Heatiator ECO-WINS18 User manual

Heatiator
Brand
Heatiator
Model
ECO-WINS18
Category
Stoves
Type
User manual

This manual is also suitable for

www.heatilatorecochoice.com
DO NOT DISCARD THIS MANUAL
CAUTION
• Important operating
and maintenance
instructionsincluded.
• Leavethismanualwith
party responsible for
useandoperation.
• Read, understand and
followtheseinstructions
forsafeinstallationand
operation.
DO NOT
DISCARD
WARNING
If the information in these instruc-
tions is not followed exactly, a
re may result causing property
damage, personal injury, or death.
• Donotstoreorusegasolineorotheram-
mablevaporsandliquidsinthevicinityof
thisoranyotherappliance.
• Donotoverre-Ifheaterorchimneycon-
nectorglows,youareoverring.Overring
willvoidyourwarranty.
• Complywithallminimumclearancesto
combustiblesasspecied.Failureto
complymaycausehousere.
Fire Risk.
WARNING
Forusewithsolidwoodfuelonly.
Otherfuelsmayoverreandgenerate
poisonousgases(i.e.carbonmonoxide).
Installationandserviceofthisapplianceshould
beperformedbyqualiedpersonnel.Hearth&
HomeTechnologiesrecommendsNFIcertied
professionals,ortechnicianssupervisedbyanNFI
certiedprofessional.
WARNING
Hot glass will cause burns.
• Donottouchglassuntilitiscooled
• NEVERallowchildrentotouchglass
• Keepchildrenaway
• CAREFULLYSUPERVISEchildreninsameroomas
replace.
• Alertchildrenandadultstohazardsofhigh
temperatures.
High temperatures may ignite clothing or other
ammable materials.
• Keepclothing,furniture,draperiesandother
ammablematerialsaway.
HOT SURFACES!
Glassandothersurfacesare
hotduringoperationAND
cooldown.
Model:
ECO-WINS18
WOOD BURNING INSERT
Owner’s Manual
InstallationandOperation
Consumer Care 1-866-427-3316 - Prior to calling, please have the model and serial number of the unit you are calling
about. This information can be found at the front of the unit.
7065-132B • August 29, 2011
Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
2
Serial No / Numéro De Série
U.S. ENVIRONMENTAL PROTECTION AGENCY - Certified to comply with July 1990 particulate emission standards.
LISTED ROOM HEATER, SOLID FUEL TYPE. "For Use with Solid Wood Fuel Only."
Also For Use In Mobile Homes
7065-134
I
nstall and use only in accordance with manufacturer's installation, venting and
operating instructions.
CONTACT YOUR LOCAL BUILDING OR FIRE OFFICIALS ABOUT
RESTRICTIONS AND INSTALLATION INSPECTION IN YOUR AREA.
Refer to manufacturer's instructions and local codes for precautions required for
passing chimney through a combustible wall or ceiling.
When used as a masonry insert stove, install only in a masonry fireplace built to
national and/or local codes. Do not remove brick or mortar to accommodate
insert. Installation requires minimum of a starter pipe into existing chimney with
airtight face seal.
Install only on a non-combustible hearth. Approved for installation and use in
factory built zero-clearance fireplaces conforming to minimum fire chamber
specifications, follow instructions in the owner’s manual.
Components required for installation: listed vent liner only.
In Canada a full length 6 inch (152mm) S635 flue liner is required as per ULC
S628-93.
WARNING - Inspect and clean chimney frequently. Under certain conditions of
use, creosote buildup may occur rapidly.
Do not connect this unit to a chimney serving another appliance.
DANGER: Risk of electrical shock. Disconnect power supply before servicing.
Route power cord away from unit. Do not route cord under or in front of
appliance.
Electrical Rating: 115 VAC .63 AMPS 60 Hz
Do not use grate or elevate fire. Build wood fire directly on hearth(firebrick).
Do not overfire. If heater or chimney connector glows, you are overfiring.
Operate only with doors closed. Open only to add fuel to the fire.
Replace glass only with 5mm ceramic available from your dealer.
OPTIONAL COMPONENTS: Mantel Deflector, Part MNTL-18-DFLCTR
PREVENT HOUSE FIRES
1445 N. Highway, Colville, WA 99114
Model / Modèle
:
ECO-WINS18
WOOD INSERT
DO NOT REMOVE THIS LABEL / NE PAS ENLEVER L'ÉTIQUETTE
Manufactured by /
Fabriqué par:
Tested to / Testé a:
UL 1482, ULC S628-93
ATTENTION! Inspectez et nettoyez la cheminée fréquemment. Sous certaines conditions, il se peut que la
créosote s'accumule rapidement.
Ne pas connecter cet appareil à une cheminée servant un autre appareil.
DANGER: Il y a risque de décharge électrique. Déconnectez le fil électrique de la prise de contact avant le
service. 
Éloignez le fil électrique de l'appareil. Ne pas faire passer le fil électrique au dessus ou en dessous de
l'appareil.
Puissance Électrique: 115 VAC, .63 Amps, 60 Hz.
N'élevez pas le feu. Bâtissez le feu de bois directement sur l'âtre.
N
e pas surchauffer. Si l'appareil de chauffage ou le tuyau de cheminée rougissent, vous surchauffez.
Opérez l'appareil seulement lorsque la porte de chargement est fermée. Ouvrez la porte seulement lorsque
vous devez ajouter des combustibles dans le feu.
Remplacez la vitre seulement avec une vitre céramique de 5 mm disponible chez votre fournisseur.
PIÈCES OPTIONNELLES: Déflecteur de cheminée d Piéce 7044-214
APPAREIL DE CHAUFFAGE DE PIÈCE, DE TYPE DE COMBUSTIBLE SOLIDE.
PRÉVENTION DES FEUX DE MAISON
Installez et utilisez en accord avec les instructions d'installation et d'opération du fabricant. Contactez le
bureau de la construction ou le bureau des incendies au sujet des restrictions et des inspections d'installation
dans votre voisinage.
Référez vous aux instructions du fabricant et des codes locaux pour les précautions requises pour passer une
cheminée à travers un mur ou un plafond combustibles, et les compensations maximums.
Lorsque vous utilisez un poêle inséré fabriqué en briques, installez un foyer en briques fabriqué selon des
codes national et/ou locaux. Ne pas enlever de la brique ou du mortier pour accommoder la pièce insérée.
L'installation demande un tuyau allant de la cheminée existante avec un couvert hermétique.
Installez seulement sur un foyer incombustible. Approuvé pour l'installation et l'usage dans les cheminées
avec espace libre de zéro, fabriquées en usine et se conformant aux spécifications minimum de chambre de
feu.
Composants requis pour l'installation: aération homologué revêtement seulement.
Au Canada, un tuyau doublé de grandeur de 6 inch (152mm) S635 est exigé par le code ULC S628-93.
