Harman XXV Owner's manual

Brand: Harman

Model: XXV

Category: Stoves

Type: Owner's manual

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/151 3-90-00684c

Model(s):

XXV Freestanding Pellet Stove

INSTALLER: Leave this manual with party responsible for use and operation.

OWNER: Retain this manual for future reference.

Contact your local dealer with questions on installation, operation or service.

NOTICE: SAVE THESE INSTRUCTIONS

Please read this entire manual before

installation and use of this pellet fuel-

burning room heater.

Failure to follow these instructions could

result in property damage, bodily injury

or even death.

• Donotstoreorusegasolineorotherammablevapors

andliquidsinthevicinityofthisoranyotherappliance.

• Donotoverre-Ifanyexternalpartstartstoglow,you

areoverring.Reducefeedrate.Overringwillvoid

yourwarranty.

• Complywithallminimumclearancestocombustibles

asspecied.Failuretocomplymaycausehousere.

Checkbuildingcodespriortoinstallation.

• InstallationMUSTcomplywithlocal,regional,stateand

nationalcodesandregulations.

• Contactlocalbuildingorreofcialsaboutrestrictions

andinstallationinspectionrequirementsinyourarea.

Testedandapprovedforwoodpelletfuelonly.Burning

ofanyothertypeoffuelvoidsyourwarranty.

Hot glass will cause burns.

• Donottouchglassuntilitiscooled.

• NEVERallowchildrentotouchglass.

• Keepchildrenaway.

• CAREFULLYSUPERVISEchildreninsameroomas

stove.

• Alertchildrenandadultstohazardsofhightemperatures.

High temperatures may ignite clothing or other

ammable materials.

• Keepclothing,furniture,draperiesandotherammable

materialsaway.

HOT SURFACES!

Glass and other surfaces are hot

duringoperationANDcooldown.

To obtain a French translation of this manual, please

contactyourdealerorvisitwww.harmanstoves.com.

Pourobtenirunetraductionfrançaisedecemanuel,s’il

vous plaît contacter votre revendeur ou visitez www.

harmanstoves.com.

NOTE

WARNING

Owner’s Manual

Care and Operation

XXV

Use&CareVideo

CAUTION

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/152 3-90-00684c

Ne remplacer la vitre qu’avec une vitre céramique 5 mm de même qualité

disponible auprès de votre revendeur.

Pour une information plus complète, se reporter à la notice d’utilisation

Tenir la porte frontale et le couvercle de trémie hermétiquement clos durant le

fonctionnement de l’appareil.

DISTANCES DE SECURITE PAR RAPPORT AUX MATERIAUX

COMBUSTIBLES

Entre Mur Arrière et appareil 76 mm

Entre Paroi latérale et appareil 305 mm

Installation en angle

Entre murs et apparell 159 mm

Installation en alcôve

Hauter minimale de l’alcôve 1524 mm

Parois latérales de l’alcôve 305 mm

Profondeur maximale de l’alcôve 914 mm

PROTECTION DU PLANCHER

Côtés 200 mm

Arrière 200 mm

Avant 450 mm

*mesurer à partir de la surface de la porte en verre.

Utiliser une protection de sol non combustible sous l’appareil qui s’étend sur

les côtés. l’avant et l’arrière du poêle (voir schéma).

ll est recommandé que la protection s’étende jusque sous le conduit en cas

d’installation d’un conduit horizontal ou sous le té en cas de conduit vertical.

US ENVIRONMENTAL PROTECTION AGENCY

Certiﬁ ed to comply with 2015 particulate emission standards. Not approved

for sale after May 15, 2020.

Certiﬁ é conforme aux normes 2015 d’émission de particules. Non approuvé pour la

vente après le 15 mai 2020.

Room Heater Pellet fuel Burning type (UM) 84-HUD

“PREVENT HOUSE FIRES” Install and use only in

accordance with the manufacturer’s installation and

operation instructions. Contact local building or ﬁ re

ofﬁ cials about restrictions and inspection in your area.

WARNING: FOR MANUFACTURED HOMES: Do

not install appliance in a sleeping room. An outside

combustion air inlet must be provided. The structural

integrity of the manufactured home ﬂ oor, ceiling and

walls must be maintained.

This wood heater needs periodic inspection and repair

for proper operation. Consult the owner’s manual for

further information. It is against federal regulations to

operate this wood heater in a manner inconsistent with

the operating instructions in the owner’s manual.

Refer to manufacture’s instructions and local codes

for precautions required for passing chimney through

a combustible wall or ceiling. Inspect and clean

exhaust venting system frequently in accordance with

manufacturer’s instructions.

Use a 3” or 4” diameter type “L” or “PL” venting system.

Do not connect this unit to a chimney ﬂ ue servicing

another appliance.

FOR USE WITH PELLETIZED WOOD FUEL ONLY.

EPA Certiﬁ ed Emissions: 1.8 g/hr

Input Rating Max: 5.7 lb. fuel/hr

Electrical Rating: 240 VAC, 50 Hz, Start 2.6 AMPS,

run 2.0 AMPS

U.S. Electrical Rating: 115 VAC, 60Hz, Start 4.2

AMPS, Run 3.6 AMPS

Fuel Type: Wood Pellets

Route power cord away from unit.

DANGER: Risk of electrical shock. Disconnect

power supply before servicing.

Replace glass only with 5mm ceramic available from

your dealer.

BARCODE LABEL

Report #/Rapport # 0135PS014S

Test to/testé à: ASTM E 1509-12, ULC-S627-00, EPA

Method 28 & 5G

008

Serial No.

de série:

Rev F3-90-00025

Floor Protection

6.25”

Floor Protection

12”

3”

Floor Protection

36”

12”

352MountainHouseRoad

Halifax,PA17032

ECO:

PART#/REV: 3-90-00025_REVG

ORIGINATOR: SpidleT

DATE: 04/15

LABELSIZE: 10.5”Hx5.5”W

LOCATION: RearTop

CLASS:

ADHESIVE:486

MATERIAL:METAL

INK:BLACK

OVERCOAT:

LABELTICKET

(2)Holes=.125

(2)Holes=.125x.210

Corners.062

MODEL / MODÈLE: “XXV”

Room Heater Pellet Fuel-Burning Type

SUITABLE FOR MOBILE-HOME INSTALLATION

This pellet burning appliance has been tested and listed for use in

Manufactured Homes In accordance with OAR 814-23-900 through 814-23-909

Date of Manufacture / Date de fabrication:

2015 2016 2017 JAN FEB MAR APR MAY JUN JUL AUG SEP OCT NOV DEC

Manufactured by / Fabriqué par: Hearth and Home Technologies 352 Mountain House Road, Halifax PA 17032

For further instruction refer to owner’s manual.

