Gilson MAA-28 Operating instructions

Rev: 08/29/2012

Heating Adapter Kit for MA-52X 5qt Mixers

MAA-29

PHONE: 800-444-1508 P.O. Box 200, Lewis Center, Ohio 43035-0200 FAX: 800-25 5-5314

740-548-7298 E-mail: customerservice@gilsonco.com Website: www.globalgilson.com 740 -548-5314

OPERATING MANUAL

FEATURES:

The MAA-29 Heating Adapter Kit includes:

• 250Wattheatingmantleappropriately1inthick,8ininside

diameterand3indeep.Suppliedwithelectricalleadand

Velcrostraps.

• Controllerfortheheatermantlewith0—100%proportional

heatingscale,12ampBusstypefuse,heat-onindicator

lightandpowercord.

• Connectingcordconnectsheatingmantletocontroller.

• PedestalSpacerKitwithdrilledmetalspacerblockand

four2inlong5/16-18HexBolts.

Ifanypartsaremissingordamaged,contactdeliveringcarrier

andGilsonCustomerServiceimmediately.

ASSEMBLY INSTRUCTIONS:

A. Installation of the Pedestal Spacer:

1. Turn mixerpowerswitch<OFF>and disconnectpower

cordfromwallreceptacle.

2. Removethebowlandbeater.

3. Laythemixerdownontheoppositesidefromthecontrol

panel,orturncompletelyupsidedown.Ifputonitsside,

thepedestalarmmustbesupportedtoholdthebowlheight

adjustmentleveroffthetabletop.Ifturnedupsidedown,

thepedestalarmmustbeclampedtostabilizethemixer

duringinstallationofthepedestalspacer.

4. RemovethefourPhillipsmachinescrewsconnectingthe

pedestalbasetothepedestalspacer.

5. Removeandsetasidethescreen.

MAA-29

(Continuedonback.)

6. Setthepedestalbaseaside.

7. Determine top-bottom orientation of the metal spacer

blockbymatchingthepedestalarmcontour.Thefourbolt

holesonthespacerareevenlyspaced.Thespacermust

beorientedcorrectlyfronttoback.

8. Alignthefourholesonthespacerblockwiththefourholes

onthepedestalarm.Next,alignthepedestalbaseover

thefourholesofthespacerbottom.Thenalignthescreen

overthebottomofthepedestalbase.Placeaboltineach

ofthefourholesandtightenwithasocketwrench.

9. Sitmixeruprightontable,installpaddleandbowl,plug

mixerbackintowallreceptacleandtestoperationofmixer

toensurespacerissecureandproperlyinstalled.Operate

mixerinaccordancewithmanufacturersinstructions.

NOTE:  Modified mixers may no longer qualify for

applicationsinvolvingfood,cosmeticsorpharmaceuticals.

Checkwithallapplicableagenciesandcodesbefore

usingamodifiedmixerforthesepurposes.

B. Installation of the Heating Mantle:

WARNING!

The MAA-29 heating mantle is custom designed for

thisapplication.It is designed tofit only the stainless

steel 5qt mixing bowl of the MA-52X as supplied by

Gilson.DO NOTuseforalternatepurposes.Useforan

alternatepurpose,oralterationofthemantlewillcause

unsatisfactoryperformanceandwarrantytobevoided.

WARNING!

MAA-29 mantles are NOT intended for use with

flammablesorinhazardousareas.Heatingmantlesare

electricallyoperatedheatingdevices.Exposuretowater

willdamagethemantleandcancauseelectricalshock

totheoperator.ALWAYSdisconnectamantlefromit’s

power source beforehandling. DO NOT handle hot

mantles. MANTLES iN uSE ShOuLD NOT bE LEfT

uNATTENDED!

OPERATING INSTRUCTIONS:

Themantlecanbecenteredunderneaththe5qtmixerbowl

andallowedtorestpassivelyonthepedestalbase.Thisallows

theoperatortoraiseandlowerthebowloutofthemantleas

anadditionalcontroloverheatingcycles.

Themantlecanalsobeattachedtothemixerbowlsupport

arms.Themantlewillthentravelupanddownwiththemixing

bowl.PasstheVelcrostrapsontheheatingmantleoverthe

mixingbowlsupportarms.Drawthestrapsupsnug.

Gilson MAA-28 Operating instructions

Related papers

Other documents