Davey PB1200-150L Operating instructions

Brand: Davey

Model: PB1200-150L

Type: Operating instructions

Please pass these instructions on to the operator of this equipment.

Installation and

Operating Instructions

Davey Cascade Waterfall

and Davey Cascade Waterfall

LED Light Control Box

Distributed in Australia and New Zealand by Davey Water Products Pty Ltd.

Congratulations on your purchase of a

Davey Cascade Waterfall.

All components have been designed and manufactured

to give trouble free, reliable operation.

TABLE OF CONTENTS

Pg.

1 Davey Cascade Waterfall ...........................................................................................................................................3

1.1 Dimensions ......................................................................................................................................................3

2 Specications .............................................................................................................................................................4

3 Installation for Davey Cascade Waterfall .................................................................................................................... 5

4 Installation for Single Unit ..........................................................................................................................................5

5 Installation for Multiple Units ......................................................................................................................................6

6 Davey Cascade Waterfall LED Control Box ...............................................................................................................7

7 Installation for LED Control Box .................................................................................................................................7

8 Wiring Diagram ...........................................................................................................................................................8

9 Controls Index .............................................................................................................................................................8

Davey Guarantee .........................................................................................................................................................10

IMPORTANT INFORMATION

Should you wish to use the light function on your Davey Cascade Waterfall, prior to installation, it is

important to rst plug the unit into the Davey Light Control Box (KZD60) and test the LED light strip for

functionality.

It is also important that the unit be installed, such that it can be

removed for servicing and or replacement

DAVEY CASCADE WATERFALL

Keep this manual safe for future reference

READ THIS MANUAL CAREFULLY

· Installation must be done in compliance to local guidelines and regulations

· Installation to be made by authorised personnel only ( e.g. licensed engineers, electrician and plumber)

· Only ltered water should be used with this product, otherwise clogging within the product may occur and

cause leakage

DIMENSION

MODEL NO A (mm) B (mm) C (mm) D (mm) LED TYPE OF WALL INSTALLATION

PB300-25L 306 138 76 25 4W DC 12V Existing Wall

PB300-150L 306 263 76 150 4W DC 12V New Feature Wall (singe brick)

PB300-230L 306 343 76 230 4W DC 12V New Feature Wall (double brick)

PB600-25L 606 138 76 25 8W DC 12V Existing Wall

PB600-150L 606 263 76 150 8W DC 12V New Feature Wall (singe brick)

PB600-230L 606 343 76 230 8W DC 12V New Feature Wall (double brick)

PB900-25L 906 138 76 25 12W DC 12V Existing Wall

PB900-150L 906 263 76 150 12W DC 12V New Feature Wall (singe brick)

PB900-230L 906 343 76 230 12W DC 12V New Feature Wall (double brick)

PB1200-25L 1206 138 76 25 17W DC 12V Existing Wall

PB1200-150L 1206 263 76 150 17W DC 12V New Feature Wall (singe brick)

PB1200-230L 1206 343 76 230 17W DC 12V New Feature Wall (double brick)

Davey Cascade Waterfall is designed to cater for a wide range of sizes to suit various wall lengths and widths.

They are suited for existing and new feature wall installations.

The “Clear Overow” construction requires no painting or no special covering to the face of the feature wall

as it can be easily tucked away. The “Clear Overow” allows it to blend in to your feature wall regardless of

composition.

Davey Cascade Waterfall will provide you with a peaceful and relaxing sound of a running waterfall.

APPROXIMATE PROJECTION OF SHEET OF WATER PER

300MM OF WATERFALL LENGTH SPECIFICATION

Maximum height

23Lpm 34Lpm 45Lpm

300 mm

600 mm

900 mm

SPECIFICATIONS

PB300-25L/PB600-25L/PB900-25L/PB1200-25L/PB300-150L/PB600-150L/PB900-150L/PB1200-150L/

PB300-230L/PB600-230L/PB900-230L/PB1200-230L

Important: Do not remove Grout Guard until the installation is complete.

Do not leave unit in direct sunlight for long periods of time.

200mm100mm

INSTALLATION FOR DAVEY CASCADE WATERFALL

NOTE: It is important to install the Waterfall unit/s in such a way that they can be removed for servicing

and/or replacement.

CONSTRUCTED WALLS: 25mm LIP VERSIONS

PB300-25L/PB600-25L/PB900-25L/PB1200-25L

SINGLE BRICK WALLS DURING CONSTRUCTION: 150mm LIP VERSIONS

PB300-150L/PB600-150L/PB900-150L/PB1200-150L

LIMESTONE BLOCK OR DOUBLE BRICK WALLS DURING CONSTRUCTION: 230mm LIP VERSIONS

PB300-230L/PB600-230L/PB900-230L/PB1200-230L

NOTE: 90 PVC Elbow supplied for bottom feed installations

INSTALLATION FOR PIPING SINGLE UNIT WITH BALL VALVE

NOTE: It is recommended that barrel unions be used for connection to the back of the Waterfall unit/s. This is in

the event that they may need to be removed for service or replacement.

MULTIPLE UNITS WITH BALL VALVE. ( IT IS BEST TO VALVE EACH UNIT)

Warning: Only ltered water should be used with this product, otherwise clogging within the

product may occur and cause leakage.

DAVEY CASCADE WATERFALL LED LIGHT CONTROL BOX

Model: KZD60

Keep this manual safe for future reference

APPLICABLE FOR DAVEY CASCADE WATERFALL MODELS:

PB300-25L/PB600-25L/PB900-25L/PB1200-25L

PB300-150L/PB600-150L/PB900-150L/PB1200-150L

PB300-230L/PB600-230L/PB900-230L/PB1200-230L

Warning: This electrical control box must be installed by a licensed or certied electrician

or a qualied serviceman in accordance to the requirements of local government

standard or regulations. Improper installation will create electric hazards which could

result in serious injury, death as well as damage to the property.

ALWAYS DISCONNECT THE POWER SUPPLY BEFORE SERVICE AND MAINTAINANCE!

INSTALLATION

1. Remove the Panel from the Control Box, position the box to the desired tting place and mark on the wall

with the location of the drilled holes, then drill 4 holes of ø8mm on the marked position and insert a plastic

tting, secure the box by fastening 4 screws of M5 x 35 to the plastic ttings(See diagram below).

2. Feed the LED lights Cable through the cable gland(s) and connect the cable as shown in the Control Box

Wiring Diagram. Reassemble the panel cover and secure the panel by fastening with the 4 x M4 x 12 screws.

3. If multiple Davey Cascade Waterfalls are being installed, the pre-set holes on the side of the Control Box can

be used.

CONTROL BOX INSTALLATION DIAGRAM

SPECIFICATIONS

Working Temperature -20~+40°C

Input AC 100-240V,50/60Hz

Output DC 12V, 60W

Frequency RF 433MHz

IP 45

Double Insulated

CONTROL BOX WIRING DIAGRAM

Warning: Electrical load of the control box should not exceed 60W.

CONTROLS INDEX

PATTERN TABLE

No. PATTERNS REMARKS

1 Static white

2 Static blue

3 Static green

4 Static cyan

5 Static purple

6 Static yellow

7 Three-colour change Red, Green, Blue

8 Seven-colour change White, Red, Yellow, Blue, Green Cyan, Purple

9 Seven-colour gradual change (Fast) White, Red, Yellow, Blue, Green Cyan, Purple

10 Seven-colour gradual change (Slow) White, Red, Yellow, Blue, Green Cyan, Purple

1010

SETTING OF THE REMOTE CONTROL

Operating distance for the remote control is approximately 25m.

Each control box is associated with a remote control. To use a single remote to control a multiple number of

control boxes, you would need to congure the Frequency at the back of the remote control. The Frequency of

the Remote would then need to be synchronized with all the control boxes.

• Slide open the back of Remote Control

• Set the Frequency

• Turn on Control Box(es)

• Sync the Remote to the Control Box(es)

• Press the Sync Button until the lights on the Control Boxes turn on

If you have multiple Control Boxes and you want to use a Remote Control for a specic control box, you must

set the Frequency on the Remote Control to a unique combination.

• Slide open the back of Remote Control

• Set a unique Frequency on the Remote Control

• Turn on the Control Box associated with that particular Remote Control

• Sync the Remote to the Control Box

• Press the Sync Button until the lights on the Control Box turn on

• Once synced, turn off the control box and move to the next set of Control Box and Remote. Repeat the

above steps.

1111

* Installation and operating instructions are included with the product when purchased new.

They may also be found at davey.com.au

DAVEY

REPAIR OR REPLACEMENT GUARANTEE

In the unlikely event in Australia or New Zealand that this Davey product develops any malfunction within one

year of the date of original purchase due to faulty materials or manufacture, Davey will at our option repair or

replace it for you free of charge, subject to the conditions below.

Should you experience any diculties with your Davey product, we suggest in the rst instance that you

contact the Davey Dealer from which you purchased the Davey product. Alternatively you can phone our

Customer Service line on 1300 232 839 in Australia, or 0800 654 333 in New Zealand, or send a written letter to

Davey at the address listed below. On receipt of your claim, Davey will seek to resolve your diculties or, if the

product is faulty or defective, advise you on how to have your Davey product repaired, obtain a replacement or

a refund.

Your Davey One Year Guarantee naturally does not cover normal wear or tear, replacement of product

consumables, loss or damage resulting from misuse or negligent handling, improper use for which the product

was not designed or advertised, failure to properly follow the provided installation and operating instructions,

failure to carry out maintenance, corrosive or abrasive water or other liquid, lightning or high voltage spikes, or

unauthorized persons attempting repairs. Where applicable, your Davey product must only be connected to

the voltage shown on the nameplate.

Your Davey One Year Guarantee does not cover freight or any other costs incurred in making a claim. Please

retain your receipt as proof of purchase; you MUST provide evidence of the date of original purchase when

claiming under the Davey One Year Guarantee.

Davey shall not be liable for any loss of prots or any consequential, indirect or special loss, damage or injury

of any kind whatsoever arising directly or indirectly from Davey products. This limitation does not apply to any

liability of Davey for failure to comply with a consumer guarantee applicable to your Davey product under the

Australian or New Zealand legislation and does not aect any rights or remedies that may be available to you

under the Australian or New Zealand Consumer Legislation.

In Australia, you are entitled to a replacement or refund for a major failure and for compensation for any other

reasonably foreseeable loss or damage. You are also entitled to have the goods repaired or replaced if the

goods fail to be of acceptable quality and the failure does not amount to a major failure.

Should your Davey product require repair or service after the guarantee period; contact your nearest Davey

Dealer or phone the Davey Support Centre on the number listed below.

For a complete list of Davey Dealers visit our website (davey.com.au) or call:

AUSTRALIA

Davey Support Centre

6 Lakeview Drive,

Scoresby, Australia 3179

Ph: 1300 232 839

Fax: 1300 369 119

Website: davey.com.au

Davey Water Products Pty Ltd

Member of the GUD Group

ABN 18 066 327 517

NEW ZEALAND

Davey Support Centre

7 Rockridge Avenue,

Penrose, Auckland 1061

Ph: 0800 654 333

Fax: 09 527 7654

Website: daveynz.co.nz

™ Davey is a trademark of Davey Water Products Pty Ltd.

1212

P/N 402365-2

AUSTRALIA

Davey Support Centre

6 Lakeview Drive,

Scoresby, Australia 3179

Ph: 1300 232 839

Fax: 1300 369 119

Website: davey.com.au

Davey Water Products Pty Ltd

Member of the GUD Group

ABN 18 066 327 517

NEW ZEALAND

Davey Support Centre

7 Rockridge Avenue,

Penrose, Auckland 1061

Ph: 0800 654 333

Fax: 09 527 7654

Website: daveynz.co.nz

™ Davey is a trademark of Davey Water Products Pty Ltd.

Davey PB1200-150L Operating instructions

Davey PB1200-150L Operating instructions

Davey PB1200-150L Operating instructions

Related papers

Other documents