Dometic CoolMatic CSMP2 Operating instructions

Page is loading ...

EN

CSMP2

6

Please read this operating manual carefully before starting the device.

Keep it in a safe place for future reference. If the device is passed on to

another person, this operating manual must be handed over to the user

along with it.

The manufacturer cannot be held liable for damage resulting from improper usage

or incorrect operation.

Contents

1 Explanation of symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

2 Safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

3 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

4 Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

5 Technical description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

6 Installation and connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

7 Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

8 Cleaning and care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

9 Guarantee . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

10 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

11 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

CS-MP2-IO-West.book Seite 6 Dienstag, 14. März 2017 6:59 18

EN

CSMP2 Explanation of symbols

7

1 Explanation of symbols

D

!

A

I

2 Safety instructions

2.1 General safety

!

WARNING!

• Do not operate the device if it is visibly damaged.

• This device may only be repaired by qualified personnel. Improper

repairs can lead to considerable hazards.

• Persons (including children) whose physical, sensory or mental

capacities or whose lack of experience or knowledge prevent

them from using this product safely should not operate it without

the supervision or instruction of a responsible person.

• Electrical devices are not toys.

Always keep and use the device out of the reach of children.

• Children must be supervised to ensure that they do not play with the

device.

DANGER!

Safety instruction: Failure to observe this instruction will cause fatal or

serious injury.

WARNING!

Safety instruction: Failure to observe this instruction can cause fatal or

serious injury.

CAUTION!

Safety instruction: Failure to observe this instruction can lead to injury.

NOTICE!

Failure to observe this instruction can cause material damage and impair

the function of the product.

NOTE

Supplementary information for operating the product.

CS-MP2-IO-West.book Seite 7 Dienstag, 14. März 2017 6:59 18

EN

Safety instructions CSMP2

8

• If this device's power cable is damaged, it must be replaced by the

manufacturer, customer service or a similarly qualified person in order

to prevent safety hazards.

• Do not store any explosive substances such as spray cans with

propellants in the device.

!

CAUTION!

• Disconnect the device from the mains

– before cleaning and maintenance

–after use

• Food may only be stored in its original packaging or in suitable

containers.

A

NOTICE!

• Check that the voltage specification on the type plate corresponds to

that of the energy supply.

• The cooling device is not suitable for transporting caustic materials or

materials containing solvents.

• Disconnect the cooler and other power consuming devices from the

battery before connecting the quick charging device.

2.2 Operating the device safely

D

DANGER!

• Do not touch exposed cables with your bare hands. This especially

applies when operating the device with an AC mains power supply.

A

NOTICE!

• In order to work properly, the cooler must have been standing upright

for at least an hour before you switch it on.

• The cooler has a built-in inclination sensor which switches it off when it

is tilted. Nevertheless, always switch off the cooler before tilting the

cab.

Before switching the cooler on again, let it stand for at least 15 minutes

after lowering the cab.

• Do not use electrical devices inside the cooler unless they are

recommended by the manufacturer for the purpose.

• Install the device in a dry location where it is protected against

splashing water.

CS-MP2-IO-West.book Seite 8 Dienstag, 14. März 2017 6:59 18

EN

CSMP2 Scope of delivery

9

• Do not install the device near naked flames or other heat sources

(heaters, direct sunlight, gas ovens etc.)

• Danger of overheating!

Ensure at all times that there is sufficient ventilation so that the heat that

arises during operation does not build up. Make sure that the device

is sufficiently far away from walls and other objects so that the air can

circulate.

• Ensure that the ventilation slots are not covered.

• Do not fill the inner container with ice or fluid.

• Never immerse the device in water.

• Protect the device and the cable against heat and moisture.

3Scope of delivery

4 Intended use

The CoolMatic CSMP2 (ref. no. 9105204453) is a cooler for installing in a

Mercedes-Benz Actros (L and LH cab). It is suitable for cooling food.

!

Quantity Description

1Cooler

1 Set of fastening material

1 Operating manual

CAUTION! Be careful when cooling perishable medicines.

If you wish to cool medicines, please check if the cooling capacity of the

device is suitable for the medicine in question.

