Hayward Above Ground Skim-Vac : SP11041, SP11051, SP1106, & SP1107 Owner's manual
- Category
- Above ground pool accessories
- Type
- Owner's manual
IS1104 Rev D
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 1
SKIM-VAC
Owner’s Manual
Models SP1094D, SP11041, SP11051, SP11052
SP11054, SP1106, SP11063, SP1107, SP11071
IMPORTANT SAFETY INSTRUCTIONS
Basic safety precautions s
h
ou
ld
a
l
ways
b
e fo
ll
owe
d
, inc
l
u
d
ing t
h
e fo
ll
owing: Fai
l
ure to fo
ll
ow instructions
can cause severe injury and/or death.
This is the safety-alert symbol. When you see this symbol on your equipment or in this manual, look for
one of the following signal words and be alert to the potential for personal injury.
WARNING warns about hazards that could cause serious personal injury, death or major property
damage and if ignored presents a potential hazard.
CAUTION warns about hazards that will or can cause minor or moderate personal injury and/or property
damage and if ignored presents a potential hazard. It can also make consumers aware of actions that are
unpredictable and unsafe.
The NOTICE label indicates special instructions that are important but not related to hazards.
Hayward Pool Products
620 Division Street, Elizabeth, NJ 07207
Phone: (908) 355-7995
www.hayward.com
Contents
Product Warnings…………….……2
Introduction……….…………..…..…4
Installation……….……………..….…4
WA
R
follow ins
t
WA
R
Suction in
s
severe inju
Hair Entra
Limb Entr
a
cracked, m
Body Suc
t
Eviscerati
sump or s
u
disembow
e
Mechanic
opening of
WAR
o
W
b
e
a
p
o D
o D
o T
h
o N
o R
e
o I
n
g
u
o I
n
WA
R
suction o
u
WA
R
material c
a
WA
R
replaced
a
CAU
T
being use
d
on this pro
positioned
WAR
start up, n
o
follow safe
and clamp
pool and s
p
be in open
back to th
e
open filter
is dischar
g
WAR
of pump a
n
servicing p
circulation
circulation
circulatio
n
air can cau
high volu
m
R
NING
-
Re
a
t
ructions can
c
R
NING
– Suc
s
uction outlets
ry and/or deat
h
pment
- Hair c
a
a
pment
- A lim
b
issing, or not s
t
ion Entrapm
e
on/ Disembo
w
u
ction outlet co
v
e
lment.
a
l Entrapmen
a suction outl
e
NING
- To R
e
W
hen outlets ar
e
e
installed. Su
c
p
art, as measu
r
ual suction fitt
i
ual suction fitt
i
h
e maximum s
y
ever use Pool
o
e
place damag
e
n
addition two
o
u
idelines, follo
w
n
stallation of a
v
R
NING
– Fail
u
u
tlets can resu
R
NING
– Fail
a
n result in an
R
NING
– Suc
a
t least every
S
T
ION
– Com
p
d
as means of
d
uct. Closely
s
to prevent chil
NING
– Haz
o
rmal operatio
n
ty and operati
o
due to pressur
e
p
a water circul
a
position. Befo
e
pool. Do not
c
manual air reli
e
ed.
NING
– Sep
n
d/or filter com
ool and spa cir
system if a sys
system unless
n
system at m
o
se component
s
m
e blower when
USE ONLY
H
a
d and foll
o
c
ause severe i
n
tion Entrap
m
and/or suctio
n
h
due to the fol
a
n become ent
a
b
inserted into
ecurely attach
e
e
nt
- A negative
w
elment
- A n
e
v
er which is, d
a
t
- There is pot
e
e
t cover resulti
n
e
duce the ris
e
small enough
c
tion outlets in
r
ed from near
p
ngs shall be pl
ngs shall not b
y
stem flow rate
o
r Spa if any su
c
e
d, broken, cra
c
o
r more suction
w
all National,
v
acuum releas
e
u
re to remove
lt in an increa
s
ure to keep su
increase pot
e
tion outlet co
m
S
EVEN years o
r
p
onents such
access to the
upervise child
r
dren from usin
g
ardous Pres
s
n
, and after pu
m
o
n instructions
e
in the system
a
tion system, a
re starting sys
t
c
hange filter co
e
f valve. Do no
aration Haza
ponents. Strai
culation syste
m
tem compone
n
filter manual a
o
re than 50 PS
I
s
to explode, w
i
air purging th
e
H
AYWARD GE
N
o
w all inst
r
n
jury and/or d
m
ent Hazard.
