STIEBEL ELTRON CK 15E User guide

Page is loading ...

_&.(&.7( :::67,(%(/(/752186$&20

&217(176_23(5$7,21

*(1(5$/,1)250$7,21

OPERATION

1. General information ________________________________ 2

1.1 Safety information ______________________________________ 2

1.2 Other symbols in this document _____________________ 3

2. Safety ________________________________________________ 3

2.1 Intended use _____________________________________________ 3

2.2 General safety information ___________________________ 3

2.3 General information ____________________________________ 4

2.4 Test symbols _____________________________________________ 4

2.5 Licences / certiﬁcates __________________________________ 4

3. Appliance description ______________________________ 4

3.1 Control with external room temperature control-

ler _________________________________________________________ 4

4. Operation CK 15 E / CK 20 E ________________________ 4

4.1 Starting heating _________________________________________ 4

4.2 Stopping heating / frost protection __________________ 4

5. Operation CKT 15 E / CKT 20 E _____________________ 5

5.1 Starting heating _________________________________________ 5

5.2 Adjusting the time switch _____________________________ 5

5.3 Stopping heating / frost protection __________________ 5

6. Cleaning, care and maintenance __________________ 5

7. Storage _______________________________________________ 5

8. Troubleshooting _____________________________________ 5

INSTALLATION

9. Safety ________________________________________________ 6

9.1 General safety information ___________________________ 6

9.2 Instructions, standards and regulations ____________ 6

10. Appliance description ______________________________ 6

10.1 Standard delivery _______________________________________ 6

11. Installation __________________________________________ 6

12. Electrical connection _______________________________ 6

13. Appliance handover ________________________________ 6

14. Speciﬁcation _________________________________________ 7

14.1 Dimensions ______________________________________________ 7

14.2 Speciﬁcation table ______________________________________ 7

14.3 Wiring diagram CK 15 E / CK 20 E ___________________ 8

14.4 Wiring diagram CKT 15 E / CKT 20 E ________________ 8

CUSTOMER SERVICE AND WARRANTY

ENVIRONMENT AND RECYCLING

23(5$7,21

1. General information

Note

Read these instructions carefully before using

the appliance and familiarize yourself with its

functions. Keep these instructions safe. Pass on

the instructions to a new user if required.

1.1 Safety information

1.1.1 Structure of safety information

KEYWORD Type of risk

Here, possible consequences are listed that

may result from not observing the safety in-

formation.

fSteps to prevent the risk are listed.

1.1.2 Symbols, type of risk

6\PERO 7\SHRIULVN

!

Injury

Electrocution

Burns or scalding

Fire

1.1.3 Keywords

.(<:25' 'HVFULSWLRQ

DANGER If this information is not observed, it will result in serious

injury or death.

WARNING If this information is not observed, it can result in serious

injury or death.

CAUTION If this information is not observed, it can lead to medium

or minor injury.

23(5$7,21

6$)(7<

ENGLISH

:::67,(%(/(/752186$&20 _&.(&.7(_

1.2 Other symbols in this document

Note

Notes are bordered by horizontal lines above

and below the text. General information is iden-

tiﬁed by the symbol shown on the left.

fRead these notes carefully.

6\PERO



Damage to the appliance and environment

Appliance disposal

Never cover the appliance

fThis symbol indicates that you have to do something.

The action you need to take is described step by step.

2. Safety

Observe the following safety information and regulations.

Operate the appliance only when fully installed and with

all safety equipment ﬁtted.

2.1 Intended use

This appliance is designed to heat living areas.

Any other use beyond that described shall be deemed

inappropriate.

2.2 General safety information

DANGER Fire

Never operate this appliance ...

- if the minimum clearances to adjacent

object surfaces are not maintained, for ex-

ample to furniture, net curtains, curtains,

textiles or other ﬂammable materials (for

minimum clearances, see speciﬁcation/di-

mensions chapter).

- in rooms where the appliance is at risk from

ﬁre or explosion as a result of chemicals,

dust, gases or vapors.

- in the direct proximity of pipes or contain-

ers that carry or contain ﬂammable or ex-

plosive materials.

- if work such as laying cables, grinding or

sealing is carried out in the installation

room.

