l St a t i o n Sw i t c h pa n e l
(fi g . 6.3)
7
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
7. de C k La y o u t
ge n e r a l la y o u t
(fi g . 7.1)
ANCHOR LIGHT
SIDE PANEL STORAGE)
SWIM LADDER
LOCKABLE SKI/
WAKEBOARD
STORAGE
CONTROL STATION
DEDICATED COOLER
STORAGE (BELOW SEAT)
AFT JUMP SEATS
ADJUSTABLE HELM
SEAT W/ FLIP-UP
THIGH RISE
HORN
SIDE PANEL
STORAGE
BOW SEATING
(W/ STORAGE BELOW)
W/ STEREO
FUEL FILL
SUNPAD
SWIM PLATFORM
ANCHOR STORAGE/
BEACH BOARDING
LADDER (OPT)
BUCKET SEAT W/
FLIP-UP THIGH RISE
BOW BLOCK-OFF
DOOR
MOTOR BOX
HATCH
BUILT-IN
INSULATED ICE CHEST
8
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
8. CL e a t s
Cleats must not be used for lifting the boat; they
are intended for docking or mooring use only.
cl e a t lo c a t i o n S
(fi g . 8.1)
9. na v i g a t i o n a n d an C h o r Li g h t s
See General Information Manual for a detailed
explanation of the anchor lights.
10. bi L g e La y o u t
Bi l g e la y o u t
(fi g . 8.3)
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
STERN EYE
STERN EYE
ANCHOR LIGHT
BULB REPLACEMENT
FUSE TYPE BULB
BULB REPLACEMENT
BULB# GE2641L
PORT/STBD COMBO
na v i g a t i o n a n d an c h o r li g h t S
(fi g . 8.2)
ANCHOR LIGHT (STD)
PORT & STBD
COMBO LIGHT
BATTERIES
POWER TRIM PUMP
AUTOMATIC FIRE EXTINGUISHER (OPT)
BLOWER
FUEL TANK
TRANSDUCER (OPT)
BILGE PUMP & FLOAT SWITCH
E
F
G
A
B
C
D
F
E
G
A
C
B
D
12. fu e L sy s t e m
The 230 Select standard gasoline fuel system
consists of a 40 gallon (151 liter) fuel tank, fuel tank
vent, anti-siphon valve, engine fuel supply line and
fuel fill.
11. fi r e ex t i n g u i s h i n g sy s t e m
(op t i o n a L )
Your 230 Select has an automatic fire extinguisher
system option. Refer to the General Information
Manual for a detailed explanation of the automatic
fire extinguisher system.
13. en t e r t a i n m e n t sy s t e m
The 12 volt AM/FM radio single CD stereo is located
in the port glove box.
The system includes six (6) water proof speakers,
a subwoofer, a digital remote control located at
the control station and an optional remote on the
transom. An optional speaker system is available
with the Water Sports Tower option.
9
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
14. re a r fa C i n g Lo u n g e r
(op t i o n a L )
The optional transom bench seat flips up to convert
the sun pad to a rear facing lounger.
Remove the sun pad filler cushion, lift the bench
seat up and place the support brace into the recess
on the seat base.
DO NOT operate the boat while the seat/sun pad
is in the UP position.
IN DOWN POSITION WHEN ENGINE IS RUNNING.
! WARNING
co n v e r t i B l e Be n c h Se a t /re a r fa c i n g lo u n g e r
( fi g . 9.1)
BENCH SEAT FILLER CUSHION
TRANSOM BENCH SEAT (DOWN POSITION)
AFT FACING SUN LOUNGER(UP POSITION)
SUN PAD SUPPORT BRACE
15. Ca n v a s
The optional canvas package consists of:
The Canvas Cockpit Cover w/ Tonneau is also
available as an individual option as well as a
Forward Bow Bimini Top w/ Boot.
! DANGER
Exhaust fumes from engines contain deadly carbon
monoxide gas (CO). Boats enclosed with canvas or with
poor ventilation are most likely to collect fumes.
CO sickness symptoms include headache, nausea
and dizziness. Do not mistake these symptoms for
sea sickness.
Ventilate boat. See Section 1.4, Carbon Monoxide, for
more details.
Do not use the rear (aft) curtain while engine is
running or boat is moving.
16. eL e C t r i C a L sC h e m a t i C s
This owner's manual contains electrical schematics
and wiring harness illustrations for your boat. These
electrical schematics were generated by electrical
CAD designers at the engineering division for
technical reference and service technicians. Sea
Ray
®
does not recommend that you attempt to work
on the boat’s electrical system yourself. Instead,
we recommend that you take your boat to your
authorized Sea Ray
®
dealer for service. Sea Ray
®
reserves the right to change or update the electrical
system on any model at any time without notice to
the consumer and is NOT obligated to make any
updates to units built prior to changes.
10
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
dc wi r i n g di a g r a m (1 o f 3)
drawing no. 09-601 (1 of 3)
(fi g . 10.1)
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
11
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
dc wi r i n g di a g r a m (2 o f 3)
drawing no. 09-601 (2 of 3)
(fi g . 11.1)
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
12
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
dc wi r i n g di a g r a m (3 o f 3)
drawing no. 09-601 (3 of 3)
(fi g . 12.1)
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
13
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
Bi l g e ha r n e S S
drawing no. 09-871 (3 o f 3)
(fi g . 13.1)
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
pr e m i e r St e r e o ha r n e S S
drawing no. 09-874
(fi g . 13.2)
BLOWER
TRIM PUMP
BILGE PUMP
FUEL SENDER
PLUG TO DECK
HARNESS
FWD PORT
STEREO AMP
BILGE COMPONENT
BOARD V401
STEREO REMOTE
TURN ON
14
230 Se l e c t ow n e r S ma n u a l
230 Select
Manual Part Number: MRP 1902268
de c k ha r n e S S
drawing no. 09-876 (1 o f 2)
(fi g . 14.1)
Bi l g e ha r n e S S
drawing no. 09-876 (2 o f 2)
(fi g . 14.2)
FWD
STBD
TRANSOM
STEREO
REMOTE
DECK TO
BILGE
CONNECTOR
FWD
PORT
DECK TO
BILGE
HARNESS
PLUG
STBA BOW
COCKPIT
LIGHT
HORN
BOW
LIGHT
STEREO STBD
TO PORT
ROUTING
STEREO
PLUG
TRANSOME
STEREO REMOTE
STBD AFT
LED LIGHT
STBD FWD
LED LIGHT
STBD DASH
LED LIGHT
PORT DASH
LED LIGHT
PORT FWD
LED LIGHT
PORT AFT
LED LIGHT
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
Index i
230 Select
in d e x
Manual Part Number: MRP 1902268
a
Anchor Lights ...............................................................8
C
Canvas.........................................................................9
Clearances .................................................................. 4
Cleats .......................................................................... 8
d
Deck Layout .................................................................7
Dimensions .................................................................. 4
e
Electrical Schematics .................................................. 9
f
Fire Extinguishing System ...........................................8
Fuel System .................................................................8
g
Gauge Layout .............................................................. 6
h
Helm Layout.................................................................6
n
Navigation Lights .........................................................8
p
Passenger Locations ................................................... 1
r
Rear Facing Lounger ................................................... 9
s
Safety Label Locations ................................................ 2
Switch Layout .............................................................. 6
t
Through-Hull Cutouts .................................................. 5
Manual Part Number: MRP 1902268
THIS PAGE LEFT INTENTIONALLY BLANK
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
Sea Ray 2009 SEA RAY 230 SELECT Owner's manual
- Type
- Owner's manual
- This manual is also suitable for
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Sea Ray 2007 230 SELECT Owner's manual
-
-
-
-
-
-
-
-
-
Other documents
-
Tommy Docks TD-20240-2 Installation guide
-
Protocol 4382-2AA Porta Lounger User manual
-
S R Smith DS-1-61-2PK User manual
-
S R Smith D898.391 User manual
-
S.R.Smith R-Series™ Rotomolded Lounger In Pool-Chair Owner's manual
-
Coopers 10590 Operating instructions
-
RST Brands OP-OL04-Bei User guide
-
Noble House 297262 Installation guide
-
Noble House 41193 Operating instructions
-
Case Eos Platform Lounger User manual
