Globe Food Equipment SP30P Installation guide

Brand: Globe Food Equipment

Model: SP30P

Type: Installation guide

This manual is also suitable for

Instruction Manual for Globe Mixers

Models SP10, SP20, SP25, SP30, SP30P,

SP40, SP60, SP62P and SP80PL

Model SP20

For Service on Your Mixer:

1. Visitourwebsiteatwww.globeslicers.com

 (selecttheSupport/Partsdropdown).

2. OrcalltheGlobeservicedepartmentat937-297-7247andaskforcontact 

 informationforyourlocalservicecompany.

Model#:

Serial#:

VisitourwebsiteforinformationonadditionalproductsavailablefromGlobe.

www.globeslicers.com

Slicers, Mixers, Vegetable Cutters, Meat Choppers and Scales

Thismanualcontainsimportantsafetyinstructionswhich

mustbestrictlyfollowedwhenusingthisequipment.

- IMPORTANT SAFETY NOTICE -

ATTENTIONOWNERSANDOPERATORS................................................................................................................3

KEYCOMPONENTSOFTHEMIXER........................................................................................................................4

INSTALLATION....................................................................................................................................................... 5-6

OPERATINGINSTRUCTIONS.............................................................................................................................. 6-10

CLEANINGINSTRUCTIONS....................................................................................................................................11

IMPORTANTPOINTS...............................................................................................................................................12

RECOMMENDEDMAINTENANCE..........................................................................................................................12

CAPACITYCHART....................................................................................................................................................13

TROUBLESHOOTING........................................................................................................................................ 14-15

LIMITEDMIXERWARRANTY...................................................................................................................................16

GLOBE FOOD EQUIPMENT COMPANY

2153 DRYDEN RD.

DAYTON, OH 45439

PHONE: 937-299-5493

TOLL FREE: 800-347-5423

FAX: 937-299-4147

E-MAIL: [email protected]

WEBSITE: www.globeslicers.com

Printed in the U.S.A. 1-2010

Index

Page3

Globe’sequipmentisdesignedtoprovidesafeandproductiveprocessingoffoodproductsaslongasthe

equipmentisusedinaccordancewiththeinstructionsinthismanualandisproperlymaintained.Unlessthe

operatorisadequatelytrainedandsupervisedthereisapossibilityofseriousinjury.Ownersofthisequipment

beartheresponsibilitytomakecertainthatthisequipmentisusedproperlyandsafely,strictlyfollowallthe

instructionscontainedinthismanualandtherequirementsoflocal,stateorfederallaw.

Ownersshouldnotpermitanyonetotouchthisequipmentunlesstheyareover18yearsold,areadequately

trainedandsupervised,andhavereadandunderstoodthismanual.Ownersshouldalsoensurethatno

customers,visitorsorotherunauthorizedpersonnelcomeincontactwiththisequipment.Pleaserememberthat

Globecannotanticipateeverycircumstanceorenvironmentinwhichitsequipmentwillbeoperated.Itisthe

responsibilityoftheownerandtheoperatortoremainalerttoanyhazardsposedbythefunctionofthisequipment.

Ifyouareeveruncertainaboutaparticulartaskorthepropermethodofoperatingthisequipment,askyour

supervisor.

Thismanualcontainsanumberofprecautionstofollowtohelppromotesafeuseofthisequipment.Throughout

themanualyouwillseeadditionalwarningstohelpalertyoutopotentialhazards.

Warnings affecting your personal safety are indicated by:

Warnings related to possible damage to the equipment are indicated by:

GlobehasputseveralwarninglabelsintheEnglishlanguageonitsmixers.Frenchlabelsarealsoavailable

andcanreplacetheEnglishlabelsattheowner’sdiscretion.Ifthewarninglabelsorthismanualaremisplaced,

damaged,orillegible,orifyourequireadditionalcopies,pleasecontactyournearestrepresentativeorGlobe

directlyfortheseitemsatnocharge.

Pleaserememberthatthismanualorthewarninglabelsdonotreplacetheneedtobealert,toproperlytrainand

superviseoperators,andtousecommonsensewhenusingthisequipment.

Attention Owners and Operators

Page4

Key Components of the Mixer

SP20 FRONT VIEW

SP20 SIDE VIEW

StopButton

StartButton

AttachmentHub

PlanetaryGreaseFitting

PlanetaryShaft

BowlHandle

BowlClamp

SpeedControl

BowlGuard

BuiltinIngredientChute

Bowl

RubberFeet

Timer

AttachmentHub

Thumbscrew

BowlLiftLever

BowlGuardHandle

SplashGuard

BowlCradle

BowlSlides

PowerCord

BowlLiftWheel

(ModelsSP40and

SP60)

PowerBowlLiftControls

(ModelsSP62Pand

SP80PL)

GearOilMeter

(ModelsSP62P

andSP80PL)

Page5

Installation

UNPACKING

Unpackthemixerimmediatelyafterreceipt.Ifthemachineisfoundtobedamaged,savethepackagingmaterial

andcontactthecarrierwithinfteen(15)daysofdelivery.Immediatelycontactyoursourceoftheequipment.

You have no recourse to damage after fteen (15) days.

TO AVOID SERIOUS PERSONAL INJURY:

• ALWAYSinstallequipmentinworkareawithadequatelightandspace.

• ONLYoperatethemixeronasolid,LEVEL,non-skidsurfacethatisnonammable.

• NEVERbypass,alter,ormodifythisequipmentinanywayfromitsoriginalcondition.Doingsomaycreate 

 hazardsandwillvoidwarranty.

• NEVERoperatethemixerwithoutallwarningsattachedtoit.

• DO NOTattempttoliftthemixeralone.

INSTALLATION

1. Readthismanualthoroughlybeforeinstallationandoperation.DONOTproceedwithinstallationand 

 operationifyouhaveanyquestionsordonotunderstandanythinginthismanual.Contactyourlocal 

 representativeorGloberst.

2. Removethecorrugatedboxfromtheskidbyremovingthebandsonthebox.NOTE:TheSP62PandSP80PL

 areshippedinawoodencrate.Onlytheboltsatthebottomofthecrate(allfoursides)needtoberemoved.

3. Carefullyunboltthemixerfromtheskidusingan11/16”or3/4”wrench.

4. Selectalocationforthemixerkeepingthesepointsinmind:

 • Floororcountermustbelevel.

 • Easyaccessformaintenanceandservice.

 • Clearanceforoperatingcontrols,installingandremovingagitators,bowl,orattachments.

 • Sufcientspaceforaddingingredientsduringmixingperiods.

 • Ensurerearventilationoutletofmixerisnotblocked.

5. Useatleasttwootherpeopletotilttheunitandinstalltherubberfeet.

6. AboltdowntemplateandboltsareavailablefortheSP10,SP20,orSP25.ContactGlobeifthisisneeded.

7. Inspectthemixertoensureallpartshavebeenprovided(i.e.bowl,beater,whip,anddoughhook).TheSP62P

 onlyhasabowlanddoughhook.

8. Readtheelectricalinformationfoundonthedataplatelocatedattherearofthemachine.Theincoming

 powershouldmatchtheratingonthedataplate.

CONNECTING TO ELECTRICAL POWER

Cord Connected Units: This machine is provided with a three-prong grounding plug. The outlet that

this plug is connected to must be properly grounded. If the receptacle is not the proper grounding type

contact an electrician. Do not under any circumstances cut or remove the third ground prong from the

power cord or use any adapter plug. Never use an extension cord. Low amp supply could damage the

mixer or cause a re.

Page6

Installation

CONNECTING TO ELECTRICAL POWER cont’d.

Units Without Power Cord or Plug: Have a licensed electrician connect the unit to the power supply.

Three Phase Units: Have a licensed electrician wire the machine correctly to ensure that the planetary

shaft is rotating in the same direction as the arrow sticker located on the front of the machine. Check the

rotation of the planetary shaft prior to rst use. When standing in front of the mixer, the planetary shaft

should be moving in a clockwise direction (i.e., the planetary shaft should appear to move from right to

left). If the unit is operated backwards (counterclockwise) damage will occur to the mixer!

9. CompletethewarrantycardandmailittoGlobeorregisteronlineatwww.globeslicers.com/warranty.asp.

10. Cleanthemixerpriortousingit.Followthecleaninginstructionsonpage11.NOTE:Itisnormalforthe 

 factorytoapplyagenerousamountofgreaseinandonthemachinesbeforeinitialuse.Excessgrease 

 (brownincolor)willbeonallmetalsurfaces(e.g.topportionofbowlguard,speedcontrol,bowlclamps,bowl

 liftlever,andattachmenthubthumbscrew).Excesshigh-pressuredgrease(brownish-black)mayalsobe

 foundontheplanetaryshaftandsomedrippingsmaybefoundinthebowl.

Operating Instructions

TO AVOID SERIOUS PERSONAL INJURY:

• DO NOToperatethemixerbeforereadingtheinstructionmanualrst.

• ALWAYSdisconnectorunplugelectricalpowerbeforecleaning,servicing,or

 adjustinganypartsorattachments.

• ALWAYSkeephands,hair,andclothingawayfrommovingparts.

ABOUT THE REMOVABLE BOWL GUARD (if applicable)

Thebowlguardcanberotatedorremovedtoaccommodatetheoperator’sfunction.Theinterlockingbowlguardis

easytoremoveandreattachforeasycleaninginasinkordishwasher.

 NOTE:Whenguardisopenornotproperlyinstalled,themixerwillnotoperate.

 

 NOTE:Rotatethebowlguardclockwise(open)andcounterclockwise(closed)to

 attachagitatorstothemixer.

Opening / Rotating the Bowl Guard:

Rotatingthebowlguardclockwise(open)andcounterclockwise(closed),allowsthe

operatortoeasilyaddingredientsandproperlyremovetheagitatorandbowlfromthe

mixer.

 1.Whentheseparatedhandlesarelineduptogetherandpushedsecurelytotheright

 ofthemixer,thebowlguardisinthelockedpositionandready.(Seeg.6-1)

g.6-1

Page7

Operating Instructions

 2.Torotatethebowlguardtoitsopenposition,grasptheseparatedhandlesonthebowlguardandmovethem,

 togetherasone,clockwisetoopen/rotatethebowlguard.Toclosethebowlguard,grasptheseparated

 handlesandmovethemtogetherasone,counterclockwisetoclose/rotatethebowlguardbackintoalocked

 position.

Removing and Attaching the Bowl Guard:

NOTE:Beforeremovingorattachingthebowlguard,makesurethebowlisinthedown/

loweredpositionandtheagitatortoolisofftheshaft.



 1.Toremovethebowlguardforcleaning,pushthelowerpartoftheseparatedhandle

 out(clockwise)dividingthehandleandreleasingtheguardfromtherotationring.

 (seeg.7-1)

 2.Onceseparated,takeholdofthelowerseparatedhandleandcontinueturningthe

 guardclockwiseuntilthebowlguardreleasesfromtheringcatchonthemixer.

 (seeg.7-2)

 3.Toreattachthebowlguard,lineuptheringcatchontheleftofthemixer;lift

 guardgentlyintoplaceandrotatetheguard’slowerhandlecounterclockwise

 untilitsnapsbackintoplacewiththeupperpartofthehandle.

ATTACHING THE BOWL TO THE MIXER

NOTE:InstallthebowlBEFOREattachingtheagitators.

1. Lowerthebowlbypullingthebowlliftleverforwardanddowntoitsresting

 position.FormodelsSP40andSP60rotatethebowlliftwheel

 counterclockwiseuntilitstops.FortheSP62PandSP80PLpressthedown

 arrow(bluebutton)tolowerthebowluntilitstops.

2. Liftthebowlbythebowlhandlesand

 a. slowlypositionthelockingpin(locatedontherearofthebowl)intotheholeinthe

  middlerearofthecradle(seeg7-3).

 b. lowerthebowlontothepinslocatedoneithersideofthebowlcradle.

3. Oncethebowlispositionedonthecradle,securethebowlbypullingeachbowlclamp

 forwarduntilthebowlislockedtight(seeg7-4).

g.7-1

g.7-2

g.7-3 g.7-4

Page8

Operating Instructions

ATTACHING THE AGITATOR TO THE MIXER (i.e., Beater, Hook, Whip)

NOTE:Itiseasiertoinstalltheagitatorpriortoaddingtheingredientsintothebowl.

1. Rotatethebowlguardtotheleftsoitrestsintheopenposition(seeg8-1).

Excessiveforceusedtoopenandclosethebowlguardmaydamagethe

springlockandbowlguardmicroswitch,andwillvoidthewarranty.

2. Slidetheagitatorslowlyupwardsontotheplanetaryshaftttingtheshaftpinthroughthe

 slotintheagitator(seeg8-2).

3. Rotatetheagitatorclockwisetosecureitontotheplanetaryshaft.

MIXING INGREDIENTS

Followthecapacitychartlocatedonpage13inthismanual.

Overloadingornotfollowingthischartwilldamagethemixerandvoid

thewarranty.

Agitatorsshouldalwaysrotateinaclockwisedirectionaroundthebowl.Iftheagitatormoves

counterclockwise,contactalicensedelectricianimmediatelytoremedy

incorrectwiring.

IMPORTANT: Make sure the speed control lever is on the rst (1) speed.

1. Addtheappropriatemixingingredientsintothebowl.

2. Liftcompletelyuponthebowlliftleveruntilthebowllocksintoposition.Onthe 

 SP40andSP60rotatethebowlliftwheelclockwiseuntilthebowlisalltheway 

 upintoposition.FortheSP62PandSP80PLpresstheuparrow(bluebutton)untilthe

 bowlisupintoposition.

3. Rotatethebowlguardtotherightsoitlocksintotheclosedposition(seeg8-3).

 Aclickingsoundwillbeheard.

NOTE: Themixerwillnotstartifthebowlguardisopenorthebowlisintheloweredposition.

4. Setthetimerfortheappropriatemixingtimeorsetthemixerfornon-timedoperation.

 a. Timed Operation: Turnthetimerknobinaclockwisedirectionatleastveminutespast“0”tothedesired

  time.NOTE:Tosetthetimeforlessthanveminutesturnthetimerknobclockwisetosixthen  

  counterclockwisebacktothedesiredtime.

 b. Non-Timed Operation:Turnthetimerknobinacounterclockwisedirectiontothegreen“on”position. 

  NOTE:Heavyloadsshouldnotbemixedlongerthanfteen(15)minutesatthissettingwithoutanequal

  amountofresttimeforthemixer.Failuretoadheretotheseinstructionsmaycausethemixerto

  automaticallyshutoffduetooverloading.

g.8-2

g.8-1

g.8-3

Page9

Operating Instructions

5. Selecttheappropriatespeedsettingbyliftingorloweringthespeedcontrollever.Threexedspeedsare 

 availableforuse:rst(1),second(2),andthird(3).NOTE:TheSP62PhastwospeedsandtheSP80PLhas

 fourxedspeeds.

 GearSpeed ProductType/Ingredient

 1(low)  Heavy:mixingpizza,bread,pastaanddonutdoughs,wafe/cakebatter,mashingpotatoes

 2(medium) Medium:2ndstageofmixingfordonutdough,etc.

 3(high)  Light:whippingcream,eggwhites,meringue



 IMPORTANT: When mixing product always follow the recommended agitator and speed setting

according to the capacity chart located on page 13 of this manual.

6. Pressthegreenstartbuttonlocatedonthemiddleofthecontrolpanel.

Always STOP the mixer BEFORE changing speeds! Failure to do so may damage the

gears or other parts and WILL void the warranty!

7. Tochangethespeedwhilemixing

 a. presstheredstopbutton

 b. changethespeedbyraisingorloweringthespeedcontrollever

 c. pressthegreenstartbuttontorestartthemixer.

NOTE: TheSP62PandSP80PLwillautomaticallyshutoffifthespeedischangedwhilethemixerisinoperation.

NOTE: Themixerisequippedwithamotoroverloadprotection.Ifthemixershutsoffduringoperationreducethe

   batchsizeand

  a. SP25andsmallermodels:Pressthestopbuttonthenpresstheoverloadresetbutton.

  b. Largermodels:Waittwominutes.Pressthestopbuttonthenpressthestartbutton.

NOTE: 2ndspeedshouldneverbeusedon50%ARorlowerwiththeexceptionoftheSP60.TheSP60

  requiresa50%reductioninbatchsizetomixinspeed2with50%ARdoughs.

NOTE: Reducebatchsizeby10%ifchilledour,waterbelow70°F,ice,orhighglutenourisbeingused.

IMPORTANT: Forheavierloads,themixershouldnotrunlongerthanfteenminuteswithoutpausingforacool

downperiodofatleastfteenminutesormorebeforeresumingmixing.Forlighterloadsthemixershouldnotrun

longerthanthirtyminuteswithoutpausingforacooldownperiodofatleastthirtyminutesormorebeforeresuming

mixing.

8. Whentheingredientshavebeenthoroughlymixed,presstheredstopbuttontostopthemixer.

 NOTE:Ifthetimerwasusedthemixerwillautomaticallystopwhenthetimehasexpired.

9. Lowerthebowlbypullingthebowlliftleverforwardanddowntoitsrestingposition.FormodelsSP40and 

 SP60,rotatethebowlliftwheelcounterclockwiseuntilitstops.FormodelsSP62PandSP80PLpressthe

 downarrow(bluebutton)untilthebowlstops.

10. Rotatethebowlguardtotheleftsoitisintheopenposition.

11. Removetheagitatorfromtheplanetaryshaftbyliftingitupwardsthenrotatingitcounterclockwiseuntilitis 

 unlocked.Lowertheagitatorandremovefromplanetaryshaft.

Page10

Operating Instructions

12. Pusheachbowlclampbackwardstounlockthebowlfromthebowlcradle.

13. Liftupslightlyonthebowlsoitclearsthepinsonthebowlcradle.

Most batches are heavy. Always use two people to remove and transport the loaded

bowl after mixing is complete. A bowl truck is included with the SP60, SP62P and

SP80PL models and should be used to unload bowls containing more than 50 lbs.

per batch.

HOW TO USE THE ATTACHMENT HUB

Never put your hand into the feed chute when using any mixer attachment.

ThemixermustbeOFFbeforeinstallingattachments!DoNOTuseattachmentswhilemixing!

1. Loosenandremovetheattachmenthubthumbscrew(seeg10-1).

2. Removetheplasticcoverfromtheattachmenthub(seeg10-1).

3. Lubricatetheattachmentshaftwithafoodqualitygreaseormineraloil.

4. Inserttheattachmentshaftintothehubmakingsuretolineupthealignmentpinwith

 thehubhole.

5. Tightenthethumbscrewbackintothehubandsecurelytightenit.

6. Selecttheappropriatespeedsettingbyliftingorloweringthespeedcontrollever.

 Recommended Speed while using attachments:

 Attachment  RecommendedSpeed

 VegetableSlicer   1or2

 CheeseShredder/Grater  2or3

 MeatGrinder   1only

 NOTE: Makesurethebowlisupandthebowlguardisclosed.Themixerwillnotstartifthebowlandthe 

  bowlguardarenotintheproperoperatingposition.

7. Turnthetimerknobinacounterclockwisedirectiontothegreen“on”position.

8. Pressthegreenstartbuttonlocatedonthemiddleofthecontrolpanel.

Always STOP the mixer BEFORE changing speeds! Failure to do so may damage the

gears or other parts and WILL void the warranty!

9. Tochangethespeedwhileusingmixerattachments:

 a. presstheredstopbutton

 b. changethespeedbyraisingorloweringthespeedcontrollever

 c. pressthegreenstartbuttontorestartthemixer.



NOTE: TheSP62PandSP80PLwillautomaticallyshutoffifthespeedsarechangedwhilethemixerisin

  operation.

PlasticCover

Thumbscrew

g.10-1

Page11

• Dilutedetergentpersupplier’sinstruction.

• DO NOThosedownorpressurewashanypartofthemixer.

• NEVERuseascrubberpad,steelwool,orabrasivematerialtocleanthemixer.

• NEVERusebleach(sodiumhypochlorite)orbleachbasedcleaner.

• ALWAYSremovetheagitatoraftereachbatch.Ifnot,theagitatorcanbecomestuckontheshaftand 

 difculttoremove.

The entire mixer, including removable parts, must be thoroughly cleaned and sanitized using the

procedures identied by your local health department and the ServSafe Essentials published by the

National Restaurant Association Educational Foundation (NRAEF). Visit www.servsafe.com for

more details.

It is extremely important to sanitize the mixer and to follow the instructions on the quaternary

sanitizer container to ensure proper sanitation is achieved.

ALWAYS DISCONNECT OR UNPLUG THE ELECTRICAL POWER FROM THE MIXER BEFORE

CLEANING.

RECOMMENDED CLEANING  

PART

REQUIRED ACTION FREQUENCY

Agitators Hand-washusingmildsoapandwater,rinse,dryand

sanitize.

Cleanaftereachuse.

RemovableBowlGuard Hand-washusingmildsoapandwater,rinse,dryand

sanitizeorplaceindishwasher.

Cleanaftereachuse.

Bowl Usingaspongeorcloth,mildsoapandwater,apply

pressuretoensurethebowlisclean,rinse,dry,and

sanitize.Thebowlcanalsobeplacedinadishwasher.

Cleanaftereachuse.

RearSplashGuard Hand-washusingmildsoapandwater,rinse,dryand

sanitize.

Cleanaftereachuse.

BowlCradle Hand-washusingmildsoapandwater,rinse,dryand

sanitize.

Daily

PlanetaryShaft Wipewithcleandampcloth,dryandsanitize.Applyalight

quantityofGlobeoil(mineraloil)totheplanetaryshaftafter

cleaning.

Cleanaftereachuse.

Exterior Hand-washusingmildsoapandwater,rinse,dry,and

sanitize.DONOTuseawaterhose!

Daily

HubInterior Wipewithcleandampcloth,dry,andsanitize. Daily

Cleaning Instructions

Page12

YournewGlobemixerwillprovideyearsofuninterruptedservice,butonlyifyoudothefollowing.

Installation

• Donotuseanextensioncordtoconnectelectricalpower.

• Makesureall3Phaseunits(seedataplate)runinthedirectionofthearrowonfrontofthemachine.

Operation

• Turnoffthemixerpriortochangingspeeds.

• Followthecapacitychartonpage13,especiallyformixingdough.

• Useonlyrst(1)speedformixingdough.2ndspeedshouldneverbeusedon50%ARorlowerwiththe

 exceptionoftheSP60.TheSP60requiresa50%reductioninbatchsizetomixinspeed2with50%AR

 doughs.

• Iftheunitshutsoffduringmixing(overloadprotectiontrips),reducethebatchsize.

Maintenance

• Addonly2pumpsofgreasetotheplanetarygreasettingonceayear.

Important Points

Recommended Maintenance

PART REQUIRED ACTION FREQUENCY

PlanetaryRing Reapplygrease(e.g.blackaxlegrease).  Onceayear.

 Injectgrease(2pumpsonly)intozerktting

 onthesideofplanetary.DONOToverll!

BowlSlideRods ApplyGlobeoil(mineraloil)onthebowlsliderods. Ifthebowlbecomesdifcultto

 Raiseandlowerthebowltodistributetheoilonto  raiseorlower.

 therods.

GearOilMeter ContactaGlobeauthorizedservicertochangethe  Onceayear.Whenthegearoil

(SP62Pand gearoil.  metershowstheoilbeingbelow

SP80PLonly)   halfofthecircle.

Page13

Capacity Chart

The following maximum capacities are intended as a guideline only. Varying factors such as the type of ﬂour used,

temperature of water used and other conditions may require the batch to be reduced.

Product Agitator

and Speed

SP5 SP8 SP10 SP20 SP25 SP30/

SP30P

SP40 SP60 SP62P SP80PL

WafeorHotcakeBatter

Flat Beater 2 qts. 3 qts. 5 qts. 8 qts. 10 qts. 12 qts. 16 qts. 24 qts. ---- 30 qts.

WhippedCream

Wire Whip 2 qts. 2 qts. 2 qts. 4 qts. 5 qts. 6 qts. 9 qts. 12 qts. ---- 16 qts.

MashedPotatoes

Flat Beater 4 lbs. 4 lbs. 8 lbs. 15 lbs. 18 lbs. 23 lbs. 30 lbs. 40 lbs. ---- 50 lbs.

EggWhites

Wire Whip ¾ pts. ¾ pts. 1 pt. 1 qt. 1¼ qts. 1½ qts. 1¾ qts. 2 qts. ---- 2 qts.

Meringue

(Qty.ofWater)

Wire Whip ¼ pts. ½ pts. ¾ pts. 1½ pts. 1¾ pts. 1 qt. 1¼ qts. 1¾ qts. ---- 3 qts.

RaisedDonutDough

(65%AR)*

Dough Hook

1st and 2nd

2 lbs. 2 lbs. 4½ lbs. 9 lbs. 12 lbs. 15 lbs./

20 lbs.

25 lbs. 60 lbs. 75 lbs. 80 lbs.

HeavyBreadDough

(55%AR)*•

Dough Hook

1st only

4 lbs. 3 lbs. 7½ lbs. 15 lbs. 20 lbs. 30 lbs./

35 lbs.

40 lbs. 70 lbs. 75 lbs. 80 lbs.

BreadandRollDough

(60%AR)*•

Dough Hook

1st only

5 lbs. 5 lbs. 12½ lbs. 25 lbs. 25 lbs. 45 lbs. 60 lbs. 80 lbs. 90 lbs. 90 lbs.

PizzaDough,Thin

(40%AR)*•

Dough Hook

1st only

3 lbs. 2 lbs. 5 lbs. 9 lbs. 12 lbs. 16 lbs./

25 lbs.

30 lbs. 40 lbs. (1st) 50 lbs.

35 lbs. (2nd)

50 lbs.

PizzaDough,Medium

(50%AR)*•

Dough Hook

1st only

4 lbs. 4 lbs. 5 lbs 10 lbs. 15 lbs. 25 lbs./

36 lbs.

40 lbs. 70 lbs. (1st)

35 lbs. (2nd)

80 lbs. (1st)

60 lbs. (2nd)

90 lbs.

PizzaDough,Thick

(60%AR)*•

Dough Hook

1st only

5 lbs. 5 lbs. 10 lbs 20 lbs. 25 lbs. 40 lbs./

45 lbs.

50 lbs. 70 lbs. 90 lbs. 100 lbs.

FondantIcing

Flat Beater 4 lbs. 3 lbs. 6 lbs 12 lbs. 15 lbs. 18 lbs. 25 lbs. 36 lbs. ---- 60 lbs.

Cake

Flat Beater 5 lbs. 6 lbs. 10 lbs. 20 lbs. 25 lbs. 30 lbs. 40 lbs. 60 lbs. ---- 90 lbs.

PieDough

Flat Beater 5 lbs. 4 lbs. 10 lbs. 18 lbs. 22 lbs. 27 lbs. 35 lbs. 50 lbs. 60 lbs. 70 lbs.

Pasta,BasicEggNoodle

Dough Hook 1 lb. 2 lbs. 3 lbs. 5 lbs. 6 lbs. 8 lbs./

15 lbs.

17 lbs. 35 lbs. 40 lbs. 50 lbs.

* NOTE: The mixer capacity depends on the moisture content of the dough. When mixing doughs (pizza, bread,

or bagels) check your AR%! %AR (% Absorption Ratio) = Water weight divided by ﬂour weight. The capacities

listed above are based on ﬂour at room temperature and 70°F water temperature. (1 gallon of water

weighs 8.33 lbs.)

 Maximum Mixing Time - 7 Minutes

• If high gluten ﬂour is used, reduce the batch size by 10%.

 If using chilled ﬂour, water below 70°F, or ice, reduce batch size by 10%.

 2nd speed should never be used on 50% AR or lower with the exception of the SP60. The SP60 requires a

50% reduction in batch size to mix in speed 2 with 50% AR doughs.

Do not use attachments on hub while mixing!

Page14

Problem Possible Causes Action Required

Mixerwillnotrun. Bowlguardnotinclosedposition. Rotateguardtotherightuntilfullyclosed.

 Bowlnotraised. Raisebowltohighestposition.



 Timerisnotengaged. Turntimeratleastveminutespast“0”,thento 

  desiredtimeorsettimetothegreen“on”position.

 Powernotconnectedproperly. Checkallpowerconnections.Plugintoalivesocket.

  (Do not use extension cord!) Testsocketwith 

  anotheritem.

 Buildingcircuitbreakerisoff. Checkbreakerbox.

 Internaloverloadtripped. SP25&smallermodels:Pressstopbuttonthen 

  pressresetbutton.Largermodels:Waittwo 

  minutes.Pressstopbuttonthenpressstartbutton.

  (If overload continues to trip, reduce batch size

and/or adjust recipe!)

Gearnotengaged. Switchgearfullyintoposition.(Mixer will not operate

if the speed control lever is positioned in between

speeds)

Mixerstopsduring Internaloverloadtripped. SP25&smallermodels:Pressstopbuttonthen

mixing.  pressresetbutton.Largermodels:Waittwo 

  minutes.Pressstopbuttonthenpressstartbutton.

  (If overload continues to trip, reduce batch size

and/or adjust recipe!)

 Damagedorbrokentransmissionbelt. SP25&largermodels:Techniciantoreplacebelt.

 Speedswerechangedduringmixing, Returnspeedcontrollevertoaspeedmodel 

 SP80PLonly. positionandrestartthemixer.

Mixerisnoisy. Mixerisnotinstalledonlevelsurface. Adjustsurfaceorrelocatemixer.Makesurerubber

  feetareinstalled.

 Bowlnotseatedcorrectlyorclamps Ensurebowlisseatedintobowlcradlecorrectlyand

 notinplace. bowlclampsarelockedintoplace.



 Agitatornotttedproperly. Removeandattachagitatorintopositionproperly.

 Overloadingbowl. Reducebatchsize.(See Capacity Chart)

 Damagedorwornbelt. Replacebelt.

 Planetaryringgearneeds Techniciantoinspectforsourceofnoise.  

 moregrease. Reapplyhigh-pressuregrease.Contacttechnician.



Safetyguardseized Clean&lubricateslidesheath. Technicianmustdropdownplanetaryassemblyto

(willnotmovefreely).  accessmat&sheath.Contacttechnician.

Agitatorswon’tgo Lackoflubricationand/orcleaning Wipeplanetaryshaftwithacleandampclothand

ontotheplanetary oftheplanetaryshaft. lubricatetheshaftwithmineraloilorfoodquality

shafteasily.  grease.

Troubleshooting

Page15

Problem Possible Causes Action Required

Mixingtimeistoo Three-phasemixeriswiredwrong. Agitatorsshouldrotateclockwisearoundbowl.Ifnot,

long.  electricianmustrewire.

 Batchsizetoosmall. Increasebatchsizeorusesmallerbowladapterkit.

  (Contact dealer for purchase)

 Incorrectrecipeportionsor Followportionsandtemperaturesperrecipe 

 temperatures. instructions.

Bowlraisesticking Lackoflubricationonbowlslides. Lubricatebowlslideswithmineraloilorfoodquality

ornotoperational.  grease.Ifstillsticking,technicianmustcleanbowl 

  raisemechanism.

Oneormoregears Brokenbelt. Techniciantoreplacebelt.

notworking.

 Damagedorbrokengear. Techniciantoreplacegear.Always stop mixer

before shifting gears!

Mixerwillnotmix Incorrectorlowvoltage. Contactelectrician.

mediumorheavy

loads. Beltslipping. Techniciantoreplacebelt.

Residueleaking Contaminatedhubduetobuild-upof Techniciantoremovehubandcleaninterior.Toavoid

fromhub. meatand/orvegetablejuices problem,alwayswipehubanddryaftereachuse. 

 (especiallytomatoes). *Note: Acid from tomato juices will corrode/

contaminate interior parts! Don’t mix tomatoes in

meat grinder!

Agitatorstouching Defectiveordentedbowl. Removedentsorreplacebowl.

bottomorsidesof

bowl. Defectiveagitator. Replaceagitator.

Brokenwhipwires. Batchsizetoolargeformixer.Items Reducebatchsize.(See Capacity Chart)Adjust 

 toorm,speedtoohigh. recipe.Reducespeed.

 Handutensildroppedintobowlwhile Stopmixerbeforeworkingonmixture.

 mixing.

Brokenatbeater. Ingredientstoocoldortoolarge Waitforingredientstoreachroomtemperature 

 (e.g.frozenbutter,creamcheese beforemixing.Reducechunksize.

 cutinchunks).

Brokendough Batchsizetoolargeformixer. Reducebatchsize.(See Capacity Chart)

hook.  Adjustrecipe.

 Ingredientstoocoldortoolarge. Waitforingredientstoreachroomtemperature 

  beforemixing.Reducechunksize.

Mixtureclimbsup Three-phasemixeriswired Electriciantorewire.

doughhook. incorrectly.

Discolorationof Bowlhasnotbeenthoroughlycleaned. Cleanbowlagain(refertopage11).

mixedproduct.

Troubleshooting

Page16

Limited Mixer Warranty

GlobeFoodEquipmentCompany(“GFE”)warrantstotheoriginalpurchaserofnewequipmentthatsaid

equipment,wheninstalledinaccordancewithourinstructionswithinNorthAmericaandsubjectedtonormaluse,

isfreefromdefectsinmaterialorworkmanshipforaperiodof2yearsonparts(excludeswear/expendableparts).

Thelaborwarrantyis1yearonlaborfromoriginalinstallation,or18monthsfromactualshipmentdate,whichever

dateoccursrst.Mixerattachmentshavea1yearreplacementwarrantyfrominvoicedate.Thereisnolabor

warrantyformixerattachments.Thevegetableslicingassembly,shredder/graterassembly,andmeatgrinderare

consideredmixerattachments.

THISWARRANTYISINLIEUOFALLOTHERWARRANTIES,WHETHEREXPRESSEDORIMPLIED.GFE

EXPRESSLYDISCLAIMSANYIMPLIEDWARRANTYOFMERCHANTABILITYOREXPRESSORIMPLIED

WARRANTYOFFITNESSFORAPARTICULARPURPOSE.

GFE’SOBLIGATIONANDLIABILITYUNDERTHISWARRANTYISEXPRESSLYLIMITEDTOREPAIRINGAND

REPLACINGEQUIPMENTWHICHPROVESTOBEDEFECTIVEINMATERIALORWORKMANSHIPWITHIN

THEAPPLICABLEWARRANTYPERIOD.AllrepairspursuanttothisWarrantywillbeperformedbyan

AuthorizedDesignatedGFEServiceLocationduringnormalworkinghours.INNOEVENTSHALLGFEBE

LIABLEFORINCIDENTALORCONSEQUENTIALDAMAGESTOBUYERORANYTHIRDPARTY,INCLUDING,

WITHOUTLIMITATION,LOSSOFPROPERTY,PERSONALINJURY,LOSSOFBUSINESSORPROFITSOR

OTHERECONOMICLOSSES,ORSTATUTORYOREXEMPLARYDAMAGES,WHETHERINNEGLIGENCE,

WARRANTY,STRICTLIABILITY,OROTHERWISE.

Thiswarrantyisgivenonlytotherstpurchaserfromaretaildealer.Nowarrantyisgiventosubsequent

transferees.

Thiswarrantydoesnotcoverproductfailurescausedby:failuretomaintain,neglect,abuse,damagedueto

excesswater,re,normalwear,impropersetupanduse.Periodicmaintenanceisnotcovered.

Thiswarrantyisnotinforceuntilsuchtimeasaproperlycompletedandsignedinstallation/warrantyregistration

oranonlineregistrationformhasbeenreceivedbyGFEwithin30daysfromthedateofinstallation.Register

onlineatwww.globeslicers.com/warranty.asp.

THEFOREGOINGWARRANTYPROVISIONSAREACOMPLETEANDEXCLUSIVESTATEMENTBETWEEN

THEBUYERANDSELLER.GFENEITHERASSUMESNORAUTHORIZESANYPERSONSTOASSUMEFOR

ITANYOTHEROBLIGATIONORLIABILITYINCONNECTIONWITHSAIDEQUIPMENT.

Exampleofitemsnotcoveredunderwarranty,butnotlimitedtojusttheseitems:

 1. ActsofGod,re,waterdamage,vandalism,accident,theft.

 2. Freightdamage.

 3. Improperinstallationoralterationofequipment.

 4. Useofgenericoraftermarketparts.

 5. RepairsmadebyanyoneotherthanaGFEdesignatedservicer.

 6. Lubrication.

 7. Expendablewearparts.(Thisincludesthebowl,atbeater,wirewhip,spiraldoughhook,

  andthepastryknife.)

 8. Cleaningofequipment.

 9. Misuseorabuse.



Globe Food Equipment SP30P Installation guide

Brand: Globe Food Equipment

Model: SP30P

Type: Installation guide

This manual is also suitable for

Download PDF

report

Globe Food Equipment SP30P Installation guide

This manual is also suitable for

Globe Food Equipment SP30P Installation guide

Related papers

Other documents