- if sprays, ﬂoor polish or similar products

containing gasoline are used. Vent the room

sufﬁciently before heating.

- if an appliance component is damaged, the

appliance has fallen over or already had a

fault.

- outdoors.

DANGER Fire

Never place any ﬂammable, combustible or in-

sulating objects or materials, such as laundry,

blankets, magazines, containers with ﬂoor pol-

ish or gasoline, spray cans or similar on the ap-

pliance or in direct proximity to it.

WARNING Fire

Ensure that no foreign bodies enter the venti-

lation air and extract air apertures. This could

result in electric shock or ﬁre or in damage to

the appliance.

WARNING Fire

To prevent ﬁres ensure that the air inlets and

outlets are never blocked. Never position the

appliance on soft surfaces, such as a bed, as this

could result in the apertures becoming blocked.

DANGER Overheating

The appliance could continue to heat the room

unchecked if it is operated on a time switch.

Ensure constant supervision if the appliance is

used in a small room and the persons within

that room cannot leave the room on their own.

23(5$7,21

$33/,$1&('(6&5,37,21

_&.(&.7( :::67,(%(/(/752186$&20

!

WARNING Injury

Where children or persons with limited physi-

cal, sensory or mental capabilities are to be

allowed to control this appliance, ensure that

this will only happen under supervision or after

appropriate instructions by a person respon-

sible for their safety.

Children should be supervised to ensure that

they never play with the appliance.

CAUTION Burns

The casing surfaces of the appliance and the

expelled air become hot during use (above 90 °C

(194 °F)). To prevent burns ensure that the hot

surfaces never come into contact with bare skin.

2.3 General information



Damage to the appliance and the environment

- Never cover this appliance.

- Never step on the appliance.

2.4 Test symbols

See type plate on the appliance.

2.5 Licences / certiﬁcates

- ETL (USA)

-C-ETL (Canada)

3. Appliance description

This appliance is wall mounted and is particularly suit-

able for work rooms, kitchens, bathrooms, wash rooms

and similar.

The external casing of the appliance is made from stove

enameled sheet steel. The sides are made out of plastic.

The controls are located on the right side panel.

The quiet fan draws in the ambient air that is heated by

a bare wire heater element. The air then exits evenly

through the hot air channel and the air outlet grille set

into the bottom of the appliance.

The appliance heats up the ambient air inside the room

and maintains it at the selected temperature.

3.1 Control with external room temperature control-

ler

(Only applicable for: CK)

In rooms larger than 20 m

2

(215 sqft) you can operate

the appliance with a conventional wall mounted room

thermostat.

fTo do so, turn the temperature selector fully

clockwise.

fControl the temperature by using the wall thermostat.

4. Operation CK 15 E / CK 20 E



26_07_31_0211

1 Temperature selector

4.1 Starting heating

The temperature is inﬁnitely adjustable. The appliance

stops heating as soon as the selected room temperature

has been reached.

fTurn the temperature selector clockwise to the re-

quired setting.

4.2 Stopping heating / frost protection

fTurn the temperature selector fully counter clockwise.

This position ensures frost protection. The heater starts

automatically if the room temperature drops below the

frost protection temperature.

23(5$7,21

23(5$7,21&.7(&.7(

ENGLISH

:::67,(%(/(/752186$&20 _&.(&.7(_

5. Operation CKT 15 E / CKT 20 E





26_07_31_0214

1 Temperature selector

2 Timer

5.1 Starting heating

The temperature is inﬁnitely adjustable. The appliance

stops heating as soon as the selected room temperature

has been reached.

fTurn the temperature selector clockwise to the re-

quired setting.

5.2 Adjusting the time switch

With the time switch, the appliance heats with full output

and without temperature control.

fTurn the Timer clockwise to set any number of min-

utes to count down from 0-60minutes.

5.3 Stopping heating / frost protection

This position ensures frost protection. The heater starts

automatically if the room temperature drops below the

frost protection temperature.

fTurn the temperature selector fully counter clockwise

and ensure that the time switch is set to "0".

6. Cleaning, care and maintenance

The appliance contains no user serviceable parts.

Clean the appliance when cold with ordinary cleaning

products. Avoid abrasive or corrosive cleaning products.

If a pale brownish discoloration appears on the appliance

casing, wipe this off as soon as possible with a damp

cloth.



Damage to the appliance and the environment

Never spray cleaning spray into the air slot.

7. Storage

fWhen not in use, keep the appliance in a dry place.

8. Troubleshooting

If the appliance does not heat, check the temperature set

at the appliance and the circuit breacker.

The appliance has a safety high limit that shuts the ap-

pliance down if it overheats. After the cause has been re-

moved (for example air outlet or inlet apertures covered)

and the appliance has cooled down for a few minutes,

operation starts again.

If you cannot remedy the fault, notify the contractor who

installed the appliance. To facilitate and speed up your

enquiry, please provide the serial number from the type

plate (000000-0000-000000).

_&.(&.7( :::67,(%(/(/752186$&20

,167$//$7,21

6$)(7<

,167$//$7,21

9. Safety

Only licensed electricians should carry out the mainte-

nance and repair of this appliance.

9.1 General safety information

We guarantee trouble-free operation and operational re-

liability only if the original accessories and spare parts

intended for the appliance are used.

9.2 Instructions, standards and regulations

Note

Observe all applicable national and local regula-

tions and instructions.

10. Appliance description

This appliance is a wall mounted electric heater. It is par-

ticularly suitable for heating rooms, such as work rooms,

kitchens, bathrooms, wash rooms etc.

10.1 Standard delivery

- Wall mount bracket

- Bottom bracket

11. Installation

DANGER Electrocution

- If installing the appliance in rooms with a

bath and/or shower, take the relevant safe-

ty zone into account in accordance with the

information on the appliance type plate.

- Install the appliance in such a way that

switching and control equipment cannot be

touched by a person in the bath or shower.

DANGER Fire

- Only ﬁt the appliance to a vertical wall that

is heat-resistant to at least194°F(90 °C).

- Maintain minimum clearances to adjacent

surfaces.

- Never install the appliance directly below a

wall socket.

fCheck the hole distances for the wall mounting brack-

et in the dimensioned drawing.

fSecure the wall mounting bracket with suitable fas-

teners. The horizontal and vertical slots in the wall

mounting bracket enable alignment if drilled holes

are not completely accurate.

fHook in the appliance so that both top protrusions

are inserted into the slots in the wall mounting

bracket.

fSecure the appliance with the bottom bracket and

one screw against unintentional unhooking. To do so,

hook the bottom bracket from the back into the rear

panel.

12. Electrical connection

DANGER Electrocution

Carry out all electrical connection and installa-

tion work in accordance with relevant regula-

tions.



Damage to the appliance and the environment

- Observe the type plate. The speciﬁed volt-

age must match the mains voltage.

Never install the appliance directly below an outlet.

In case of ROMEX wire, install ½" ROMEX connector in

knockout. In case of Greenﬁeld, please use ½" Greenﬁeld

connector.

13. Appliance handover

Explain the functions of the appliance to the user. Draw

special attention to the safety information. Hand the op-

erating and installation instructions to the user.

ENGLISH

14. Speciﬁcation

14.1 Dimensions

80_07_31_0012

1 Wall mounting bracket

2 Cable entry

3 Bottom bracket

14.2 Speciﬁcation table

Part number 074058 074057 230345 230346

Wattage W 1500 1500 / 2000 1500 1500 / 2000

Temperature range °F / °C 41-86 / 5-30 41-86 / 5-30 41-86 / 5-30 41-86 / 5-30

Frost protection setting °F / °C 44.6 / 7 44.6 / 7 44.6 / 7 44.6 / 7

Power supply singlephase ~ 120 V singlephase ~ 208/240 V singlephase ~ 120 V singlephase ~ 208/240 V

Operating noise dB(A) 53 53 53 53

Height inch / mm 18.1" / 460 18.1" / 460 18.1" / 460 18.1" / 460

Width inch / mm 13.2" / 335 13.2" / 335 13.2" / 335 13.2" / 335

Depth inch / mm 4.875 4.875 4.875" / 123 " / 123 " / 123 4.875" / 123

Weight lb / kg 8.0 / 4.4 8.0 / 4.4 8.0 / 4.4 8.0 / 4.4

IP rating IP13B IP13B IP13B IP13B

Safety category I I I I

Color Alpine white Alpine white Alpine white Alpine white

PBTP/ASA Polybutylenterephtalat/Acrylnitril-Styrol-Acrylester

PA Polyamid

PC Polycarbonat

PE Polyethylen

PS Polystyrol

Si Silicon

_&.(&.7( :::67,(%(/(/752186$&20

,167$//$7,21

63(&,),&$7,21

14.3 Wiring diagram CK 15 E / CK 20 E

1

5

)

! &  .

! )  )

)

;

0

0

a

5

$

*5'

/

1

/

CK 15 E:

CK 20 E:

26_07_31_0221

A1 Electric heating element assembly

F1 Temperature high Limit

M1 Fan

N1 Thermostat

R1 Heating resistor

R2 Heating resistor

X1 Wiring Block

14.4 Wiring diagram CKT 15 E / CKT 20 E

> 174°F ± 41°F

> 80°C ± 5K

-

> 174°F ± 41°F

> 80°C ± 5K

-

!















1

5 5

)

;

7

0

*5'

/

1

/

$

0



a

CKT 15 E:

CKT 20 E:

26_07_31_0221

A1 Electric heating element assembly

F1 Temperature high Limit

M1 Fan

N1 Thermostat

R1 Heating resistor

R2 Heating resistor

T1 60 minute timer

X1 Wiring Block

ENGLISH

:::67,(%(/(/752186$&20 _&.(&.7(_

:$55$17<_(19,5210(17$1'5(&<&/,1*

Limited Warranty

Residential & Commercial warranty: Stiebel Eltron war-

rants to the original owner that the CK 15 E / CK 20 E /

CKT 15 E / CKT 20 E will be free from defects in work-

manship and materials for a period of THREE YEARS

from the date of purchase. Should the part(s) prove

to be defective under normal use during this period,

Stiebel Eltron, Inc. will be responsible for replacement

of the detective part(s) only. Stiebel Eltron, Inc. is not

responsible for labor charges to remove and/or replace

the detective part(s), or any incidental or consequen-

tial expenses. Should the owner wish to return the wall

heater for repair, the owner must ﬁrst secure written

authorization from Stiebel Eltron, Inc. The owner shall

be required to show proof of purchase date, and to pay

all transportation costs to return the detective part(s)

or wall heater for repair or replacement. Warranty is

void if heater has been installed or used improperly or

if design has been altered in any way.

!

The installation, electrical connection and

ﬁrst operation of this appliance should be

carried out by a qualiﬁed installer.

!

The company does not accept liability for fail-

ure of any appliances which have not been

installed and operated in accordance with the manu-

facturer‘s instructions.

Environment and recycling

Please help us to protect the environment by disposing

of the packaging in accordance with the national regula-

tions for waste processing.

Page is loading ...

14. Données techniques

14.1 Cotes

80_07_31_0012

1 Fixation murale

2 Passage des câbles électriques

3 Équerre de ﬁxation

Réf. commande 074058 074057 230345 230346

Puissance de raccordement W 1500 2000 1500 1500 / 2000

Plage de réglage °F / °C 41-86 / 5-30 41-86 / 5-30 41-86 / 5-30 41-86 / 5-30

Protection hors gel °F / °C 44.6 / 7 44.6 / 7 44.6 / 7 44.6 / 7

Raccordement électrique singlephase ~ 120 V singlephase ~ 208/240 V singlephase ~ 120 V singlephase ~ 208/240 V

Bruit en fonctionnement dB(A) 53 53 53 53

Hauteur inch / mm 18.1" / 460 18.1" / 460 18.1" / 460 18.1" / 460

Largeur inch / mm 13.2" / 335 13.2" / 335 13.2" / 335 13.2" / 335

Profondeur inch / mm 4.875 4.875 4.875 4.875" / 123 " / 123 " / 123 " / 123

Poids lb / kg 8.0 / 4.4 8.0 / 4.4 8.0 / 4.4 8.0 / 4.4

Degré de protection (IP) IP13B IP13B IP13B IP13B

Classe de protection I I I I

Couleur blanc alpin blanc alpin blanc alpin blanc alpin

(4.875")

Page is loading ...

A 164753-35855-8559

B 292329-35855-8559

North, Central and South America

United States of America

STIEBEL ELTRON CK 15E User guide

Related papers

Other documents