York BQ 036 User manual

Brand: York

Model: BQ 036

Category: Heat pumps

Type: User manual

This manual is also suitable for

036-21508-005-A-0305

FOR DISTRIBUTION USE ONLY - NOT TO BE USED AT POINT OF RETAIL SALE

SINGLE PACKAGE HEAT PUMP UNITS

BQ 036, 048 & 060

3, 4 & 5 NOMINAL TONS

10.0 SEER

TECHNICAL GUIDE

DESCRIPTION

YORK Sunline 2000™ heat pumps are convertible single

package units with a common cabinet and a common roof

curb for the 3, 4 and 5 ton sizes. The units were designed for

light commercial and commercial applications. They can eas-

ily be installed on a roof curb, slab, roof jack or frame.

All units include:

• Powder Paint finish that meets ASTM-B-117 1000 hour

salt spray standards

• Permanently lubricated motors

• Bottom or side air discharge configuration capability

(field convertible)

• Manufactured under the quality standards of ISO9001

• Simplicity

Control Board

• Copper tube/aluminum fin coils

• Easy access to all components

• Rigging holes in base rails for lifting

• Fork lift slots on three sides

• Single point power connection

• Complete factory package - tested, charged and wired

• CSA agency listing on all units

WARRANTY

• Factory Limited Parts Warranty

• One-year parts warranty

• A Five-year parts warranty on the compressor and

electric heat elements.

036-21508-005-A-0305

2 Unitary Products Group

TABLE OF CONTENTS

DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRODUCT NOMENCLATURE

. . . . . . . . . . . . . . . . . . .3

FEATURES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

FACTORY-INSTALLED OPTIONS . . . . . . . . . . . . . 12

FIELD-INSTALLED ACCESSORIES . . . . . . . . . . . 13

GUIDE SPECIFICATIONS . . . . . . . . . . . . . . . . . . . 40

Fig. #

Pg. #

LIST OF FIGURES

1 UNIT CUTAWAY . . . . . . . . . . . . . . . . . . . . . . . . 12

2 TYPICAL FIELD POWER & CONTROL WIRING 34

3 UNIT DIMENSIONS (3 - 5 TON HEAT PUMP)

FRONT VIEW . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

4 UNIT WITH ECONOMIZER RAINHOOD . . . . . . 35

5 UNIT WITH FIXED OUTDOOR AIR/MOTORIZED

DAMPER RAINHOOD . . . . . . . . . . . . . . . . . . . . 36

6 UNIT DIMENSIONS (REAR VIEW) . . . . . . . . . . 36

7 DISCONNECT/BLOWER ACCESS LOCATION 37

8 TYPICAL APPLICATIONS . . . . . . . . . . . . . . . . . 38

9 FOUR AND SIX POINT LOADING . . . . . . . . . . . 39

10 ROOF CURB DIMENSIONS . . . . . . . . . . . . . . . 40

Tbl. #

Pg. #

LIST OF TABLES

1 SOUND POWER RATING . . . . . . . . . . . . . . . . . 15

2 CAPACITY RATINGS . . . . . . . . . . . . . . . . . . . . 15

3 BQ036 COOLING CAPACITIES (3 TON) . . . . . 16

4 BQ048 COOLING CAPACITIES (4 TON) . . . . . 17

5 BQ060 COOLING CAPACITIES (5 TON) . . . . . 18

6 BQ HEATING CAPACITIES . . . . . . . . . . . . . . . . 19

7 SUPPLY AIR BLOWER PERFORMANCE (3 TON

BELT DRIVE) - SIDE DUCT APPLICATION . . . 20

8 SUPPLY AIR BLOWER PERFORMANCE (4 TON

BELT DRIVE) - SIDE DUCT APPLICATION . . . 21

9 SUPPLY AIR BLOWER PERFORMANCE (5 TON

BELT DRIVE) - SIDE DUCT APPLICATION . . . 22

10 SUPPLY AIR BLOWER PERFORMANCE (3 - 5

TON DIRECT DRIVE) - SIDE DUCT

APPLICATION . . . . . . . . . . . . . . . . . . . . . . . . . . 23

11 BELT DRIVE BLOWER MOTOR AND DRIVE

DATA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

12 STATIC RESISTANCES . . . . . . . . . . . . . . . . . . 24

13 ELECTRIC HEATER CFM LIMITATIONS . . . . . 24

14 ELECTRICAL DATA - BQ036 & 048 DIRECT

DRIVE WITHOUT POWR’D CONVENIENCE

OUTLET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

15 ELECTRICAL DATA - BQ060 DIRECT DRIVE

WITHOUT POWR’D CONVENIENCE

OUTLET 26

16 ELECTRICAL DATA - BQ036 & 048 BELT

DRIVE WITHOUT POWR’D CONVENIENCE

OUTLET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

17 ELECTRICAL DATA - BQ060 BELT DRIVE

WITHOUT POWR’D CONVENIENCE

OUTLET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

18 ELECTRICAL DATA - BQ036 & 048 DIRECT

DRIVE WITH POWR’D CONVENIENCE

OUTLET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

19 ELECTRICAL DATA - BQ060 DIRECT DRIVE WITH

POWR’D CONVENIENCE OUTLET . . . . . . . . . 30

20 ELECTRICAL DATA - BQ036 & 048 BELT DRIVE

WITH POWR’D CONVENIENCE OUTLET . . . . 31

21 ELECTRICAL DATA - BQ060 BELT DRIVE WITH

POWR’D CONVENIENCE OUTLET . . . . . . . . . 32

22 PHYSICAL DATA . . . . . . . . . . . . . . . . . . . . . . . . 33

23 ELECTRIC HEAT CORRECTION FACTORS . . 33

24 VOLTAGE LIMITATIONS . . . . . . . . . . . . . . . . . . 33

25 UTILITIES ENTRY . . . . . . . . . . . . . . . . . . . . . . . 37

26 MINIMUM CLEARANCES . . . . . . . . . . . . . . . . . 37

27 BQ 4 POINT LOADS WEIGHT DISTRIBUTION 39

28 BQ 6 POINT LOADS WEIGHT DISTRIBUTION 39

29 CENTER OF GRAVITY . . . . . . . . . . . . . . . . . . . 39

30 OPERATING WEIGHTS (LBS.) . . . . . . . . . . . . . 39

036-21508-005-A-0305

Unitary Products Group 3

PRODUCT NOMENCLATURE

036-21508-005-A-0305

4 Unitary Products Group

PRODUCT NOMENCLATURE - Continued

3-6T Sunline Model Number Nomenclature

Standard Cabinet

AA None

AB Phase Monitor

AC Coil Guard

AD Dirty Filter Switch

AE Phase Monitor & Coil Guard

AF Phase Monitor & Dirty Filter Switch

AG Coil Guard & Dirty Filter Switch

AH Phase Monitor, Coil Guard, & Dirty Filter Switch

AJ SS Drain Pan

AK SS Drain Pan & Phase Monitor

AL SS Drain Pan & Coil Guard

AM SS Drain Pan & Dirty Filter Switch

AN SS Drain Pan, Phase Monitor, Coil Guard & Dirty Filter Switch

AS Bottom Drain Connection

CA CPC Controller with Dirty Filter Switch & Air Proving Switch

CB CPC Controller, DFS, APS & Phase Monitor

CC CPC Controller, DFS, APS & Coil Guard

CD CPC Controller, DFS, APS, Phase Monitor, & Coil Guard

CE CPC Controller, DFS, APS & Technicoat Cond. Coil

CF CPC Controller, DFS, APS, Technicoat Cond. Coil, & Phase Monitor

CG CPC Controller, DFS, APS, Technicoat Cond. Coil, & Coil Guard

CH CPC Controller, DFS, APS, Technicoat Cond. Coil, Phase Monitor, & Coil Guard

CJ CPC Controller, DFS, APS & Technicoat Evap. Coil

CK CPC Controller, DFS, APS, Technicoat Evap. Coil, & Phase Monitor

CL CPC Controller, DFS, APS, Technicoat Evap. Coil, & Coil Guard

CM CPC Controller, DFS, APS, Technicoat Evap. Coil, Phase Monitor, & Coil Guard

CN CPC Controller, DFS, APS & Technicoat Evap. & Cond Coils

CP CPC Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Phase Monitor

CQ CPC Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Coil Guard

CR CPC Controller, DFS, APS, Technicoat Evap. & Cond Coils, Phase Monitor, & Coil Guard

CS CPC Controller, DFS, APS, SS Drain Pan

CT CPC Controller, DFS, APS, SS Drain Pan, Phase Monitor, & Coil Guard

CU CPC Controller, DFS, APS, SS Drain Pan, & Technicoat Cond Coils

CV CPC Controller, DFS, APS, SS Drain Pan, & Technicoat Evap Coil

CW CPC Controller, DFS, APS, SS Drain Pan, & Technicoat Evap and Cond Coils

CX CPC Controller, DFS, APS, SS Drain Pan, Phase Monitor, Coil Guard, & Technicoat Evap and Cond Coils

JA Johnson UNT Controller with Dirty Filter Switch & Air Proving Switch

JB Johnson UNT Controller, DFS, APS & Phase Monitor

JC Johnson UNT Controller, DFS, APS & Coil Guard

JD Johnson UNT Controller, DFS, APS, Phase Monitor, & Coil Guard

JE Johnson UNT Controller, DFS, APS & Technicoat Cond. Coil

JF Johnson UNT Controller, DFS, APS, Technicoat Cond. Coil, & Phase Monitor

JG Johnson UNT Controller, DFS, APS, Technicoat Cond. Coil, & Coil Guard

JH Johnson UNT Controller, DFS, APS, Technicoat Cond. Coil, Phase Monitor, & Coil Guard

JJ Johnson UNT Controller, DFS, APS & Technicoat Evap. Coil

JK Johnson UNT Controller, DFS, APS, Technicoat Evap. Coil, & Phase Monitor

JL Johnson UNT Controller, DFS, APS, Technicoat Evap. Coil, & Coil Guard

JM Johnson UNT Controller, DFS, APS, Technicoat Evap. Coil, Phase Monitor, & Coil Guard

JN Johnson UNT Controller, DFS, APS & Technicoat Evap. & Cond Coils

JP Johnson UNT Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Phase Monitor

JQ Johnson UNT Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Coil Guard

036-21508-005-A-0305

Unitary Products Group 5

JR Johnson UNT Controller, DFS, APS, Technicoat Evap. & Cond Coils, Phase Monitor, & Coil Guard

JS Johnson UNT Controller, DFS, APS, SS Drain Pan

JT Johnson UNT Controller, DFS, APS, SS Drain Pan, Phase Monitor, & Coil Guard

JU Johnson UNT Controller, DFS, APS, SS Drain Pan, & Technicoat Cond Coils

JV Johnson UNT Controller, DFS, APS, SS Drain Pan, & Technicoat Evap Coil

JW Johnson UNT Controller, DFS, APS, SS Drain Pan, & Technicoat Evap and Cond Coils

JX Johnson UNT Controller, DFS, APS, SS Drain Pan, Phase Monitor, Coil Guard, & Technicoat Evap and Cond Coils

HA Honeywell Excel 10 Controller with Dirty Filter Switch & Air Proving Switch

HB Honeywell Excel 10 Controller, DFS, APS & Phase Monitor

HC Honeywell Excel 10 Controller, DFS, APS & Coil Guard

HD Honeywell Excel 10 Controller, DFS, APS, Phase Monitor, & Coil Guard

HE Honeywell Excel 10 Controller, DFS, APS & Technicoat Cond. Coil

HF Honeywell Excel 10 Controller, DFS, APS, Technicoat Cond. Coil, & Phase Monitor

HG Honeywell Excel 10 Controller, DFS, APS, Technicoat Cond. Coil, & Coil Guard

HH Honeywell Excel 10 Controller, DFS, APS, Technicoat Cond. Coil, Phase Monitor, & Coil Guard

HJ Honeywell Excel 10 Controller, DFS, APS & Technicoat Evap. Coil

HK Honeywell Excel 10 Controller, DFS, APS, Technicoat Evap. Coil, & Phase Monitor

HL Honeywell Excel 10 Controller, DFS, APS, Technicoat Evap. Coil, & Coil Guard

HM Honeywell Excel 10 Controller, DFS, APS, Technicoat Evap. Coil, Phase Monitor, & Coil Guard

HN Honeywell Excel 10 Controller, DFS, APS & Technicoat Evap. & Cond Coils

HP Honeywell Excel 10 Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Phase Monitor

HQ Honeywell Excel 10 Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Coil Guard

HR Honeywell Excel 10 Controller, DFS, APS, Technicoat Evap. & Cond Coils, Phase Monitor, & Coil Guard

HS Honeywell Excel 10 Controller, DFS, APS, SS Drain Pan

HT Honeywell Excel 10 Controller, DFS, APS, SS Drain Pan, Phase Monitor, & Coil Guard

HU Honeywell Excel 10 Controller, DFS, APS, SS Drain Pan, & Technicoat Cond Coils

HV Honeywell Excel 10 Controller,DFS, APS, SS Drain Pan, & Technicoat Evap Coil

HW Honeywell Excel 10 Controller,DFS, APS, SS Drain Pan, & Technicoat Evap and Cond Coils

HX Honeywell Excel 10 Controller,DFS, APS, SS Drain Pan, Phase Monitor, Coil Guard, & Technicoat Evap and Cond Coils

NA Novar ETC-3 Controller with Dirty Filter Switch & Air Proving Switch

NB Novar ETC-3 Controller, DFS, APS & Phase Monitor

NC Novar ETC-3 Controller, DFS, APS & Coil Guard

ND Novar ETC-3 Controller, DFS, APS, Phase Monitor, & Coil Guard

NE Novar ETC-3 Controller, DFS, APS & Technicoat Cond. Coil

NF Novar ETC-3 Controller, DFS, APS, Technicoat Cond. Coil, & Phase Monitor

NG Novar ETC-3 Controller, DFS, APS, Technicoat Cond. Coil, & Coil Guard

NH Novar ETC-3 Controller, DFS, APS, Technicoat Cond. Coil, Phase Monitor, & Coil Guard

NJ Novar ETC-3 Controller, DFS, APS & Technicoat Evap. Coil

NK Novar ETC-3 Controller, DFS, APS, Technicoat Evap. Coil, & Phase Monitor

NL Novar ETC-3 Controller, DFS, APS, Technicoat Evap. Coil, & Coil Guard

NM Novar ETC-3 Controller, DFS, APS, Technicoat Evap. Coil, Phase Monitor, & Coil Guard

NN Novar ETC-3 Controller, DFS, APS & Technicoat Evap. & Cond Coils

NP Novar ETC-3 Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Phase Monitor

NQ Novar ETC-3 Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Coil Guard

NR Novar ETC-3 Controller, DFS, APS, Technicoat Evap. & Cond Coils, Phase Monitor, & Coil Guard

NS Novar ETC-3 Controller, DFS, APS, SS Drain Pan

NT Novar ETC-3 Controller, DFS, APS, SS Drain Pan, Phase Monitor, & Coil Guard

NU Novar ETC-3 Controller, DFS, APS, SS Drain Pan, & Technicoat Cond Coils

NV Novar ETC-3 Controller, DFS, APS, SS Drain Pan, & Technicoat Evap Coil

NW Novar ETC-3, DFS, APS, SS Drain Pan, & Technicoat Evap and Cond Coils

NX Novar ETC-3 Controller, DFS, APS, SS Drain Pan, Phase Monitor, Coil Guard, & Technicoat Evap and Cond Coils

TA Technicoat Condenser Coil

TB Technicoat Condenser Coil & Phase Monitor

TC Technicoat Condenser Coil & Coil Guard

Standard Cabinet

036-21508-005-A-0305

6 Unitary Products Group

TD Technicoat Condenser Coil & Dirty Filter Switch

TE Technicoat Condenser Coil, Phase Monitor, & Coil Guard

TF Technicoat Condenser Coil, Phase Monitor, & Dirty Filter Switch

TG Technicoat Condenser Coil, Coil Guard, & Dirty Filter Switch

TH Technicoat Condenser Coil, Phase Monitor, Coil Guard, & Dirty Filter Switch

TJ Technicoat Evaporator Coil

TK Technicoat Evaporator Coil & Phase Monitor

TL Technicoat Evaporator Coil & Coil Guard

TM Technicoat Evaporator Coil & Dirty Filter Switch

TN Technicoat Evaporator Coil, Phase Monitor, & Coil Guard

TP Technicoat Evaporator Coil, Phase Monitor, & Dirty Filter Switch

TQ Technicoat Evaporator Coil, Coil Guard, & Dirty Filter Switch

TR Technicoat Evaporator Coil, Phase Monitor, Coil Guard, & Dirty Filter Switch

TS Technicoat Evaporator & Condenser Coils

TT Technicoat Evaporator & Condenser Coils & Phase Monitor

TU Technicoat Evaporator & Condenser Coils & Coil Guard

TV Technicoat Evaporator & Condenser Coils & Dirty Filter Switch

TW Technicoat Evaporator & Condenser Coils, Phase Monitor, & Coil Guard

TX Technicoat Evaporator & Condenser Coils, Phase Monitor, & Dirty Filter Switch

TY Technicoat Evaporator & Condenser Coils, Coil Guard, & Dirty Filter Switch

TZ Technicoat Evaporator & Condenser Coils, Phase Monitor, Coil Guard, & Dirty Filter Switch

T1 Technicoat Condenser & SS Drain Pan

T3 Technicoat Condenser Coil, SS Drain Pan, Phase Monitor, Coil Guard, & Dirty Filter Switch

T4 Technicoat Evaporator & SS Drain Pan

T6 Technicoat Evaporator Coil, SS Drain Pan, Phase Monitor, Coil Guard, & Dirty Filter Switch

T7 Technicoat Evaporator & Condenser Coils & SS Drain Pan

T9 Technicoat Evaporator & Condenser Coils, SS Drain Pan, Phase Monitor, Coil Guard, & Dirty Filter Switch

LA Simplicity Intelli-Comfort Controller

LB Simplicity Intelli-Comfort Controller, & Phase Monitor

LC Simplicity Intelli-Comfort Controller, & Coil Guard

LD Simplicity Intelli-Comfort Controller, Phase Monitor, & Coil Guard

LE Simplicity Intelli-Comfort Controller, & Technicoat Cond. Coil

LF Simplicity Intelli-Comfort Controller, Technicoat Cond. Coil, & Phase Monitor

LG Simplicity Intelli-Comfort Controller, Technicoat Cond. Coil, & Coil Guard

LH Simplicity Intelli-Comfort Controller, Technicoat Cond. Coil, Phase Monitor, & Coil Guard

LJ Simplicity Intelli-Comfort Controller, & Technicoat Evap. Coil

LK Simplicity Intelli-Comfort Controller, Technicoat Evap. Coil, & Phase Monitor

LL Simplicity Intelli-Comfort Controller, Technicoat Evap. Coil, & Coil Guard

LM Simplicity Intelli-Comfort Controller, Technicoat Evap. Coil, Phase Monitor, & Coil Guard

LN Simplicity Intelli-Comfort Controller, & Technicoat Evap. & Cond Coils

LP Simplicity Intelli-Comfort Controller, Technicoat Evap. & Cond Coils, & Phase Monitor

LQ Simplicity Intelli-Comfort Controller, Technicoat Evap. & Cond Coils, & Coil Guard

LR Simplicity Intelli-Comfort Controller, Technicoat Evap. & Cond Coils, Phase Monitor, & Coil Guard

LS Simplicity Intelli-Comfort Controller, SS Drain Pan

LT Simplicity Intelli-Comfort Controller, SS Drain Pan, Phase Monitor, & Coil Guard

LU Simplicity Intelli-Comfort Controller, SS Drain Pan, & Technicoat Cond Coils

LV Simplicity Intelli-Comfort Controller, SS Drain Pan, & Technicoat Evap Coil

LW Simplicity Intelli-Comfort Controller, SS Drain Pan, & Technicoat Evap and Cond Coils

LX Simplicity Intelli-Comfort Controller, SS Drain Pan, Phase Monitor, Coil Guard, & Technicoat Evap and Cond Coils

WA Intelli-Comfort w/Mod Link Controller

WB Intelli-Comfort w/Mod Link Controller, & Phase Monitor

WC Intelli-Comfort w/Mod Link Controller, & Coil Guard

WD Intelli-Comfort w/Mod Link Controller, Phase Monitor, & Coil Guard

WE Intelli-Comfort w/Mod Link Controller, & Technicoat Cond. Coil

Standard Cabinet

036-21508-005-A-0305

Unitary Products Group 7

WF Intelli-Comfort w/Mod Link Controller, Technicoat Cond. Coil, & Phase Monitor

WG Intelli-Comfort w/Mod Link Controller, Technicoat Cond. Coil, & Coil Guard

WH Intelli-Comfort w/Mod Link Controller, Technicoat Cond. Coil, Phase Monitor, & Coil Guard

