Maytag MGR6751BDB - 30" Gas Double Oven Range Installation guide

Brand: Maytag

Model: MGR6751BDB - 30" Gas Double Oven Range

Category: Cookers

Type: Installation guide

MaytagDoubleOven

GasRange

Cuisini_re

gazb deuxfoursMaytag/Estufaa GasdeHornoDobleMaytag

j_J

\ \

j_1 j

MODELSERIES:MGR6775, MGR6875/

SI_RIEDEMODF:LE: MGR6775, MGR6875/

SERIESDELMODELO:MGR6775, MGR6875

DoubleOvenGasRange

PLEASEKEEPTHIS MANUALFOR FUTUREREFERENCE

This manualis intendedto assist inthe initial installation and adjustmentsof the range.

• Onlyqualified personnelshouldinstall or servicethis range.

• Read"Safety Instructions" in Use&Carebook before using range.

• Improper installation, adjustment,alteration, service,maintenanceor useof range

can result in serious injury or property damage.

Do not lift or moverangebygraspingdoorhandles,main top,

the maximumallowable wood cabinettemperatures of 194_E

If this range is installedwith cabinets that have a lower

working temperature than 194°F,discoloration, delamination

or melting mayoccur.

Place range ina well lit area.DOnot set range overholesin

the floor or otherlocations where it may be subjectto strong

drafts. Anyopeningin the wall behind the rangeand in the

floorunder the range shouldbe sealed. Makesurethe flow

of cooling/ventilation air is not obstructed belowthe range.

Note:A rangeshould NOTbeinstalled over kitchen carpeting.

High Altitude Notice: Thespecified gasburner ratings

typically apply to elevations up to 2000feet. For higher

altitudes, the ratesmay needto be reducedtoachieve

satisfactory operation.Alocal certified gasservicer wi!! be

ab!eto advise if a reductionis necessarY.

Arisk of rangetip-over existsif the applianceis not installedin

accordancewith the providedinstallationinstructions.Theproper use

of the ANTI-TIPdeviceminimizes the risk ofTIP-OVER.Inusing this

device the consumermust still observethe safetyprecautions as

stated in the USEand CAREMANUALandavoid usingthe ovendoors as

a step stool. Installationinstructions areprovidedfor wood and cement

in either floor or wall. Anyother type of construction may require

special installationtechniques as deemednecessaryto provide

adequatefastening ofthe ANTI-TIPbracketto the floor or wall. The

bracketmust be installed to engagethe RIGHTrear levelingfoot. Install

the bracket asshown in steps8a or 8b through 12.

MOBILEHOMES

Theinstallation of a rangedesignedfor mobile home installation must

conform with the Manufactured HomeConstructionand Safety

Standard,Title 24 CFR,Part3280 (formerlythe FederalStandardfor

MobileHomeConstructionand Safety,Title 24 HUD,Part 280)or, when

such standard is not applicable,the Standardfor ManufacturedHome

InstallationsANSIA225.1/NFPA501A,or with localcodes.In Canada

the range must be installedin accordancewith the current CSA

StandardC22.1- CanadianElectrical CodePart 1 and SectionZ240.4.1

- Installation Requirementsfor GasBurningAppliancesin Mobil Homes

(CSAStandardCAN/CSA- Z240MH).

ElectricalGroundingInstructions_ Thisappliance isequipped J

with a (three-prong)groundingplugfor Yourprotectionagainst J

shock hazardandshou!dbe pluggeddirectlyintoa proper!y J

groundedrecePtacle_DOnot cutor removethegroundingProng J

from!bspug I

RECREATIONALPARKTRAILERS

Theinstallation of a rangedesignedfor recreational parktrailers must

conform with stateor other codesor,in the absenceof such codes,

with the Standardfor RecreationalParkTrailers,ANSIA119.5-latest

edition. In Canadathe rangemust be installed in accordancewith

CAN/CSA- Z240.6.2- Electrical Requirementsfor R.V.'s(CSAStandard

CAN/CSA- Z240 RVSeries)and SectionZ240.4.2- Installation

Requirementsfor PropaneAppliancesand Equipmentin R.V.'s(CSA

StandardCAN/CSA- Z240 RVSeries).

[l(I]_]_l_fl_[_] i i: 1:11.'F:I_[_]_

Electric Supply

Theappliance,when installed,must be electrically groundedin

accordancewith local codes or, in the absenceof local codes,with the

NationalElectricalCode,ANSI/NFPA70. InCanadathe rangemust be

installedin accordancewith the current CSAStandard C22.1-

CanadianElectrical CodePart1.

