Huffy 16” Green Machine Junior Owner's manual

Huffy
Brand
Huffy
Model
16” Green Machine Junior
Type
Owner's manual

This manual is also suitable for

Owner’s Manual
16” Green Machine
Assembly Instructions
Date of Purchase: ___________________
Please write the date of purchase.
You should also retain the sales receipt.
THIS DOCUMENT CONTAINS IMPORTANT SAFETY INFORMATION.
READ AND KEEP FOR FUTURE REFERENCE.
Date Code Label
Here
HGM-16 EN-AU 050615 m0023
Copyright Huffy Corporation 2015
EN
AU
2 2
PLEASE READ AND FULLY UNDERSTAND THIS OWNERS MANUAL BEFORE OPERATING THE PRODUCT
This symbol is important. It is the WARNING symbol. The warning symbol precedes safety instructions. Failure to fol-
low these instructions may result in injury to the rider or to others, or damage to the product.
All wheeled vehicles will provide safe, enjoyable transportation and recreation when used and maintained properly. Like
bicycling, skateboarding, and in-line skating, riding can be dangerous even under the best of circumstances. We do not want
you to get hurt. Please follow all safety rules and operating instructions.
This toy should be used with caution since skill is required to avoid falls or collisions causing injury to the user or third par-
ties.
WARNING - TO AVOID SERIOUS INJURY:
• Adult assembly is required.
• Continuous adult supervision is required.
• Product does not have a brake - operator back pedals to slow or stop.
• Ensure rider can reach the pedals through full range of motion.
• Always wear a CPSC approved helmet while riding, with the chinstrap securely fastened.
• Always wear shoes when riding.
• Ride on smooth paved surfaces. Do not ride on streets or roadways.
• Always comply with local laws and regulations.
• Never use near motor vehicles.
• Do not ride on hills, steeply sloped areas, on or near steps, near swimming pools, or in alleys.
• Do not ride the product at dusk, at night or at times of limited visibility.
• Do not ride off road, on grass or wet surfaces.
• Do not ride the product over curbs or bumps that can damage the steering mechanism.
• Do not ride the product without the ag installed.
• Do not wear headphones or anything else that would impair your ability to hear or see.
• Do not jump or ramp product.
Safety and Warning Information
3 3
• Do not tow the product.
• Do not pull any objects with the product.
• Do not push the product.
• Never ride with more than one person. Maximum weight is 80 lbs (36Kg).
• This product should only be used by persons 5+ years of age.
• Excessive weight may cause a hazardous or unstable condition.
• Replace worn or broken parts immediately.
• If anything does not operate properly, discontinue use.
• Understand all operating procedures before riding.
• Do not add a motor to the product.
• Do not modify the product.
• Before each ride check all screws and fasteners; re-tighten any that are loose. Replace any fasteners that are damaged.
• Know your limits. Be familiar with your abilities. Use common sense.
Safety and Warning Information - continued
4 4
Tools necessary for assembly:
Phillips screwdriver
The instructions in this manual refer to the right and left side of the product, these are dened from the rider position.
Do not discard any parts until the unit is completely assembled.
WARNING:
Wheels & Axle:
• The wing-nuts must be securely tightened to ensure rear wheels do not come loose from the axle.
• All hardware must be sufciently tightened to ensure it does not come loose.
Pivot Bolt:
Pivot hardware must be correctly installed to ensure they do not come loose.
Steering Function:
• Over tightening the steering linkage may prevent the steering from operating properly.
• Pulling back on the right lever, and pushing forward on the left lever will turn the product towards the right.
• Pulling back on the left lever, and pushing forward on the right lever will turn the product towards the left.
• Steering this product takes some practice. Ensure the rider can properly steer the product. Practice in an open area.
Seat:
Secure the seat bolt each time the seat is moved.
Flag:
The ag is provided to make the rider and the product more visible. Do not use the product without the ag installed.
Assembly Notes
5 5
(both sides)
(both sides)
LABEL SHEET
NOTE: APPLY LABELS PRIOR TO ASSEMBLY
001
“Huy” and “Green Machine” are registered trademarks of Huy Corporation
6 6
315
316
x 1
x 1
336
338
315
316
341
315
316
341
341
301
305
300
337
WING BOLT MUST BE FULLY TIGHTENED BY HOLDING WING BOLTS
AT BOTH ENDS OF AXLE.
note
note
note
346
(x2)
1
7 7
303
x 2
345
x 2
304
x 2
303
303
304
304
302
301
345
305
300
345
306
2
8 8
310
309
310
307
306
306
342
308
x 1 Limiter Pin
307
x 1
B
C
A
3
9 9
335
x 2
334
x 2
311
312
314
315
316
313
335
335
335
335
334
334
ENSURE BUSHING
IS IN PLACE BEFORE
ASSEMBLY
note
B
C
A
4
10 10
311
314
315
315
316
316
317
x 1
x 1
(both wheels)
WING BOLT MUST
BE FULLY TIGHTENED
BY HOLDING WING BOLTS
AT BOTH ENDS OF AXLE.
B
C
A
312
335
335
313
note
x 2
335
314
x 1
5
11 11
320
319
319
319
319
318
BA
DC
note
OPPOSITE SIDE
6
12 12
322
321
321
324
323
323
322
324
x 4
x 4
320
note
ROUND HOLES
note
HEX HOLES
ORIENTATION
OF NUT
note
7
13 13
325
310
310
RH
x 4
326
321323
LH
note
INSERT SCREWS FIRST
note
TURN UNIT UPSIDE DOWN
8
14 14
329
329
328
TOP
TOP
BOTTOM
BOTTOM
328
310
310
320
310
x 8
9
15 15
333
331
344
332
310
343
310
x 6
344
x 2
10
16 16
313
