Zoppas PCX37SB User manual

Brand: Zoppas

Model: PCX37SB

Type: User manual

This manual is also suitable for

PC37SB

Zoppas PCX37SB is a built-in refrigerator-freezer designed for both food storage and freezing. It features adjustable temperature controls for both the refrigerator and freezer compartments, allowing you to customize the temperature to your specific needs. The refrigerator compartment includes an interior light for easy visibility, while the freezer compartment has a fast freeze function for quickly freezing fresh foods. Additionally, the appliance has a reversible door design, making it suitable for a variety of kitchen layouts.

INDEX

Warnings 15

Installation 16

Changing the opening directions

of the doors and Panelling

Regulation and Control 18

How to use your

Refrigerator-Freezer

Maintenance of your

Refrigerator-Freezer

20 - 21

Something not working 22 - 23

Normal noises when

functioning

Guarantee, Service

and Spare Parts

Tecnical Features 26

WARNINGS

Warnings for your safety. Carefully read

these instructions before installing and

using the machine

m This freezer is designed to be operated by adults

only. Children should not be allowed to tamper

with the controls or play with the product.

m Any electrical work required to install the appliance

should be carried out by a qualified electrician or

competent person.

m This appliance is heavy. Care should be taken

when moving it.

m Make sure that the cable is not trapped underneath

the appliance, nor touches the motor.

m Repairs carried out by inexperienced persons may

cause injuries or serious malfunctioning. Refer to

the nearest Authorized Dealer.

m Make sure the rear part of the appliance stands

against a wall as there are working parts which

heat up and should not be of easy access.

m Make sure that there is a continous and adequate

ventilation as a failure to do so may result in dama-

ge to the appliance or deterioration of the food.

m The appliance should be left for at least 4 hours

after installation before it is turned on ill order to

allow the refrigerant to settle.

m This product must be serviced only by a AUTHO-

RIZED DEALER, and only GENUINE SPARE

PARTS must be employed.

m Before cleaning or reparing the appliance, make

sure it is unplugged.

m It is dangerous to alter the specifications or modify

this product in any way.

m These domestic refrigerators are designed to be

used specifically for the storage and conservation

of food.

m DO NOT USE SHARP INSTRUMENTS to scrap off

frost or ice. Frost may be removed by using a plas-

tic scraper. (See defrosting instructions).

m Frozen food must not be re-frozen once it has been

thawed out.

m Manufacturer’s storage recommendations should

be strictly complied with.

m Lollies can cause frost burns if consumed right

away from the freezer.

m Do not place carbonate or fizzy drinks in the free-

zer as these may explode.

m When and old freezer is to be discarded make sure

to:

m Dismount the doors in order to prevent children

from getting trapped inside.

Have the gas from the cooling system with-

drawn before making it to scrap iron.

INSTALLATION

Positioning

• Place the refrigerator away from direct sunlight and

heat sources.

• Maintain recommended ventilation – see Fig. 1.

• Make sure the refrigerator is accurately levelled tur-

ning the adjustable feet in order to avoid vibrations

and noises. Fig. 2.

• This is a built in design to be aligned with other fur-

niture.

• The appliance must be located in places of maxi-

mum temperature as follows:

+ 32°C for N Class, classification on identifiying

plate.

+ 43°C for T Class, classification on identifiying

plate.

If the temperatures are higher than these both above

mentioned, the functions of appliance could result

reduce.

Cleaning the interior

• Do not use alcohol or any cleanig product contai-

ning alcohol because it can damage the cabinet.

• Before using the appliance for the first time wash the

interior whith luke warm water and some neutral

soap so as to remove the typical smell of a brand-

new product arid then dry thoroughly.

• Do not use detergents or abrasive powders as these

will damage the finish.

• Remove security used for transportation.

Electrical connection

m Before plugging the appliance make sure that the

voltage and frequency shown on the «Technical

Features» correspond to your home spply.

m It is essention that the appliance be efficiently

earthed.

For this purpose the supply cable plug incorpora-

tes a special earth contact. If the sockets of your

domestic wiring system are not grounded, have

the appliance connected to a separate ground wire

in accordance with existing safety regulations.

«THE MANUFACTURER DECLINES TO ACCEPT

ANY LIABILITY IF THIS SAFETY RULE IS NOT

OBSERVED».

m Should a change of the supply cord be necessary,

remove the lid of the terminal board acting on «E»

and «F» as shown figure 3 in order to gain access

to the terminals. Fig. 3.

Starting-up

• Plug the appliance into the mains.

• Make sure the inner light «H» turns on when opening

the door.

• Turn to intermediate position the knob of the «tem-

perature regulator» «A» for refrigerating compart-

ment and «B» for freezing compartment.

Fig. 1

Fig. 2

Fig. 3

CHANGING THE OPENING DIRECTION OF DOORS AND PANELLING

If you wish to change the opening side of the doors

proceed as follows:

• Remove the handles of the doors, if they are side

fixing by screws (1).

• Take off the plinth pressed onto cabinet. (In some

models) (2).

• Remove the lower hinge taking care for the lower

door not to fall off (3).

• Lift the lower door off the central hinge (4).

• Remove the central hinge taking care for the upper

door no to fall off and not to lose the plastic washer

(5).

• Take the upper door off the upper hinge. Be carefull

not to lose the plastic washer (6).

• Unscrew the plastic plugs located on the opposite

side of the central hinge and introduce them in the

holes occupied before by the hinge (7).

• Unscrew the axle of the upper hinge and screw it

into the hinge on the opposite side. Make sure to fit

in the metal washer for blocking (8).

Place upper door.

For the remaining parts proceed the other way round.

Once finished make sure that all joints close per-

fectly well all around the door and check that the

internal light turns of when the fridge door closes.

How to panel the door

If your appliance is provided with metal strips for

panelling and you wish to do so proceed as follows:

• Remove one of the side strips.

• Loosen the screws of the remaining strips.

• Start putting on the panel where you took off the

strip pushing it right up to the end.

• Replace the strip on this side.

• Tighten all screws.

NOTE: The panel dimensions must be 2 mm. shorter

than the doors. Maximun thickness of the

panel is 4 mm.

REGULATION AND CONTROL

Temperature Regulator for Refrigerator:

«A»

Allows to adjust the temperature inside the refrigerator

according to use and external conditions.

• Pos. 1 = Minimum cold

• Pos. 6 = Maximum cold

• Pos. 0 = Motor disconnected

Temperature Regulator for Freezer: «B»

Allows to adjust the temperature inside the freezer

according to use and external conditions.

• Pos. 1 = Minimum cold

• Pos. 6 = Maximum cold

• Pos. 0 = Motor disconnected

Green light: «K» (Some models only).

This light is on when the fridge thermostat is set to

working position (1 to 6). It will turn off if the thermos-

tat is changed to stop position «0».

Orange light: «L» (Some models only).

Indicates that the freezer is on freezing mode (S).

Red light: «M» (Some models only).

When lighted indicates abnormal temperature condi-

tions in the freezer, but for the exceptions appearing

on Page «Freezing of Food» and Page «Something not

working».

Fridge green light: «P» (Some models only).

This light is on when the fridge thermostat is set to

working position (1 to 6). It will turn off if the thermos-

tat is changed to stop position «0».

Interior light: «H»

Comes on when opening the door of the refrigeration

compartment and shuts off when you close the refri-

gerator compartment.

When changing the light bulb, first remove the protec-

tive cover «X», by firmly holding the edge and pulling

it horizontally. (see point 3 «IF SOMETHING DOES

NOT WORK»).

HOW TO USE YOUR REFRIGERATOR-FREEZER

Freezer Compartment:

This freezer, marked , is suitable for

freezing food and permits long term storage of fro-

zen food.

Freezing of food:

Congelation has to take place in the shortest pos-

sible time, 24 hours maximum. For that you have to

proceed as follows:

• Push the button «N» to freeze fresh food.

• If the freezer was disconnected and empty, 3

hours before introducing the food to be frozen.

• If the freezer is already working and has food in it,

24 hours before putting in the food to be frozen.

• The maximum amount to be frozen in 24 hours is

that specified in «Technical Features».

• Put the food to be frozen into lower compartment of

freezer. The tray at the top can also be used for this

purpose.

• Red light «M» may be on for a few hours during fre-

ezing process.

• Switch-on time for this light will vary according to

amount of food being put in for congelation and

time while door remains open.

• Once 24 hours from the introduction of the food

have elapsed the congelation can be considered as

finished.

• Push the button «N» again in order to set the

appliance back to «conservation» mode.

Conservation of frozen food:

• For a safe storage of food the temperature inside the

freezer compartment should never rise above -

18°C.

• An automatic device regulates this temperature.

• Make sure the «Temperature Regulator» is in a

medium setting.

• However, it may sometimes be necessary (due to

poor ventilation, high room temperature, frequent

opening of the door…) to vary the setting of the

«Temperature Regulator».

• In case of an accidental stop of the appliance or a

power cut proceed as follows:

• Keep the doors closed at all events.

• Try to find out for how long the failure is goint to last.

• Once normality is reestablished:

A) If the freezer is full and the power failure is less

than «Temperature Rising Time» indicated for

each model in «Technical Features» no damage

has been done to the food store.

B) If the freezer is not full the cold will be lost in a

shorter time If thawing has not yet started proce-

ed as said in previous point.

C) If thawing has started, consume the food inme-

diately, or cook it and then freezen it again.

Refrigerator Compartment:

This compartment is meant for keeping drinks and

fresh food.

The inner temperature is quite equalized. Avoid

food touching inner walls, as the cold is being pro-

duced in there and the food could partly get frozen.

On the other hand this would prevent a good circula-

tion of the cold air.

This appliance is provided with an automatic defros-

ting divice. Therefore you might find sometimes a fine

layer of ice or water drops.

Useful Hints:

Do not introduce any new food during a freezing

period.

Do not put any newly introduced food for freezing

near to already frozen food.

Wrap the food up properly or place it in hermethic

recipies before introducing it into the freezer.

Do not introduce any hot food into the freezer.

Food and drinks of a strong flavour may pass this

on to others and affect their flavour. Wrap them up

adequately or put them into tight closing bags.

Follow the instructions given in the cook books,

freezing books and wrapping utensiles for better

conservation of food.

MAINTENANCE OF YOUR REFRIGERATOR-FREEZER

Prior to undertaking any maintenance operation,

be sure to unplug the appliance.

Defrosting of the freezer

The inner walls of the freezer become gradually cove-

red with a layer of frost keeping in mind not to open

the door frequently and keeping the food wrapped up

in closed bags.

Whenever the thickness of ice reaches 5 mm. the frost

should be removed. Hereto proceed as follows:

• Remove all food staff and place it in the coolest pos-

sible place.

• Place the Plastic Scraper (supplied with the applian-

ce) into the existing slot above the plinth.

• Place a bowl under the outlet to collect the water.

• Pull out the drawers and the upper tray.

• Under no circumstances should you try and tear off

the ice formed, wait for it to melt away.

• Once the ice eliminated and the appliance is clean

and dry, remove the plastic scraper and replace the

drawers and the upper tray.

• Plug in the appliance.

MAINTENANCE OF YOUR REFRIGERATOR-FREEZER

Defrosting of the refrigerator

Frost is automatically eliminated in the refrigerator.

Clean regularly the water drain opening «G», with its

accessory.

Cleaning

• Do not use alcohol or any cleaning product contai-

ning alcohol because it can damage the cabinet.

• Use lukewarm water and neutral soap or bicarbona-

te of soda for cleaning the interior and the exterior of

the appliance. Never use detergents nor abrasive

powders.

• Clean the black grill on the read of the appliance

(condenser), motor and the upper and downer ven-

tilation slots with a brush or vacuum cleaner. This

way the performance of the appliance will improve

and energy consumption reduced.

• Clean the water container above the motor.

• Extract the base pulling it outwards in order to per-

mit cleaning undermeath the appliance.

Idle periods

During periods when the appliance is not in use take

the following precautions:

• Unplug the appliance.

• Remove all the food.

• Defrost and clean the interior and all accessories.

• Leave the door ajar to permit the air to circulate in

the interior and thus avoid unpleasant smells.

SOMETHING NOT WORKING

PROBLEM CAUSE SOLUTION

A) LAMP AND INDICATORS

1. Green lamp does not come • Appliance not connected. • Plut it in.

on (if available). • No power at mains socket. • Check the domestic automatic

cut out.

2. The red light does not • Freezer is not properly closed. • Close the door. The light will

come off (if available). come off after a few hours.

• Freezer door has been open for • This is normal. Will come off

too long. after a few hours.

• The «Temperature Regulator of • This is normal. Will come off

the Freezer» has been recently after a few hours.

moved to a colder position.

• Food has been put into the freezer. • This is normal. Will come off

after a few hours.

• The layer of ice in the freezer is • Remove it according to

too thick. instructions.

