PurePro LUX-106UV-P User manual

PurePro
Brand
PurePro
Model
LUX-106UV-P
Category
Water dispensers
Type
User manual
P
R
O
P
URE
DRINKING WATER SYSTEM
REVERSE OSMOSIS SYSTEM
Thank you very much for selecting Pure-Pro Water Corp.
In order to bring the best use of your system, please read
the user's manual carefully before installation and follow
the regulations.
USER'S MANUAL
01 Introduction of LUX-106UV-P
02 What is reverse osmosis
03 Components & Selected filters
04 The parts of LUX-106UV-P
05 Cartridge filters
06
07 Tubing connection diagram
08 Installation diagram
09 Change filters
10 Change membrane
11 Operation regulation
13 FAQ
14 Maintenance checking list
15 Memo
Ultraviolet Water Sterilizer
LUX-106UV-P
01
PURE-PRO REVERSE OSMOSIS SYSTEM
P
R
O
P
URE
DRINKING WATE R SYSTEM
Membrane: 100 GPD / 378 LPD
With a transformer, available in 110Volt, 220Volt or 240Volt (50/60Hz)
Operation pressure: 5 -80 psi
Dimensions: (cm) 37 (L) x 20 (W) x 45 (H) - System
(cm) 28 (L) x 28 (W) x 35 (H)- Tank
Weight: 8 kg - system
4 kg - tank
¨Features
100GPD membrane. (Made in USA)
3.2 Gallons NSF Standards Water Storage Tank.
FDA Approved Polypropylene Made Flat Cap Housing (double o'ring).
Automatic Shut-off Valve, Flow Restrictor, Stainless Steel Check Valve.
New Euro-Luxury faucet - supreme quality with elegant design.
Feed water connector.
Drain Saddle Valve.
Four Color Coded 1/4 inch Tubing for System Connection.
Completely Assembled.
PurePro label with USA Flag.
100% Factory Tested and Sterilized Ready for Installation.
Installation Instruction.
¨Specifications
Luxury pump RO system
Introduction of LUX-106UV-P
¨Supreme Quality, Luxury RO System
A combination of the best of World. RO and UV system. The UV light will disinfect
filtered water at normal flow rate, providing one of the safest filtering systems
available. Bacteria, viruses and other micro-organisms are destroyed by
interfering with the DNA and RNA in the organisms' reproductive cycles. It cause
immediate death for organisms and wipe out their ability to survive and reproduce.
LUX-106UV system provides safe, pure water using Reverse Osmosis
Technology. It is one of the finest units in its class. It uses no chemicals or
electricity and provides premium water quality. It's capable of removing over 95%
of total dissolved solids, +99% of all organic and +99% of all bacteria.
Reverse osmosis was originally designed to make sea water drinkable for the
navy. It is ideal for anyone on a low sodium diet. An R.O. membrane has a pore
size much smaller than bacteria virus, or the cryptosporidium parasite. When
functioning properly it will remove all microorganisms from tap water and produce
sterile water. Reverse osmosis is the reversal of the natural flow of osmosis. In a
water purification system, the goal is not to dilute the salt solution, but to
separate the pure water from the salt and other contaminants. When the natural
osmotic flow is reversed, water from the salt solution is forced to pass through the
membrane in the opposite direction by application of pressure-thus the term
REVERSE OSMOSIS. Through this process, we are able to produce pure water
by screening out the salts and other contaminants.
02
PURE-PRO REVERSE OSMOSIS SYSTEM
P
R
O
P
URE
DRINKING WATE R SYSTEM
What is reverse osmosis
Reverse Osmosis
Pressure
Membrane
Water flow
Luxury pump RO system
03
PURE-PRO REVERSE OSMOSIS SYSTEM
P
R
O
P
URE
DRINKING WATE R SYSTEM
Components & Selected filters
3.2G water storage tank
Housing wrench
Deliver-valve Water supply connector Drain saddle
¨Selected filters
¨Components
Alkaline filter
Tank ball shut-off valve
Tubing
Alkaline
Luxury pump RO system
New Euro-Luxury faucet
Mineral filter
Mineral
Infra-Red filter
Infra-Red
04
PURE-PRO REVERSE OSMOSIS SYSTEM
P
R
O
P
URE
DRINKING WATE R SYSTEM
Luxury pump RO system
The parts of LUX-106UV-P
Front view
Top view
High pressure protector
Transformer
Pump
Flow restrictor
To drain out tube
Auto shut-off valve
RO membrane housing
Post carbon filter
IN
OUT
IN
The 1st stage housing
The 2nd stage housing
The 3rd stage housing
To the tank
To the faucet
Input water
UV water sterilizer
05
PURE-PRO REVERSE OSMOSIS SYSTEM
P
R
O
P
URE
DRINKING WATE R SYSTEM
Service Life
6 Months
2 Years
1 Year
Cartridge filters
Stage 1
Stage3
Stage 2
Stage 4
TFC Membrane
Stage 5
Post Carbon Filter
Cartridge Filters
Filter Description
6 Months
6 Months
This 5micron sediment filter is made of 100%
pure polypropylene fibers. High capacity filter
removes dusts, particles and rusts.