333
331
318
300
343
302
334
307
308
309
310
321
323
322
324
320
319
325
326
310
328
329
310
301
346
304
303
311
305
332
312
314
315
316
317
335
345
344
342
310
336
337
341
316
315
338
17 17
ASSEMBLY PARTS LIST
PAGE-ID No. DESCRIPTION PAGE-ID No. DESCRIPTION
Label Sheet 001 Label Sheet 4 315 Washer (x1)
1 300 Main Frame 316 Wing bolt (x1)
336 Left Arm 5 317 End Cap (x2)
337 Right Arm 314 Bushing (x1)
338 Steering Shaft 315 Washer (x1)
315 Washer (x1) 316 Wing bolt (x1)
316 Wing Bolt (x1) 312 Hub Cap (x1)
341 Cap (x2) 313 Tire (x1)
305 Steering Linkage Left 335 Bushing (x2)
301 Steering Linkage Right 6 318 Front Wheel
346 Bushing (x2) 320 Crank
2 302 Rear Frame 319 Crank Keeper (x4)
303 Washer (x2) 7 321 Keeper Plate (screw side)
304 Cap Nut (x2) 323 Keeper Plate (nut side)
345 Bushing (x2) 322 Screw (x4)
3 308 Steering Keeper 324 Nut (x4)
306 Steering Tube 8 325 Axle Bracket Right
342 Steering Limiter 326 Axle Bracket Left
307 Limiter Pin 310 Screw (x4)
309 Cap 9 328 Top Pedal (x2)
310 Screw (x1) 329 Bottom Pedal (x2)
4 311 Axle Shaft 310 Screw (x 8)
312 Hub Cap (x1) 10 331 Seat
313 Tire (x1) 332 U-Bolt
335 Bushing (x2) 333 Flag
334 Bushing Insert (x2) 343 Fender
314 Bushing (x1) 310 Screws (x6)
344 Wingnut (x2)
18 18
Huffy Warranty Information
General:
• Part or model specications are subject to change without notice.
• This Limited Warranty is the only warranty for the product. There are no other express warranties.
• The only uses for this product are described in the Owner’s Manual, on the product or in any additional documents pro-
vided with the product. Warranty registration is not required.
• The Limited Warranty extends only to the original owner consumer and is not transferable to anyone else.
• All warranties are from date of purchase.
What does this Limited Warranty cover?
This Limited Warranty covers all parts.
What must you do to keep the Limited Warranty in effect?
This Limited Warranty is effective only if:
• the product is completely and correctly assembled;
• the product is used under normal conditions for its intended purpose (see the following section for excluded activities);
• the product receives all necessary maintenance and adjustments.
What is NOT covered by this Limited Warranty?
This product is designed for recreational use only. This Limited Warranty does not cover normal wear and tear, normal main-
tenance items, or any damage, failure, or loss that is caused by improper assembly, maintenance, adjustment, storage, or
use of the product.
This Limited Warranty will be void if the product is ever:
• Used in any competitive sport
• Used for stunt riding, jumping, aerobatics or similar activity
• Modied in any way
• Ridden by more than one person at a time
• Rented
• Used in a manner contrary to the instructions and warnings in the Owner’s Manual, on the product or in any additional
documents provided with the product.
19 19
Huffy Warranty Information - continued
The Limited Warranty does not apply to incidental or consequential loss or damage due directly or indirectly from use of this
product. Some States do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation
may not apply to you.
What IS covered by the Limited Warranty? (except as noted below)
Components determined by the manufacturer to be defective will be replaced, without charge to you.
What rights do you have?
This Limited Warranty gives you specic legal rights. You may also have other rights which vary from State to State.
How do you report a problem with this product or submit a warranty claim?
• Contact Consumer Service - See included list for Consumer Contact information.
In Australia or New Zealand:
The following text is incorporated into this Limited Warranty if this product was purchased in Australia (but it is not incorpo-
rated if such product was purchased in New Zealand):
Our goods come with guarantees that cannot be excluded under the Australian Consumer Law. You are entitled to a
replacement or refund for a major failure and for compensation for any other reasonably foreseeable loss or damage. You
are also entitled to have the goods repaired or replaced if the goods fail to be of acceptable quality and the failure does not
amount to a major failure.
Do not return to the place of purchase.
For Australia or New Zealand Warranty contact info, please see supplied contact sheet.
How long does this Limited Warranty Last?
Excluding the wheels, all components are warranted for six (6) months from the date of purchase.
• Helmet should sit level on your head and low on your forehead
• Adjust the strap sliders below the ear on both sides.
• Buckle the chin strap. Adjust strap until it is snug.
• No more than two  ngers should  t between the strap and your chin.
• A proper  tting helmet should be comfortable and not rock forward/backward or side to side.
• Always read the user manual that comes with your helmet to make sure it is  tted and attached
properly to the wearer’s head according to the  tting instructions described in the user manual.
Check www.Huffybikes.com/contact for the current contact information
WARNING:
ALWAYS WEAR YOUR HELMET WHEN
RIDING THIS PRODUCT!
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20

Huffy 16” Green Machine Junior Owner's manual

Huffy
Brand
Huffy
Model
16” Green Machine Junior
Type
Owner's manual
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents