Gilson MAA-28 Operating instructions

Gilson
Brand
Gilson
Model
MAA-28
Category
Mixers
Type
Operating instructions

Gilson MAA-28 provides precise temperature control for consistent and repeatable mixing results. Its key features include:

  • Versatile temperature range: Heat liquids and solids up to 150°C (302°F) for a wide range of applications.
  • Accurate temperature control: Dial in the desired temperature with precision using the intuitive control knob.
  • Uniform heating: The heating mantle ensures even heat distribution, eliminating hot spots and ensuring consistent mixing.
  • Easy to use: Simply place the mantle around the mixing vessel and adjust the temperature. No complex setup or calibration is required.

Gilson MAA-28 provides precise temperature control for consistent and repeatable mixing results. Its key features include:

  • Versatile temperature range: Heat liquids and solids up to 150°C (302°F) for a wide range of applications.
  • Accurate temperature control: Dial in the desired temperature with precision using the intuitive control knob.
  • Uniform heating: The heating mantle ensures even heat distribution, eliminating hot spots and ensuring consistent mixing.
  • Easy to use: Simply place the mantle around the mixing vessel and adjust the temperature. No complex setup or calibration is required.
Rev: 08/29/2012
Heating Adapter Kit for MA-52X 5qt Mixers
MAA-29
PHONE: 800-444-1508 P.O. Box 200, Lewis Center, Ohio 43035-0200 FAX: 800-25 5-5314
740-548-7298 E-mail: customerservice@gilsonco.com Website: www.globalgilson.com 740 -548-5314
OPERATING MANUAL
FEATURES:
The MAA-29 Heating Adapter Kit includes:
• 250Wattheatingmantleappropriately1inthick,8ininside
diameterand3indeep.Suppliedwithelectricalleadand
Velcrostraps.
• Controllerfortheheatermantlewith0—100%proportional
heatingscale,12ampBusstypefuse,heat-onindicator
lightandpowercord.
• Connectingcordconnectsheatingmantletocontroller.
• PedestalSpacerKitwithdrilledmetalspacerblockand
four2inlong5/16-18HexBolts.
Ifanypartsaremissingordamaged,contactdeliveringcarrier
andGilsonCustomerServiceimmediately.
ASSEMBLY INSTRUCTIONS:
A. Installation of the Pedestal Spacer:
1. Turn mixerpowerswitch<OFF>and disconnectpower
cordfromwallreceptacle.
2. Removethebowlandbeater.
3. Laythemixerdownontheoppositesidefromthecontrol
panel,orturncompletelyupsidedown.Ifputonitsside,
thepedestalarmmustbesupportedtoholdthebowlheight
adjustmentleveroffthetabletop.Ifturnedupsidedown,
thepedestalarmmustbeclampedtostabilizethemixer
duringinstallationofthepedestalspacer.
4. RemovethefourPhillipsmachinescrewsconnectingthe
pedestalbasetothepedestalspacer.
5. Removeandsetasidethescreen.
MAA-29
(Continuedonback.)
6. Setthepedestalbaseaside.
7. Determine top-bottom orientation of the metal spacer
blockbymatchingthepedestalarmcontour.Thefourbolt
holesonthespacerareevenlyspaced.Thespacermust
beorientedcorrectlyfronttoback.
8. Alignthefourholesonthespacerblockwiththefourholes
onthepedestalarm.Next,alignthepedestalbaseover
thefourholesofthespacerbottom.Thenalignthescreen
overthebottomofthepedestalbase.Placeaboltineach
ofthefourholesandtightenwithasocketwrench.
9. Sitmixeruprightontable,installpaddleandbowl,plug
mixerbackintowallreceptacleandtestoperationofmixer
toensurespacerissecureandproperlyinstalled.Operate
mixerinaccordancewithmanufacturersinstructions.
NOTE: Modified mixers may no longer qualify for
applicationsinvolvingfood,cosmeticsorpharmaceuticals.
Checkwithallapplicableagenciesandcodesbefore
usingamodifiedmixerforthesepurposes.
B. Installation of the Heating Mantle:
WARNING!
The MAA-29 heating mantle is custom designed for
thisapplication.It is designed tofit only the stainless
steel 5qt mixing bowl of the MA-52X as supplied by
Gilson.DO NOTuseforalternatepurposes.Useforan
alternatepurpose,oralterationofthemantlewillcause
unsatisfactoryperformanceandwarrantytobevoided.
WARNING!
MAA-29 mantles are NOT intended for use with
flammablesorinhazardousareas.Heatingmantlesare
electricallyoperatedheatingdevices.Exposuretowater
willdamagethemantleandcancauseelectricalshock
totheoperator.ALWAYSdisconnectamantlefromit’s
power source beforehandling. DO NOT handle hot
mantles. MANTLES iN uSE ShOuLD NOT bE LEfT
uNATTENDED!
OPERATING INSTRUCTIONS:
Themantlecanbecenteredunderneaththe5qtmixerbowl
andallowedtorestpassivelyonthepedestalbase.Thisallows
theoperatortoraiseandlowerthebowloutofthemantleas
anadditionalcontroloverheatingcycles.
Themantlecanalsobeattachedtothemixerbowlsupport
arms.Themantlewillthentravelupanddownwiththemixing
bowl.PasstheVelcrostrapsontheheatingmantleoverthe
mixingbowlsupportarms.Drawthestrapsupsnug.
  • Page 1 1
  • Page 2 2

Gilson MAA-28 Operating instructions

Gilson
Brand
Gilson
Model
MAA-28
Category
Mixers
Type
Operating instructions

Gilson MAA-28 provides precise temperature control for consistent and repeatable mixing results. Its key features include:

  • Versatile temperature range: Heat liquids and solids up to 150°C (302°F) for a wide range of applications.
  • Accurate temperature control: Dial in the desired temperature with precision using the intuitive control knob.
  • Uniform heating: The heating mantle ensures even heat distribution, eliminating hot spots and ensuring consistent mixing.
  • Easy to use: Simply place the mantle around the mixing vessel and adjust the temperature. No complex setup or calibration is required.
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents