Raystar 112LP GPS Transducer
E32001, E32002
Raystar 112LP GPS Transducer Service Manual 83143-1 1
Warning
CE Marking of Equipment/Replacement Parts
If the Raytheon equipment under repair, test, calibration, installation or setting to work carries the European CE mark,
only parts and components supplied or approved for such use by Raytheon should be used in order to maintain
compliance with the relevant CE requirements.
Incorporation, use or attachment, by any means, of parts or components not supplied for or not approved for such use by
Raytheon or, if supplied or approved for use by Raytheon, not properly fitted in accordance with instructions published,
provided or recommended by Raytheon, may cause the equipment to malfunction and, in particular, to become unsafe or
to no longer meet the relevant CE requirements. In these circumstances, Raytheon Marine Europe Ltd excludes liability
to the fullest extent permissible in law for any loss or damage including any liability for its contribution to such loss or
damage by its negligent acts or omissions .
E32001 (SeaTalk),
E32002 (NMEA),
Raystar 112LP GPS Transducer
Service Manual
D4376-1
Raystar 112LP GPS Transducer
E32001, E32002
2 Raystar 112LP GPS Transducer Service Manual 83143-1
Chapter 1. Disassembly/Assembly
Gasket for
Surface Mounting
Bracket for
Pole/ Rail Mounting
1
10
7 (x3)
Torque
3lb/in
6
5
4
3
8
2 (x3)
Torque
3lb/in
11
12 (x2)
9
13
1. Top cover
2. Screw (x3), No.2 x 3/8 inch
3. Base
4. 'O' ring, inner case seal
5. Cable gland
6. Cable clamp
7. Screw (x3), No.2 x 5/16 inch
8. 'O' ring, outer case seal
9. Base gasket
10. PCB assembly (NMEA or SeaTalk)
11. Pole/rail mounting bracket
12. Screw (x2), M4 x 12 mm
13. Cable (NMEA and SeaTalk)
14. Stud (x2)
15. Thumbnut (x2)
Cable fitting dimensions
14 (x2)
15 (x2)
5mm (0.2 inch)
20mm
(0.8 inch)
Cable clamp
PCB assembly wiring
(NMEA or SeaTalk)
BrownRed Screen Yellow Green
ONLY use studs (14)
and thumbnuts (15)
when surface mounting.
D4375-1
Figure 1: Raystar 112LP GPS Transducer exploded view
Raystar 112LP GPS Transducer
E32001, E32002
Raystar 112LP GPS Transducer Service Manual 83143-1 3
1.1 Raystar 112LP GPS Transducer spare parts list
The item numbers refer to
Figure 1: Raystar 112LP GPS Transducer exploded view
Item Spare Description Part No. Comments
Upper housing assembly,
including
E38002
1 Top cover
2 Screw (x3), No.2 x 3/8 inch Torque 3 lb/in
Lower housing assembly,
including
E38003
3 Base
4 ‘O’ ring, inner case seal Also in E38005
5 Cable gland Also in E38005,E38006
6 Cable clamp Also in E38006
7 Screw (x3), No.2 x 5/16 inch Torque 3 lb/in
8 ‘O’ ring, outer case seal Also in E38005,E38006
9 Base gasket Also in E38005
10 PCB assembly
NMEA E38004
SeaTalk E38007
Pole/rail mounting bracket kit,
including
E35001 Accessory
11 Mounting bracket
12 Screw (x2), M4 x 12mm
Cable assembly,
including
E38006
13 Cable (NMEA)
5 Cable gland Also in E38003, E38005
6 Cable clamp Also in E38003
7 Screw (x3), No.2 x 5/16 inch Also in E38003
Seal kit,
including
E38005
4 ‘O’ ring, inner case seal Also in E38003
5 Cable gland Also in E38003, E38006
8 ‘O’ ring, outer case seal Also in E38003, E38006
9 Base gasket Also in E38003
1.2 Connections (NMEA and SeaTalk)
3 Screen (0V/ground)
2 Screen
(0V/ground)
1 Red
(Power )
4 Yellow
(NMEA out)
5 Green
(NMEA in)
6 Brown (RTCM in)
D4377-1
NMEA connection
D4378-1
Red (12V)
Yellow (SeaTalk input/output)
Brown (RTCM in)
Green (not connected)
Screen (0V/ground)
SeaTalk connection
(Socket removed for SeaTalk)
Raystar 112LP GPS Transducer
E32001, E32002
4 Raystar 112LP GPS Transducer Service Manual 83143-1
Chapter 2. PCB Details
2.1 PCB Layout – NMEA
Taken from Drawin
g
No: 4396-003 Issue: K Date: 10-06-98
D4379-1
Raystar 112LP GPS Transducer
E32001, E32002
Raystar 112LP GPS Transducer Service Manual 83143-1 5
PCB Component List – NMEA
Taken from Drawin
g
No: 4396-003 Issue: K Date: 10-06-98
D4380-1
Raystar 112LP GPS Transducer
E32001, E32002
6 Raystar 112LP GPS Transducer Service Manual 83143-1
2.2 PCB Layout – SeaTalk
Taken from Drawin
g
No: 4396-005 Issue: K Date: 10-06-98
D4381-1
Raystar 112LP GPS Transducer
E32001, E32002
Raystar 112LP GPS Transducer Service Manual 83143-1 7
PCB Component List – SeaTalk
Taken from Drawin
g
No: 4396-005 Issue: K Date: 10-06-98
D4382-1
Raystar 112LP GPS Transducer
E32001, E32002
8 Raystar 112LP GPS Transducer Service Manual 83143-1
Circuit Diagram – NMEA
D4385-1
Raystar 112LP GPS Transducer
E32001, E32002
Raystar 112LP GPS Transducer Service Manual 83143-1 9
Circuit Diagram – SeaTalk
D4386-1
Raystar 112LP GPS Transducer
E32001, E32002
10 Raystar 112LP GPS Transducer Service Manual 83143-1
Raytheon Marine Company
Recreational Products
676 Island Pond Road
Manchester
NH 03109-5420, USA
Telephone 603.647.7530
Fax 603.634.4756
www.raymarine.com
Raytheon Marine Company
Recreational Products
Anchorage Park
Portsmouth, Hampshire
England PO3 5TD
Telephone 01705 693611
Fax 01705 694642
www.raymarine.com
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
Raytheon Raystar 112LP User manual
- Category
- Signal cables
- Type
- User manual
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
Other documents
-
Raymarine 6760 User manual
-
-
-
-
-
-
-
-
-