BOMBARDIER Outlander 800/800 XT User manual

vmo2006 OUTLANDER 800 ang.FH8 Tue May 03 08:17:59 2005 Page 1

Composite

C M Y CM MY CY CMY K



WARNING

YOUR VEHICLE CAN BE HAZARDOUS TO OPERATE. A collision or rollover

can occur quickly, even during routine maneuvers such as turning and driv-

ing on hills or over obstacles, if you fail to take proper precautions.

For your safety, understand and follow all the warnings contained in this

Operator's Guide and the labels on your vehicle. Failure to follow these

warnings can result in SEVERE INJURY OR DEATH!

Keep this Operator's Guide with the vehicle at all times.



WARNING

Disregarding any of the safety precautions and instructions contained in this

Operator's Guide, SAFETY VIDEOCASSETTE and on-product labels could

cause injury including the possibility of death!

This category R (recreational) ATV is for off road use only. It is mainly for general

recreational use but it may also be used for utility purposes.



WARNING

This ATV may exceed the performance of other ATVs you may have ridden

in the past.

This is a high performance ATV designed for use by experienced operators.

Printed in Canada. (vmo2006-007 DR)

®™ and the BRP loge are trademarks of Bombardier Recreational Products Inc. or its affiliates.

* Trademark of Bombardier Inc. used under license.

IMPORTANT INFORMATION

This Operator’s Guide utilizes the following symbols to emphasize particular in-

formation:



The Safety Alert Symbol indicates a potential personal injury hazard.



WARNING

Indicates a potential hazard that, if not avoided, could

result in serious injury or death.

CAUTION: Denotes an instruction which, if not followed, could severely

damage vehicle components.

All safety documentation should remain with the vehicle at the time of sale.

All content of the Safety Information section should be interpreted by the reader

as a warning which, if not followed, may result in injury including the possibility

of death.

In Canada, products are distributed by Bombardier Recreational Products Inc.

(BRP).

In USA, products are distributed by BRP US Inc.

The following trademarks are the property of Bombardier Recreational Prod-

ucts Inc.:

OUTLANDER

TM

ROTAX

®

XP-S

TM

TTI™

______________________

1

FOREWORD

Congratulations on your purchase of

a new Bombardier

*

recreational vehi-

cle. It is backed by the BRP warran-

ty and a network of authorized Bom-

bardier ATV dealers ready to provide

the parts, service or accessories you

may require.

Your dealer is committed to your satis-

faction. He has taken training to per-

form the initial setup and inspection

of your vehicle as well as completed

the final adjustment before you took

possession. At delivery, your dealer

would have explained the operation,

maintenance and safety features of

the vehicle. We trust you have tak-

en full advantage of this! If you need

more complete servicing information,

please ask your dealer.

Atdelivery,youwerealsoinformedof

the warranty coverage and completed

the Warranty Registration Form which

is to be sent to us for processing. In

the near future you should be receiv-

ing a warranty card which will confirm

our receipt of the registration as well

as be used for warranty or recall pur-

poses.

You are invited to contact our cus-

tomer assistance center should you

experience problems which cannot be

resolved by an authorized Bombardier

ATV dealer.

It is understood that this Operator’s

Guide may be translated into another

language. In the event of any discrep-

ancy, the English version shall prevail.

Throughout this document the mascu-

line is used to denote the masculine or

feminine.

The information and components/sys-

tem descriptions contained in this

document are correct at the time of

publication. Bombardier Recreational

Products Inc., however, maintains a

policy of continuous improvement of

its products without imposing upon

itself any obligation to install them

on products previously manufactured.

Due to late changes, some differ-

ences between the manufactured

product and the descriptions and/or

specifications in this guide may occur.

BRP reserves the right at any time to

discontinue or change specifications,

designs, features, models or equip-

ment without incurring any obligation

upon itself.

The illustrations in this document

show the typical construction of the

different assemblies and may not re-

produce the full detail or exact shape

of the parts. However, they represent

parts that have the same or similar

function.

The use of RIGHT and LEFT indica-

tions in the text always refers to driv-

ing position (when sitting on vehicle).

Specifications are given in the inter-

national metric system with the SAE

U.S. equivalent in parenthesis. Where

precise accuracy is not required, some

conversions are rounded off for easier

use.

We recommend genuine Bombardier

products for replacement parts and

accessories. They’ve been especially

designed for your vehicle and manu-

factured to meet BRP’s demanding

standards.

A SHOP MANUAL can be obtained for

complete service and maintenance in-

formation and more repair information.

______________________

3

TABLE OF CONTENTS

While reading this Operator’s Guide, remember that:



WARNING

Indicates a potential hazard that, if not avoided, could result in serious in-

jury or death.

INTRODUCTION ..................................................................... 9

SAFETY INFORMATION

SPECIAL SAFETY MESSAGES................................................... 12

OPERATION WARNINGS.......................................................... 15

SAFETY WARNING ................................................................ 42

Pre-Operation Check ........................................................... 43

Clothing.......................................................................... 44

Carrying Loads .................................................................. 45

Hauling a Trailer................................................................. 45

Working with your Vehicle..................................................... 45

Recreational Riding............................................................. 45

Environment..................................................................... 46

Design Limitation............................................................... 46

Off-Highway Operation......................................................... 46

General Operating and Safety Precautions .................................. 47

Uphill Driving .................................................................... 47

Downhill Driving ................................................................ 47

Side Hilling....................................................................... 48

Drop-Offs........................................................................ 48

Riding Techniques .............................................................. 48

Routine Maintenance........................................................... 55

HANG TAG .......................................................................... 56

LOCATION OF THE IMPORTANT LABELS...................................... 57

VEHICLE INFORMATION

HOW TO IDENTIFY YOUR ATV .................................................. 62

EMISSION REQUIREMENTS ..................................................... 63

CONTROLS/INSTRUMENTS/EQUIPMENT .................................... 64

1) Throttle Lever ................................................................ 66

2) 2WD/4WD Selector.......................................................... 66

3) Brake Lever................................................................... 66

4) Brake Lever Lock ............................................................ 67

5) Transmission Lever.......................................................... 67

4

_______________________

6) Multi-Function Switch ....................................................... 68

7) Speedometer................................................................. 70

8) 12-Volt Power Outlet ........................................................ 73

9) Ignition Switch ............................................................... 73

10) Fuel Tank Cap............................................................... 74

11) Brake Pedal ................................................................. 74

12) Footpeg...................................................................... 75

13) Access Panel................................................................ 75

14) Rear Storage Compartment............................................... 75

15) Seat Latch................................................................... 76

16) Cargo Racks................................................................. 76

17) Trailer Hitch ................................................................. 77

18) Radiator Cap ................................................................ 77

19) Fuses ........................................................................ 77

20) Tool Kit....................................................................... 78

21) Dipstick...................................................................... 78

22) Winch........................................................................ 78

23) Winch Control Switch...................................................... 79

24) Fairlead ...................................................................... 79

LIQUIDS.............................................................................. 80

Fuel............................................................................... 80

Engine Oil........................................................................ 80

Gearbox Oil...................................................................... 82

Engine Coolant.................................................................. 82

Brake Fluid....................................................................... 83

Battery ........................................................................... 84

BREAK-IN PERIOD.................................................................. 85

OPERATING INSTRUCTIONS..................................................... 86

General........................................................................... 86

Pre-Operation Check ........................................................... 86

Starting the Engine ............................................................. 86

Shifting the Transmission...................................................... 87

2WD/4WD Selector............................................................. 87

Winch Operation................................................................ 88

Stopping the Engine............................................................ 88

Post-Operation Care............................................................ 88

SPECIAL PROCEDURES........................................................... 89

Flooded Engine (Drowned Mode)............................................. 89

Engine Overheat................................................................ 89

Turn Over ........................................................................ 89

ATV Immersion.................................................................. 90

Storage and Preseason Preparation .......................................... 90

______________________

5

CARGO AND TRANSPORTATION ............................................... 91

TROUBLESHOOTING.............................................................. 93

SPECIFICATIONS ................................................................... 96

MAINTENANCE INFORMATION

MAINTENANCE CHART......................................................... 102

GENERAL .......................................................................... 106

ENGINE ............................................................................ 107

Oil Change and Oil Filter Replacement..................................... 107

Oil Strainer Cleaning.......................................................... 107

Gearbox Oil Replacement.................................................... 107

Coolant Replacement ........................................................ 108

Drive Belt...................................................................... 109

Valve Adjustment............................................................. 109

Spark Arrester................................................................. 109

Radiator........................................................................ 110

AIR INTAKE SYSTEM ............................................................ 111

Air Filter Removal............................................................. 111

Air Filter cleaning ............................................................. 111

Air Filter Installation........................................................... 111

ELECTRICAL....................................................................... 112

Spark Plug ..................................................................... 112

Battery ......................................................................... 112

Fuses........................................................................... 113

Bulb Replacement ............................................................ 114

DRIVE TRAIN...................................................................... 116

Drive Shaft Boot/Protector................................................... 116

Wheel .......................................................................... 116

Wheel Bearing Condition .................................................... 116

Tires/Wheels .................................................................. 117

STEERING SYSTEM.............................................................. 119

Throttle Cable Lubrication.................................................... 119

Throttle Lever Adjustment................................................... 120

SUSPENSION..................................................................... 122

Lubrication..................................................................... 122

Inspection...................................................................... 122

Adjustment.................................................................... 122

BRAKE.............................................................................. 123

Front and Rear Brakes........................................................ 123

Brake Fluid Replacement .................................................... 123

BODY/FRAME..................................................................... 124

Engine Area ................................................................... 124

6

_______________________

Hitch/Trailer Ball Condition................................................... 124

Chassis Fasteners ............................................................ 124

Seat Fasteners................................................................ 124

VehicleCleaning and Protection............................................. 124

STORAGE AND PRESEASON PREPARATION ............................... 125

WARRANTY

BRP LIMITED WARRANTY NORTH AMERICA: 2006 BOMBARDIER

†

ATV ................................................................................. 128

BRP INTERNATIONAL LIMITED WARRANTY: 2006 BOMBARDIER

†

ATV 132

PRIVACY OBLIGATION/DISCLAIMER......................................... 135

CHANGE OF ADDRESS/OWNERSHIP ........................................ 137

______________________

7

NOTICE

This Operator's Guide has been pre-

pared to acquaint the owner/operator

of a new vehicle with the various ve-

hicle controls, maintenance and safe

operating instructions. It is indispens-

able for the proper use of the product.

This Operator's Guide uses the follow-

ing symbols.



WARNING

Indicates a potential hazard that, if

not avoided, could result in serious

injury or death.

CAUTION: Denotes an instruction

which, if not followed, could se-

verely damage vehicle compo-

nents.

NOTE:

Indicates supplementary infor-

mation needed to fully complete an in-

struction.

Although the mere reading of such in-

formation does not eliminate the haz-

ard, the understanding and application

of the information will promote the

correct use of this vehicle.

To fully appreciate the pleasures, en-

joyment and excitement of using this

vehicle, there are some basic rules

that MUST be observed and followed

by any user.

8

_______________________

INTRODUCTION

Your dealer should have provided you

with some basic information on the

particular controls and features of your

new vehicle. Please take the time to

study this Operator's Guide and all

on-product warning labels as well as

the SAFETY VIDEOCASSETTE that

came with this vehicle. They more

completely describe what you should

know about this vehicle before riding

it.

