Kenmore 25370083000 Owner's manual

Brand: Kenmore

Model: 25370083000

Type: Owner's manual

Owner's Manual

n_isowner's Guideprovidesspecificoperatinginstructionsforyourmodel.Usethe air

conditioneronlyasinstructedin thisguide.Theseinstructionsarenotmeantto cover

every possiblecondition and situation treat may occur. Common sense and caution

must be practicedwhen instafling,operating, and maintaining any appliance.

Record Your Model and seriaJ Numbers

Recordin the space provided below the model and seda[ numbers. The serial plate is

located behind filter at the bottom of unit. Readingthe numbers may be easier by _sing

a flashlightor by remowng the cabinet front as instructedunder "Care and Cleaning."

Model Number:.

Serial Number.

Purchase Date:

P/N309000827 (11/99)

Important Safety

Instructions

Avoid fire hazard or

electdc shock. Do not use an extension

cord or an adaptor plug. Do not remove

any prong from the power cord.

Grounding type

wall feces

under _'_

any drcumstances, )

cut, remove, l

or bypassthe )

_grounding prong.._

Power supply

• cord with 3-prong

grounding plug

Read all instructions before using this air conditioner.

For Your Safety

Do not store or use gasoline or other flammable vapors and liquids in the vicinityof

this or any other appliance. Readprc_luct labelsfor flammability and other warnings.

Prevent Accidents

To reduce the risk of fire, electrical shock, or injury to persons when usingyour air

conditioner, follow basic precautions, including the following:

• Besure the electrical service isadequate for the model you have chosen.

• If the air conditioner isto be installed in a window, you witl probably want to

clean both sides of the glass first. If the window is a triple-track type with a

screen panel induded, you may went to remove the screen completely before

installation.

• Be sure the air conditioner has been securely and correctly installed accordingto

the separate installation instructions provided with this manual. Save this

manual. Save this manual and installation instructions for possible future use in

removing or reinstallingthis unit.

• When handling the air conditioner, be careful to avoid cuts from sharp metal fins

on front and rear coils.

Electrical Informationf13__=_amm

The complete electrical rating of your new room air conditioner is stated on the

serial ptate. Refer to the rating when checking the electrical requirements.

• Be sure the air conditioner is properly grounded. To minimize shock and fire

hazards, proper grounding is important. The Dower cord is equipped with a

three-prong grounding plug for protection against shock hazards.

• Your air conditioner must be used in a properly grounded wall receptacle. If the

wall receptacle you intend to use is not adequately grounded or protected by a

time delay fuse or circuit breaker, have a qualified electrician install the proper

receptacle.

• Do not run air conditioner with outside protective cover in ptace. This could result

in mechanical damage within the air conditioner.

• Do not use an extension cord or an adapter plug.

Energy Saving Ideas

• The capacityof the roomair conditioner must fit the room sizefor efficient and

satisfactoryoperation.

• Installthe room air conditioneronthe shady sideof your home. A window that

facesnorth isbest becauseit isshadedmost of the day.

• Do not block air flow inside with blinds, curtains or furniture; or outside with

shrubs,enclosures,or other buildings.

• Close the fireplacedamper, floor and wall registersso cool air doesnot escape

up the chimney and into the duct work.

• Keepblinds and drapesin other windows closedduring the sunniestpartof the

day.

• Cleanthe air filter as recommendedin the section "Care andCleaning."

• Properinsulation and water strippingin your home will help keep warm airout

and cool airin.

• External house shading with trees, plants or awningswill help reducethe air

conditioner'swork load.

• Operate heat producing appliances such as ranges, washers, dryers and

dishwashersduring the coolestpart of the day.

How and Why

Your room air conditioner provides the following functions to make hot weather

living more comfortable:

• Cools and circulatesroomair.

• Lowershumidityby removingexcessmoisture.

• Filtersout summertime dust,dirt,andsome airborneimpurities.

The air conditioner performs thesefunctions bydrawing room air through a filter I_,

wh ch traps dust and dirt particles.Theair then passesover a cooling coil which !

refrigerates the air and removesexcessmoisture. The same air isthen returned to

the room --- cooler,drier and cleaner.Moisture removedfrom theroom air iscarried

to the outsideand evaporated.

Your air conditioner is designed tO be easyto operate and to provide plenty of

cooling power.

Normal Sounds

At thefront of theunit,

y_u may

of rushingair being moved

bythefan.

Sound

Ascoolingsystemscycleon

and off, you may hear a

"dicking" sound.

Today'shighefficient

compressorsmay havea

highpitchedchatterduring

the coolingcycle.

Unit may vibrateand make

noisebecauseof poorwall

orwindow constructionor

incorrect installation.

Pinging or Swishing

Dropletsof water hitting

duringnormal

operationmay cause

"pinging or swishing"

sounds.

_Gurgling orhissing"

noisemay be hearddue to refrigerant

passingthrough evaporationduringnormal

operation.

rl_all_Jm

Using Air Conditioner

To reduce the risk of fire, electric shock, or injury to persons, read

the IMPORTANT SAFETY INSTRUCTIONSbefore operating this appliance.

NOTE:Ifthe airconditioneristurnedoff,

wait 3 minutes before restarting. This

allows pressureinsidethe compressorto

equalize. Failure to follow these

Jinstructions may cause inefficient

[operation.

To begin operating the air condffioner, follow these steps:

1. Plug inthe air conditioner. (To prevent electricar hazards, do not use an extension

cord or an adapter plug.)

2. Set the thermostat to the highest number (coldest or cooler setting).

3. Set the selector control to the highest COOL setting (see below).

4. Adjust the louvers for comfortable air flow (see Air Directional Louvers).

5. Once the room has cooled, adjust the thermostat to the setting you find most

comfortable.

Review the "Air Conditioner Features" section for other settings.

Air Conditioner Features,

The contmb featured in this manual are representational of the many models

available. Yourmodel may offer slightlydifferent features.

COOL Mode

When in one of the COOLsettings,the airconditioner runs all the time, circulating

the air. Cooling starts only if the room temperature risesabove the coolnesslevel

selectedon the TEMPControl, and stopsoncethe setcoolnesslevelisreached.This

setting givesthe most evenroom temperatures.

FAN Mode

When in the FANsetting, the fan runs continuously to circulate air in the room

without cooling.

TEMP Control

TheTEMPControl servesasthethermostat toset thedegreeof roomcoolness.Turn

the knob clockwisefrom 1 to 9 to increasethe coolingtemperature.

HEAT (some models)

The HEATselectionprovidesquiet,efficientcirculation ofwarm air.Turnthe selector

to the HEATsetting and set the thermostatto the warmestsetting (1).When the

HEATsetting isselected,the thermostat maintainsthe temperaturebyautomatically

turning the heateron and off in responseto room temperature. Oncethe room is

warm, adjust the thermostat to a cooler setting. The fan runs continuously to

circulate air in the room.

Conditioner Features Air Directional Louvers

Air directional louvers control air flow direction. Your air conditioner has the louver

(continued)

type described below.

(4 WAY)

4-Way Louvers

The 4-Way air directionallouversallow you to directair flow up or down, left or

rightthroughoutthe roomasneeded To adjustthe air directionallouversside-to-

side,usethe centerhandle asyoumove itside-to-side,

Care and Cleaning

RG. 1

Cleanyourairconditioneroccasionallyto keep it looking new. Besure to unplug

the unit before deaning to prevent shock or fire hazards.

Air Filter Cleaning

The air filter should be checked at leastonce a month to seeif cleaning isnecessary, aroma=

Trapped particles in the filter can build up and cause an accumulation of frost on

the cooling coils.

"• Grasp filter and remove by pu]ling the filter up and out (FIG. 1).

• Wash filter with warm soapy water. Rinsethoroughly. GentJyshake excesswater

from filter. Be sure filter isthoroughly drybefore replacing.

Or,

Instead of washing you may vacuum the filter dean.

• Reinstallthe fitter by sliding filter beck into place.

Cabinet Cleaning

• Be sureto unplug the air conditionerto prevent shockor fire hazard. The cabinet and

from may be dusted with an oil-free doth or washed with a cloth dampened in a

solutionof warm water and mild liquid dishwashing detergent. Rinsethoroughly and

wipe dry.

• Never use harsh cleaners,wax or polishon the cabinet front.

• Be sure to wring excesswater from the doth before wiping around the controls.

Excesswater in or around the controlsmay causedamage to the air conditioner.

• The cabinet front can be removed for more thorough cleaning,

• Removefilter

• Removethe two (2) screwsbehind the filter that hold the fTontframe to the unit.

• Removethe knobs from the controls.

• Pressfirmly on each side of the cabinetclose to the from. While pressing, gently pull

the front out and lift up to remove.

• Clean the front in a sink using liquid dishwashing detergent and warm water. Rinse

thoroughly and dry.

• Replacecabinet front (reverseabove instructions).Replacethe screws.

'_Replacefilter. Plug in air conditioner.

Routine Maintenance

W',nter Storage

If you plan to store the air conditioner during the winter, remove it carefully from

the window according to the installation instructions. Cover it with plasticor return

dt to the original carton_ NOTE: To prevent rust or electrical connections from

being damaged, store air €onditioner in an upright position and a dry place.

A winter cover can be purchased from your dealer, The cover will protect the air

conditioner when it isleft in place through the winter,

Before performing any service,unplug the power cordfrom

the electricaloutlet.

After servicing,reversethefollowing proceduresto reinstall the air conditioner.

Cleaning the Cabinet Front

Removethe frontpanel.Washwith warm, sudsywater. Rinseand drywith asoft

cloth. Neverusesolvents,cleaningfluids,abrasivecleanersor strong detergents.If

thepackagingleavesa gumresidue,removewith a clothdippedinrubbingalcohol.

Repairing Paint Damage

Inspectweather-exposedparts (cabinetshell, mounting hardware, if used,etc.)

onceor twicea year,especiallyin areasnearoceansor where rustisa problem,ff

needed,touchupwith a goodgradeof extedorpaint.

Cleaning Inside the Air Conditioner

No liquid should get into the motor, electricalcontrolbox,or

compressorelectricalterminals.

1. Removefront panel.

2. With help and using the proper lifting methods to avoid personal injury, remove

the chassisfrom cabinet shell.* When removing the air conditioner from cabinet

shellor window, there may be water inside the base that may spill on the floor.

Be careful to avoid cuts from sharp metal fins on the front and rear coils.

3. Uquidsshould not get into electricalparts. Warp the fan motor, electricalcontrol

box, and electrical terminals in plastic. This will keep water or other liquid from

getting inside where it could danlage the insulation and cause serious _rouble.

4. Clean and hose out base, coils, and water pans. Clean at least once a year or

more often if the coils and panscollect dirt, sand, leaves, algae, or insects.

5. After cleaning, remove plastic protection. Wait 24 hours before starting the unit

again. This allows time for all areas to dry out.

NOTE: Water from rainfall or from normal use does not harm these components

sincethe water isnot asforcefully driven into parts as a stream of water from a

garden hose.

*HANDLE NOTE: If the air conditioner has a chassis handle, it isNOT intended for lifting

the unit. it is for sliding the chassisWITHINthe cabinet shell only (to aid in cleaning,

maintenance, etc.).

Room Air ConditionerTroubleshooting Guide

THE AIR CONDITIONER WILL NOT OPERATE

Cheek If ..,

The power supply cord isunplugged.

A household fusehasblown or circuitbreaker

tripped.

The FanControl issetto OFF

Firmlyplugthe cord into a liveoutletwith propervoltage.

Replacethe fuseor resetthe circuit.Make surethe unit isplugged into a

propedy groundedreceptacleasdescribedin the OwnersManual

_rovidedwith the unit.

SetFanControl to the desiredsetting.

THE UNIT BLOWS FUSES OR TRIPS CIRCUIT BREAKER

Check If ...

Too manyappliancesare beingused onthe

samecircuit.

An extensioncord isbeing usedwith the unit_

The unitisbeing restartedimmediatelyafter

turningoff coolingcircuit.

T_ o,,

Unplugore relocate appliancesthat sharethe samecircuit.

IDo not usean extensioncordto run the air conditioner.

Waitthreeminutes after turningoff cooling unitbefore tryingto restart

unit

THE AIR CONDITIONER TURNS ON AND OFF, OR DOES NOT COOL ROOM

Ch_k If .,4

Thefilter isdirtyor obstructedby debds.

The cotisaredirty or obstructeclby debris. Check

both insideevaporatorand outsidecondenser

coils

There k excessivemoisture or heatinthe room

being cooled(cooking,hot showers,etc.)

The FanControl ison a PowerSaver/Energy

Saversetting.

TheVent Control issetto OPENor EXHAUST.

TheTemperatureControl isnot at a coolenough

setting.

T_ °,,

Cleanfilter usingavacuumcleaneror washfilter in warm water and a

mild detergent.Drythoroughlybefore reuse.

Callthe local Searsstore to inspectand dean the coils and condensate

water passages. OR Iffamiliar with electrical appliances

_erformthe mcluireddeaning by carefullyfollowing the maintenance

instructionsprovidedwith the unit.

Iseexhaustventfanswhile cooking orbathing and try not to use

heet-preducing appliancesduringthe hottest part ofthe day.

UseNORMALsettings for best comfort. When the Power Saversettings

are in use,the fan doesnot circulate the room air continuously.

Setthe Vent Control to CLOSEDfor maximum cooling.

SettheTemperature Controlto a cooler setting.

WATER DRIPS FROM THE CABINET INTO THE HOUSE

If ... Then ...

The unitisnot leveled properly.Theunitshould Levelthe air conditionerto providea 1/4" downward slopeto the outside

sope sight y downwardto the outside. (Yzbubbleoncarpenter3level)to provideproperdrainage.Repositionor

shimthe cabnetasnecessary.DO NOTdri a hole in the drain pan.

THE AIR CONDITIONER SEEMSTO RUN TOO MUCH

If .,. Then ..

The currentunit replaced an oldermodel. Theuse of moreefficient components maycausethe unitto run longer

than anoldermodel, butthetotal energyconsumption will be less.Newer

unitsdo notemit the "blast"of cold airyou may be accustomedto from

older units,but this ISNOTan indicationof lessercooling capadty or

efficiency.Referto the effidencyrating(EER)and capacityrating (in

BTUs)marked onthe unit.

The unit isin a heavilyoccupiedroomor heat- Useexhaustventfanswhile cooking or bathing.Trynot to useheat-

)roducingappliancesare in useinthe room. producingappliancesduringthe hottestpart ofthe day.A higher capacity

unit ma)'be requireddepending]onthe sizeof the room beingcooled.

TYPICAL AIR CONDITIONER SOUNDSYOU MAY HEAR:

Condenser - You mayheardropletsofwater hitting Compressor - Themodern highefficiencycompressormay have

the condenser,causinga "pinging"or "clicking"sound, ahighpitched humor puLsaUngnoisethat cycleson and off.

Unit Vibra_qn - The unitmay vibrateand make noise Thermostat - Asthe coolingsystemcycles,the thermostat

becauseof poorwallor windowconstruction, mayclick.

Fen - Youmay hearair movementfrom the fan.

D/817 TPS-S4-- Room/_r conditioner T_Jbieshooting Guide -- aev_o_ "A" -- March 18, 1996 -- Page1 of 1 O Sears,Roebuck _ Co.

Warranty

WARRANTY

Full One-Year Warranty on Air Conditioner

Forone yearfrom date of purchase,when this air conditionerisoperatedend

maintained for normal room cooling accordingto instructionsin this owner's

manual,Searswillrepairit, free of charge,if defectivein material orworkmanship.

Full Five-Year Warranty on Sealed Refrigeration System

Forfiveyearsfromthe dateof purchase,when thisairconditioner isoperatedand

maintained for normal room cooling accordingto instructionsin this owner_

manual,Searswillrepairthe sealedrefrigerationsystem (consistingof refrigerant,

connectingtubing, and compressor),free of charge, if defectivein material or

workmanship.

Warranty Service

Warrantyserviceisavailable bycontactingthe nearest servicecenterin the United

States,

Thiswarrantygivesyouspecificlegaldghts, and you may have other rights whichvaryfrom

statetostate.

SEARS,ROEBUCKand CO. Dept. 817WA, Hoffman Estates, IL 60179

Sears Service

Maintenance Agreement

"We ServiceWhat We Sell" iso.urassuranceyoucan depend on Searsfor service.

Yourairconditionerhasaddedvaluewhen youconsiderthatSearshasserviceunits

nationwide,staffed with professionaltechnicianstrained on all appliances Sears

sells.Theyhavethe knowledgeand skills,tools,parts,and equipmentto insureour

pledgeto youthat _We ServiceWhat We Sell"

Sears Maintenance Agreement

Maintain thevalueof yourair conditionerwith a SearsMaintenance Agreement.

Searsair conditionersare designed, manufactured, and tested for years of

dependableoperation.Yet, anymodernappliance may requireservicefromtimeto

time.TheSearsMaintenanceAgreementoffersyouanoutstandingserviceprogram

for yourairconditioner.

The Sears Maintenance Agreement

• Isyourwayto buytomorrow's serviceat today'sprice.

= Eliminatesrepairbills resulting from normal use.

• Allows for asmany servicecallsas required.

• Providesan annual PreventiveMaintenance Checkat your request to keepyour

Air Conditioner in properrunning condition.

For more information, call 1-800-827-6655

Kenmore 25370083000 Owner's manual

Kenmore 25370083000 Owner's manual

Kenmore 25370083000 Owner's manual

Related papers

Other documents