Hayward Pools H250FDN User manual

Brand: Hayward Pools

Model: H250FDN

Category: Above ground pool accessories

Type: User manual

FOR YOUR SAFETY

WARNING: If the information in these

instructions is not followed exactly, a ﬁre

or explosion may result causing property

damage, injury, or death.

- Donotstoreorusegasolineorotheram-

mablevaporsorliquidsinthevicinityofthis

oranyotherappliance.

WHAT TO DO IF YOU SMELL GAS:

• Donottrytolightanyappliance.

• Donottouchanyelectricalswitch;donotuse

anyphoneinyourbuilding.

• Immediatelycallyourgassupplierfroma

neighbor’sphone.Followthegassupplier’s

instructions.

• Ifyoucannotreachyourgassupplier,callthe

redepartment.

-Installationandservicemustbeperformedby

aqualiedinstaller,serviceagency,orthegas

supplier.

POOL AND SPA/HOT TUB HEATERS

H250FDN & H250FDP; H350FDN & H350FDP;

H400FDN & H400FDP MODELS

OWNER’S MANUAL

HAYWARD

FOR YOUR SAFETY

Thisproductmustbeinstalledandservicedbyauthorizedpersonnel,qualiedinpool/spa

heaterinstallation.Improperinstallationand/oroperationcancreatecarbonmonoxidegas

anduegasesthatcancauseseriousinjury,propertydamage,ordeath.

1301640701 1007

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

Warnings ....................................................................................................3-6

Section I General information ........................................................................7

Section II. Consumer Operation & Maintenance ...........................................8

Using chlorinators and chemical feeders:......................................................9

Lighting & Operating instructions label ........................................................10

Operation: Set point adjustment .................................................................11

Fahrenheit versus Celsius ...........................................................................11

Sequence of operation ...............................................................................11

Failure to Light .............................................................................................12

Loss of ame – recycle ................................................................................12

Adaptive learning routine .............................................................................13

Keypad inputs ..............................................................................................13

Automatic reset time ....................................................................................13

Periodic inspection: .....................................................................................13

Winterization: ...............................................................................................14

Damage by Freezing ...................................................................................14

Spring start-up: ............................................................................................15

Error codes .............................................................................................15-16

CONTENTS

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

Basicsafetyprecautionsshouldalwaysbefollowed,includingthefollowing:Failuretofollowinstructions

cancausesevereinjuryand/ordeath.

Thisisthesafety-alertsymbol.Whenyouseethissymbolonyourequipmentorinthismanual,lookfor

oneofthefollowingsignalwordsandbealerttothepotentialforpersonalinjury.

WARNINGwarnsabouthazardsthatcouldcauseseriouspersonalinjury,deathormajorpropertydam-

ageandifignoredpresentsapotentialhazard.

CAUTIONwarnsabouthazardsthatwillorcancauseminorormoderatepersonalinjuryand/orprop-

ertydamageandifignoredpresentsapotentialhazard.Itcanalsomakeconsumersawareofactionsthat

areunpredictableandunsafe.

ATTENTIONindicatesspecialinstructionsthatareimportantbutnotrelatedtohazards.

READ AND FOLLOW ALL INSTRUCTIONS IN THIS OWNER’S

MANUAL AND ON EQUIPMENT.

IMPORTANT SAFETY INSTRUCTIONS

Before installing or servicing this electrical equipment, turn power supply OFF.

KEEP SAFETY LABELS IN GOOD CONDITION AND REPLACE IF MISSING OR DAMAGED.

WARNING–Toreduceriskofinjury,donotpermitchildrentouseorclimbontheheater,pumpsor

lters.Closelysupervisechildrenatalltimes.Componentssuchastheltrationsystem,pumps,and

heatersmustbepositionedtopreventchildrenfromusingthemasameansofaccesstothepool.

CAUTION –Thisheaterisintendedforuseonpermanentlyinstalledswimmingpoolsandmayalso

beusedwithspas.DoNOTusewithstorablepools.Apermanentlyinstalledpoolisconstructedinor

onthegroundorinabuildingsuchthatitcannotbereadilydisassembledforstorage.Astorablepoolis

constructedsothatitiscapableofbeingreadilydisassembledforstorageandreassembledtoitsoriginal

integrity.

Thoughthisproductisdesignedforoutdooruse,itisstronglyrecommendedtoprotecttheelectrical

componentsfromtheweather.Selectawelldrainedarea,onethatwillnotoodwhenitrains.Itrequiresfree

circulationofairforcooling.Donotinstallinadampornon-ventilatedlocation.