Whether you are a new user or an

experienced rider, it is important for

your personal safety that you know the

controls and features of this vehicle.

Equally important is knowing how to

properly ride.

Irrespective of your age, experience or

state regulations, it is always prudent

for you or any other person who may

ride your vehicle, to take an approved

safe riding course. Please check with

your dealer or local authorities for avail-

ability in your area. If you are a com-

pletely new rider, this should be done

before your first ride. Your instructor

should be able to provide advice on lo-

cal conditions and safe riding practices

particular to the area.

Riding conditions vary from place

to place. Each is subject to weather

conditions which may radically change

from time to time and from season to

season. Riding on sand is different

than riding on snow or through forests

or marshes. Each location may re-

quire a greater degree of awareness

and skill. Show good judgement. Al-

ways proceed with caution. Please

do not take any unnecessary risks that

could leave you stranded or possibly

injured.

The contents of this Operator's Guide

provide riding information which has

been proven reliable by other users.

They are not intended as a definitive

means of avoiding accidents. How

you apply this information, coupled

with your mental and physical condi-

tion, the particular terrain hazard and

your risk acceptance level will have

an effect on your riding experience.

Have fun... and ride responsibly.

This Operator's Guide has been pre-

pared to acquaint the owner/operator

of a new vehicle with the various ve-

hicle controls, maintenance and safe

operating instructions. They are indis-

pensable for the proper use of the

product.

We would be pleased to receive any

comments on the content and format

of this Operator's Guide, the SAFETY

VIDEOCASSETTE or on-product warn-

ings labels.

______________________

9

SAFETY

INFORMATION

____________

SAFETY INFORMATION

___________

11

SPECIAL SAFETY MESSAGES

THIS VEHICLE IS NOT A TOY AND

CAN BE HAZARDOUS TO OPERATE.

This vehicle handles differently from

other vehicles including motorcycles

and cars. A collision or rollover can

occur quickly, even during routine ma-

neuvers such as turning and driving on

hillsor over obstacles, if you fail to take

proper precautions.

SEVERE INJURY OR DEATH

can re-

sult if you do not follow these instruc-

tions:

 Read this Operator's Guide and all

on-product warning labels careful-

ly and follow the operating proce-

dures described. Watch and pay at-

tention to the SAFETY VIDEOCAS-

SETTE before operation.

 Never operate this vehicle without

proper instruction. Take a training

course. Beginners should receive

training from a certified instructor.

Contact an authorized Bombardier

ATV dealer to find out about avail-

able training course nearest you or

call the Specialty Vehicle Institute

of America (SVIA) at 1 800 877-

2887 or in Canada, the Canada safe-

ty Council (CSC) at 1 (613) 739-1535

ext. 227.

 Always follow this age recommen-

dation: A person under 16 years old

should never operate this vehicle.

 Never carry a passenger on this ve-

hicle.

 Never operate this vehicle on any

paved surfaces, including side-

walks, driveways, parking lots and

streets.

 Never operate this vehicle on any

public street, road or highway, even

a dirt or gravel one.

 Never take place on this vehicle

without wearing an approved hel-

met that fits properly. You should

also wear eye protection (goggles

or face shield), gloves, boots, long

sleeved shirt or jacket, and long

pants.

 Never consume alcohol or drugs be-

fore or while riding this vehicle.

 Never operate at excessive speeds.

Always go at a speed that is prop-

er for the terrain, visibility, and op-

erating conditions, and your experi-

ence.

 Never attempt wheelies, jumps, or

other stunts.

 Always inspect your vehicle each

time you use it to make sure it is

in safe operating condition. Always

follow the inspection and mainte-

nance procedures and schedules

described in this Operator's Guide.

 Always keep both hands on the

handlebars and both feet on the

footrests of the vehicle during op-

eration.

 Always go slowly and be extra care-

ful when operating on unfamiliar

terrain. Always be alert to changing

terrain conditions when operating

this vehicle.

 Never operate on excessively

rough, slippery or loose terrain un-

til you have learned and practiced

the skills necessary to control this

vehicle on such terrain. Always be

especially cautious on these kinds

of terrain.

 Always follow proper procedures

for turning as described further in

this Operator's Guide. Practice

turning at low speeds before at-

tempting to turn at faster speeds.

Do not turn at excessive speed.

12

___________

SAFETY INFORMATION

___________

 Never operate this vehicle on hills

too steep for the vehicle or for your

abilities. Practice on smaller hills

before attempting larger hills.

 Always follow proper procedures

for climbing hills as described

further in this Operator's Guide.

Check the terrain carefully before

you start up any hill. Never climb

hills with excessively slippery or

loose surfaces. Shift your weight

forward. Never open the throt-

tle suddenly or make sudden gear

changes. Never go over the top of

any hill at high speed.

 Always follow proper procedures

for going down hills and for brak-

ing on hills as described further in

this Operator's Guide. Check the

terrain carefully before you start

down any hill. Shift your weight

backward. Never go down a hill at

high speed. Avoid going down a hill

at an angle that would cause the

vehicle to lean sharply to one side.

Go straight down the hill where

possible.

 Always follow proper procedures

for crossing the side of a hill as

described further in this Operator's

Guide. Avoid hills with excessively

slippery or loose surfaces. Shift

your weight to the uphill side of

the vehicle. Never attempt to turn

the vehicle around on any hill un-

til you have mastered the turning

technique described in this Opera-

tor's Guide on level ground. Avoid

crossing the side of a steep hill if

possible.

 Always use proper procedures if

you stall or roll backwards when

climbing a hill. To avoid stalling,

use proper gear and maintain a

steady speed when climbing a hill.

If you stall or roll backwards, follow

the special procedure for braking

described in this Operator's Guide.

Dismount on the uphill side or to a

side if pointed straight uphill. Turn

the vehicle around and remount,

following the procedure described

further in this Operator's Guide.

 Always check for obstacles before

operating in a new area. Never at-

tempt to operate over large obsta-

cles, such as large rocks or fallen

trees. Always follow proper proce-

dures when operating over obsta-

cles as described further in this Op-

erator's Guide.

 Always be careful when skidding

or sliding. Learn to safely control

skidding or sliding by practicing at

low speeds and on level smooth

terrain. On extremely slippery sur-

faces, such as ice, go slowly and be

very cautious in order to reduce the

chance of skidding out of control.

 Never operate this vehicle in fast

flowing water or in water deeper

than that specified in this Opera-

tor's Guide. Remember that wet

brakes may have reduced stopping

ability. Test your brakes after leav-

ing water. If necessary, apply them

several times to let friction dry out

the pads.

 Always be sure there are no ob-

stacles or people behind the vehi-

cle when you operate in reverse.

When it is safe to proceed in re-

verse, go slowly.

 Always use the size and type tires

specified further in this Operator's

Guide. Always maintain proper tire

pressure as described further in this

Operator's Guide.

____________

SAFETY INFORMATION

___________

13

 Never modify this vehicle through

improper installation or use of ac-

cessories. Only use BRP's ap-

proved accessories. Do not install

passenger seat or use the racks to

carry a passenger.

 Never exceed the stated load lim-

its for this vehicle including opera-

tor, all other loads and added acces-

sories. Cargo should be properly

distributed and securely attached.

Reduce speed and follow instruc-

tions in this manual for carrying car-

go or pulling a trailer. Allow greater

distance for braking.

 FOR MORE INFORMATION

ABOUT ATV SAFETY, call the Spe-

cialty Vehicle Institute of America

(SVIA) at 1 800 887-2887 or in

Canada, the Canada Safety Coun-

cil (CSC) at 1 (613) 739-1535 ext.

227 or contact an authorized Bom-

bardier ATV dealer to find out about

available training courses nearest

you.

14

___________

SAFETY INFORMATION

___________

OPERATION WARNINGS

While reading this Operator’s Guide, remember that:



WARNING

Indicates a potential hazard that, if not avoided, could result in serious in-

jury or death.

The following warning and their format have been requested by the United States

Consumer Product Safety Commission and are required to be in the Operator's

Guide for all ATVs.

NOTE:

The following illustrations are general representations only. Your model

may differ.



WARNING

V00A0AQ

POTENTIAL HAZARD

Operating this vehicle without proper instruction.

WHAT CAN HAPPEN

The risk of an accident is greatly increased if the operator does not know

how to operate this vehicle properly in different situations and on different

types of terrain.

HOW TO AVOID THE HAZARD

Beginning and inexperienced operators should complete the training

course offered by BRP. They should then regularly practice the skills

learned in the course and the operating techniques described in this

Operator's Guide.

For more information about the training course, contact an authorized

Bombardier ATV dealer or call BRP at 1 (819) 566-3366.

____________

SAFETY INFORMATION

___________

15



WARNING

V00A01Q

POTENTIAL HAZARD

Failure to follow the age recommendations for this vehicle.

WHAT CAN HAPPEN

A lack of respect for this age recommendation can lead to severe injury or

death of the child.

Even though a child may be within the age group for which this vehicle is

recommended, he may not have the skills, abilities, or judgment needed

to operate this vehicle safely and may be involved in a serious accident.

HOW TO AVOID THE HAZARD

No one under 16 should operate this vehicle.

16

___________

SAFETY INFORMATION

___________



WARNING

V00A02Q

POTENTIAL HAZARD

Carrying a passenger on this vehicle.

WHAT CAN HAPPEN

Greatly reduces your ability to balance and control this vehicle.

Could cause an accident, resulting in harm to you and/or your passenger.

HOW TO AVOID THE HAZARD

Never carry passenger. Even with a long seat that provides unrestricted

operator movement, it is not designed nor intended to carry passenger(s).

____________

SAFETY INFORMATION

___________

17



WARNING

V00A03Q

POTENTIAL HAZARD

Operating this vehicle on paved surfaces.

WHAT CAN HAPPEN

The ATV's tires are designed for off-road use only, not for use on pavement.

Paved surfaces may seriously affect handling and control of this vehicle,

and may cause the vehicle to go out of control.

HOW TO AVOID THE HAZARD

Never operate this vehicle on any paved surfaces, including sidewalks,

driveways, parking lots and streets.

18

___________

SAFETY INFORMATION

___________



WARNING

V00A04Q

POTENTIAL HAZARD

Operating this vehicle on public streets, roads or highways.

WHAT CAN HAPPEN

You can collide with another vehicle.

HOW TO AVOID THE HAZARD

Never operate this vehicle on any public street, road or highway, even a

dirt or gravel one. In many states or provinces it is illegal to operate ATVs

on public streets, roads or highways.

____________

SAFETY INFORMATION

___________

19



WARNING

V00A06Q

POTENTIAL HAZARD

Riding this vehicle without wearing an approved helmet, eye protection

and protective clothing.

WHAT CAN HAPPEN

The following items concern all ATV's operator:

– riding without an approved helmet increases the chances of a severe

head injury or death in the event of an accident

– riding without eye protection can result in an accident and increases

the chances of a severe injury in the event of an accident

– riding without protective clothing increases the chances of severe in-

jury in the event of an accident.

HOW TO AVOID THE HAZARD

Always wear an approved helmet that fits properly. You should also wear:

– eye protection (goggles or face shield)

– gloves and boots,

– Iong sleeved shirt or jacket

–Iongpants.

20

___________

SAFETY INFORMATION

___________

Page is loading ...

BOMBARDIER Outlander 800/800 XT User manual

This manual is also suitable for

BOMBARDIER Outlander 800/800 XT User manual

Related papers

Other documents