CS-MP2-IO-West.book Seite 9 Dienstag, 14. März 2017 6:59 18

EN

Technical description CSMP2

10

5 Technical description

5.1 Function description

The cooler chills products and keeps them cool. A maintenance-free refrigerant

circuit with compressor provides the cooling.

The cooler is designed for continuous operation at ambient temperatures between

–10 °C and +55 °C and air humidity up to 90 %.

It can be tilted sideways up to 30°.

Before exposing the cooler to extreme conditions – such as on expeditions – please

contact the manufacturer. All materials used in the cooling device are compatible for

use with foodstuffs.

Battery monitor

The device is equipped with a multi-level battery monitor that protects your vehicle

battery against excessive discharging when the device is connected to the on-board

12/24 V supply.

If the cooler is operated when the vehicle ignition is switched off, the cooler switches

off automatically as soon as the supply voltage falls below a set level. The cooler will

switch back on once the battery has been recharged to the restart voltage level.

A

The switch-off and switch-on points measured at the connection terminals of the

compressor are listed in the following table.

NOTICE! Risk of damage

When switched off by the battery monitor, the battery will no longer be

fully charged. Avoid starting repeatedly or operating electric consumers

without longer charging phases. Ensure that the battery is recharged.

Voltage

12 V 24 V

Cut-off voltage 11.3 V 24.6 V

Restart voltage 12.5 V 26.0 V

CS-MP2-IO-West.book Seite 10 Dienstag, 14. März 2017 6:59 18

EN

CSMP2 Installation and connection

11

5.2 Operating and display elements

6 Installation and connection

The cooler is installed in the drawer under the bed.

➤ Lift the mattress.

➤ Unscrew the four screws (fig. 1, page 3) and take off the board.

➤ Pull out the drawer and take out the container (fig. 2, page 3).

After you fit the cooler, you can put the container back in.

I

➤ Remove the screws (fig. 3 1, page 3) and unplug the panel beside the drawer

(fig. 3 2, page 3).

➤ Have the supply cable from slot X 7 (fig. 4, page 3) to the cooler laid by a

specialist Mercedes Benz garage.

➤ Cut out a section for ventilation at the appropriate position on the panel (fig. 5,

page 3).

➤ Push on the plate nuts supplied (fig. 6, page 3 and fig. 7, page 4).

➤ Feed the connection cable for the cooler through the hole provided (fig. 8,

page 4).

➤ Fasten the cooler with the screws provided at the appropriate positions (fig. 9,

page 4).

➤ Fasten the cooler cable to the position marked on the drawer using the clip

provided and place the rubber in the appropriate position (fig. 0, page 4).

➤ Have the cooler cable connected to the cable laid by the Mercedes-Benz garage

from the fuse box behind the cover panel (fig. a, page 4).

➤ Push the drawer back in (fig. b, page 4).

No. in

fig. c,

page 5

Description Explanation

1 Temperature controller – Switches the cooler on or off

– Adjusts the temperature

NOTE

If you cannot fully pull out the drawer, this is how to release it:

CS-MP2-IO-West.book Seite 11 Dienstag, 14. März 2017 6:59 18

EN

Operation CSMP2

12

➤ Screw the lock tight again and put the panel back on.

➤ Fasten the board again and put the mattress back on.

✓ Installation is complete.

7Operation

I

7.1 Before initial use

I

7.2 Energy saving tips

• Allow hot food to cool down first before you place it into the device.

• Do not open the cooler more often than necessary.

• Do not leave the cooler open for longer than necessary.

• Avoid unnecessarily low temperature settings.

7.3 Using the cooler

A

➤ Switch on the cooler on by turning the temperature control knob to the right.

✓ The cooler starts cooling the interior.

NOTE

Empty the cool box and switch it off before tilting the cab.

NOTE

Before starting your new cooler for the first time, you should clean it

inside and outside with a damp cloth for hygienic reasons

(see "Cleaning and care" on page 13).

NOTICE! Danger of overheating

Ensure at all times that there is sufficient ventilation so that the heat that

generated during operation can dissipate. Ensure that the ventilation

slots are not covered. Make sure that the device is sufficiently far away

from walls and other objects so that the air can circulate.

NOTICE! Danger from excessively low temperature

Ensure that the only those objects are placed in the cooler that are

intended to be cooled at the selected temperature.

CS-MP2-IO-West.book Seite 12 Dienstag, 14. März 2017 6:59 18

EN

CSMP2 Cleaning and care

13

➤ Set the cooling temperature using the temperature control knob.

Turn right = colder, turn left = warmer.

I

8 Cleaning and care

A

➤ Occasionally clean the inside of the device with a damp cloth.

9Guarantee

The statutory warranty period applies. If the product is defective, please contact the

manufacturer's branch in your country (see the back of the instruction manual for the

addresses) or your retailer.

For repair and guarantee processing, please include the following documents when

you send in the device:

• A copy of the receipt with purchasing date

• A reason for the claim or description of the fault

10 Disposal

➤ Place the packaging material in the appropriate recycling waste bins wherever

possible.

M

If you wish to finally dispose of the product, ask your local recycling centre

or specialist dealer for details about how to do this in accordance with the

applicable disposal regulations.

NOTE

If you do not want to use the cooler for a longer period of time:

Leave the cooler slightly open. This prevents smells from building up.

NOTICE! Danger of damaging the device

Never clean the device under running water or in dish water.

Do not use abrasive cleaning agents or hard objects during cleaning as

these can damage the device.

CS-MP2-IO-West.book Seite 13 Dienstag, 14. März 2017 6:59 18

EN

Technical data CSMP2

14

11 Technical data

The coolant circuit contains R134a.

Contains fluorinated greenhouse gases

Hermetically sealed equipment

Certification

The device has e1 certification.

This device conforms to the following EC guideline:

• EMC Directive 72/245/EEC version 95/54/EC

CSMP2

Ref. no.: 9105204453

Capacity: 25 litres

Voltage: 12/24 Vg

Cooling capacity: +10 °C to 0 °C

Coolant quantity: 30 g

CO2 equivalent: 0.043 t

Global warming potential (GWP): 1430

Weight: 12.5 kg

CS-MP2-IO-West.book Seite 14 Dienstag, 14. März 2017 6:59 18

Page is loading ...

AUSTRALIA

Dometic Australia Pty. Ltd.

1 John Duncan Court

Varsity Lakes QLD 4227

 1800 212121

 +61 7 55076001

Mail: [email protected]

AUSTRIA

Dometic Austria GmbH

Neudorferstraße 108

A-2353 Guntramsdorf

 +43 2236 908070

 +43 2236 90807060

Mail: [email protected]

BENELUX

Dometic Branch Office Belgium

Zincstraat 3

B-1500 Halle

 +32 2 3598040

 +32 2 3598050

Mail: [email protected]e

BRAZIL

Dometic DO Brasil LTDA

Avenida Paulista 1754, conj. 111

SP 01310-920 Sao Paulo

 +55 11 3251 3352

 +55 11 3251 3362

Mail: [email protected].br

DENMARK

Dometic Denmark A/S

Nordensvej 15, Taulov

DK-7000 Fredericia

 +45 75585966

 +45 75586307

Mail: [email protected]k

FINLAND

Dometic Finland OY

Mestarintie 4

FIN-01730 Vantaa

 +358 20 7413220

 +358 9 7593700

Mail: [email protected]

FRANCE

Dometic SAS

ZA du Pré de la Dame Jeanne

B.P. 5

F-60128 Plailly

 +33 3 44633525

 +33 3 44633518

Mail : vehiculesdeloisirs@dometic.fr

HONG KONG

Dometic Group Asia Pacific

Suites 2207-11 · 22/F · Tower 1

The Gateway · 25 Canton Road,

Tsim Sha Tsui · Kowloon

 +852 2 4611386

 +852 2 4665553

Mail: [email protected]

HUNGARY

Dometic Zrt. Sales Office

Kerékgyártó u. 5.

H-1147 Budapest

 +36 1 468 4400

 +36 1 468 4401

Mail: budapest@dometic.hu

ITALY

Dometic Italy S.r.l.

Via Virgilio, 3

I-47122 Forlì (FC)

 +39 0543 754901

 +39 0543 754983

Mail: vendite@dometic.it

JAPAN

Dometic KK

Maekawa-Shibaura, Bldg. 2

2-13-9 Shibaura Minato-ku

Tokyo 108-0023

 +81 3 5445 3333

 +81 3 5445 3339

Mail: [email protected]p

MEXICO

Dometic Mx, S. de R. L. de C. V.

Circuito Médicos No. 6 Local 1

Colonia Ciudad Satélite

CP 53100 Naucalpan de Juárez

Estado de México

 +52 55 5374 4108

 +52 55 5393 4683

Mail: [email protected].mx

NETHERLANDS

Dometic Benelux B.V.

Ecustraat 3

NL-4879 NP Etten-Leur

 +31 76 5029000

 +31 76 5029019

Mail: [email protected]l

NEW ZEALAND

Dometic New Zealand Ltd.

PO Box 12011

Penrose

Auckland 1642

 +64 9 622 1490

 +64 9 622 1573

Mail: [email protected]

NORWAY

Dometic Norway AS

Østerøyveien 46

N-3232 Sandefjord

 +47 33428450

 +47 33428459

Mail: firmapo[email protected]

POLAND

Dometic Poland Sp. z o.o.

Ul. Puławska 435A

PL-02-801 Warszawa

 +48 22 414 3200

 +48 22 414 3201

Mail: [email protected]

PORTUGAL

Dometic Spain, S.L.

Branch Office em Portugal

Rot. de São Gonçalo nº 1 – Esc. 12

2775-399 Carcavelos

 +351 219 244 173

 +351 219 243 206

Mail: [email protected]

RUSSIA

Dometic RUS LLC

Komsomolskaya square 6-1

RU-107140 Moscow

 +7 495 780 79 39

 +7 495 916 56 53

Mail: [email protected]

SINGAPORE

Dometic Pte Ltd

18 Boon Lay Way 06–140 Trade Hub 21

Singapore 609966

 +65 6795 3177

 +65 6862 6620

Mail: [email protected]

SLOVAKIA

Dometic Slovakia s.r.o. Sales Office Bratislava

Nádražná 34/A

900 28 Ivánka pri Dunaji

/ +421 2 45 529 680

Mail: bratislava@dometic.com

SOUTH AFRICA

Dometic (Pty) Ltd.

Regional Office

South Africa & Sub-Saharan Africa

2 Avalon Road

West Lake View Ext 11

Modderfontein 1645

Johannesburg

 +27 11 4504978

 +27 11 4504976

Mail: [email protected]

SPAIN

Dometic Spain S.L.

Avda. Sierra del Guadarrama, 16

E-28691 Villanueva de la Cañada

Madrid

 +34 91 833 60 89

 +34 900 100 245

Mail: [email protected]

SWEDEN

Dometic Scandinavia AB

Gustaf Melins gata 7

S-42131 Västra Frölunda

 +46 31 7341100

 +46 31 7341101

Mail: info@dometicgroup.se

SWITZERLAND

Dometic Switzerland AG

Riedackerstrasse 7a

CH-8153 Rümlang

 +41 44 8187171

 +41 44 8187191

Mail: [email protected]

UNITED ARAB EMIRATES

Dometic Middle East FZCO

P. O. Box 17860

S-D 6, Jebel Ali Freezone

Dubai

 +971 4 883 3858

 +971 4 883 3868

Mail: [email protected]

UNITED KINGDOM

Dometic UK Ltd.

Dometic House, The Brewery

Blandford St. Mary

Dorset DT11 9LS

 +44 344 626 0133

 +44 344 626 0143

Mail: custom[email protected]o.uk

USA

Dometic RV Division

1120 North Main Street

Elkhart, IN 46515

 +1 574-264-2131

GERMANY

Dometic WAECO International GmbH

Hollefeldstraße 63 · D-48282 Emsdetten

 +49 (0) 2572 879-195 ·  +49 (0) 2572 879-322

Mail: info@dometic-waeco.de

dometic.com

4445101990 207.5924.67 03/2017

CS-MP2-IO-West.book Seite 48 Dienstag, 14. März 2017 6:59 18

Dometic CoolMatic CSMP2 Operating instructions

This manual is also suitable for

Dometic CoolMatic CSMP2 Operating instructions

in other languages

Related papers

Other documents