Minimum Clearances To Combustible Material
Espaces Libres Minimum Des Matériaux Combustibles
Hearth Extension /
Extension de l'âtre
THERMAL PROTECTION /
Protection Thermique
Espace Libre Manteau de Cheminée
No Mantel Deflector
Pas de protection de cheminée
n/a
18"
(457)
18”
(457)
B
18"
(457)
n/a
n/a
C
CANADA
C
n/a
18"
(457)
18”
(457)
B
n/a
26"
(660)
21.25”
(540)
USA/
États-Unis
18"
(457)
18"
(457)
16"
(406)
16"
(406)
E
FLOOR PROTECTION /
PROTECTION DU PLANCHER
Floor height 0" to 7" (0 to 178mm) below Insert Base
Hauteur du sol de 0” à 7” (0 à 178mm) sous la base de l’insert
Floor height greater than 7" (178mm) below Insert Base
Hauteur de sol supérieure à 7” (178mm) sous la base de l’insert
1 inch (25) of k=0.47, R = 2.13
12"
(305)
12”
(305)
A
18”
(457)
n/a
n/a
D
18”
(457)
n/a
n/a
Masonry, Heat Exchanger & Zero
Clearance
En briques, Circulant la chaleur &
d'espace libre
MANTEL CLEARANCES
www.heatilatorecochoice.com
007026
A
B
C
D
F
E
SideWall /
Mur de Côté
Maximum Mantel Depth - 11.5" (292mm)
Profondeur Maximum de la Manteau de Cheminée - 11.5"
(292mm)
Fascia or Trim
/
Panneau ou Moulure
Mantel /
Manteau de Cheminée
Fuel
Door
AD
18”
(457)
n/a
n/a
n/a
26"
(660)
21.25”
(540)
with Mantel Deflector
avec un déflecteur de cheminée
USA
/
États-Unis
CANADA
E
F
F
8"
(203)
8”
(203)
USA/
États-Unis & Canada
Floor height 0" to 7" (0 to-178mm) below Insert Base
Hauteur du sol de 0” à 7” (0 à 178mm) sous la base de l’insert
Floor height greater than 7" (178) below Insert Base
Hauteur de sol supérieure à 7” (178) sous la base de l’insert
Only ember protection required
Made in U.S.A. of US and
imported parts.
Fabriqué aux
États-Unis-d’Amérique par des
pièces d’origine américaine et
pièces importées.
W/N 20514
2011
2012 2013 JAN FEB MAR APR MAY JUN JUL AUG SEP OCT NOV DEC
HOT WHILE IN OPERATION DO NOT TOUCH, KEEP CHILDREN,
CLOTHING AND FURNITURE AWAY. CONTACT MAY CAUSE SKIN
BURNS. SEE NAMEPLATE AND INSTRUCTIONS.
CAUTION:
CHAUD LORS DE L'OPÉRATION. NE PAS TOUCHER. GARDEZ LES
ENFANTS ET LES VÊTEMENTS LOIN DE L'ESPACE DÉSIGNÉ DE
L'INSTALLATION. LE CONTACT PEUT CAUSER DES BRÛLURES À LA PEAU. VOIR
L'ÉTIQUETTE ET LES INSTRUCTIONS.
ATTENTION
:
ETL4001508
ModelName
TestLab&Report
Number
MfgDate
SAMPLE OF SERIAL NUMBER / SAFETY LABEL
LOCATION: UNDER ASH LIP, PULL OUT TO VIEW
SerialNumber
SAMPLE
Read this manual before installing or operating this appliance.
Please retain this owner’s manual for future reference.
Congratulations!
CongratulationsonselectingaHeatilatorwoodburning
appliance.Thewoodburningapplianceyouhaveselected
isdesignedtoprovidetheutmostinsafety,reliabilityand
efciency.
Astheownerofanewwoodburningappliance,you’llwant
toreadandcarefullyfollowalloftheinstructionscontained
inthisowner’smanual.Payspecialattentiontoallcautions
andwarnings.
Thisowner’smanualshouldberetainedforfuturerefer-
ence.Wesuggestyoukeepitwithyourotherimportant
documentsandproductmanuals.
Yournewwoodburningappliancewillgiveyouyearsof
durableuseandtrouble-freeenjoyment.Welcometothe
Heatilatorfamilyofwoodburningproducts!
NOTE: Clearances may only be reduced by means
approved by the regulatory authority having jurisdiction
3Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
Congratulations...............................................................2
SampleofSafety/SerialNumberLabel...........................2
WarrantyPolicy...............................................................4-5
Section 1: Listing and Code Approvals
A. ApplianceCertications.....................................6
B. MobileHomeApproved.....................................6
C. GlassSpecications..........................................6
D. BTU&EfciencySpecications........................6
User’s Guide
Section 2: Operating Instructions
A. YourWoodAppliance.......................................7
B. FireSafety.........................................................8
C. Overring...........................................................8
D. Combustible/Non-combustibleMaterial............8
E. SeasonedWood................................................8
F. ChimneyFire.....................................................8
G. BurningProcess................................................9
H. BurnRateAirControl........................................10
I. BurnRatesandOperatingEfciency................10
J. CorrectBafe&BlanketPlacement..................11
K. BuildingaFire...................................................12
L. WoodFuel&Storage........................................13
M. BlowerControlBoxSnapDiscOperations.......14
N. BlowerOperatingInstructions...........................14
O. ClearSpace......................................................15
P. FrequentlyAskedQuestions.............................15
Q. Opacity(Smoke)...............................................15
R. QuickStartGuide..............................................16
Section 3: Maintenance and Service
A. DisposalofAshes.............................................17
B. Chimney&ChimneyConnector
Inspection/Cleaning...........................................17
C. ApplianceInspection-Routine.........................17
D. GlassCleaning..................................................18
E. FirebrickInspection&ReplacementInstruction18
F. QuickReferenceMaintenanceGuide...............19
Section 4: Troubleshooting Guide.....................21
Section 5: Service Parts Replacement
A. GlassReplacement...........................................21
B. SnapDiscReplacement....................................21
C. WiringDiagram.................................................21
D. BlowerReplacement.........................................22
E. Bafe&CeramicBlanketRemoval...................23
F. DoorHandleAssembly.....................................23
G. TubeChannelAssemblyReplacement.............24
Installer’s Guide
Section 6: Getting Started
A. Design,Installation&Location
Considerations..................................................25
B. Draft..................................................................25
C. NegativePressure.............................................26
D. LocatingYourApplianceandChimney.............27
E. ChimneyTerminationRequirements.................27
F. 2-10-3Rule.......................................................28
G. ToolsandSuppliesNeeded..............................29
H. FireSafety.........................................................29
I. InspectApplianceandComponents
andPre-BurnChecklist.....................................29
Section 7: Dimensions and Clearances
A. ApplianceDimensions.......................................30
B. ClearancestoCombustibles(ULandULC)
 andHearthProtectionRequirements................31-32
C. AlternateFloorProtectionCalculation...............33

Section 8: Chimney Systems
A. VentingSystems...............................................34
B. Inspections........................................................34
C. LargerChimneys...............................................34
D. MasonryChimney.............................................34-35
E. MetalHeatCirculatingChimney........................36
F. PrefabricatedMetalChimney............................36
G. SecuringChimneyComponents.......................37
H. AlteringtheFireplace........................................37
I. Factory-BuiltSolidFuelFireplaces...................37
J. OvalizingRoundStainlessSteelLiners............38
K. ChimneyHeight/RiseandRun........................38
Section 9: Appliance Set-up
A. OutsideAirKitInstallation.................................39
B. SecuringStovePipe/LinertoFlueCollar..........40
C. OptionalOffsetAdapterInstallation..................40
D. SecuringAppliancetoStovePipe/Liner............41
E. StandardSurround&CastTrim,.......................41
Section 10: Moble Home Installation.................42
Section 11: Reference Materials
ServiceParts&Accessories.....................................43-46
ServiceMaintenanceLog..........................................47
ContactInformation...................................................48
TABLE OF CONTENTS
Safety Alert Key:
• DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury.
• WARNING!Indicatesahazardoussituationwhich,ifnotavoidedmayresultindeathorseriousinjury.
• CAUTION! Indicatesahazardoussituationwhich,ifnotavoided,mayresultinminorormoderateinjury.
• NOTICE:Indicatespracticeswhichmaycausedamagetotheapplianceortoproperty.
!
Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
4
Warranty Period Heatilator ECO-CHOICE
Appliances
Components Covered
Parts Labor Pellet EPA Wood
1year X X
Allpartsandmaterialexceptascoveredby
Conditions,Exclusions,andLimitationslisted
3years X Firepotsandburnpots
3years 1year X X Castings
5years 3years X Manifoldtubes
5years 3years X X Fireboxandheatexchanger
90days X X
Allreplacementpartsbeyondwarrantyperiod
Seeconditions,exclusions,andlimitationsonnextpage
Page1of2
Hearth & Home Technologies Inc.
HEATILATOR ECO-CHOICE WARRANTY
Hearth&HomeTechnologiesInc.,onbehalfofitshearthbrands(“HHT”),extendsthefollowingwarrantyforECO-
CHOICEbyheatilatorwoodandpellethearthappliancesthatarepurchasedfromanHHTauthorizeddealer.
WARRANTY COVERAGE:
HHTwarrantestotheoriginalowneroftheHHTapplianceatthesiteofinstallation,andtoanytransferreetakingown-
ershipoftheapplianceatthesiteofinstallationwithintwoyearsfollowingthedateoforiginalpurchase,thattheHHT
appliancewillbefreefromdefectsinmaterialsandworkmanshipatthetimeofmanufacture.Afterinstallation,ifcov-
eredcomponentsmanufacturedbyHHTarefoundtobedefectiveinmaterialsorworkmanshipduringtheapplicable
warrantyperiod,HHTwill,atitsoption,repairorreplacethecoveredcomponents.HHT,atitsowndiscretion,mayfully
dischargeallofitsobligationsundersuchwarrantiesbyreplacingtheproductitselforrefundingtheveriedpurchase
priceoftheproductitself.Themaximumamountrecoverableunderthiswarrantyislimitedtothepurchaserpriceof
theproduct.Thiswarrantyissubjecttoconditions,exclusionsandlimitationsasdescribedbelow.
WARRANTY PERIOD:
Warrantycoveragebeginsonthedateoforiginalpurchase.Inthecaseofnewhomeconstruction,warrantycoverage
beginsonthedateofrstoccupancyofthedwellingorsixmonthsafterthesaleoftheproductbyanindependent,
authorizedHHTdealer/distributor,whicheveroccursearlier.Thewarrantyshallcommencenolaterthan24months
followingthedateofproductshipmentfromHHT,regardlessoftheinstallationoroccupancydate.Thewarrantyperiod
forpartsandlaborforcoveredcomponentsisproducedinthefollowingtable.
7014-212B1-10-11
5Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
WARRANTY COVERAGE:
• ThiswarrantyonlycoversHHTappliancesthatarepurchasedthroughanHHTauthorizeddealerordistributor.Alistof
HHTauthorizeddealersisavailableonthHHTbrandedwebsites.
• ThiswarrantyisonlyvalidwhiletheHHTapplianceremainsatthesiteoforiginalinstallation.
• Contactyourinstallingdealerforwarrantyservice.Iftheinstallingdealerisunabletoprovidenecessaryparts,contact
thenearestHHTauthorizeddealerorsupplier.Additionalservicefeesmayapplyifyouareseekingwarrantyservice
fromadealerotherthanthedealerfromwhomyouoriginallypurchasedtheproduct.
• Checkwithyourdealerinadvanceforanycoststoyouwhenarrangingawarrantycall.Travelandshippingcharges
forpartsarenotcoveredbythiswarranty.
WARRANTY EXCLUSIONS:
Thiswarrantydoesnotcoverthefollowing:
• Changesinsurfacenishesasaresultofnormaluse.Asaheatingappliance,somechangesincolorofinteriorand
exteriorsurfacenishesmayoccur.Thisisnotaawandisnotcoveredunderwarranty.
• Damagetoprinted,plated,orenameledsurfacescausedbyngerprints,accidents,misuse,scratches,melteditems,
orotherexternalsourcesandresiduesleftontheplatedsurfacesfromtheuseofabrasivecleanersorpolishes.
• Repairorreplacmentofpartsthataresubjecttonormalwearandtearduringthewarrantyperiod.Thesepartsinclude:
paint,wood,pelletandcoalgaskets;rebricks;grates;ameguides;lightbulbs;batteriesandthediscolorationof
glass.
• Minorexpansion,contraction,ormovementofcertainpartscausingnoise.Theseconditionsarenormalandcom-
plaintsrelatedtothisnoisearenotcoveredbythiswarranty.
• Damagesresultingfrom:(1)failuretoinstall,operate,ormaintaintheapplianceinaccordancewiththeinstallation
instructions,operatinginstructions,andlistingagentidenticationlabelfurnishedwiththeappliance;(2)failureto
installtheapplianceinaccordancewithlocalbuildingcodes;(3)shippingorimproperhandling;(4)improperoperation,
abuse,misuse,continuedoperationwithdamaged,corrodedorfailedcomponents,accident,orimproperly/incorrectly
performedrepairs;(5)environmentalconditions,inadequateventilation,negativepressure,ordraftingcausedbytightly
sealedconstructions,insufcientmake-upairsupply,orhandlingdevicessuchasexhaustfansorforcedairfurnaces
orothersuchcauses;(6)useoffuelsotherthanthosespeciedintheoperatinginstructions;(7)installationoruseof
componentsnotsuppliedwiththeapplianceoranyothercomponentsnotexpresslyauthorizedandapprovedbyHHT;
(8)modicationoftheappliancenotexpresslyauthorizedandapprovedbyHHTinwriting;and/or(9)interruptionsor
uctuationsofelectricalpowersupplytotheappliance.
• Non-HHTventingcomponents,hearthcomponentsorotheraccessoriesusedinconjunctionwiththeappliance.
• Anypartofapre-existingreplacesysteminwhichaninsertoradecorativegasapplianceisinstalled.
• HHT’sobligationunderthiswarrantydoesnotextendtotheappliances’capabilitytoheatthedesiredspace.Informa-
tionisprovidedtoassisttheconsumerandthedealerinselectingtheproperappliancefortheapplication.Consider-
ationmustbegiventoappliancelocationandconguration,environmentalconditions,insulationandairtightnessof
thestructure.
This warranty is void if:
• Theappliancehasbeenover-redoroperatedinatmospherescontaminatedbychlorine,uorine,orotherdamaging
chemicals.Overringcanbeidentiedby,butnotlimitedto,warpedplatesortubes,rustcoloredcastiron,bubbling,
crackinganddiscolorationofsteelorenamelnishes.
• Theapplianceissubjectedtoprolongedperiodsofdampnessorcondensation.
• Thereisanydamagetotheapplianceorothercomponentsduetowaterorweatherdamagewhichistheresultof,but
notlimitedtoimproperchimneyorventinginstallation.
WARRANTY EXCLUSIONS:
• Theowner’sexclusiveremedyandHHT’ssoleobligationunderthiswarranty,underanyotherwarranty,expressor
implied,orincontract,tortorotherwise,shallbelimitedtoreplacement,repair,orrefund,asspeciedabove.Inno
eventwillHHTbeliableforanyincidientalorconsequentialdamagescausedbydefectsintheappliance.Somestates
donotallowexclusionsorlimitationofincidentalorconsequentialdamages,sotheselimitationsmaynotapplytoyou.