WARNING –Itisrequiredthatlicensedelectriciansdoallelectricalwiring.Riskof

ElectricShock.Hazardousvoltagecanshock,burn,causedeathorseriousproperty

damage.Toreducetheriskofelectricshock,doNOTuseanextensioncordtoconnect

unittoelectricsupply.Provideaproperlylocatedoutlet.AllelectricalwiringMUSTbe

inconformancewithapplicablelocalandnationalcodesandregulations.Beforework-

ingonthisunit,turnoffpowersupplytotheheater.

WARNING –Toreducetheriskofelectricshockreplacedamagedwiringimmediately.Locateconduit

topreventabusefromlawnmowers,hedgetrimmersandotherequipment.

WARNING –Failuretobondtopoolstructurewillincreaseriskforelectrocutionandcouldresultin

injuryordeath.Toreducetheriskofelectricshock,theelectricianmustcomplywithinstallationin-

structionsandmustbondtheheateraccordingly.Inaddition,thelicensedelectricianmustalsoconform

tolocalelectricalcodesforbondingrequirements.

SAFETY INFORMATION

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

NOTES TO THE ELECTRICIAN:

Useasolidcopperconductor,size8orlarger.Runacontinuouswirefromexternalbondinglugtorein-

forcingrodormesh.ConnectaNo.8AWGsolidcopperbondingwiretothegroundinglugprovidedonthe

heaterandtoallmetalpartsofswimmingpoolorspa,andtoallelectricalequipment,metalpiping(except

gaspiping),andconduitwithin5ft.(1.5m)ofinsidewallsofswimmingpoolorspa.

IMPORTANT-ReferenceNECcodesforallwiringstandardsincluding,butnotlimitedto,grounding,

bondingandothergeneralwiringprocedures.

WARNING – Suction Entrapment Hazard.

Suctioninsuctionoutletsand/orsuctionoutletcoverswhicharedamaged,broken,

cracked,missing,orunsecuredcancausesevereinjuryand/ordeathduetothefol-

lowingentrapmenthazards:

Hair Entrapment-Haircanbecomeentangledinsuctionoutlets.

Limb Entrapment-Alimbinsertedintoanopeningofasuctionoutletorsuctionoutlet

coverthatisdamaged,broken,cracked,missing,ornotsecurelyattachedcanresultina

mechanicalbindorswellingofthelimb.

Body Suction Entrapment-Adifferentialpressureappliedtoalargeportionofthebodyorlimbscan

resultinanentrapment.

Evisceration/ Disembowelment-Avacuumapplieddirectlytotheintestinesthroughanunprotected

suctionoutletsumporsuctionoutletcoverwhichisdamaged,broken,cracked,missing,orunsecured

canresultinevisceration(disembowelment).

Mechanical Entrapment-Thereispotentialforjewelry,swimsuit,hairdecorations,nger,toeorknuck-

letobecaughtinanopeningofasuctionoutletorsuctionoutletcoverresultinginmechanicalentrap-

ment.

WARNING-Toreducetheriskofentrapmenthazards:

• Whensuctionoutletsarelessthana18”x23”equivalent,aminimumoftwofunction-

ingsuctionoutletsperpumpmustbeinstalled.Suctionoutletsinthesameplane(i.e.

oororwall),mustbeinstalledaminimumofthreefeet(3’)[1meter]apart,asmea-

suredfromnearpointtonearpoint.

• Dualsuctionoutletsshallbeplacedinsuchlocationsanddistancestoavoid“dual

blockage”byauser.

• Dualsuctionttingsshallnotbelocatedonseatingareasoronthebackrestforsuch

seatingareas.

• Themaximumsystemowrateshallnotexceedtheowratingofanylisted(percurrentrevisionof

ASME/ANSIA112.19.8)suctionoutletcoverinstalled.

• NeverusethePoolorSpaifanysuctionoutletcomponentisdamaged,broken,cracked,missing,or

notsecurelyattached.

• Replacedamaged,broken,cracked,missing,ornotsecurelyattachedsuctionoutletcomponentsim-

mediately.

• InstalltwoormoresuctionoutletsperpumpinaccordancewithlatestAPSP(formallyNSPI)Stan-

dardsandCPSCguidelines.FollowallapplicableNational,State,andLocalcodes.

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

WARNING–Failuretoremovepressuretestplugsand/orplugsusedinwinterizationofthepool/spa

fromthesuctionoutletscanresultinanincreasepotentialforsuctionentrapmentasdescribedabove.

WARNING–Failuretokeepsuctionoutletcomponentsclearofdebris,suchasleaves,dirt,hair,paper

andothermaterialcanresultinanincreasepotentialforsuctionentrapmentasdescribedabove.

