208/230 VoltPackaged Single Stage Gas Heat/Electric Air Conditioner Three Phase 60HZ
NOTES:
1. Disconnect all power before servicing.
2. For supply conections use copper conductors only.
3. Not suitable on systems that exceed 150v to ground.
4. If any of the original wire as supplied with the furnace
must be replaced, it must be replaced with wiring material
having a temprature rating of at least 105C.
5. For supply wire ampacities and overcurrent protection,
see unit rating plate.
1. Couper le courant avant de faire letretien.
2. Employez uniquement des conducteurs en culvre.
9. Ne convient pas aux installations des plus de 150V
a la terre.
TO THERMOSTAT
7110080
11/09
FAULT CONDITION
FAULT CONDITION STATUS LIGHT (YELLOW)
STATUS LIGHT (RED)
POWER ON
ON
ON
1 FLASH
2 FLASH
3 FLASH
4 FLASH
5 FLASH
CONTINUOUS FLASH
CONTINUOUS FLASH
OFF
POWER OFF
LOW FLAME SENSOR SIGNAL
FLAME PRESENT
LIMIT CIRCUIT OPEN
IGNITION FAILURE (CHECK GROUND)
230 VAC & NEUTRAL REVERSED OR
NO GROUND
FALSE FLAME OR GAS RELAY
SHORTED
PRESURE SWITCH STUCK OPEN
WITH INDUCER ON
PRESURE SWITCH STUCK CLOSED
WITH INDUCER OFF
WIRING DIAGRAM
FIELD WIRING
LEGEND:
LOW VOLTAGE
HIGH VOLTAGE
¢711008x¤
FLAME STATUS
L1
XFMR
X13 COM
HUM
NEUTRALS
COM
3 AMP FUSE
BLOWER OFF
24V
X13 COOL
X13 HEAT
X13 FAN
1
2
3
4
5
6
7
8
9
4
5
6
1
2
3
R
C
Y
G
W
R
C
1
2
2
1
2
-
1
8
76
5
4329
1
8
76
5
4329
TO 208/230 VAC
POWER SUPPLY
OUTDOOR FAN
MOTOR
COMPRESSOR
CONTACTOR
COMPRESSOR
T2
T1
T3
CAPACITOR
TO DISCHARGE
AIR SENSOR
BLUE
YELLOW
YELLOW
PLUG E
ECONOMIZER
ACCESSORY PLUG
ECONOMIZER JUMPER
HARNESS ASSY.
8 WIRE
ECONOMIZER
ACCESSORY PLUG
PRESSURE
SWITCH
LIMIT
SWITCH
FLAME ROLL-OUT
SWITCH
GROUND
FLAME
SENSOR
PRESSURE
SWITCH
GAS
VALVE
21
IGNITOR
INDUCER
N
L
C
G
TI
T2
T3
T4
T5
L1L2L3
T3 T2
T1
BLACK
ORANGE
C
C
S
R
1
8
76
5
4329
1
8
76
5
4329
CCH
BLACK
BLACK
BLACK
BLACK
BLACK
24V
208V
240V
COM
G
C
W1
Y2
Y1
R
BLACK
BLUE
BLUE
RED
YELLOW
BROWN
RED
GREEN/YELLOW
BLACK
GREEN
ORANGE
BLUE
ORANGE
BLUE
BLUE
BLUE
BLACK
WHITE
YELLOW
ORANGE
YELLOW
WHITE
RED
BLACK
YELLOW
ORANGE
BROWN
BROWN
BLACK
BLACK
RED
RED
RED
BLACK
WHITE
RED
RED
RED
GREY
GREEN
YELLOW
BLUE
YELLOW
BLACK
GREY
GREEN
YELLOW
YELLOW
BLACK
RED
WHITE
GREEN