Keep viewing and ash removal doors tightly

closed during operation.

DO NOT REMOVE THIS LABEL / NE PAS

ENLEVER CETTE ÉTIQUETTE

MINIMUM CLEARANCES TO COMBUSTIBLES/

DISTANCES DE SECURITE PAR RAPPORT AUX

MATERIAUX COMBUSTIBLES:

Back Wall / Entre Mur Arrière 3”/ 76mm

Side Wall / Entre Paroi Latér 12”/ 305mm

CORNER INSTALLATION / EN ANGLE

Walls to Appliance / 6.25”/159mm

Entre Murs et appareil

FLOOR PROTECTION / Protection Du Plancher

USA Canada

Sides*/Côtés (A) 6” 200mm

Back**/Arrière (B) 0” 200mm

Front*/Avant (C) 6” 450mm

**Measured from pedestal base in the US ONLY

**Mesuré à partir de la base du socle aux États-Unis

uniquement

*Measured from Glass Opening US ONLY

*Mesurer à partir de la surface de la porte en verre

CANADA ONLY

Floor Protection Must Be a Non-Combustible Material.

Must Also be Place Under Any Horizontal Flue

Connector, Extending 2” or 51mm Beyond the Pipe

Measurement.

Pour protéger le plancher, il faut sous le pêole un

matériau. Qui doit aussi être placé sous les parties

horizontales du tuyau de raccord à la cheminée et

s’étendre à 51mm ø 2 po. au-delà de la mesure du

tuyau.

Made in U.S.A. of US and imported parts. / Fabriqué aux

États-Unis-d’Amérique par des pièces d’origine américaine

et pièces importées.

L'appareil de chauffage à pellets type de combustion de carburant (UM) 84-

HUD

"Empêcher MAISON incendies" Installer et utiliser uniquement en

conformité avec installation et d'utilisation les instructions du fabricant.

Contactez le service des incendies à propos des restrictions et l'inspection

dans votre région.

AVERTISSEMENT: POUR maisons préfabriquées: Ne pas installer

l'appareil dans une chambre à coucher. Une entrée d'air de combustion à

l'extérieur doit être fournie. L'intégrité structurale de la maison étage, plafond

et murs fabriqués doit être maintenue.

Ce poêle à bois doit inspection périodique et la réparation pour un

fonctionnement correct. Consultez le manuel du propriétaire pour plus

d'informations. Ce est contre les règlements fédéraux pour faire fonctionner

ce poêle à bois d'une manière incompatible avec les instructions d'utilisation

dans le manuel du propriétaire.

Reportez-vous aux instructions du fabricant et les codes locaux pour les

précautions nécessaires pour faire passer la cheminée à travers un mur ou un

plafond combustible. Inspectez et nettoyez système d'évacuation souvent en

conformité avec les instructions du fabricant.

Utilisez un "ou 4" Type de diamètre «L» 3 ou le système de ventilation "PL".

Ne pas connecter cet appareil à un conduit de cheminée desservant un autre

appareil.

À UTILISER AVEC LA GRANULE DE BOIS SEULEMENT.

Émissions certiﬁ és EPA: 1,8 g / h

Entrée Max Note: £ 5,7 carburant / h

Note électrique: 240 VAC, 50 Hz, 2,6 Lancer AMPS, exécutez 2,0 AMPS

US Note électrique: 115 VAC, 60Hz, Start 4,2 AMPS, Run 3,6 AMPS

Type de carburant: granules de bois

Route cordon électrique de l'appareil.

DANGER: Risque de choc électrique. Couper l'alimentation avant

l'entretien.

Remplacer le verre seulement avec de la céramique 5mm disponible chez

votre revendeur.

Pour de plus amples instructions consulter le manuel du propriétaire.

Gardez la visualisation et les portes d’enlèvement de cendres

hermétiquement fermé pendant le fonctionnement.

Listing Label Information/Location

A. Congratulations

CongratulationsonselectingaHarman®FreestandingPellet

Stove.TheHarman®XXVpelletstoveyouhaveselected

isdesignedtoprovidetheutmostinsafety,reliability, and

efciency.

Astheownerofanewpelletstove,you’llwanttoreadand

carefullyfollowalloftheinstructionscontainedinthisowner’s

manual.Payspecialattentiontoallcautionsandwarnings.

Themodelinformationregardingyourspecic

stovecanbefoundontheratingplateusually

locatedinthecontrolareaofthestove.

Read this manual before operating this appliance.

Please retain this Owner’s Manual for future reference.

Read the Installation Manual before making any installation or nishing changes.

Welcome

Brand:________________________________________________ ModelName:___________________________

SerialNumber:__________________________________________ DateInstalled: __________________________

Appliance Information:

Local Dealer Information

DEALER: Fill in

your name, address,

phone and email

information here and

appliance information

below.

DealerName:________________________________________________________

Address:____________________________________________________________

____________________________________________________________

Phone:_____________________________________________________________

Email:_____________________________________________________________

SerialNumber

ModelName

Thisowner’smanual shouldberetainedforfuturereference.

We suggest that you keep it with your other important

documentsandproductmanuals.

Your new Harman® XXV Pellet Stove will give you years

ofdurableuseandtrouble-freeenjoyment.Welcometothe

Harman®family!

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/153 3-90-00684c

Table of Contents

1 Welcome

A. Congratulations .................................2

2 Product Specic and Important Safety Information

A. ApplianceCertication............................4

B. MobileHomeApproved...........................4

C. BTU&EfciencySpecications.....................5

3 General Information

A. ApplianceSafety ................................6

B. ClearSpace....................................6

C. ControlExplanation ..............................7

D. FuelSpecication................................8

E. GeneralOperatingInformation......................9

F. BeforeYourFirstFire.............................9

4 Operating Instructions

A. StartingYourFirstFire...........................10

B. FireCharacteristics .............................10

C. FeedLimitAdjustmentInstructions .................10

D. IgnitionCycles ................................. 11

E. AutomaticIgnition...............................12

5 Maintenance and Service

A. ProperShutdownProcedure......................14

B. QuickReferenceMaintenanceChart................ 14

C. GeneralMaintenance............................14

D. GlassMaintenance..............................15

E. BurnpotMaintenance............................16

F. CombustionBlowerChamber ..................... 17

G.PelletFeederChamber ..........................18

Safety Alert Key:

• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.

• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.

• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.

• NOTICE: Used to address practices not related to personal injury.

6 Troubleshooting and Frequently Asked Questions

A. ErrorCodeDescription...........................19

B. FrequentlyAskedQuestions ...................... 19

C. Troubleshooting................................20

7 Reference Materials

A. SafetyReminders...............................21

B. MotorandComponentLocation....................22

C. LossofPower..................................23

D. EmergencyManualIgnition....................... 23

E. ServiceParts..................................24

F. WarrantyPolicy ................................31

G.ContactInformation............................. 34

= Contains updated information



Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/154 3-90-00684c

Product Specic and Important Safety Information

A. Appliance Certication B. Mobile Home Approved

This appliance is approved for mobile home installations

whennotinstalledinasleepingroomandwhenanoutside

combustionairinletisprovided.

Thestructuralintegrityofthemobilehomeoor,ceiling,and

wallsmustbemaintained.Theappliancemustbeproperly

groundedtotheframeofthemobilehomeanduseonlylisted

pelletvent,Class“PL”connectorpipe.

A Harman® OutsideAir Kit must be installed in a mobile

homeinstallation.

NOTE: Thisinstallationmustconformwithlocalcodes.

In the absence of local codes you must comply with

the ASTM E1509-2004, ULC S628-93, ULC/ORD-C-

1482-M1990, (UM) 84-HUD

THE STRUCTURAL INTEGRITY OF THE

MANUFACTURED HOME FLOOR, WALL, AND

CEILING/ROOF MUST BE MAINTAINED.

DO NOT INSTALL IN SLEEPING ROOM.

WARNING

TheXXVisCertiedtocomplywith2015

particulate emission standards. Not

approvedforsaleafterMay15,2020.

MODEL: XXVPelletStove

LABORATORY: OMNITestLaboratories,Inc

REPORT NO. 0135PS014S

TYPE: PelletFueled/SupplementaryFor

ResidentialUse

STANDARD(s): ASTME1509-04,ULC/ORD-

C1482-M1990,ULC-S627-00,EPA

Method28&5G

ELECTRICAL

RATING

115 VAC, 60 Hz, Start 4.2 Amps,

Run2.8Amps

GLASS

SPECIFICATIONS

5mmmirroredceramicglass

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/155 3-90-00684c

C. BTU & Efciency Specications

NOTE: Hearth & Home Technologies, manufacturer of

thisappliance,reservestherighttoalteritsproducts,their

specicationsand/orpricewithoutnotice.

* Weighted average LHV efciency using data collected

during EPA emissions test.

**Weighted average HHV efciency using data collected

during EPA emissions test.

***A range of BTU outputs based on EPA Default Efciency

and the burn rates from the low and high EPA tests.

****Based on the maximum feed rate per hour multiplied by

approximately 8,600 BTU’s which is the average BTU’s from

a pound of pellets.

Thiswoodheaterhasamanufacturer-setminimumlowburn

ratethatmustnotbealtered.Itisagainstfederalregulations

toalter this settingorotherwise operatethiswood heater

inamannerinconsistentwithoperatinginstructionsinthis

manual.

Thiswoodheaterneedsperiodicinspectionandrepairfor

properoperation.Itisagainstfederalregulationstooperate

this wood heater in a manner inconsistent with operating

instructionsinthismanual.

Harman® is a registered trademark of Hearth & Home

Technologies.

WARNING

Risk of Fire! Hearth & Home Technologies disclaims any

responsibility for, and the warranty and agency listing will

be voided by the below actions.

DO NOT:

• Install or operate damaged appliance

• Modify appliance

• Install other than as instructed by Hearth & Home

Technologies

• Operate the appliance without fully assembling all

components

• Overre

• Install any component not approved by Hearth &

Home Technologies

• Install parts or components not Listed or approved.

• Disable safety switches

Improper installation, adjustment, alteration, service or

maintenance can cause injury or property damage.

For assistance or additional information, consult a qualied

installer, service agency or your dealer.

EPA Certication Number: 994-15

EPA Certied Emissions: 1.8g/hr

*LHV Tested Efciency: 78%

**HHV Tested Efciency: 66.5%

***EPA BTU Output: 10,600-36,900

****BTU Input 14,200-49,300

Vent Size: 3Inch

Hopper Capacity: 65lbs

Fuel WoodPellet

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/156 3-90-00684c

WARNING! DO NOT operate stove before reading and

understanding operating instructions. Failure to operate

stove according to operating instructions could cause

re or injury.

If you expect that small children or vulnerable adults

maycomeintocontactwiththisappliance,thefollowing

precautionsarerecommended:

• Installaphysicalbarriersuchas:

 - Adecorativerescreen.

 - Adjustablesafetygate.

• Installaswitchlockorawall/remotecontrolwithchild

protectionlockoutfeature.

• Keepremotecontrolsoutofreachofchildren.

• Neverleavechildrenalonenearahotstove,whether

operatingorcoolingdown.

• TeachchildrentoNEVERtouchthestove.

• Consider not using the stove when children will be

present.

Contactyourdealerformoreinformation,orvisit:www.

hpba.org/safety-information.

To prevent unintended operation when not using your

stoveforanextended period oftime(summermonths,

vacations,trips,etc):

• Unplugstovefromreceptacle.

A. Appliance Safety

ContactyourdealerorHearth&HomeTechnologiesifthebarrier

isnotpresentorhelpisneededtoproperlyinstallone.

HOT SURFACES!

Glassandothersurfacesarehotduring

operationANDcooldown.

Hot glass will cause burns.

• DO NOTtouchglassuntilitiscooled

• NEVERallowchildrentotouchglass

• Keepchildrenaway

• CAREFULLYSUPERVISEchildreninsameroomasstove.

• Alertchildrenandadultstohazardsofhightemperatures.

High temperatures may ignite clothing or other ammable

materials.

• Keepclothing, furniture, draperies and other ammable

materialsaway.

General Information

WARNING

B. Clear Space

WARNING

RISK OF FIRE! Do NOT place combustible objects

in front or to the sides of the appliance. High

temperatures may ignite clothing, furniture or draperies.

Mantel:

 Avoid placing candles and other heat-sensitive

objectsonmantelorhearth.Heatmaydamagethese

objects.

WARNING

RISK OF FIRE! Keep combustible materials, gasoline

and other ammable vapors and liquids clear of

appliance.

• Do NOT store ammable materials in the appliance’s

vicinity.

• Do NOT use gasoline, lantern fuel, kerosene, charcoal

lighter uid or similar liquids to start or “freshen up” a

re in this heater.

Keep all such liquids well away from the heater while it is

in use as combustible materials may ignite.

NOTICE

Clearances may only be reduced by means approved by

the regulatory authority having jurisdiction.

WARNING

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/157 3-90-00684c

C. Control Explanation

Mode Selector

Allows you to choose between Room Temp Mode,

Constant Burn Mode, or OFF. Also allows you to

vary the distribution blower speed by turning the

knob to the high or low side of each mode.

Feed Limit

Sets the maximum feed

rate

Test

Runs all motors at full

speed for one minute to

check operation. After

a minute, the control

will simulate a minimum

burn and the combustion

blower will remain on

low.

Distribution Blower

speed adjustment range.

L = low

H = high

Variable speed

anywhere between L

and H; although as the

stove temp. goes up, so

does the L and H scale.

Power Light

Indicates power to the

control.

Indicates power to

the feed motor.

Indicates power to

combustion blower

Status Light

Will be lit in either stove

or room temp mode when

pointer is not within off

position band except after

normal shut down. Blinks to

indicate errors listed below.

Indicates power to

distribution blower.

Indicates igniter is on.

Igniter switch

Set to appropriate Start-

Up mode.

Temp dial

Allows you to adjust the

room temperature in

Room Temp Mode using

the outer scale marked in

degrees Fahrenheit. It also

allows you to adjust the

stove temperature while in

Constant Burn Mode using

the inner scale marked from

1 to 7.

Dealer Diagnostic Port

For dealer maintenance

only. Requires special DDM

monitor supplied to Harman®

Dealers exclusively.

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/158 3-90-00684c

NOTICE

Hearth&HomeTechnologiesisnotresponsibleforstove

performanceorextramaintenancerequiredasaresultof

usingfuelwithhigherashormineralcontent.

Size

• Pellets are either 1/4 inch or 5/16 inch (6-8mm) in

diameter

• Lengthshouldbenomorethan1-1/2inches(38mm)

• Pellet length can vary from lot to lot from the same

manufacturer.

Performance

• Higherashcontentrequiresmorefrequentmaintenance.

• “Premium” grade pellets will produce the highest heat

output.

• Burning pellets longer than 1-1/2 inches (38mm) can

causeinconsistentfeedingand/orignition.

Werecommendthatyoubuyfuelinmulti-tonlotswhenever

possible. However, we do recommend trying different

brands prior to purchasing multi-ton lots, to ensure your

satisfaction.

Storage

• Woodpelletsshouldbeleftintheiroriginalsealedbag

untilreadytouse,topreventmoisture.

• Donotstorefuelwithinthespeciedclearanceareas,or

inalocationthatwillinterferewithroutinecleaningand

maintenanceprocedures.

D. Fuel Specications

Fuel and Fuel Storage

Pellet fuel quality can uctuate from manufacturer to

manufacturer,andevenfrombagtobag.

Hearth&HomeTechnologiesrecommendsusingonlyfuel

thatiscertiedbythePelletFuelsInstitute(PFI).

FuelMaterial

• Madefromsawdustand/orotherwoodby-products

• Sourcematerialtypicallydeterminesashcontent

HigherAshContentMaterial

• Hardwoodswithhighmineralcontent

• Barkandleavesassourcematerial

• “Standard”gradepelletsandotherbiomass

LowerAshContentMaterial

• Softwood;pine,r,etc.

• Materialswithlowermineralcontent

• “Premium”gradepellets

Clinkers

Minerals and other non-combustible materials, like sand,

willturnintoahardglass-likesubstancewhenheated.

Treesfromdifferentareaswillvaryinmineralcontent.For

this reason, some fuels will produce more clinkers than

others.

Moisture

Alwaysburndryfuel.Burningfuelwithhighmoisturecontent

takesenergyto dryandtendstocooltheappliancethus,

robbingheatfromyourhome.Damppelletfuelcouldturn

backintosawdustwhichdoesnotowproperlythroughthe

feedsystem.

Tested and approved for use with wood pellets ONLY.

Burningofanyotherfuelwillvoidyourwarranty.

CAUTION

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/159 3-90-00684c

F. Before Your First Fire

1. First, make sure your appliance has been properly

installedandthatallsafetyrequirementshavebeenmet.

Payparticularattentiontothereprotectionandventing

instructions.

2. Doublecheckthattheashpanandreboxareempty!

3. Closethefrontdoor.

E. General Operating Information

1. Room Sensor Calls For Heat

Theapplianceislikemostmodernfurnaces;whentheroom

sensorcallsforheat,yourappliancewill automaticallylight

anddeliverheat.

Whentheroomisuptotemperatureandtheroomsensoris

satised,theappliancewillshutdown.

2. Heat Output Controls

The appliance will turn on and off as the room sensor

demands.Whentheroomsensorcallsforheat,theappliance

willalwaysstartuponHigh.Afterburningapproximately7-10

minutes,theappliancewillthenburnattherateatwhichit

wasoriginallyset.Iftheapplianceissetatoneofthelower

settings,itwillrunquieterbuttakelongertoheatupanarea

thanifitweresetatahigherburnrate.

Regardlessoftheburnrate,whentheareaiswarmenough

tosatisfytheroomsensor,theappliancewillshutoff.

FireHazard.

Keepcombustiblematerials,gasoline

andotherammablevaporsandliquids

clearofappliance.

WARNING

• DoNOTstoreammablematerialsintheappliance’svicinity.

• NEVER USE GASOLINE, GASOLINE-TYPE LANTERN

FUEL, KEROSENE, CHARCOAL LIGHTER FLUID, OR

SIMILARLIQUIDSTOSTARTOR“FRESHENUP”AFIRE

INTHISHEATER.KEEPALLSUCHLIQUIDSWELLAWAY

FROMTHEHEATERWHILEITISINUSE.

• DONOTBURNGARBAGEORFLAMMABLEFLUIDSSUCH

ASGASOLINE,NAPHTHAORENGINEOIL.

• DO NOT USE CHEMICALS OF FLUIDSTO STARTTHE

FIRE.

• Combustiblematerialsmayignite.

Figure 3.1

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/1510 3-90-00684c

B. Fire Characteristics

Aproperlyadjustedrehasamediumactiveamepattern

that extends out of the burn pot approximately 6 inches

(152mm).

C. Feed Limit Adjustment Instructions

TheFeed Limit controlisfactory setat#4, and shouldbe

adequateformostfuels.

However,iftheflameheightistoohighortoolow,youwill

needtoadjustthefeedrate. Waituntiltheappliancehasbeen

burningfor15minutesbeforemakingyouradjustmentsand

llow15minutesfortheFeedLimittotakeeffect.

A. Starting Your First Fire

1. A room sensor is required for proper operation of this

appliance in “Room Temp” mode. At this time, ll the

hopper with pellets, insure the control is set to “OFF”.

Figure4.2.Plugthepowercordintoaproperlygrounded,

nearbyoutlet.

2. Oncepowerispresent,theunititwillrunthroughaquick

diagnosticstesttoinsurethecontrolisoperatingproperly.

Thisisnormal.

3. Foryourrstreitmaybenecessarytopurgetheauger

systembyputtingthefeedLimitknob to “Test”priorto

startingtheunit.Figure4.3.Thisinsuresthatplenty of

fuelenterstheburnpotforproperignition.

4. Flip toggle switch to desired mode “auto or Disabled”.

Figure4.4.SetFeedLimitknobtodesiredsettingandturn

modedialto“RoomTemp”or“ConstantBurn”Figure4.5.

Note:Feedrateof#4isagoodstartingpoint.Adjustments

madeneedtobemadedependingonfuelqualityand/or

heatoutputdesired.

5.

Thefuelfeedsystemandtheignitershould

now

beon.

6. Oncetheappliancehasignited,letitburnforapproximately

7-10 minutes.After this time the unit should begin to

operateperthesettingsatthecontrol.

Figure 4.5

Odorsandvaporsreleasedduringinitialoperation.

• Curingofhightemperaturepaint.

• Openwindowsforaircirculation.

Odorsmaybeirritatingtosensitiveindividuals.

Figure 4.2 Figure 4.3

Figure 4.4

Operating Instructions

CAUTION

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/1511 3-90-00684c

D. Ignition Cycles

1. Atthebeginningofeachignitioncycle,itisnormaltosee

somesmokeintherebox.Thesmokewillstoponcethe

restarts.

2. Thedistributionblowerwillautomaticallyturnonafteryour

appliancehasreachedthesettemperature.

Thisblowertransfersheatfromyourapplianceintothe

room,andwillcontinuetorunin“ConstantBurn”mode

atthesetspeedyouhavethecontrolknobat.In“room

temp” mode however, the blower will turn on and off

inaccordanceto whattemperaturetheroom sensoris

reading.Whentheroomsensorissatisedtheblowerwill

shutdownuntiltheroomsensorseesademandforheat.

3. Occasionallytheappliancemayrunoutoffuelandshut

itselfdown.Whenthishappens,theunitwillneedtobe

turnedtotheoffpositionandrestarted.

Ifneeded,followSectionA, “StartingYourFirstFire”.

FireRisk

DoNOToperateappliance:

• Withappliancedooropen.

• Burnpotooropen.

• Cleaningslideplatesopen.

DoNOTstorefuel:

• Closerthanrequiredclearancestocombustibles

toappliance

• Withinspacerequiredforloadingorashremoval.

WARNING

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/1512 3-90-00684c

Igniter Switch to "AUTO" (up position)

Makesuretheunitispluggedintoaproperlygrounded,120

VAC,60Hzelectricalsource.Thepowerlightshouldbethe

onlylightlit.

Note: Be sure there is no fuel or other combustibles in

the ash pan prior to lighting.

1. TurnModeSelectorto"OFF".

2. Fillhopperwithpellets.

3. Cleanburnpotwithscraper,ifnecessary.

4. Ifstartingafteranemptyhopper,turnFeedLimitto"TEST"

(forone60secondcycle).

Thiswillowpelletsintothe

augertubeandalsoallow you tocheckthemotorsfor

operation.

NOTE: The auger motor will not operate with the view

door open.

5. TurnFeedLimitto#4.

6. FliptheIgniterSwitchupintothe"AUTO"position.

7. TurntheTemperatureDialtothedesiredroomtemperature.

8. TurnModeSelectortoRoomTemperatureorConstant

Burn.

9. Fillhopperwithpelletsandremoveashesasrequired.

Keep the hopper lid and rebox doors closed while in

operation.Maintaindoorsealsingoodcondition.Failure

todosowillaffectoperationoftheapplianceandmay

permitescapeofsmokeorgasesintothelivingspace.

1. Fines are small pieces of broken pellets (sawdust). Fines

do not ow easily and often build up on the hopper funnel

bottom angles. These nes can be pushed into the feeder

opening and then ll the hopper with pellets. As the system

works, they will be burned.

2. The "TEST" cycle will operate the feed motor for exactly

one minute. Turning to "TEST" again and again may load

too much fuel into the burn pot causing excessive smoke

on start-up.

3. The rebox low pressure switch will not allow the auger

motor or the igniter element to operate if the view door is

open.

4. Adjust Feed Rate. If this is your rst re or you are trying

different pellets, set the Feed Limit to #4, Figure 4.6 This

is a conservative number and will probably need to be

increased. After you know a feed rate setting that works

well, use that setting. Remember, if your feed rate is too

high you may waste fuel.

5. This is usually a weekly maintenance procedure. Cleaning

the burn pot with the scraper with a small amount of new

fuel in the bottom is not a problem. First, scrape the ashes

off the front of the burn pot into the ash pan. Then scrape

the holed surface downward into the burn pot. When the

stove feeds, these scrapings will be pushed out by the

feeder.

6. The ash pan can hold the ashes from approximately 1 ton

of premium fuel. This means the ashes will only need to

be emptied a few times a year.

7. Setting the Feed Limit # for maximum burn: With the unit

burning in "AUTO", turn to "Stove Mode" and put the fan on

"H". Set the Temperature Dial to #7. Allow the unit to burn

for about 30 minutes and check ash on front of burn pot.

Figure 4.7. If the ash line is larger than 1", turn the Feed

Limit from #4 to #5. Allow another 30 minutes of burn time

and check again. If, at #6 setting, a 1" or less ash bed is

not obtainable, it is not a problem. The 1" ash bed is only

at maximum burn rate and during normal operation, the

ash bed will be larger.

NEVER USE GASOLINE, GASOLINE-TYPE LANTERN

FUEL, KEROSENE, CHARCOAL LIGHTER FLUID, OR

SIMILAR LIQUIDS TO START OR 'FRESHEN UP' A FIRE

IN THIS HEATER. KEEP ALL SUCH LIQUIDS WELL

AWAY FROM THE HEATER, WHILE IN USE.

BURNING GARBAGE, USE OF IMPROPER FUELS,

FIRE STARTERS OR ALTERING THE STOVE FOR

HIGHER HEAT OUTPUT MAY CAUSE DAMAGE TO

THE STOVE AND COULD RESULT IN A HOUSE FIRE.

USE ONLY APPROVED FUELS AND FOLLOW ONLY

THESE OPERATION GUIDELINES.

Figure 4.6

See Note 7

Figure 4.7

E. Automatic Ignition

WARNING

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/1513 3-90-00684c

TheXXVPelletStoveismorethanjustautomaticignition,it

isalsoautomatictemperaturecontrol.Theautomaticsystem

willallowtheresizetobeadjustedtomatchtheheating

needsandevenputthereoutifnecessary.Ifheatisneeded

afterthereisout,theXXVPelletStovewillautomatically

re-igniteandadjusttheresizetomatchtheheatingneed.

Thetotallyautomaticroomsensormodeisrecommended

becauseofitsefciency.Theunitcanbeswitchedbetween

"AUTO"and"DISABLED"atanytimeduringoperation.

Igniter switch to “AUTO”

Room Temperature Mode

In“RoomTempMode”heatoutputiscontrolledautomatically

bytheRoomSensingProbe.WhentheRoomSensingProbe

callsforheat,thestovewillincreaseoutput.WhentheRoom

SensingProbeisgettingclosetothesettemperature,the

stovewillbegintoleveloffoutputandkeepthereburning

atjusttherighttemperaturetomaintainthatsetting.

High output is determined by the feed rate setting. This

setting,generallyon#4,canbeincreasedifhigherburnrates

arenecessary(Figure4.6).Theunit’smaximumburnrate

shouldnotcreatelessthan1”ofashontheburnpotfront

edge(Figure4.7).Overfeedingisnotasafetyconcern,but

fuelmaybewastedifunburnedpelletsfallintotheashpan.

In“RoomTempMode”aconstantfuelconsumptionrateis

sacricedforexactroomtemperature.Therefore,asitgets

coldermorepelletswillbeburnedautomatically.

The distribution blower speed will vary according to the

positionofthemodeselectorpointer,andresize.

Igniter switch to “AUTO”

Constant Burn Mode

Thisallowsforautomaticignitionuponstart-uponly.Theunit

canthenbesetatanydesiredsetting.Theheatoutputand

fuel consumption will remain constant regardless of room

temperature.Theunit’smaximumfeedrateshouldnotcreate

lessthan1”ofashontheburnpotfrontedge.Figure4.7.

Theunit’slowburnormaintenancesettingisaslowasitwill

go.Itwillnotgooutunlessitrunsoutoffueloristurnedoff.

Shut-Down Procedure

To kill the re or stop burning the stove, turn the Mode

Selectorto“OFF”.This will causetheretodiminishand

burnout.Whenthereburnsoutandthestovecoolsdown

everythingwillstop.

Ifyoupulltheplugtoshutdownthestove,allmotorswillstop.

Thismaycauseincompletecombustionandsmokeinthe

rebox.Iftheloaddoorisopened,thesmokemayescape.

Thebestwaytoshutdownthestoveissimplyletitrunout

ofpellets,thenthestovewillshutdownautomatically.

Room Temperature Mode: This setting will produce a room temperature

of 70 degrees with the distribution blower at medium speed.

This setting will produce medium heat with the distribution

blower on "low".

This setting will produce continuous maximum heat output

with the distribution blower at full speed.

Constant Burn Mode

E. Automatic Ignition (Continued)

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/1514 3-90-00684c

Types of Fuel

Thetypeoffuelyouareburningwilldictatehowoftenyouhave

tocleanyourburnpot.

Ifthefuelyouareburninghasahighdirtorashcontent,itmay

benecessarytocleantheburnpotmorethanonceaday.

Dirtyfuelwillcauseclinkerstoformintheburnpot.Aclinkeris

formedwhendirt,ashoranon-burnablesubstanceisheated

to2000°F(1093°C)andbecomesglass-like.

B. Quick Reference Maintenance Chart

Follow the detailed instructions found in this section

for each step listed in the chart below.

Cleaning or Inspection

Frequency Daily Weekly Monthly Yearly

AshPan Every5bagsoffueldepending

onthefueltypeorashbuild-up

OR X

AshRemovalfromFirebox Every5bagsormore

frequentlydependingonthe

fueltypeorashbuild-up

OR X

HeatExchanger Every1tonoffuel OR X

Blower,Combustion(Exhaust) Morefrequentlydependingon

thefueltype

OR X

Blower,Distribution Every25bagsormore

frequentlydependingonthe

fueltype

OR X

DoorGasketInspection Priortoheatingseason OR X

ExhaustPath Morefrequentlydependingon

ashbuild-up

OR X

Firebox-PrepareforNon-BurnSeason Atendofheatingseason OR X

Burnpot-Burningpellets-hardwood Every3bags OR X

Burnpot-Burningpellets-softwood Every5bags OR X

Glass Whenclearviewofburnpot

becomesobscure

OR X

Hopper/HopperLidGasket Every50bagsoffuelorwhen

changingfueltypes

OR X

VentingSystem Morefrequentlydependingon

thefueltype

OR X

Maintenance & Service

A. Proper Shutdown Procedure

C. General Maintenance

Whenproperlymaintained,yourstovewillgiveyoumany

yearsoftrouble-freeservice.Contact your dealertoanswer

questionsregardingproperoperation,trouble-shootingand

serviceforyourappliance.Visitwww.harmanstoves.comto

ndadealer.Werecommendannualservicebyaqualied

servicetechnician.

Shock and Smoke Hazard

• Turnunittotheoffposition,letappliance

completelycoolandcombustionblowermust

beoff.Nowyoucanunplugappliancebefore

servicing.

• Smokespillageintoroomcanoccurifappliance

isnotcoolbeforeunplugging.

• Riskofshockifappliancenotunpluggedbefore

servicingappliance.

CAUTION

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/1515 3-90-00684c

Glass Gasket

Replace glass only

with high temperature

ceramic glass.

Inspect door gasket during

cleaning and inspection

D. Glass Maintenance

The glass used in your stove is manufactured to exact

standards to withstand the high heat of the re, but like all

glass, it must be treated with common sense and care. Never

abuse the glass by slamming the door shut or striking the

glass with a heavy object. If the glass is broken or damaged,

do not operate the stove until it has been replaced.

Glass - Cleaning

Sometimesitwillbenecessaryto clean accumulatedash

fromtheglasssurface;allowingthisashtoremainonthe

glassforlongperiodscanresultin“etching”duetotheacidity

oftheash.Nevercleantheglasswhileitishot,anddo not

useabrasivesubstances.Washthesurfacewithcoolwater,

andrinsethoroughly.Youmaywishtouseanon-abrasive

cleanerspecicallydesignedforuseonstoveglass.Inany

case,drythoroughlybeforerelightingyourstove.

Glass - Replacement

Ifthestove’sglassiscrackedorbroken,youmustreplace

it before operating your stove.  Remove pieces carefully.

Replace glass only with Harman® replacement glass; do

not use substitutes.

Carefullyremovedamagedglass,gasketmaterial,andhold

downclips(setaside).

Installtheselfadhesive1/4””gasketmaterialaroundthefront

faceoftheglass.Settheglasspanelandgasketgentlyonto

thedoor.Installtheholddownclipsandtightenwithbolts.

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/1516 3-90-00684c

Whenaddingfuel,taketheopportunitytocleantheburnpot.

(Weekly at minimum)

• Scrapethetopholedsurfaceandsidesoftheburnpot

down to auger tube Figure 5.1. It is not necessary to

completely remove all material from the burn pot. The

excesswillbepushedoutduringthenextuse.

• With the re out and burn pot cold, use the supplied

allen wrench to remove any build-up that may have

accumulatedintheholes oftheburnpotgrate.Simply

pushtheallenwrenchdownthrougheachholeensuring

itisclearofanybuild-uppayingattentionnottodamage

theigniterelementintheprocess.

Monthly, or after each ton of fuel burned:

• Loosenthe(2)wingthumbscrewsonthelowerfrontangle

oftheburnpot.Figure5.2

• Liftofftheclean-outcovertoopenthebottomclean-out

chamber.Figure5.3

• Cleanashbuildupfrominsidethechamberwhilecover

isoff.Usethescrapertotaponthetopfrontedgeofthe

burn pot.This will help knock pieces of ash, loosened

bythescrapingprocess,downthroughtheholes.Italso

helpsknockscaleoffoftheigniterelement.

Figure 5.3

Theigniterismadetoberemovableforservicebyinsulated

male/femalewireconnectors.Theseconnectionsbetween

thehot leads (thewires inside theburn pot)andthe cold

leads(thewiresfromthecontrolboard)arealwayspulled

totheinsiderearofthefeederbody. (Not coiled inside the

burn pot.)

Itisveryimportantthattheseconnectionsaretotheinside

rearofthefeederbody.Also,theextrawireoftheigniterwire

serviceloopmustbepulledoutthroughtherearofthefeeder

andtiedupsothatitwillnotbedamagedbyanymovingparts.

Note: The hot lead/cold lead connection must always

be pulled to the rear of the feeder body before

operation.

Viewed from below through the ash pan opening.

Igniter hot lead wires

(High temperature)

Burn pot igniter

E. Burnpot Maintenance

Figure 5.1

Figure 5.2

Figure 5.3

Wing Thumb Screws

Use caution when cleaning burn pot clean-out

chamber. Do not damage the high temperature igniter

wires.

CAUTION

Disconnect the power to the unit before removing

cover.

DANGER

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/1517 3-90-00684c

Monthly Cleaning- continued:

CleantheheatexchangerwithscraperasshowninFigure

5.4.Brushorscrapetheinsideofthestovetoremoveyash.

Removetheashpananddisposeofashesinanapproved

manner,accordingtolocalcodes.

The exhaust passage may need cleaned as well. Keep

inmindtheESPSensorislocatedjustinsidetheexhaust

passageFigure5.7.BesurenottodamagetheESPSensor

whilecleaningthisarea.

• Removethecombustionblowerbylooseningthe3wing

nuts(Figure5.5),twistingthecombustionblowermount

platecounterclockwisetounlock,andpullingtheblower

out.

• Cleanthecombustionblowerhousingandfanbladewith

abrushandavacuumcleanerFigure5.6.

Note:Donotuseahouseholdvacuumtocleanthestove.We

recommendthatyouuseashopvacuumthatisequippedwith

anedustltercalledaHEPAlteroravacuumspecially

madeforyashandsoot.USINGAVACUUMWHICHIS

NOTEQUIPPEDWITHAFINEDUSTFILTERWILLBLOW

FLYASHANDSOOTOUTINTOTHEROOM.

NOTE:THESTOVEMUSTBECOMPLETELYOUTBEFORE

YOU VACUUMTHE STOVE.LIVEPELLET EMBERS, IF

SUCKEDINTOTHEVACUUM,WILLLIGHTTHEVACUUM

ONFIREANDMAYULTIMATELYCAUSEAHOUSEFIRE.

Useabrushtocleantheue,beingcarefulnottodamage

theESPprobeFigure5.7.

Reinstallthecombustionblowerbyturningplateclockwise

tolockintoplaceandtighteningthe3wingnuts.Besure

thefanplateisushwiththeexhausthousingonthestove

bodyandthemotorarmaturepointsuptowardthehopper.

Slideashpanintothestoveandlatchthedoor.

Figure 5.4

F. Combustion Blower Chamber

Scrapeheat

exchanger

witharrow

scrapertool.

Figure 5.5

Loosen

(3)thumb

screws.

Figure 5.6

Cleantheseareaswithbrush

andvacuum

Figure 5.7

ESPProbe

Be careful not

todamageESP

probe when

cleaning with

brush.

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/1518 3-90-00684c

Feeder Chamber

The chamber may get a buildup of nes from the feeder

mechanismmovement.This area shouldbe checkedand

cleanedatleastonceayear.

To remove the feeder cover:

• Loosenthe5/16"wingnut.Figure5.8.

• Liftupandslidethecoveroffofthethreadedstud.

• InspectandcleantheinnerchamberifnecessaryFigure

5.9.

• Reinstallthecovermakingcertainitisseatedproperlyon

thefeederbodyandtightenastightlyasyoucanbyhand.

NOTE: Views are shown with the rear motor covers

removed.

Pellet Metering

Slide Plate

Possible pellet nes

buildup area.

Figure 5.9

5/16" Wing NutFeeder clean out cover

Figure 5.8

G. Pellet Feeder Chamber

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/1519 3-90-00684c

Troubleshooting and Frequently Asked Questions

Status light error messages:

3 Blinks:IndicatesthattheESP(ExhaustSensingProbe)

hasfailed,hasabrokenconnection,orhasgoneoutofrange

toomanytimes.Thisrequiresamanualreset*.

4 Blinks: Can occur only in Room Temp Mode and

indicatesRoom Sensing Probefailed or notinstalled. If a

RoomSensingProbeistheninstalled,thestatuslightwill

automaticallyreset.

NOTE:Unitwillnotstartin"AUTO"withthisstatuserror.

5 Blinks (In Igniter Auto. Mode Only):Indicatesthattheunit

hasfailedtolightwithinthe36minutestartcycle.Toreset-

TurnModeSelectorto"OFF",thenturntoeithermodeagain.)

6 Blinks :Indicatesthatthecontrolhascalculatedpooror

incompletecombustionoccurringformorethan25minutes.

Asixblinkstatusmaybesetifthestoveisallowedtorunout

ofpellets.Toreset,turnmodeselectorto"OFF"thenback

ontothedesiredmode.Iftheunitwasnotoutofpellets,see

Troubleshootingsectionformoredetails.

* Manual reset-disconnectpowercordforafewseconds

andreconnect.IferrorstilloccurscallyourDealer.

A. Error Code Description

B. Frequently Asked Questions

ISSUES SOLUTIONS

1. Metallicnoise. 1. Noiseiscausedbymetalexpandingandcontractingasit

heatsupandcoolsdown,similartothesoundproduced

byafurnaceorheatingduct.Thisnoisedoesnotaffect

theoperationorlongevityofyourappliance.

2. Whiteashbuilduponglass. 2. Thisisnormal.Cleantheglassusinganynon-abrasive

glasscleaner.

3. Glasshasbuildupofblacksoot 3. Excessive build-up of ash. See solution #4. The lower

burn settings will produce more ash, the higher burn

settingsproduceless.Themoreitburnsonlowthemore

frequentcleaningoftheglassisrequired.

4. Glasshasturneddirty. 4. Excessivebuild upof ash.Thelower burnsettings will

producemoreash,thehigherburnsettingsproduceless.

Themoreitburnsonlowthemorefrequentcleaningof

theglassisrequired.

5. Firehastallameswithblacktailsandislazy. 5. Thefeedrateneedstobereducedortheburnpotneeds

cleaning. Heat exchanger or exhaust blower needs

cleaning.

6. Smokystart-uporpuffsofsmokefromtheairwash. 6. Either the burnpot is dirty or there is too much fuel at

start-upandnotenoughair.

7. Largeameatstart-up. 7. This is normal. Flame will settle down once the re is

established.

Contact your dealer for additional information regarding operation and troubleshooting. Visit www.harmanstoves.

com to nd dealer.

Harman® • XXV Owner’s Manual_R33 • 2004 -___ • 09/1520 3-90-00684c

STOVE DOES NOT FEED

1. Nofuelinhopper.

2. Fireboxdraftmaybetoolowforsensingswitchinfeeder

circuit to operate. Check for closed doors, loose or

missinggasketondoorsorhopperlid.

3. FeedmotorwillnotrununtiltheESPcontrolsensesa

certaintemperature.Maybeyoudidnotputenoughfuel

orstartinggelintheburnpotbeforemanuallylightingthe

re.

4. Restrictioninthehopperorfeeder.Removeallfueland

examine.Cleartheobstruction.

5. Feedmotorhasfailed.

PARTIALLY BURNED PELLETS

1. Feedratetoohigh.

2. Poorairtofuelmixture.(Checkburnpotclean-outcover

andairintake).

3. Burn pot or heat exchanger tubes may need  to be

cleaned.

4. Combinationofalltheabove.

5. #6statusblink:A6blinkcontrolboardstatusindication

iscausedbypoororincompletecombustion.Thecircuit

boardhastheabilitytotrackthecombustionthroughfeed

settingsandESPtemperatures.Whenthecontrolboard

hascalculatedpoororincompletecombustion,itwillshut

downthe unitas asafety feature.(Poor orincomplete

combustionisacontributorofcreosotewhichmaycause

achimneyre)

A 6 blink status may be caused by several things:

1. Blockedorpartiallyblockedue.

2. Blockedorpartiallyblockedinletair.

a. Backdraft damper on the inlet pipe may be stuck

closed.

b. Ifoutsideairisinstalled,theinletcovermaybeblocked.

3. Theairchamberundertheburnpotmaybelledwithnes

andsmallbitsofash.

4. Theholesintheburnpotmaybegettinglledwithashor

carbonbuildup.

5. Combustionblowerfanbladesmayneedcleaned.

6. Fuelrestrictionsasnotedabove.

SMOKE SMELL

Sealtheventpipejointsandconnectiontostovewithsilicone.

Theexhaustventistheonlypartofthesystemthatisunder

positivepressure.

FIRE HAS GONE OUT- Check for status light.

1. Nofuelinhopper.

2. Draftistoolow,blockedue.

3. Somethingisrestrictingfuelow.

4. Hopperlidnotclosedproperly.

5. Feedmotororcombustionblowerhasfailed.

SMOKE IS VISIBLE COMING OUT OF VENT

1. Air-fuelratioistoorich.

a.Feedratetoohigh.

b.Drafttoolowcausedbyagasketleak.

LOW HEAT OUTPUT

1. Feedratetoolow

2. Drafttoolowbecauseofgasketleak.

3. Poorqualityordamppellets

4. Combinationof1and2.

HELPFUL HINTS

1. Cleaning Burn Pot

Wheneveryourstoveisnotburning,taketheopportunityto

scrapethe burnpot toremove carbon buildup.A vacuum

cleanerishandytoremovetheresidue.Besurethestove

iscoldifyouuseavacuum.

Carbonbuildupcanbescrapedloosewiththereburning

usingthespecialtoolprovidedwithyourstove.Scrapethe

oorandsidesoftheburnpot.Thecarbonwillbepushedout

bytheincomingfuel.Alwayswearglovestodothis.

2. Removing Ashes

TurntheTempDialtonumber1approximately30minutes

beforeremovingashes.Thiswillresultinacoolerstoveand

ashpan.

Maximum Feed Limit settings are not needed in most

cases.Operatinginthenormalrange(#4)isrecommended

whenmaximumheatoutputisnotrequired.TheESPprobe

preventsthestovefrombeingover-red.

Keepthestovefreeofdustanddirt.

Fuel

TheXXVPelletStoveisapprovedforburninganygradeof

pelletizedbio-massfuel.

It should be noted, however, that higher ash content will

requiremorefrequentashremoval,scrapingoftheburnpot,

andmayprovidelessBTU’sperpound.

Fuel should not be stored within the stove installation

clearances or within the space required for charging and

ashremoval.

C. Troubleshooting

Withproper installation,operation, andmaintenance yourappliance willprovide yearsof trouble-free service. If you do

experienceaproblem,thistroubleshootingguidewillassistaqualiedservicepersoninthediagnosisofaproblemandthe

correctiveactiontobetaken.Thistroubleshootingguidecanonlybeusedbyaqualiedservicetechnician.

Page is loading ...

Harman XXV Owner's manual

Brand: Harman

Model: XXV

Category: Stoves

Type: Owner's manual

Download PDF

report

Harman XXV Owner's manual

Harman XXV Owner's manual

Related papers

Other documents