Vestil PM2-3344-SLP Owner's manual

Brand: Vestil

Model: PM2-3344-SLP

Type: Owner's manual

This manual is also suitable for

PM2-SLP series

rev. 3/3/2015 PM2-3344-SLP, MANUAL.doc





PM2‐3344‐SLPSuperLowProfilePalletTrucks

InstructionManual



After delivery, immediately remove the packaging from the product in a manner that preserves the packaging and

maintainstheorientationoftheproductinthepackaging;theninspecttheproductcloselytodeterminewhether it

sustained damage during transport. If damage is discovered during  the inspection, immediately record a complete

descriptionofthedamageonthebilloflading.Iftheproductisundamaged,discardthepackaging.



NOTES:

1)Compliancewithlaws,regulations,codes,andnon‐voluntarystandardsenforcedinthelocationwheretheproduct

isusedisexclusivelytheresponsibilityoftheowner/end‐user.

2)Vestilisnotliableforanyinjuryorpropertydamagethatoccursasaconsequenceoffailingtoapplyeither:a)the

instructions

inthis manual; or b)informationprovidedon labels affixedtotheproduct.NeitherisVestilresponsible

foranyconsequentialdamagessustainedasaresultoffailingtoexercisesoundjudgmentwhileassembling,installing,

usingormaintainingthisproduct.



Vestil Manufacturing Co.

2999 North Wayne Street, P.O. Box 507, Angola, IN 46703

Telephone: (260) 665-7586 -or- Toll Free (800) 348-0868

Fax: (260) 665-1339

www.vestilmfg.com e-mail: [email protected]m

Table of Contents

Product specifications………………………………………..…………………………………………………………….. 2

Signal words….……………………………………………………………………………………………………………… 3

Safe use recommendations………………………………………………………………………..……………………….. 3

FIG. 1A: PLC-P-FM exploded parts diagram and bill of materials……………………………………………………… 4

FIG. 1B: Adjust pail stops……………………………………….................................................................................. 4

Height adjustment……………………………………………………………………………………………………………. 5

FIG. 2: Height adjustment diagram………………………………………………………………………………………… 5

Use instructions……………………………………………………………………………………………………………… 5

FIG. 3: Center pail beneath platen………………………………………………………………………………………… 5

FIG. 4: Adjust burper plunger assembly…………………………………………………………………………………… 5

Inspections & Maintenance………………………………………………………………………………………………… 6

Label placement diagram……...………………………………………………………………………………………….. 6

Limited warranty…...……………………………………………………………………………………………………….. 7

rev. 3/3/2015 PM2-3344-SLP, MANUAL.doc



Signalwords:

ThismanualusesSIGNALWORDStoindicatethelikelihoodofpersonalinjuries,aswellastheprobableseriousnessofthose

injuries, ifthe productis misused in the ways described. Other signal words call attention to uses of theproduct likely cause

propertydamage.Thesignalwordsusedappearbelowalong

withthemeaningofeachword:





 Identifiesahazardoussituationwhich,ifnotavoided,WILLresultinDEATHorSERIOUSINJURY.

Useofthissignalwordislimitedtothemostextremesituations.



 Identifies a hazardous situation which, if not avoided, COULD result in  DEATH or SERIOUS

INJURY.



 Indicates a hazardous situation which, if not avoided, COULD result in MINOR or MODERATE

injury.



 Identifies practices likely to result in product/property damage, such as operation that might

damagetheproduct.



Each person who assembles, installs,uses, or maintains this productshould read the entiremanual andfully understand

thedirectionsinadvance.Ifafterreadingthemanualyoudonotunderstandaninstruction,askyoursupervisororemployerfor

clarification,becausefailuretoadheretothedirectionsinthismanualmight

resultinseriouspersonalinjury.



Productspecifications:



Dimensionsandotherpertinentspecificationsappearinthetablebelow.

Model

Uniform

capacity

Overallforkdimensions Forkservicerange Netweight

PM2‐2044‐SLP 2,200lb.

1,000kg

20in.(W)x44in.(L)

51cmx112cm

in.to3

in.

3.8cmto8.6cm

313lb.

142.3kg

PM2‐2744‐SLP 2,200lb.

1,000kg

20in.(W)x44in.(L)

51cmx112cm

in.to3

in.

3.8cmto8.6cm

323lb.

146.8kg

PM2‐3344‐SLP 2,200lb.

1,000kg

20in.(W)x44in.(L)

51cmx112cm

in.to3

in.

3.8cmto8.6cm

333lb.

