Hayward H350FDP Owner's manual

Brand: Hayward

Model: H350FDP

Category: Above ground pool accessories

Type: Owner's manual

FOR YOUR SAFETY

WARNING: If the information in these

instructions is not followed exactly, a re or

explosion may result causing property damage,

injury, or death.

- Donotstoreorusegasolineorotheram-

mablevaporsorliquidsinthevicinityofthis

oranyotherappliance.

WHAT TO DO IF YOU SMELL GAS:

• Donottrytolightanyappliance.

• Donottouchanyelectricalswitch;donotuse

anyphoneinyourbuilding.

• Immediatelycallyourgassupplierfroma

neighbor’sphone.Followthegassupplier’s

instructions.

• Ifyoucannotreachyourgassupplier,callthe

redepartment.

-Installationandservicemustbeperformedby

aqualiedinstaller,serviceagency,orthegas

supplier.

POOL AND SPA/HOT TUB HEATERS

H150FD, H200FD, H250FD, H300FD,

H350FD, H400FD & H500FD MODELS

OWNER’S MANUAL

FOR YOUR SAFETY

Thisproductmustbeinstalledandservicedbyauthorizedpersonnel,qualiedinpool/spa

heaterinstallation.Improperinstallationand/oroperationcancreatecarbonmonoxidegas

anduegasesthatcancauseseriousinjury,propertydamage,ordeath.

1301640701 REV G 0914

PRINTED 10/24/2011 AT 1:13 PM

U.S. PATENT NOS. 6,321,833 & 7,971,603

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

Warnings .......................................................................................................3

Section I. General information .......................................................................7

Section II. Consumer Operation & Maintenance ...........................................8

Maintaining proper water chemistry...............................................................8

Lighting & Operating instructions label ........................................................10

Temperature adjustment ..............................................................................11

Temperature Lock-out..................................................................................12

Fahrenheit versus Celsius ...........................................................................12

Winterization ................................................................................................12

Spring start-up .............................................................................................12

Error codes ..................................................................................................13

Warranty ......................................................................................................15

CONTENTS

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

Basicsafetyprecautionsshouldalwaysbefollowed,includingthefollowing:Failuretofollowinstructions

cancausesevereinjuryand/ordeath.

Thisisthesafety-alertsymbol.Whenyouseethissymbolonyourequipmentorinthismanual,lookfor

oneofthefollowingsignalwordsandbealerttothepotentialforpersonalinjury.

WARNINGwarnsabouthazardsthatcouldcauseseriouspersonalinjury,deathormajorpropertydam-

ageandifignoredpresentsapotentialhazard.

CAUTIONwarnsabouthazardsthatwillorcancauseminorormoderatepersonalinjuryand/orprop-

ertydamageandifignoredpresentsapotentialhazard.Itcanalsomakeconsumersawareofactionsthat

areunpredictableandunsafe.

ATTENTIONindicatesspecialinstructionsthatareimportantbutnotrelatedtohazards.

READ AND FOLLOW ALL INSTRUCTIONS IN THIS OWNER’S

MANUAL AND ON EQUIPMENT.

IMPORTANT SAFETY INSTRUCTIONS

Before installing or servicing this electrical equipment, turn power supply OFF.

KEEP SAFETY LABELS IN GOOD CONDITION AND REPLACE IF MISSING OR DAMAGED.

WARNING–Toreduceriskofinjury,donotpermitchildrentouseorclimbontheheater,pumpsor

lters.Closelysupervisechildrenatalltimes.Componentssuchastheltrationsystem,pumps,and

heatersmustbepositionedtopreventchildrenfromusingthemasameansofaccesstothepool.

CAUTION –Thisheaterisintendedforuseonpermanentlyinstalledswimmingpoolsandmayalso

beusedwithspas.DoNOTusewithstorablepools.Apermanentlyinstalledpoolisconstructedinor

onthegroundorinabuildingsuchthatitcannotbereadilydisassembledforstorage.Astorablepoolis

constructedsothatitiscapableofbeingreadilydisassembledforstorageandreassembledtoitsoriginal

integrity.

Thoughthisproductisdesignedforoutdooruse,itisstronglyrecommendedtoprotecttheelectrical

componentsfromtheweather.Selectawelldrainedarea,onethatwillnotoodwhenitrains.Itrequiresfree

circulationofairforcooling.Donotinstallinadampornon-ventilatedlocation.

WARNING –Itisrequiredthatlicensedelectriciansdoallelectricalwiring.Riskof

ElectricShock.Hazardousvoltagecanshock,burn,causedeathorseriousproperty

damage.Toreducetheriskofelectricshock,doNOTuseanextensioncordtoconnect

unittoelectricsupply.Provideaproperlylocatedoutlet.AllelectricalwiringMUSTbe

inconformancewithapplicablelocalandnationalcodesandregulations.Beforework-

ingonthisunit,turnoffpowersupplytotheheater.

WARNING –Toreducetheriskofelectricshockreplacedamagedwiringimmediately.Locateconduit

topreventabusefromlawnmowers,hedgetrimmersandotherequipment.

WARNING –Failuretobondtopoolstructurewillincreaseriskforelectrocutionandcouldresultin

injuryordeath.Toreducetheriskofelectricshock,theelectricianmustcomplywithinstallationin-

structionsandmustbondtheheateraccordingly.Inaddition,thelicensedelectricianmustalsoconform

tolocalelectricalcodesforbondingrequirements.