Electrical Supply Connection

Therange requires 120volts,60 cycle alternating current from a

dedicated groundedoutlet with a 15 ampcircuit breaker.Seeserial

platefor rating, locatedon flip-up plate at the rear of upperleft-hand

corner of backguard.Usermay experienceoccasional circuit tripping if

GroundFaultCircuit Interrupter (GFCl)outlet or breaker is in use.

Gas Supply

Installationof thisrangemustconformwith localcodesor,inthe

absenceoflocalcodes,with theNational FuelGasCode,ANSIZ223.1-

latestedition.In Canadathe rangemustbeinstalledin accordance

withthecurrentCGAStandardCAN/CGA-B149- InstallationCodesfor

GasBurningAppliancesand Equipmentand/orlocalcodes.

In TheCommonwealthOf Massachusetts

Thisproductmustbe installedbya licensedplumberorgasfitter when

installedwithin the CommonwealthofMassachusetts.A"T" handle

typemanualgasvalvemustbe installedin thegas supplylineto this

appliance.Aflexiblegasconnector,when used,mustnotexceeda

lengthofthree(3)feet / 36 inches.

Gas leaks mayoccurin yoursystemand result in a dangerous

situation. Gasleaks may not be detectedbysmell alone.Gas

suppliers recommendyou purchaseandinstall an ULapproved

gas detector.Install and use in accordancewith manufacturerls

instructions.

A QUALIFIED SERVICEMAN OR GASAPPLIANCE INSTALLER

MUST MAKETHEGAS SUPPLYCONNECTION.Leak testing of the

appliance shall be conducted by the installer according to the

instructions given in Step 6.

Applya non-corrosiveleak detection fluid to all joints andfittings in

the gas connectionbetween the supply lineshut-off valve and the

range.Include gasfittings andjoints in the rangeif connectionswere

disturbed duringinstallation. Checkfor leaks! Bubblesappearing

aroundfittings andconnectionswill indicatea leak. If a leakappears,

turn off supply line gasshut-off valve,tighten connections,turn on the

supply line gasshut off valve,and retest for leaks.

CAUTION:NEVERCHECK FORLEAKSWITH A FLAME.WHEN

LEAKCHECKIS COMPLETE,WIPE OFFALL RESIDUE.

NATURALGASSUPPLYLINEMUSTHAVEA NATURALGASSERVICE

REGULATOR.INLETPRESSURETOTHISAPPLIANCESHOULDBE

REDUCEDTOA MAXIMUMOF14INCHESWATERCOLUMN(0.5 POUNDS

PERSQUAREINCH(P.S.I.)LIQUEFIEDPETROLEUM(L.P.)/PROPANEGAS

SUPPLYLINEMUSTHAVEA L.P.GASPRESSUREREGULATOR.INLET

PRESSURETOTHISAPPLIANCESHOULDBEREDUCEDTOAMAXIMUM

OF14INCHESWATERCOLUMN(0.5 P.S.I.).INLETPRESSURESIN

EXCESSOF0.5 P.S.I.CANDAMAGETHEAPPLIANCEPRESSURE

REGULATORANDOTHERGASCOMPONENTSINTHISAPPLIANCEAND

CANRESULTINA GASLEAK.

Gassupply pressurefor testing regulatormust beat least 1" water

column pressureabovemanifold pressureshown on serial plate.

Check Pressure of House Piping System

1.Theapplianceand itsindividual shutoff valvemustbe

disconnectedfrom the gassupply piping systemduringany

pressuretestingofthat system at testpressures inexcess of

1/2 Ibs./sq.in.(3.5 kPa)(13.8 in. water column).

2. Theappliancemustbeisolatedfrom the gassupply piping

systemby closingits individualmanualshutoff valveduringany

pressuretestingofthe gassupply pipingsystemat test

pressuresequaltoor lessthan1/2 Ibs./sq.in. (3.5kPa)(13.8

in. water column).

A GASSHUT-OFFVALVESHOULDBEPUTINANACCESSIBLELOCATION

INTHESUPPLYLINEAHEADOFTHERANGE,FORTURNINGONAND

TURNINGOFFGASSUPPLY.Rangeis to be connectedto house piping

with flexible metal connectorsfor gasappliances.CONNECTORNUTS

MUSTNOTBECONNECTEDDIRECTLYTOPIPETHREADS.THE

CONNECTORSMUSTBEINSTALLEDWITHADAPTORSPROVIDEDWITH

THECONNECTOR.

Thehouse piping and/or rangeconnector usedto connect the rangeto

the main gas supply must beclean,free of metalshavings,rust, dirt

and liquids (oil or water). Dirt,etc. in the supply lines canwork its way

intothe rangemanifold andin turn causefailure of the gasvalvesor

controls andclog burners and/or pilot orifices.

Alwaysuse anew flexible connector.Do not use exsisting flexible

connector.

NOTE:It is recommendedtousea CSAcertified flexible connectornolongerthan 36" (91.4 cm) with aminimum BTU/HRrating of88,200.

'If! I " v IV "*,_ I" "! _1

Follow these procedures to remove appliance for servicing:

1. Sliderangeforward to disengagerangefrom the anti-tip bracket.

2. Shutoff gassupply toappliance.

3. Disconnectelectricalsupply to appliance,if equipped.

4. Disconnectgas supply tubingtoappliance.

5. Reverseproceduretoreinstall. If gaslinehasbeendisconnected, THE APPLIANCE

checkfor gas leaksafter reconnection.

6.Topreventrange from accidentallytipping,range mustbe securedto thefloor by sliding rearlevelinglegintothe anti-tip bracket.

NOTE:A qualified servicer shoulddisconnect andreconnect the gas supply.Theservicer MUSTfollow installation instructions provided with the gas

appliance connector andthe warning label attachedto the connector.

Whenyour rangerequires service or replacement parts,contact your dealer or authorized service agency.Pleasegive the complete model and serial

number of the rangewhich is locatedon flip-up plate at the rear of upperleft-hand corner or centerof backguard.

I Yourrange may notbe equippedwith someof the features referred to in this manual. I

Page is loading ...

C_bktbpmustbegushor

!_ ibo_ thecountertop/

duplan

NOTE:Figure may notbe representativeof actual unit./REMARQUE:L'illustrationpeut ne pas prdsenterrappareil actuel./NOTA:La

figura puedeno ser exacta a la unidad.

CLEARANCEDIMENSIONS

Rangemaybe installedwith zeroinches clearanceadjacentto (against)combustibleconstructionatthe rearandonthe sidesbelowthe cooktop.

Forcompleteinformationinregard tothe installationofwall cabinetsabovethe rangeandclearancestocombustiblewall abovethecooking

topsee theinstallationdrawings.ForSAFETYCONSIDERATIONSdonotinstalla rangein anycombustiblecabinetrywhich isnotin accordwith

the installationdrawings.

* NOTE:30 inch(76.2 cm) dimensionbetweencookingtop and wall cabinetshown onillustrationdoesnot apply toranges with an elevated

ovenor microwave.Theinstallationinstructionsoftheelevatedovenwill specify theminimumacceptabledimensionbetweenthecooktop

andelevatedoven.The30 inch(76.2cm)dimensionmay be reducedto notlessthan24 inches(61cm)when the wall cabinetsin adomestic

homeare protectedwith fireproof materialsin accordancewith AmericanNational Standards- National FuelGasCodeorin mobilehomes

whentheyare protectedwith fireproof materialsinaccordancewith the FederalStandardfor MobileHomeConstructionand Safety.

Toeliminatethe risk ofburnsorfire byreachingoverheatedsurface units,cabinetstoragespacelocatedabovethesurface unitsshouldbe

avoided.If cabinetstorage isto be provided,the risk canbereduced byinstallinga range hoodthatprojectshorizontallya minimumof5

inches(13 cm)beyondthe bottomofthecabinets

DEGAGEMENTS

La cuisini_re peut_tre installee avecun d_gagementnul contre des mat_riaux combustibles a I'arriere etsur les cSt_sen dessousde iatable

de cuisson.Pourdes renseignementscomplets concernantI'installation des armoiresau-dessus de la cuisini_re et les degagementsaux

parois combustiblesau-dessus dela surface de cuisson, consultezles schemas sur I'installation. Pourdes RAISONSDESI_CURITI_,n'installez

pas unecuisini_re dans des armoires en materiaux combustiblesnonconformesaux schemasde I'installation.

* REMARQUE:La dimensionde76,2cm(30po)entre la surfacedecuissonetles armoiresmuralespr_senteessur I'illustrationneconcernepasles

cuisini_resavecunfour sureleveou un micro-ondes.Lesinstructionsd'installationdu four sur_lev_precisentla dimensionminimale acceptable

entre lasurfacedecuissonetle four sur_leve.Ladimensionde 76,2cm (30po)peut_trereduite apasmoinsde61 cm(24po)Iorsqueles armoires

muralesd'uneresidencesont protegeespardes materiauxignifugesconform_mentaux normesde I'AmericanNationalStandards- NationalFuel

GasCode(Codenational des combustiblesgazeux),ou Iorsqueles armoires muralesd'une maisonmobile sont protegeespar desmat_riaux

ignifugesselon la normefed_rale :Mobile Homeconstruction and Safety(norme desecurit_ et de construction des maisonsmobiles).

Pour_liminerle risquede brilure oud'incendie,en passantla main au-dessusdeselementsde surfacechauffes,I'espacederangementdansles

armoires situees au-dessusdeselementsde surfacedolt _treevit_. Si une armoire de rangementexiste,le risquepeut _trer_duit eninstallant

unehotte d'extraction quidepassehorizontalementd'un minimum de 13 cm(5 po)de lapartie inferieuredesarmoires.

DIMENSIONES DE LOS ESPACIOSDE DESPEJE

Estaestufa sepuede instalar sin espaciosdedespeje contrasuperficies combustiblesen la parte trasera y a los costadosde la mismapor

debajo de la cubierta. Paraobtener informacion completa sobrela instalaci6n de los armarios sobre la cubierta y los espaciosde despeje

para lasparedescombustibles sobre lacubierta yealasfiguras de instalaci6n. Por RAZONESDESEGURIDAD,no instale una estufa en ninguna

ubicaci6n con armarios combustiblesque no concuerdencon las figuras de instalaci6n.

* NOTA:El despejede 30 pulgadas(76,2 cm) entre lacubierta de cocci6ny el armario quese muestra en lafigura no seaplica a las estufas

con hornoselevadoso alos microondas.Lasinstrucciones de instalaci6ndel homo elevadoespecificaran el espaciominimo entre la cubierfa

y el homo elevado.Eldespejede 30 pulgadas(76,2 cm)puedeser reducidoa nomenos de24 pulgadas(61cm) cuandolos armariosdel hogar

estanprotegidoscon materialesa pruebadefuego deacuerdocon las NormasNacionalesdeEstadosUnidos(ANS)y el C6digoNacionalde Gas

oen lascasasrodantescuandolas mismasestanprotegidascon materialesapruebadefuego deacuerdocon la NormaFederaldeConstrucci6n

y SeguridaddeViviendasM6viles.

Paraeliminar elriesgo dequemaduraso de incendioscuandoseintenta alcanzaralgin objetosobre loselementossuperiores,evite almacenar

articulosen los armariosque estansobrela estufa. Sise instala unarmario sobrelacubierta,sepuedereducirel riesgo instalandouna campana

de ventilacion quese proyecte horizontalmenteen un minimo de 5 pulgadas(13 cm) mas alia de la base de los armarios.

THISPRODUCTSHOULDNOTBEINSTALLEDBELOWVENTILATIONTYPEHOODSYSTEMTHATDIRECTSAIRINA DOWNWARDDIRECTION.

THESESYSTEMSMAYCAUSEIGNITIO[_ANDCOMBUSTIONPROBLEMSWITHTHEGASBURNERSRESULTINGINPERSONALINJURYANDMAY

EFFECTTHECOOKINGPERFORMANCEOFTHEUNIT,

NOTE:THEFIGUREMAYNOTACCURATELYREPRESENTYOURRANGECOOKTOP;HOWEVER,THISWARNINGAPPLIESTOALLGASCOOKING

PRODUCTS.

CEPRODUITNEDOlTPASI_TREINSTALLI_SOUSUNEHOTTED'EXTRACTIONQUIRENVOIEL'AIRVERSLEBAS.

CESSYSTI_MESPEUVENTENTRA[NERDESPROBLI_MESD'INFLAMMATIONETDECOMBUSTIONAVECLESRROLEURS

A GAZ.ENTBAINANTDESBLESSURESEl RISQUANTD'AFFECTERLA PERFORMANCEDECUISSONDEL'APPAREIL.

REMARQBE: L'ILLUSTRATIONPEUTNEPASREPRI_SENTERPRI_CISEMENTLATABLEDECUISSONDEVOTRE

CUISINII_RE:CEPENDANT,CETAVERTISSEMENTCONCERNETOUSLESAPPAREILSDECUISSONA GAZ.

ESTEPRODUCTONOSEDEBEINSTALARDEBAJODESISTEMASDECAMPANASDEVENTILACIONQUEDIRIJANEL

FLUJODEAIREHAClAABAJO.

ESTOSSISTEMASPUEDENCAUSARPROBLEMASDEENCENDIDOY DECOMBUSTIONDELOSQUEMADORES.LO

QUEPUEDERESULTARENLESIONESPERSONALESYAFECTARELRENDIMIENTODELACOCCIONDELAUNIDAD.

NOTA:LAFIGUBAPUEDENOREPRESENTARCONEXACTITUDSUCUBIERTA.SINEMBARGO.ESTAADVERTENClASE

APLICAATODOSLOSPRODUCTOSDECOCClONA GAS.

Page is loading ...

Turnongassupplyshut-offvalve./OuvrezlerobinetdeIalimentationen

gaz./Abralavblvuladecierredelgas.

Checkallgasconnectionjointsandfittings for leakswitha non-corrosive

leakdetectionfluid, thenwipe off./V_rifiezI'absence de fuite ;_tousles

raccordementsdegaz avec un liquidede d_tecUondesfuitesnoncorrosif,

puisessuyez-le./Verifiquetodaslas conexionesy juntasdel suministmde

gasa la estufausando un liquidode detecci6nde escapesno corrosivo

paraasegurarsedeque nohayanescapes.Limpie el liquidocuando

hayaterminado.

Ddll1/8" (3mmholes).MountANTI-TIPbracketto wallorfloor with2 screws./

Percezdestrousde 1/8 po(3 mm).InstallezlesupportANTIRENVERSEMENT

au murou au solavec deuxvis./Taladreagujerosde 1/8" (3 mm). Instale

elsoporteANTIVUELCOen la paredo en el pisousando 2 tornillos.

Turnon maingas valve at meter./Ouvrezle robinet principalau niveau

du compteur./Abrala vblvulade gasen el medidor.

Adjustlegs./Ajustezles pieds./Ajustelostornillosniveladores.

du herd de la cuisinKere/ o

deede eJhorde de la _tufa

Drillholesas required.MountANTI-TIPbracketto floor with 2 concrete

screws(notprovided)./Percezdestrousselonle besoin.Installezle

supportANTIRENVERSEMENTau solavecdeux vis_ b_ton(non

foumies)./Taladre losagujerosque necesite.Instaleelsoporte

ANTIVUELCOen el pisousando 2 tornillospara concreto(no

proporcionados).

Page is loading ...

Checkflame heightand color./V_rifiezla hauteur et la couleurde la

flamme./Verifique la altura y elcolorde la llama.

Yellow Goto step

3aune Passeza 1'6tape

Amariiia Vayaal paso

6iue iiftin_ 6o tostep

Flamme bieue Passez5_1'6tape

ee see Jevant

Azui que se Vayaal paso

eepara del quemader

Checkfor distinctinnerblueflame./V_rifiezqeelaflammepr_seeteee caee

int_rieur bleubien pr_cis./Verifiqeeqee el interiorde la llamasea azuL

Adjustbyopeningair shetterJAjustezen ouvrantI'obterateur d'air./

Ajuste abriendoelobturador.

Adjustby closingair shetterJAjustezen fermantI'obturateerd'air./

Ajustecerraedo el obturador.

! /

/ /

Removerear burnerkeob,/Enlevezleboeton

de br61eerarri_re./Retirela perilladel

qeemadortrasero.

/i /

Removespillgasket./Eelevez lejoint anti-

d_bordemeet./Retirelajunta de derrames.

Rotateas eecesary,/Tournezae besoie,/

Giresies necesario,

Maytag MGR6751BDB - 30" Gas Double Oven Range Installation guide

Brand: Maytag

Model: MGR6751BDB - 30" Gas Double Oven Range

Category: Cookers

Type: Installation guide

Download PDF

report

Maytag MGR6751BDB - 30" Gas Double Oven Range Installation guide

Maytag MGR6751BDB - 30" Gas Double Oven Range Installation guide

in other languages

Related papers

Other documents