151.4kg



Safeuserecommendations:



Vestil strives to identify foreseeable hazards associated with the use of its products. However, material handling is

dangerous and no manual can address every conceivable risk. The end‐user ultimately must exercise sound judgment at all

timestominimizetherisksassociatedwiththeuseofthisproduct.



 Failure to read and understand the entire manual before assembling, installing, using and servicing the

product is a misuse of the product. If this product is used improperly or carelessly, the operator and/or bystanders might

sustainseriouspersonalinjuries.Toreducethelikelihoodofinjury:

 DO NOT modify theproduct in any way UNLESS you first obtain written approval from Vestil. Unauthorized modifications

automaticallyvoidtheLimitedWarrantyandmight maketheproductunsafetouse.

 Readthemanualwheneverthehandlemustbeinstalledordisconnected.

 Readthemanualwheneverthereleasemechanismrequiresadjustment.

 DONOTexceedthe2,200poundcapacity(alsoseeLabel287in“Labelplacementdiagram”onp.6).

 Keepclearofthewheelsandforkswhileusingthepallettruck.

 DONOTcontinuetousethepallettruckifyouobserveabnormalmotionorhearunusualnoiseswhileraising/loweringthe

forks or moving the truck. Immediately tag the unit “Out of service”. Restore the unit to normal operating condition before

returningittoservice.

 DONOTattempttoresolveanyproblem(s)withtheproductunlessyouarebothauthorizedtodosoandcertainthatitwill

besafetouseafterwards.

 DONOTusethisdeviceUNLESSallproductlabels(see“LabelPlacementDiagram”onp.5)arereadableandundamaged.

Properuse,maintenance,andstorageareessentialforthisproducttofunctionproperly.

o Keeptheproductclean&dry.

o Vestil bears no responsibility for problems that result as a consequence of using unapproved replacement parts. Contact

Vestiltoorderauthorizedreplacementsandsparepartsforthisequipment.



rev. 3/3/2015 PM2-3344-SLP, MANUAL.doc

Assemblyinstructions:

Thefollowinginstructionsexplainhowtoattachtheoperatorhandletothemainbodyofthetruck.



Frontview Si

deview

NOTE: Photosthatappearintheassembly

instructionsareofthehandleandreceiver

connectionwhichappearsinsidethedashed

boxes inthefrontandsideviews.

Step2. Pullthechainoutofthehandleandlayitoverthepivot

pin.

Step1. Insertthebottomofthehandleinto

thereceiver.

Receiver

Step3. Useahammertoinserttheaxlepin through theholes

inthereceiver;thenhammerspringpinsthroughtheendsof

theaxlepin(groovesareprovidedinthereceiverholesforthe

springpins.]Removetheshippingpin.Theshippingpinisnot

partofthefinishedassembly.

Pivot

pin

Chain

Axlepin

Springpin

Shipping

Axlepin

Groovefor

springpin

Spring

in

Step 4. Feedthechainbehindthepivotand

through the axlepin holeandintotherelease

levercavity(alsoseestep1).Thethreaded

shaftandlocknutat

theendofthechainshouldfit in the release

lever asshownbelow.

Release

lever

Release

lever

cavity

Threaded

shaft

Locknut

Release

lever

Pump

iston

rev. 3/3/2015 PM2-3344-SLP, MANUAL.doc



Releaseleveroperation:

Acontrolleverispartofthehandleassembly.Thecontrolleverhas3positions,eachofwhichcorrespondstoadifferent

functionasindicatedinthediagrambelow.Toraisetheforks,pushthecontrolleverdowntotheRAISEposition;thenmovethe

handleup‐and‐down.Tolower

theforks,pullthecontrolleverup.ThecontrolleverreturnstotheDRIVEpositionautomatically

onceitisreleasedfromtheLOWERposition.





Step5. Liftthereleaseleveruntilthethreadedshaftcanslideintotheslotintheendofthelever.



Threaded

shaft

Locknut

Release

lever



 



Troubleshooting:

1. ControllevelintheDRIVEposition:

a. Iftheforkselevatewhilepumpingthehandleup‐and‐down,thelocknut(seestep5above;fastenedtotheendofthe

threadedshaft)requiresadjustment.Turnthenutclockwise;thenpumpthehandleagaintodetermineiftheforks

still

rise.Continuetoturnthenutclockwiseuntiltheforksnolongerrise.

b. Ifpumpingthehandlecausestheforkstolower,turnthelocknutcounterclockwise.Turnthenutcounterclockwise

untiltheforksnolongerdescend.

2. ControlleverintheLOWERposition:

a. Iftheforks

donotlower,turnthelocknutclockwise.Turnthenutclockwiseuntiltheforkslower.

3. ControlleverintheRAISEposition:

a. Iftheforksdonotrisewhilepumpingthehandle,turnthenutcounterclockwise.Continuetoturnthenutuntilthe

forksriseproperly.

RAISE

osition

LOWER

position

DRIVE position

Release

lever

rev. 3/3/2015 PM2-3344-SLP, MANUAL.doc

Labelplacementdiagram:



BA

C

A:Label371



B:Label465



C:Label463



rev. 3/3/2015 PM2-3344-SLP, MANUAL.doc

LIMITEDWARRANTY



Vestil Manufacturing Corporation (“Vestil”) warrants this Semi‐Automatic Strapping Machine, model S‐2001 to be free of

defects in material and workmanship during the warranty period. Our warranty obligation is to provide a replacement for a

defective original part if the part is covered by the warranty, after we receive a proper request from the warrantee (you) for

warrantyservice.



Whomayrequestservice?

Only awarrantee may request service.Youare a warrantee if you purchasedthe productfrom Vestilor from an authorized

distributorANDVestilhasbeenfullypaid.



Whatisan“originalpart”?

Anoriginalpartisapartusedtomaketheproductasshippedtothewarrantee.



Whatisa“properrequest”?

A request for warranty service is proper if Vestil receives: 1) a photocopy of the Customer Invoice that displays the shipping

date; AND 2) a written request for warranty service including your name and phone number.Send requests by any of the

followingmethods:



 Mail   FaxEmail

VestilManufacturingCorporation  (260)665‐1339  [email protected]

2999NorthWayneStreet,POBox507 Phone

Angola,IN46703    (260)665‐7586



Inthewrittenrequest,listthepartsbelievedtobedefectiveandincludetheaddresswherereplacementsshouldbedelivered.



Whatiscoveredunderthewarranty?

AfterVestilreceivesyourrequestforwarrantyservice,anauthorizedrepresentativewillcontactyoutodeterminewhetheryour

claimiscoveredbythewarranty.Beforeprovidingwarrantyservice,Vestilmayrequireyoutosendtheentireproduct,orjust

the defective part or parts, to

 its facility in Angola, IN. The warranty covers defects in the following original dynamic

components:motors,hydraulicpumps,electroniccontrollers,switchesandcylinders.Italsocoversdefectsinoriginalpartsthat

wearundernormalusageconditions(“wearingparts”),suchasbearings,hoses,wheels,seals,brushes,andbatteries.



Howlongisthewarrantyperiod?

The warranty period for original dynamic components is 90 days. For wearing parts, the warranty period is 90 days. The

warranty periods begin on the date when Vestil ships the product to the warrantee.If the product was purchased from an

authorizeddistributor,theperiodsbeginwhenthe distributor shipstheproduct.Vestilmay,at itssolediscretion,extendthe

warrantyperiodsforproductsshippedfromauthorizeddistributorsbyupto

30daystoaccountforshippingtime.



Ifadefectivepartiscoveredbythewarranty,whatwillVestildotocorrecttheproblem?

Vestilwillprovideanappropriatereplacementforanycoveredpart.AnauthorizedrepresentativeofVestilwillcontactyouto

discussyourclaim.



Whatisnotcoveredbythewarranty?

1. Labor;

2. Freight;

3. Occurrenceofanyofthefollowing,whichautomaticallyvoidsthewarranty:

 Productmisuse;

 Negligentoperationorrepair;

 Corrosionoruseincorrosiveconditions;

 Inadequateorimpropermaintenance;

 Damagesustainedduringshipping;

 Accidentsinvolvingtheproduct;

 Unauthorizedmodifications:DONOTmodifytheproductINANYWAYwithoutfirstreceivingwrittenauthorization

fromVestil.Modification(s)mightmaketheproductunsafetouseormightcauseexcessiveand/orabnormalwear.



Doanyotherwarrantiesapplytotheproduct?

VestilManufacturingCorp.makes no other express warranties. All impliedwarrantiesaredisclaimedtotheextentallowedby

law.AnyimpliedwarrantynotdisclaimedislimitedinscopetothetermsofthisLimitedWarranty.



Vestil PM2-3344-SLP Owner's manual

Brand: Vestil

Model: PM2-3344-SLP

Type: Owner's manual

This manual is also suitable for

PM2-SLP series

Download PDF

report

Vestil PM2-3344-SLP Owner's manual

This manual is also suitable for

Vestil PM2-3344-SLP Owner's manual

Related papers

Other documents