SAFETY INFORMATION

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

NOTES TO THE ELECTRICIAN:

Useasolidcopperconductor,size8orlarger.Runacontinuouswirefromexternalbondinglugtorein-

forcingrodormesh.ConnectaNo.8AWGsolidcopperbondingwiretothegroundinglugprovidedonthe

heaterandtoallmetalpartsofswimmingpoolorspa,andtoallelectricalequipment,metalpiping(except

gaspiping),andconduitwithin5ft.(1.5m)ofinsidewallsofswimmingpoolorspa.

IMPORTANT-ReferenceNECcodesforallwiringstandardsincluding,butnotlimitedto,grounding,

bondingandothergeneralwiringprocedures.

WARNING – Suction Entrapment Hazard.

Suctioninsuctionoutletsand/orsuctionoutletcoverswhicharedamaged,broken,

cracked,missing,orunsecuredcancausesevereinjuryand/ordeathduetothefol-

lowingentrapmenthazards:

Hair Entrapment-Haircanbecomeentangledinsuctionoutlets.

Limb Entrapment-Alimbinsertedintoanopeningofasuctionoutletorsuctionoutlet

coverthatisdamaged,broken,cracked,missing,ornotsecurelyattachedcanresultina

mechanicalbindorswellingofthelimb.

Body Suction Entrapment-Adifferentialpressureappliedtoalargeportionofthebodyorlimbscan

resultinanentrapment.

Evisceration/ Disembowelment-Avacuumapplieddirectlytotheintestinesthroughanunprotected

suctionoutletsumporsuctionoutletcoverwhichisdamaged,broken,cracked,missing,orunsecured

canresultinevisceration(disembowelment).

Mechanical Entrapment-Thereispotentialforjewelry,swimsuit,hairdecorations,nger,toeorknuck-

letobecaughtinanopeningofasuctionoutletorsuctionoutletcoverresultinginmechanicalentrap-

ment.

WARNING-Toreducetheriskofentrapmenthazards:

• Whensuctionoutletsarelessthana18”x23”equivalent,aminimumoftwofunction-

ingsuctionoutletsperpumpmustbeinstalled.Suctionoutletsinthesameplane(i.e.

oororwall),mustbeinstalledaminimumofthreefeet(3’)[1meter]apart,asmea-

suredfromnearpointtonearpoint.

• Dualsuctionoutletsshallbeplacedinsuchlocationsanddistancestoavoid“dual

blockage”byauser.

• Dualsuctionttingsshallnotbelocatedonseatingareasoronthebackrestforsuch

seatingareas.

• Themaximumsystemowrateshallnotexceedtheowratingofanylisted(percurrentrevisionof

ASME/ANSIA112.19.8)suctionoutletcoverinstalled.

• NeverusethePoolorSpaifanysuctionoutletcomponentisdamaged,broken,cracked,missing,or

notsecurelyattached.

• Replacedamaged,broken,cracked,missing,ornotsecurelyattachedsuctionoutletcomponentsim-

mediately.

• InstalltwoormoresuctionoutletsperpumpinaccordancewithlatestAPSP(formallyNSPI)Stan-

dardsandCPSCguidelines.FollowallapplicableNational,State,andLocalcodes.

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

WARNING–Failuretoremovepressuretestplugsand/orplugsusedinwinterizationofthepool/spa

fromthesuctionoutletscanresultinanincreasepotentialforsuctionentrapmentasdescribedabove.

WARNING–Failuretokeepsuctionoutletcomponentsclearofdebris,suchasleaves,dirt,hair,paper

andothermaterialcanresultinanincreasepotentialforsuctionentrapmentasdescribedabove.

WARNING–Suctionoutletcomponentshaveanitelife,thecover/grateshouldbeinspectedfre-

quentlyandreplacedatleasteverytenyearsoriffoundtobedamaged,broken,cracked,missing,ornot

securelyattached.

WARNING–AllsuctionanddischargevalvesMUSTbeOPENwhenstartingthecirculationsystem.

Failuretodosocouldresultinseverepersonalinjuryand/orpropertydamage.Alldrainsandsuction

outletsMUSThaveproperlyinstalledcovers,securelyattachedusingthescrewssuppliedwiththecov-

ers.Ifscrewsarelost,orderreplacementpartsfromyoursupplier.

WARNING – Hazardous Pressure.Poolandspawatercirculationsystemsoperate

underhazardouspressureduringstartup,normaloperation,andafterpumpshutoff.

Standclearofcirculationsystemequipmentduringstartup.Failuretofollowsafety

andoperationinstructionscouldresultinviolentseparationofthepumphousing

andcoverduetopressureinthesystem,whichcouldcausepropertydamage,severe

personalinjury,ordeath.Beforeservicingpoolandspawatercirculationsystem,all

systemandpumpcontrolsmustbeinoffpositionandltermanualairreliefvalve

mustbeinopenposition.Beforestartingsystempump,allsystemvalvesmustbeset

inapositiontoallowsystemwatertoreturnbacktothepool.Donotchangelter

controlvalvepositionwhilesystempumpisrunning.Beforestartingsystempump,

fullyopenltermanualairreliefvalve.Donotcloseltermanualairreliefvalve

untilasteadystreamofwater(notairorairandwater)isdischarged.

WARNING – Separation Hazard.Failuretofollowsafetyandoperationinstruc-

tionscouldresultinviolentseparationofpumpcomponents.Strainercovermustbe

properlysecuredtopumphousingwithstrainercoverlockring.Beforeservicing

poolandspacirculationsystem,manualairreliefvalvemustbeinopenposition.Do

notoperatepoolandspacirculationsystemifasystemcomponentisnotassembled

properly,damaged,ormissing.Donotoperatepoolandspacirculationsystemunless

lterairreliefvalvebodyisinlockedpositioninlterupperbody.

WARNING –Neveroperateortestthecirculationsystematmorethan40PSI.

WARNING–Fireandburnhazard.Motorsoperateathightemperaturesandiftheyarenotproperly

isolatedfromanyammablestructuresorforeigndebristheycancauseres,whichmaycausesevere

personalinjuryordeath.Itisalsonecessarytoallowthemotortocoolforatleast20minutespriorto

maintenancetominimizetheriskofburns.

WARNING–Failuretoinstallaccordingtodenedinstructionsmayresultinseverepersonalinjuryor

death.

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

WARNING–Thefollowing“SafetyRulesforHotTubs”recommendedbytheU.S.Consumer

ProductSafetyCommissionshouldbeobservedwhenusingthespa.

1. Spaorhottubwatertemperaturesshouldneverexceed104°F[40°C].Atemperatureof100°F

[38°C]isconsideredsafeforahealthyadult.Specialcautionissuggestedforyoungchildren.Pro-

longedimmersioninhotwatercaninducehyperthermia.

2. Drinkingofalcoholicbeveragesbeforeorduringspaorhottubusecancausedrowsiness,which

couldleadtounconsciousnessandsubsequentlyresultindrowning.

3. Pregnantwomenbeware!Soakinginwaterabove100°F[38°C]cancausefetaldamageduringthe

rstthreemonthsofpregnancy(resultinginthebirthofabrain-damagedordeformedchild).Preg-

nantwomenshouldadheretothe100°F[38°C]maximumrule.

4. Beforeenteringthespaorhottub,usersshouldcheckthewatertemperaturewithanaccuratether-

mometer;spaorhottubthermostatsmayerrinregulatingwatertemperaturesbyasmuchas4°F

(2.2°C).

5. Personstakingmedications,whichinducedrowsiness,suchastranquilizers,antihistaminesoranti-

coagulants,shouldnotusespasorhottubs.

6. Ifthepool/spaisusedfortherapy,itshouldbedonewiththeadviceofaphysician.Alwaysstirpool/

spawaterbeforeenteringthepool/spatomixinanyhotsurfacelayerofwaterthatmightexceed

healthfultemperaturelimitsandcauseinjury.Donottamperwithcontrols,becausescaldingcan

resultifsafetycontrolsarenotinproperworkingorder.

7. Personswithamedicalhistoryofheartdisease,circulatoryproblems,diabetesorbloodpressure

problemsshouldobtainaphysiciansadvicebeforeusingspasorhottubs.

8. Hyperthermiaoccurswhentheinternaltemperatureofthebodyreachesalevelseveraldegrees

abovenormalbodytemperatureof98.6°F[37°C].ThesymptomsofHyperthermiainclude:drowsi-

ness,lethargy,dizziness,fainting,andanincreaseintheinternaltemperatureofthebody.

The effects of Hyperthermia include:

1. Unawarenessofimpendingdanger.

2. Failuretoperceiveheat.

3. Failuretorecognizetheneedtoleavethespa.

4. Physicalinabilitytoexitthespa.

5. Fetaldamageinpregnantwomen.

6. Unconsciousnessresultingindangerofdrowning.

DEFINITIONS:

SuctionOutlet– ThetermSuctionOutletisatting,ttingassembly,cover/grateandrelatedcompo-

nentsthatprovideameansforwatertoexitthepoolandintothepumpcirculating

system.

Inchesof

Mercury(inHg)- Aunitformeasuringpressurebelowatmospheric(“suction”or“vacuum”)(1.0inch

Hg=.491PSI)

MainDrain– SeeSuctionOutlet

PSI– Anabbreviationforpoundspersquareinch.

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

INTRODUCTION:

Thismanualcontainsinstructionsforoperationandthesafeuseoftheswimmingpool/spa/hottubheat-

ers.Haywardstronglyrecommendsthattheownerreadthemanualbeforeusingtheswimmingpool/spa/

hottubheater.Ifafterreviewingthemanualanyquestionsremainunanswered,contactthefactoryorlocal

representative.

LIMITED WARRANTY SUMMARY:

Wewarrantthepool/spa/hottubheatertobefreefromdefectsinmaterialsandworkmanship,andwe

willwithinoneyearfromdateofinstallationforallusers,fortheoriginalpurchaser,repairor,atouroption,

replacewithoutchargeanydefectivepart.Wefurtherwarrantthatiftheheatexchangerorexchangerheaders

(water-containingsection)leakwithinoneyearfromdateofsuchinstallationforallusers,duetodefectsin

materialsandworkmanship,wewillprovideareplacementpart.Costoffreight,installation,fuel,andservice

labor(afteroneyear)isatuser’sexpense.Forfulldetailsofwarrantyagreement,seewarrantycerticate

includedinthismanual.

ATTENTION:Ifthepool/spa/hottubheaterisdamagedordestroyedbyimpropermaintenance,exces-

sivewaterhardness,incorrectwaterchemistry,orfreezingitisnotcoveredunderthemanufacturer’s

warranty.

SECTION I. GENERAL INFORMATION

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

8SECTION II. CONSUMER OPERATION & MAINTENANCE

TheheatexchangerinyourHaywardpoolheaterismadefromthehighestqualityofcopperandnickel

(Cupronickel)materials.Thepremiummaterialsandtheexactingprocessesusedinthemanufactureofthe

heatexchangerisstateoftheartinpoolheaterdesignandmanufacture.Yet,itremainsvitalthattheheatex-

changerbeprotectedfromdamagingorcorrosivechemicals,insufcientwateroworimproperlybalanced

waterchemistry.Heatexchangerdamageorfailureresultingfromimproperow,improperlybalancedpool

waterortheimproperadditionofsanitizersintothewaterisNOTcoveredunderthetermsofyourwarranty.

Thefollowingfactorsarecriticaltoheatexchangerprotection.Followtheseguidelinestohelpprevent

pre-maturedamageorfailuretoyourheaterandheatexchanger.

1. WATER FLOW THROUGH HEATER

 Watermustbeowingthroughtheheaterattheminimumratedowrateduringoperation.Checkthat

thepumpisoperatingandthesystemislledwithwaterandpurgedofallairpriortostartingtheheater.The

minimumratedowratesarelistedintheinstallationmanualonpage26.Someinstallationsmayrequirean

adjustmenttothewaterpressureswitchforproperlow-owprotection.Testyoursystemandifnecessary,

adjustthewaterpressureswitchasdescribedintheinstallationmanualonpage36.

2. POOL/SPA WATER CHEMISTRY

 Thechemistrybalanceandmineralcontentofswimmingpoolwaterchangesdailyduetotheadditionof

poolandsanitizingchemicals,batherloads,rain,runoffandtheamountofsun-tonameafew.Improperchem-

istrybalanceandmineralcontentcancausescalinganddepositstoformonpoolwalls,intheltrationsystem,

intheheatexchangertubesandadditionallycanpromotecorrosiveactiontoallmetalsinthewaterpath.Chang-

ingspawaterregularlyandmaintainingthecorrectchemicalbalanceinyourpool/spawillkeepthepool/spa

safeandsanitary,andwillhelpprotecttheheatexchanger.Usea4-waypool/spawatertestkittocheckyour

waterfrequently(atleastweekly).Usethefollowingguidelinestohelpprotectyourheater’sheatexchanger:

3. SKIMMER CHLORINATION

 Placingchlorineorbrominetabletsdirectlyintotheskimmermayresultinhighchemicalconcentrations

owingthroughtheheater.DONOTplacechlorineorbrominetabletsintheskimmer.

WARNING: Failure to Maintain Proper Water Chemistry May Cause

Premature Heat Exchanger Damage or Failure

MAINTAINING PROPER WATER CHEMISTRY

Recommended

LevelEffect of Low Levels Effect of High Levels

Chlorine1 - 3 ppm

Bromine 2 - 4 ppm

pH 7.4 - 7.6corrosive to heat exchanger,

swimmer irritation

cloudy water, scaling of heat exchanger,

reduced sanitizer effectiveness

Total Alkalinity80 - 120 ppm corrosive to heat exchanger,

large fluctuations in pH scaling of heat exchanger

Calcium Hardness 200 - 400 ppm corrosive to heat exchangerscaling of heat exchanger

Salt 2700 - 5000 ppm poor salt chlorinator performancecorrosive to heat exchanger

hazy water, algea growth,

bacteria causing infections

swimmer irritation, bleaching of clothes/hair,

corrosive to heat exchanger

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

New Figure 1 for UHS owner manual page 9:

Figure 1

New text for UHS owner manual page 11:

TEMPERATURE ADJUSTMENT

This pool heater is equipped with a digital thermostat which allows the user to select the desired

water temperature. The heater will then function automatically to maintain the desired

temperature. The heater has 3 modes of operation:

1. STANDBY: in this mode, the heater will not function to heat the water.

2. SPA: in this mode, the heater will automatically function to maintain the water

temperature setting for SPA mode.

3. POOL: in this mode, the heater will automatically function to maintain the water

temperature setting for POOL mode.

Use the MODE button to change modes. The indicator lights will illuminate to show which mode

the heater is currently in. Each mode has its own temperature setting, allowing the user to have

2 individual pre-set temperature settings. To adjust the temperature while in SPA or POOL

mode, use the UP and DOWN buttons. The numeric display will flash to indicate the

temperature setting is being displayed / adjusted. When the numeric display is not flashing, the

actual water temperature is being displayed. The temperature settings for both SPA and POOL

modes are initially set at the factory to 65°F. The minimum allowed settings for SPA and POOL

modes are both 65°F. The maximum allowed settings for SPA and POOL modes are adjustable

up to 104°F using the temperature lockout feature (see below).

After selecting SPA or POOL mode or adjusting the temperature setting, it is normal for the

heater to delay up to 10 seconds before the heater starts operating. This delay is an internal

self-test of the heater. On occasion, the numeric display may show a diagnostic error code;

refer to list of diagnostic error codes in Figure 4. Pressing the MODE button to cycle to

STANDBY and back to SPA or POOL will clear a diagnostic error code. When clearing a

User Interface

Keypad

Front Access

Panel

WARNING:Ifyousmellgasintheapplianceareaorneartheoor(PROPANEIS

HEAVIERTHANAIRANDHENCESETTLESONTHEFLOOR),stopandfollow

theinstructionsonthefrontcoverofthismanual.Sincepropanecanaccumulateincon-

nedareas,extracareshouldbetakenwhenlightingpropaneheaters.

ATTENTION:Donotusetheheaterbelow40°F(4°C)temperaturewithoutadequatetemperatureprotection.

WARNING:Donotingestalcoholordrugsduringuseorpriortousingpool,spa,orhottub.Ingestionofsuch

intoxicantscancausedrowsiness,whichcanleadtounconsciousness,andsubsequentlyresultindrowning.

4. CHLORINATOR INSTALLATION

 Chlorinatorsmustbeinstalleddownstreamoftheheater,andacheckvalvemustbeinstalledbetweenthe

heaterandchlorinatortopreventhighchemicalconcentrationsfrombackowingintotheheater.Makesureyour

pipingarrangementmeetsthechlorinatorinstallationrequirementsshownintheinstallationmanualonpage26.

5. BYPASS

Untilwaterchemistryisproperlybalanced,andifyourpipinghasabypassvalveinstalledfortheheater,

openthebypasssothatcorrosiveandpotentiallydamagingwaterwillnotowthroughtheheaterandthere-

foretheheatexchanger.Closethebypassvalveoncethewaterisproperlybalanced.Failuretoclosethe

bypassvalvewhenattemptingtooperatetheheaterwillresultinextensivedamagetotheheatexchanger.

Ensurewaterowthroughtheheaterisrestoredbeforeoperatingtheheater.Abypassfeatureisalsoadvanta-

geousforserviceneedsandfortheabilitytoremovetheheaterfromthewaterpathwhennotheating.Refer

topage26intheinstallationmanualforfurtherinformation.

HEATER OPERATION:

Fulllightingandshutdowninstructionsareincludedonthelighting&operatinginstructionslabelafxed

totheinsideofthefrontaccesspanel.SeeFigure1forthelocationofthislabelandthekeypad.SeeFigure2

forthelabel.

Figure1:Keypadandlabellocations

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

Figure2:Lighting&OperatingInstructionslabel

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

TEMPERATURE ADJUSTMENT

Thispoolheaterisequippedwithadigitalthermostatwhichallowstheusertoselectthedesiredwater

temperature.Theheaterwillthenfunctionautomaticallytomaintainthedesiredtemperature.Theheaterhas

3modesofoperation:

1. STANDBY:inthismode,theheaterwillnotfunctiontoheatthewater.

2. SPA:inthismode,theheaterwillautomaticallyfunctiontomaintainthewatertemperaturesettingfor

 SPAmode.

3. POOL:inthismode,theheaterwillautomaticallyfunctiontomaintainthewatertemperaturesetting

 forPOOLmode.

UsetheMODEbuttontochangemodes.Theindicatorlightswillilluminatetoshowwhichmodethe

heateriscurrentlyin.Eachmodehasitsowntemperaturesetting,allowingtheusertohave2individual

pre-settemperaturesettings.ToadjustthetemperaturewhileinSPAorPOOLmode,usetheUPandDOWN

buttons.Thenumericdisplaywillashtoindicatethetemperaturesettingisbeingdisplayed/adjusted.When

thenumericdisplayisnotashing,theactualwatertemperatureisbeingdisplayed.Thetemperaturesettings

forbothSPAandPOOLmodesareinitiallysetatthefactoryto65°F.TheminimumallowedsettingsforSPA

andPOOLmodesareboth65°F.ThemaximumallowedsettingsforSPAandPOOLmodesareadjustableup

to104°Fusingthetemperaturelockoutfeature(seenextsection).

AfterselectingSPAorPOOLmodeoradjustingthetemperaturesetting,itisnormalfortheheaterto

delayupto10secondsbeforetheheaterstartsoperating.Thisdelayisaninternalself-testoftheheater.On

occasion,thenumericdisplaymayshowadiagnosticerrorcode;refertolistofdiagnosticerrorcodesin

Figure4.PressingtheMODEbuttontocycletoSTANDBYandbacktoSPAorPOOLwillclearadiagnostic

errorcode.Whenclearingadiagnosticerrorcodethisway,itisnormalfortheheatertodelayupto5seconds

beforeresumingnormaloperation,assumingthediagnosticerrorcodedoesnotre-appear.

diagnostic error code this way, it is normal for the heater to delay up to 5 seconds before

resuming normal operation, assuming the diagnostic error code does not re-appear.

Figure 3: User interface keypad

TEMPERATURE LOCK-OUT

The digital thermostat in this pool heater allows the user to lock the maximum temperature

setting allowed. This feature is useful for preventing unauthorized users from manually adjusting

the temperature settings higher than desired. On a new heater, the maximum allowed

temperature lock settings are initially set at the factory to 90°F for POOL mode, and 104°F for

SPA mode. To adjust these settings, use the following procedure:

1. Use the MODE button to put the heater in STANDBY mode.

2. Press and hold both the UP and DOWN buttons at the same time.

3. After 3 seconds, the thermostat enters maximum temperature lock adjustment mode.

4. The SPA indicator light illuminates and the numeric display shows the current SPA mode

maximum temperature lock setting. Both the SPA indicator light and the numeric display

flashes rapidly when in adjustment mode.

5. Use the UP and DOWN buttons to set the desired maximum temperature lock setting.

When finished, press the MODE button.

6. The POOL indicator light illuminates and the numeric display shows the current POOL

mode maximum temperature lock setting. Both the POOL indicator light and the

numeric display flashes rapidly when in adjustment mode.

7. Use the UP and DOWN buttons to set the desired maximum temperature lock. When

finished, press the MODE button.

8. The heater will return to STANDBY mode.

Numeric Display

Buttons

Indicator Lights

Figure3:Userinterfacekeypad

TEMPERATURE LOCK-OUT:

Thedigitalthermostatinthispoolheaterallowstheusertolockthemaximumtemperaturesettingallowed.

Thisfeatureisusefulforpreventingunauthorizedusersfrommanuallyadjustingthetemperaturesettingshigher

thandesired.Onanewheater,themaximumallowedtemperaturelocksettingsareinitiallysetatthefactoryto

90°FforPOOLmode,and104°FforSPAmode.Toadjustthesesettings,usethefollowingprocedure:

1. UsetheMODEbuttontoputtheheaterinSTANDBYmode.

2. PressandholdboththeUPandDOWNbuttonsatthesametime.

3. After3seconds,thethermostatentersmaximumtemperaturelockadjustmentmode.

4. TheSPAindicatorlightilluminatesandthenumericdisplayshowsthecurrentSPAmodemaximum

 temperaturelocksetting.BoththeSPAindicatorlightandthenumericdisplayashesrapidlywhenin

 adjustmentmode.

5. UsetheUPandDOWNbuttonstosetthedesiredmaximumtemperaturelocksetting.Whennished,

 presstheMODEbutton.

6. ThePOOLindicatorlightilluminatesandthenumericdisplayshowsthecurrentPOOLmodemaximum

 temperaturelocksetting.BoththePOOLindicatorlightandthenumericdisplayashesrapidlywhenin

 adjustmentmode.

7. UsetheUPandDOWNbuttonstosetthedesiredmaximumtemperaturelock.Whennished,pressthe

 MODEbutton.

8. TheheaterwillreturntoSTANDBYmode.

FAHRENHEIT VERSUS CELSIUS:

ThetemperaturecanbedisplayedinFahrenheitorCelsius.TOchangethedisplay,usethe“MODE”button

toplacetheheaterin“STANDBY”.Thenpressandholdthe“UP”and“MODE”buttonsuntilthedisplayshows

the°F/°Cselection.Pressthe“DOWN”buttontotogglebetweenselections.Toaccepttheselection,pressthe

“MODE”button.Iftheuserdoesnotact,theselectionwillbeautomaticallyacceptedafter60seconds.

WINTERIZATION:

Inmoderateclimates,theheatercancontinuetooperateduringshort-termcoldspells.Donotusethe

heatertomaintainthewatertemperaturejustabovefreezingorforfreezeprotection.Caremustbetakento

avoidfreeze-upintheheater.Whenitisusedduringfreezingweather,thepumpmustruncontinuously.The

heaterisnotwarrantedagainstfreeze-ups.Inregionswherefreezingtemperaturesareencountered,allwater

mustbedrainedfromtheheaterwhenitisoutofservice,topreventdamagetotheheaterandpiping.Drain-

ingtheheatexchangerisrecommendedaspartoftheseason’sshutdownprocedures.

SPRING START-UP – CONSULT A PROFESSIONAL:

1. Inspectandcleantheheater,beingsuretheheaterisfreeofleavesanddebrispriortostartup.

2. Besureinletandoutletpipingareproperlyattachedtotheheaterandthedrainvalveisclosed.

3. Turntheltrationsystempump“ON”andallowthesystemtorunlongenoughtopurgealltheair

fromthelines.

4. Turnthegassupplytotheheater“ON”.

5. Setthetemperaturecontrolusingthekeypadto“POOL”or“SPA”andadjustthesetpointtothe

desiredtemperaturesetting.

6. Ifoperatingdifcultiesareencountered,contactaqualiedservicecompanyforassistance.

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

Figure4:ERROR CODES

ERROR CODES:

Figure4liststheerrorcodesthatmaybedisplayedontheheaterdisplayboard.

Contactaqualiedservicecompanyforassistance.

Code Description Information

bD Internalfault/power-up

error

Oninitialtrialforignition.Automaticresetisimmediateoncethegasvalverelay

checkresultsareacceptable.

Gasvalvesensed

as“ON”error

Ifvalveisopenwhenitshouldbeclosedtheheaterwillshutdownandgointo

lockout.Blowerwilloperateuntilerrorconditioniscorrected.Automaticrestart

2minutesaftererroriscorrected.

Gasvalvesensed

as“OFF”error

Ifvalveisclosedbutameissensedtheblowerwillrunfor5sthenstartanew

ignitionsequence.Iferroroccurs10timesduringacallforheatthecontrolwill

gointolockout.Automaticresetis60minutes.

bD Dataretrievalerror Ifcontrolinputdataiscorruptedtheheaterwillshutdownandgointolockout.

Flamepresentwithgas

valve“OFF”error

Ifameissensedwiththegasvalveoffthecontrolwillgointolockout.The

blowerwillrununtilerrorconditioniscorrected.Whencorrected,controlwill

runblowerfor5sthenautomaticallyrestartafter2minutes.

PF Electricalsupplywiring

error

Thiscodewilldisplayif120Vpolarityisreversed,lowvoltageisdetected,orif

thegroundpathisnotsufcient.Resetisimmediateaftererroriscorrected.

Blowervacuumswitch

openerror

Iftheblowerproverswitchdoesnotcloseaftertheblowerstartsthecontrolwill

stoptheignitiontrialgointolockout.Theblowerwillcontinuetorun.Automatic

resetisimmediateaftertheswitchcloses.

Blowervacuumswitch

openwhenexpected

closederror

Iftheblowerproverswitchopensunexpectedlyduringoperationthecontrolwill

shutdownandattempttore-light.Iftheswitchdoesnotcloseaftertheblower

startsthecontrolwillgointolockoutwiththeblowerrunning.Automaticresetis

immediateaftererroriscorrected.

Blowervacuumswitch

openduringpost-purge

error

Iftheblowerproverswitchopensduringthepostpurgecycle(heaterisnotr-

ing)thecontrolwilldisplaytheerrorcode.Thepost-purgecyclewillbecom-

pletedoncetheblowerproverswitchcloses.

Blowervacuumswitch

closedwhenexpected

openerror

Iftheblowerproverswitchisclosedbeforeblowerstart-upthecontrolwillnot

starttheblower.Automaticresetisimmediatewhentheswitchopens.

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

Figure4:ERROR CODES(continued)

Code Description Information

Igniteropenerror Ifthecontrolisnotinlockoutandsensesthattheignitercircuitisopenwhenthe

blowerisrunningthecontrolwillturnofftheblowerandgointolockout.Auto-

maticrestart2minaftererroriscorrected.

Thermistorerror Anexcessivetemperaturedifferencebetweenthetwothermistors(5°Formore)

oran“outofbounds”conditiononbothsensors(lessthan10°Forgreaterthan

180°F)willresultintheerrorcode.Automaticrestartis2minutesaftertheerror

iscorrected.

WaterTemperature

SensingError

A)Inletwatertemperaturesensorisreportingatemperatureinexcessof104°F.

Normaloperationresumes2minutesafterinletwatertemperaturesensorreports

temperaturesof104°Forless.Thiserrorfunctionsinbothnormalandremote

thermostatmodes.

B)Inletwatertemperaturesensorisreportingatemperaturechangeatarate

fasterthan6°Fin60seconds,indicatingapotentiallydamaginglowwaterow

conditon.Normaloperationresumeswhentemperaturesstabilize.Ifthiscondi-

tionisdetected3timesinaonehourperiod,theheaterwilllock-outuntilthe

electricalpoweriscycledoffandbackon.

Keypadbuttonstuck

closederror

Ifoneofthekeypadbuttonsisclosed(orpressed)formorethan30stheerror

codewillbedisplayedbutthecontrolwillcontinuetofunction.Theerrorcode

willbeclearedwhentheconditioniscorrected.

IF Ignitionfailureerror Ifthecontrolexceedsthemaximumnumberofignitionretriesorrecyclesthe

heaterwillshutdownandgointolockout.Automaticresetis60minutes.

Communicationerror Ifcommunicationbetweentheignitionboardandthedisplayboardisnotestab-

lishedwithin3sofpower-upanerrorwillbedisplayed.Aftercommunicationis

established,ifitislostfor30s,theerrorwillbedisplayed.Theerrorcodewill

becleareduponavaliddataexchangebetweenboards.

Limitstringopenerror Ifthelimitstringopenstheheatershutsdownandgoesintolockout.Automatic

restartis2minutesaftertheerrorconditioniscorrectedandthelimitstring

closes.Seebelowformoredetail.

EE EEPROMERROR Anerrorwasdetectedintheignitioncontrolcircuitboard.

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

HAYWARD POOL HEATER CERTIFICATE OF LIMITED WARRANTY

Limitedheaterwarranty:

TERMSANDCOVERAGE:Wewarrantourpoolheatertobefreefromdefectsinworkmanshipandmateri-

alsundernormaluseandservice.PursuanttothiswarrantyandsubjecttotheConditionsand

Exceptionsindicatedbelow:

 1.Wewillreplace(costoffreight,installation,costoffuel,andservicelaboratuser’sexpense)with

theprevailingcomparablemodel,or,atouroption,repairanypool/spaheaterthatleaksundernor-

maluseandservicewithinoneyearfromthedateoforiginalinstallationforallusers.

 2.Inaddition,wewillreplace(costoffreight,installation,costoffuel,andservicelaboratuser’s

expense)or,atouroption,repairanypartorpartsofthepool/spaheaterwhichmalfunctionsunder

normaluseandservicewithinoneyearfromthedateoforiginalinstallationforallusers.

LIMITATION ON IMPLIED WARRANTIES:WEARENOTLIABLEFORANYCONSEQUENTIAL

DAMAGESFORBREACHOFANYWRITTENORIMPLIEDWARRANTYOFTHISPRODUCT.Im-

pliedwarranties,includingtheWARRANTYofMERCHANTABILITYandallotherimpliedwarranties

thatmayarisefromcourseofdealingorusageoftradeimposedonthesaleofthisheaterunderlawsofthe

statearelimitedindurationtothetermofone(1)yearforallproductswhenproductsareNOTinstalledand

servicedbyalicensedandqualiedpoolequipmentprofessionalwithallsufcientexperienceinpoolequip-

mentinstallationandmaintenanceandadheringtotherequirementsofthejurisdictionwheretheproductis

installed.

Warrantyextendsindurationtothetermof(2)yearsforallnon-ASMEcertiedproductsandthree(3)years

forallASMEcertiedproductsONLYwhenproductsareinstalledandservicedbyalicenesedandqualied

poolequipmentprofessionalwithsufcientexperienceinpoolequipmentinstallationandmaintenanceand

adheringtotherequirementsofthejurisdictionwheretheproductisinstalled.Therearenowarrantieswhich

extendbeyondthedescriptiononthefacehereof.Weshallnotinanyeventbeheldliableforanyspecial,

indirectorconsequentialdamages.

EXPENSE OF DELIVERY AND INSTALLATION:

Eachpoolheaterorreplacementparttobefurnishedunderthiswarrantyshallbefurnishedatournearest

distributioncenter.Weshallnotpay,norberesponsibleforshippingordeliverychargestotheplaceofinstal-

lation,norforlaborchargesorothercostsofremovalorinstallation.Everydefectiveheaterorpartreplaced

underthiswarrantyshallbecomeourproperty,andassuch,mustbereturnedtoourdistributioncenterwith

transportationchargespaidbytheuser.Anyreplacementpoolheaterfurnishedunderthiswarrantyshallre-

maininwarrantyonlyfortheunexpiredportionofthiswarranty.

CONDITIONS AND EXCEPTIONS:

Thiswarrantyappliesonlytothepool/spaatitsoriginalplaceofinstallationandonlyfortheoriginalowner.

Itdoesnotapplyifthepoolheaterisinstalledinviolationofanyapplicablecodeorordinance,orisnot

installed,operatedandmaintainedinaccordancewithourinstructions,orismisused,damagedbyaccident,

weather,actofGod,freezing,watervoidand/orexcesspressure,alteredordisconnected.Itdoesnotapply

withrespectto:

 1.AheaternotequippedwithCertiedC.S.A.limitcontrolsorequivalentpressurereliefvalve.

 2.Aheateroperatedwithsettingsinexcessof,and/orwithfuelnotconformingtothoseshownonrat-

ingplate;

 3.Aheateronwhichtheserialnumbershavebeenaltered,defaced,orremoved.

 4.Leaksarisingfromdefectiveinstallation;

 5.Productionofnoise,odors,ordiscolored(rusty,etc.)water;

 6.Leakagesubstantiallycontributedtobysediment,limeprecipitateand/orhigherthannormaldis-

solvedsolids(pHabove7.8)inthetank,coppertubes,orwaterways;

 7.Leakagecausedsubstantiallycontributedtobycorrosiveelementsintheatmosphere(suchasthe

storageofchlorineorotherchemicals);

Pomona, CA Clemmons, NC Nashville, TN

Tel: 908-351-5400 www.haywardpool.com

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

 8.Leakagecausedsubstantiallyorcontributedtobycorrosivepoolwaterinanacidcondition(pHbelow7.2);

 9.Damagecausedsubstantiallyorcontributedtobyanexternalsourceofenergy;

 10.Apool/spaheaterisawatercontainingdevice.Leakageofwaterfromthisdevicecanbeexpected

atsometimeduetomalfunctionorthelimitationsoftheservicelifeofvariouscomponents.

Donotinstallthisproductwheresuchleakagecancausedamage.MANUFACTURERISNOTRESPON-

SIBLEORLIABLEFORANYCOSTSINCURREDBYSUCHDAMAGE.

IN NO CASE ARE WE TO BE HELD LIABLE FOR DAMAGE

TO SURROUNDING AREA OR PROPERTY

CAUSED BY LEAKAGE OR MALFUNCTION.

HOW TO CLAIM UNDER THIS WARRANTY:

Theoriginalowner,upondiscoveringthedefect,mustpresenttheattachedcompletedwarrantyclaimcard

withproofofpurchaseeithertothedealerornotifytheCompanyinwritingateitheraddress:

HAYWARD POOL PRODUCTS, INC.

620 DIVISION ST.

ELIZABETH, NJ 07207

HAYWARD POOL PRODUCTS, INC.

2875 POMONA BOULEVARD

POMONA, CA 91768

Uponreceiptofsuchnoticationweshalldecidewhethertorepairsuchpartsorreplaceanypoolheater,

reservingatalltimestherighttoinspectinordertoverifyanyclaimeddefect.Wealsoreservetherightto

haveourrepresentativesmakeanyinspections,repairs,ortofurnishreplacements.Thiswarrantyisintended

asalegallybindingobligationoftheCompany,enforceableinthecourts.Thiswarrantymaygiveyouspe-

ciclegalrightswhichmayvaryfromstatetostate.

LIMITATION ON LIABILITY:

Allintendedrepresentationshavebeenexpresslysetforthinthisdocument.Thiswarrantymaynotbe

extendedbyoraloranyotheradditionalrepresentations,writtensalesinformation,drawings,orothermal-

function,isstrictlylimitedtorepairorreplacementofthedefectiveheaterorpart,asprovidedhereinand

theCompanyisnotresponsiblehereunderforincidentalorconsequentialorincidentalcostsordamages.

Thecompanyneitherassumes,norauthorizesanypersonorrmtoassumeforus,anyfurtherliabilityor

obligationinconnectionwiththesale,installation,use,maintenance,orexistenceoftheheater.SAFETY

WARNING:Poolheatersareheatproducingappliancesandtoavoiddamageorinjuryintheeventofpos-

sibleoverheatingoftheouterjacket(1)nomaterialsshouldbestoredagainstthejacketand(2)careshould

betakentoavoidunnecessarycontact(especiallybychildren)withthejacket.Whenlightingagasheater,the

lightinginstructionsmustbefollowedexactlytoprevent“ashback”ofexcessgasintheheater.Electronic

ignitionheatersandelectricheatersmusthavethepowershutoffwhenmakingadjustmentsto,servicing,or

comingintocontactwiththeheater.UNDERNOCIRCUMSTANCESSHOULDFLAMMABLEMATERI-

ALS,SUCHASGASOLINEORPAINTTHINNERS,BEUSEDORSTOREDINTHEVICINITYOFTHE

HEATERORINANYLOCATIONFROMWHICHFUMESCOULDREACHTHEHEATER.Foryour

comfort,enjoymentandsafety,pleasereadtheenclosedoperatinginstructionscarefully.

HAYWARD POOL HEATER CERTIFICATE OF LIMITED WARRANTY (CONTINUED)

Hayward H350FDP Owner's manual

Brand: Hayward

Model: H350FDP

Category: Above ground pool accessories

Type: Owner's manual

Download PDF

report

Hayward H350FDP Owner's manual

Hayward H350FDP Owner's manual

Related papers

Other documents