WARNING–Suctionoutletcomponentshaveanitelife,thecover/grateshouldbeinspectedfre-

quentlyandreplacedatleasteverytenyearsoriffoundtobedamaged,broken,cracked,missing,ornot

securelyattached.

WARNING–AllsuctionanddischargevalvesMUSTbeOPENwhenstartingthecirculationsystem.

Failuretodosocouldresultinseverepersonalinjuryand/orpropertydamage.Alldrainsandsuction

outletsMUSThaveproperlyinstalledcovers,securelyattachedusingthescrewssuppliedwiththecov-

ers.Ifscrewsarelost,orderreplacementpartsfromyoursupplier.

WARNING – Hazardous Pressure.Poolandspawatercirculationsystemsoperate

underhazardouspressureduringstartup,normaloperation,andafterpumpshutoff.

Standclearofcirculationsystemequipmentduringstartup.Failuretofollowsafety

andoperationinstructionscouldresultinviolentseparationofthepumphousing

andcoverduetopressureinthesystem,whichcouldcausepropertydamage,severe

personalinjury,ordeath.Beforeservicingpoolandspawatercirculationsystem,all

systemandpumpcontrolsmustbeinoffpositionandltermanualairreliefvalve

mustbeinopenposition.Beforestartingsystempump,allsystemvalvesmustbeset

inapositiontoallowsystemwatertoreturnbacktothepool.Donotchangelter

controlvalvepositionwhilesystempumpisrunning.Beforestartingsystempump,

fullyopenltermanualairreliefvalve.Donotcloseltermanualairreliefvalve

untilasteadystreamofwater(notairorairandwater)isdischarged.

WARNING – Separation Hazard.Failuretofollowsafetyandoperationinstruc-

tionscouldresultinviolentseparationofpumpcomponents.Strainercovermustbe

properlysecuredtopumphousingwithstrainercoverlockring.Beforeservicing

poolandspacirculationsystem,manualairreliefvalvemustbeinopenposition.Do

notoperatepoolandspacirculationsystemifasystemcomponentisnotassembled

properly,damaged,ormissing.Donotoperatepoolandspacirculationsystemunless

lterairreliefvalvebodyisinlockedpositioninlterupperbody.

WARNING –Neveroperateortestthecirculationsystematmorethan40PSI.

WARNING–Fireandburnhazard.Motorsoperateathightemperaturesandiftheyarenotproperly

isolatedfromanyammablestructuresorforeigndebristheycancauseres,whichmaycausesevere

personalinjuryordeath.Itisalsonecessarytoallowthemotortocoolforatleast20minutespriorto

maintenancetominimizetheriskofburns.

WARNING–Failuretoinstallaccordingtodenedinstructionsmayresultinseverepersonalinjuryor

death.

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

WARNING–Thefollowing“SafetyRulesforHotTubs”recommendedbytheU.S.Consumer

ProductSafetyCommissionshouldbeobservedwhenusingthespa.

1. Spaorhottubwatertemperaturesshouldneverexceed104°F[40°C].Atemperatureof100°F

[38°C]isconsideredsafeforahealthyadult.Specialcautionissuggestedforyoungchildren.Pro-

longedimmersioninhotwatercaninducehyperthermia.

2. Drinkingofalcoholicbeveragesbeforeorduringspaorhottubusecancausedrowsiness,which

couldleadtounconsciousnessandsubsequentlyresultindrowning.

3. Pregnantwomenbeware!Soakinginwaterabove100°F[38°C]cancausefetaldamageduringthe

rstthreemonthsofpregnancy(resultinginthebirthofabrain-damagedordeformedchild).Preg-

nantwomenshouldadheretothe100°F[38°C]maximumrule.

4. Beforeenteringthespaorhottub,usersshouldcheckthewatertemperaturewithanaccuratether-

mometer;spaorhottubthermostatsmayerrinregulatingwatertemperaturesbyasmuchas4°F

(2.2°C).

5. Personstakingmedications,whichinducedrowsiness,suchastranquilizers,antihistaminesoranti-

coagulants,shouldnotusespasorhottubs.

6. Ifthepool/spaisusedfortherapy,itshouldbedonewiththeadviceofaphysician.Alwaysstirpool/

spawaterbeforeenteringthepool/spatomixinanyhotsurfacelayerofwaterthatmightexceed

healthfultemperaturelimitsandcauseinjury.Donottamperwithcontrols,becausescaldingcan

resultifsafetycontrolsarenotinproperworkingorder.

7. Personswithamedicalhistoryofheartdisease,circulatoryproblems,diabetesorbloodpressure

problemsshouldobtainaphysiciansadvicebeforeusingspasorhottubs.

8. Hyperthermiaoccurswhentheinternaltemperatureofthebodyreachesalevelseveraldegrees

abovenormalbodytemperatureof98.6°F[37°C].ThesymptomsofHyperthermiainclude:drowsi-

ness,lethargy,dizziness,fainting,andanincreaseintheinternaltemperatureofthebody.

The effects of Hyperthermia include:

1. Unawarenessofimpendingdanger.

2. Failuretoperceiveheat.

3. Failuretorecognizetheneedtoleavethespa.

4. Physicalinabilitytoexitthespa.

5. Fetaldamageinpregnantwomen.

6. Unconsciousnessresultingindangerofdrowning.

DEFINITIONS:

SuctionOutlet– ThetermSuctionOutletisatting,ttingassembly,cover/grateandrelatedcompo-

nentsthatprovideameansforwatertoexitthepoolandintothepumpcirculating

system.

Inchesof

Mercury(inHg)- Aunitformeasuringpressurebelowatmospheric(“suction”or“vacuum”)(1.0inch

Hg=.491PSI)

MainDrain– SeeSuctionOutlet

PSI– Anabbreviationforpoundspersquareinch.

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

INTRODUCTION:

Thismanualcontainsinstructionsforinstallation,operation,maintenance,troubleshooting,andpartslists

forthesafeuseoftheswimmingpool/spa/hottubheaters.Haywardstronglyrecommendsthattheowner

readthemanualbeforeusingtheswimmingpool/spa/hottubheater.Ifafterreviewingthemanualanyques-

tionsremainunanswered,contactthefactoryorlocalrepresentative.

LIMITED WARRANTY SUMMARY:

Wewarrantthepool/spa/hottubheatertobefreefromdefectsinmaterialsandworkmanship,andwe

willwithinoneyearfromdateofinstallationforallusers,fortheoriginalpurchaser,repairor,atouroption,

replacewithoutchargeanydefectivepart.Wefurtherwarrantthatiftheheatexchangerorexchangerheaders

(water-containingsection)leakwithinoneyearfromdateofsuchinstallationforallusers,duetodefectsin

materialsandworkmanship,wewillprovideareplacementpart.Costoffreight,installation,fuel,andservice

labor(afteroneyear)isatuser’sexpense.Forfulldetailsofwarrantyagreement,seewarrantycerticate

includedinthismanual.

ATTENTION:Ifthepool/spa/hottubheaterisdamagedordestroyedbyimpropermaintenance,exces-

sivewaterhardness,incorrectwaterchemistry,orfreezingitisnotcoveredunderthemanufacturer’s

warranty.

SECTION I. GENERAL INFORMATION

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

SECTION II. CONSUMER OPERATION & MAINTENANCE

FOR YOUR SAFETY – READ BEFORE OPERATING THE HEATER

GENERAL:

Watermustbeowingthroughtheheaterduringoperation.Checkthatthepumpisoperatingandthesys-

temislledwithwaterandpurgedofallairpriortostartingtheheater.Inanewpoolitisrecommendedthat

thelterbeoperatedlongenoughtocompletelycleanandclearthepoolwaterandltersystem.

Balancethepool/spawaterchemistryandcleanthelter.Thenfollowtheinstructionsbelow.

POOL/SPA WATER CHEMISTRY:

SeeFigure1.Themineralcontentofswimmingpoolwaterincreasesdailyduetoadditionofpoolsanitiz-

ingchemicalsandnaturalevaporation.Excessmineralswilldepositonpoolwalls,intheltrationsystem,

andintheheatexchangertubesifthemineralcontentistoohigh.

Changingspawaterregularlyandmaintainingcorrectchemicalbalanceinpool/spawillkeepthepool/

spasafeandsanitary,andwillprotecttheheateranditswarrantycoverage.PurchaseaPHwatertestkitand

checkthefollowingchemicallevelsfrequently.

CHLORINE OR BROMINE:Recommendedlevelis1to4ppm.Testbeforeuse.pH:Recommendedideal

level7.4to7.6.HIGHreadingsreducesanitizerefciency.LOWreadingsarecorrosive.

TOTAL ALKALINITY:80–120ppm.Testweeklyduringregularuse.LOWreadingsarecorrosiveand

causerapidpHchangeswhenchemicalsareadded.

CALCIUM HARDNESS:200–400ppm.Testwheneverpool/spaislled.

LOWlevelsofhardnesscanbeverycorrosive.

Remember,additionofanychemicalscanchangethelevelsofchlorine,pH,andtotalalkalinity.

Itisrecommendedthatresidentialspawaterbechangedevery2to3monthstopreventwaterproblems.

Publicspasmayneedtohavethewaterchangedeveryweek,orevendaily,dependingonthebatherload.

Figure1

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

WARNING:Ifyousmellgasintheapplianceareaorneartheoor(PROPANEIS

HEAVIERTHANAIRANDHENCESETTLESONTHEFLOOR),stopandfollow

theinstructionsonthefrontcoverofthismanual.Sincepropanecanaccumulateincon-

nedareas,extracareshouldbetakenwhenlightingpropaneheaters.

ATTENTION:Donotusetheheaterbelow40°F(4°C)temperaturewithoutadequatetemperaturepro-

tection.

WARNING:Donotingestalcoholordrugsduringuseorpriortousingpool,spa,orhottub.Ingestion

ofsuchintoxicantscancausedrowsiness,whichcanleadtounconsciousness,andsubsequentlyresultin

drowning.

USING CHLORINATORS AND CHEMICAL FEEDERS:

Followtheinstructionsprovidedwithanyautomaticormanualchlorinatorandchemicalfeeder.All

chemicalsmustbeintroducedanddilutedintothepoolorspawaterbeforebeingcirculatedthroughthe

heater.Donotplacechlorinetabletsorbrominesticksdirectlyintotheskimmer.Highchemicalconcentra-

tionsmayresultwhenthepumpisnotrunning.Highchemicalconcentrationswillcauseveryrapidcorrosion

oftheheatexchanger.ThisdamagewillnotbecoveredbytheHaywardwarranty.

HEATER OPERATION:

Fulllightingandshutdowninstructionsareincludedonthelighting&operatinginstructionslabelafxed

totheinsideofthefrontaccesspanel.SeeFigure2forthelocationofthislabelandthekeypad.SeeFigure3

forthelabel.

Lighting&shutdown

labelislocatedonthe

insideofthefront

accesspanel

Removethese(4)screwsto

removethefrontaccesspane

Keypad

Figure2:Keypadandlabellocations

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

Figure3:Lighting&OperatingInstructionslabel

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

KEYPAD INPUTS

Thecontrolacceptsuserinputsviathekeypadonthefrontpanel.

1. Whenchangingthemodefrom“STANDBY”toeither“SPA”or“POOL”theremaybeuptoa10-

seconddelayfortheblowerfantobeginrunning.Thecontrolperformsaninternalself-testandthen

veriesthattheblowervacuumswitchcontactsareopenbeforeenergizingtheblower.

2. Itisnormalfortheheatertodisplaya1-to2-seconddelayinrespondingtoanykeypadinput.

3. Itisnormalfortheheatertodisplayuptoa5-seconddelaywhenthekeypadisusedtoresetthecon-

troltoclearanerrorcode.

4. Thecontrolwillacceptamodechangeduringlockoutafter5seconds.Thecontrolwillcontinueto

displaytheerrorcodeandremaininlockoutuntilitisreset.Atresetthecontrolwillgotothelast

savedmode.

OPERATION: SET POINT ADJUSTMENT:

Thesetpointtemperatureisdisplayedbypressingthe“UP”or“DOWN”buttonswhilein“POOL”or

“SPA”mode.Thesetpointwillblinkwhileitisdisplayed.Furtherpressingofthe“UP”or“DOWN”buttons

willadjustthesetpointtemperatureupordownasdesired.Thesetpointrangeisbetween65°F(18°C)and

104°F(40°C).

FAHRENHEIT VERSUS CELSIUS:

ThetemperaturecanbedisplayedinFahrenheitorCelsius.TOchangethedisplay,usethe“MODE”but-

tontoplacetheheaterin“STANDBY”.Thenpressandholdthe“UP”and“DOWN”buttonsuntilthedisplay

showsthe°F/°Cselection.Pressthe“DOWN”buttontotogglebetweenselections.Toaccepttheselection,

pressthe“MODE”button.Iftheuserdoesnotact,theselectionwillbeautomaticallyacceptedafter60sec-

onds.

WINTERIZATION:

Inmoderateclimates,theheatercancontinuetooperateduringshort-termcoldspells.Donotusethe

heatertomaintainthewatertemperaturejustabovefreezingorforfreezeprotection.Caremustbetakento

avoidfreeze-upintheheater.Whenitisusedduringfreezingweather,thepumpmustruncontinuously.The

heaterisnotwarrantedagainstfreeze-ups.Inregionswherefreezingtemperaturesareencountered,allwater

mustbedrainedfromtheheaterwhenitisoutofservice,topreventdamagetotheheaterandpiping.Drain-

ingtheheatexchangerisrecommendedaspartoftheseason’sshutdownprocedures.

Figure4:Keypad  KeypadImput

SPRING START-UP – CONSULT A PROFESSIONAL:

1. Inspectandcleantheheater,beingsuretheheaterisfreeofleavesanddebrispriortostartup.

2. Besureinletandoutletpipingareproperlyattachedtotheheaterandthedrainvalveisclosed.

3. Turntheltrationsystempump“ON”andallowthesystemtorunlongenoughtopurgealltheair

fromthelines.

4. Turnthegassupplytotheheater“ON”.

5. Setthetemperaturecontrolusingthekeypadto“POOL”or“SPA”andadjustthesetpointtothe

desiredtemperaturesetting.

6. Ifoperatingdifcultiesareencountered,contactaqualiedservicecompanyforassistance.

ERROR CODES:

Figure5liststheerrorcodesthatmaybedisplayedontheheaterdisplayboard.

Contactaqualiedservicecompanyforassistance.

Code Description Information

Internalfault/power-up

error

Oninitialtrialforignition.Automaticresetisimmediateoncethegasvalve

relaycheckresultsareacceptable.

Gasvalvesensed

as“ON”error

Ifvalveisopenwhenitshouldbeclosedtheheaterwillshutdownandgointo

lockout.Blowerwilloperateuntilerrorconditioniscorrected.Automaticrestart

2minutesaftererroriscorrected.

Gasvalvesensed

as“OFF”error

Ifvalveisclosedbutameissensedtheblowerwillrunfor5sthenstartanew

ignitionsequence.Iferroroccurs10timesduringacallforheatthecontrolwill

gointolockout.Automaticresetis60minutes.

bD Dataretrievalerror Ifcontrolinputdataiscorruptedtheheaterwillshutdownandgointolockout.

Flamepresentwithgas

valve“OFF”error

Ifameissensedwiththegasvalveoffthecontrolwillgointolockout.The

blowerwillrununtilerrorconditioniscorrected.Whencorrected,controlwill

runblowerfor5sthenautomaticallyrestartafter2minutes.

Electricalsupplywiring

error

Thiscodewilldisplayif120Vpolarityisreversed,lowvoltageisdetected,orif

thegroundpathisnotsufcient.Resetisimmediateaftererroriscorrected.

Proverswitch

openerror

Iftheblowerproverswitchdoesnotcloseaftertheblowerstartsthecontrolwill

stoptheignitiontrialgointolockout.Theblowerwillcontinuetorun.Automat-

icresetisimmediateaftertheswitchcloses.

Proverswitchopen

whenexpectedclosed

error

Iftheblowerproverswitchopensunexpectedlyduringoperationthecontrolwill

shutdownandattempttore-light.Iftheswitchdoesnotcloseaftertheblower

startsthecontrolwillgointolockoutwiththeblowerrunning.Automaticresetis

immediateaftererroriscorrected.

Figure5:ERROR CODES

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

Proverswitchopendur-

ingpost-purgeerror

Iftheblowerproverswitchopensduringthepost-purgecycle(heaterisnotr-

ing)thecontrolwilldisplaytheerrorcode.Thepost-purgecyclewillbecom-

pletedoncetheblowerproverswitchcloses.

Proverswitchclosed

whenexpectedopen

error

Iftheblowerproverswitchisclosedbeforeblowerstart-upthecontrolwillnot

starttheblower.Automaticresetisimmediatewhentheswitchopens.

Igniteropenerror Ifthecontrolisnotinlockoutandsensesthattheignitercircuitisopenwhen

theblowerisrunningthecontrolwillturnofftheblowerandgointolockout.

Automaticrestart2min.aftererroriscorrected.

Thermistorerror Anexcessivetemperaturedifferencebetweenthetwothermistors(5°Formore)

oran“outofbounds”conditiononbothsensors(lessthan10°Forgreaterthan

180°F)willresultintheerrorcode.Automaticrestartis2minutesaftertheerror

iscorrected.

Excessivewater

temperatureerror

Ifwatertemperatureexceeds105°Ftheheaterwillshutdownandgointolock-

out.Automaticrestartis2minutesafterwatertemp.dropsbelow105°F.

Rapidwater

temperaturerise

Ifwatertemperaturerisestoorapidlytheheaterwillshutdownandgointolock-

out.Automaticrestartisafter2minutes.Afterthethirdoccurrenceinthesame

callforheattheheaterwilllockout.

Keypadbuttonstuck

closederror

Ifoneofthekeypadbuttonsisclosed(orpressed)formorethan30stheerror

codewillbedisplayedbutthecontrolwillcontinuetofunction.Theerrorcode

willbeclearedwhentheconditioniscorrected.

Ignitionfailureerror Ifthecontrolexceedsthemaximumnumberofignitionretriesorrecyclesthe

heaterwillshutdownandgointolockout.Automaticresetis60minutes.

Communicationerror Ifcommunicationbetweentheignitionboardandthedisplayboardisnotestab-

lishedwithin3sofpower-upanerrorwillbedisplayed.Aftercommunicationis

established,ifitislostfor30s,theerrorwillbedisplayed.Theerrorcodewill

becleareduponavaliddataexchangebetweenboards.

Limitstringopenerror Ifthelimitstringopenstheheatershutsdownandgoesintolockout.Automatic

restartis2minutesaftertheerrorconditioniscorrectedandthelimitstring

closes.

EE EEPROMerror Anerrorwasdetectedintheignitioncontrolcircuitboard.

Figure5:ERROR CODES(continued)

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

HAYWARD POOL HEATER CERTIFICATE OF LIMITED WARRANTY

Limitedheaterwarranty:

TERMSANDCOVERAGE:Wewarrantourpoolheatertobefreefromdefectsinworkmanshipandmateri-

alsundernormaluseandservice.PursuanttothiswarrantyandsubjecttotheConditionsand

Exceptionsindicatedbelow:

 1.Wewillreplace(costoffreight,installation,costoffuel,andservicelaboratuser’sexpense)with

theprevailingcomparablemodel,or,atouroption,repairanypool/spaheaterthatleaksundernor-

maluseandservicewithinoneyearfromthedateoforiginalinstallationforallusers.

 2.Inaddition,wewillreplace(costoffreight,installation,costoffuel,andservicelaboratuser’s

expense)or,atouroption,repairanypartorpartsofthepool/spaheaterwhichmalfunctionsunder

normaluseandservicewithinoneyearfromthedateoforiginalinstallationforallusers.

LIMITATION ON IMPLIED WARRANTIES:WEARENOTLIABLEFORANYCONSEQUENTIAL

DAMAGESFORBREACHOFANYWRITTENORIMPLIEDWARRANTYOFTHISPRODUCT.Im-

pliedwarranties,includingtheWARRANTYofMERCHANTABILITYandallotherimpliedwarrantiesthat

mayarisefromcourseofdealingorusageoftradeimposedonthesaleofthisheaterunderlawsofthestate

arelimitedindurationtothetermofone(1)yearforallusers.Therearenowarrantieswhichextendbeyond

thedescriptiononthefacehereof.Weshallnotinanyeventbeheldliableforanyspecial,indirect,orconse-

quentialdamages.

EXPENSE OF DELIVERY AND INSTALLATION:

Eachpoolheaterorreplacementparttobefurnishedunderthiswarrantyshallbefurnishedatournearest

distributioncenter.Weshallnotpay,norberesponsibleforshippingordeliverychargestotheplaceofinstal-

lation,norforlaborchargesorothercostsofremovalorinstallation.Everydefectiveheaterorpartreplaced

underthiswarrantyshallbecomeourproperty,andassuch,mustbereturnedtoourdistributioncenterwith

transportationchargespaidbytheuser.Anyreplacementpoolheaterfurnishedunderthiswarrantyshallre-

maininwarrantyonlyfortheunexpiredportionofthiswarranty.

CONDITIONS AND EXCEPTIONS:

Thiswarrantyappliesonlytothepool/spaatitsoriginalplaceofinstallationandonlyfortheoriginal

owner.Itdoesnotapplyifthepoolheaterisinstalledinviolationofanyapplicablecodeorordinance,oris

notinstalled,operatedandmaintainedinaccordancewithourinstructions,orismisused,damagedbyac-

cident,weather,actofGod,freezing,watervoidand/orexcesspressure,alteredordisconnected.Itdoesnot

applywithrespectto:

 1.AheaternotequippedwithCertiedC.S.A.limitcontrolsorequivalentpressurereliefvalve.

 2.Aheateroperatedwithsettingsinexcessof,and/orwithfuelnotconformingtothoseshownonrat-

ingplate;

 3.Aheateronwhichtheserialnumbershavebeenaltered,defaced,orremoved.

 4.Leaksarisingfromdefectiveinstallation;

 5.Productionofnoise,odors,ordiscolored(rusty,etc.)water;

 6.Leakagesubstantiallycontributedtobysediment,limeprecipitateand/orhigherthannormaldis-

solvedsolids(pHabove7.8)inthetank,coppertubes,orwaterways;

 7.Leakagecausedsubstantiallycontributedtobycorrosiveelementsintheatmosphere(suchasthe

storageofchlorineorotherchemicals);

 8.Leakagecausedsubstantiallyorcontributedtobycorrosivepoolwaterinanacidcondition(pH

below7.2);

 9.Damagecausedsubstantiallyorcontributedtobyanexternalsourceofenergy;

 10.Apool/spaheaterisawatercontainingdevice.Leakageofwaterfromthisdevicecanbeexpected

atsometimeduetomalfunctionorthelimitations

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

oftheservicelifeofvariouscomponents.Donotinstallthisproductwheresuchleakagecancausedamage.

MANUFACTURERISNOTRESPONSIBLEORLIABLEFORANYCOSTSINCURREDBYSUCH

DAMAGE.

IN NO CASE ARE WE TO BE HELD LIABLE FOR DAMAGE

TO SURROUNDING AREA OR PROPERTY

CAUSED BY LEAKAGE OR MALFUNCTION.

HOW TO CLAIM UNDER THIS WARRANTY:

Theoriginalowner,upondiscoveringthedefect,mustpresenttheattachedcompletedwarrantyclaimcard

withproofofpurchaseeithertothedealerornotifytheCompanyinwritingateitheraddress:

HAYWARD POOL PRODUCTS, INC.

620 DIVISION ST.

ELIZABETH, NJ 07207

HAYWARD POOL PRODUCTS, INC.

2875 POMONA BOULEVARD

POMONA, CA 91768

Uponreceiptofsuchnoticationweshalldecidewhethertorepairsuchpartsorreplaceanypoolheater,

reservingatalltimestherighttoinspectinordertoverifyanyclaimeddefect.Wealsoreservetherightto

haveourrepresentativesmakeanyinspections,repairs,ortofurnishreplacements.Thiswarrantyisintended

asalegallybindingobligationoftheCompany,enforceableinthecourts.Thiswarrantymaygiveyouspe-

ciclegalrightswhichmayvaryfromstatetostate.

LIMITATION ON LIABILITY:

Allintendedrepresentationshavebeenexpresslysetforthinthisdocument.Thiswarrantymaynotbe

extendedbyoraloranyotheradditionalrepresentations,writtensalesinformation,drawings,orothermal-

function,isstrictlylimitedtorepairorreplacementofthedefectiveheaterorpart,asprovidedhereinand

theCompanyisnotresponsiblehereunderforincidentalorconsequentialorincidentalcostsordamages.

Thecompanyneitherassumes,norauthorizesanypersonorrmtoassumeforus,anyfurtherliabilityor

obligationinconnectionwiththesale,installation,use,maintenance,orexistenceoftheheater.SAFETY

WARNING:Poolheatersareheatproducingappliancesandtoavoiddamageorinjuryintheeventofpos-

sibleoverheatingoftheouterjacket(1)nomaterialsshouldbestoredagainstthejacketand(2)careshould

betakentoavoidunnecessarycontact(especiallybychildren)withthejacket.Whenlightingagasheater,the

lightinginstructionsmustbefollowedexactlytoprevent“ashback”ofexcessgasintheheater.Electronic

ignitionheatersandelectricheatersmusthavethepowershutoffwhenmakingadjustmentsto,servicing,or

comingintocontactwiththeheater.UNDERNOCIRCUMSTANCESSHOULDFLAMMABLEMATERI-

ALS,SUCHASGASOLINEORPAINTTHINNERS,BEUSEDORSTOREDINTHEVICINITYOFTHE

HEATERORINANYLOCATIONFROMWHICHFUMESCOULDREACHTHEHEATER.Foryour

comfort,enjoymentandsafety,pleasereadtheenclosedoperatinginstructionscarefully.

Hayward Pool Products, Inc.

620 Division St.

Elizabeth, NJ 07207

Hayward Pool Products, Inc.

2875 Pomona Boulevard

Pomona, CA 91768

Hayward Pool Products, Inc.

2880 Plymouth Drive

Oakville, Ontario L6H 5R4

Hayward S.A.

Zoming de Jumet

B6040 Jumet, Belgique

Hayward Pools H250FDN User manual

Brand: Hayward Pools

Model: H250FDN

Category: Above ground pool accessories

Type: User manual

Download PDF

report

Hayward Pools H250FDN User manual

Hayward Pools H250FDN User manual

Related papers

Other documents