WJ Intelli-Comfort w/Mod Link Controller, & Technicoat Evap. Coil

WK Intelli-Comfort w/Mod Link Controller, Technicoat Evap. Coil, & Phase Monitor

WL Intelli-Comfort w/Mod Link Controller, Technicoat Evap. Coil, & Coil Guard

WM Intelli-Comfort w/Mod Link Controller, Technicoat Evap. Coil, Phase Monitor, & Coil Guard

WN Intelli-Comfort w/Mod Link Controller, & Technicoat Evap. & Cond Coils

WP Intelli-Comfort w/Mod Link Controller, Technicoat Evap. & Cond Coils, & Phase Monitor

WQ Intelli-Comfort w/Mod Link Controller, Technicoat Evap. & Cond Coils, & Coil Guard

WR Intelli-Comfort w/Mod Link Controller, Technicoat Evap. & Cond Coils, Phase Monitor, & Coil Guard

WS Intelli-Comfort w/Mod Link Controller, SS Drain Pan

WT Intelli-Comfort w/Mod Link Controller, SS Drain Pan, Phase Monitor, & Coil Guard

WU Intelli-Comfort w/Mod Link Controller, SS Drain Pan, & Technicoat Cond Coils

WV Intelli-Comfort w/Mod Link Controller, SS Drain Pan, & Technicoat Evap Coil

WW Intelli-Comfort w/Mod Link Controller, SS Drain Pan, & Technicoat Evap and Cond Coils

WX Intelli-Comfort w/Mod Link Controller, SS Drain Pan, Phase Monitor, Coil Guard, & Technicoat Evap and Cond Coils

Hinged Filter Door & Toolless Access Cabinet

BA Hinged Filter Door & Toolless Access Panels

BB Phase Monitor, Hinged Filter Door & Toolless Access Panels

BC Coil Guard, Hinged Filter Door & Toolless Access Panels

BD Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

BE Phase Monitor & Coil Guard, Hinged Filter Door & Toolless Access Panels

BF Phase Monitor & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

BG Coil Guard & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

BH Phase Monitor, Coil Guard, & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

BJ SS Drain Pan & Hinged Filter Door & Toolless Access Panels

BK SS Drain Pan & Phase Monitor, Hinged Filter Door & Toolless Access Panels

BL SS Drain Pan & Coil Guard, Hinged Filter Door & Toolless Access Panels

BM SS Drain Pan & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

BN SS Drain Pan & Phase Monitor & Coil Guard, Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

BS Bottom Drain Connection, Hinged Filter Door & Toolless Access Panels

DA CPC Controller with Dirty Filter Switch & Air Proving Switch, Hinged Filter Door & Toolless Access Panels

DB CPC Controller, DFS, APS & Phase Monitor, Hinged Filter Door & Toolless Access Panels

DC CPC Controller, DFS, APS & Coil Guard, Hinged Filter Door & Toolless Access Panels

DD CPC Controller, DFS, APS, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

DE CPC Controller, DFS, APS & Technicoat Cond. Coil, Hinged Filter Door & Toolless Access Panels

DF CPC Controller, DFS, APS, Technicoat Cond. Coil, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

DG CPC Controller, DFS, APS, Technicoat Cond. Coil, & Coil Guard, Hinged Filter Door & Toolless Access Panels

DH CPC Controller, DFS, APS, Technicoat Cond. Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

DJ CPC Controller, DFS, APS & Technicoat Evap. Coil, Hinged Filter Door & Toolless Access Panels

DK CPC Controller, DFS, APS, Technicoat Evap. Coil, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

DL CPC Controller, DFS, APS, Technicoat Evap. Coil, & Coil Guard, Hinged Filter Door & Toolless Access Panels

DM CPC Controller, DFS, APS, Technicoat Evap. Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

DN CPC Controller, DFS, APS & Technicoat Evap. & Cond Coils, Hinged Filter Door & Toolless Access Panels

DP CPC Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

DQ CPC Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Coil Guard, Hinged Filter Door & Toolless Access Panels

DR CPC Controller, DFS, APS, Technicoat Evap. & Cond Coils, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

DS CPC Controller, DFS, APS, SS Drain Pan Hinged Filter Door & Toolless Access Panels

DT CPC Controller, DFS, APS, SS Drain Pan, Phase Monitor, & Coil Guard Hinged Filter Door & Toolless Access Panels

DU CPC Controller, DFS, APS, SS Drain Pan, & Technicoat Cond Coils Hinged Filter Door & Toolless Access Panels

DV CPC Controller, DFS, APS, SS Drain Pan, & Technicoat Evap Coil Hinged Filter Door & Toolless Access Panels

DW CPC Controller, DFS, APS, SS Drain Pan, & Technicoat Evap and Cond Coils Hinged Filter Door & Toolless Access Panels

Standard Cabinet

036-21508-005-A-0305

8 Unitary Products Group

DX CPC Controller, DFS, APS, SS Drain Pan, Phase Monitor, Coil Guard, & Technicoat Evap and Cond Coils Hinged Filter Door & Toolless

Access Panels

EA Johnson UNT Controller with Dirty Filter Switch & Air Proving Switch, Hinged Filter Door & Toolless Access Panels

EB Johnson UNT Controller, DFS, APS & Phase Monitor, Hinged Filter Door & Toolless Access Panels

EC Johnson UNT Controller, DFS, APS & Coil Guard, Hinged Filter Door & Toolless Access Panels

ED Johnson UNT Controller, DFS, APS, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

EE Johnson UNT Controller, DFS, APS & Technicoat Cond. Coil, Hinged Filter Door & Toolless Access Panels

EF Johnson UNT Controller, DFS, APS, Technicoat Cond. Coil, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

EG Johnson UNT Controller, DFS, APS, Technicoat Cond. Coil, & Coil Guard, Hinged Filter Door & Toolless Access Panels

EH Johnson UNT Controller, DFS, APS, Technicoat Cond. Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

EJ Johnson UNT Controller, DFS, APS & Technicoat Evap. Coil, Hinged Filter Door & Toolless Access Panels

EK Johnson UNT Controller, DFS, APS, Technicoat Evap. Coil, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

EL Johnson UNT Controller, DFS, APS, Technicoat Evap. Coil, & Coil Guard, Hinged Filter Door & Toolless Access Panels

EM Johnson UNT Controller, DFS, APS, Technicoat Evap. Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

EN Johnson UNT Controller, DFS, APS & Technicoat Evap. & Cond Coils, Hinged Filter Door & Toolless Access Panels

EP Johnson UNT Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

EQ Johnson UNT Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Coil Guard, Hinged Filter Door & Toolless Access

Panels

ER Johnson UNT Controller, DFS, APS, Technicoat Evap. & Cond Coils, Phase Monitor, & Coil Guard, Hinged Filter Door &

Toolless Access Panels

ES Johnson UNT Controller, DFS, APS, SS Drain Pan Hinged Filter Door & Toolless Access Panels

ET Johnson UNT Controller, DFS, APS, SS Drain Pan, Phase Monitor, & Coil Guard Hinged Filter Door & Toolless Access Panels

EU Johnson UNT Controller, DFS, APS, SS Drain Pan, & Technicoat Cond Coils Hinged Filter Door & Toolless Access Panels

EV Johnson UNT Controller, DFS, APS, SS Drain Pan, & Technicoat Evap Coil Hinged Filter Door & Toolless Access Panels

EW Johnson UNT Controller, DFS, APS, SS Drain Pan, & Technicoat Evap and Cond Coils Hinged Filter Door & Toolless Access Panels

EX Johnson UNT Controller, DFS, APS, SS Drain Pan, Phase Monitor, Coil Guard, & Technicoat Evap and Cond Coils Hinged Filter Door &

Toolless Access Panels

GA Honeywell Excel 10 Controller with Dirty Filter Switch & Air Proving Switch, Hinged Filter Door & Toolless Access Panels

GB Honeywell Excel 10 Controller, DFS, APS & Phase Monitor, Hinged Filter Door & Toolless Access Panels

GC Honeywell Excel 10 Controller, DFS, APS & Coil Guard, Hinged Filter Door & Toolless Access Panels

GD Honeywell Excel 10 Controller, DFS, APS, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

GE Honeywell Excel 10 Controller, DFS, APS & Technicoat Cond. Coil, Hinged Filter Door & Toolless Access Panels

GF Honeywell Excel 10 Controller, DFS, APS, Technicoat Cond. Coil, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

GG Honeywell Excel 10 Controller, DFS, APS, Technicoat Cond. Coil, & Coil Guard, Hinged Filter Door & Toolless Access Panels

GH Honeywell Excel 10 Controller, DFS, APS, Technicoat Cond. Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access

Panels

GJ Honeywell Excel 10 Controller, DFS, APS & Technicoat Evap. Coil, Hinged Filter Door & Toolless Access Panels

GK Honeywell Excel 10 Controller, DFS, APS, Technicoat Evap. Coil, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

GL Honeywell Excel 10 Controller, DFS, APS, Technicoat Evap. Coil, & Coil Guard, Hinged Filter Door & Toolless Access Panels

GM Honeywell Excel 10 Controller, DFS, APS, Technicoat Evap. Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access

Panels

GN Honeywell Excel 10 Controller, DFS, APS & Technicoat Evap. & Cond Coils, Hinged Filter Door & Toolless Access Panels

GP Honeywell Excel 10 Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Phase Monitor, Hinged Filter Door & Toolless Access

Panels

GQ Honeywell Excel 10 Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Coil Guard, Hinged Filter Door & Toolless Access Panels

GR Honeywell Excel 10 Controller, DFS, APS, Technicoat Evap. & Cond Coils, Phase Monitor, & Coil Guard, Hinged Filter Door & Too

lless

Access Panels

GS Honeywell Excel 10 Controller, DFS, APS, SS Drain Pan

GT Honeywell Excel 10 Controller, DFS, APS, SS Drain Pan, Phase Monitor, & Coil Guard

GU Honeywell Excel 10 Controller, DFS, APS, SS Drain Pan, & Technicoat Cond Coils

GV Honeywell Excel 10 Controller,DFS, APS, SS Drain Pan, & Technicoat Evap Coil

GW Honeywell Excel 10 Controller,DFS, APS, SS Drain Pan, & Technicoat Evap and Cond Coils

GX Honeywell Excel 10 Controller,DFS, APS, SS Drain Pan, Phase Monitor, Coil Guard, & Technicoat Evap and Cond Coils

PA Novar ETC-3 Controller with Dirty Filter Switch & Air Proving Switch, Hinged Filter Door & Toolless Access Panels

PB Novar ETC-3 Controller, DFS, APS & Phase Monitor, Hinged Filter Door & Toolless Access Panels

Hinged Filter Door & Toolless Access Cabinet

036-21508-005-A-0305

Unitary Products Group 9

PC Novar ETC-3 Controller, DFS, APS & Coil Guard, Hinged Filter Door & Toolless Access Panels

PD Novar ETC-3 Controller, DFS, APS, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

PE Novar ETC-3 Controller, DFS, APS & Technicoat Cond. Coil, Hinged Filter Door & Toolless Access Panels

PF Novar ETC-3 Controller, DFS, APS, Technicoat Cond. Coil, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

PG Novar ETC-3 Controller, DFS, APS, Technicoat Cond. Coil, & Coil Guard, Hinged Filter Door & Toolless Access Panels

PH Novar ETC-3 Controller, DFS, APS, Technicoat Cond. Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

PJ Novar ETC-3 Controller, DFS, APS & Technicoat Evap. Coil, Hinged Filter Door & Toolless Access Panels

PK Novar ETC-3 Controller, DFS, APS, Technicoat Evap. Coil, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

PL Novar ETC-3 Controller, DFS, APS, Technicoat Evap. Coil, & Coil Guard, Hinged Filter Door & Toolless Access Panels

PM Novar ETC-3 Controller, DFS, APS, Technicoat Evap. Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

PN Novar ETC-3 Controller, DFS, APS & Technicoat Evap. & Cond Coils, Hinged Filter Door & Toolless Access Panels

PP Novar ETC-3 Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

PQ Novar ETC-3 Controller, DFS, APS, Technicoat Evap. & Cond Coils, & Coil Guard, Hinged Filter Door & Toolless Access Panels

PR Novar ETC-3 Controller, DFS, APS, Technicoat Evap. & Cond Coils, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access

Panels

PS Novar ETC-3 Controller, DFS, APS, SS Drain Pan

PT Novar ETC-3 Controller, DFS, APS, SS Drain Pan, Phase Monitor, & Coil Guard

PU Novar ETC-3 Controller, DFS, APS, SS Drain Pan, & Technicoat Cond Coils

PV Novar ETC-3 Controller, DFS, APS, SS Drain Pan, & Technicoat Evap Coil

PW Novar ETC-3, DFS, APS, SS Drain Pan, & Technicoat Evap and Cond Coils

PX Novar ETC-3 Controller, DFS, APS, SS Drain Pan, Phase Monitor, Coil Guard, & Technicoat Evap and Cond Coils

UA Technicoat Condenser Coil, Hinged Filter Door & Toolless Access Panels

UB Technicoat Condenser Coil & Phase Monitor, Hinged Filter Door & Toolless Access Panels

UC Technicoat Condenser Coil & Coil Guard, Hinged Filter Door & Toolless Access Panels

UD Technicoat Condenser Coil & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

UE Technicoat Condenser Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

UF Technicoat Condenser Coil, Phase Monitor, & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

UG Technicoat Condenser Coil, Coil Guard, & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

UH Technicoat Condenser Coil, Phase Monitor, Coil Guard, & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

UJ Technicoat Evaporator Coil, Hinged Filter Door & Toolless Access Panels

UK Technicoat Evaporator Coil & Phase Monitor, Hinged Filter Door & Toolless Access Panels

UL Technicoat Evaporator Coil & Coil Guard, Hinged Filter Door & Toolless Access Panels

UM Technicoat Evaporator Coil & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

UN Technicoat Evaporator Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

UP Technicoat Evaporator Coil, Phase Monitor, & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

UQ Technicoat Evaporator Coil, Coil Guard, & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

UR Technicoat Evaporator Coil, Phase Monitor, Coil Guard, & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

US Technicoat Evaporator & Condenser Coils, Hinged Filter Door & Toolless Access Panels

UT Technicoat Evaporator & Condenser Coils & Phase Monitor, Hinged Filter Door & Toolless Access Panels

UU Technicoat Evaporator & Condenser Coils & Coil Guard, Hinged Filter Door & Toolless Access Panels

UV Technicoat Evaporator & Condenser Coils & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

UW Technicoat Evaporator & Condenser Coils, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

UX Technicoat Evaporator & Condenser Coils, Phase Monitor, & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

UY Technicoat Evaporator & Condenser Coils, Coil Guard, & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

UZ Technicoat Evaporator & Condenser Coils, Phase Monitor, Coil Guard, & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

U1 Technicoat Condenser & SS Drain Pan, Hinged Filter Door & Toolless Access Panels

U3 Technicoat Condenser Coil, SS Drain Pan, Phase Monitor, Coil Guard, & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

U4 Technicoat Evaporator & SS Drain Pan, Hinged Filter Door & Toolless Access Panels

U6 Technicoat Evaporator Coil, SS Drain Pan, Phase Monitor, Coil Guard, & Dirty Filter Switch, Hinged Filter Door & Toolless Access Panels

U7 Technicoat Evaporator & Condenser Coils & SS Drain Pan, Hinged Filter Door & Toolless Access Panels

U9 Technicoat Evaporator & Condenser Coils, SS Drain Pan, Phase Monitor, Coil Guard, & Dirty Filter Switch, Hinged Filter Door & Toolless

Access Panels

QA Simplicity Intelli-Comfort Controller with Hinged Filter Door & Toolless Access Panels

QB Simplicity Intelli-Comfort Controller, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

QC Simplicity Intelli-Comfort Controller, & Coil Guard, Hinged Filter Door & Toolless Access Panels

Hinged Filter Door & Toolless Access Cabinet

036-21508-005-A-0305

10 Unitary Products Group

QD Simplicity Intelli-Comfort Controller, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

QE Simplicity Intelli-Comfort Controller, & Technicoat Cond. Coil, Hinged Filter Door & Toolless Access Panels

QF Simplicity Intelli-Comfort Controller, Technicoat Cond. Coil, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

QG Simplicity Intelli-Comfort Controller, Technicoat Cond. Coil, & Coil Guard, Hinged Filter Door & Toolless Access Panels

QH Simplicity Intelli-Comfort Controller, Technicoat Cond. Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access

QJ Simplicity Intelli-Comfort Controller, & Technicoat Evap. Coil, Hinged Filter Door & Toolless Access Panels

QK Simplicity Intelli-Comfort Controller, Technicoat Evap. Coil, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

QL Simplicity Intelli-Comfort Controller, Technicoat Evap. Coil, & Coil Guard, Hinged Filter Door & Toolless Access Panels

QM Simplicity Intelli-Comfort Controller, Technicoat Evap. Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access

QN Simplicity Intelli-Comfort Controller, & Technicoat Evap. & Cond Coils, Hinged Filter Door & Toolless Access Panels

QP Simplicity Intelli-Comfort Controller, Technicoat Evap. & Cond Coils, & Phase Monitor, Hinged Filter Door & Toolless Access Pan

QQ Simplicity Intelli-Comfort Controller, Technicoat Evap. & Cond Coils, & Coil Guard, Hinged Filter Door & Toolless Access Panels

QR Simplicity Intelli-Comfort Controller, Technicoat Evap. & Cond Coils, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolles

QS Simplicity Intelli-Comfort Controller, SS Drain Pan Hinged Filter Door & Toolless Access Panels

QT Simplicity Intelli-Comfort Controller, SS Drain Pan, Phase Monitor, & Coil Guard Hinged Filter Door & Toolless Access Panels

QU Simplicity Intelli-Comfort Controller, SS Drain Pan, & Technicoat Cond Coils Hinged Filter Door & Toolless Access Panels

QV Simplicity Intelli-Comfort Controller, SS Drain Pan, & Technicoat Evap Coil Hinged Filter Door & Toolless Access Panels

QW Simplicity Intelli-Comfort Controller, SS Drain Pan, & Technicoat Evap and Cond Coils Hinged Filter Door & Toolless Access Panels

QX Simplicity Intelli-Comfort Controller, SS Drain Pan, Phase Monitor, Coil Guard, & Technicoat Evap and Cond Coils Hinged Filter Door &

Toolless Access Panels

XA Intelli-Comfort w/Mod Link Controller, Hinged Filter Door & Toolless Access Panels

XB Intelli-Comfort w/Mod Link Controller, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

XC Intelli-Comfort w/Mod Link Controller, & Coil Guard, Hinged Filter Door & Toolless Access Panels

XD Intelli-Comfort w/Mod Link Controller, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access Panels

XE Intelli-Comfort w/Mod Link Controller, & Technicoat Cond. Coil, Hinged Filter Door & Toolless Access Panels

XF Intelli-Comfort w/Mod Link Controller, Technicoat Cond. Coil, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

XG Intelli-Comfort w/Mod Link Controller, Technicoat Cond. Coil, & Coil Guard, Hinged Filter Door & Toolless Access Panels

XH Intelli-Comfort w/Mod Link Controller, Technicoat Cond. Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access

XJ Intelli-Comfort w/Mod Link Controller, & Technicoat Evap. Coil, Hinged Filter Door & Toolless Access Panels

XK Intelli-Comfort w/Mod Link Controller, Technicoat Evap. Coil, & Phase Monitor, Hinged Filter Door & Toolless Access Panels

XL Intelli-Comfort w/Mod Link Controller, Technicoat Evap. Coil, & Coil Guard, Hinged Filter Door & Toolless Access Panels

XM Intelli-Comfort w/Mod Link Controller, Technicoat Evap. Coil, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolless Access

XN Intelli-Comfort w/Mod Link Controller, & Technicoat Evap. & Cond Coils, Hinged Filter Door & Toolless Access Panels

XP Intelli-Comfort w/Mod Link Controller, Technicoat Evap. & Cond Coils, & Phase Monitor, Hinged Filter Door & Toolless Access Pan

XQ Intelli-Comfort w/Mod Link Controller, Technicoat Evap. & Cond Coils, & Coil Guard, Hinged Filter Door & Toolless Access Panels

XR Intelli-Comfort w/Mod Link Controller, Technicoat Evap. & Cond Coils, Phase Monitor, & Coil Guard, Hinged Filter Door & Toolles

XS Intelli-Comfort w/Mod Link Controller, SS Drain Pan Hinged Filter Door & Toolless Access Panels

XT Intelli-Comfort w/Mod Link Controller, SS Drain Pan, Phase Monitor, & Coil Guard Hinged Filter Door & Toolless Access Panels

XU Intelli-Comfort w/Mod Link Controller, SS Drain Pan, & Technicoat Cond Coils Hinged Filter Door & Toolless Access Panels

XV Intelli-Comfort w/Mod Link Controller, SS Drain Pan, & Technicoat Evap Coil Hinged Filter Door & Toolless Access Panels

XW Intelli-Comfort w/Mod Link Controller, SS Drain Pan, & Technicoat Evap and Cond Coils Hinged Filter Door & Toolless Access Panels

XX Intelli-Comfort w/Mod Link Controller, SS Drain Pan, Phase Monitor, Coil Guard, & Technicoat Evap and Cond Coils Hinged Filter Door &

Toolless Access Panels

Hinged Filter Door & Toolless Access Cabinet

036-21508-005-A-0305

Unitary Products Group 11

FEATURES

All models are available with a wide variety of factory-

mounted options such as electric heaters, phase monitor,

convenience outlet, dirty filter switch, disconnect switch,

smoke detectors, and coil guards to make them suitable for

almost every application.

All units are self-contained and assembled on full perimeter

base rails with forklift holes on three sides and holes for over-

head rigging. Every unit is completely piped, wired, charged

and tested at the factory to simplify the field installation and to

provide years of dependable operation.

All models (including those with an economizer) are suitable

for either bottom or horizontal duct connections. For bottom

duct, remove the sheet metal panels from the supply and

return air openings through the base of the unit. For horizon-

tal duct, remove the supply and return air panels on the rear

of the unit.

All models are available with these “factory mounted” outdoor

air damper options:

• Single enthalpy economizer

• Motorized outdoor air damper

Supply air blowers are equipped with either a direct drive or a

belt drive that can be adjusted to meet the exact require-

ments of the job.

All compressors are equipped with internal pressure relief.

Every refrigerant circuit includes a liquid line filter-drier, a high

pressure switch and a suction line with a freezestat and low

pressure/loss of charge switch to protect all system compo-

nents.

• Simplicity™ Controls - Simplicity™ control boards have

standardized a number of features previously available

only as options or by utilizing additional controls.

• Low Ambient - An integrated low-ambient control

allows all units to operate in the cooling mode down

to 0ºF outdoor ambient without additional assis-

tance. Optionally, the control board can be pro-

grammed to lockout the compressors when the

outdoor air temperature is low or when free cooling

is available.

• Anti-Short Cycle Protection - To aid compressor

life, an anti-short cycle delay is incorporated into the

standard controls. Compressor reliability is further

ensured by programmable minimum run times. For

testing, the anti short cycle delay can be temporarily

overridden with the push of a button.

• Fan Delays - Fan on and fan off delays are fully pro-

grammable and are independent of one another. All

units are programmed with default values based

upon their configuration of cooling and heat.

• Safety Monitoring - The control board monitors the

high and low-pressure switches, the freezestats, the

gas valve, if applicable, and the temperature limit

switch on gas heat units. The unit control board will

alarm on ignition failures, compressor lockouts and

repeated limit switch trips.

• Nuisance Trip Protection- To prevent nuisance

trouble calls, the control board uses a “three strikes,

you’re out” philosophy. The high and low-pressure

switches and the freezestats must trip three times

within two hours before the unit control board will

lock out the compressor.

• On Board Diagnostics - Each alarm will energize a

trouble light on the thermostat, if so equipped, and

flash an alarm code on the control board LED. Each

high and low-pressure switch alarm as well as each

freezestat alarm has its own flash code. The control

board saves the five most recent alarms in memory,

and these alarms can be reviewed at any time.

Alarms and programmed values are retained

through the loss of power.

All units have long lasting powder paint cabinets with 750

hour salt spray test approval under ASTM-B117 procedures.

All models are CSA listed.

• Warranty - All models include a one-year limited parts

warranty on the complete unit. Compressors and electric

heater elements carry a five-year warranty

• Electric Heat Operation - All electric heat models are

wired for a single power source and include a bank of

nickel chromium elements mounted at the discharge of

the supply air blower to provide a high velocity and uni-

form distribution of air across the heating elements.

Every element is fully protected against excessive tem-

perature by thermal limit switches.

The power supply wiring can be routed into the control

box through a threaded pipe connection (field supplied)

in the base pan of the unit or through a knockout in the

wiring panel on the side of the unit.

• BAS Controls - York’s Sunline™ series units offer fac-

tory mounted BAS controls such as SImplicity™

INTELLI-Comfort™, Novar, Honeywell, Johnson, and

CPC.

036-21508-005-A-0305

12 Unitary Products Group

FACTORY-INSTALLED OPTIONS

• SINGLE INPUT ELECTRONIC ENTHALPY ECONO-

MIZERS - Includes a slide-in / plug-in damper assembly

with fully modulating spring-return motor actuator capa-

ble of introducing up to 100% outdoor air with nominal

1% leakage type dampers.

The enthalpy system contains one sensor that monitors

the outdoor air and determines when the air is cool

enough and dry enough to provide free cooling.

The rainhood is painted to match the basic unit and must

be field-assembled before installing.

• MOTORIZED OUTDOOR AIR INTAKE DAMPER -

Includes a slide-in / plug-in damper assembly with a 2-

position, spring return motor actuator which opens to a

pre-set position whenever the supply air blower is oper-

ating and will drive fully closed when the blower unit

shuts down.

The rain hood is painted to match the basic unit and

must be field assembled before installing.

• PHENOLIC COATED EVAPORATOR AND CON-

DENSER COILS - Special coating process that utilizes

Technicoat 10-1

processes. Coating is applied by total

immersion of the complete coil for maximum protection.

• ELECTRIC HEATERS - Wired for single point power

supply. These nickel chromium heater elements are pro-

vided with limit and automatic reset capability to prevent

operation at excessive temperatures.

• FILTER OPTIONS - Standard units are shipped with 1”

throw-away filters installed. 2” pleated filters are offered

as a factory installed option.

• CONVENIENCE OUTLET - This 110 volt outlet can be

“powered” by the unit with a stepdown transformer or the

unit may be ordered with a “non-powered” convenience

outlet that can be wired in the field.

• DISCONNECT SWITCH - For heat pump units with elec-

tric heat, an HACR breaker sized to the unit is provided.

For heat pump units without electric heat, a switch sized

to the largest electric heat available for the particular unit

is provided. Factory-installed option only.

• BAS - Building Automation System Controls

Simplicity™ INTELLI-Comfort™ CONTROL - The

York® Simplicity™ INTELLI-Comfort™ control is factory

installed. It includes a supply air sensor, a return air sen-

sor, and an outside air sensor. There are provisions for a

field installed dirty filter indicator switch, an air-proving

switch, an Outside Air Humidity sensor, a Return Air

Humidity sensor, an Inside IAQ sensor, and an Outside

FIGURE 1 - UNIT CUTAWAY

036-21508-005-A-0305

Unitary Products Group 13

Air IAQ sensor. Construction mode operation, 365-day

real time clock with 7 day programming plus holiday

scheduling is built-in. Two different modes of demand

ventilation are achieved through the INTELLI-Com-

fort™using CO2 sensors. It uses an inside CO2 sensor

to perform Demand Ventilation. It can also use an Out-

side CO2 sensor to perform Differential Demand Ventila-

tion. It uses a Patented Comfort Ventilation algorithm to

provide comfortable ventilation air temperature. The pat-

ented economizer-loading algorithm will protect the

equipment when harsh operating conditions exist.

Humidity in the occupied space or return duct can be

monitored and controlled via humidity sensors and the

on-board connection for hot gas re-heat system. It uses

the INTELLI-Start™ algorithm to maximize energy sav-

ings by recovering the building from the Unoccupied Set-

points to the Occupied Setpoints just in time for the

Occupied Time Period to begin. The Simplicity™

INTELLI-Comfort™ balances space temperature, venti-

lation air temperature, CO2 and humidity for ultimate

comfort.

• Simplicity™ INTELLI-Comfort™ with MOD LINK CON-

TROL - The York® Simplicity™ INTELLI-Comfort™ with

Mod Link control is factory installed. It includes all the

features of the INTELLI-Comfort™ control with an addi-

tional control to translate communications from MOD-

BUS to the BACnet MSTP protocol.

• Novar® BAS CONTROL - The Novar® ETC-3 building

automation system controller is factory installed.

Includes supply air sensor, return air sensor, dirty filter

indicator switch, and air proving switch.

• JOHNSON CONTROLS BAS CONTROL - The Johnson

Control YK-UNT-1126 building automation system con-

troller is factory installed. Includes supply air sensor,

return air sensor, dirty filter indicator switch, and air prov-

ing switch.

• CPC BAS CONTROL - The Computer Process Controls

Model 810-3060 ARTC Advanced Rooftop building auto-

mation system controller is factory installed. Includes

supply air sensor, return air sensor, dirty filter indicator

switch and air proving switch.

• HONEYWELL BAS CONTROL - The Honeywell

W7750C building automation system controller is factory

installed. Includes air supply sensor, return air sensor,

dirty filter indicator switch, and air proving switch.

• SMOKE DETECTORS - (supply air & return air) The

smoke detectors stop operation of the unit by interrupting

power to the control board if smoke is detected within the

air compartment.

• STAINLESS STEEL DRAIN PAN - An optional rust-

proof stainless steel drain pan is available to provide

years of trouble-free operation in corrosive environ-

ments.

• BOTTOM DRAIN CONNECTION - An optional bottom

drain connection is available for inside the curb connec-

tions for applications in cold environments to reduce

freezing drain lines.

• COIL GUARD - Customers can purchase a coil guard kit

to protect the condenser coil from damage. This is not a

hail guard kit.

• PHASE MONITORS - Designed to prevent unit damage.

The phase monitor will shut the unit down in an out-of-

phase condition.

• DIRTY FILTER SWITCH - This kit includes a differential

pressure switch that energizes the fault light on the unit

thermostat, indicating that there is an abnormally high

pressure drop across the filters. Factory installed option

or field installed accessory.

• HINGED FILTER DOOR/“TOOLLESS” BLOWER AND

ACCESS PANELS (not hinged) - This option allows for

easy access and maintenance.

NOTE:Knobs are shipped inside the unit to prevent ship-

ping damage. These must be field installed for

tool-less operation.

FIELD-INSTALLED ACCESSORIES

• SINGLE INPUT ELECTRONIC ENTHALPY ECONO-

MIZERS - Includes a slide-in / plug-in damper assembly

with fully modulating spring-return motor actuator capa-

ble of introducing up to 100% outdoor air with nominal

1% leakage type dampers.

The enthalpy system contains one sensor that monitors

the outdoor air and determines when the air is cool

enough and dry enough to provide free cooling.

The rainhood is painted to match the basic unit and must

be field-assembled before installing.

• MOTORIZED OUTDOOR AIR INTAKE DAMPER -

Includes a slide-in / plug-in damper assembly with a 2-

position, spring return motor actuator which opens to

some pre-set position whenever the supply air blower is

operating and will drive fully closed when the blower unit

shuts down.

The rain hood is painted to match the basic unit and

must be field assembled before installing.

• ELECTRIC HEATERS wired for single point power sup-

ply. These nickel chromium heater elements are pro-

vided with limit and automatic reset capability to prevent

operation at excessive temperatures.

• ROOF CURBS - Eight and fourteen-inch high roof curbs

provide a water-tight seal between the unit and the fin-

ished roof. These full perimeter curbs meet the require-

ments of the National Roofing Contractors Association

(NRCA) and are shipped knocked-down for field assem-

bly.

036-21508-005-A-0305

14 Unitary Products Group

Roof curbs are designed to fit inside the base rails of the

unit and include both a wood nailing strip and duct

hanger supports.

• POWER EXHAUST - Our single input economizer

options are available with power exhaust. Whenever the

outdoor air intake dampers are opened for free cooling,

the exhaust fan will be energized to prevent the condi-

tioned space from being over-pressurized during econo-

mizer operation.

The power exhaust option can only be used on bot-

tom duct configurations.

• BAROMETRIC RELIEF DAMPER - This damper acces-

sory can be used to relieve internal building air pressure

on units with an economizer without power exhaust. This

accessory includes a rain hood, a bird screen and a fully

assembled damper. With bottom duct connections, the

damper should be mounted over the opening in the

return air panel. With horizontal ductwork, the accessory

should be mounted on the return air duct.

• ENTHALPY ACCESSORY CONTROL KIT - This kit

contains the required components to convert a single

enthalpy economizer to dual enthalpy.

• BURGLAR BARS - Mount in the supply and return

openings to prevent entry into the duct work.

• CO

SENSOR - Senses CO

levels and automatically

overrides the economizer when levels rise above the

present limits.

• COIL GUARD - Customers can purchase a coil guard kit

to protect the condenser coil from damage. This is not a

hail guard kit.

• HAIL GUARD - Hail guard is available to protect the unit

from hail damage. This is a sloped hood that fits above

the coil.

036-21508-005-A-0305

Unitary Products Group 15

TABLE 1: SOUND POWER RATING

UNIT

SIZE

CFM

ESP BLOWER

SOUND POWER (db 10

-12

Watts)

Octave Band Centerline Frequency (Hz)

SWL

dB(A)

10Ft.

IWG SPEED KW 63 125 250 500 1,000 2,000 4,000 8,000

036 1,200 0.6 LOW 0.60 84 84 74 67 69 62 57 52 74 41

048 1,600 0.55 HIGH 0.80 85 85 75 68 70 63 58 53 75 42

060 2,000 0.45 HIGH 1.00 86 86 76 69 71 64 59 54 76 43

1. These values have been accessed using a model of sound propagation from a point source into the hemispheric\free field. The

dBA values provided are to be used for reference only. Calculation of dBA values cover matters of system design and the fan

manufacture has no way of knowing the details of each system. This constitutes and expectation to any specification or guaran-

tee requiring a dBA value or sound data in any other form than sound power level ratings.

2. At a distance of 10 feet from the blower.

TABLE 2: CAPACITY RATINGS

MBH SEER EER MBH COP MBH COP

036 39 10.00 9.20 8.6 7.3 39.0 3.0 23.0 2.1

048 48 10.20 9.25 8.6 6.7 48.0 3.0 26.4 2.0

060 59 10.00 9.20 8.4 7.0 59.0 3.0 36.0 2.1

HSPF

UNIT SIZE

(MBH)

ARI RATINGS

HEATING CAPACITY

47°F 17°F

COOLING PERFORMANCE

SOUND

RATING

bels

NOTES:

1. Certified in accordance with the Unitary Small Equipment certification program, which is based on ARI Standard 210/240.

2. Rated in accordance with ARI Standard 270.

SEER = Seasonal Energy Efficiency Ratio - the total cooling output in BTU’s during a normal annual usage period for cooling divided by the total electric power input

in watt-hoursduring the same period.

EER = Energy Efficiency Ratio-the cooling capacity in BTU’s per hour (BTUH) divided by the power input in watts at any given set of rating conditions, expressed in

BTUH per watt (BTUH/watt).

COP = Coefficient of Performance - the total heating capacity provided by the refrigeration system, including circulating fan heat but excluding supplementary resistance

(BTU’s per hour) divided by the total electric input (watts) x 3.412.

HSPF = Heating Seasonal Performance Factor - the total heating output during a normal annual usage period for heating divided by the total electric power input during

the same period. (Based on Region IV minimum design heating requirement).

036-21508-005-A-0305

16 Unitary Products Group

TABLE 3: BQ036 COOLING CAPACITIES (3 TON)

CFM WB °F 86 83 80 77 74 71 68 86 83 80 77 74 71 68

72 51 3.4 37 32 28 24 19 - - 47 3.7 34 29 25 22 17 - -

67 46 3.4 40 40 36 31 26 21 16 44 3.7 38 38 34 29 24 20 15

62 42 3.3 42 42 41 39 34 29 24 38 3.6 38 38 37 35 30 26 21

57 42 3.3 42 42 42 40 35 30 25 37 3.6 37 37 37 35 30 26 22

72 49 3.4 35 30 26 22 18 - - 46 3.7 32 28 24 20 16 - -

67 45 3.4 39 37 33 29 24 20 15 42 3.7 36 34 30 27 22 18 14

62 41 3.3 41 41 40 37 32 28 24 37 3.6 37 37 36 33 28 25 21

57 41 3.3 41 41 41 38 34 29 25 36 3.6 36 36 36 33 29 25 21

72 48 3.4 33 29 24 20 16 - - 45 3.7 30 27 22 18 15 - -

67 44 3.3 39 36 32 28 23 20 15 41 3.7 36 33 29 26 21 18 13

62 40 3.3 40 39 38 34 30 26 22 36 3.6 36 35 34 30 27 23 19

57 40 3.3 40 40 39 35 31 27 23 36 3.5 36 36 35 31 27 24 20

72 47 3.4 31 27 24 20 16 - - 44 3.7 29 25 22 18 14 - -

67 41 3.3 36 32 29 25 22 18 14 39 3.6 34 30 27 23 20 17 13

62 38 3.3 38 37 36 32 29 25 21 35 3.6 35 34 33 29 26 23 19

57 37 3.3 37 37 36 33 30 26 22 35 3.5 35 35 34 31 28 24 20

72 45 3.3 28 25 22 19 16 - - 42 3.6 26 23 20 17 14 - -

67 41 3.3 34 30 27 24 20 17 14 38 3.6 31 27 25 22 18 15 12

62 36 3.3 36 35 33 30 27 24 21 34 3.5 34 33 31 28 25 22 19

57 36 3.3 36 36 34 31 28 25 22 33 3.5 33 33 31 28 25 22 20

72 45 3.3 26 24 20 17 15 - - 40 3.6 23 21 17 15 13 - -

67 39 3.3 31 28 25 22 19 17 14 35 3.6 27 25 22 19 17 15 12

62 35 3.2 35 34 32 29 25 23 20 32 3.5 32 30 28 25 22 20 17

57 35 3.2 35 35 32 30 26 24 21 31 3.5 31 31 28 26 23 21 18

CFM WB °F 86 83 80 77 74 71 68 86 83 80 77 74 71 68

72 44 4.0 31 27 24 20 16 - - 42 4.2 30 26 23 19 15 - -

67 40 4.0 34 34 31 26 22 18 13 36 4.1 31 31 28 24 20 16 12

62 35 3.9 35 35 34 32 28 24 20 34 4.1 34 34 33 31 27 23 19

57 35 3.9 35 35 35 33 29 25 20 33 4.1 33 33 33 31 27 23 19

72 43 4.0 30 26 22 19 15 - - 41 4.2 29 25 21 18 15 - -

67 38 4.0 32 31 27 24 20 16 12 35 4.1 30 28 25 22 18 15 11

62 34 3.9 34 34 33 30 26 23 19 33 4.1 33 33 32 29 25 22 19

57 34 3.9 34 34 34 31 28 24 20 32 4.1 32 32 32 29 26 22 19

72 42 4.0 28 25 21 17 14 - - 39 4.2 26 23 19 16 13 - -

67 37 4.0 32 30 26 23 19 16 12 34 4.1 30 27 24 21 17 15 11

62 33 3.9 33 32 31 28 24 21 18 32 4.1 32 31 30 27 24 20 17

57 32 3.8 32 32 31 28 24 21 18 32 4.0 32 32 31 28 24 21 18

72 41 4.0 27 23 20 17 13 - - 37 4.2 24 21 18 15 12 - -

67 35 3.9 30 27 24 21 18 15 11 32 4.1 28 24 22 19 17 14 10

62 32 3.9 32 31 30 26 24 21 17 30 4.1 30 29 28 25 22 19 16

57 31 3.8 31 31 31 27 25 21 18 29 4.0 29 29 29 25 23 20 17

72 40 3.9 24 22 19 16 14 - - 35 4.1 21 19 17 14 12 - -

67 34 3.9 28 24 22 19 16 14 11 31 4.0 25 22 20 18 15 12 10

62 30 3.8 30 29 27 25 22 20 17 29 4.0 29 28 26 24 21 19 16

57 30 3.8 30 30 28 25 23 20 18 28 4.0 28 28 26 24 21 19 17

72 38 3.9 21 20 16 14 12 - - 34 4.1 19 18 15 12 11 - -

67 32 3.9 25 22 20 18 15 13 11 29 4.0 23 20 18 16 14 12 10

62 29 3.8 29 27 25 23 20 18 16 27 4.0 27 25 24 21 18 17 15

57 29 3.8 29 29 26 24 21 19 17 26 4.0 26 26 23 22 19 17 15

NOMINAL RATING

900

TOTAL

CAP.

MBH

POWER

INPUT

TOTAL

CAP.

MBH

TOTAL

CAP.

MBH

POWER

INPUT

TOTAL

CAP.

MBH

1750

1050

POWER

INPUT

ENTERING DRY BULB, °F ENTERING DRY BULB, °F

AIR ON

EVAPORATOR

COIL

TEMPERATURE OF AIR ON CONDENSER COIL

105°F 115°F

1200

SENSIBLE CAPACITY

1400

1200

SENSIBLE CAPACITY

1400

SENSIBLE CAPACITY

1500

900

1050

1500

ENTERING DRY BULB, °F

AIR ON

EVAPORATOR

COIL

TEMPERATURE OF AIR ON CONDENSER COIL

85°F

POWER

INPUT

95°F

SENSIBLE CAPACITY

1750

ENTERING DRY BULB, °F

1. These capacities are gross ratings. For net capacity, determine the kW of the supply air blower motor from the SUPPLY AIR BLOWER PERFORMANCE

Table, multiply this value by 3.415 MBH/kW to determine the motor heat, and deduct this heat from the gross capacity of the unit.

2. These ratings include the compressor and the condenser fan motors but not the supply air blower motor. The total condenser fan motor power input

is 0.35kW. Refer to the SUPPLY AIR BLOWER PERFORMANCE Table for the kW of the supply air blower motor.

036-21508-005-A-0305

Unitary Products Group 17

TABLE 4: BQ048 COOLING CAPACITIES (4 TON)

CFM WB °F 86 83 80 77 74 71 68 86 83 80 77 74 71 68

72 56 4.1 42 36 31 26 - - - 53 4.5 40 35 29 24 - - -

67 53 4.0 48 47 41 36 30 25 - 51 4.4 46 45 41 35 30 24 -

62 49 4.0 49 49 48 44 38 33 28 46 4.3 46 46 45 41 35 30 24

57 49 3.9 49 49 49 44 38 33 28 46 4.3 46 46 46 41 35 30 24

72 55 4.0 40 35 30 25 - - - 53 4.4 38 33 28 23 - - -

67 52 4.0 47 44 39 34 29 24 - 51 4.4 44 44 39 34 29 24 -

62 48 3.9 48 48 47 43 38 33 28 47 4.3 47 47 45 40 36 31 26

57 48 3.9 48 48 48 43 38 33 28 45 4.2 45 45 45 40 35 30 25

72 53 4.0 37 33 28 24 - - - 52 4.4 36 32 27 23 - - -

67 51 4.0 46 42 37 33 28 24 - 50 4.3 44 43 38 34 29 25 -

62 47 3.9 47 47 46 41 37 32 28 45 4.2 45 45 44 40 36 31 27

57 47 3.9 47 47 47 42 38 33 29 44 4.1 44 44 44 40 36 31 27

72 52 4.0 34 30 26 22 - - - 49 4.3 33 29 25 21 - - -

67 49 3.9 42 38 34 30 26 22 - 47 4.2 42 38 34 30 26 22 -

62 46 3.8 46 45 42 38 34 30 26 43 4.1 43 42 40 36 32 28 24

57 45 3.8 45 45 43 39 35 31 27 42 4.1 42 42 40 36 32 28 24

72 50 3.9 31 27 24 20 - - - 47 4.2 29 25 22 18 - - -

67 47 3.9 38 35 31 28 24 21 - 45 4.2 37 34 30 27 23 20 -

62 44 3.8 44 42 39 35 32 28 25 40 4.1 40 39 36 32 29 25 22

57 44 3.7 44 43 39 36 32 29 25 40 4.0 40 39 36 32 29 25 22

CFM WB °F 86 83 80 77 74 71 68 86 83 80 77 74 71 68

72 51 4.9 40 35 29 24 - - - 49 5.2 39 34 29 23 - - -

67 46 4.7 42 42 39 34 28 23 - 41 5.0 40 40 37 32 26 21 -

62 43 4.6 43 43 42 37 32 27 21 40 4.9 40 40 39 34 29 23 18

57 43 4.6 43 43 43 38 32 28 22 40 4.8 40 40 40 34 30 24 19

72 50 4.8 38 33 28 23 - - - 47 5.1 37 32 27 22 - - -

67 45 4.7 41 41 37 32 27 22 - 40 4.9 37 36 35 30 25 20 -

62 42 4.6 42 42 41 37 32 27 22 39 4.8 39 39 37 34 29 24 19

57 42 4.5 42 42 42 37 33 27 23 38 4.7 38 38 38 33 30 25 20

72 49 4.8 35 31 26 22 - - - 46 5.1 34 29 25 20 - - -

67 44 4.6 40 40 35 31 26 22 - 39 4.9 36 36 32 28 23 19 -

62 41 4.5 41 41 40 35 32 27 23 37 4.7 37 37 36 33 28 24 19

57 41 4.4 41 41 41 36 32 28 23 37 4.7 37 37 37 34 28 25 20

72 47 4.7 32 28 24 20 - - - 44 5.0 31 27 23 19 - - -

67 42 4.5 38 36 32 28 24 20 - 37 4.8 36 34 30 26 21 17 -

62 39 4.4 39 38 37 33 28 25 20 36 4.7 36 35 34 30 26 22 18

57 39 4.4 39 39 37 33 29 25 21 36 4.6 36 36 34 31 26 23 19

72 44 4.6 28 25 21 18 - - - 42 4.9 28 24 21 17 - - -

67 40 4.5 36 32 29 25 22 18 - 36 4.7 34 31 27 24 20 17 -

62 38 4.4 38 36 34 29 27 22 20 35 4.6 35 34 30 28 24 20 17

57 37 4.3 37 37 34 30 27 23 20 35 4.6 35 35 31 29 24 21 18

NOMINAL RATING

1200

TOTAL

CAP.

MBH

POWER

INPUT

TOTAL

CAP.

MBH

TOTAL

CAP.

MBH

POWER

INPUT

TOTAL

CAP.

MBH

2000

1800

1600

1400

POWER

INPUT

ENTERING DRY BULB, °F ENTERING DRY BULB, °F

AIR ON

EVAPORATOR

COIL

TEMPERATURE OF AIR ON CONDENSER COIL

105°F 115°F

SENSIBLE CAPACITY

ENTERING DRY BULB, °F

AIR ON

EVAPORATOR

COIL

TEMPERATURE OF AIR ON CONDENSER COIL

1200

1400

85°F

POWER

INPUT

95°F

SENSIBLE CAPACITY

ENTERING DRY BULB, °F

2000

1800

1600

1. These capacities are gross ratings. For net capacity, determine the kW of the supply air blower motor from the SUPPLY AIR BLOWER PERFORMANCE

Table, multiply this value by 3.415 MBH/kW to determine the motor heat, and deduct this heat from the gross capacity of the unit.

2. These ratings include the compressor and the condenser fan motors but not the supply air blower motor. The total condenser fan motor power input

is 0.35kW. Refer to the SUPPLY AIR BLOWER PERFORMANCE Table for the kW of the supply air blower motor.

036-21508-005-A-0305

18 Unitary Products Group

TABLE 5: BQ060 COOLING CAPACITIES (5 TON)

CFM WB °F 86 83 80 77 74 71 68 86 83 80 77 74 71 68

72 68 5.7 51 44 38 31 - - - 67 6.0 51 45 38 31 - - -

67 65 5.6 58 56 50 43 37 30 - 64 5.9 56 56 50 43 37 30 -

62 61 5.6 61 61 59 53 46 39 33 59 5.9 59 59 57 50 44 38 31

57 60 5.5 60 60 59 53 47 40 33 58 5.8 58 58 57 51 44 39 32

72 67 5.6 48 42 36 30 - - - 66 5.9 48 42 36 30 - - -

67 64 5.6 57 54 48 42 36 30 - 63 5.9 55 54 48 42 35 29 -

62 60 5.5 60 60 57 51 45 39 33 57 5.8 57 57 55 50 44 38 32

57 59 5.5 59 59 58 52 46 40 34 57 5.8 57 57 56 50 45 39 33

72 66 5.6 45 40 34 29 - - - 65 5.9 45 40 34 29 - - -

67 63 5.5 56 51 45 40 35 29 - 61 5.9 55 51 45 40 34 29 -

62 59 5.4 59 59 55 50 44 39 33 56 5.8 56 56 54 49 44 38 33

57 58 5.4 58 58 57 52 46 41 36 56 5.7 56 56 55 50 44 39 34

72 64 5.5 42 37 32 27 - - - 62 5.9 43 38 33 28 - - -

67 61 5.5 52 47 42 37 33 28 - 59 5.8 53 48 44 39 34 29 -

62 57 5.4 57 56 51 46 41 37 32 54 5.7 54 54 52 48 43 38 33

57 57 5.4 57 57 53 48 44 39 34 54 5.7 54 54 53 49 43 39 34

72 62 5.5 38 34 30 25 - - - 60 5.8 41 36 32 28 - - -

67 59 5.5 48 43 39 35 31 26 - 57 5.8 51 46 42 38 34 29 -

62 55 5.4 55 52 47 43 39 35 30 52 5.7 52 52 50 46 42 38 34

57 55 5.3 55 54 49 45 41 37 32 52 5.6 52 52 51 47 42 39 35

CFM WB °F 86 83 80 77 74 71 68 86 83 80 77 74 71 68

72 64 6.0 51 44 38 31 - - - 60 6.9 50 43 37 30 - - -

67 59 5.9 51 51 49 42 36 29 - 54 6.6 54 53 47 41 34 27 -

62 54 5.9 54 54 51 46 40 33 26 49 6.5 49 49 48 42 35 28 22

57 54 5.8 54 54 52 46 41 33 26 49 6.5 49 49 49 43 35 28 23

72 63 5.9 48 42 36 30 - - - 60 6.8 47 41 35 29 - - -

67 58 5.9 51 51 46 40 34 28 - 54 6.6 47 47 45 39 32 26 -

62 53 5.8 53 53 52 46 40 34 28 49 6.5 49 49 47 42 36 30 24

57 53 5.8 53 53 52 46 41 35 27 49 6.4 49 49 48 43 37 31 25

72 62 5.9 45 39 34 28 - - - 59 6.8 44 38 33 27 - - -

67 57 5.9 51 49 44 38 33 27 - 53 6.5 45 45 42 36 31 26 -

62 52 5.8 52 52 51 46 40 35 30 48 6.4 48 48 46 42 36 31 25

57 52 5.7 52 52 51 46 40 36 31 47 6.4 47 47 46 43 36 32 25

72 60 5.9 41 37 32 27 - - - 56 6.7 40 35 30 25 - - -

67 55 5.8 48 46 41 36 31 26 - 51 6.5 43 43 38 33 29 24 -

62 50 5.7 50 50 48 43 39 34 29 46 6.4 46 46 43 38 33 28 24

57 50 5.7 50 50 48 43 39 34 30 45 6.3 45 45 43 38 33 28 25

72 57 5.8 38 34 30 25 - - - 53 6.6 36 31 27 23 - - -

67 53 5.8 47 43 38 34 30 26 - 48 6.4 41 39 35 30 26 22 -

62 48 5.7 48 48 45 41 37 32 28 44 6.3 44 44 39 35 30 26 22

57 48 5.6 48 48 45 41 38 32 28 43 6.2 43 43 40 36 30 26 23

NOMINAL RATING

1500

TOTAL

CAP.

MBH

POWER

INPUT

TOTAL

CAP.

MBH

TOTAL

CAP.

MBH

POWER

INPUT

TOTAL

CAP.

MBH

2500

2250

2000

1750

POWER

INPUT

ENTERING DRY BULB, °F ENTERING DRY BULB, °F

AIR ON

EVAPORATOR

COIL

TEMPERATURE OF AIR ON CONDENSER COIL

105°F 115°F

SENSIBLE CAPACITY

ENTERING DRY BULB, °F

AIR ON

EVAPORATOR

COIL

TEMPERATURE OF AIR ON CONDENSER COIL

1500

1750

85°F

POWER

INPUT

95°F

SENSIBLE CAPACITY

ENTERING DRY BULB, °F

2500

2250

2000

1. These capacities are gross ratings. For net capacity, determine the kW of the supply air blower motor from the SUPPLY AIR BLOWER PERFORMANCE

Table, multiply this value by 3.415 MBH/kW to determine the motor heat, and deduct this heat from the gross capacity of the unit.

2. These ratings include the compressor and the condenser fan motors but not the supply air blower motor. The total condenser fan motor power input

is 0.35kW. Refer to the SUPPLY AIR BLOWER PERFORMANCE Table for the kW of the supply air blower motor.

036-21508-005-A-0305

Unitary Products Group 19

TABLE 6: BQ HEATING CAPACITIES

CAP

& KW-100 102030405060

MBH 13.1 16.4 23.5 29.1 30.2 41.7 47 48.2

KW 2.9 3 3.2 3.3 3.5 3.7 3.8 3.9

MBH 11.9 15 21.5 26.7 27.7 38.2 43.1 44.1

KW 3 3.1 3.4 3.4 3.6 3.8 3.9 4.1

MBH 10.9 13.6 19.6 24.3 25.2 34.8 39.3 40.2

KW 3.1 3.2 3.4 3.5 3.8 3.9 4.1 4.2

MBH 12.4 15.5 22.5 27.7 28.7 39.6 44.7 45.8

KW 2.7 2.9 3 3.1 3.3 3.5 3.6 3.7

MBH 11.4 14.1 20.3 25.2 26.1 36.1 40.7 41.6

KW 2.9 3 3.2 3.3 3.5 3.7 3.8 3.9

MBH 10.4 13.1 18 23.2 24.2 33.3 37.6 38.5

KW 3 3.1 3.2 3.4 3.6 3.8 3.9 4

MBH 11.8 14.8 21.3 26.5 27.5 37.8 42.7 43.7

KW 2.7 2.8 3 3.1 3.3 3.4 3.5 3.6

MBH 10.8 13.5 19.4 24 24.9 34.4 38.8 39.7

KW 2.9 3 3.1 3.3 3.4 3.6 3.7 3.8

MBH 9.9 12.4 17.8 22 22.9 31.5 35.6 36.5

KW 2.9 3.1 3.2 3.4 3.5 3.7 3.8 3.9

MBH 11.2 14.1 20.3 25.2 26.1 35.9 40.6 41.6

KW 2.6 2.7 2.9 3 3.3 3.3 3.5 3.5

MBH 10.2 12.8 18.5 22.8 23.6 32.7 36.9 37.8

KW 2.8 2.9 3 3.2 3.3 3.5 3.6 3.7

MBH 9.3 11.7 16.7 20.7 21.5 29.8 33.6 34.4

KW 2.8 3 3.1 3.3 3.4 3.6 3.7 3.8

MBH 12.3 17.3 22.5 28.2 36.3 44.5 53.8 61.6

KW 3.4 3.5 3.6 3.6 3.8 4 4.6 5.2

MBH 11.8 16.6 21.6 27.1 34.9 42.8 51.7 59.2

KW 3.5 3.6 3.8 3.8 4 4.2 4.8 5.4

MBH 10.9 15.3 19.9 24.9 32.1 39.4 47.6 54.5

KW 3.6 3.7 4 4 4.1 4.4 5 5.7

MBH 12.1 17 22 27.7 34.5 42.3 51.2 58.6

KW 3.3 3.4 3.5 3.6 3.6 3.8 4.4 5

MBH 11.6 16.3 21.2 26.6 33.2 40.7 49.2 56.3

KW 3.4 3.5 3.6 3.7 3.8 4 4.6 5.2

MBH 10.7 15 19.5 24.5 30.5 37.4 45.3 51.8

KW 3.5 3.6 3.8 3.9 4 4.2 4.8 5.4

MBH 10.9 15.3 19.9 24.9 31.7 38.9 47 53.8

KW 3.1 3.2 3.3 3.4 3.5 3.7 4.2 4.8

MBH 10.5 14.7 19.1 24 30.5 37.4 45.2 51.7

KW 3.2 3.3 3.4 3.5 3.6 3.8 4.4 5

MBH 9.6 13.5 17.6 22 28.1 34.4 41.6 47.6

KW 3.3 3.4 3.5 3.6 3.8 4 4.6 5.2

MBH 18.2 24.7 31.1 38.4 45.6 55.4 64.7 75.6

KW 5 5.1 5.2 5.3 5.3 5.6 5.9 6.5

MBH 17.5 23.7 29.9 37 43.9 53.3 62.2 72.7

KW 5.2 5.3 5.4 5.5 5.6 5.9 6.2 6.8

MBH 16.1 21.8 27.5 34 40.4 49 57.2 66.9

KW 5.4 5.6 5.7 5.8 5.9 6 6.5 7.2

MBH 18 24.4 30.8 38.1 45 54.7 63.9 74.7

KW 4.7 4.8 4.9 5 5.3 5.5 5.8 6.4

MBH 17.3 23.5 29.6 36.6 43.3 52.6 61.4 71.8

KW 4.9 5 5.1 5.2 5.5 5.8 6.1 6.7

MBH 15.9 21.6 27.2 33.7 39.8 48.4 56.5 66.1

KW 5.1 5.3 5.4 5.5 5.8 6.1 6.4 7

MBH 16.2 22 27.8 34.3 41.4 50.2 58.7 68.6

KW 4.5 4.6 4.7 4.8 5 5.3 5.5 6.1

MBH 15.6 21.2 26.7 33 39.8 48.3 56.4 66

KW 4.7 4.8 4.9 5 5.2 5.5 5.8 6.4

MBH 14.4 19.5 24.6 30.4 36.6 44.5 51.9 60.7

KW 4.9 5 5.1 5.2 5.5 5.8 6.1 6.7

1750

1400

1500

2000

2500

1200

1600

OUTDOOR AIR TEMPERATURE, °F (72% RH)

CFM RET. AIR °FModel Tonnage

2000

1050

1200

036-21508-005-A-0305

20 Unitary Products Group

TABLE 7: SUPPLY AIR BLOWER PERFORMANCE (3 TON BELT DRIVE) - SIDE DUCT APPLICATION

RPM WATTS RPM WATTS RPM WATTS RPM WATTS RPM WATTS RPM WATTS RPM WATTS

2000 843 860 880 925 919 1005 956 1065 993 1145 1030 1195 1067 1235

1900 817 775 854 850 893 920 930 995 970 1065 1008 1125 1046 1170

1800 790 700 828 760 867 840 906 905 944 980 985 1040 1025 1100

1700 - - 802 670 840 745 881 815 920 900 961 970 1001 1030

1600 ----818665858740898820940890980950

1500 ------842695882755922835962895

1400 ------833650867705904765942820

1300 --------858665893725932785

1200 --------847640880680916730

RPM WATTS RPM WATTS RPM WATTS RPM WATTS RPM WATTS RPM WATTS RPM WATTS

2000 1103 1270 ------------

1900 1085 1210 ------------

1800 1064 1145 1102 1180 ----------

1700 1040 1075 1081 1115 1121 1140 --------

1600 1020 1005 1060 1050 1100 1085 --------

1500 1003 945 1044 995 1086 1035 --------

1400 982 880 1024 920 1067 965 1107 1000 ------

1300 970 835 1010 870 1053 920 1099 960 ------

1200 953 780 992 815 1034 855 1080 905 ------

1, 2

AVAILABLE EXTERNAL STATIC PRESSURE-IWG

0.90 1.00 1.10 1.20 1.30 1.40 1.50

UNIT

TONNAGE

AIR

FLOW

CFM

1, 2

UNIT

TONNAGE

AIR

FLOW

CFM

0.60 0.70 0.80

AVAILABLE EXTERNAL STATIC PRESSURE-IWG

0.20 0.30 0.40 0.50

1. 230/460/575 Volts

2. For 208 Volts multiply values by 0.95.

3. Includes allowances for a wet evaporator coil, 1” filters, and the heat exchangers. Refer to STATIC RESISTANCE Table

for resistance values on applications other than gas / electric units with side duct airflows.

Page is loading ...

York BQ 036 User manual

Brand: York

Model: BQ 036

Category: Heat pumps

Type: User manual

This manual is also suitable for

Download PDF

report

York BQ 036 User manual

This manual is also suitable for

York BQ 036 User manual

Related papers

Other documents