3. Inner light (refrigerator • Appliance unplugged. • Plug the appliance into mains.

compartment) does not • No power at mains socket. • Check the domestic automatic

come on «H». cutout.

• Bulb loose or burnt out. • Tighten or substitute it for

another of same rating.

B) PERFORMANCE

1. The freezer or the • The appropriate «Temperature • Change «Regulator» to another

refrigerator do not cool. Regulator» is in position «0». position.

2. The freezer or the • Door not properly closed. • Close well.

refrigerator do not cool • The door has been opened • Avoid frequent opening.

enough. frequently.

• Inadequate position of «Temperature • Change position to a cooler one.

Regulator».

• Food has been introduced • The appliance will get back to

recently in large quantity. normal, wait.

3. Food gets frozen in the • «Temperature Regulator» in • Change position to less cold.

refrigerator. inadequate position.

• Food touches the back walls. • Bring food forwards.

Some functioning problems may be due to causes which can easily be solved before calling the Network

Service. Follow theses instructions:

SOMETHING NOT WORKING

PROBLEM CAUSE SOLUTION

4. The motor does not stop • «Temperature Regulator» in • Change position to less cold.

running. inadequate position.

• Door not properly closed. • Close the door correctly.

• Door opened frequently. • Avoid frequent opening.

• Food has been put in recently in • Wait for the appliance to come

large quantity. back to normal.

• «Temperature Regulator of Freezer» • This is normal.

in position «6».

C) WATER/ICE

1. Makes too much ice. • «Temperature Regulator» in • Chante position to less cold.

inadequate position.

• Door not properly closed. • Close correctly.

• Excessive door opening. • Avoid frequent opening.

2. Water in the lower part of • Drain blocked. • Clean duct «G».

the refrigerator.

3. Water in the vegetable box. • Wet vegetables have been • This is normal.

introduced.

4. The outside of the cabinet • High humidity level in the room. • This is normal. It does not affect

steams up. the performance of the appliance.

D) DOORS

1. Door does not close. • The appliance is not properly • Level smooth.

levelled.

• Door has been banged too hard • Never bang the door.

and bounces back.

• Food protrudes. • Place food properly.

• Drawers protrude. • Push them into place.

E) NOISES

• Appliance not properly levelled. • Level properly.

• Friction from back pipes. • Space well.

• Some fixing screw is loose. • Tighten the screw.

• Something inside is vibrating. • Place correctly.

• Others. • See next page.

NORMAL NOISES WHEN FUNCTIONING

1. Temperature Regulator

May cause cracking sounds when the system con-

nects or disconnects.

2. Refrigerating system

The gas used for cooling may produce a burbling

sound while running through the piping.

3. Compressor

May cause zumbing noises and/or slight bumping.

4. Insulation

The material used has a tendency to increase noises,

but it does insulate perfectly and is of low energy con-

sumption.

GUARANTEE, SERVICE AND SPARE PARTS

Together with the appliance you should reccive an ins-

truction booklet like this together with:

• A guarantee card«Certificato di Garanzia», with the

conditions of the guarantee printed on the back

• List «Centri di assistenza tecnica autorizzati».

This documentation should always be at hand for con-

sulting. Should this appliance be sold or transfered to

another user, make sure that this documentation stays

with the appliance so the new owner can be acquain-

ted with the functioning of the appliance and relevant

warnings.

TECHNICAL FEATURES

DIMENSIONS WITH

DOORS CLOSED

DIMENSIONS WITH

DOORS OPEN

This appliance complies with the following CEE Directives:

– 73/23 CEE of 19/02/73 (low voltage directive) and subsequent modifications.

– 89/336 CEE of 03/05/89 (electromagnetic compatibility directive and subsequent modifications.

DATA IN AGREEMENT WITH «UNE» REQUIREMENTS

MODEL

«A» (mm) 1.840 1.980

VOLTAGE (V) ±6% 220...230 220…230

FREQUENCY (Hz) 50 50

FREEZING CAPACITY (Kg/24h) 12 12

POWER CONSUMPTION (W) 150 150

TEMPERATURE RISING TIME (h) 15 15

593

610

1.175

«A»

600

90°

593

645

Zoppas PCX37SB User manual

Brand: Zoppas

Model: PCX37SB

Type: User manual

This manual is also suitable for

PC37SB

Download PDF

report

Zoppas PCX37SB User manual

This manual is also suitable for

Zoppas PCX37SB User manual

Related papers

Other documents