This 1micron sediment filter is made of 100%
pure polypropylene fibers. High capacity filter
removes dusts, particles and rusts.
Made in USA. High rejection TFC type membrane
with the capacity of producing 100 gallons per day.
This membrane removes the following hard water
contaminants that may be present in your water:
lead, cooper, barium, chromium, mercury, sodium,
cadmium, fluoride, nitrite, nitrate, and selenium.
NSF approved. This post carbon filter is designed
to improve taste. It removes any residual
impurities and odors from the tank and provides a
finer conditioning of pure water.
5 Micron
Sediment Filter
1 Micron
Sediment Filter
Stage 6
1 Year
Block Carbon Filter
This block carbon filter is composed of high-
performance carbon that removes free chlorine,
odor, organic contaminants, pesticides and
chemicals that contributed to taste and odor.
Luxury pump RO system
1GPM Heavy duty stainless steel 304 pressure
vessel. Heavy duty quartz sleeve. High output,
hard glass UV lamps for maximum efficiency. CE
ballast with lamp failure indicator and warning
buzzer.
UVC-LIGHTING
ULTRAVIOLET WATER STERILIZER
UV Water Sterilizer
06
PURE-PRO REVERSE OSMOSIS SYSTEM
P
R
O
P
URE
DRINKING WATE R SYSTEM
Luxury pump RO system
Ultraviolet Water Sterilizer
stainless steel 1gpm uv system
The knack of 1gpm PUREPRO UV system lies in employing the 254nm ultraviolet
rays (UV-C) to caused immediate death for organisms or wipe out their ability to
survive and reproduce.
1. Take out the UV sterilizer from the box as shown in the picture.
3. Connect the wire to both ends of UV lamp.
4. Tight up the UV cap.
Install UV lamp :
UV lamp
Wire
UV cap
Stainless steel UV sterilizer
UV quartz
2. Open the cap and insert the UV quartz.
PURE-PRO REVERSE OSMOSIS SYSTEM
07
P
R
O
P
URE
DRINKING WATE R SYSTEM
Tubing connection diagram
CONNECTING THE COLOR TUBING:
A. Connect the WHITE tubing to the water supply connector.
B. Connect the BLUE tubing to the sink top faucet.
C. Connect the BLACK tubing to the drain saddle.
D. Connect the RED tubing to the storage tank.
Luxury pump RO system
Faucet
Tank
Drain
Input water
A
B
C
D
08
PURE-PRO REVERSE OSMOSIS SYSTEM
Input water : Install water tank :
Install drain saddle :
Assemble membrane :
Drill a 1/4" hole into
the drain pipe.
Mount drain
saddle aligning
holes.
Installation diagram
P
R
O
P
URE
DRINKING WATE R SYSTEM
Faucet
Kitchenware table
Twisted plastic locker
Rubber gasket
Flat metal piece
Screw locker
Tubing
Cutting ring
Concave type screw
Install faucet :
Luxury pump RO system
P
R
O
P
U
R
E
D
R
I
N
K
I
N
G
W
AT
E
R
S
Y
ST
E
M
Loose the Jaco fitting anticlockwise.
Jaco
Remove the membrane housing cap.
Install the membrane by carefully
pushing the spigot end into the
socket at the far end of the housing
until completely in.
Hand tighten
plastic shut-off
valve to tank.
Then connect
color tubing.
To RO system
Tank ball shut-
off valve
To RO system
Deliver valve
Water supply connector
To water
source pipe
09
PURE-PRO REVERSE OSMOSIS SYSTEM
P
R
O
P
URE
DRINKING WATE R SYSTEM
Micro Computer Controller
POWER
SOURCEPROCESSFLUSH
FULL
To RO system
1 Prepare a housing
wrench.
2 Turn off water
source.
4 Unplug electricity.
6 Put the replacement filters in the
housings and double O' ring.
7 Drain out 1 Gallon of water to
purify replacement filters.
3 Switch off water tank.
Change filters
Be sure tighten with
O-ring to prevent
from leaking.
5 Open housings clockwise with a wrench.
Luxury pump RO system
10
PURE-PRO REVERSE OSMOSIS SYSTEM
P
R
O
P
URE
DRINKING WATE R SYSTEM
P
R
O
P
U
R
E
DR
I
N
K
I
N
G
W
A
T
E
R
S
Y
S
T
EM
5 Remove the membrane housing
cap anticlockwise.
PR
O
P
U
R
E
D
R
I
N
K
I
N
G
W
A
T
E
R
S
Y
S
T
E
M
6 Remove the membrane by a pincer.
7 Install the membrane by carefully
pushing the spigot end into the
socket at the far end of the housing
until completely in.
To RO system
1 Unplug electricity.
2 Turn off water source. 3 Switch off water tank.
Change membrane
Luxury pump RO system
Jaco
4 Loose the Jaco fitting anticlockwise.
11
PURE-PRO REVERSE OSMOSIS SYSTEM
P
R
O
P
URE
DRINKING WATE R SYSTEM
5 Let the water run for at least 30
minutes. This flushes the carbon
filters on first time use.
1 Plug in electricity.
2 Turn on water source.
3 Switch on water tank.
Operation regulation
To RO system
Luxury pump RO system
4 Pump starts to function.
Pump
12
PURE-PRO REVERSE OSMOSIS SYSTEM
P
R
O
P
URE
DRINKING WATE R SYSTEM
A.With everything connected, turn on the water check for leaks.
B.Make sure the storage tank shut-off valve is "OFF". Open the sink
top faucet.
C.Within a few minutes (up to 15) the water will start to run from the
faucet slowly.
D.Let the water run for at least 30 minutes. This flushes the carbon
filters on first time use.
E.After initial flushing, open the shut-off valve on the tank and close
the sink top faucet.
F.Tank will now full of water (usually 2 to 3 hours) after the tank has
filled. Open the sink top faucet and drain all water until the storage
tank is empty and there is only a small flow from the sink top
faucet.*** DO NOT USE FIRST TANK OF WATER.***
G.Close the sink top faucet. The system is now ready for use.
H.Change filters regularly every 6 to 12 months and have the
membrane checked annually.
Caution
0
1.Do not use hot water (over 45 C)!
2.Do not freeze the machine!
3.Switch off electricity and water source if away for more than 5 days,
and drain out pure water.
Operation regulation
Luxury pump RO system
13
PURE-PRO REVERSE OSMOSIS SYSTEM
P
R
O
P
URE
DRINKING WATE R SYSTEM
FAQ
Q: What is the guarantee on the PurePro system ?
The PurePro system (excluding filters) is guaranteed for 1 year for material and
workmanship. All defective parts will be replaced free within the first year under
natural breakdown. The membrane has one year pro-rated guarantee.
Q: What factors affect the quantity and the quality of the water production?
There are four major variables to consider:
1.Pressure-The greater the water pressure, the better water quantity and
quality it produced. Water pressure of 60 PSI is ideal.
00
2.Temperature-76 F is the ideal water temperature for R.O. 40 F water will
0
cause the production of R.O. water to fall to half of that at 76 F. The maximum
0
water temperature recommended is 85 F.
3.Total Dissolved Solids (TDS)-The higher the amount of dissolved
contaminants in the water, the lower the quantity of water produced. A high
level of TOTAL DISSOLVED SOLIDS can be overcome with additional water
pressure.
4.Membrane-Different membranes have different characteristics. Some
produce more water than others; some have better contaminant rejection
capabilities; some have greater resistance to chemical abrasion for longer life.
PurePro system includes TW30-1812-100 The Thin Film Composite (TFC)
membranes combine the best of these characteristics and are considered the
finest membrane in the world.
Q: What is the maintenance schedule for the PurePro system ?
The three pre-filter cartridges should be changed every 6 months. The 5 micron
sediment cartridge filter is the first one; the second is a carbon cartridge filter,
and the third one is a 1 micron sediment filters. (some systems comes with the
Extruded carbon filter.) Failure to change the cartridge every 6 months may
cause chlorine to destroy the membrane.
Q: What does the PurePro series drinking water taste like?
The taste of the PurePro water depends on the amount of contaminants in the
tap water originally. If 95% of dissolved minerals and chemicals are removed,
the R.O. water may taste like distilled water (no minerals), bottled water (low
mineral), or natural spring water (moderate mineral content).
Luxury pump RO system
14
PURE-PRO REVERSE OSMOSIS SYSTEM
P
R
O
P
URE
DRINKING WATE R SYSTEM
Maintenance checking list
Date
Filters
1st stage 2nd stage 3rd stage
4th stage 5th stage 6th stage
Luxury pump RO system
15
PURE-PRO REVERSE OSMOSIS SYSTEM
Type of product
Date of purchase
Name Tel
Address
P
R
O
P
URE
DRINKING WATE R SYSTEM
Memo
Luxury pump RO system
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16

PurePro LUX-106UV-P User manual

PurePro
Brand
PurePro
Model
LUX-106UV-P
Category
Water dispensers
Type
User manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents