TechnicalInformation
Cayman(987)
2/05 ENU 9160 9
CDC-4CDChanger (INo. 692)
Vehicle Type: CaymanS
ModelYear:
As of 2006
Situation: Installation Instructions
Information: Theabove-mentioned vehiclecomesequipped with CDchangerpreparationconsistingof:
-optical waveguideconnection point (atthe frontpanelinthe luggage compartment)and
-power supplyline(at thefrontpanelinthe middleor rightofthe luggagecompartment behindthe trim
panel). Thismeansthatretrofittingcanbe performed withoutany greatexpense.
Beforeorderingparts,alwayscheck and considerthe existingvehicleequipment! Thecorrectoptical
waveguidemustalsobe orderedforthe "CDC-4CDchanger" set!
Thecorrectoptical waveguidetobe used is:
-vehicle type (left-handdrive [LHD])
-equipment version(e.g. with/without soundsystem, navigationmodule)
-installation version (USA/RoW).
Forve hicles with brakeb oosterlining,theplastic luggage compartmenttrim panel
997.551.133.00.02Acan also be retrofitted upon request.
Parts Info:
997.044.900.78 CDchanger
Onlyforvehicles withoutBose SurroundSoundSystem (INo. 680):
2005©Porsche Cars North America,Inc.
Tequipment
Nov16, 2005
Page 1of 8
Cayman(987)
9 9160 ENU 2/05
TechnicalInformation
997.622.708.00 1x Opticalwaveguide, withoutnavigation module
997.622.715.00 1x Opticalwaveguide, withnavigationmodule
Onlyforvehicles withBose SurroundSoundSystem (INo. 680):
997.622.712.00 1x Opticalwaveguide, withoutnavigation module
997.622.713.00 1x Opticalwaveguide, withnavigationmodule
Parts List:
Figure2
997.645.140.02 1x CDchanger
Figure2-A-
997.645.221.00 1x CDchanger suppor t
Figure2-B-
999.703.501.40 2x Insertmounting
Figure2-D-
999.507.766.02 2x Speednut, M6
Figure2-E-
900.378.179.09 2x Hexagon-headbolt,M6 x 16
Figure2-F-
N 014 12813 6x Countersunkscrew, M5x 8
Figure2-G-
997.610.122.00 1x Connectionpointholder(not shown)
ATTENTION
The optical waveguide can become damaged due to incorrectinstallation or if the requirements for handling
opticalwaveguides aredisregarded.
Observe the requirementsfor working with opticalwaveguides
Workshop Manual ’9772IN Optical
waveguide - MOST bus’
Nov16, 2005
Page2 of 8
Tequipment
2005©Porsche Cars Nor th America, Inc.
TechnicalInformation
Cayman(987)
2/05 ENU 9160 9
ATTENTION
Damage to aud io systems
♦
due to voltage spikes
Beforeunplugging/removingan audio system, remove ignition key and switch off theaudio system.
Tools:
Sidecutters Phillipsscrewdriver(medium)
Socket,a/f 10mm Ratchet,3/8-inch withextension
PIWISTester P 9718 Carpetknife
Torquewrench0-30Nm(0-22ftlb.) Needle-nosepliers
WorkProcedure:1 Preparatorywork.
1.1 Removeluggage compar tment cover.
WorkshopManual’703019Removing and installing
luggagecom partmentcover -sectionon "Removing"’
1.2 Onlyfor vehicleswith TirePressureMonitoring controlunit:
Removefasteningscrewon TirePressureMonitoringcontrolunit andlay controlunit toone side.
WorkshopManual’443419 RemovingandinstallingTirePressureMonitoring controlunit-
sectionon "Removing"’
1.3 Onlyfor vehicleswith luggage compartment cooling:
Remove airguide fromfrontpanel.
Figure4
2 Installopticalwaveguide.
2.1 Removeconnection pointholder.
2.1.1 Onlyforvehicles with opticalwaveg uide
component(navigationunita nd/or amplifier)in
theluggage compartment:
Disconnectoptical waveguide connection
point
Figure4 -B-in thefrontluggage
compartment. (Note: Figure3wasnot
applicablefor USA/Canada and wastherefore
skipped)
2.1.2 Removeconnectionpoint holder
Figure4-A-
from plenumpanelusing needle-nosepliers.
2005©Porsche Cars North America,Inc.
Tequipment
Nov16, 2005
Page 3of 8
Cayman(987)
9 9160 ENU 2/05
TechnicalInformation
Figure5
2.2 Onlyfor vehicleswithout opticalwaveguide
componentintheluggagecompartment:
Pullprotectivecap
Figure5 -A- off theoptical
waveguide.
Figure6
2.3 Onlyfor vehicleswithout opticalwaveguide
component:
Routeoptical waveguidefrom opticalwaveguide
connectionpoint
Figure6-A- alongthe plenum
panelto theCDchang er installationposition
Figure6-B- and secureat this po sition.
2.4 Onlyfor vehicleswith optical waveguide
component:
Routeoptical waveguidefrom opticalwaveguide
connectionpoint
Figure6-A- alongthe plenum
panelto theCDchang er installationposition
Figure6-B- andtothe amplifier
Figure6 -C-
andsecureat thisposition.
Note
Ifthe connectionpointholder isdamaged during removal,
usea new connectionpoint holder(see scope ofparts).
Thenpush theplug socketinto thenewconnectionpoint
holder.
2.5 Fastenconnectionpointholder tothe frontpaneland connectopticalwaveguide connection
point.
2.6 Onlyfor vehicleswith optical waveguidecomponent:
Securethestandardopticalwaveguide asa permanentfixture. Thisremainsfunctionlessinthe
vehicle.
3 Exposetheelectric wire(powersup ply) betweenthe carpet liningand frontpanel.
Nov16, 2005
Page4 of 8
Tequipment
2005©Porsche Cars Nor th America, Inc.
TechnicalInformation
Cayman(987)
2/05 ENU 9160 9
Figure7
4 InstallCD changer.
WorkshopManual’916019
Removingand installingCD changer- sectionon
"Installing"’
4.1 AdjustCD changer toinstallationposition.
4.1.1 Loosenadjustingscrews
Figure7.
4.1.2 Adjustinstallation position(horizontal)bymoving
theadjustingscrews.
4.1.3 Tightenadjustingscrews.
Figure8
4.2 Onlyfor USA/Canadianvehicles:
4.2.1 Clipinspeed nuts
Figure8-E-.
Figure9
4.2.2 Clipinser t mounting
Figure9-D- into CD
changerretainingframe.
4.2.3 Insert CDchangerintoCDchanger retaining
frameand tightenfasteningscrews
Figure9
-G-.
Tighteningtorque: 2.5 (2.0 ftlb.) Nm
2005©Porsche Cars North America,Inc.
Tequipment
Nov16, 2005
Page 5of 8
Cayman(987)
9 9160 ENU 2/05
TechnicalInformation
Note
Ensurethatthe inser t mounting isseated correctlyinthe frontpanel.
Figure10
4.2.4 GuideCDchangerretainingframe with inser t
mountings
Figure10 -B- into the frontpanel
from above
Figure10 -Inset-andswivelit
downwards.
SecureCDchangerretainingframewith two
screws
Figure10-A-.
Note
Figure13shows theconnectors (Item s A,B and E)for theRoWversion ofthenavigationunit (CDchanger
andnavigationunit arrangedone on topof theother).
Figure13
4.3 Plugelectricconnectors
Figure13-C- and
opticalwaveguide
Figure13-D- intothe CD
changeruntiltheyarefelttoengage.
Nov16, 2005
Page6 of 8
Tequipment
2005©Porsche Cars Nor th America, Inc.
TechnicalInformation
Cayman(987)
2/05 ENU 9160 9
Note
Figure14shows theRoW version oftheaudio components(CD changerandnavigationunitarrangedone
ontopof theother).
Figure14
5 PositionCDchanger withsupportontothe mounting
pointand pushittowardsthe frontpaneluntil theC D
changersupport clicksinto place.
6 Only for vehicleswith luggage compar tment cooling:
Installair guide.
7 Only for vehicleswith TirePressureMonitoring
controlunit:
Insert TirePressure Monitoringcontrolunitand
tightenfasteningscrews.
WorkshopManual
’443419Removing andinstalling TirePressure
Monitoringcontrolunit- sectionon "Installing"’
8 Installluggagecom partmentc over and tighten
plasticscrews.
WorkshopManual’703019
Removingand installingluggagecompartment cover
-section on"Installing"’
Note
Forfurtherinformation andinstructionson carrying outthemenu items,see
WorkshopManual
’911019Removing andinstalling PCMdisplay andoperator controlunit -sectionon "Programming"’.
9 Code CDchanger.
9.1 Connectbatterycharger.
9.1.1 PIWISTesterP 9718mustthen beconnectedand ignitionswitchedon.
9.1.2 Select"GATEWAY"controlunitand"Coding" functionselection. Press•F12“ to continue.
9.1.3 Inthe"Gatewaycoding" menu,selectRequiredinstalledcomponents listsand press•F8“to
changethe CDchangercoding toInstalled.
9.1.4 Select"PCM2.1" controlunitand "PCM 2.1 MMI"function selection.
9.1.5 Inthe"PCM 2.1MM I functionselection"m enu, selectPlanned & Actualconfiguration andcheck
thatthe CD changerisconfigured.
9.1.6 Inthe"PCM 2.1MMIPlanned & Actualconfiguration" menu,press•F8“ toacceptthe mapping.
9.1.7 Readoutfault memoryanderase itifnecessary.
9.1.8 Switchignitionoffand disconnectPIWIS TesterP 9718 .
2005©Porsche Cars North America,Inc.
Tequipment
Nov16, 2005
Page 7of 8
Cayman(987)
9 9160 ENU 2/05
TechnicalInformation
9.1.9 Disconnectbatterycharger.
9.2 Performa functiontest.
WorkingTime: 916023 00: InstallingCDC-4 CDchanger Labortime: 100 TU
Includes: InstallingCD changer,routingopticalwaveguide intheluggage
compartment and codingPCM with thePIWIS Tester.
Without: Retrofitting plastictrimp anel forluggagec ompartment.
References:
WorkshopManual’443419Removing and installingTirePressure Monitoring controlunit’
WorkshopManual’703019Removing and installingluggagecompartm ent cover’
WorkshopManual’911219Removing and installingnavigationunit’
WorkshopManual’916019Removing and installingCDchanger’
Important Notice: Porsche CarsN.ATechnical Bulletinsare intendedfor useby professionaltechnicians, nota "Do-it-yourselfer." Theyarewrittento informthese technicians ofconditions thatmay
occur o n some vehicles,or toprovide informationth a t could assist in the properservice ofa vehicle. Specialtoolsmay berequiredto perform certain operations i de n tified in thesebulletins. Use oftools
andprocedureso ther than thoserecommended inthese bulletinsmay bedetrimentalto thesafe operationof yourvehicle. Properlytrained tec hnicianshave theequipment, tools,safety instructions
andknow-how to do ajob properlyandsafely. If aconditionis described,do notassume thatthe bulletinapplies toyour vehicle, or thatyour vehicle will havethat condition. See yo ur Porsche Dealerfor
information onwhether yourvehicle may b enefitfromthe information. Part numbers listedin thesebulletins arefor referenceonly. Alwayschec k withyour authorized Porsc he dealerto verifycorrectpar t
numbers.
©Porsche Cars NorthAm erica, Inc.
Dealership
Distribution
Routing
ServiceManager
Asst. Manager
_______
_______
ShopForeman
Warranty Admin.
_______
_______
ServiceTechnician
ServiceTechnician
________
________
_______
_______
_______
_______
_______
_______
Dr. Ing. h.c. F.Porsche AGis theowner ofnumerous trademark s, bothregisteredand unregistered,including withoutlimitat ion the Porsc he Crest®,Porsche®, Boxster®,Carrera®,Cayenne®,
Tiptronic®,VarioCam®, PCM ®,911®, 4S®,and themo d el numbers and distinctive shapesof Porsche’saut omobilessuch as,the federallyregistered911 automobile. The thirdparty trademarks
contained hereinarethepropert ies ofth eir respectiveown ers. Porsche Cars North America,Inc., believesthe specifications to be correctatthe timeof printing. However,specifications, standard
equipmentand options aresubjectto changewithout notice.
Printed inthe USA
Nov16, 2005
Page8 of 8
Tequipment
2005©Porsche Cars Nor th America, Inc.
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Porsche Mobile Charger Connect Operating instructions
-
-
-
-
-
-
-
-
-
Other documents
-
Signat Porsche S865071 User manual
-
Mooney SBM20-238 Owner's manual
-
Fiberplex WEN-6-1.5 User manual
-
Pride BOXTER Owner's manual
-
-
Psion Teklogix 9160 User manual
-
-
-
Dension Gateway 500S Installation guide
-
Mobridge A2011 Installation guide
