PREVOST H3-45 Owner's manual

COACH MANUFACTURER

OPERATOR’S MANUAL

H SERIES COACHES

PA1577

October 2011

PA1577 rev.5

October 2011

Featuring:

 EPA2010 regulations engine with selective catalytic reduction SCR

system

First edition: November 2010, starting from vehicle B-1721.

REVISION DESCRIPTION DATE

1 Introduction of Prevost AWARE Adaptive Cruise Braking February 2011

2 Standard engine oil type update – changed to 10W30 June 2011

3 2011 inducement strategy added June 2011

4 Reorganization of manual structure September 2011

5 2012 inducement strategy added, Idle shutdown timer, towing procedure October 2011

FOREWORD i

This Operator's Manual for the PREVOST H3-

41 and H3-45 coaches has been prepared to

thoroughly acquaint you, the driver, with the

equipment and features of the coach in order for

you to fully appreciate and safely enjoy this

vehicle. Prevost Car Incorporated is committed

to the continuous improvement of coach quality,

reliability, durability and safety. With innovative

features, the H3 series coach was designed with

passenger and driver safety and comfort in mind.

This manual contains information available at the

time of publication. Because standard and

optional equipment is covered in this manual,

some of the optional equipment described may

not apply to your coach. If in doubt, refer to the

technical documentation package provided with

the coach.

Driver's controls and instruments incorporate

advanced technology for enhanced driving ease

and security. This manual describes the main

features, instruments and controls, and servicing

requirements for both standard and optional

equipment. Read this manual carefully to take

advantage of the coach's advanced features and

to ensure optimum safety and passenger comfort.

Keep this manual in the coach at all times. Make

sure this manual is kept with the coach when

ownership is transferred. Please use the

appropriate card at the end of this manual to

promptly notify Prevost Car of any change of

address or transfer of ownership. This will ensure

we provide fast and reliable coach service to all

coach operators.

Warnings, cautions and notes are used

throughout this manual to emphasize important

points when necessary:

WARNING

Directs the operator’s attention to unsafe

practices which could result in serious

personal injury or severe damage to the

vehicle.

CAUTION

Directs the operator’s attention to unsafe

practices where personal injury is not likely

but damage to vehicle components could

occur.

NOTE

Indicates supplementary information essential

to the proper operation of the vehicle.

The service life of the coach depends on the kind

of attention it receives. Pay close attention to the

warnings, cautions and notes. Read the various

notices and instructions posted throughout the

coach and attached to equipment.

Since continuous improvement is a primary focus at Prevost

Car, we reserve the right to make changes anytime, without

notice, and without incurring any obligation.

Before reproducing or copying this manual, in whole or in

part, written consent must be obtained from Prevost Car

Incorporated.

TABLE OF CONTENTS iii

SECTION 1 SAFETY PRECAUTIONS..............................................................................................1-1

SECTION 2 COACH EXTERIOR .......................................................................................................2-1

SECTION 3 COACH INTERIOR........................................................................................................3-1

SECTION 4 CONTROLS AND INSTRUMENTS...............................................................................4-1

SECTION 5 OTHER FEATURES ......................................................................................................5-1

SECTION 6 STARTING AND STOPPING PROCEDURES..............................................................6-1

SECTION 7 SAFETY FEATURES AND EQUIPMENT .....................................................................7-1

SECTION 8 CARE AND MAINTENANCE ........................................................................................8-1

SECTION 9 TECHNICAL INFORMATION........................................................................................9-1

ABBREVIATIONS

APPENDIX A – SERVICE LITERATURE

APPENDIX B – TROUBLESHOOTING MULTIPLEX

APPENDIX C – ALLISON DIAGNOSTIC TROUBLESHOOTING CODES

APPENDIX D – SPHEROS PREHEATER FLASH CODE

APPENDIX E – TPMS TROUBLESHOOTING GUIDE

SAFETY PRECAUTIONS 1-1

SECTION 1 SAFETY PRECAUTIONS

SAFE OPERATING PRACTICES ................................................................................................................ 2