Thiswarrantygivesyouspecicerights;youmayalsohaveotherrights,whichvaryfromstatetostate.EXCEPTTO
THEEXTENTPROVIDEDBYLAW,HHTMAKESNOEXPRESSWARRANTIESOTHERTHANTHEWARRANTY
SPECIFIEDHEREIN.THEDURATIONOFANYIMPLIEDWARRANTYISLIMITEDTODURATIONOFTHEEX-
PRESSEDWARRANTYSPECIFIEDABOVE.
Page2of2
7014-212B1-10-11
Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
6
1
Listing and Code Approvals
TheHeatilatroECO-WINS18meetstheU.S.Environmental
ProtectionAgency’s1990particulateemissionstandards.
A. Appliance Certication
C. Glass Specications
D. BTU & Efciency Specications
Thisstoveisequippedwith5mmceramicglass.Replace
glassonlywith5mmceramicglass.Pleasecontactyour
dealerforreplacementglass.
B. Mobile Home Approved
EPA Certied:
2.6gramsperhour
Efciency:
88%
BTU Output:
10,900to22,600/hr
Heating Capacity:
1,130to2,060sqftdepend-
ingonclimatezone
Vent Size:
6inches
Firebox Size:
2.0cubicfeet
Max Wood Length:
18inches
Fuel:
CordWood
Shipping Weight:
337lbs
Model:
ECO-WINS18
Laboratory: Intertek
Report No:
100398890PRT-001
Type:
SolidFuelType,ListedRoomHeater
Standard: UL1482andULCS628-93and
(UM)84-HUD,MobileHome
Approved.
NOTE:Hearth&HomeTechnologies,manufacturerof
thisappliance,reservestherighttoalteritsproducts,
theirspecicationsand/orpricewithoutnotice.
NOTE:Thisinstallationmustconformwithlocalcodes.Inthe
absenceoflocalcodesyoumustcomplywiththeUL1482,
(UM)84-HUDandNPFA211intheU.S.A.andtheULCS628-
93andCAN/CSA-B365InstallationCodesinCanada.
• Thisapplianceisapprovedformobilehomeinstalla-
tionswhennotinstalledinasleepingroomandwhen
anoutsidecombustionairinletisprovided.
• Thestructuralintegrityofthemobilehomeoor,ceil-
ing,andwallsmustbemaintained.
• The appliance must be properly grounded to the
frame of the mobile home with #8 copper ground
wire,anduseonlylisteddouble-wallconnectorpipe.
• OutsideAirKit,partOAK-ACCmustbeinstalledina
mobilehomeinstallation.
Improper installation, adjustment, alteration, service or
maintenancecancauseinjuryorpropertydamage.
Forassistanceoradditionalinformation,consultaqualied
installer,serviceagencyoryourdealer.
ECO-CHOICEisaregisteredtrademarkofHearth&Home
Technologies.
• Installationanduseofanydamagedappliance.
• Modicationoftheappliance.
• Installation other than as instructedby Hearth & Home
Technologies.
• Installationand/oruseofanycomponentpartnotapproved
byHearth&HomeTechnologies.
• Operating appliance without fully assembling all
components.
• Operatingappliancewithoutlegsattached(ifsuppliedwith
unit).
• DoNOTOverre-Ifapplianceorchimneyconnectorglows,
youareoverring.
Anysuchactionthatmaycausearehazard.
WARNING
FireRisk.
Hearth&HomeTechnologiesdisclaimsany
responsibilityfor,andthewarrantywillbe
voidedby,thefollowingactions:
Intertek Testing Laboratory is a National Recognized
Test Lab (NRTL) approved by OSHA.
7Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
2
Operating Instructions
WARNING! DO NOT operate appliance before reading and understanding operating instructions.
Failuretooperateapplianceaccordingtooperatinginstructionscouldcausereorinjury.
User Guide
A. Your Wood Appliance
WARNING
Hot glass will cause burns.
• DO NOTtouchglassuntilitiscooled
• NEVERallowchildrentotouchglass
• Keepchildrenaway
• CAREFULLYSUPERVISEchildreninsameroomasappliance.
• Alertchildrenandadultstohazardsofhightemperatures.
High temperatures may ignite clothing or other ammable materials.
• Keepclothing,furniture,draperiesandotherammablematerialsaway.
HOT SURFACES!
GlassandothersurfacesarehotduringoperationANDcooldown.
Figure 7.1 General Operating Parts
NOTICE:Ifyouexpectthatchildrenmaycomeintocontactwiththisappliance,werecommenda
barriersuchasadecorativescreen.Seeyourdealerforsuggestions.
BLOWER CONTROL
PANEL
BURN RATE
CONTROL
DOOR HANDLE
SURROUND & TRIM SET
SERIAL LABEL
POWERCORD
Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
8
B. Fire Safety
To provide reasonable re safety,the following should be
givenseriousconsideration:
1. Install at least one smoke detector on each oor of
your home to ensure your safety. They should be
located away from the heating appliance and close
to the sleeping areas. Follow the smoke detector
manufacturer’splacementandinstallationinstructions,
andbesuretomaintainregularly.
2. AconvenientlylocatedClassAreextinguisher.
3. Apracticedevacuationplan,consistingofatleasttwo
escaperoutes.
4. Intheeventofachimneyre:
a. Prepareoccupantsforimmediateevacuation
b. Notifyredepartment
D. Combustible/Non-combustible Materials
• Combustible Material
Material made of or surfaced with wood, compressed
paper, plant bers, plastics, or any material capable
of igniting and burning, whether ame-proofed or not,
plasteredorunplastered.
• Non-combustible Material
Materialwhichwillnotigniteandburn.Suchmaterialsare
those consisting entirely of steel, iron, brick, tile, slate,
glassorplasters,oranycombinationthereof.
• Non-combustible Sealant Material
Sealants which will not ignite and burn: Rutland, Inc.
Fireplace Mortar #63, Rutland 76R, Nuflex 304, GE
RTV106orGERTB116(orequivalent).
E. Seasoned Wood
Burnonlydryseasonedwood.
• Storewoodundercover,outoftherainandsnow.
• Dryandwell-seasonedwoodwillnotonlyminimizethe
chanceofcreosoteformation,butwillgiveyouthemost
efcientre.
• Evendrywoodcontainsatleast15%moisturebyweight,
andshouldbeburnedhotenoughtokeepthechimney
hotforaslongasittakestodrythewoodout-aboutone
hour.
• Itisawasteofenergytoburnunseasonedwoodofany
kind.
Deadwoodlyingontheforestoorshouldbeconsideredwet,
andrequiresfullseasoningtime.
• Standingdeadwoodcanbeconsideredtobeabout2/3
seasoned.
• Totellifwoodisdryenoughtoburn,checktheendsof
thelogs.
• Iftherearecracksradiatinginalldirectionsfromthecenter,
itisdry.
• Ifyourwoodsizzlesinthere,eventhoughthesurface
isdry,itmaynotbefullycured.
C. Overring
Donotover-re.
Over-ringmay ignite creosoteor will damagethe
stoveandchimney.
Topreventover-ringyourstove,DONOT:
• Useammableliquids
• Overloadwithwood
• Burntrashorlargeamountsofscraplumber
• Permittoomuchairtothere
WARNING! Risk of Fire!
Symptoms of over-ring may include one or more of the
following:
• Chimneyconnectororapplianceglowing
• Roaring,rumblingnoises
• Loudcrackingorbangingsounds
• Metalwarping
• Chimneyre
1. Symptoms of Over-Firing
2. What To Do if Your Stove is Over-Firing
• Immediatelyclosethedoorandaircontrolstoreduce
airsupplytothere.