n
outlet covers
w
lowing entrap
m
a
ngled in sucti
o
an opening of
a
e
d can result in
pressure appli
e
gative pressu
r
a
maged, broke
n
e
ntial for jewelr
y
n
g in mechanic
a
k of Entrapm
to be blocked
the same plan
p
oint to near po
aced in such l
o
e located on s
e
shall not exce
e
c
tion outlet co
m
c
ked, missing,
o
outlets per pu
m
State, and Loc
a
e
or vent syste
m
pressure test
s
e potential f
o
ction outlet c
o
e
ntial for sucti
o
m
ponents hav
e
r
if found to b
e
as the filtrati
o
pool by young
r
en at all times
.
g
them as a m
e
s
ure.
Pool an
d
m
p shut off. St
a
could result in
, which could
c
ll system and
p
em pump, all s
ntrol valve pos
t close filter m
a
rd. Failure to
f
ner cover must
m
, filters manu
a
n
t is not assem
b
ir relief valve b
I
. Do not purg
e
i
th risk of seve
r
e
pump, filter,
o
N
UINE REPLA
C
r
uctions
in
t
eath.
w
hich are, da
m
m
ent hazards:
o
n outlet cover
.
a
suction outle
t
a mechanical
b
e
d to a large p
o
r
e applied dire
c
n
, cracked, mis
y
, swimsuit, ha
a
l entrapment.
ent Hazards:
by a person, a
m
e (i.e. floor or
w
int.
o
cations and di
s
e
ating areas or
e
d the flow rati
n
m
ponent is da
m
o
r not securely
m
p installed in
a
l codes applic
a
m
, which reliev
e
plugs and/or
p
o
r suction entr
a
o
mponents cl
e
o
n entrapmen
t
e
a finite life,
t
damaged, br
o
n system, pu
m
children. To
r
.
Components
s
e
ans of access
t
d
spa water circ
a
nd clear of cir
c
violent separa
t
c
ause property
p
ump controls
m
ystem valves
m
ition while sys
t
a
nual air relief
v
f
ollow safety a
n
be properly se
a
l air relief valv
b
led properly,
d
ody is in locke
d
e
the system
w
r
e injury or dea
t
o
r piping.
C
EMENT PAR
T
t
his owner’s m
m
aged, broken,
.
t
sump or sucti
o
b
ind or swellin
g
o
rtion of the bo
c
tly to the intes
s
sing, or unsec
u
a
ir decorations,
:
minimum of tw
w
all), must be i
stances to avo
i
on the backre
s
n
g as stated o
n
m
aged, broken,
attached sucti
o
accordance w
i
able.
e
s entrapping
s
p
lugs used in
w
a
pment as de
s
e
ar of debris,
s
t
as described
t
he cover/grat
o
ken, cracked
,
m
ps and heate
r
educe risk of i
n
such as the filt
t
o the pool.
ulation system
c
ulation syste
m
t
ion of the pum
damage, seve
r
m
ust be in off
p
m
ust be set in a
t
em pump is ru
v
alve until a st
e
n
d operation in
cured to pump
e must be in o
p
d
amaged, or m
i
d
position in fil
w
ith compress
e
t
h to anyone n
e
T
S
m
anual and on
cracked, missi
on outlet cove
r
g
of the limb.
o
dy or limbs ca
n
tines through
a
u
red can result
finger, toe or
k
w
o functioning
s
nstalled a mini
i
d “dual block
a
s
t for such seat
i
n
the suction fit
cracked, miss
i
o
n outlet comp
i
th latest ASM
E
s
uction, is reco
w
interization
o
s
cribed above
.
s
uch as leaves
above.
e should be i
n
,
missing, or n
r must be pos
n
jury, do not p
e
ration system,
s operate und
e
m
equipment d
u
p housing and
r
e personal inj
u
p
osition and fil
t
position to all
o
nning. Before
s
e
ady stream of
structions cou
l
housing with
s
p
en position.
D
i
ssing. Do not
o
ter upper body
ed air. Purgin
g
e
arby. Use onl
y
the equipmen
ng, or unsecur
e
r
that is damag
e
n
result in an e
n
a
n unprotected
in evisceratio
n
k
nuckle to be c
a
s
uction outlets
mum of three
f
a
ge” by a user.
i
ng areas.
tings.
i
ng, or not sec
u
onents immed
i
E
, APSP Standa
r
mmended.
o
f the pool/sp
.
, dirt, hair, pa
p
n
spected freq
u
ot securely at
t
itioned so as
t
e
rmit children t
o
pumps, and h
e
e
r hazardous p
r
u
ring pump sta
cover, and/or
f
u
ry, or death. B
t
er manual air r
o
w system wat
e
s
tarting syste
m
water (not air
o
l
d result in viol
e
s
trainer cover l
o
D
o not operate
p
o
perate pool a
n
. Never opera
t
g
the system wi
y
a low pressur
t. Failure to
e
d can cause
e
d, broken,
n
trapment.
suction outlet
n
/
a
ught in an
per pump mus
t
f
eet (3’) [1 met
e
u
rely attached.
i
ately.
r
ds and CPSC
a from the
p
er and other
u
ently and
t
ached.
t
o prevent the
i
o
use or climb
e
aters must be
r
essure during
rt up. Failure t
o
f
ilter housing
efore servicing
elief valve mu
s
e
r to return
m
pump, fully
o
r air and wate
r
e
nt separation
o
ck ring. Befor
e
p
ool and spa
n
d spa
t
e or test the
th compresse
d
e (below 5 PSI)
2
t
e
r]
r
o
t
r
)
e
,
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 3
WARNING – Risk of Electric Shock. All electrical wiring MUST be in conformance with applicable local codes,
regulations, and the National Electric Code (NEC). Hazardous voltage can shock, burn, and cause death or serious property
damage. To reduce the risk of electric shock, do NOT use an extension cord to connect unit to electric supply. Provide a properly
located electrical receptacle. Before working on any electrical equipment, turn off power supply to the equipment. To reduce
the risk of electric shock replace damaged wiring immediately. Locate conduit to prevent abuse from lawn mowers, hedge
trimmers and other equipment. Do NOT ground to a gas supply line.
WARNING – Risk of Electric Shock Failure to ground all electrical equipment can cause serious or fatal electrical shock
hazard. Electrical ground all electrical equipment before connecting to electrical power supply.
WARNING – Risk of Electric Shock Failure to bond all electrical equipment to pool structure will increase risk for
electrocution and could result in injury or death. To reduce the risk of electric shock, see installation instructions and consult a
professional electrician on how to bond all electrical equipment. Also, contact a licensed electrician for information on local
electrical codes for bonding requirements.
Notes to electrician: Use a solid copper conductor, size 8 or larger. Run a continuous wire from external bonding lug to
reinforcing rod or mesh. Connect a No. 8 AWG (8.4 mm2) [No. 6 AWG (13.3 mm2) for Canada] solid copper bonding wire to the
pressure wire connector provided on the electrical equipment and to all metal parts of swimming pool, spa, or hot tub, and metal
piping (except gas piping), and conduit within 5 ft. (1.5 m) of inside walls of swimming pool, spa, or hot tub.
IMPORTANT - Reference NEC codes for all wiring standards including, but not limited to, grounding, bonding and other general
wiring procedures.
WARNING – Risk of Electric Shock . The electrical equipment must be connected only to a supply circuit that is
protected by a ground-fault circuit-interrupter (GFCI). Such a GFCI should be provided by the installer and should be tested on a
routine basis. To test the GFCI, push the test button. The GFCI should interrupt power. Push reset button. Power should be
restored. If the GFCI fails to operate in this manner, the GFCI is defective. If the GFCI interrupts power to the electrical equipment
without the test button being pushed, a ground current is flowing, indicating the possibility of an electrical shock. Do not use this
electrical equipment. Disconnect the electrical equipment and have the problem corrected by a qualified service representative
before using.
CAUTION – HAYWARD® pumps are intended for use with permanently-installed pools and may be used with hot tubs and
spas if so marked. Do not use with storable pools. A permanently-installed pool is constructed in or on the ground or in a
building such that it cannot be readily disassembled for storage. A storable pool is constructed so that it is capable of being
readily disassembled for storage and reassembled to its original integrity.
WARNING – Risk of Hyperthermia. To avoid hyperthermia the following “Safety Rules for Hot Tubs” are recommended by
the U.S. Consumer Product Safety Commission.
1. Spa or hot tub water temperatures should never exceed 104°F [40°C]. A temperature of 100°F [38°C] is
considered safe for a healthy adult. Special caution is suggested for young children. Prolonged immersion in
hot water can induce hyperthermia.
