Bowflex VeloCore Bike User manual

8027841.081520.A

Service Manual

Table of Contents

Nautilus, Inc., www.NautilusInc.com, 5415 Centerpoint Parkway, Groveport, OH 43125 U.S.A. - Customer Service: North America (800) 605-3369, [email protected] | outside U.S.

ZZZQDXWLOXVLQWHUQDWLRQDOFRP_1DXWLOXV,QF_1DXWLOXVWKH1DXWLOXVORJR%RZÀH[WKH%ORJRDQG9HOR&RUHDUHWUDGHPDUNVRZQHGE\RUOLFHQVHGWR1DXWLOXV,QFZKLFKDUH

UHJLVWHUHGRURWKHUZLVHSURWHFWHGE\FRPPRQODZLQWKH8QLWHG6WDWHVDQGRWKHUFRXQWULHV2WKHUWUDGHPDUNVDUHWKHSURSHUW\RIWKHLUUHVSHFWLYHRZQHUV_

ORIGINAL MANUAL - ENGLISH VERSION ONLY

8027842.081520.A

%RZÁH[

™

VeloCore

™

Bikes

Service Manual

™

Section Code Section Page Number

  ,PSRUWDQW6DIHW\,QVWUXFWLRQV 

  6DIHW\:DUQLQJ/DEHOVDQG6HULDO1XPEHU 

1 FCC Compliance 3

  6SHFL¿FDWLRQV 

1 Maintenance 5

1 Checking the Drive Belt Tension 5

1 Moving/Storing the Machine 6

  /HYHOLQJWKH0DFKLQH 

1 Emergency Stop 7

1 Resistance Adjustment 7

  /HDQ0RGH 

1 Console 7

  +HDUW5DWH$UPEDQG 

1 Mounting/Dismounting 9

1 Adjustments 9

  /RFNLQJWKH)O\ZKHHOIRU6WRUDJH 

1 Demonstration Mode 11

  7URXEOHVKRRWLQJ 

  0DLQWHQDQFH3DUWV([SORGHG9LHZ 

  5HSODFHPHQW3URFHGXUH6NLOO/HYHO 

Mechanical Procedures

2 Adjust the Belt Tension 16

  $GMXVWWKH%XPSHU/HDQ7HQVLRQ 

Part Replacement

4 Replace the Crank Arm 24

  5HSODFHWKH/RZHU:LULQJ+DUQHVV 

  5HSODFHWKH0DVW'DWD&DEOH 

7 Replace the Resistance PCB 37

8 Replace the Speed Sensor 40

8027843.081520.A

Service Procedures

Important Safety Instructions

This icon means a potentially hazardous situation which, if not avoided, could result in death or serious injury. Read and

understand all Warnings on this machine.

Before servicing or using this equipment, obey the following warnings:

Read and understand the Service Manual before working on the machine. Failure to obey the instructions and safety warnings

could cause injury to the service technician or bystanders.

 .HHSE\VWDQGHUVDQGFKLOGUHQDZD\IURPWKHSURGXFWEHLQJVHUYLFHGDWDOOWLPHV

 0DNHVXUHWKDWWKHUHSDLULVGRQHLQDQDSSURSULDWHZRUNVSDFHDZD\IURPIRRWWUDI¿FDQGH[SRVXUHWRE\VWDQGHUV

 'LVFRQQHFWDOOSRZHUWRWKHPDFKLQHEHIRUH\RXVHUYLFHLW

 6RPHFRPSRQHQWVRIWKHHTXLSPHQWFDQEHKHDY\RUDZNZDUG(QOLVWWKHVHUYLFHRIDVHFRQGSHUVRQZKHQ\RXGRPDLQWHQDQFHVWHSVLQYROYLQJ

these components. Do not try to do heavy or awkward steps on your own.

 8VHRQO\UHSODFHPHQWSDUWVDQGKDUGZDUHWKDWDUHVXSSOLHGRUDSSURYHGE\1DXWLOXV)DLOXUHWRXVH1DXWLOXVDSSURYHGUHSODFHPHQWSDUWVFDQ

DGYHUVHO\DIIHFWWKHVDIHW\DQGIXQFWLRQDOLW\RIWKHHTXLSPHQWFUHDWLQJDULVNWRXVHUVDQGZLOOYRLGWKHZDUUDQW\

• Be sure that all warning stickers and instructional placards applied to the product stay present and in good condition when doing maintenance or

UHSODFLQJFRPSRQHQWV,IDWDQ\WLPHWKH:DUQLQJODEHOVEHFRPHORRVHXQUHDGDEOHRUGLVORGJHGUHSODFHWKHODEHOV,ISXUFKDVHGLQ86&DQDGD

FRQWDFW&XVWRPHU6HUYLFHIRUUHSODFHPHQWODEHOV,ISXUFKDVHGRXWVLGH86&DQDGDFRQWDFW\RXUORFDOGLVWULEXWRUIRUWKHP

 'RQRWWU\WRFKDQJHWKHGHVLJQRUIXQFWLRQDOLW\RIWKHPDFKLQHEHLQJVHUYLFHGDVWKLVFDQDGYHUVHO\DIIHFWXVHUVDIHW\

 'RQRWSXWWKHPDFKLQHEDFNLQVHUYLFHXQWLODOOVKURXGVLQVWUXFWLRQVZDUQLQJODEHOVDQGFRUUHFWIXQFWLRQDOLW\KDYHEHHQYHUL¿HGDQGWHVWHGIRU

FRUUHFWSHUIRUPDQFH

 6$9(7+(6(,16758&7,216

NOTICE:7KLVGRFXPHQWSURYLGHVLPSRUWDQWVDIHW\LQVWUXFWLRQVDGMXVWPHQWVDQGJHQHUDOWURXEOHVKRRWLQJLQIRUPDWLRQIRUWKHPDLQWHQDQFHRIWKH%RZÀH[

™

9HOR&RUH

™

DQG9HOR&RUH

™

ELNHV

If you need assistance, please call Nautilus Customer Service(if purchased in US/Canada) or your local distributor (if purchased

RXWVLGH86&DQDGD7R¿QG\RXUORFDOGLVWULEXWRUJRWRZZZQDXWLOXVLQWHUQDWLRQDOFRP

This icon means a potentially hazardous situation which, if not avoided, could result in death or serious injury. Read and understand

all Warnings on this machine.

Important Safety Instructions and General Troubleshooting

Information for the %RZÁH[

™

VeloCore

™

Bikes

™

Nautilus, Inc., www.NautilusInc.com, 5415 Centerpoint Parkway, Groveport, OH 43125 U.S.A. - Customer Service: North America (800) 605-3369, [email protected] | outside U.S. www.nautilusinternational.com | Printed

LQ&KLQD_1DXWLOXV,QF_1DXWLOXVWKH1DXWLOXVORJR%RZÀH[WKH%ORJR9HOR&RUHDQG-51<DUHWUDGHPDUNVRZQHGE\RUOLFHQVHGWR1DXWLOXV,QFZKLFKDUHUHJLVWHUHGRURWKHUZLVHSURWHFWHGE\FRPPRQODZLQWKH

United States and other countries. | The Bluetooth

ZRUGPDUNDQGORJRVDUHUHJLVWHUHGWUDGHPDUNVRZQHGE\%OXHWRRWK6,*,QFDQGDQ\XVHRIVXFKPDUNVE\1DXWLOXV,QFLVXQGHUOLFHQVH_

ORIGINAL DOCUMENT - ENGLISH VERSION ONLY

FCC Compliance

&KDQJHVRUPRGL¿FDWLRQVWRWKLVXQLWQRWH[SUHVVO\DSSURYHGE\WKHSDUW\UHVSRQVLEOHIRUFRPSOLDQFHFRXOG

void the user’s authority to operate the equipment.

This product complies with part 15 of the FCC rules. Operation is subject to the following two conditions: (1) This device

may not cause harmful interference, and (2) this device must accept any interference received, including interference that

may cause undesired operation.

1RWH This product has been tested and found to comply with the limits for a Class B digital device, pursuant to CFR47

Part 15 Subpart B of the FCC Rules. These limits are designed to provide reasonable protection against harmful

interference in a residential installation. This equipment generates radio frequency energy and, if not installed and used in

accordance with the instructions, may cause harmful interference to radio communications.

However, there is no guarantee that interference will not occur in a particular installation. In the unlikely event that this

equipment does cause harmful interference to radio or television reception, which can be determined by turning the

HTXLSPHQWRႇDQGRQWKHXVHULVHQFRXUDJHGWRWU\WRFRUUHFWWKHLQWHUIHUHQFHE\RQHRUPRUHRIWKHIROORZLQJPHDVXUHV

• Reorient or relocate the receiving antenna.

• Increase the separation between the equipment and receiver.

• Consult the dealer or an experienced radio/TV technician for help.

7KLVSURGXFWFRPSOLHVZLWKWKH(XURSHDQ5DGLR(TXLSPHQW'LUHFWLYH(8

SAFETY WARNING LABELS AND SERIAL NUMBER

WARNING!

,QMXU\RUGHDWKLVSRVVLEOHLIFDXWLRQLVQRWXVHGZKLOHXVLQJWKLV

machine.

• Keep children and pets away.

5HDGDQGIROORZDOOZDUQLQJVRQWKLVPDFKLQH

5HIHUWRWKH2ZQHU¶V0DQXDOIRUDGGLWLRQDOZDUQLQJVDQGVDIHW\

LQIRUPDWLRQ

7KHKHDUWUDWHGLVSOD\HGLVDQDSSUR[LPDWLRQDQGVKRXOGEHXVHGIRU

UHIHUHQFHRQO\

1RWLQWHQGHGIRUXVHE\DQ\RQHXQGHU\HDUVRIDJH

7KHPD[LPXPXVHUZHLJKWIRUWKLVPDFKLQHLVOEVNJ

7KLVPDFKLQHLVIRUKRPHXVHRQO\

&RQVXOWDSK\VLFLDQSULRUWRXVLQJDQ\H[HUFLVHHTXLSPHQW

(/DEHOLVDYDLODEOHLQ(QJOLVKDQG)UHQFK&DQDGLDQRQO\

3URGXFWVSHFL¿FDWLRQ

6HULDOQXPEHU

/HDQORFNZDUQLQJ

instructions

Console

VHULDOQXPEHU

SPECIFICATIONS

0D[LPXP8VHU:HLJKW   NJOEV

16” monitor 22” monitor

Machine Weight without Dumbbells: NJOE NJOE

$SSUR[6FUHHQ6L]HPHDVXUHGGLDJRQDOO\ 39.6 cm (15.6”) 54.6 cm (21.5”)

:HLJKWRI'XPEEHOOVVXSSOLHGLQ86&DQDGDNJOEV

7RWDO6XUIDFH$UHDIRRWSULQWRIHTXLSPHQW 9290.2 cm

(1440 in

)

Power Requirements

3RZHU$GDSWHU

Input Voltage:     9$&+]$

Output Voltage:   9'&$

$UP%DQGVXSSOLHGLQ86&DQDGD 5HFKDUJHDEOHOLWKLXPEDWWHU\

'2127GLVSRVHRIWKLVSURGXFWDVUHIXVH7KLVSURGXFWLVWREHUHF\FOHG)RUSURSHU

GLVSRVDORIWKLVSURGXFWSOHDVHIROORZWKHSUHVFULEHGPHWKRGVDWDQDSSURYHGZDVWH

center.

6HOHFWWKHDUHDZKHUH\RXDUHJRLQJWRVHWXSDQGRSHUDWH\RXUPDFKLQH)RUVDIHRSHUDWLRQWKHORFDWLRQPXVWEHRQDKDUGOHYHOVXUIDFH$OORZD

ZRUNRXWDUHDRIDPLQLPXPP[P´[´

0.6m

24”

2.7m 108”

1.8m

72”

0.6m

24”

0.6m

24”

0.6m

24”

61.2 cm

(24.1”)

151.8 cm

(59.8”)

133.6 cm

(52.6”)

´PRQLWRU

61.2 cm

(24.1”)

151.8 cm

(59.8”)

140.3 cm

(55.3”)

´PRQLWRU

MAINTENANCE

5HDGDOOPDLQWHQDQFHLQVWUXFWLRQVIXOO\EHIRUH\RXVWDUWDQ\UHSDLUZRUN,QVRPHFRQGLWLRQVDQDVVLVWDQWLVUHTXLUHGWRGRWKHQHFHVVDU\WDVNV

(TXLSPHQWPXVWEHUHJXODUO\H[DPLQHGIRUGDPDJHDQGUHSDLUV7KHRZQHULVUHVSRQVLEOHWRPDNHVXUHWKDWUHJXODUPDLQWHQDQFHLV

done. Worn or damaged components must be repaired or replaced immediately. Only manufacturer supplied components can be

used to maintain and repair the equipment.

 ,IDWDQ\WLPHWKH:DUQLQJODEHOVEHFRPHORRVHXQUHDGDEOHRUGLVORGJHGUHSODFHWKHODEHOV,ISXUFKDVHGLQ86&DQDGDFRQWDFW

&XVWRPHU6HUYLFHIRUUHSODFHPHQWODEHOV,ISXUFKDVHGRXWVLGH86&DQDGDFRQWDFW\RXUORFDOGLVWULEXWRUIRUWKHP

Disconnect all power to the machine before you service it.

Daily: %HIRUHHDFKXVHH[DPLQHWKHH[HUFLVHPDFKLQHIRUORRVHEURNHQGDPDJHGRUZRUQSDUWV'RQRWXVHLIIRXQGLQWKLV

FRQGLWLRQ5HSDLURUUHSODFHDOOSDUWVDWWKH¿UVWVLJQRIZHDURUGDPDJH0DNHVXUHDGMXVWPHQWNQREVDUHWLJKW7LJKWHQ

DVQHFHVVDU\&KHFNWKH3HGDOVDQGWLJKWHQDVQHFHVVDU\$IWHUHDFKZRUNRXWXVHDGDPSFORWKWRZLSH\RXUPDFKLQH

DQG&RQVROHIUHHRIPRLVWXUH

NOTICE: ,IQHFHVVDU\RQO\XVHDPLOGGLVKVRDSZLWKDVRIWFORWKWRFOHDQWKH&RQVROH'RQRWFOHDQZLWKDSHWUROHXP

EDVHGVROYHQWDXWRPRWLYHFOHDQHURUDQ\SURGXFWWKDWFRQWDLQVDPPRQLD'RQRWFOHDQWKH&RQVROHLQGLUHFW

VXQOLJKWRUDWKLJKWHPSHUDWXUHV%HVXUHWRNHHSWKH&RQVROHIUHHRIPRLVWXUH

Weekly: &OHDQWKHPDFKLQHWRUHPRYHDQ\GXVWGLUWRUJULPHIURPWKHVXUIDFHV

&KHFNSHGDOVDQGFUDQNDUPVDQGWLJKWHQDVQHFHVVDU\0DNHVXUHDOOEROWVDQGVFUHZVDUHWLJKW7LJKWHQDVQHFHVVDU\

&KHFNIRUVPRRWKVHDWRSHUDWLRQ

Note:'RQRWXVHSHWUROHXPEDVHGSURGXFWV

Monthly

or after 20 hours:

&KHFNWKHGULYHEHOWWHQVLRQDQGDGMXVWLIQHFHVVDU\

&KHFNLQJWKH'ULYH%HOW7HQVLRQ

7RFKHFNWKH'ULYH%HOWWHQVLRQWKHELNHQHHGVWREHRSHUDWHG6HWWKHUHVLVWDQFHDWDPHGLXPWRKLJKOHYHO*HWWKHSHGDOVURWDWLQJDWDERXW

5307KHQVXGGHQO\LQFUHDVHWKH530WR\RXUPD[LPXPDELOLW\,IWKHSHGDOVPRYHQRUPDOO\ZLWKQRVOLSSLQJWKHWHQVLRQLVFRUUHFW,IWKH3HGDOV

VOLSWKHEHOWQHHGVWREHDGMXVWHG5HIHUWRWKH³$GMXVWWKH%HOW7HQVLRQ´SURFHGXUH

0RYLQJDQG6WRULQJWKH0DFKLQH

The machine may be moved by one or more persons depending on their physical abilities and capacities. Make sure that you and

RWKHUVDUHDOOSK\VLFDOO\ÀWDQGDEOHWRPRYHWKHPDFKLQHVDIHO\

 5HPRYHWKHSRZHUDGDSWHU5HPRYHWKHGXPEEHOOVDQ\PHGLDGHYLFHVRUZDWHUERWWOHVIURPWKHELNHEHIRUHPRYLQJLW

2. %HVXUHWKHPDFKLQHLVVWDELOL]HGLQWKHXSULJKWSRVLWLRQZLWKWKH/HDQ/RFN.QRESXOOHGXSORFNHGSRVLWLRQ

3. 7RORFNWKH)O\ZKHHOWXUQWKH(PHUJHQF\%UDNH5HVLVWDQFH$GMXVWPHQW.QREFORFNZLVHXQWLOLWHQFRXQWHUVDQLQFUHDVHLQUHVLVWDQFHThen rotate

WKH(PHUJHQF\%UDNH5HVLVWDQFH$GMXVWPHQW.QREDQRWKHUWXUQFORFNZLVH

7LJKWHQWKH(PHUJHQF\%UDNH5HVLVWDQFH$GMXVWPHQW.QREDVGHVFULEHGXQWLOWKH)O\ZKHHOLVORFNHGEHIRUHPRYLQJLW

 8VHWKH7UDQVSRUW+DQGOHWRFDUHIXOO\OLIWWKHPDFKLQHRQWRWKHWUDQVSRUW

rollers.

5. Push the machine into position.

 &DUHIXOO\ORZHUWKHPDFKLQHLQWRSRVLWLRQ

NOTICE:%HFDUHIXOZKHQ\RXPRYHWKHPDFKLQH$EUXSWPRWLRQVFDQDIIHFW

the computer operation.

For safe storage of the machine, remove the power adapter and

place in a secure location. Be sure the machine is stabilized in

WKHXSULJKWSRVLWLRQZLWKWKH/HDQ/RFN.QRESXOOHGXSORFNHG

SRVLWLRQ7LJKWHQWKH%UDNH5HVLVWDQFH$GMXVWPHQW.QREDV

described until the Flywheel is locked. Place the machine in a

secure location away from children and pets.

/HYHOLQJWKH0DFKLQH

6HWXSDQGRSHUDWHWKLVPDFKLQHRQDVROLGOHYHOKRUL]RQWDOVXUIDFH7KH

PDFKLQHQHHGVWREHOHYHOHGLI\RXUZRUNRXWDUHDLVXQHYHQ/HYHOHUVDUH

IRXQGRQHDFKVLGHRIWKHIURQWVWDELOL]HU/LIWWKHVWDELOL]HUVOLJKWO\WRWDNH

WKHZHLJKWRIIWKHDGMXVWHUWKHQWXUQWKHVWDELOL]HUIRRWWRDGMXVW

Do not adjust the levelers to such a height that they detach or

unscrew from the machine. Injury to you or damage to the

machine can occur.

0DNHVXUHWKHPDFKLQHLVOHYHODQGVWDEOHEHIRUH\RXH[HUFLVH

(PHUJHQF\6WRS

To stop the pedals immediately, push down hard on the Emergency Brake/Resistance Adjustment

.QRE

This bike cannot stop the Pedals independently of the Flywheel. Reduce the pace to

slow the Flywheel and Pedals to a stop. Do not dismount the bike until the Pedals have

come to a complete stop. Be aware that the moving Pedals can strike the backs of the

legs.

5HVLVWDQFH$GMXVWPHQW

7XUQWKH(PHUJHQF\%UDNH5HVLVWDQFH$GMXVWPHQW.QREWRDGMXVWWKHUHVLVWDQFHOHYHO&ORFNZLVHZLOO

increase the value, counter-clockwise will decrease the value.

Lean Mode

7RXQORFNWKHOHDQLQJPRGHSXVKWKHEXWWRQDOOWKHZD\GRZQZLWKDQRSHQKDQG7RORFNWKHELNH

LQWKHVWDWLRQDU\PRGHSXOOXSRQWKHEXWWRQXQWLOLWFOLFNV7DNHDPRPHQWWRSUDFWLFHXQORFNLQJDQG

locking the lean mode.

NOTICE: 7KHELNHPXVWEHXSULJKWLQRUGHUIRUWKH/HDQ/RFN.QREWRHQJDJHLQWKHORFNHGSRVLWLRQ

'RQRWDWWHPSWWRVHWWKH.QRELQDSDUWLDOO\ORFNHGSRVLWLRQ

Lean mode (unlocked) ,QFRUUHFWVHWWLQJSDUWLDOO\ORFNHGStationary mode (locked)

Console Display

6WDWXV/('

Console

$:L¿FRQQHFWLRQLVUHTXLUHGWRXVH\RXU%RZÀH[PDFKLQH,I\RXGRQRWKDYHD:L¿FRQQHFWLRQDYDLODEOHFRQWDFW\RXU%RZÀH[5HSUHVHQWDWLYH

LPPHGLDWHO\IRUIXUWKHUDVVLVWDQFH$-51<PHPEHUVKLSLVUHTXLUHGIRUWKH-51<H[SHULHQFH±VHHZZZERZÁH[FRPMUQ\IRUGHWDLOV

6WDWXV/('

7KH6WDWXV/('VKRZVLIWKH&RQVROHLVDFWLYDWHGDQGVWDUWLQJXSRSHUDWLQJFRUUHFWO\/('LVRQRULIWKH&RQVROHLVH[SHULHQFLQJDQHUURU/('

EOLQNVWLPHV7RUHVHWWKH&RQVROHGXULQJDQHUURUGLVFRQQHFWWKHSRZHUWRWKHPDFKLQHIRUVHFRQGVDQGUHFRQQHFWLW

86%&KDUJLQJ

If a USB Device is attached to the USB Port, the Port will attempt to charge the Device. Depending on the amperage of

device, the power supplied from the USB Port may not be enough to operate the Device and charge it at the same time.

:RUNRXWZLWK2WKHU)LWQHVV$SSV

7KLV¿WQHVVPDFKLQHKDVLQWHJUDWHG%OXHWRRWK

FRQQHFWLYLW\ZKLFKDOORZVLWWRZRUNZLWKDQXPEHURI¿WQHVVDSSV)RURXU

latest list of supported apps, please visit: ZZZQDXWLOXVFRPSDUWQHUV

%OXHWRRWK

+HDUW5DWH(QDEOHG

<RXU¿WQHVVPDFKLQHLVHTXLSSHGWREHDEOHWRUHFHLYHDVLJQDOIURPD%OXHWRRWK

Heart Rate Sensing device. When

connected, the Console will display the Bluetooth

Connected icon. Be sure to follow the described method to sync your

device.

,I\RXKDYHDSDFHPDNHURURWKHULPSODQWHGHOHFWURQLFGHYLFHFRQVXOW\RXUGRFWRUEHIRUHXVLQJD%OXHWRRWK

VWUDSRURWKHU%OXHWRRWK

heart rate monitor.

%OXHWRRWK

+HDUW5DWH$UPEDQG

<RXU¿WQHVVPDFKLQHLVSURYLGHGZLWKD%OXHWRRWK

Heart Rate Armband. When the

Bluetooth

Heart Rate Armband is connected, the Console will display the Bluetooth

Connected icon.

If you have a pacemaker or other implanted electronic device, consult your

GRFWRUEHIRUHXVLQJD%OXHWRRWK

DUPEDQGRURWKHU%OXHWRRWK

heart rate

monitor.

The Heart Rate Armband should be worn on the upper portion of your forearm, with the

Heart Rate Sensor to the inside of your forearm. It should be snug enough not to move around on your arm, but not so

tight that it restricts blood circulation.

1RWH Be sure to remove the protective cover from the Heart Rate Sensor

before use.

1. Put the Bluetooth

Heart Rate Armband onto the upper portion of your

forearm.

 3XVKWKH2Q2ႇ/('EXWWRQRQWKH+HDUW5DWH$UPEDQGWRDFWLYDWHLW7KH

/('ZLOOÀDVKEOXHTXLFNO\LQGLFDWLQJWKDWWKHDUPEDQGKDVEHHQDFWLYDWHG

 7KH/('ZLOOÀDVKEOXHVORZO\ZKHQDKHDUWUDWHLVGHWHFWHG7KH%OXHWRRWK

Connected icon will activate on the Con-

sole when connected. You are ready to workout.

$WWKHHQGRI\RXUZRUNRXWSXVKWKH2Q2ႇ/('EXWWRQWRGLVFRQQHFWDQGGHDFWLYDWH\RXU+HDUW5DWH$UPEDQG

,I\RXSUHVVWKH2Q2ႇ/('EXWWRQDQGWKH/('ÀDVKHVUHG

several times, the battery is low and should be charged. To

charge the Bluetooth

Heart Rate Armband, connect the

Charging Cable to the Charging Terminals on the inside of the

Sensor. Connect the Charging Cable to a powered USB Port.

7KH/('ZLOOÀDVKUHGDQGJUHHQZKLOHFKDUJLQJ:KHQIXOO\

FKDUJHGWKH/('ZLOOEHJUHHQFRQWLQXRXVO\

USB Connector

Charging Terminals

Heart Rate Sensor

Armband

Charging Cable

2Q2ႇ/('

button

0RXQWLQJDQG'LVPRXQWLQJWKH0DFKLQH

%HIRUHPRXQWLQJRUGLVPRXQWLQJWKHPDFKLQHEHVXUHLWLVVWDELOL]HGLQWKHXSULJKWSRVLWLRQZLWKWKH/HDQ/RFN.QRESXOOHGXSORFNHGSRVLWLRQ

Care should be used when mounting or dismounting the machine.

Before mounting or dismounting the machine, be sure it is stabilized in the upright position with the Lean Lock Knob completely

SXOOHGXSORFNHGSRVLWLRQ,IWKH/HDQ/RFNPHFKDQLVPLVQRWHQJDJHGWKHELNHPD\EHFRPHXQEDODQFHGDQGIDOOZKLFKFDQ

cause injury or damage to the equipment.

6HDW$GMXVWPHQW

&RUUHFWVHDWSODFHPHQWHQFRXUDJHVH[HUFLVHHI¿FLHQF\DQGFRPIRUWZKLOHUHGXFLQJWKHULVNRILQMXU\

:KHQ\RXDGMXVWWKHVHDWXVHWKHVKRHVWKDW\RXSODQWRZHDUIRUULGLQJ

 6WDQGLQJQH[WWRWKHELNHUDLVHORZHUWKH6HDWVRWKDWLWLVOHYHOZLWKWKHWRSRI\RXUKLSERQH

Note: 7LJKWHQWKH6HDW3RVW$GMXVWPHQW+DQGOHWRVHFXUHWKH6HDW3RVW%HVXUHWKDWWKHKDQGOHLVIXOO\

tightened. Pull the handle out to disengage and turn so that it points down, then release.

 6LWRQWKHELNH:LWKWKHKLSVOHYHOSODFHWKHEDOORIWKHIRRWRQWKH3HGDODWWKHERWWRPRIWKHSHGDO

VWURNHR¶FORFN7KHOHJVKRXOGEHVOLJKWO\EHQWDWWKHNQHHDSSUR[GHJUHHV

 ,I\RXUOHJLVWRRVWUDLJKWRU\RXUIRRWFDQQRWWRXFKWKH3HGDO\RXQHHGWRPRYHWKHVHDWGRZQZDUG

,I\RXUOHJLVEHQWWRRPXFK\RXQHHGWRPRYHWKHVHDWXSZDUG

Step off the machine before you adjust the seat.

4. /RRVHQWKH6HDW3RVW$GMXVWPHQW+DQGOHRQWKH6HDW3RVWas you hold the upright post to prevent it

IURPGURSSLQJAdjust the seat to the desired height.

Do not lift the Seat post above the “STOP” mark on the Seat Post.

5. Tighten the Seat Post Adjustment Handle to secure the Seat Post%HVXUHWKDWWKHKDQGOHLVIXOO\WLJKWHQHG. Pull the handle out to disengage

and turn so that it points down, then release.

 :KLOHVHDWHGURWDWHWKH3HGDOVVRWKH\DUHOHYHODR¶FORFNR¶FORFNSRVLWLRQ,QWKLVSRVLWLRQEHVXUHWKHIURQWNQHHLVDOLJQHGRYHURUVOLJKWO\

EHKLQGWKHSHGDOD[OH.

 7RPRYHWKHVHDWFORVHUWRRUDZD\IURPWKHFRQVROHORRVHQWKH6HDW6OLGHU$GMXVWPHQW+DQGOH6OLGHWKHVHDWWRWKHGHVLUHGSRVLWLRQDQGIXOO\

tighten the handle. Pull the handle down to disengage and turn so that it points rearward, then release.

Note:,IWKHKDQGOHFDQQRWWXUQGXHWRFRQWDFWZLWKDQRWKHUSDUWSXOOWKHKDQGOHWXUQDQGSXVKLWEDFNLQWRUHSRVLWLRQLW&RQWLQXHWXUQLQJDVQHHGHG

)RRW3RVLWLRQ3HGDO6WUDS$GMXVWPHQW

)RRWSHGDOVZLWKVWUDSVSURYLGHVHFXUHIRRWLQJWRWKHH[HUFLVHELNH$OZD\VZHDUUXEEHUVROHGDWKOHWLFVKRHVRUcycling

shoes with cleats ZKHQ\RXXVHWKLVPDFKLQH'RQRWXVHWKHPDFKLQHZLWKEDUHIHHWRURQO\ZHDULQJVRFNV

 3XWWKHEDOORIHDFKIRRWLQWKH)RRW5HVWUDLQWRQWKH3HGDOV

2. Fasten the strap over the shoe.

3. 5HSHDWIRUWKHRWKHUIRRW

%HVXUHWRHVDQGNQHHVSRLQWGLUHFWO\IRUZDUGWRHQVXUHPD[LPXP3HGDOHI¿FLHQF\3HGDOVWUDSVFDQEHOHIWLQSRVLWLRQIRU

VXEVHTXHQWZRUNRXWV

NOTICE: I I\RXFKRRVHWRUHSODFHWKH3HGDOVZLWK\RXURZQWKHQPDNHVXUHWRIROORZWKDWSHGDOPDQXIDFWXUHU¶V

LQVWDOODWLRQVSHFL¿FDWLRQV

8VLQJWKH6KRH&OLSV&OHDWV

Foot pedals that are equipped for cycling shoes with cleats provide secure footing on the

H[HUFLVHELNH7KHVKRHFOHDWVSURYLGHG¿WERWKWKHULJKWDQGOHIW3HGDOV

3ULRUWRXVHPDNHVXUH\RXXQGHUVWDQGWKHRSHUDWLRQRIWKHHQJDJHPHQWUHOHDVH

mechanism for the pedals and cleats (shoes).

.HHSFOHDWVDQGELQGLQJVFOHDURIGLUWDQGGHEULVWRHQVXUHHQJDJHPHQWDQG

release.

&KHFNWKHFOHDWVSHULRGLFDOO\IRUZHDU:KHQWKHFOHDWVDUHZRUQUHSODFHWKHP

5HSODFHWKHFOHDWZKHQLWEHFRPHVGLႈFXOWWRUHOHDVHRUVWDUWVWRUHOHDVHZLWK

PXFKOHVVHႇRUWWKDQZKHQLWZDVLQQHZFRQGLWLRQ

3HGDOVDQGFOHDWVDUH63'&RPSDWLEOH7KH\¿WDQ\VKRHVL]HZLWKWKHFRUUHFWFOHDWPRXQWV

shoes with “Standard 2-Hole MTB SPD Cleat Mounts” (MTB SPD = Mountain Bike Shimano

Pedaling Dynamics).

1. Be sure that the arrow on top of the Pedal points forward.

2. Push the cleat down and forward to engage the Pedal.

3. Repeat for the other foot.

4. Practice engaging and disengaging from the Pedals before starting your workout.

To disengage (release) the cleats from the pedals, push the heels outward and lift.

,IWKHERG\ZHLJKWRIDXVHULVYHU\ORZWKHXVHUPD\KDYHGLႈFXOW\ZLWKRSHUDWLRQRIWKH

engagement/release mechanism in the Pedals. It may be necessary to decrease the

retention force of the mechanism. To adjust the retention:

 /RFDWHWKHRSHQLQJLQWKHUHDURIWKH3HGDOIRUDFFHVVWRWKHDGMXVWPHQWEROW,WLVEH-

tween the 2 screws that attach the Foot Restraint to the Pedal.

2. Use a 3mm hex wrench to turn the adjustment bolt. To decrease the retention, turn it left

(counterclockwise). To increase the retention, turn it right (clockwise).

+DQGOHEDU$GMXVWPHQW

7KHLGHDOSRVLWLRQVKRXOGDOORZDVOLJKWEHQGLQWKHHOERZVDQG\RXUVKRXOGHUVWRIDOOLQWRDUHOD[HGSRVLWLRQ

7RDGMXVWWKHKDQGOHEDUSRVLWLRQ

1. /RRVHQWKH+DQGOHEDU3RVW$GMXVWPHQW+DQGOHRQWKH+DQGOHEDU3RVWas you hold the upright post to prevent it

IURPGURSSLQJ$GMXVWWKH+DQGOHEDUWRWKHGHVLUHGKHLJKW

Do not lift the Handlebar Post above the “STOP” mark on the Handlebar Post.

2. 7LJKWHQWKH+DQGOHEDU3RVW$GMXVWPHQW+DQGOHWRVHFXUHWKH+DQGOHEDU%HVXUHWKDWWKHKDQGOHLVIXOO\

tightened. Pull the handle out to disengage and turn so that it points down, then release.

Note:,IWKHKDQGOHFDQQRWWXUQGXHWRFRQWDFWZLWKDQRWKHUSDUWSXOOWKHKDQGOHWXUQDQGSXVKLWEDFNLQWRUHSRVLWLRQLW

Continue turning as needed.

(QJDJH

'LVHQJDJHUHOHDVH

/RFNLQJWKH)O\ZKHHOIRU6WRUDJH

:KHQWKHPDFKLQHLVQRWLQXVHEHVXUHWRORFNWKH)O\ZKHHOZLWKWKH(PHUJHQF\%UDNH5HVLVWDQFH$GMXVWPHQW.QRETo lock the Flywheel, turn the

(PHUJHQF\%UDNH5HVLVWDQFH$GMXVWPHQW.QREFORFNZLVHXQWLOLWHQFRXQWHUVDQLQFUHDVHLQUHVLVWDQFHThen rotate the Emergency Brake/Resistance

$GMXVWPHQW.QREDQRWKHUWXUQFORFNZLVH7KH)O\ZKHHOLVQRZORFNHG7KHÀ\ZKHHOVKRXOGEHORFNHGIRUVWRUDJHRIWKHPDFKLQH

For safe storage of the machine, remove the power supply and place in a secure location. Be sure the machine is stabilized in the

XSULJKWSRVLWLRQZLWKWKH/HDQ/RFN.QREFRPSOHWHO\SXOOHGXSORFNHGSRVLWLRQ7LJKWHQWKH%UDNH5HVLVWDQFH$GMXVWPHQW.QRE

as described until the Flywheel is locked. Place the machine in a secure location away from children and pets.

:LWKWKH)O\ZKHHOORFNHGWKHOHYHORIUHVLVWDQFHZLOOEHRXWRIWKHUDQJHRIRSHUDWLRQGLVSOD\HGE\WKH&RQVROH'RQRWXVHWKHPDFKLQHZLWKWKH

OHYHORIUHVLVWDQFHRXWVLGHRIWKH0% - 100% range. 7KLVZLOOGDPDJHWKHDELOLW\WRTXLFNO\VWRSWKH)O\ZKHHOGXULQJDQHPHUJHQF\DQGWKHHIIHFWLYHQHVV

RIVHFXULQJWKHELNHIRUVWRUDJH Turn the EPHUJHQF\%UDNH5HVLVWDQFH$GMXVWPHQW.QREXQWLOWKH/(9(/GLVSOD\HGRQWKH&RQVROHLVOHVVWKDQ

7KHUHVLVWDQFHLVQRZLQWKHGHVLJQHGUDQJHRIRSHUDWLRQIRUWKHELNH

'HPRQVWUDWLRQ0RGH

'XULQJ'HPRQVWUDWLRQ0RGHWKH&RQVROHZLOOGLVSOD\DYLGHRSUHVHQWDWLRQWKDWKLJKOLJKWVWKHNH\IHDWXUHVRIWKHPDFKLQHDQGWKH-51<PHPEHUVKLS

The machine ships with Demonstration Mode inactive.

To activate the Demonstration mode:

:LWKWKHPDFKLQHDFWLYDWHG

WDSWHQWLPHVLQWKHXSSHUULJKWFRUQHURIWKH

Console Display. The Console will display the ³$GYDQFHG8VHU$FWLRQV´

menu.

Note: In order to display the ³$GYDQFHG8VHU$FWLRQV´PHQX, the

&RQVROHFDQQRWEHORJJHGLQWRWKH-51<

™ app.

2. 7DSRQWKH³'HPRPRGHDSS´RSWLRQ

Note: This is where Demo mode is activated and de-activated.

3. 7DSRQWKH³$FWLYDWH'HPRPRGH´RSWLRQ

4. ,QVSHFWWKH&RQVROHWREHVXUHWKDW'HPRPRGHLVDFWLYHDQGUXQQLQJRQ

the Console Display.

5. $GMXVWWKHYROXPHZLWKWKHYROXPHFRQWUROVRQWKHEDFNRIWKH&RQVROH

'LVSOD\WRWKHPLGGOHYROXPHOHYHO2EVHUYHKRZWKHYROXPHZRUNVLQWKH

environment, and adjust it accordingly.

7RH[LW'HPRQVWUDWLRQPRGHSHUIRUPWKHDERYHVWHSVEXWVHOHFW³'H$FWLYDWH'HPR0RGH´

X10

7URXEOHVKRRWLQJ

&RQGLWLRQ3UREOHP Things to Check Solution

No display/partial display/unit

will not turn on

Check electrical (wall) outlet 0DNHVXUHXQLWLVSOXJJHGLQWRDIXQFWLRQLQJZDOORXWOHW

&KHFNFRQQHFWLRQDWIURQWRIXQLW &RQQHFWLRQVKRXOGEHVHFXUHDQGXQGDPDJHG0DNHVXUHWKHDGDSWHULVIXOO\

plugged into the power inlet connector. Replace adapter or connection at unit

LIHLWKHUDUHGDPDJHG

&KHFNGDWDFDEOHLQWHJULW\ $OOZLUHVLQFDEOHVKRXOGEHLQWDFW,IDQ\DUHYLVLEO\FULPSHGRUFXWUHSODFH

FDEOH

&KHFNGDWDFDEOH

connections/orientation

%HVXUHFDEOHLVFRQQHFWHGVHFXUHO\DQGRULHQWHGSURSHUO\6PDOOODWFKRQ

connector should line up and snap into place.

&KHFNFRQVROHGLVSOD\IRU

damage

&KHFNIRUYLVXDOVLJQWKDWFRQVROHGLVSOD\LVFUDFNHGRURWKHUZLVHGDPDJHG

5HSODFH&RQVROHLIGDPDJHG

,IWKHDERYHVWHSVGRQRWUHVROYHWKHSUREOHPFRQWDFW&XVWRPHU6HUYLFHLI

LQVLGH86&DQDGDRU\RXUORFDOGLVWULEXWRULIRXWVLGH86&DQDGD

6SHHGGLVSOD\HGLVDOZD\V³´

stuck in Pause mode

'DWDFDEOH 0DNHVXUHWKHGDWDFDEOHLVFRQQHFWHGWRWKH&RQVROHIURPWKHPDLQIUDPH

DVVHPEO\

Speed Sensor 0DNHVXUHWKHGDWDFDEOHLVFRQQHFWHGWRWKH6SHHG6HQVRU

No Speed/RPM reading &KHFNGDWDFDEOHLQWHJULW\ $OOZLUHVLQFDEOHVKRXOGEHLQWDFW,IDQ\DUHFXWRUFULPSHGUHSODFHFDEOH

&KHFNGDWDFDEOHFRQQHFWLRQV

orientation

%HVXUHFDEOHLVFRQQHFWHGVHFXUHO\DQGRULHQWHGSURSHUO\6PDOOODWFKRQ

connector should line up and snap into place.

&KHFN6SHHG6HQVRU$VVHPEO\ 6SHHG6HQVRU$VVHPEO\VKRXOGEHFRQQHFWHGWRGDWDFDEOH5HDOLJQVHQVRU

LIQHFHVVDU\5HSODFHLIWKHUHLVDQ\GDPDJHWRWKHVHQVRURUWKHFRQQHFWLQJ

wire.

8QLWRSHUDWHVEXW%OXHWRRWK

Heart Rate (HR) not displayed

Bluetooth

Heart Rate Sensing

'HYLFH$UPEDQGSURYLGHGwith

U.S./Canada machines)

Make sure device is directly against skin and device is on.

Bluetooth

Heart Rate Sensing

Device Batteries

,IGHYLFHKDVUHSODFHDEOHEDWWHULHVLQVWDOOQHZEDWWHULHV0DNHVXUHEDWWHULHV

DUHFKDUJHGLIDSSOLFDEOH

,QWHUIHUHQFH 7U\PRYLQJXQLWDZD\IURPVRXUFHVRILQWHUIHUHQFH790LFURZDYHHWF

Connected to previous user 7KH&RQVROHPD\EHVWLOOFRQQHFWHGWRWKHSUHYLRXVXVHU3XVK&RQQHFW

Bluetooth

EXWWRQWRGLVFRQQHFWIURPWKHPFRQQHFWWR\RXU+HDUW5DWH

Sensing Device.

&RQVROHVKXWVRIIHQWHUVVOHHS

mode) while in use

Check electrical (wall) outlet 0DNHVXUHXQLWLVSOXJJHGLQWRDIXQFWLRQLQJZDOORXWOHW

&KHFNFRQQHFWLRQDWIURQWRIXQLW &RQQHFWLRQVKRXOGEHVHFXUHDQGXQGDPDJHG5HSODFHDGDSWHURUFRQQHF-

WLRQDWXQLWLIHLWKHUDUHGDPDJHG

&KHFNGDWDFDEOHLQWHJULW\ $OOZLUHVLQWKHFDEOHVKRXOGEHLQWDFW,IDQ\DUHFXWRUFULPSHGUHSODFH

FDEOH

&KHFNGDWDFDEOHFRQQHFWLRQV

orientation

%HVXUHFDEOHLVFRQQHFWHGVHFXUHO\DQGRULHQWHGSURSHUO\6PDOOODWFKRQ

connector should line up and snap into place.

Reset machine 8QSOXJXQLWIURPHOHFWULFDORXWOHWIRUPLQXWHV5HFRQQHFWWRRXWOHW

Check Speed Sensor 6SHHGVHQVRUVKRXOGEHFRQQHFWHGWRGDWDFDEOH5HSODFHLIWKHUHLVDQ\

damage to the sensor or the connecting wire.

&RQWDFW&XVWRPHU6HUYLFHLILQVLGH86&DQDGDRU\RXUORFDOGLVWULEXWRULI

outside US/Canada).

Unit rocks/does not sit level Check level adjustment /HYHOHUVPD\EHWXUQHGWROHYHOPDFKLQH

&KHFNVXUIDFHXQGHUXQLW $GMXVWPHQWPD\QRWEHDEOHWRFRPSHQVDWHIRUH[WUHPHO\XQHYHQVXUIDFHV

Move machine to level area.

&RQGLWLRQ3UREOHP Things to Check Solution

3HGDOVORRVHXQLWGLI¿FXOWWR

pedal/ Pedals seem to skip or

slip with a sudden increase in

rpm

Check pedal to crank

connection

3HGDOVKRXOGEHWLJKWHQHGVHFXUHO\WRFUDQNDUP%HVXUHFRQQHFWLRQLVQRW

FURVVWKUHDGHG'RQRWXVHLISHGDOLVQRWIXOO\WLJKWHQHG

&KHFNFUDQNDUPWRD[OH

connection

&UDQNDUPVKRXOGEHWLJKWHQHGVHFXUHO\WRD[OH

&KHFNGULYHEHOWWHQVLRQ 5HIHUWRWKH³$GMXVWWKH%HOW7HQVLRQ´SURFHGXUH&RQWDFW&XVWRPHU6HUYLFH

LILQVLGH86&DQDGDRU\RXUORFDOGLVWULEXWRULIRXWVLGH86&DQDGD

Clicking sound when pedaling Check pedal to crank

connection

5HPRYHSHGDOV0DNHVXUHWKHUHLVQRGHEULVRQWKUHDGVDQGUHLQVWDOOWKH

pedals.

Click, tick or knocking sound &KHFNIRUORRVHKDUGZDUH Tightly secure all hardware.

Seat post movement Check adjustment handle 0DNHVXUHWKHUHLVQRGHEULVRQWKUHDGVDQGUHLQVWDOOWKHDGMXVWPHQWKDQGOH

Be sure the adjustment handle is securely tightened.

+DQGOHEDUSRVWPRYHPHQW Check adjustment handle 0DNHVXUHWKHUHLVQRGHEULVRQWKUHDGVDQGUHLQVWDOOWKHDGMXVWPHQWKDQGOH

Be sure the adjustment handle is securely tightened.

Bike will not lean &KHFN/HDQ/RFN.QRE %HVXUHNQRELVSXVKHGFRPSOHWHO\GRZQXQORFNHGSRVLWLRQ

Bike will not lock in Stationary

mode

&KHFN/HDQ/RFN.QRE %HVXUHELNHLVXSULJKW3XOOWKHNQREFRPSOHWHO\XSXQWLO\RXKHDUDFOLFN

,IWKH/HDQ/RFNPHFKDQLVPGRHVQRWFOLFNFRQWDFW&XVWRPHU6HUYLFHLI

LQVLGH86&DQDGDRU\RXUORFDOGLVWULEXWRULIRXWVLGH86&DQDGD

1RLVHUDWWOLQJIURP/RFNRXW

DVVHPEO\

&KHFN/HDQ/RFN.QRE %HVXUHNQRELVSXVKHGFRPSOHWHO\GRZQXQORFNHGSRVLWLRQ

/HIWDQG5LJKWOHDQIRUFHLVQRW

the same

&KHFNEXPSHUWHQVLRQ 5HIHUWRWKH³$GMXVWWKH%XPSHU/HDQ7HQVLRQ´SURFHGXUHLQWKHVHUYLFH

PDQXDO&RQWDFW&XVWRPHU6HUYLFHLILQVLGH86&DQDGDRU\RXUORFDO

GLVWULEXWHULIRXWVLGH86&DQDGD

Console continuously displays a

YLGHRRIPDFKLQHIHDWXUHV

Console is in demonstration

mode

7DSRQWKHXSSHUULJKWFRUQHURIWKHFRQVROHGLVSOD\WHQWLPHV7DSRQ³'HPR

PRGHDSS´DQGWKHQWDSRQWKH³'HDFWLYDWH'HPRPRGH´RSWLRQ

&RQVROHGLVSOD\VDVHULHVRI

FRORUVDWVWDUWXS/&'GLVSOD\

test mode)

Reset machine 8QSOXJXQLWIURPHOHFWULFDORXWOHWIRUVHFRQGV5HFRQQHFWWRRXWOHW

Maintenance Parts

A Console Q 3LYRW6KURXG/HIW GG Drive Pulley

B +DQGOHEDU R )HQGHU/HIW HH Idler Pulley

C +DQGOHEDU3RVW S )URQW6WDELOL]HU II Flywheel

D /HDQ/RFN.QRE T 7UDQVSRUW:KHHO -- Speed Sensor Magnet (5)

E %UDNH5HVLVWDQFH.QRE U Console Mast KK Speed Sensor

F $GMXVWPHQW+DQGOH6HDW+DQGOHEDU 9 :DWHU%RWWOH+ROGHU // 5HVLVWDQFH0DJQHW$VVHPEO\

G Seat Stem : 'DWD&DEOH8SSHU MM Power Inlet

H Seat X 'XPEEHOO5DFN'XPEEHOOVRQO\VXSSOLHG

with U.S./Canada machines)

NN 'DWD&DEOH/RZHU

I Seat End Cap < &RQVROH0DVW$GMXVWDEOH OO PCB, Tillt Sensor

- Main Frame Z End Cap, Console Mast PP 6WDWLF%XPSHU$VVHPEO\

K Transport Handle AA Main Shroud, Right QQ Static Bumper Shroud

/ 5HDU6WDELOL]HU BB Pivot Shroud, Right RR 0RYLQJ%XPSHU$VVHPEO\

M /HYHOHU CC Fender, Right SS Moving Bumper Shroud

N 0DLQ6KURXG/HIW DD Crank Arm, Right TT /HDQ/RFNRXW$VVHPEO\

O &UDQN$UP/HIW EE Pedal w/Foot Restraint, Right UU 5HVLVWDQFH5RG/LQNDJH

P 3HGDOZ)RRW5HVWUDLQW/HIW FF Drive Belt

REPLACEMENT PROCEDURE SKILL LEVEL

/HYHO, /RZYHU\OLWWOHPHFKDQLFDONQRZOHGJHRUH[SRVXUH

/HYHO,, ,QWHUPHGLDWHVRPHH[SHULHQFHZLWKPHFKDQLFDOSURFHGXUHV

/HYHO,,, $GYDQFHGNQRZOHGJHDEOHDERXWPHFKDQLFDOSURFHGXUHV

'LVFRQQHFWDOOSRZHUWRWKHPDFKLQHEHIRUH\RXVHUYLFHLW

:KHQGLVSRVLQJRIROGSDUWVREH\WKHDSSOLFDEOHORFDODQGSURYLQFLDOUHTXLUHPHQWV

For instructions to replace the following parts, please refer to the Assembly Manual for your bike:

• )URQW6WDELOL]HU

• Handlebar

• Handlebar Post

• Pedals

• 5HDU6WDELOL]HU

• Seat

• Seat Post

• Water Bottle Holders

• Dumbbell Holders

Adjust the Belt Tension

on the %RZÁH[

™

VeloCore

™

Bikes

6NLOO/HYHO,,

8027844.081520.A

Replacement Procedure

NOTICE: 7KLVGRFXPHQWSURYLGHVLQVWUXFWLRQVIRUWKHDGMXVWPHQWRIWKH'ULYH%HOW7HQVLRQRQWKH%RZÀH[

™

9HOR&RUH

™

DQG9HOR&RUH

™

ELNHV

If you need assistance, please call

Nautilus Customer Service(if purchased in US/Canada) or your local distributor (if purchased out-

VLGH86&DQDGD7R¿QG\RXUORFDOGLVWULEXWRUJRWRZZZQDXWLOXVLQWHUQDWLRQDOFRP

This icon means a potentially hazardous situation which, if not avoided, could result in death or serious injury. Read and understand

all Warnings on this machine.

,PSRUWDQW6DIHW\,QVWUXFWLRQV%HIRUHVHUYLFLQJRUXVLQJWKLVHTXLSPHQWREH\WKHIROORZLQJZDUQLQJV

This icon means a potentially hazardous situation which, if not avoided, could result in death or serious injury. Read and understand

all Warnings on this machine.

5HDGDQGXQGHUVWDQGWKH3DUW5HSODFHPHQW3URFHGXUHEHIRUHZRUNLQJRQWKHPDFKLQH)DLOXUHWRREH\WKHLQVWUXFWLRQVDQGVDIHW\ZDUQLQJVFRXOGFDXVH

LQMXU\WRWKHVHUYLFHWHFKQLFLDQRUE\VWDQGHUV

• .HHSE\VWDQGHUVDQGFKLOGUHQDZD\IURPWKHSURGXFWEHLQJVHUYLFHGDWDOOWLPHV

• 'LVFRQQHFWDOOSRZHUWRWKHPDFKLQHEHIRUH\RXVHUYLFHLW

0DNHVXUHWKDWWKHUHSDLULVGRQHLQDQDSSURSULDWHZRUNVSDFHDZD\IURPIRRWWUDI¿FDQGH[SRVXUHWRE\VWDQGHUV

• 6RPHFRPSRQHQWVRIWKHHTXLSPHQWFDQEHKHDY\RUDZNZDUG(QOLVWWKHVHUYLFHRIDVHFRQGSHUVRQZKHQ\RXGRPDLQWHQDQFHVWHSVLQYROYLQJWKHVH

components. Do not try to do heavy or awkward steps on your own.

•

8VHRQO\UHSODFHPHQWSDUWVDQGKDUGZDUHWKDWDUHVXSSOLHGRUDSSURYHGE\1DXWLOXV)DLOXUHWRXVH1DXWLOXVDSSURYHGUHSODFHPHQWSDUWVFDQDGYHUVHO\

DIIHFWWKHVDIHW\DQGIXQFWLRQDOLW\RIWKHHTXLSPHQWFUHDWLQJDULVNWRXVHUVDQGZLOOYRLGWKHZDUUDQW\

• Be sure that all warning stickers and instructional placards applied to the product stay present and in good condition when doing maintenance or

UHSODFLQJFRPSRQHQWV,IDWDQ\WLPHWKH:DUQLQJODEHOVEHFRPHORRVHXQUHDGDEOHRUGLVORGJHGUHSODFHWKHODEHOV,ISXUFKDVHGLQ86&DQDGDFRQWDFW

&XVWRPHU6HUYLFHIRUUHSODFHPHQWODEHOV,ISXUFKDVHGRXWVLGH86&DQDGDFRQWDFW\RXUORFDOGLVWULEXWRUIRUWKHP

'RQRWWU\WRFKDQJHWKHGHVLJQRUIXQFWLRQDOLW\RIWKHPDFKLQHEHLQJVHUYLFHGDVWKLVFDQDGYHUVHO\DIIHFWXVHUVDIHW\

'RQRWXVHWKHPDFKLQHXQWLODOOVKURXGVLQVWUXFWLRQVZDUQLQJODEHOVDQGFRUUHFWIXQFWLRQDOLW\KDYHEHHQYHULILHGDQGWHVWHGIRUFRUUHFWSHUIRUPDQFH

7RROV5HTXLUHGQRWLQFOXGHG

#2 Phillips screwdriver

 PP+H[ZUHQFK

13mm Open end wrench

 PP6RFNHWDQGH[WHQVLRQDQG:UHQFK

(optional)

™

LQ&KLQD_1DXWLOXV,QF_1DXWLOXVWKH1DXWLOXVORJR%RZÀH[WKH%ORJRDQG9HOR&RUHDUHWUDGHPDUNVRZQHGE\RUOLFHQVHGWR1DXWLOXV,QFZKLFKDUHUHJLVWHUHGRURWKHUZLVHSURWHFWHGE\FRPPRQODZLQWKH8QLWHG

States and other countries. | ORIGINAL DOCUMENT - ENGLISH VERSION ONLY

1. 8QSOXJWKH$&$GDSWHUIURPWKHZDOORXWOHWDQGPDFKLQH%HVXUH

WKHELNHLVVWDELOL]HGLQWKHXSULJKWSRVLWLRQZLWKWKH/HDQ/RFN.QRELQ

the locked position.

Be sure the bike is stabilized in the upright position

ZLWKWKH/HDQ/RFN.QREFRPSOHWHO\SXOOHGXSORFNHG

SRVLWLRQ,IWKH/HDQ/RFNPHFKDQLVPLVQRWHQJDJHGWKH

bike may become unbalanced and fall, which can cause

injury or damage to the equipment.

.HHSWKHÁ\ZKHHOVWDEOHGXULQJWKLVSURFHGXUH'RQRW

WXUQWKHFUDQNDUPV)O\ZKHHOPRYHPHQWFDQSXOOÀQJHUV

in and cause injury.

2. 7RFKHFNWKH'ULYH%HOWWHQVLRQWKHELNHQHHGVWREHRSHUDWHG6HW

WKHUHVLVWDQFHDWDPHGLXPWRKLJKOHYHO6LWRQWKHELNHDQGXVHWKH

SHGDOVDWDSSUR[LPDWHO\5307KHQDFFHOHUDWHTXLFNO\VSHHGEXUVW

WR\RXUPD[LPXPDELOLW\DQGIHHOZKHWKHUWKH'ULYH%HOWVOLSV,IWKH

pedals move normally with no skipping (slip), the tension is correct.

,IWKHWHQVLRQLVFRUUHFW²JRWRVWHS

,IWKH'ULYH%HOWVOLSV²FRQWLQXHWRVWHS

3. Using a #2 Phillips Screwdriver, remove 3 screws (a) that attach

WKH&HQWHU'LVFWRWKH5LJKW0DLQ6KURXG6HWWKHPVDIHO\DVLGHIRU

UHDVVHPEO\

Note:<RXUPDFKLQHPD\QRWPDWFKWKHLPDJHVSURYLGHGH[DFWO\

Locked position

5LJKWVLGHFUDQNDUPQRWVKRZQIRUFODULW\

4. 8VLQJD3KLOOLSV6FUHZGULYHUUHPRYHVFUHZVEFIURPWKH

5LJKW0DLQ6KURXG%HVXUHWRQRWHWKHLUORFDWLRQVIRUUHDVVHPEO\

5HPRYHWKHERWWRPVFUHZV¿UVWDQGWKHQWKHWRSVFUHZV

&DUHIXOO\DQJOHDQGUHPRYHWKH5LJKW0DLQ6KURXGDQG5HDUUHG

6KURXG6HWWKHSDUWVVDIHO\DVLGHIRUUHDVVHPEO\

5. Check the tension:

3XVKWKH'ULYH%HOWGRZQZDUGDWWKHPLGSRLQW0EHWZHHQWKH

pulleys and measure the distance. The Drive Belt should have only

´FPRIJLYH

Or:

+ROGWKHHGJHVRIWKH'ULYH%HOWDWWKHPLGSRLQW0DQGWZLVWLW,W

should turn only 90 degrees (1/4 turn, to vertical).

,IWKHWHQVLRQLVFRUUHFW²JRWRVWHS

,IWKHWHQVLRQLVQRWFRUUHFW²FRQWLQXHWRVWHS

5LJKWVLGHFUDQNDUPQRWVKRZQIRUFODULW\

5LJKW0DLQVKURXGUHPRYHG

Main

shroud

5HDU

shroud

Center disc

6 8VLQJDPPKH[ZUHQFKORRVHQWKH7HQVLRQHU3LYRWEROW

7. Using a 13 mm open end wrench, loosen the inner Nut on the

Tensioning Bolt.

8. Using a 13 mm open end wrench or socket and wrench, adjust the

outer Nut on the Tensioning Bolt:

If the Drive Belt is too loose—turn the Nut on the Tensioning Bolt

clockwise.

If the Drive Belt is too tight—turn the Nut on the Tensioning Bolt

counterclockwise.

Note:,IDGMXVWLQJWKH1XWIURPWKHEDFNDVRFNHWH[WHQVLRQPD\EH

necessary.

9. &KHFNWKHEHOWWHQVLRQ

,IWKHWHQVLRQLVFRUUHFW²FRQWLQXHWRVWHS

,IWKHWHQVLRQLVQRWFRUUHFW²UHSHDWVWHS

10. Using a 13 mm socket and wrench or open end wrench,tighten the

inner Nut on the Tensioning Bolt.

11 8VLQJDPPKH[ZUHQFKWLJKWHQWKH7HQVLRQHU3LYRWEROW

12. *HWRQWKHELNHDQGFKHFNWKHPRYHPHQWRIWKH'ULYH%HOWE\URFNLQJ

EDFNDQGIRUWKRQWKHSHGDOV7KH3HGDOVDQG)O\ZKHHOVKRXOGPRYHDV

one.

$GMXVWWKH'ULYH%HOWWHQVLRQDJDLQLIQHFHVVDU\

13. Reinstall the Right Main Shroud and Rear Shroud.

14. Final Inspection

Inspect your machine to ensure that all hardware is tight and components

DUHSURSHUO\DVVHPEOHG

Do not use until the machine has been fully assembled and

inspected for correct performance in accordance with the

Owner’s Manual.

7HQVLRQHUKDUGZDUH1XWVDUHEHKLQGÀ\ZKHHOPRXQWSODWH

Tensioner pivot bolt

2XWHUQXWRQ7HQVLRQLQJEROWYLHZIURPEDFN

Tensioner

bracket

2XWHUQXW

Tensioner pivot bolt

7HQVLRQLQJEROW

Nut

location

)O\ZKHHO

mount plate

7HQVLRQLQJEROWDQGLQQHUQXW

Inner nut

Tensioner

pivot bolt

7HQVLRQLQJEROW

$GMXVWWKH%XPSHU/HDQ7HQVLRQ

on the %RZÁH[

™

VeloCore

™

Bikes

6NLOO/HYHO,,

8027845.081520.A

Replacement Procedure

NOTICE: 7KLVGRFXPHQWSURYLGHVLQVWUXFWLRQVIRUWKHFDOLEUDWLRQRIWKHOHDQWHQVLRQDQGDGMXVWPHQWRIWKHELNH¶VYHUWLFDODOLJQPHQWRQWKH%RZÀH[

™

9HOR&RUH

™

16 and

9HOR&RUH

™

ELNHV

If you need assistance, please call Nautilus Customer Service (if purchased in US/Canada) or your local distributor (if purchased out-

VLGH86&DQDGD7R¿QG\RXUORFDOGLVWULEXWRUJRWRZZZQDXWLOXVLQWHUQDWLRQDOFRP

This icon means a potentially hazardous situation which, if not avoided, could result in death or serious injury. Read and understand

all Warnings on this machine.

,PSRUWDQW6DIHW\,QVWUXFWLRQV%HIRUHVHUYLFLQJRUXVLQJWKLVHTXLSPHQWREH\WKHIROORZLQJZDUQLQJV

This icon means a potentially hazardous situation which, if not avoided, could result in death or serious injury. Read and understand

all Warnings on this machine.

5HDGDQGXQGHUVWDQGWKH3DUW5HSODFHPHQW3URFHGXUHEHIRUHZRUNLQJRQWKHPDFKLQH)DLOXUHWRREH\WKHLQVWUXFWLRQVDQGVDIHW\ZDUQLQJVFRXOGFDXVH

LQMXU\WRWKHVHUYLFHWHFKQLFLDQRUE\VWDQGHUV

• .HHSE\VWDQGHUVDQGFKLOGUHQDZD\IURPWKHSURGXFWEHLQJVHUYLFHGDWDOOWLPHV

• 'LVFRQQHFWDOOSRZHUWRWKHPDFKLQHEHIRUH\RXVHUYLFHLW

0DNHVXUHWKDWWKHUHSDLULVGRQHLQDQDSSURSULDWHZRUNVSDFHDZD\IURPIRRWWUDI¿FDQGH[SRVXUHWRE\VWDQGHUV

• 6RPHFRPSRQHQWVRIWKHHTXLSPHQWFDQEHKHDY\RUDZNZDUG(QOLVWWKHVHUYLFHRIDVHFRQGSHUVRQZKHQ\RXGRPDLQWHQDQFHVWHSVLQYROYLQJWKHVH

components. Do not try to do heavy or awkward steps on your own.

•

8VHRQO\UHSODFHPHQWSDUWVDQGKDUGZDUHWKDWDUHVXSSOLHGRUDSSURYHGE\1DXWLOXV)DLOXUHWRXVH1DXWLOXVDSSURYHGUHSODFHPHQWSDUWVFDQDGYHUVHO\

DIIHFWWKHVDIHW\DQGIXQFWLRQDOLW\RIWKHHTXLSPHQWFUHDWLQJDULVNWRXVHUVDQGZLOOYRLGWKHZDUUDQW\

• Be sure that all warning stickers and instructional placards applied to the product stay present and in good condition when doing maintenance or

&XVWRPHU6HUYLFHIRUUHSODFHPHQWODEHOV,ISXUFKDVHGRXWVLGH86&DQDGDFRQWDFW\RXUORFDOGLVWULEXWRUIRUWKHP

'RQRWWU\WRFKDQJHWKHGHVLJQRUIXQFWLRQDOLW\RIWKHPDFKLQHEHLQJVHUYLFHGDVWKLVFDQDGYHUVHO\DIIHFWXVHUVDIHW\

States and other countries. | ORIGINAL DOCUMENT - ENGLISH VERSION ONLY

7RROV5HTXLUHGQRWLQFOXGHG

#2 Phillips screwdriver

Flathead screwdriver

 PP:UHQFK

™

Page is loading ...

Bowflex VeloCore Bike User manual

Related papers

Other documents