DEFENSIVE DRIVING PRACTICES ............................................................................................................ 2

OTHER PRECAUTIONS .............................................................................................................................. 3

1-2 SAFETY PRECAUTIONS

SAFE OPERATING PRACTICES

To ensure safe and reliable operation, heed the

following safety precautions.

o Operation and maintenance of the vehicle

must be performed only by qualified

personnel.

o Before driving, conduct a walk around

inspection and check that all baggage

compartment doors and equipment access

doors are securely shut.

o Make sure good visibility is maintained at all

times. Keep windshields clean and free of

obstructions.

o Adjust the driver's seat so that all controls

can be reached easily.

o Always wear your safety belt when driving.

o Check the instrument panel frequently. Do

not operate the vehicle when dials or

indicators do not indicate normal operating

conditions.

o Always pay attention to pedestrians passing

in front and behind the vehicle. Always yield

to pedestrians at pedestrian walkways.

o Do not drive over obstacles on the road.

Empty boxes, piles of leaves, and snowdrifts

could conceal hidden dangers that could

damage the vehicle suspension and

underbody.

o When turning or changing lanes, signal your

intention well in advance.

o When approaching to make a right turn,

reduce the space between the vehicle and

the curb to make sure another vehicle

cannot pass on the right. Since the vehicle

makes wide turns, allow enough space to

make safe turns.

o Switch from high beams to low beams when

meeting or following other vehicles within

500 feet (150 meters).

o Never leave the vehicle unattended with the

engine running or with the key in the ignition.

Turn off the engine, remove keys and apply

the parking brake before leaving the vehicle.

o Shut-off the engine before refueling, adding

oil, performing maintenance or servicing

tasks, unless stated otherwise.

o Fuel is highly flammable and explosive. Do

not smoke when refueling. Keep away from

open flames or sparks.

o Do not run the engine or HVAC system with

access doors left open. Close compartment

doors before operating any equipment.

o Do not remove the surge tank filler cap or

the cooling system pressure cap when the

engine is hot. Let the engine cool down

before removing filler caps.

o Do not attempt to push or pull-start the

vehicle.

o The service life of the vehicle depends on

the kind of maintenance it receives. Always

record any problems and report them

immediately to maintenance personnel. After

each trip, perform a system diagnostic to

check if error codes and anomalies were

recorded in the vehicle electronic modules.

DEFENSIVE DRIVING PRACTICES

o For city driving, allow a four to six second

travel interval between your vehicle and the

vehicle ahead. Increase this travel interval

to six to eight seconds for highway driving.

Increase time interval for driving at night or

in foul weather.

o Be prepared to stop when approaching an

intersection. The stopping distance of the

vehicle increases with the weight and speed.

o Establish eye-to-eye contact with other

drivers and with pedestrians. Use, high

beam and low beam headlights, turn signals

and horn as needed.

o On highway, don't stare at the road ahead.

Keep your eyes moving. Check mirrors and

dashboard instruments frequently.

o To keep the vehicle from drifting across

lanes during highway driving, always look

over the horizon on the road ahead.

o Adjust your speed to road conditions, traffic

and visibility. Never exceed the posted

speed limits.

o If another vehicle is following close behind,

reduce your speed to let the vehicle pass.

For additional information about safe operation

and defensive driving practices, contact the local

department of motor vehicles authority.

SAFETY PRECAUTIONS 1-3

OTHER PRECAUTIONS

WARNING

This vehicle is not designed to carry standing

passengers.

WARNING

Prior to working on a system inside vehicle,

make sure to cut electrical power and air

supply. A component could be supplied with

electricity even if the ignition switch is set to

the OFF position and/or a component could

be pressurized even if air tanks are emptied.

Always refer to the appropriate wiring and

pneumatic diagrams prior to working on

electrical and/or pneumatic systems.

NOTE

When the ignition switch is set to the OFF

position, the electrical components are not

energized except for the CECM (Chasis

Electronic Control Module), the battery

equalizer, the preheater system and some

electronic modules; which are energized during

15 minutes after the ignition has been set to

the OFF position. Prior to working on one of

these electrical components, set the battery

master switch in the main power compartment

to the OFF position. If the vehicle will not be

operated for a long period (more than 2

weeks), it is recommended, in order to prevent

the batteries from discharging, to trip the main

circuit breakers located in the main power

compartment to stop the small current drawn

by the radio preset station memory, the CECM

memory and the instrument cluster clock. Note

that the radio station presets will be erased,

same thing for the diagnostic codes history and

the instrument cluster clock will have to be

reset.

CAUTION

Prior to arc welding on the vehicle, refer to

section 00-GENERAL of your maintenance

manual. Precautions have to be taken to

avoid costly damage to the electronic

components.

COACH EXTERIOR 2-1

SECTION 2 COACH EXTERIOR

EXTERIOR VIEW..........................................................................................................................................2

EXTERIOR LIGHTING..................................................................................................................................3

ENGINE COMPARTMENT CURBSIDE DOOR ........................................................................................... 4

ENGINE COMPARTMENT DOOR ...............................................................................................................4

DIESEL PARTICULATE FILTER ACCESS DOOR .....................................................................................5

MAIN POWER COMPARTMENT (BATTERY) ............................................................................................5

RADIATOR DOOR .......................................................................................................................................6

SCR CATALYTIC CONVERTER ACCESS HATCH....................................................................................6

A/C CONDENSER COMPARTMENT ..........................................................................................................6

EVAPORATOR COMPARTMENT ...............................................................................................................7

FRONT ELECTRICAL AND SERVICE COMPARTMENT...........................................................................7

BAGGAGE COMPARTMENTS....................................................................................................................8

FUEL AND DIESEL EXHAUST FLUID (DEF) FILLER NECK ACCESS ....................................................8

SPARE WHEEL COMPARTMENT ..............................................................................................................9

ENTRANCE DOOR ......................................................................................................................................9

ENTRANCE DOOR OPENING INTERIOR OPERATING SWITCHES......................................................................... 10

ENTRANCE DOOR OPENING EXTERIOR OPERATING SWITCH ...........................................................................10

DOOR OPERATION LOGIC ............................................................................................................................10

EMERGENCY DOOR OPENING ...................................................................................................................... 10

WHEELCHAIR LIFT DOOR .......................................................................................................................10

REAR VIEW MIRRORS..............................................................................................................................11

ELECTRICALLY ADJUSTED REAR VIEW MIRRORS (RAMCO)..............................................................................11

BACK UP CAMERA...................................................................................................................................11

120 VOLTS CONNECTORS.......................................................................................................................11

ENGINE BLOCK HEATER ..............................................................................................................................11

BATTERY CHARGER ....................................................................................................................................11

HUBODOMETER........................................................................................................................................11

TRAILER HITCH.........................................................................................................................................12

2-2 COACH EXTERIOR

EXTERIOR VIEW

H3-45 (TYPICAL) 18688

1. Engine air intake

2. Engine compartment curbside door

3. Main power compartment (battery

compartment)

4. Wheelchair access door (optional Ricon lift)

5. Baggage compartment

6. Fuel filler neck and diesel exhaust fluid

(DEF) filler neck access door

7. Condenser compartment

8. Entrance door control switch

9. Entrance door

10. Back up camera (optional)

11. Diesel Particulate Filter (DPF) access door

12. Engine compartment rear door

13. Rear-view mirror

14. Spare wheel compartment

15. Front electrical and service compartment

16. Driver’s power window

17. Evaporator compartment

18. Fuel filler neck access door

19. Tag axle

20. Radiator door

21. SCR catalytic converter access door

COACH EXTERIOR 2-3

EXTERIOR LIGHTING

EXTERIOR LIGHTING 18588

2-4 COACH EXTERIOR

ENGINE COMPARTMENT CURBSIDE

DOOR

Lock this door using the

exterior compartment key.

To open, pull up the door

handle to release the latch

and then pull the door

open.

The curbside door also has a safety catch to

prevent it from closing inadvertently. Release

the catch before attempting to close.

DOOR HANDLE 18184

The engine compartment curbside door provides

access to the following (if equipped):

 Engine compartment rear door release lever

 Davco Fuel Pro 382 filtration system

 Primary & secondary air system fill valve

 Power steering fluid tank

 Booster block terminals

 Wet air tank drain cock

 Lavatory waste water tank access cap

 Engine air filter

 Battery charger 110-120 volts connector

 Engine block heater 110-120 volts connector

WARNING

Unless otherwise stated, do not run the

engine when the engine compartment

curbside door is open.

ENGINE COMPARTMENT DOOR

To open the engine door,

first open the curbside

door. Lift the latch release

lever. Unlatch the door

and pull it out and up.

The door should stay open on it’s own but it is

recommended to always use the safety catch as

shown. The lighting in the engine compartment

turns on automatically when the door is open if

the engine compartment light switch is set to ON

and the ignition switch is set to ON or ACC. Use

this switch located in the engine compartment to

turn off the light if not required when the door is

open for a prolonged period. When open or not

closed properly, a pictogram appears on the

instrument cluster DID. To close the door, lift it

slightly and release the safety catch.

OPENING THE ENGINE COMPARTMENT DOOR 18331

This door provides access to the following

equipment:

 Engine

 Alternators

 Belts

 Compressor(s)

 Belt tensioning pressure control valve (see

Section 8 Care And Maintenance)

 Starter selector switch (see Section 6

Starting and Stopping Procedures)

 Plates and certification

COACH EXTERIOR 2-5

 Air filter restriction indicator

 Couplings and valves for lavatory

maintenance

 Fresh water tank coupling

 Engine oil dipstick

 Transmission oil dipstick

 Cooling fluid surge tank & access cap

WARNING

Unless otherwise stated, do not run the

engine when the engine compartment door is

open.

DIESEL PARTICULATE FILTER

ACCESS DOOR

The engine door must be

open before opening the

DPF access door. To

open the DPF access

door, press the latch

release lever. Using both

hands, push the door up

until it locks in place.

To close the door, press the latch release lever

again and lower the door, holding it with both

hands.

DIESEL PARTICULATE FILTER ACCÈSS DOOR

MAIN POWER COMPARTMENT

(BATTERY)

To unlock the main power

compartment door, use

the exterior compartment

door key. The door will

pop open.

The compartment light turns on automatically

when the door is open. A telltale light indicating

that a compartment door is open will illuminate

on the dashboard.

This compartment is closed off from the engine

compartment and is used to house the batteries

and electrical components. The following items

are located in the main power compartment:

 (4x) 12-volts batteries

 Main circuit breakers (12 & 24 volts)

 Battery charger (optional)

 Vanner battery equalizer

 Battery master switch

 Rear junction box

 Rear multiplex modules

 Transmission Electronic Control Module for

Allison transmission or Volvo I-Shift

 Rear fuse box (VECR)

 Relays

 Electronic ground stud

PARTIAL VIEW OF MAIN POWER COMPARTMENT

MAIN CIRCUIT BREAKERS 12 & 24 VOLTS

2-6 COACH EXTERIOR

RADIATOR DOOR

Open the engine radiator door by pushing on the

latch release lever.

RADIATOR DOOR LATCH RELEASE LEVER LOCATION

18529

SCR CATALYTIC CONVERTER

ACCESS HATCH

To gain access to the SCR catalytic converter:

1. Open the radiator door first;

2. Pull the catch connecting rod to unlock the

access hatch;

3. Lift the hatch open;

4. Hold the door open by inserting the support

rod free end into the receptacle located on

the left side of the door.

WARNING

After inserting the support rod into the

receptacle, make sure that the rod supports

the door securely from falling down on to your

head or body.

WARNING

External and internal temperatures remain hot

long after engine has been shutdown. Allow

the Aftertreatment Device and DPF to cool

before handling. Wear protective clothing and

glove while servicing.

ACCESSING THE SCR CATALYTIC CONVERTER 04035

A/C CONDENSER COMPARTMENT

To open the condenser compartment door:

1. Open the fuel filler door first;

2. Move the latch bolt pin to the right as shown

(step 1 on image);

3. Rotate the latch handle as shown (step 2);

4. Open the door on the right side when facing

it.

A/C CONDENSER COMPARTMENT DOOR OPENING

COACH EXTERIOR 2-7

CONDENSER COMPARTMENT 22362

EVAPORATOR COMPARTMENT

To access the evaporator compartment, pull the

release latch located on the left side wall of the

rearmost baggage compartment.

Release latch

EVAPORATOR COMPARTMENT ACCESS 18306

The evaporator compartment contains relays,

diodes and a multiplex electronic module

mounted on a panel located on the R.H. side

wall when facing the compartment.

EVAPORATOR COMPARTMENT 22365

NOTE

It is important to keep the evaporator

compartment door closed while checking the

HVAC system to prevent faulty readings.

HVAC COMPONENTS PANEL

FRONT ELECTRICAL AND SERVICE

COMPARTMENT

Unlock this compartment

door using the exterior

compartment key. The

light in the front service

compartment turns on

automatically when the

door is open.

The front electrical and service compartment

provides access to the following:

 Front fuse box (VECF) & spare fuses

 ABS module

2-8 COACH EXTERIOR

 VECU

 Front multiplex modules I/O-A, I/O-B;

 Relays & resistors

 Kneeling audible alarm

 Emergency door opening unlock valve

 Windshield washer reservoir

 Headlights washer reservoir

 Reclining bumper opening handle

 Accessories air tank purge valve

 Accessories air tank fill valve

FRONT ELECTRICAL & SERVICE COMPARTMENT

FRONT ELECTRICAL & SERVICE COMPARTMENT 14072

BAGGAGE COMPARTMENTS

Baggage compartments can hold a maximum

load of 2500 lb each, spread evenly over the

floor. The total combined weight of cargo and

passengers must not exceed 15660 lb. The

baggage compartments can be locked or

unlocked by using the exterior compartment key.

Pressurized cylinders assist the opening and

closing of the baggage compartment doors.

To close, pull the door down by the notch in the

lower part of the door. Once below a certain

point, release the door and the cylinders will

slam the door shut. Push-in the top part of the

door past the safety catch on both sides to fully

close.

Lights in the baggage compartments turn on

automatically when the door is open. A

pictogram appears on the DID when a

compartment door is open.

WARNING

To avoid injury, keep hands clear of door

edge and door frame when closing.

NOTE

To prevent theft and vandalism, always lock all

doors before leaving the vehicle unattended.

NOTE

The baggage compartment doors can be

locked / unlocked with the optional baggage

compartments locking system. The switch is

located on the lateral control panel. Refer to

Section 4 Controls and Instruments.

NOTE

To prevent the door from closing in case of

defective cylinders, lock the door in open

position by pushing it further towards the body

of the coach, until it locks in place.

FUEL AND DIESEL EXHAUST FLUID

(DEF) FILLER NECK ACCESS

Both fuel filler neck doors must be opened with

the exterior compartment key. To open, turn the

key ¼ turn clockwise and pull the door open.

COACH EXTERIOR 2-9

NOTE

It is recommended to refuel from the curbside

whenever possible, to avoid spilling fuel into

the evaporator compartment. Any amount of

fuel vapor in this compartment would be

carried right up into the cabin by the HVAC

system fresh air intake.

Moreover, the curbside filler neck access door

is the only access to the DEF filler neck.

NOTE

Provided the vehicle is parked on level

ground, an automatic nozzle will automatically

shut off when tank is approximately 95% full.

CAUTION

Do not fill to more than 95% of the tank

capacity. Do not "top off" the tank, doing so

may result in fuel spillage when the fuel

expands.

FUEL FILLER DOOR 03093

CAUTION

Diesel exhaust fluid DEF will begin to

crystallize and freeze at 12°F (-11°C) and

expand by 7% when frozen. To allow

expansion without damaging the DEF tank, do

not fill the tank with more than 15.9 gallons

(60 liters).

During vehicle operation, the SCR system is

designed to provide heating for the DEF tank

and supply lines. If DEF freezes when the

vehicle is shut down, start up and normal

operation of the vehicle will not be inhibited. The

SCR heating system is designed to quickly

return the DEF to liquid form and the operation

of the vehicle will not be impacted.

SPARE WHEEL COMPARTMENT

The spare wheel is located in the compartment

behind the front bumper.

WARNING

This compartment is not designed for

miscellaneous storage. Never store loose

objects in this compartment because they can

block the steering linkage mechanism.

TOOLS IN FIRST BAGGAGE COMPARTMENT 13015

To access the spare wheel compartment, pull on

the release handle located in the front electrical

and service compartment, near the lower door

hinge. The bumper will lower gradually.

NOTE

The jack and tools are located in the first

baggage compartment.

When closing the compartment, be sure the

bumper is firmly in place.

ENTRANCE DOOR

Lock or unlock the entrance door from outside

the vehicle by turning the key in the door lock

(counterclockwise to lock, clockwise to unlock).

To unlock the entrance door from the inside,

slide the lock lever on the inside of the door to

the left. If the orange tab on the door-lock lever

is visible, the door is unlocked.

NOTE

If the interior lever is used to exit the coach

and the key is not used to unlock the door, it

will lock again upon closing. Remember to

remove the keys upon exiting.

2-10 COACH EXTERIOR

Interior door lock

ENTRANCE DOOR 18437

ENTRANCE DOOR OPENING INTERIOR

OPERATING SWITCHES

From the inside, open the door by pressing the

door opening switch on the dashboard. Close

by pressing the door closing switch on the

dashboard. Refer to Section 4 Controls and

Instruments for more information.

DASHBOARD SWITCHES 06464

ENTRANCE DOOR OPENING EXTERIOR

OPERATING SWITCH

Opening and closing of the door may also be

pneumatically controlled from the outside using

the 3-position switch located on the door L.H.

side. Open the door by pushing the switch

forward, close by pushing the switch rearward.

EXTERIOR DOOR OPERATING SWITCH 18316

DOOR OPERATION LOGIC

If the switch is held in position until the door is

fully open or closed, the system holds pressure

in the door cylinder, locking the door in that

position. The door can be open to any position

by releasing the switch (or button, if inside)

when the desired position is attained. However,

the door is not locked in any position other than

fully open or fully closed. The door can then be

open or closed further by pushing or pulling on

the door.

When the door is almost shut, a mechanism will

finish the closing of the door. This works even

when the door is shut manually.

EMERGENCY DOOR OPENING

Refer to Section 7 Safety Features and

Equipment.

WHEELCHAIR LIFT DOOR

To open the optional wheelchair lift door, the

coach must be parked on a flat and level surface

with the parking brake applied. The wheelchair

access door swings to the side and is

maintained open by a locking mechanism.

Open the baggage compartment containing the

lift mechanism (Ricon only). The baggage

compartment door is located directly below the

wheelchair lift door and it opens to the side. If

the parking brake is not applied, a switch in the

door will activate the parking brake when it

detects the door is open.

Open the door completely until it locks in the

open position. To close the door, lift on the

locking mechanism arm and slam the door shut.

Refer to Section 5 Other Features for more

information on operating the optional wheelchair

lift.

Page is loading ...

PREVOST H3-45 Owner's manual

This manual is also suitable for

PREVOST H3-45 Owner's manual

Related papers

Other documents