Waeco CT-25, CT-30 Operating instructions

CT-25, CT-30

(12 V DC/230 V AC)

Thermoelektrische Kühlbox

Bedienungsanleitung. . . . . .5

Thermoelectric coolbox

Instruction Manual . . . . . . .13

Glacière thermoélectrique

Notice d’emploi . . . . . . . . .21

Nevera termoeléctrica

Instrucciones de uso . . . . .29

Frigorifero termoelettrico

portatile

Istruzioni per l’uso . . . . . . .37

Thermo-elektrische koelbox

Gebruiksaanwijzingen . . . 46

Termoelektrisk køleboks

Betjeningsanvisning. . . . . 54

Termoelektrisk kylbox

Bruksanvisning . . . . . . . . 62

Termoelektrisk kjøleboks

Bruksanvisning . . . . . . . . 70

Sähkökäyttöinen kylmälaukku

Käyttöohjeet. . . . . . . . . . . 78

D

GB

F

E

I

NL

DK

S

N

FIN

_CT-25_CT-30.book Seite 1 Freitag, 12. März 2004 7:51 07

Page is loading ...

CT-25, CT-30 Notes on using the instruction manual

13

Please read this manual carefully before starting the device. Keep it in

a safe place for future reference. If the device is resold, this instruction

manual must be handed over to the purchaser along with the device.

Contents

1 Notes on using the instruction manual. . . . . . . . . . . . . . . . . . . . . . . 13

2 Safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

3 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

4 Proper use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

5 Technical description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

6 Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

7 Cleaning and care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

8 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

9 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

10 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

1 Notes on using the instruction manual

The following symbols are used in this instruction manual:

Caution!

Safety instruction: failure to observe this instruction can cause

injury or damage the device.

Caution!

Safety instruction relating to a danger from electrical current or

voltage. Failure to observe this instruction can damage the device

and impair its function and cause injury.

Note

Supplementary information for operating the device.

➤ Action: this symbol indicates that you need to do something.

The required action is described step-by-step.

✓ This symbol indicates the result of an action.

Please observe the following safety instructions.

_CT-25_CT-30.book Seite 13 Freitag, 12. März 2004 7:51 07

Safety instructions CT-25, CT-30

14

2 Safety instructions

2.1 General safety

z Connect the device as follows:

– With the cable supplied (see fig. 3, page 3, 2) to the AC mains

– With the cable supplied to the cigarette lighter in the vehicle (see fig. 3,

page 3, 1).

z Do not pull the plug out of the cigarette lighter or the socket by the cable.

z If the cable is damaged, it must be replaced to prevent possible electrical

hazards.

z Do not operate the device if it is visibly damaged.

z This device may only be repaired by specialist personnel. Inadequate

repairs can lead to considerable hazards.

Should your device need to be repaired, please contact WAECO

customer services.

z Pull out the plug:

– Before cleaning and care

– After use

z Ensure that the ventilation slots are not covered.

z On boats: if the device is powered by the mains, ensure that the power

supply has a ground fault interrupter circuit. Lethal hazard!

z Disconnect the cooling device and other power consuming devices from

the battery before connecting the quick charging device.

z Check that the voltage specification on the type plate corresponds to that

of the energy supply.

z The cooling device is not suitable for transporting caustic materials or

materials containing solvents.

Electronic devices are not toys!

Always keep and use the device out of the reach of children.

_CT-25_CT-30.book Seite 14 Freitag, 12. März 2004 7:51 07

CT-25, CT-30 Scope of delivery

15

2.2 Operating the device safely

z Before starting the device ensure that the power supply line and the plug

are dry.

z Only operate the device when you or another person can attend to it.

z Do not place the device near flames or other heat sources (heating, direct

sunlight, gas ovens etc.).

z Do not fill the inner container with ice or fluid.

z Do not immerse the device in water.

z Protect the device and the cable against heat and moisture.

z Do not touch exposed cables with your bare hands. This especially

applies to when operating the device with the AC mains: Lethal hazard!

z WAECO cannot be held liable for damage resulting from improper usage

or incorrect operation.

3 Scope of delivery

Before starting the device check if all of the parts belonging to the scope of

delivery are present.

Quantity Description

1 Cooling device

1 Mains rectifier for 230 Volt AC mains

1 Connection cable for cigarette lighter

_CT-25_CT-30.book Seite 15 Freitag, 12. März 2004 7:51 07

Proper use CT-25, CT-30

16

4 Proper use

The coolbox is suitable for cooling foodstuffs. The device is also suitable for

camping.

The device is equipped with an automatic switch function, and can be oper-

ated either on a mains voltage of 220 - 240 V

AC

or on a 12 V

DC

on-board

socket in your car (cigarette lighter), boat or caravan.

If you wish to cool medicines, please check if the cooling capacity of the

device is suitable for the medicine in question.

The handle has a locking function, which means that the lid will only open

when the handle is folded all the way back.

When opening the lid, make sure that the lugs on the side of it

audibly and completely latch into the handle, which is folded all

the way back, in order to prevent the lid from snapping shut.

5 Technical description

The coolbox is suitable for mobile use. It can cool down or keep cool products

by up to 20 °C below ambient temperature.

Its cooling system is a non-wearing and CFC-free Peltier cooling, the heat is

discharged by a fan.

5.1 Description of the device

Your coolbox consists of the following parts (see fig. 5, page 4):

No. in

fig. 5

Description

ALid

B cable compartment

(on the back of the lid)

C Vents

D Handle

EContainer

_CT-25_CT-30.book Seite 16 Freitag, 12. März 2004 7:51 07

CT-25, CT-30 Operation

17

6 Operation

Before starting your new cooling device for the first time, you

should clean it inside and outside with a damp cloth for hygienic

reasons (please also refer to the “Cleaning and care” chapter on

page 18).

6.1 Energy saving tips

z Choose a well ventialated installation location which is protected against

direct sunlight.

z Allow food to cool down first before placing it in the device.

z Do not open the cooling device more often than necessary.

z Do not leave the lid or door open for longer than necessary.

6.2 Using the cooler

➤ Place the coolbox on a firm base.

➤ Connect the coolbox

– With the cable supplied (see fig. 3, page 3, 2) to an AC mains power

socket or

– Using the connection cable supplied to the cigarette lighter in your

vehicle (see fig. 3, page 3, 1).

Close the coolbox by pushing down the lid and turning the handle

forward. After a short time, you can check the inside of the lid to

see whether the coolbox is working properly.

✓ After a certain period of time, the temperature inside the container will

cool down by up to 20 °C.

Ensure that the objects placed in the cool box are suitable for cool-

ing/warming to the selected temperature.

➤ If you wish to switch off the device, pull out the connecting cable.

_CT-25_CT-30.book Seite 17 Freitag, 12. März 2004 7:51 07

Cleaning and care CT-25, CT-30

18

7 Cleaning and care

Caution!

Before cleaning the coolbox, pull the cable out of the socket or the

cigarette lighter.

Caution!

Do not clean the coolbox under flowing water or in dish water.

Caution!

Do not use abrasive cleaning agents or hard objects during

cleaning as these can damage the coolbox.

➤ Clean the interior of the coolbox with a damp cloth from time to time.

➤ Clean the exterior of the device with a damp cloth.

8 Disposal

8.1 Disposing of packaging material

Do not simply throw the packaging material away. Please observe the

following instructions:

z Place packaging in the appropriate reycling waste bins.

z Ask your local authority for the location of the recycling unit closest to you.

8.2 Disposing of the device

If you wish to finally dispose of the coolbox, take it to the nearest recycling

centre or return it to your specialist dealer who will be happy to take it back

for a small fee.

_CT-25_CT-30.book Seite 18 Freitag, 12. März 2004 7:51 07

CT-25, CT-30 Troubleshooting

19

9 Troubleshooting

Fault Possible cause Suggested remedy

Your coolbox is not

working and the fan

wheel which can be

seen from the outside

is not turning.

There is no voltage

flowing from the cig-

arette lighter in your

vehicle.

The ignition must be switched on in

most vehicles for voltage to flow at

the cigarette lighter.

The ignition is on and

the coolbox is not

working.

Pull the plug out of the

cocket and make the

following checks.

The cigarette lighter

socket is dirty. This

results in a poor

electrical contact.

Clean the socket of the cigarette lighter

with a non-metallic brush and a solvent,

to ensure that the middle contact pin is

clean. If the plug of your coolbox

becomes very warm in the cigarette

lighter socket, either the socket must be

cleaned or the plug has not been assem-

bled correctly.

The fuse of the ciga-

rette lighter cable

has blown.

Replace the fuse (5 A) in the cigarette

lighter plug (see fig. 4, page 4, A).

The vehicle fuse has

blown.

Replace the vehicle cigarette lighter fuse

(usually 15 A). Please refer to the oper-

ating manual of your vehicle.

Your coolbox does not

cool satisfactorily and

the outer fan wheel is

not turning.

The fan motor is

defective.

This can only be repaired by an author-

ised customer services unit.

The coolbox does not

cool satisfactorily and

the outer fan wheel is

turning.

The ventilator motor

for the inner motor is

defective.

This can only be repaired by an author-

ised customer services unit.

The Peltier element

is defective.

Only for devices with

AC operating mode:

The integrated mains

adapter is defective.

This can only be repaired by an author-

ised customer services unit.

_CT-25_CT-30.book Seite 19 Freitag, 12. März 2004 7:51 07

Technical data CT-25, CT-30

20

10 Technical data

DIN ISO 9001 is applied at WAECO International.

This device is CFC-free.

This device carries the GS symbol to indicate tested and proven safety.

Versions, technical modifications and delivery options reserved.

CT-25-12/230 CT-30-12/230

Capacity: 22 litres 28 litres

Connection voltage: 12 V

DC

or 220 V

AC

- 240 V

AC

50 Hz

Power consumption: 38 W at 12 V

DC

40 W at 230 V

AC

Temperature range: max. 20 °C under ambient temperature

Weight: approx. 4.1 kg approx. 4.5 kg

Testing/certification:

_CT-25_CT-30.book Seite 20 Freitag, 12. März 2004 7:51 07

Page is loading ...

4445100082 5/2004

www.waeco.de E-Mail: [email protected]

Zentrale/Headquarters

WAECO International GmbH · D-48282 Emsdetten · Hollefeldstraße 63 · Tel. +49 2572 879-0 · Fax +49-2572 879-300

Europa/Europe

WAECO (Schweiz) AG · CH-8153 Rümlang (Zürich) · Riedackerstrasse 7a · Tel. +41 1 8187171 · Fax +41 1 8187191

WAECO Danmark A/S · DK-6640 Lunderskov · Tværvej 2 · Tel. +45 75585966 · Fax +45 75586307

WAECO Ibérica S.A. · E-08349 Cabrera de Mar (Maresme) · Camí del Mig, 106 · Tel. +34 93 7502277 · Fax +34 93 7500552

WAECO Distribution SARL · F-60230 Chambly (France) · BP 59 · Tel. +33 1 30282020 · Fax +33 1 30282010

WAECO Finland OY · FIN-00880 Helsinki · Pulttitie 17 · Tel. +358 42 4592200 · Fax +358 9 7593700

WAECO Italcold SRL · I-61015 Novafeltria · Zona Industriale Sartiano, 298/9 · Tel. +39 0541 920827 · Fax +39 0541 920237

WAECO Norge AS · N-3208 Sandefjord · Leif Weldingsvei 16 · Tel. +47 33428450 · Fax +47 33428459

WAECO Benelux B.V. · NL-4700 BL Roosendaal · Postbus 1461 · Ettenseweg 60 · Tel. +31 165 586700 · Fax +31 165 555562

WAECO Svenska AB · S-42131 Västra Frölunda (Göteborg) · Gustaf Melins gata 7 · Tel. +46 31 7341100 · Fax +46 31 7341101

WAECO UK Ltd. · UK-Broadmayne · Dorset DT2 8LY · Unit G1 · Roman Hill Business Park · Tel. +44 1305 854000 · Fax +44 1305 854288

Übersee/Overseas + Naher Osten/Middle East

WAECO Pacific Pty. Ltd. · Burleigh Heads, QLD 4220 · 21 Taree Street · Tel. +61 7 55076000 · Fax +61 7 55221003

WAECO Impex Ltd. · Hong Kong Flat 8-10, 13/F · Good Harvest Ind. Bldg. · 9 Tsun Wen Road · Tel. +852 2 4632750 · Fax +8 52 24639067

WAECO Impex Ltd. · Taipei 106, Taiwan · 2 FL-3 No. 56 Tunhua South Rd, Sec 2 · Tel. +886 2 27014090 · Fax +886 2 27060119

WAECO Middle East FZCO · Jebel Ali, Dubai · R/A 8, SD 6 · Tel. +971 4 8833858 · Fax +971 4 8833868

WAECO USA, Inc. · Clinton, CT 06413 · 8 Heritage Park Road · Tel. +1 860 6644911 · Fax +1 860 6644912

D

CH

DK

E

F

FIN

I

N

NL

S

UK

AUS

HK

ROC

UAE

USA

adresse_neu.fm Seite 2 Montag, 3. Mai 2004 4:24 16

Waeco CT-25, CT-30 Operating instructions

This manual is also suitable for

Waeco CT-25, CT-30 Operating instructions

in other languages

Related papers

Other documents