2. Drinking of alcoholic beverages before or during spa or hot tub use can cause drowsiness, which
could lead to unconsciousness and subsequently result in drowning.
3. Pregnant women beware! Soaking in water above 100°F [38°C] can cause fetal damage during the
first three months of pregnancy (resulting in the birth of a brain-damaged or deformed child). Pregnant women
should adhere to the 100°F [38°C] maximum rule.
4. Before entering the spa or hot tub, users should check the water temperature with an accurate ther-
mometer; spa or hot tub thermostats may err in regulating water temperatures by as much as 4°F (2.2°C).
5. Persons taking medications, which induce drowsiness, such as tranquilizers, antihistamines or anti-
coagulants, should not use spas or hot tubs.
6. If the pool/spa is used for therapy, it should be done with the advice of a physician. Always stir pool/ spa
water before entering the pool/spa to mix in any hot surface layer of water that might exceed healthful
temperature limits and cause injury. Do not tamper with controls, because scalding can result if safety controls
are not in proper working order.
7. Persons with a medical history of heart disease, circulatory problems, diabetes or blood pressure
problems should obtain a physicians advice before using spas or hot tubs.
8. Hyperthermia occurs when the internal temperature of the body reaches a level several degrees above
normal body temperature of 98.6°F [37°C]. The symptoms of Hyperthermia include: drowsiness, lethargy,
dizziness, fainting, and an increase in the internal temperature of the body.
The effects of Hyperthermia include:
1. Unawareness of impending danger.
2. Failure to perceive heat.
3. Failure to recognize the need to leave the spa.
4. Physical inability to exit the spa.
5. Fetal damage in pregnant women.
6. Unconsciousness resulting in danger of drowning.
SAVE THESE INSTRUCTIONS
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 4
INSTALLATION INSTRUCTIONS:
1. Place vacuum cleaner head on vacuum hose and prepare for vacuuming as usual. With pump and
filter system operating, fill vacuum hose with water.
2. Keeping water in hose, place hose end over SKIM-VAC hose connection.
3. Insert SKIM-VAC into skimmer and firmly place over basket. Hold SKIM-VAC in place until all air is
evacuated from vacuum hose. Once the air is removed, the pump suction will hold the SKIM-VAC
firmly in place.
4. To remove SKIM-VAC, merely grasp the hose connection (near the plate) and give a sideward
twist or briefly lift vacuum head from pool. This will "break" the suction and allow easy removal.
NOTE: Take care not to damage or scuff-up SKIM-VAC's specially designed sealing surface. For best
results, store the SKIM-VAC in a safe place when not in use.
NOTE: SP1106 and SP1107 SKIM-VACS, fit 7” baskets. SP11063 fits 8” baskets.
Mode
l
Description Skimme
r
Gasket
SP1094D 1 ¼” x 1 ½” Combo hose elbow SP1094, SP1095 No
SP11041 1 ¼” x 1 ½” Combo hose elbow SP1090, SP1091, SP1092 front access No
SP11051 1 ½” Hose straight adapter SP1090, SP1091, SP1096, SP1097, SP1098, Top cover Yes
SP11052 1 ¼” Hose elbow SP1090, SP1091, SP1092 front access Yes
SP11054 1 ¼” x 1 ½” Combo hose elbow SP1090, SP1091, SP1092 front access Yes
SP1106 1 ½” Hose straight adapter SP1082, SP1084, SP1085, SP1075 Yes
SP11063 1 ½” Hose straight adapter SP1070 No
SP1107 1 ½” Hose straight adapter SP1082, SP1084, SP1085, SP1070, SP1075 No
SP11071 1 ¼” x 1 ½” Combo hose elbow SP1089 No
-
1
-
2
-
3
-
4
Hayward Above Ground Skim-Vac : SP11041, SP11051, SP1106, & SP1107 Owner's manual
- Category
- Above ground pool accessories
- Type
- Owner's manual
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Hayward SP1091LX Owner's manual
-
-
Hayward RC9740WCCUB Owner's manual
-
-
-
-
Hayward W3EC50C93S Owner's manual
-
Hayward S166T Owner's manual
-
-
Other documents
-
Korg NANOKON2BK User manual
-
Polygroup SFX600 Blue Wave Skimmerplus Filter Pump Owner's manual
-
Polygroup SFX600 Operating instructions
-
Hayward Pools H250FDN User manual
-
Jacuzzi (2017) J-100™ Owner's manual
-
-
-
-
-