• Ifyoususpectachimneyre,calltheredepartment
andevacuateyourhouse.
• Contact your local chimney professional and have
yourstoveandstovepipeinspectedforanydamage.
• Donotuseyourstoveuntilthechimneyprofessional
informsyouitissafetodoso.
Hearth&HomeTechnologiesWILL NOTwarrantystoves
thatexhibitevidenceofover-ring.Evidenceofover-ring
includes,butisnotlimitedto:
• Warpedairtube
• Deterioratedrefractorybrickretainers
• Deterioratedbafeandotherinteriorcomponents
F. Chimney Fire
WARNING! Risk of Fire! A chimney recan permanently
damageyourchimneysystemandnearbystructures.
Intheeventofachimneyre,Hearth&HomeTechnolo-
giesInc.recommends
• Replacementofthechimney,and
• Inspectionoftheadjacentstructuretotheprovisionsof
NFPALevelIIIinspectioncriteria
9Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
G. Burning Process
Inrecentyearstherehasbeenanincreasingconcernabout
airquality.Muchoftheblameforpoorairqualityhasbeen
placedontheburningofwoodforhomeheating.
Inordertoimprovethesituation,wehavedevelopedcleaner-
burningwoodappliancesthatsurpasstherequirementsfor
emissionsestablishedbyourgoverningagencies.
Thesewoodappliancesmustbeproperlyoperatedinorder
to ensure that they perform the way they are designed to
perform.
1. Kindling or First Stage
Ithelpstoknowalittleabouttheactualprocessofburningin
ordertounderstandwhatgoesoninsidetheappliance.The
rststageofburningiscalledthekindlingstage.
Inthisstage:
• Woodisheatedtoatemperaturehighenoughtoevapo-
ratethemoisturepresentinallwood.
• Woodwillreachtheboilingpointofwater(212°F)andwill
notgetanyhotteruntilthewaterisevaporated.
Thisprocesstakesheatfromthecoalsandtendstocoolthe
appliance.
Firerequiresthreethingstoburn:
• Fuel
• Air
• Heat
Ifheatisrobbedfromtheapplianceduringthedryingstage,
thenewloadofwoodhasreducedthechancesforagood
cleanburn.
Itisalwaysbesttoburndry,seasonedrewood.Whenthe
woodisn’tdry,youmustopentheaircontrolsandburnata
highburnsettingforalongertimetostartitburning.
The heat generated from the re should be warming your
homeandestablishingtheuedraft,notevaporatingthemois-
tureoutofwet,unseasonedwood,resultinginwastedheat.
2. Second Stage
Inthesecondarystagewoodgivesoffammablegaseswhich
burnabovethefuelwithbrightames.
Duringthisstageofburning:
• Theamesmustbemaintainedandnotallowedtogoout
toensurethecleanestpossiblere.
•Iftheamestendtogoout,itissettoolowforyourburn-
ingconditions.
Theaircontrollocatedattheupperrighthandcornerisusedto
adjustforburnrates.ThisiscalledtheBurnRateAirControl. 
Figure 10.1 on page 10.
3. Final Stage
Thenalstageofburningisthecharcoalstage.Thisoccurs
when the ammable gases have been mostly burned and
onlycharcoal remains.Thisisanaturallycleanportionof
theburn.Thecoalsburnwithhotblueames.
• Itisveryimportanttoreloadyourappliancewhileenough
livelyhotcoalsremaininordertoprovidetheamountof
heatneededtodryandrekindlethenextloadofwood.
•ItisbesttoopentheBurnRateAirControlbefore reload-
ing.Thislivensupthecoalbedandreducesexcessive
emissions(opacity/smoke).Figure 10.1 on page 10.
• Opendoorslowlysothatashorsmokedoesnotexitap-
pliancethroughopening.
• Break up any large chunks and distribute the coals so
thatthenewwoodislaidonhotcoals.
Airqualityisimportanttoallofus,andifwechoosetouse
woodtoheatourhomesweshoulddosoresponsibly.
Weneedto learn to burn in the cleanest way possible al-
lowingustocontinueusingourwoodappliancesformany
yearstocome.
NOTICE:Improperoperationcanturnanywoodappli-
anceintoasmolderingenvironmentalhazard.
Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
10
H. Burn Rate Air Control
• The air supply enters at the upper front of the rebox,
nearthetopoftheglassdoor.
• Thispreheatedairsuppliesthenecessaryfreshoxygen
tomixwith the unburnedgases, helping to createsec-
ond,thirdandfourthcombustions
• ThisairisregulatedbytheBurnRateAirControl.
• TherearefoursettingsHigh,Medium-High,Medium-Low
andLow.
• WhenthecontrolisraisedallthewayupitisontheHigh
settingand when pushed all the down it is on the Low
setting.Figure 10.1.
I. Burn Rates and Operating Efciency
For maximum operating efciency
1. Followtheinstructionsbelowforeachburnrateforthe
BurnRateAirControl.Figure 10.1.
2. Burndry,well-seasonedwood.
Burn Rates
1. Starting a Fire
• OpentheBurnRateAirControlbyraisingitalltheway
tothetopfortheHighsetting.

• Theblowertendstocooltheappliance.Leavetheblower
offuntiltheburniswellestablished,i.e.,30minutes.
• Afterloadingtheappliancewith wood andstartingthe
re,settheBurnRateAirControlstothedesiredsetting
byfollowingtheburnrateinstructionsbelow.
2. High Burn Rate - Maximum Heat* - 30,000+ BTU/hr
•
Raise the Burn Rate Air Control all the way up until it
stops(topmarker)toafullyopenposition.
•
Besureandmonitortherecloselywhileinthissettingto
avoidoverringyourstove.
3.
Medium-High Burn Rate* - 15,000 to 30,000 BTU/hr
• Raise the Burn Rate Air Control to the Medium High
marker.
Blowermayremainon.
4.
Medium-Low Burn Rate* - 10,000 to 15,000 BTU/hr
• RaisetheBurnRateAirControltotheMediummarker.
Leave the blower off until the burn is well established,
i.e.,30minutes.
5. Low Burn Rate* - Below 10,000 BTU/hr
• LeavetheBurnRateAirControlatthebottommarker.
Leave the blower off until the burn is well established,
i.e.,30minutes.
*NOTE:
Theseareapproximatesettings,andwillvarywith
type of wood or chimney draft. Due to altitude and other
environmentalcircumstances,thisoperationalinformationis
aguidelineonly.
Figure 10.1 - Burn Rate Air Control
-HIGH
-MEDIUM HIGH
-MEDIUM
-LOW
11Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
CORRECT POSITION
INCORRECT POSITIONS
Improperbafeplacementmaycause:
• Overheatingofrebox
• Overheatingthechimney
Bafemustbeplacedproperly(seeinstructions)
Replacebafeifdamagedormissing.
WARNING
Fire Risk
J. Correct Bafe & Blanket Placement
CeramicBlanketandBafeBoardareNOT
incontactwiththebackoftherebox.
CeramicBlanketisNOTincontactwiththe
backofthereboxandNOTevenwiththe
BafeBoardinthefront.
CeramicBlanketisbunchedupattheback
ofthereboxandNOTevenwiththeBafe
Boardinthefront.
Ceramic Blanket
Back of Firebox
Baffle Board
CeramicBlanketandBafeBoardMUSTbe
in contact with the back of the rebox and
evenwitheachotherinthefront.
Ceramic Blanket
Back of Firebox
Baffle Board
Figure 12.1 - Correct Bafe and Blanket Positions Figure 12.2 - Incorrect Bafe and Blanket Positions
Note: Thisaregenericdrawingsandmay
notrepresentyourspecicmodel.
NOTE: Amissing,damagedorimproperlypositionedbafe
isdangerousandmaycausedamageandpoorefciency.
Itwillalsovoidyourwarranty.
Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
12
K. Building A Fire
NOTE:
• Buildreonbrickreboxooronly.
• DoNOTusegratesorothermethodstosupportfuel.
Itwilladverselyaffectemissions.
Odorsandvaporsreleasedduringinitialoperation.
• Curingofhightemperaturepaint.
• Openwindowsforaircirculation.
Odorsmaybeirritatingtosensitiveindividuals.
CAUTION
Fire Risk.
Keepcombustiblematerials,gasoline
andotherammablevaporsandliquids
clearofappliance.
WARNING
• DoNOTstoreammablematerialsintheappliance’s
vicinity.
• DONOTUSEGASOLINE,LANTERNFUEL,
KEROSENE,CHARCOALLIGHTERFLUIDOR
SIMILARLIQUIDSTOSTARTOR“FRESHENUP”A
FIREINTHISHEATER.
• Keepallsuchliquidswellawayfromtheheaterwhileit
isinuse.
• Combustiblematerialsmayignite.
Beforelightingyourrstreintheappliance:
1. Conrmthebafeandceramicblanketarecorrectlyposi-
tioned.Seepage 11 fordetaileddiagrams.Theyshouldbe
evenwiththefronttubeandrestingonbothtubes. Figure
12.1.
2. Removealllabelsfromglass.
Therearemanywaystobuildare.Thebasicprincipleisto
lighteasily-ignitabletinderorpaper,whichignitesthefastburn-
ingkindling,whichinturnignitestheslow-burningrewood.
Hereisonemethodthatworkswell:
1. Raise
theBurnRateAirControltotheHighSetting.
2. Placeseveralwadsofcrushedpaperonthereboxoor.
Heatingtheuewithslightlycrumplednewspaperbefore
addingkindlingkeepssmoketoaminimum.
3. Laysmalldrysticksofkindlingontopofthepaper.
4. Makesurethatnomatchesorothercombustiblesarein
theimmediateareaoftheappliance.Besuretheroomis
ventilatedandtheueunobstructed.
5. Lightthepaperintheappliance.NEVERlightorrekindle
rewithkerosene,gasoline,orcharcoallighteruid;the
resultscanbefatal.
6. Oncethekindlingisburningquickly,addseveralfull-length
logs3to4inches(76to102mm)indiameter.Becareful
nottosmotherthere.Stackthepiecesofwood1/2inch
to1inchapart;nearenoughtokeepeachotherhot,but
farenoughawayfromeachothertoallowairowbetween
them.
7. Oncethereisanestablishedbedofcoals,settheBurn
RateAirControltothedesiredsettingfollowingtheinstruc-
tions found in the Section: Burn Rates and Operating
Efciency.
8. Ifyouhaveinstalledtheoptionalblower,pleasenotethat
theblowertendstocooltheappliance.Leavetheblower
offuntiltheburniswellestablished,i.e.,30minutes.
9. Whenreadytoreload,ItisbesttosettheBurnRateAirControl
intheHighpositionbefore reloading.
• Thislivensupthecoalbedandreducesexcessiveemissions
(opacity/smoke).
• Opendoorslowlysothatashorsmokedoesnotexitappliance
throughopening.
• Largelogsburnslowly,holdingarelonger.
• Smalllogsburnfastandhot,givingquickheat.
10.
Aslongastherearehotcoals,repeatingsteps6through8will
maintainacontinuousrethroughouttheseason.
13Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
L. Wood Fuel & Storage
Moisture
Seasoned Wood
• Cutlogstosize
• Splitto6inches(152mm)orlessindiameter
• Airdrytoamoisturecontentofnotmorethan20%
- Softwood-aboutninemonthstodry
- Hardwood-abouteighteenmonthstodry
Softwoods Hardwoods
• DouglasFir • Oak
• Pine • Maple
• Spruce • Apple
• Cedar • Birch
• Poplar
• Aspen
• Alder
Themajorityoftheproblemsapplianceownersexperience
arecausedbytryingtoburnwet,unseasonedwood.
• Wet,unseasonedwoodrequiresenergytoevaporatethe
waterinsteadofheatingyourhome,and
• Causesevaporatingmoisturewhichcoolsyourchimney,
acceleratingformationofcreosote.
Storing Wood
Stepstoensureproperlyseasonedwood:
• Stack wood to allow air to circulate freely around and
throughwoodpile.
• Elevate wood pile offground to allow air circulation
underneath.
• Smallerpiecesofwooddryfaster.Anypieceover6in.
(152mm)indiametershouldbesplit.
• Wood(wholeorsplit)shouldbestackedsobothendsof
eachpieceareexposedtoair.Moredryingoccursthrough
thecutendsthanthesides.
• Store wood under cover to prevent water absorption
from rain or snow.Avoid covering the sides and ends
completely.
Processed Solid Fuel Fire Logs
• NOTpermittedforuseinthisappliance
WARNING
Fire Risk.
• DONOTBURNGARBAGEORFLAMMABLE
FLUIDSSUCHASGASOLINE,NAPTHAOR
ENGINEOIL.
• DONOTUSECHEMICALSORFLUIDSTOSTARTA
FIRE.
• DoNOTburntreatedwoodorwoodwithsalt(driftwood).
• Maygeneratecarbonmonooxideifburnmaterialother
thanwood.
Mayresultinillnessorpossibledeath.
Hardwood vs Softwood
Yourapplianceperformancedependsonthequalityofthe
rewoodyouuse.
• Seasonedwoodcontainsabout8,000BTUsperpound.
• Hardwoodsaremoredensethansoftwoods.
• Hardwoodscontain60%moreBTUsthansoftwoods.
• Hardwoodsrequiremoretimetoseason,burnslowerand
arehardertoignite.
• Softwoodsrequirelesstimetodry,burnfasterandare
easiertoignite.
• Starttherewithsoftwoodtobringtheapplianceupto
operatingtemperatureandtoestablishdraft.
• Addhardwoodforslow,evenheatandlongerburntime.
• DoNOTburnwetorgreenwood.
• Storewoodindrylocation.
• Stackwoodsobothendsareexposedtoair.
Wet,unseasonedwoodcancauseaccumulationof
creosote.
Fire Risk.
WARNING
WARNING
Fire Risk
DoNOTstorewood:
• Infrontoftheappliance.
• Inspacerequiredforloadingorash
removal.
NOTICE:Seasoningtimemayvarydependingondrying
conditions.
Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
14
N. Blower Operating Instructions
1. The blower will turn on/off automatically when set to
AUTO.Figure 14.1.
2. WhensettoMANUAL,thefanwillturnon/offonlywhen
youturnitonoroff.Thissettingover-ridestheinternal
snapdisc.
3. BlowerControlsarelocatedonbottomleftofappliance.
M. Blower Control Box & Snap Disc
Operating Instructions
Figure 14.1
1.Initial (cold) startup: RaisetheBurnRateAirControl
allthewayuptotheHighsetting.
Theblowertendsto
cooltheappliance.Leavethebloweroffuntiltheburnis
wellestablished,i.e.,30minutes.
2. High Burn Setting: RaisetheBurnRateAirControlall
thewayuptotheHighsetting.Theblowermayremain
on.
3. Medium or Medium High Burn Setting:BurnRateAir
Controlisclosedthenopenedto1inch(pullup).The
blowermayremainon.
4. Medium Low Burn Setting: BurnRateAirControlis
closed then opened to 1/4 inch to 1/2 inch (pull up).
Leavetheblowerofffortherst30minutesuntiltheburn
iswellestablished.
5. Low Burn Setting: Burn Rate Air Control is closed
(downposition).
Leavetheblowerofffortherst30min-
utesuntiltheburniswellestablished.
NOTE: Formaximumefciencyandlowestemissions,
when operating the blower in either the automatic or
manualsettingforthelowandmediumlowburnsettings
leavethebloweroffuntiltheburniswellestablished,i.e.,
30minutes,
When reloading the appliance, raise the Burn RateAir
ControlallthewalltotheHighsettingfor5to15minutes
beforesettingtothedesiredburnrate.
6. Theblowerisequippedwitharheostat(speedcontrol).
The highest blower speed is obtained by turning the
rheostaton,thenadjustingbacktowards“OFF”asfaras
possiblewithoutturningthebloweroff.Foralowblower
speed,turnthecontrolknobclockwiseasfaraspossible
15Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
Q. Opacity (Smoke)
Opacity is the measure of how cleanly your appliance is
burning.
Opacityismeasuredinpercent:
• 100%opacityiswhenanobjectistotallyobscuredby
thesmokecolumnfromachimney,and
• 0%opacitymeansthatnosmokecolumncanbeseen.
As you become familiar with your appliance, you should
periodicallychecktheopacity.Thiswillallowyoutoknow
howtoburnasnearlysmoke-freeaspossible(goalof0%
opacity).
P. Frequently Asked Questions
ISSUES SOLUTIONS
Odorfromappliance Whenrstoperated,thisappliancemayreleaseanodorfortherstseveralhours.Thisis
causedbythecuringofthepaintandtheburningoffofanyoilsremainingfrommanufacturing.
Metallicnoise Noiseiscausedbymetalexpandingandcontractingasitheatsupandcoolsdown,similarto
thesoundproducedbyafurnaceorheatingduct.Thisnoisedoesnotaffecttheoperationor
longevityoftheappliance.
Whirringsound Theblowermayproduceawhirringsoundwhichincreasesinvolumeasthespeedis
increased.
Odorsandvaporsreleasedduringinitialoperation.
• Curingofhightemperaturepaint.
• Openwindowsforaircirculation.
Odorsmaybeirritatingtosensitiveindividuals.
CAUTION
Figure 15.1 - Clear Space
O. Clear Space
• DoNOTplacecombustibleobjectswithin4ft(1.2m)of
thefrontofreplace.Figure 15.1.
• DoNOTplacecombustibleobjectswithin48
inchesinfrontoftheappliance.
• Hightemperaturesmayigniteclothing,furnitureor
draperies.
Fire Risk.
WARNING
NOTICE!
DoNOToperateacirculatingfanwithincloseprox-
imity,approximately4ft(1.2m),ofappliance
•Canreverseairow,blowinghotairintoappli-
ancecavity.
•Candamageapplianceblowerduetooverheat-
ing.
Maintain 4 ft (1.22m) clearance to
combustible in front of appliance
Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
16
R. Quick Start Guide
Note: Thisaregenericdrawingsandmaynotrepresent
yourspecicmodel.
FIRST FIRE ITEMS NEEDED:
10PiecesofNewspaper,10-20PiecesofDryKindling
andaFewPiecesofDrySplitWood.
The stove is ready for
normal operation.
1
2
3
6
7
LOAD WOOD
ADD NEWSPAPER
ADD MORE WOOD
4
ADD KINDLING
LIGHT THE PAPER
HIGH
LOW
OPEN AIR
CONTROL
HIGH
LOW
REDUCE AIR
CONTROL
Settodesiredheat
output
5
WARNING! Risk of Fire
Closeandsecurelylatchthedoorafter
therehasstarted,andafterrefueling,to
prevent:
•Spillageofsmoke,ameandcarbon
monoxide
•Spillageofsparks,coalsandlogs
•Over-ring
DONOTleavethestoveunattendedwith
thedooropen.
Startingaremaynotrequireanopen
doorfordraft.Theaircontrolshould
supplyadequatedraft.
17Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
3
Maintenance and Service
• Frequency: When ash is within 1-3/4 inch (44mm) of
fireboxlip.Leave1/4to1/2inch(6-13mm)ofashinthe
bottomofthefirebox.
• By:Homeowner
A. Disposal of Ashes
• Placeashesinametalcontainerwithatight-ttinglid.
• The closed container should be placed on a non-
combustibleooror on the ground,wellaway from all
combustiblematerials,pendingnaldisposal.
• Iftheashesaredisposedofbyburialinsoilorotherwise
locallydispersed,theyshouldberetainedintheclosed
containeruntilallcindershavethoroughlycooled
WARNING! Risk of Fire! Ashescouldcontainhotembers.
B. Chimney and Chimney Connector
Inspection/Cleaning
• Frequency: Every 2 months during heating season or
as recommended by a certied chimney sweep; more
frequentlyifchimneyexceedsorisunder14-16ft(4.3-
4.8m).(measuredfrombottomofappliance).
• By:CertiedChimneySweep
• Removeallashfromthe reboxandextinguishallhot
embersbeforedisposal.
• Allowtheappliancetocoolcompletely.
• Disconnectuepipeorremovebafeandceramicblanket
from appliance before cleaning chimney. Otherwise
residue can pile up on top of the bafe and ceramic
blanket.(SeeBafeRemovalonpage 23).
• Closethedoortightly.
• Thecreosote or sootshould be removed with abrush
specicallydesignedforthetypeofchimneyinuse.
• Cleanoutfallenashesfromtherebox.
• Itisalsorecommendedthatbeforeeachheatingseason
theentiresystembeprofessionallyinspected,cleaned
andrepairedifnecessary.
WARNING! Risk of Fire! IgnitedcreosoteisextremelyHOT.
Preventcreosotebuildup.
WARNING! Risk of Fire!
Donotusechimneycleanersoramecolorantsinyour
appliance.Itwillcorrodeyourpipe.
Creosote - Formation and Need for Removal
• Whenwoodisburnedslowly, itproducestarandother
organicvapors,whichcombinewithexpelledmoistureto
formcreosote.
• The creosote vapors condense in the relatively cool
chimneyueofaslow-burningre.
• As a result, creosote residue accumulates on the ue
lining. When ignited this creosote makes an extremely
hotre.
• Thechimneyandchimneyconnectorshallbeinspected
everytwomonthsduringtheheatingseasontodetermine
whenacreosotebuilduphasoccurred.
• Whencreosotehasaccumulateditshallberemovedto
reducetheriskofachimneyre.
C. Appliance Inspection - Routine
• Frequency: Every2monthsatthesametimethechim-
neyandchimneyconnectorareinspected.
• By: Homeowner
Checkfor:
• Cracksinglass
• Doorhandle-smoothcamoperation
• Bafeandceramicblanketcorrectplacement
• Bafeforcracks
• Firebrickforcracks,brokenorcrumbly
• Doorgasket.(Dollarbilltest).Placeadollarbillbetween
the stove and the door and then shut the door. If you
canpullthedollar bill out, removeonespacing washer
fromthedoorhandlebehindthelatchcamandtrythetest
again.SeeFigure 22.1 on page 22.Ifyoucanstillpull
thedollarbillout,replacethedoorgasket.
• Glassframeforloosescrews
Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
18
• Frequency: Asdesired
• By:Homeowner
• Cleanglasswithanon-abrasiveglasscleaner.Abrasive
cleanersmayscratchandcauseglasstocrack.
• Ifthedepositsontheglassarenotvery heavy,normal
glass cleaners work well. Heavier deposits may be
removedbyusingadampclothdippedinwoodashesor
byusingacommerciallyavailableovencleaner.
• Afterusinganovencleaner,itisadvisabletoremoveany
residuewith a glass cleaneror soap and water. Oven
cleaner left on during the next ring can permanently
stain the glass and damage the nish on plated metal
surfaces.
• Aportionofthecombustionairenteringthereboxisde-
ecteddownovertheinsideofthedoorglass.
• Thisairow“washes”theglass,helpingtokeepsmoke
fromadheringtoitssurface.
• Whenoperatedatalowburnrate,lessairwillbeowing
overtheglassandthesmoky,relativelycoolconditionof
alowrewillcausetheglasstobecomecoated.
• OperatingtheappliancewiththeBurnRateAirControlall
thewayopenfor15-20minutesshouldremovethebuilt
upcoating.
D. Glass Cleaning
CAUTION! Handle glass assembly with care. Glass is
breakable.
• Avoidstriking,scratchingorslammingglass
• Avoidabrasivecleaners
• Donotcleanglasswhileitishot
Replacetherebrickiftheybecomecrumblyand/orif
thereisa1/4inch(6.35mm)gapbetweenthebricks.
Thereboxislinedwithrebrick,whichhasexceptional
insulatingproperties.Donotuseagrate;simplybuild
areonthereboxoor.Donotoperateappliance
withoutrebrick.
1. Afterthecoalshavecompletelycooled,removeall
oldbrickandashfromunitandvacuumrebox.
2. Removenewbricksetfromboxandlayouttothe
diagramshownintheinstructionsthatcomewith
thereplacementbrickset.
3. Laybottombricksinunit.
4.
Installrearbricksonthetopofthebottombricks.
5. Installsidebricks.Slidetopofbrickunderclips
onsideofreboxandpushthebottomofthebrick
untilitisushwiththesideoftheunit.
E. Inspect Firebrick & Replacement
Instructions
• Frequency: Aftereachashremoval
• By:Homeowner
UsePart832-0550whenorderingindividualbrick.Provide
brickdimensionorcopythepageintheservicepartslist,mark
thedesiredbrickandtakeittoyourauthorizeddealer.
19Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
Note: These are generic drawings and may not represent your specic model.
Baffle
Blanket
Latch Cam
Spacing Washers
Bafe&Blanket
OptionalBlower
ChimneySystem
Firebrick&AshRemoval
Door&GlassAssemblies
DoorHandle
Frequency
MONTHLY
or
AfterEvery
CordofWood
Bafeandblanketplacementiscriticalto
heatoutput,efciencyandoveralllifeofthe
unit.Makesurethebafeispushedallofthe
waytothebackofthereboxandtheblanket
islayingat.Inspectbafeforcracks.
YEARLY
or
AfterEvery
4Cordsof
Wood
Vacuumtheblowerimpellers.
EVERY2
MONTHS
or
AfterEvery
4Cordsof
Wood
T
hechimneyandchimneycapmustbein-
spectedforsootandcreosoteeverytwo
monthsduringtheburnseasonormorefre-
quencyifchimneyexceedsorisunder14-16ft
(4.3m-4.8m)measuredfrombottomofappli-
ance.
Thiswillpreventpipeblockage,poordraft,
andchimneyres.
Alwaysburndrywoodtohelppreventcap
blockageandcreosotebuild-up.
WEEKLY
or
AfterEvery
25Loadsof
Wood
Ashesmustbecoolbeforeyoucandispose
oftheashesinanon-combustiblecontainer.
Firebrickisdesignedtoprotectyourrebox.
Afterashesareremoved,inspectthere-
brickandreplacerebricksthatarecrum-
bling,crackedorbroken.
WEEKLY
or
AfterEvery
25Loadsof
Wood
Keepdoorandglassgasketingoodshapeto
maintaingoodburntimesonalowburnsetting.
Totest:placeadollarbillbetweenthestove
anddoorandthenshutthedoor.Ifyoucan
pullthedollarout,removeonewasherfrom
doorhandlebehindlatchcamandtryagain.If
youcanstillpullitout,replacethedoorgasket.
Checktheglassframeforloosescrewsto
preventairleakage.Checkglassforcracks.
WEEKLY
or
AfterEvery25
LoadsofWood
Checkthedoorlatchforproperadjustment.
Thisisveryimportantespeciallyafterthedoor
ropehasformedtothestoveface.
Checkdoorhandleforsmoothcamoperation.
Task
CAUTION! Allow the appliance to completely cool
down before performing any cleaning or maintenance.
Starttherstinspectionaftertherst2monthsofuse,
or if performance changes, and adjust your schedule
accordingly.Maintenanceisrequiredforsafeoperation
andmustbeperformedtomaintainyourwarranty.
F. Quick Reference Maintenance Guide
Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
20
4
Troubleshooting Guide
Withproperinstallation,operation,andmaintenanceyourwoodstovewillprovideyearsoftrouble-freeservice.Ifyoudo
experienceaproblem,thistroubleshootingguidewillassistyouoraqualiedservicepersoninthediagnosisofaproblem
andthecorrectiveactiontobetaken.
Start Fire Problems Possible Cause Solution
Cannotgetrestarted
Excessivesmokeorspillage
Burnstooslowly
Notenoughheatoutput
Notenoughkindling/paperorno
kindling/paper
Usedrykindling,morepaper.Arrangekindling&
woodforairmovement.
Notenoughairforretoignite
Checkforrestrictedterminationcap
Checkforblockageofoutsideairkit(ifinstalled).
Checkforueblockage.
Pre-warmuebeforestartingre(refertoBuilding
aFireSection).
Checkforadequateventheight(refertoChimney
HeightSection).
Openwindowbelowtheappliancetowardsthe
wind.
Woodconditionistoowet,too
large
Usedry,seasonedwood(refertoSeasonedWood
Section).
Bedofcoalsnotestablished
beforeaddingwood
Startwithpaper&kindlingtoestablishbedof
coals(refertoBuildingaFireSection).
Flueblockagesuchasbirds’
nestsorleavesintermination
cap
Havechimneyinspectedforcreosoteandcleaned
byacertiedchimneysweep.
Downdraftornegativepressure
Competitionwithexhaust
devices
Donotuseexhaustfansduringstart-up(referto
NegativePressureSection).
Openwindowbelowtheappliancetowardsthe
wind.
Fireburnstoofast
Extremelydryorsoftwood
Mixinhardwood.
Mixinlessseasonedwoodafterreisestablished
(refertoWoodFuelSection).
Overdrafting
Checkforcorrectventheight;toomuchvertical
heightcreatesoverdrafting.
Checklocationofventtermination(referto
ChimneyTerminationRequirementSection).
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27
  • Page 28 28
  • Page 29 29
  • Page 30 30
  • Page 31 31
  • Page 32 32
  • Page 33 33
  • Page 34 34
  • Page 35 35
  • Page 36 36
  • Page 37 37
  • Page 38 38
  • Page 39 39
  • Page 40 40
  • Page 41 41
  • Page 42 42
  • Page 43 43
  • Page 44 44
  • Page 45 45
  • Page 46 46
  • Page 47 47
  • Page 48 48

Heatiator ECO-WINS18 User manual

Heatiator
Brand
Heatiator
Model
ECO-WINS18
Category
Stoves
Type
User manual
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents